Molecular characterization of Escherichia coli O157 contamination routes in a cattle slaughterhouse

Assessment of ATP-Bioluminescence and Dipslide Sampling to Determine the Efficacy of Slaughterhouse Cleaning and Disinfection Compared with Total Aerobic and Enterobacterales Counts

Inadequate cleaning and disinfection (C&D) in slaughterhouses can cause bacterial contamination of meat, resulting in foodborne disease and reduced meat quality. Different methods for monitoring the efficacy of C&D procedures are available, but few studies have assessed their reliability. This study examined C&D efficacy in slaughterhouses and evaluated the diagnostic performance of methods for measuring surface hygiene. One red meat and one poultry slaughterhouse in Sweden were each visited on six occasions before and six occasions after C&D. Sampling points were sampled with: swabbing and plating for total aerobic bacteria (TAB) and Enterobacterales (EB); dipslides for total viable count; and ATP-bioluminescence tests. To evaluate the diagnostic performance of the dipslide and ATP-bioluminescence methods, the results were compared with (TAB) as a reference. In total, 626 samples were collected. For the majority of samples, TAB was lower after than before C&D and EB were mainly detected before C&D, indicating C&D efficacy. Greater reductions in mean TAB were observed in processing areas (2.2 and 2.8 log CFU/100 cm2 in red meat and poultry slaughterhouse, respectively) than in slaughter areas (1.3 log CFU/100 cm2 in both slaughterhouses). Approximately half of all samples were assessed as non acceptably clean (52% for red meat and 46% for poultry slaughterhouse) according to previously published thresholds. Critical food contact surfaces that were insufficiently cleaned and disinfected were plucking fingers, shackles, and a post-dehairing table. Cleaning and disinfection of drains and floors were inadequate. The ATP-bioluminescence method showed low specificity compared with the reference (TAB) in both the red meat (0.30) and poultry slaughterhouses (0.64). The sensitivity of dipslides was low (0.26) in the red meat slaughterhouse compared with TAB. A combination of ATP-bioluminescence and dipslides could provide more accurate estimates of C&D efficacy.

Recent developments in antimicrobial and antifouling coatings to reduce or prevent contamination and cross-contamination of food contact surfaces by bacteria

Illness as the result of ingesting bacterially contaminated foodstuffs represents a significant annual loss of human quality of life and economic impact globally. Significant research investment has recently been made in developing new materials that can be used to construct food contacting tools and surfaces that might minimize the risk of cross-contamination of bacteria from one food item to another. This is done to mitigate the spread of bacterial contamination and resultant foodborne illness. Internet-based literature search tools such as Web of Science, Google Scholar, and Scopus were utilized to investigate publishing trends within the last 10 years related to the development of antimicrobial and antifouling surfaces with potential use in food processing applications. Technologies investigated were categorized into four major groups: antimicrobial agent-releasing coatings, contact-based antimicrobial coatings, superhydrophobic antifouling coatings, and repulsion-based antifouling coatings. The advantages for each group and technical challenges remaining before wide-scale implementation were compared. A diverse array of emerging antimicrobial and antifouling technologies were identified, designed to suit a wide range of food contact applications. Although each poses distinct and promising advantages, significant further research investment will likely be required to reliably produce effective materials economically and safely enough to equip large-scale operations such as farms, food processing facilities, and kitchens.

Future foods for risk-resilient diets

Future foods, such as microalgae, mycoprotein and mealworm, have been suggested as nutritious and sustainable dietary options. Here we consider one of the most profound, yet neglected, benefits of future foods farming systems-their potential to provide essential nutrition in the face of systemic disturbances-and discuss major barriers to realizing this prospect.

Current Interventions for Controlling Pathogenic Escherichia coli

This review examined scientific reports and articles published from 2007 to 2016 regarding the major environmental sources of pathogenic Escherichia coli and the routes by which they enter the human gastrointestinal tract. The literature describes novel techniques used to combat pathogenic E. coli transmitted to humans from livestock and agricultural products, food-contact surfaces in processing environments, and food products themselves. Although prevention before contamination is always the best "intervention," many studies aim to identify novel chemical, physical, and biological techniques that inactivate or eliminate pathogenic E. coli cells from breeding livestock, growing crops, and manufactured food products. Such intervention strategies target each stage of the food chain from the perspective of "Farm to Table food safety" and aim to manage major reservoirs of pathogenic E. coli throughout the entire process. Issues related to, and recent trends in, food production must address not only the safety of the food itself but also the safety of those who consume it. Thus, research aims to discover new "natural" antimicrobial agents and to develop "multiple hurdle technology" or other novel technologies that preserve food quality. In addition, this review examines the practical application of recent technologies from the perspective of product quality and safety. It provides comprehensive insight into intervention measures used to ensure food safety, specifically those aimed at pathogenic E. coli.

Characterization of Shiga Toxin-Producing Escherichia coli O157 Isolates from Bovine Carcasses

The main purpose of this study was to determine the prevalence of Escherichia coli O157 on bovine carcasses before and after chilling at a large slaughterhouse located in the city of Barcelona, Spain, to assess the effectiveness of dry chilling on reducing E. coli O157 contamination of carcasses. In addition, the study characterized the E. coli O157 strains isolated in terms of virulence factors, antibiotic susceptibility, and their genetic diversity. Individual bovine carcasses were sampled before (n = 300) and after (n = 300) chilling over an 8-month period. Positive samples for E. coli O157 were subjected to virulence screening by PCR (stx1, stx2, and eaeA genes and the fliCH7 gene), antimicrobial susceptibility testing, and molecular typing by pulsed-field gel electrophoresis. A total of 9.7% (29 of 300) of the nonrefrigerated carcasses examined and 2.3% (7 of 300) of the refrigerated carcasses were positive for E. coli O157. All the isolates were serotype O157:H7, 92% (33 of 36) carried the stx1, stx2, and eaeA genes, and 8% (3 of 36) carried the stx2 and eaeA genes. Antimicrobial susceptibility testing showed a high degree of resistance: 29 strains (81%) were resistant to at least 1 antimicrobial of the 12 antimicrobials tested; 69% (25 of 36) were resistant to 4 or more antimicrobials. Molecular typing by pulsed-field gel electrophoresis found a high diversity of genetic types, implying little cross-contamination in the slaughterhouse. This study confirms that E. coli O157:H7 is present on the carcasses slaughtered in Spain, although its prevalence is reduced by the dry chilling process used. The recovered isolates showed potential pathogenesis and a high degree of multidrug resistance, confirming the importance of bovine meat monitoring.

Improving the Enrichment and Plating Methods for Rapid Detection of Non-O157 Shiga Toxin-Producing Escherichia coli in Dairy Compost

A culture method to detect non-O157 Shiga toxin-producing Escherichia coli (STEC) was optimized in this study. The finished dairy compost with 30% moisture content was inoculated with a cocktail of six non-O157 STEC serovars at initial concentrations of 1 to 100 CFU/g. Afterward, non-O157 STEC cells in the inoculated dairy compost were enriched by four methods, followed by plating onto cefixime-tellurite sorbitol MacConkey agar supplemented with 5 mg/liter novobiocin (CTNSMAC) and modified Rainbow agar containing 5 mg/liter novobiocin, 0.05 mg/liter cefixime trihydrate, and 0.15 mg/liter potassium tellurite (mRBA). Immunomagnetic bead separation (IMS) was used to compare the cell concentration of individual non-O157 STEC serotypes after enrichment. There was no significant difference (P > 0.05) between CTN-SMAC and mRBA for non-O157 STEC enumeration. The single-step selective enrichment recovered ca. 0.54 log CFU/g more cells (ca. 0.41 log CFU/g for compost-adapted cells) (P < 0.05) compared with the two-step enrichment. Furthermore, the duration of the process to detect non-O157 STEC from dairy compost by selective enrichment, followed by IMS, was optimized. Among six non-O157 STEC serotypes, serotypes O111, O45, and O145 reached the highest cell density after enrichment in dairy compost, and the cell populations reached 7.3, 7.4, and 7.8 log CFU/g within 16 h of incubation, respectively. In contrast, without an enrichment step, the IMS detection limit of individual non-O157 STEC serovars ranged from 3.15 to 4.15 log CFU/g in dairy compost. These results demonstrate that low levels of non-O157 STEC can be detected within 2 days from dairy compost by using a culture method with an optimized enrichment procedure followed by IMS.

Escherichia coli O157 in ground beef from local retail markets in Pachuca, Mexico

Escherichia coli O157 strains have been recognized as pathogenic bacteria, of which raw beef is a known vehicle. An evaluation was done of the presence of E. coli O157 in ground beef from local retail markets in Pachuca, Hidalgo State, Mexico. A total of 120 ground beef samples (500 g) were tested for E. coli O157 by simultaneous application of the U. S. Department of Agriculture, Food Safety and Inspection Service (FSIS)'s Microbiology Laboratory Guidebook culture procedure 5.05, and two commercial kits, Reveal for E. coli O157:H7 and Visual Immunoprecipitate Assay (VIP) Gold for enterohemorrhagic E. coli. Two incubation times (8 and 20 h) were used with the commercial kits. Presence of stx1, stx2, and eaeA loci was determined by multiplex PCR. Of 360 subsamples (120 per procedure), 12 samples were found to be E. coli O157 positive by the FSIS culture method. With VIP, 73 subsamples were presumptive positive after 8 h of enrichment, and 60 were presumptive positive after 20 h of enrichment. Of these, only 6 (8 h) and 8 (20 h) subsamples were confirmed true positives with the FSIS method. With Reveal, 60 subsamples were presumptive positive after 8 h of enrichment and 50 were presumptive positive after 20 h of enrichment. Of these, only 6 (8 h) and 8 (20 h) subsamples were confirmed as true positives with the FSIS method. A total of 57 E. coli O157:H7 and 21 E. coli O157 strains were isolated. None of the O157 or O157:H7 strains had stx1 or stx2 loci, and only one had the eaeA locus. To our knowledge, this is the first report of the presence of E. coli O157 in commercial ground beef from Mexico, and the first report of isolation of a large number of stx-negative E. coli O157 and E. coli O157:H7 strains in Mexico.

Serotypes and virulotypes of non-O157 shiga-toxin producing Escherichia coli (STEC) on bovine hides and carcasses

Four hundred and fifty beef animal hides and a similar number of carcasses were screened for STEC in 3 beef abattoirs over a 12 month period using PCR and culture based methods. 67% (301/450) of hides and 27% (122/450) of carcasses were STEC PCR positive. Forty isolates representing 12 STEC serotypes (O5:H-, O13:H2, O26:H11, O33:H11, O55:H11, O113:H4, O128:H8, O136:H12, O138:H48, O150:H2, O168:H8 and ONT:H11) and 15 serotype-virulotype combinations were identified. This study provides much needed non-O157 STEC surveillance data and also provides further evidence of bovines as a source of clinically significant STEC as well as identifying 3 emerging serotypes O5:H- (eae-β1), O13:H2 (eae-ζ), and O150:H2 (eae-ζ) that should be considered when developing beef testing procedures for non-O157 STEC.

Prevalence of Escherichia coli O157:H7 on hides and faeces of ruminants at slaughter in two major abattoirs in Nigeria

AIM

To determine the occurrence of Escherichia coli O157: H7 in hides and faeces of slaughtered ruminants in Nigeria.

METHODS AND RESULTS

A total number of 320 animals were sampled from January to December covering the wet and harmattan seasons. Samples were obtained from the hides and faeces of animals at slaughter. The ISO (ISO 16654:2001, Microbiology of food and animal feedingstuffs--horizontal method for the detection of Escherichia coli O157) method for enrichment and isolation of E. coli O157 incorporating selective enrichment using modified tryptone soya broth with novobiocin (mTSBn),immunomagnetic separation and plating on sorbitol-MacConkey agar with cefixime tellurite (CT-SMAC) was used. Overall cattle had a prevalence rate of 49.4% followed by sheep and goats with rates of 6.3% and 2.5%, respectively. There was a significant difference in carriage of E. coli O157 among two different cattle breeds.

CONCLUSIONS

The prevalence of E. coli O157: H7 is substantial from two abattoirs in the country. The carriage and shedding of E. coli O157: H7 did not differ with season but differed among groups of ruminants and among breeds of cattle in a tropical country.

SIGNIFICANCE AND IMPACT OF THE STUDY

This is the first study on E. coli O157: H7 from abattoir operations in Nigeria. The study emphasizes the risk of E. coli O157: H7 along the meat chain and the need for concerted effort to limit it through best hygiene practices.

Attachment and biofilm formation by Escherichia coli O157:H7 at different temperatures, on various food-contact surfaces encountered in beef processing

Escherichia coli O157:H7 attached to beef-contact surfaces found in beef fabrication facilities may serve as a source of cross-contamination. This study evaluated E. coli O157:H7 attachment, survival and growth on food-contact surfaces under simulated beef processing conditions. Stainless steel and high-density polyethylene surfaces (2×5cm) were individually suspended into each of three substrates inoculated (6log CFU/ml or g) with E. coli O157:H7 (rifampicin-resistant, six-strain composite) and then incubated (168h) statically at 4 or 15°C. The three tested soiling substrates included sterile tryptic soy broth (TSB), unsterilized beef fat-lean tissue (1:1 [wt/wt]) homogenate (10% [wt/wt] with sterile distilled water) and unsterilized ground beef. Initial adherence/attachment of E. coli O157:H7 (0.9 to 2.9log CFU/cm(2)) on stainless steel and high-density polyethylene was not affected by the type of food-contact surface but was greater (p<0.05) through ground beef. Adherent and suspended E. coli O157:H7 counts increased during storage at 15°C (168h) by 2.2 to 5.4log CFU/cm(2) and 1.0 to 2.8log CFU/ml or g, respectively. At 4°C (168h), although pathogen levels decreased slightly in the substrates, numbers of adherent cells remained constant on coupons in ground beef (2.4 to 2.5log CFU/cm(2)) and increased on coupons in TSB and fat-lean tissue homogenate by 0.9 to 1.0and 1.7 to 2.0log CFU/cm(2), respectively, suggesting further cell attachment. The results of this study indicate that E. coli O157:H7 attachment to beef-contact surfaces was influenced by the type of soiling substrate and temperature. Notably, attachment occurred not only at a temperature representative of beef fabrication areas during non-production hours (15°C), but also during cold storage (4°C) temperatures, thus, rendering the design of more effective sanitation programs necessary.

Super shedding of Escherichia coli O157:H7 by cattle and the impact on beef carcass contamination

Beef carcass contamination is a direct result of pathogen transfer from cattle hides harboring organisms such as enterohemorrhagic Escherichia coli. Hide contamination occurs from direct and indirect fecal contamination in cattle production and lairage environments. In each of these environments, individual animals shedding E. coli O157:H7 at high levels (>10(4) CFU/g of feces, hereafter referred to as "super shedders") can have a disproportionate effect on cattle hide and subsequent carcass contamination. It is not known what criteria must be met to cause an animal to shed at levels exceeding 10(4) CFU/g. Understanding the factors that play a role in super shedding will aid in minimizing or eliminating the super shedding population. Interventions that would prevent super shedding in the cattle population should reduce E. coli O157:H7 transmission in the production and lairage environments resulting in reduced risk of beef carcass contamination and a safer finished product.

The occurrence of Escherichia coli O157 in/on faeces, carcasses and fresh meats from cattle

The aim of this study was to investigate whether Escherichia coli O157 is present in/on raw beef in Serbia. Correlated faecal and carcasses samples from 115 slaughtered cattle plus 26 uncorrelated carcass samples were examined. E. coli O157 detection and identification was performed using selective enrichment and immunomagnetic separation followed by selective media-plating and biochemical tests. The E. coli O157 occurrences were 2.6% in faeces and 2.8% on carcasses. The E. coli O157 occurrences were 0%, 6.2% and 2.1%, respectively, in 106 samples of beef trimmings, 48 samples of minced beef and 48 samples of batter intended for production of raw, fermented sausages. The results confirmed that faecal contamination is very important for the occurrence of E. coli O157 on beef carcasses. Furthermore, the present study revealed occasional presence of the pathogen in raw materials used for producing raw, fermented beef sausages.

Factors associated with cross-contamination of hides of Scottish cattle by Escherichia coli O157

The putative source of hide contamination for 236 cattle in Scotland followed from the farm through to slaughter was determined using phage and verocytotoxin type data. The majority of cattle (84%) were found to have subtypes of Escherichia coli O157 on their hide that had not been found previously in any animal from the farm of origin, strongly suggesting that contamination occurred once animals had left the farm of origin. Using logistic regression analysis, several variables and factors were found to be strongly associated (P < 0.01) with cross-contamination of cattle hides at the univariate level; commercial transport to slaughter, transport with other animals, use of a crush, line automation, and increasing slaughterhouse throughput were all risk factors, while feeding hay in lairage, processing an animal earlier in a slaughter cohort, and cleaning the landing area poststunning were protective. In the multivariable model, with the slaughterhouse and the farm group included as random effects, factors associated with the cross-contamination of cattle hides were identified. Transport to the slaughterhouse by a commercial hauler had a borderline-significant association with increased odds of an animal having a cross-contaminated hide (odds ratio [OR] [95% confidence interval (CI)] = 5.7 [0.99, 33.0]; P = 0.05). At the slaughterhouse, providing hay to cattle waiting in lairage (OR [95% CI] = 0.04 [<0.01, 1.04]; P = 0.05) and cleaning the landing area (OR [95% CI] = 0.03 [<0.01, 1.15,]; P = 0.06) also had a borderline-significant association with decreased odds of an animal having a cross-contaminated hide. Although the prevalence of carcass contamination remains very low, targeted intervention at the preslaughter stage may have the potential to reduce further the risk to public health.

Source tracking of Escherichia coli O157:H7 and Salmonella contamination in the lairage environment at commercial U.S. beef processing plants and identification of an effective intervention

Transportation from the feedlot and lairage at the processing plant have been identified as potential sources of Escherichia coli O157:H7 and Salmonella hide contamination. The objective of this study was to perform a comprehensive tracking analysis of E. coli O157:H7 and Salmonella associated with beef cattle from the feedlot through processing. Cattle (n = 581) were sampled in a feedlot, then transported in multiple lots to three commercial, fed beef processing plants in the United States, where they were sampled again. Samples were collected from the tractor trailers prior to loading cattle and from the lairage environment spaces prior to entry of the study cattle. Pathogen prevalence on cattle hides increased on every lot of cattle between exiting the feedlot and beginning processing. Prior to loading cattle, E. coli O157:H7 was found in 9 (64%) of 14 tractor trailers. E. coli O157:H7 was detected in over 60% of the samples from each lairage environment area, while Salmonella was detected in over 70% of the samples from each lairage environment area. E. coli O157:H7 and Salmonella isolates (n = 3,645) were analyzed using pulsed-field gel electrophoresis. The results of the pulsed-field gel electrophoresis tracking indicate that the transfer of bacteria onto cattle hides that occurs in the lairage environments of U.S beef processing plants accounts for a larger proportion of the hide and carcass contamination than does the initial bacterial population found on the cattle exiting the feedlot. Finally, the results of this study indicate that hide wash cabinets are effective in removing contamination derived from the lairage environment.

Alternative sampling to establish the Escherichia coli O157 status on beef cattle farms

Prevalence of Escherichia coli O157 in cattle at the farm level is mostly determined by taking individually rectal samples. From the animal welfare point of view the collection of such samples on the farm is not advisable. The present study evaluated alternative sample types to assess the E. coli O157 status of cattle farms. Twelve closed cattle farms were visited twice with a time interval of 6-8 months. Rectal and hide surface samples (the nose, the neck, the shoulder, the flank, and the round) were collected from beef cattle within the period of 5 months before slaughter and from their environment (overshoes from the pen bedding, swabs from the pen barrier, feed and water). Statistical analysis revealed that from all samples taken only the "overshoe method" might be a good sampling technique to substitute the collection of individual fecal samples to establish the E. coli O157 status of a farm and even a pen. Characterization of the isolates, using pulsed field gel electrophoresis, revealed that on each positive farm only one genotype was presented, even after a period of more than 6 months.

Prevalence and molecular characterization of Escherichia coli O157:H7 on Irish lamb carcasses, fleece and in faeces samples

AIMS

To determine the prevalence, seasonal variation and virulence characteristics of Escherichia coli O157:H7 in lambs presented for slaughter in Ireland.

METHODS AND RESULTS

Over a 13-month period, pre- and postchill carcass swabs, faeces and fleece samples from 1600 lambs were examined for the presence of E. coli O157:H7. Escherichia coli O157:H7 was isolated from 5.75% (23/400) of fleece samples, 1.5% (6/400) of pre- and 1% (4/400) of postchill carcass swabs but was not isolated in faeces (0/400). The present study detected no evidence of seasonal variation. Polymerase chain reaction analysis showed that both the vt1 and vt2 genes associated with clinical illness were carried by five of the E. coli O157:H7 isolates, while 24 of the remaining isolates carried the vt2 gene only. Phage typing detected four different subtypes: PT 32 (48.48%), PT 8 (12.12%), PT 31 (12.12%) and PT 21/28 (12.12%).

CONCLUSIONS

Escherichia coli O157:H7 is present in lambs at slaughter in Irish abattoirs and the virulence profiles of these isolates reveals that they are potentially harmful to humans.

SIGNIFICANCE AND IMPACT OF THE STUDY

The present study provides crucial information indicating that sheep may be a significant contributing source to human E. coli O157:H7 infection.

Occurrence of Escherichia coli O157 on hides of slaughtered cattle

AIMS

To obtain the first information on the occurrence of Escherichia coli O157 on hides of slaughtered cattle in Serbia.

METHODS AND RESULTS

A total of 355 swabs were taken on the slaughterline from five areas of hide of each of the 71 cattle in a single commercial abattoir in Serbia. Using an ISO method incorporating enrichment and immunomagnetic separation steps, E. coli O157 was isolated from the hides of 20 animals (28 x 2%). With respect to different areas of the hides, the occurrence of the pathogen was, in decreasing order: hooves (11 x 3%), brisket (8 x 4%), rump (7 x 0%), neck (4 x 2) and flank (2 x 8%). In addition, factors that had more or less effects on the occurrence included visible dirtiness of the hide, cattle's age category, geographical origin of the animals and season.

CONCLUSIONS

This study revealed the presence of E. coli O157 in the beef chain in Serbia and confirmed hide as an important potential source of related contamination of beef carcasses. Therefore, incorporation of preskinning hide decontamination treatments into HACCP-based slaughterline hygiene control measures could be very useful.

SIGNIFICANCE AND IMPACT OF THE STUDY

The results will enable further optimization of necessary measures along the beef chain to reduce the E. coli O157 risks in Serbia.

Comparison of the molecular genotypes of Escherichia coli O157:H7 from the hides of beef cattle in different regions of North America

Cattle hides become contaminated with Escherichia coli O157:H7 via pathogen transmission in the feedlot, during transport, and while in the lairage environment at the processing facility, and the bacteria can be transferred to beef carcasses during processing. Several studies have shown that E. coli O157:H7 strains possessing indistinguishable restriction digest patterns (RDPs) can be isolated from distant locations. Most of these studies, however, examined RDPs from strains isolated within a single region of the United States or Canada. The experiment described in the present study was designed to identify the molecular genotypes of E. coli O157:H7 isolates from beef cattle hides in nine major cattle-producing regions of North America. Prevalence for E. coli O157:H7 in beef cattle hide samples ranged from 9 to 85%. Pulsed-field gel electrophoresis (PFGE) analysis of XbaI-digested genomic DNA from 1,193 E. coli O157:H7 isolates resulted in 277 unique RDPs. Of the 277 unique XbaI RDPs, 54 contained isolates collected from multiple regions. After two subsequent rounds of PFGE analysis (BlnI and SpeI), there were still many isolates (n = 154) that could not be distinguished from others, even though they were collected from different regions separated by large geographical distances. On multiple occasions, strains isolated from cattle hides in Canada had RDPs that were indistinguishable after three enzyme digestions from cattle hide isolates collected in Kansas and Nebraska. This information clearly shows that strains with indistinguishable RDPs originate from multiple sources that can be separated by large distances and that this should be taken into account when the source tracking of isolates is based on PFGE.

Transportation and lairage environment effects on prevalence, numbers, and diversity of Escherichia coli O157:H7 on hides and carcasses of beef cattle at processing

Hide has been established as the main source of carcass contamination during cattle processing; therefore, it is crucial to minimize the amount of Escherichia coli O157:H7 on cattle hides before slaughter. Several potential sources of E. coli O157: H7 are encountered during transportation and in the lairage environment at beef-processing facilities that could increase the prevalence and numbers of E. coli O157:H7 on the hides of cattle. On three separate occasions, samples were obtained from cattle at the feedlot and again after cattle were stunned and exsanguinated at the processing plant (286 total animals). The prevalence of E. coli O157:H7 on hides increased from 50.3 to 94.4% between the time cattle were loaded onto tractor-trailers at the feedlot and the time hides were removed in the processing plant. Before transport, nine animals had E. coli O157:H7 in high numbers (> 0.4 CFU/cm2) on their hides. When sampled at the slaughter facility, the number of animals with high hide numbers had increased to 70. Overall, only 29% of the E. coli O157:H7 isolates collected postharvest (221 of 764) matched pulsed-field gel electrophoresis types collected before transport. The results of this study indicate that transport to and lairage at processing plants can lead to increases in the prevalence and degree of E. coli O157:H7 contamination on hides and the number of E. coli O157:H7 pulsed-field gel electrophoresis types associated with the animals. More study is needed to confirm the mechanism by which additional E. coli O157:H7 strains contaminate cattle hides during transport and lairage and to design interventions to prevent this contamination.

Prevalence of enterohaemorrhagic Escherichia coli from serotype O157 and other attaching and effacing Escherichia coli on bovine carcasses in Algeria

AIMS

Bovine meat is the principal source of human contamination of attaching and effacing Escherichia coli, including enterohaemorrhagic E. coli O157. The aim was to study the prevalence of these strains on bovine carcasses in Algeria.

METHODS AND RESULTS

Two-hundred and thirty carcasses were swabbed and analysed by classical microbiological methods for total E. coli counts and for the presence of pathogenic E. coli. The E. coli counts were high, with a 75th percentile of 444.75 CFUs cm(-2). For pathogenic E. coli, more than 7% of the tested carcasses were positive for E. coli O157. Eighteen E. coli O157 strains were isolated and typed by multiplex PCR. The main isolated pathotype (78%) was eae+ stx2+ ehxA+. In addition to E. coli O157, other attaching and effacing E. coli (AEEC) were also detected from carcasses by colony hybridization after pre-enrichment and plating on sorbitol MacConkey agar using eae, stx1 and stx2 probes. Thirty carcasses (13%) on the 230 analysed harboured at least one colony positive for one of the tested probes. These positive carcasses were different from those positive for E. coli O157. Sixty-six colonies (2.9%) positive by colony hybridization were isolated. The majority (60.6%) of the positive strains harboured an enteropathogenic E. coli-like pathotype (eae+ stx-). Only three enterohaemorrhagic E. coli (EHEC)-like (eae+ stx1+) colonies were isolated from the same carcass. These strains did not belong to classical EHEC serotypes.

CONCLUSIONS

In this study, the global hygiene of the slaughterhouse was low, as indicated by the high level of E. coli count. The prevalence of both E. coli O157 and other AEEC was also high, representing a real hazard for consumers.

SIGNIFICANCE AND IMPACT OF THE STUDY

This is the first study of this type in Algeria, which indicates that the general hygiene of the slaughterhouse must be improved.

Molecular characterization of Escherichia coli O157:H7 hide contamination routes: feedlot to harvest

This study was conducted to identify the origin of Escherichia coli O157:H7 contamination on steer hides at the time of harvest. Samples were collected from the feedlot, transport trailers, and packing plant holding pens and from the colons and hides of feedlot steers. A total of 50 hide samples were positive for E. coli O157:H7 in two geographical locations: the Midwest (25 positive hides) and Southwest (25 positive hides). Hide samples were screened, and the presence of E. coli O157: H7 was confirmed. E. coli O157:H7 isolates were fingerprinted by pulsed-field gel electrophoresis and subjected to multiplex PCR procedures for amplification of E. coli O157:H7 genes stx1, stx2, eaeA, fliC, rfbEO157, and hlyA. Feedlot water trough, pen floor, feed bunk, loading chute, truck trailer side wall and floor, packing plant holding pen floor and side rail, and packing plant cattle drinking water samples were positive for E. coli O157:H7. Pulsed-field gel electrophoresis banding patterns were analyzed after classifying isolates according to the marker genes present and according to packing plant. In this study, hide samples positive for E. coli O157:H7 were traced to other E. coli O157:H7-positive hide, colon, feedlot pen floor fecal, packing plant holding pen drinking water, and transport trailer side wall samples. Links were found between packing plant side rails, feedlot loading chutes, and feedlot pens and between truck trailer, different feedlots, and colons of multiple cattle. This study is the first in which genotypic matches have been made between E. coli O157:H7 isolates obtained from transport trailer side walls and those from cattle hide samples within the packing plant.

Isolation of E. coli O157:H7 and non-O157 STEC in different matrices: review of the most commonly used enrichment protocols

AIMS

To review and characterize the enrichment protocols used for detecting all Shiga-Toxin producing Escherichia coli (STEC) from different matrices.

METHODS AND RESULTS

Firstly, the frequency distribution of the factors characterizing the enrichment protocols is described; secondly, a multiple correspondence analysis is performed to display profiles of association of these factors, and thirdly, published results concerning the relative performances of the protocols are summarized. Trypticase Soy Broth (TSB) is reported as the most frequently used enrichment broth. More often, one antibiotic is added in enrichment broths and these broths are incubated for a duration of 16-24 h at 35-37 degrees C. It also appears that the incubation temperature does not seem to be related to the type of serogroup looked for and that antibiotics are used regardless of the matrix analysed. Finally, results relating to the enrichment protocol efficacy are rare and differ from one study to another.

CONCLUSIONS

Statistical studies must be conducted so as to assess the efficacy of the main enrichment protocols investigated in this study.

SIGNIFICANCE AND IMPACT OF THE STUDY

This study reviews the most commonly used enrichment protocols and highlights the lack of results as to their relative efficacy.

Isolation and characterization of verocytotoxin-producing Escherichia coli O157 from Turkish cattle

The objective of this study was to collect rectal swabs from the cattle in a slaughterhouse located in Hatay (Turkey) immediately after slaughter for the isolation and characterization of verotoxin-producing Escherichia coli O157 in each month during a 1-year period. The rectal swab samples were analyzed for the isolation of E. coli O157 through pre-enrichment, immunomagnetic separation and selective plating on CT-SMAC agar. E. coli O157 was isolated from 77 (13.6%) of the samples. The presence of E. coli O157 changed during a 1-year period, in that the occurrence of E. coli O157 was the highest in July and November and lowest in February. A total of 66 isolates out of 77 were serotype O157:H7 and 11 were serotype O157:NM. PCR analysis of E. coli O157 virulence genes revealed that all O157:H7/NM were positive for rbf(O157), 74 positive for EhlyA, 72 positive for eaeA, 62 positive for vtx2, and 3 positive for both vtx1 and vtx2. It was presented by cytotoxicity tests that many of E. coli O157 isolates showed high cytotoxicity on Vero cells. All of the isolates containing EhlyA showed enterohaemolysin production.

Modeling and predicting the simultaneous growth of Escherichia coli O157:H7 and ground beef background microflora for various enrichment protocols

The simultaneous growth of Escherichia coli O157:H7 (O157) and the ground beef background microflora (BM) was described in order to characterize the effects of enrichment factors on the growth of these organisms. The different enrichment factors studied were basal medium (Trypticase soy broth and E. coli broth), the presence of novobiocin in the broth, and the incubation temperature (37 degrees C or 40 degrees C). BM and O157 kinetics were simultaneously fitted by using a competitive growth model. The simple competition between the two microfloras implied that O157 growth stopped as soon as the maximal bacterial density in the BM was reached. The present study shows that the enrichment protocol factors had little impact on the simultaneous growth of BM and O157. The selective factors (i.e., bile salts and novobiocin) and the higher incubation temperature (40 degrees C) did not inhibit BM growth, and incubation at 40 degrees C only slightly improved O157 growth. The results also emphasize that when the level of O157 contamination in ground beef is low, the 6-h enrichment step recommended in the immunomagnetic separation protocol (ISO EN 16654) is not sufficient to detect O157 by screening methods. In this case, prior enrichment for approximately 10 h appears to be the optimal duration for enrichment. However, more experiments must be carried out with ground beef packaged in different ways in order to confirm the results obtained in the present study for non-vacuum- and non-modified-atmosphere-packed ground beef.

An investigation of Escherichia coli O157 contamination of cattle during slaughter at an abattoir

The extent of contamination with Escherichia coli O157 was determined for 100 cattle during slaughter. Samples from 25 consecutively slaughtered cattle from four unrelated groups were collected from the oral cavity, hide, rumen, feces after evisceration, and pre- and postchill carcass. Ten random fecal samples were collected from the pen where each group of animals was held at the abattoir. E. coli O157 was detected using automated immunomagnetic separation (AIMS), and cell counts were determined using a combination of most probable number (MPN) and AIMS. E. coli O157 was isolated from 87 (14%) of the 606 samples collected, including 24% of 99 oral cavity samples, 44% of 100 hides, 10% of 68 fecal samples collected postevisceration, 6% of 100 prechill carcass swabs, and 15% of 40 fecal samples collected from holding pens. E. coli O157 was not isolated from rumen or postchill carcass samples. E. coli O157 was isolated from at least one sample from each group of cattle tested, and the prevalence in different groups ranged from less than 1 to 41%. The numbers of E. coli O157 differed among the animals groups. The group which contained the highest fecal (7.5 x 10(5) MPN/g) and hide (22 MPN/cm2) counts in any individual animal was the only group in which E. coli O157 was isolated from carcasses, suggesting a link between the numbers of E. coli O157 present and the risk of carcass contamination. Processing practices at this abattoir were adequate for minimizing contamination of carcasses, even when animals were heavily contaminated with E. coli O157.

Horizontal transmission of Escherichia coli O157:H7 during cattle housing

Ruminant livestock, particularly cattle, is considered the primary reservoir of Escherichia coli O157:H7. This study examines the transmission of E. coli O157:H7 within groups of cattle during winter housing. Holstein Friesian steers were grouped in six pens of five animals. An animal inoculated with and proven to be shedding a marked strain of E. coli O157: H7 was introduced into each pen. Fecal (rectal swabs) and hide samples (900 cm2 from the right rump) were taken from the 36 animals throughout the study. Water, feed, and gate or partition samples from each pen were also examined. Within 24 h of introducing the inoculated animals into the pens, samples collected from the drinking water, pen barriers, and animal hides were positive for the pathogen. Within 48 h, the hides of 20 (66%) of 30 cohort animals from the six pens were contaminated with E. coli O157:H7. The first positive fecal samples from the noninoculated cohort animals were detected 3 days after the introduction of the inoculated steers. During the 23 days of the study, 15 of 30 cohort animals shed the marked E. coli O157:H7 strain in their feces on at least one occasion. Animal behavior in the pens was monitored during a 12-h period using closed circuit television cameras. The camera footage showed an average of 13 instances of animal grooming in each pen per hour. The study suggests that transmission of E. coli O157:H7 between animals may occur following ingestion of the pathogen at low levels and that animal hide may be an important source of transmission.

Escherichia coli contamination of vegetables grown in soils fertilized with noncomposted bovine manure: garden-scale studies

In this study we tested the validity of the National Organic Program (NOP) requirement for a > or =120-day interval between application of noncomposted manure and harvesting of vegetables grown in manure-fertilized soil. Noncomposted bovine manure was applied to 9.3-m2 plots at three Wisconsin sites (loamy sand, silt loam, and silty clay loam) prior to spring and summer planting of carrots, radishes, and lettuce. Soil and washed (30 s under running tap water) vegetables were analyzed for indigenous Escherichia coli. Within 90 days, the level of E. coli in manure-fertilized soil generally decreased by about 3 log CFU/g from initial levels of 4.2 to 4.4 log CFU/g. Low levels of E. coli generally persisted in manure-fertilized soil for more than 100 days and were detected in enriched soil from all three sites 132 to 168 days after manure application. For carrots and lettuce, at least one enrichment-negative sample was obtained < or =100 days after manure application for 63 and 88% of the treatments, respectively. The current > or =120-day limit provided an even greater likelihood of not detecting E. coli on carrots (> or =1 enrichment-negative result for 100% of the treatments). The rapid maturation of radishes prevented conclusive evaluation of a 100- or 120-day application-to-harvest interval. The absolute absence of E. coli from vegetables harvested from manure-fertilized Wisconsin soils may not be ensured solely by adherence to the NOP > or =120-day limit. Unless pathogens are far better at colonizing vegetables than indigenous E. coli strains are, it appears that the risk of contamination for vegetables grown in Wisconsin soils would be elevated only slightly by reducing the NOP requirement to > or =100 days.

Spread of marker bacteria from the hides of cattle in a simulated livestock market and at an abattoir

The spread of microbial contamination on the hides of beef was investigated at two stages in the meat chain: (i) in a simulated livestock market ("the market") using 33 animals, and (ii) in the unloading-to-skinning area of a commercial abattoir using 18 animals. At both stages, harmless bacterial markers (nalidixic acid-resistant Escherichia coli K-12; rifampicin- and nalidixic acid-resistant Pseudomonas fluorescens; and a tetracycline-resistant E. coli) were inoculated on the hides of a small number of selected animals, and their transfer to other animals and the environment was examined. At the market, the initial prevalence of animals positive for the hide markers (9.1% in each phase) introduced in the presale pen, sale ring, and postsale pen changed to 39.4, 15.1, and 54.5%, respectively, by the end of the market process. In addition, widespread contamination of the market environment with the hide markers was observed. At the abattoir, the initial prevalence of animals positive for the hide marker (11.1%) inoculated at unloading increased to 100% (hide before skinning) and 88.8% (skinned carcass). In addition, another marker inoculated on environmental surfaces in lairage pens, races, and stunning box was detected on 83.3% (hide before skinning) and 88.8% (skinned carcass). These results, although obtained with a relatively small number of animals, demonstrate that both the livestock market process and the unloading-to-skinning process at abattoirs can facilitate the extensive spread of microbial contamination on hides not just within, but also between, batches of animals.

Genotypic analysis of Escherichia coli recovered from product and equipment at a beef-packing plant

AIMS

To identify sources of Escherichia coli on beef by characterizing strains of the organism on animals, equipment and product at beef-packing plant.

METHODS AND RESULTS

Generic E. coli were recovered from hides, carcasses, beef trimmings, conveyers and ground beef during the summer of 2001 (750 isolates) and winter of 2002 (500 isolates). The isolates were characterized by Random Amplification of Polymorphic DNA (RAPD). The numbers of E. coli recovered from dressed carcasses were less than the numbers recovered from hides. The numbers recovered from chilled carcasses were too few for meaningful analysis of the strains present on them but the numbers recovered from trimmings and ground beef were larger. The RAPD patterns showed that the majority of isolates from hides, carcasses, beef trimmings, conveyers and ground beef were of similar RAPD types, but a few unique RAPD types were recovered from only one of those sources. The E. coli populations present on the hides of incoming animals and in the beef-processing environment were highly diverse. Randomly selected E. coli isolates from each of the five sources were further characterized by pulsed-field gel electrophoresis (PFGE). Most genotypes of E. coli defined by PFGE corresponded to the E. coli types defined by RAPD.

CONCLUSIONS

The hides of the incoming animals appeared to be only one of the sources of the E. coli on trimmings and in ground beef, as additional sources were apparently present in equipment used for carcass breaking.

SIGNIFICANCE AND IMPACT OF THE STUDY

This study indicates that hazardous microbiological contamination of meat may occur after the dressing of carcasses at commercial beef-packing plants, which suggests that attention should be given to the control of the contamination of meat during carcass breaking as well as during the dressing of carcasses.