Effect of Edible Coating on Antioxidants and Certain Properties of Dried Jerusalem Artichoke

Effect of gum Arabic and ethanol pretreatments on drying kinetics and quality attributes of dried carrot slices

Carrot is an important root vegetable to the food industry and consumers due to its nutritional and health benefits. Given the high moisture content and low shelf life of fresh carrots, preserving this highly demanded vegetable is vital. This current research modelled the drying kinetics and evaluated the quality of ultrasonic-assisted gum Arabic and ethanol pretreated and oven-dried carrot slices. Fresh carrots were processed into thin slices and immersed in 3% gum Arabic (GA), ethanol (99.9%), and distilled water (control), followed by ultrasonication (frequency: 50 Hz, power: 500 W, temperature: 25 °C) for 10 min and drying in a hot air oven at 50 °C. The loss of moisture from the carrots was periodically recorded, converted to moisture ratio before fitted to eleven semi-theoretical thin layer drying mathematical models. The effects of the pretreatments on the retention of bioactive compounds and carrots' physical and chemical properties were also evaluated. From the tested models, the Diffusion, Modified Henderson and Pabis, and Two-term models showed the best fitting (R² = 0.9944-0.9985; RSME = 0.0103-0.0227) to the experimental data from 3% GA and ethanol pretreated carrots, while control samples followed the Aghbasho model (R² = 0.9999; RMSE = 0.0033). Overall, the 3% GA pretreated carrot slices exhibited better colour (yellowness: 25.82-34.50; total colour differences: 8.12-13.06), water activity (0.37-0.44), total phenolic content (1.34-2.99 mg GAE/100 g DM), β-carotene (7.63-13.07 mg/100 g DM), and DPPH radical scavenging activity (5.67-8.02 mM AAE/100 g DM) than ethanol pretreated carrot slices and control samples. At the same time, 3 % GA pretreatment did not affect the drying rate of the carrot slices. The total soluble solids/titratable acidity ratio, rehydration capacity, and shrinkage ratio did not significantly (p > 0.05) vary among the treatments. The findings of this study can be used to develop an optimal drying protocol for pretreated carrot slices and to produce shelf-stable carrot products that can be used dried, rehydrated, or in combination with other products.

Recent processing of fruits and vegetables using emerging thermal and non-thermal technologies. A critical review of their potentialities and limitations on bioactives, structure, and drying performance

Fruits and vegetables have rich bioactive compounds and antioxidants that are vital for the human body and prevent the cell from disease-causing free radicals. Therefore, there is a growing demand for high-quality fruits and vegetables. Nevertheless, fruits and vegetables deteriorate due to their high moisture content, resulting in a 40-50% loss. Drying is a common food preservation technique in the food industry to increase fruits and vegetables' shelf-life. However, drying causes chemical modifications, changes in microstructure, and bioactives, thus, lowering the final product's quality as a considerable amount of bioactives compounds and antioxidants are lost. Conventional pretreatments such as hot water blanching, and osmotic pretreatment have improved fruit and vegetable drying performance. However, these conventional pretreatments affect fruits' bioactive compounds retention and microstructure. Hence, emerging thermal (infrared blanching, microwave blanching, and high-humidity hot-air impingement blanching) and non-thermal pretreatments (cold plasma, ultrasound, pulsed electric field, and edible films and coatings) have been researched. So the question is; (1) what are the mechanisms behind emerging non-thermal and thermal technologies' ability to improve fruits and vegetables' microstructure, texture, and drying performance? (2) how do emerging thermal and non-thermal technologies affect fruits and vegetables' bioactive compounds and antioxidant activity? and (3) what are preventing the large-scale commercialization of these emerging thermal and non-thermal technologies' for fruits and vegetables, and what are the future recommendations? Hence, this article reviewed emerging thermal blanching and non-thermal pretreatment technologies, emphasizing their efficacy in improving dried fruits and vegetables' bioactive compounds, structural properties, and drying performance. The fundamental mechanisms in emerging thermal and non-thermal blanching pretreatment methods on the fruits and vegetables' microstructure and drying performance were delved in, as well as what are preventing the large-scale commercialization of these emerging thermal and non-thermal blanching for fruits and vegetables, and the future recommendations. Emerging pretreatment approaches not only improve the drying performance but further significantly improve the retention of bioactive compounds and antioxidants and enhance the microstructure of the dried fruits and vegetables.

Impact of Gum Arabic Coating Pretreatment on Quality Attributes of Oven-Dried Red Raspberry (Rubus idaeus L.) Fruit

The present study evaluated the effect of gum arabic (GA) edible coating pretreatment on the quality of dried red raspberries. Red raspberries were independently pretreated with varied concentrations of GA (3, 5, and 10% (w/v) by dipping for 2 min before oven-drying at 60 °C until the moisture content was below 8% (18–24 h). Raspberries dipped in distilled water were used as the control samples. Quality attributes including colour, moisture content, water activity (aw), hardness, hygroscopicity, rehydration capacity, total soluble solids (TSS), titratable acidity (TA), pH, anthocyanin composition, ascorbic acid (AA) content, total phenolic content (TPC), antioxidant activity, peroxidase (POD), and polyphenol oxidase (PPO) enzyme activity were investigated. GA pretreatment of the raspberries improved the aw (lower), hardness (lower), TSS, TSS/TA ratio, BrimA, AA content, and TPC, whilst it significantly (p < 0.05) reduced the colour properties (redness, chroma, hue angle, and total colour differences) and the total anthocyanin content when compared with the control samples. The DPPH radical scavenging activity, POD, and PPO enzymes residual activities were not significantly (p > 0.05) affected by GA pretreatment. Five different types of anthocyanins, including cyanidin dihexoside, cyanidin 3-O-galactoside, cyanidin 3-O-glucosyl-rutinoside, and cyanidin 3-O-rutinoside were identified and quantified with cyanidin dihexoside being the primary anthocyanin, varying from 951.18–1053.70 µg/g DM. GA pretreatment of raspberries between 3 and 5% could result in improved physicochemical, antioxidant properties and minimum loss of anthocyanins.

Nano Coating of Aloe-Gel Incorporation Additives to Maintain the Quality of Freshly Cut Fruits

The edible coating is an environmentally friendly technology that is applied to fresh-cut fruit products. One of the natural ingredients that are potentially applicable is aloe-gel because it contains several functional components. The main advantage of aloe-coating is that additives can be incorporated into the polymer matrix to enhance its properties. Additives tend to improve the safety, nutritional, and sensory attributes of fresh fruits, but in some cases, aloe-coating does not work. Furthermore, particle size determines the effectiveness of the process on fresh-cut fruits. Aloe-gel nano-coating can be used to overcome the difficulty of adhesion on the surface of fresh-cut fruits. However, quality criteria for fresh cut fruit coated with aloe-gel nano-coating must be strictly defined. The fruit to be processed must be of minimal quality so that discoloration, loss of firmness, spoilage ratio, and fruit weight loss can be minimized. This study aims to discuss the use of nano-coating aloe-gel incorporated with additional ingredients to maintain the quality of fresh-cut fruits. It also examined the recent advances in preparation, extraction, stabilization, and application methods in fresh fruits.