Heat treatment adaptations in Clostridium perfringens vegetative cells

Survival of Clostridium perfringens, Staphylococcus aureus and Salmonella enterica in alternatively cured bacon during cooking and process deviations

Pork bellies were injected with four different alternative curing brines. The bellies were inoculated on the surface and at a depth of 1 cm with multiple strains of Clostridium perfringens, Staphylococcus aureus and Salmonella enterica. The bellies were processed using either a standard process cycle or an interrupted process cycle to simulate a process deviation. Additionally, laboratory simulation of the same cycles was conducted where surface inoculated pork belly samples (22 ± 1 g) were processed in a circulating water bath. Microbiological populations were determined at the beginning, mid-point and end of the cycles, and the change in population was calculated for each bacterium at each time point, by comparing the population to the initial inoculated population. Irrespective of the brine or process cycle, the populations of all of the inoculated bacteria on both the surface and interior samples had decreased by the end of the process. There was no difference in the reductions in bacterial populations for all of the inoculated bacteria by brine type or by sample location (P > 0.30). There were differences in the microbial population reductions for C. perfringens attributable to the processing cycle (P < 0.001), with less population reductions associated with the standard cycle when compared to the interrupted cycle. However, no differences (P > 0.10) were observed in the population reductions between the two processing cycles for either S. aureus or S. enterica.

The effect of low-temperature long-time (LTLT) cooking on survival of potentially pathogenic Clostridium perfringens in beef

Low-temperature long-time (LTLT) cooking may lead to risk of potential survival of pathogenic bacteria such as Clostridium perfringens in cooked meat. In this study, the effect of LTLT cooking on C. perfringens was investigated at temperatures commonly used by caterers. Brain heart infusion broth (BHIB) and meat cubes in pouches (vacuumed or non-vacuumed) were inoculated with C. perfringens (NCTC 8238) and heated at temperatures of 48 °C, 53 °C, 55 °C, 60 °C and 70 °C. The viability of C. perfringens in BHIB and meat was monitored using plate counting and the D-value of each thermal treatment was determined. The recovery of C. perfringens after thermal treatment was assessed using optical density measurements. Flow cytometry analysis was used to assess the physiological status (death/injury) of C. perfringens cells in BHIB. The results showed that the required log reduction (6-log) of C. perfringens can be achieved at 55 °C but not at 48 °C or 53 °C. The D-values at all temperatures were higher in meat compared to BHIB while the D-value at 55 °C was higher in non-vacuum compared to vacuum sealed meat. C. perfringens cells were able to recover and grow to pathogenic levels when thermal treatment was unable to achieve the required 6-log reduction. In BHIB, percentage of dead cells increased gradually at 48 °C, 53 °C and 55 °C while an immediate increase (>95%) was observed at 60 °C and 70 °C. These results are important to food safety authorities allowing to set the time-temperature combinations to be used in LTLT cooking to obtain safe meat.

Modeling of Clostridium perfringens vegetative cell inactivation in beef-in-sauce products: a meta-analysis using mixed linear models

The aim of the present study was to predict Clostridium perfringens vegetative cell inactivation during the final reheating step of two beef-in-sauce products prepared and distributed in a French hospital for exposure in risk assessment. In order to account for variability according to experts and international organization recommendations, published data were used to estimate the thermal inactivation parameters of a probabilistic model. Mixed effects models were proposed to describe variability on D(ref) the decimal reduction time at temperature T(ref). Many models differing by their description of variability on D(ref) were tested. Based on goodness-of-fit and parsimony of the model, the one including three random effects was chosen. That model describes random effects of vegetative cell culture conditions, strains and other uncontrolled experimental factors. In order to check the ability of the model to predict inactivation under dynamic thermal conditions, model validation was carried out on published non isothermal data. This model was then used to predict C. perfringens vegetative cell inactivation using temperature profiles inside beef-in-sauce products registered in a French hospital and to explore control measures easier to apply than French regulations.

Stress, sublethal injury, resuscitation, and virulence of bacterial foodborne pathogens

Environmental stress and food preservation methods (e.g., heating, chilling, acidity, and alkalinity) are known to induce adaptive responses within the bacterial cell. Microorganisms that survive a given stress often gain resistance to that stress or other stresses via cross-protection. The physiological state of a bacterium is an important consideration when studying its response to food preservation techniques. This article reviews the various definitions of injury and stress, sublethal injury of bacteria, stresses that cause this injury, stress adaptation, cellular repair and response mechanisms, the role of reactive oxygen species in bacterial injury and resuscitation, and the potential for cross-protection and enhanced virulence as a result of various stress conditions.

Protein expression in Vibrio parahaemolyticus 690 subjected to sublethal heat and ethanol shock treatments

Cells of Vibrio parahaemolyticus 690 were subjected either to heat shock at 42 degrees C for 45 min or to ethanol shock in the presence of 5% ethanol for 60 min. The protein profiles of the unstressed and stressed V. parahaemolyticus cells were compared. Additionally, the induction of DnaK- and GroEL-like proteins in the unstressed and stressed cells of V. parahaemolyticus was also examined. Analysis with one-dimensional sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE) indicated that three proteins with molecular masses of 93, 77, and 58 kDa were induced by both heat shock and ethanol shock. The protein patterns revealed by two-dimensional electrophoresis were more detailed than those revealed by one-dimensional SDS-PAGE. It was found that heat shock and ethanol shock affected the expression of a total of 28 proteins. Among them, four proteins with molecular masses of 94, 32.1, 26.7, and 25.7 kDa were enhanced by both heat shock and ethanol shock. Furthermore, immunoblot analysis showed the presence of a GroEL-like protein with a molecular mass of 61 kDa in the test organism, with the heat-shocked and ethanol-shocked cells producing a GroEL-like protein in a larger quantity than the unstressed cells. However, DnaK-like protein was not detectable in either the unstressed or the stressed cells.

Viability of Clostridium perfringens, Escherichia coli, and Listeria monocytogenes surviving mild heat or aqueous ozone treatment on beef followed by heat, alkali, or salt stress

The threat of pathogen survival following ozone treatment of meat necessitates careful evaluation of the microorganisms surviving under such circumstances. The objective of this study was to determine whether sublethal aqueous ozone treatment (3 ppm of O3 for 5 min) of microorganisms on beef surfaces would result in increased or decreased survival with respect to subsequent heat, alkali, or NaCl stress. A mild heat treatment (55 degrees C for 30 min) was used for comparison. Reductions in three-strain cocktails of Clostridium perfringens, Escherichia coli O157:H7, and Listeria monocytogenes on beef following the heat treatment were 0.14, 0.77, and 1.47 log10 CFU/g, respectively, whereas reductions following ozone treatment were 1.28, 0.85, and 1.09 log10 CFU/g, respectively. C. perfringens cells exhibited elevated heat resistance at 60 degrees C (D60 [time at 60 degrees C required to reduce the viable cell population by 1 log10 units or 90%] = 17.76 min) following heat treatment of beef (55 degrees C for 30 min) but exhibited reduced viability at 60 degrees C following ozone treatment (D60 = 7.64 min) compared with the viability of untreated control cells (D60 = 13.84 min). The D60-values for L. monocytogenes and E. coli O157:H7 following heat and ozone exposures were not significantly different (P > 0.05). C. perfringens cells that survived ozone treatment did not exhibit increased resistance to pH (pH 6 to 12) relative to non-ozone-treated cells when grown at 37 degrees C for 24 h. The heat treatment also resulted in decreased numbers of surviving cells above and below neutral pH values for both E. coli O157:H7 and L. monocytogenes relative to those of non-heat-treated cells grown at 37 degrees C for 24 h. There were significant differences (P < 0.05) in C. perfringens reductions with increasing NaCl concentrations. The effects of NaCl were less apparent for E. coli and L. monocytogenes survivors. It is concluded that pathogens surviving ozone treatment of beef are less likely to endanger food safety than are those surviving sublethal heat treatments.