A rapid most-probable-number-based enzyme-linked immunosorbent assay for the detection and enumeration of Salmonella Typhimurium in poultry wastewater

A validated miniaturized MPN method, based on ISO 6579:2002, for the enumeration of Salmonella from poultry matrices

AIMS

To validate the effectiveness of a miniaturized most probable number method (mMPN) in enumerating Salmonella from poultry matrices.

METHODS AND RESULTS

A MPN was developed, based on the ISO 6579:2002 method using modified semi-solid Rappaport-Vassiliadis media as the sole selective medium. The validation of the mMPN was shown to not differ significantly from, at the 95% confidence level (Student's t-test P = 0·357) to, the traditional 9-tube MPN (tMPN) using pure cultures of Salmonella ser. Typhimurium, Infantis, Montevideo, Muenster and Salmonella subsp II 1,4,12,27:b:[e,n,x] (Sofia). The validation of naturally and artificially contaminated poultry matrices (carcasses, scald tank water, faeces, caeca and feed) showed that detection using the mMPN compared well to the ISO 6572:2002; sensitivity (92%), specificity (97%) and agreement (KAPPA 0·72). The quantitative comparison between the tMPN and mMPN methods showed that 92% of enumerations were less than ± 1 log different (Student's t-test = 0·13). Financial analysis showed that the mMPN required 64% less media and 56% less labour than the tMPN.

CONCLUSION

The mMPN is a consistent, easy to automate method for the enumeration of Salmonella from different poultry matrices.

SIGNIFICANCE AND IMPACT OF STUDY

The miniaturized MPN reduces the material and labour cost of the method and enables the uniform and accurate measurement of the effectiveness of intervention strategies in the control of Salmonella colonization of poultry.

Effect of refrigerating delayed shipments of raw ground beef on the detection of Salmonella Typhimurium

In eight separate trials, four groups of raw ground beef samples were inoculated with 0.04 to 0.3 CFU/g of Salmonella Typhimurium (DT 104). Each group consisted of four 25-g samples (three inoculated and one uninoculated). After inoculation, these samples were shipped by overnight courier in Shipping containers with ice packs from the U.S. Department of Agriculture (USDA), Eastern Regional Research Center, in Wyndmoor, Pa., to the U.S. Food Safety and Inspection Service (FSIS), Eastern Laboratory, in Athens, Ga. A total of 128 samples (32 in each of four groups) were shipped. A temperature data logger was placed inside each shipping container to record the temperature during shipping and storage. The first group of ground beef samples was analyzed within approximately 1 h of arrival. The second group of samples was left in the original containers, with a gel ice pack, for 24 h before processing. The third and fourth groups of samples were removed from the original shipping containers and stored at room temperature (21 +/- 2 degrees C) for 6 h and then in a refrigerator at 4 +/- 2 degrees C for 24 and 48 h, respectively, before analysis. The samples were analyzed for the presence of Salmonella according to the USDA/FSIS Microbiological Laboratory Guidebook, chapter 4.02. There was no significant difference in the presence and levels of Salmonella in ground beef among the four test groups. These data show that it is acceptable to process the late-arriving ground beef samples for the detection of Salmonella if they are kept in a refrigerator (4 +/- 2 degrees C) for 24 to 48 h or when the shipments arrive late (24 h in the container with ice pack).