Enrichment withn-3 fatty acid by tuna oil feeding of pigs: changes in composition and properties of bacon and different sausages as affected by the supplementation period

Polyphenols-Enrichment of Vienna Sausages Using Microcapsules Containing Acidic Aqueous Extract of Boletus edulis Mushrooms

Polyphenols are ubiquitous by-products in many plant foods. Their intake has been linked to health benefits like the reduced incidence of cardiovascular disease, diabetes, and cancer. These bioactive compounds can be successfully extracted from Boletus edulis mushrooms with acidic water. However, such extract could influence the sensory or textural properties of the product to be enriched; this inconvenience can be avoided by microencapsulating it using spray drying. In this study, the Vienna sausages were reformulated by replacing 2% of the cured meat with microcapsules containing an acidic aqueous extract of Boletus edulis mushrooms and by replacing ice flakes, an ingredient that represents 22.9% of the manufacturing recipe, with ice cubes from the same extract aiming to obtain a polyphenol enriched product. The results showed a higher content of polyphenols in sausages with extract (VSe; 568.92 μg/g) and microcapsules (VSm; 523.03 μg/g) than in the control ones (455.41 μg/g), with significant differences for 2,4-dihydroxybenzoic acid, protocatechuic acid, and 1-O-galloyl-β-D-glucose. However, because of the oxidative stress caused to the microcapsules by the extract's spray drying, VSm had the highest oxidation state. PV and TBARS levels varied with storage time in all formulations, but given the short period tested, they were well below the allowed/recommended limit. The extract, as such, negatively affected the appearance, odor, and taste of Vienna sausages. The microcapsules, instead, determined an increase in their acceptance rate among consumers; they also prevented moisture loss and color changes during storage. In conclusion, microcapsules are more suitable for use as a polyphenol enrichment ingredient in Vienna sausages than the extract.

Effects of Feeding Purple Rice (Oryza sativa L. Var. Glutinosa) on the Quality of Pork and Pork Products

Purple rice is a strain of glutaneous rice rich in anthocyanins and γ-oryzanol. Both types of compounds are involved in antioxidant and lipid metabolism of mammals. Three experimental diet types were used which consisted approximately by half either of purple rice, white rice or corn. Diets were fed to 3×10 pigs growing from about 30 to 100 kg. Meat samples were investigated either as raw or cured loin chops or as smoked bacon produced from the belly. Various physicochemical traits were assessed and data were evaluated by analysis of variance. Traits describing water-holding capacity (drip, thaw, and cooking losses) and tenderness (sensory grading, shear force) of the meat were mostly not significantly affected by the diet type. However, purple rice feeding of pigs resulted in lower fat and cholesterol contents of loin and smoked bacon compared to white rice, but not compared to corn feeding except of the fat content of the loin. The shelf life of the raw loin chops was improved by purple rice as well. In detail, the occurrence of thiobarbituric acid reactive substances after 9 days of chilled storage was three to four times higher in the white rice and corn diets than with purple rice. The n-6:n-3 ratio in the raw loin chops was 9:1 with purple rice and clearly higher with 12:1 with the other diets, meat lipids. Level and kind of effect of purple rice found in raw meat was not always recovered in the cured loin chops and the smoked bacon. Still the impression of flavor and color, as well as overall acceptability were best in the smoked bacon from the purple-rice fed pigs, whereas this effect did not occur in the cured loin chops. These findings suggest that purple rice has a certain, useful, bioactivity in pigs concerning meat quality, but some of these effects are of low practical relevance. Further studies have to show ways how transiency and low recovery in meat products of some of the effects can be counteracted.