Occurrence and Risk Assessment of Dietary Exposure to Deoxynivalenol in Wheat-Based Products Based Different Wheat-Producing Area for the Inhabitants in Shanghai, China

Deoxynivalenol (DON) is one of the major mycotoxins that contaminate cereals. In this study, we determined the DON level in wheat-based products from Chinese five main production areas collected in Shanghai and calculated the daily intake of DON for inhabitants using the point evaluation and the probabilistic evaluation based on Monte Carlo simulation. The results showed the positive rates of DON in the products were higher than 80.0%, with the concentrations ranging from 41.8 to 1110 µg/kg. The estimated mean daily intakes of DON for 7- to 10-year-old children and adults groups were below 1 µg/kg bw/day, the provisional maximum tolerable daily intake (PMTDI) set by the Joint FAO/WHO Expert Committee on Food Additives (JECFA), suggesting no health risks for the consumers. However, the 99th percentiles of dietary DON exposures for children and adults exceeded the PMTDI, indicating adverse health effects might occur if the two groups intake highly contaminated wheat-based products. The potential health risks for the two groups exposed to DON in the wheat-based products from the Middle and Lower Yangtze Valley (MLYV) were higher than those from the other areas in China.

Mycotoxins Analysis in Cereals and Related Foodstuffs by Liquid Chromatography-Tandem Mass Spectrometry Techniques

In the entire world, cereals and related foodstuffs are used as an important source of energy, minerals, and vitamins. Nevertheless, their contamination with mycotoxins kept special attention due to harmful effects on human health. The present paper was conducted to evaluate published studies regarding the identification and characterization of mycotoxins in cereals and related foodstuffs by liquid chromatography coupled to (tandem) mass spectrometry (LC-MS/MS) techniques. For sample preparation, published studies based on the development of extraction and clean-up strategies including solid-phase extraction, solid-liquid extraction, and immunoaffinity columns, as well as on methods based on minimum clean-up (quick, easy, cheap, effective, rugged, and safe (QuEChERS)) technology, are examined. LC-MS/MS has become the golden method for the simultaneous multimycotoxin analysis, with different sample preparation approaches, due to the range of different physicochemical properties of these toxic products. Therefore, this new strategy can be an alternative for fast, simple, and accurate determination of multiclass mycotoxins in complex cereal samples.

Natural occurrence of deoxynivalenol and deoxynivalenol-3-glucoside in various wheat cultivars grown in Jiangsu province, China

Deoxynivalenol (DON) is a major mycotoxin found in wheat infected with Fusarium fungi. DON can be converted by plant detoxification into a form of ‘masked mycotoxin’ termed deoxynivalenol-3-glucoside (DON-3G). To recommend appropriate wheat cultivars for planting in order to reduce DON contamination in Jiangsu province, where a traditional Fusarium head blight (FHB) epidemic area is located in the lower reaches of Yangtze-Huaihe, we evaluated the capacity of various wheat cultivars to transform DON into DON-3G under field conditions. We collected and evaluated samples from 11 major wheat cultivars grown in 63 experimental stations in Jiangsu province in 2015 and 2016. All samples were contaminated with DON, with an average concentration of 2,087±112 and 2,601±126 µg/kg in 2015 and 2016, respectively. DON-3G was detected in 425 (96%) and 405 (97%) samples in 2015 and 2016, with an average concentration of 545±28 and 819±44 µg/kg, respectively. The DON-3G/DON ratio ranged from 5 to 84% (average, 30%) in 2015 and from 0 to 71% (average, 31%) in 2016. DON levels were highly correlated with DON-3G concentrations (P<0.01), and the FHB resistance of the wheat cultivars was proportional to their capacity to convert DON to DON-3G. Importantly, region, cultivar, and region × cultivar interaction all significantly affected DON and DON-3G concentrations and DON-3G/DON ratios. In general, FHB-resistant cultivars, such as Sumai 188 and Ningmai 13, had lower levels of DON and DON-3G than the others. However, additional factors, including the growing region and environmental variables, were important for wheat management when other wheat cultivars were evaluated.

Individual and Combined Cytotoxic Effects of Co-Occurring Deoxynivalenol Family Mycotoxins on Human Gastric Epithelial Cells

Mycotoxin contamination is a significant health concern for human beings, but health risk assessments are usually based on one single mycotoxin, which might neglect the additive or competitive interactions between co-occurring mycotoxins. In this study, we assessed the individual or combined toxicological effects to multiple deoxynivalenol-family mycotoxins, namely deoxynivalenol (DON), Nivalenol (NIV), and their acetyl derivatives of 3-acetyldeoxynivalenol (3-ADON), 15-acetyldeoxynivalenol (15-ADON), deoxynivalenol-3-glucoside (D3G), and Fusarenon-X (FX) based on the human gastric epithelial (GES-1) cells. GES-1 cells were treated at different concentrations over 24 h and cell viability was measured by a cell counting kit (CCK8). The results show that D3G has no toxicity and 3-ADON is less potent in reducing cell viability compared to DON, whereas 15-ADON and FX appear to be slightly less potent than their parent compounds of DON and NIV on GES-1 cells. In general, the toxic ability of individual mycotoxins was shown as 3-ADON << 15-ADON < DON < FX < NIV, in an increasing order. All mixtures caused a dose-dependent decline of cell viability and the interactions analysis of binary combinations were assessed using the combination index (CI)-isobologram method. For the interaction types of mycotoxins mixtures, the synergistic cytotoxicity of DON + 15-ADON, DON + NIV, and DON + FX at low and/or moderate inhibitory concentration levels (IC10–IC70, IC10–IC80, and IC10–IC40, respectively) were observed. FX + NIV resulted in almost completely synergistic cytotoxicity, whereas 15-ADON + NIV and 15-ADON + FX presented almost entirely antagonistic cytotoxicity on the GES-1 cell model. These results suggest that the simultaneous presence of low-dose type B trichothecenes in dietary food may be more or less toxic than the prediction based on individual mycotoxins.

Masked mycotoxins: does breeding for enhanced Fusarium head blight resistance result in more deoxynivalenol-3-glucoside in new wheat varieties?

From economic and environmental points of view, enhancing resistance to Fusarium head blight (FHB) in wheat is regarded as the best option to reduce fungal colonisation and the concomitant mycotoxin contamination. This review focuses on the effect of FHB resistance on deoxynivalenol (DON) and the masked metabolite deoxynivalenol-3-glucoside (DON-3-glucoside) in wheat. Based on published information complemented with our own results we draw the following conclusions: (1) All investigated wheat cultivars can convert DON to DON-3-glucoside. Hence, detoxification of DON to DON-3-glucoside is not a new trait introduced by recent resistance breeding against FHB. (2) The amount of DON-3-glucoside relative to DON contamination can be substantial (up to 35%) and is among other things dependent on genetic and environmental factors. (3) Correlation analyses showed a highly significant relationship between the amount of FHB symptoms and DON contamination: breeding for FHB resistance reduces DON contamination. (4) DON contamination data are highly correlated with DON-3-glucoside concentration data: in other words, reduction of DON content through resistance breeding results in a concomitant reduction in DON-3-glucoside content. (5) The DON-3-glucoside/DON ratio increases with decreasing DON contamination: the most resistant lines with the lowest DON contamination show the highest relative level of DON-3-glucoside to DON. In summary, introgressing FHB resistance reduces both DON and DON-3-glucoside levels in the grain, but the reduction is lower for the masked toxin. DON-3-glucoside can represent a possible hazard to human and animal health, especially in wheat samples contaminated with DON close to permitted limits.

Effect of environmental factors on Fusarium population and associated trichothecenes in wheat grain grown in Jiangsu province, China

The present study was performed to identify prevailing Fusarium species and the environmental factors affecting their frequencies and the contamination of grain with major mycotoxins in Jiangsu province. The precipitation levels were 184.2mm, 156.4mm, and 245.8mm in the years 2013-2015, respectively, and the temperature fluctuated by an average of 10.6±7.2°C in 2013, 10.9±7.2°C in 2014, and 10.6±6.3°C in 2015. Co-occurrence of deoxynivalenol (DON), 3-acetyldeoxynivalenol (3ADON), and 15-acetyldeoxynivalenol (15ADON) were observed in wheat. The average concentrations of DON were 879.3±1127.8, 627.8±640.5, and 1628.6±2,168.0μg/kg in 2013-2015, respectively. The average concentrations of 3ADON were 43.5±59.0, 71.2±102.5, and 33.5±111.9μg/kg in 2013-2015, respectively. We found that the average concentration of DON in wheat was positively correlated with precipitation (r=0.998, p<0.01), and 3ADON was negatively correlated with precipitation (r=-0.887, p<0.05). However, there was no correlation between precipitation and 15ADON or nivalenol (NIV). The differences in temperature were not as significant as the differences in rainfall amount over a short time period. Therefore, there were no correlations between temperature and the concentrations of trichothecenes, excluding 3ADON (r=0.996, p<0.01). Our data indicated that Fusarium asiaticum is the primary pathogenic fungus prevalent in the Fusarium head blight disease nursery. The trichothecene chemotype composition differed between Fusarium graminearum sensu stricto (s. str.) and F. asiaticum isolates. The 3ADON chemotype was found only among strains of F. asiaticum. The NIV chemotype was not observed among strains of F. graminearum, while the 15ADON chemotype represented 100% of the F. graminearum strains collected. The results of this study indicated no correlations between environmental conditions and the species or genetic chemotype composition of pathogens in Jiangsu province in 2013-2015.

Risk assessment of chronic dietary exposure to the conjugated mycotoxin deoxynivalenol-3-β-glucoside in the Dutch population

In this study, a risk assessment of dietary exposure to the conjugated mycotoxin deoxynivalenol-3-β-glucoside (DON-3G) in the Dutch population was conducted. Data on DON-3G levels in food products available in the Netherlands are scarce. Therefore, data on co-occurring levels of DON-3G and deoxynivalenol (DON), its parent compound, were used to estimate the DON-3G/DON ratio for several food product categories. This resulted in a DON-3G/DON ratio of 0.2 (90% confidence interval (CI): 0.04-0.9) in grains & grain-milling products, 0.3 (90% CI: 0.03-2.8) in grain-based products and 0.8 (90% CI: 0.4-1.8) in beer. These ratios were applied to the Dutch monitoring data of DON to estimate the DON-3G concentrations in food products available in the Netherlands. DON and DON-3G concentrations were combined with food consumption data of two Dutch National Food Consumption Surveys to assess chronic exposure in young children (2-6 years), children (7-16 years) and adults (17-69 years) using the Monte Carlo Risk Assessment program. The chronic exposure levels of DON, DON-3G and the sum of both compounds (DON+DON-3G) were compared to the tolerable daily intake (TDI) of 1 μg/kg body weight/day which is based on the most critical effect of DON, namely decreased body weight gain. The assumption was made that DON-3G is deconjugated and then fully absorbed as DON in the gastro-intestinal tract. Exposure (P97.5) of the population aged 7-16 years and 17-69 years to DON or DON-3G separately, did not exceed the TDI. However, exposure to upper bound levels of DON+DON-3G (i.e. worst-case scenario) in the same age categories (P97.5) exceeded the TDI with a maximum factor of 1.3. Exposure (P97.5) of the 2-6 year-olds to DON was close to the TDI. Within this group, exposure (P97.5) to upper bound levels of DON+DON-3G exceeded the TDI with not more than a factor 2.

Breeding healthy cereals: genetic improvement of Fusarium resistance and consequences for mycotoxins

Although it is generally agreed that increased genetic resistance to fungal colonisation by Fusarium head blight (FHB) should lead to reduced damage and particularly to reduced contamination due to mycotoxins, this review aims to highlight on this relation based on published literature in comparison to our own results. We focus here on the major cereal crop plants wheat and barley. Generally, correlations between measures for disease severity on the plants or the seeds and toxin content were found positive and significant. Breeding of new cultivars with reduced Fusarium disease severity will therefore lead to a correlated selection response in the direction of reduced toxin contamination, for the prevalent toxins such as deoxynivalenol, but also for less abundant mycotoxins and masked mycotoxins. Choosing resistant cultivars is possibly the best option for mycotoxin reduction right at the beginning of the cereal production chain: on the farmer’s field. Therefore, investment in breeding FHB resistant cultivars will contribute to sustainable reduction of the mycotoxin problems in the cereal production chain, and increase food and feed safety.

Proposal of a comprehensive definition of modified and other forms of mycotoxins including "masked" mycotoxins

As the term “masked mycotoxins” encompasses only conjugated mycotoxins generated by plants and no other possible forms of mycotoxins and their modifications, we hereby propose for all these forms a systematic definition consisting of four hierarchic levels. The highest level differentiates the free and unmodified forms of mycotoxins from those being matrix-associated and from those being modified in their chemical structure. The following lower levels further differentiate, in particular, “modified mycotoxins” into “biologically modified” and “chemically modified” with all variations of metabolites of the former and dividing the latter into “thermally formed” and “non-thermally formed” ones. To harmonize future scientific wording and subsequent legislation, we suggest that the term “modified mycotoxins” should be used in the future and the term “masked mycotoxins” to be kept for the fraction of biologically modified mycotoxins that were conjugated by plants.

Occurrence of deoxynivalenol and deoxynivalenol-3-glucoside in durum wheat

The occurrence of deoxynivalenol and deoxynivalenol-3-glucoside in durum wheat samples (n=150; 25 lines × 2 reps × 3 environments) collected in 2010 from 3 areas located in north-central Italy was evaluated. In addition, the co-occurrence of other trichothecenes was considered. An optimised extraction method based on the use of salts followed by ultra-high performance liquid chromatography-mass spectrometry analysis was used for the quantification of the mycotoxins. All samples were found positive for deoxynivalenol at concentrations ranging between 47 and 3,715 μg/kg. A ubiquitous occurrence of deoxynivalenol-3-glucoside was found; 85% of the analysed samples contained this masked mycotoxin at concentrations varying between 46 and 842 μg/kg. In addition to glycosylated deoxynivalenol, acetylated forms of deoxynivalenol (3- and 15-acetyldeoxynivalenol) were also found in most of the durum wheat samples. The deoxynivalenol-3-glucoside/deoxynivalenol ratio, reaching up to 30% in many samples, was similar to that already found in other cereals such as soft wheat and barley. These data open the way for further investigations on the role of glycosylating activity as a possible Fusarium head blight-resistance mechanism in durum wheat, as already proved in the case of soft wheat.

Special issue: Masked mycotoxins

In 1990, Gareis et al. referred to a zearalenone-glycoside as a ‘masked mycotoxin’ to emphasise the fact that this mycotoxin conjugate was not detected by routine analysis of food or feed, but probably contributed to the total mycotoxin content and subsequent effects. Indeed, pigs fed with mixed feed, artificially contaminated with synthesised zearalenone-4-ß-D-glucopyranoside, excreted zearalenone (ZEA) and α-zearalenol in their faeces and urine, demonstrating release of the aglucone during digestion. Earlier, in 1988, Engelhardt et al. demonstrated that wheat and maize cell cultures were able to transform ZEA to the ß-D-glucopyranoside-conjugate as part of their plant metabolism. It is generally known that plants can reduce the toxicity of phytotoxic compounds by chemical modification. This plant detoxification process includes the conjugation of mycotoxins to polar substances such as sugars, amino acids and sulphate, and subsequent storage of the conjugates in cell vacuoles. In 2002, Schneweis et al. described the natural occurrence of zearalenone-4-glucoside in wheat, while in 2005, Berthiller et al. published the first report on the natural occurrence of deoxynivalenol-3-glucoside (DON-3G) in maize and wheat samples. Since then, research on masked mycotoxins has grown exponentially. Besides plant metabolism, food technological processes also have an impact on the masking mechanism, specifically in cereal-based products in the case of fumonisins (Humpf and Voss, 2004; Dall’Asta et al., 2008) and deoxynivalenol (DON) (Lancova et al., 2008).