Preliminary evaluation of flow-through immunocapture followed by real-time PCR for the detection of Salmonella serovars on tomato surfaces within 8 hours

Occurrence and antibiotic resistance of multiple Salmonella serotypes recovered from water, sediment and soil on mid-Atlantic tomato farms

Salmonella outbreaks associated with the consumption of raw tomatoes have been prevalent in recent years. However, sources of Salmonella contamination of tomatoes remain poorly understood. The objectives of this study were to identify ecological reservoirs of Salmonella on tomato farms, and to test antimicrobial susceptibilities of recovered Salmonella isolates. Fourteen Mid-Atlantic tomato farms in the U.S. were sampled in 2009 and 2010. Groundwater, irrigation pond water, pond sediment, irrigation ditch water, rhizosphere and irrigation ditch soil, leaves, tomatoes, and swabs of harvest bins and worker sanitary facilities were analyzed for Salmonella using standard culture methods and/or a flow-through immunocapture method. All presumptive Salmonella isolates (n=63) were confirmed using PCR and the Vitek(®) 2 Compact System, and serotyped using the Premi(®)Test Salmonella and a conventional serotyping method. Antimicrobial susceptibility testing was carried out using the Sensititre™ microbroth dilution system. Four of the 14 farms (29%) and 12 out of 1,091 samples (1.1%) were found to harbor Salmonella enterica subsp. enterica. Salmonella was isolated by the immunocapture method from soil, while the culture method recovered isolates from irrigation pond water and sediment, and irrigation ditch water. No Salmonella was detected on leaves or tomatoes. Multiple serotypes were identified from soil and water, four of which-S. Braenderup, S. Javiana, S. Newport and S. Typhimurium-have been previously implicated in Salmonella outbreaks associated with tomato consumption. Resistance to sulfisoxazole was prevalent and some resistance to ampicillin, cefoxitin, amoxicillin/clavulanic acid, and tetracycline was also observed. This study implicates irrigation water and soil as possible reservoirs of Salmonella on tomato farms and irrigation ditches as ephemeral habitats for Salmonella. The findings point to the potential for pre-harvest contamination of tomatoes from contaminated irrigation water or from soil or water splash from irrigation ditches onto low-lying portions of tomato plants.

Real-time reverse-transcriptase--polymerase chain reaction for Salmonella enterica detection from jalapeño and serrano peppers

Outbreaks of Salmonella linked to fresh produce emphasize the need for rapid detection methods to curb the spread of foodborne pathogens. Reverse-transcriptase-polymerase chain reaction (RT-PCR) detects the presence of mRNA (shorter half-life than DNA), with greater potential of detecting viable pathogens. Real-time RT-PCR eliminates the need for gel electrophoresis and significantly enhances the speed of detection (<1 day) compared with traditional methods (>5 days). The objectives of this research were to apply real-time SYBR Green I-based RT-PCR to detect Salmonella from jalapeño and serrano peppers spiked with low and high inocula of Salmonella. Inoculated and uninoculated peppers were rinsed with water and dried under ultraviolet light for 10 min. Approximately 25 g peppers was inoculated with 10(8) to 10(1) colony forming units (CFU) of Salmonella enterica serovar Typhimurium in a stomacher bag and hand massaged in sterile 0.05 M glycine-0.14 M saline buffer (0.05% Tween, 3% beef extract) for optimal recovery of bacteria. A short preenrichment step of 6 h in buffered peptone water was needed for the detection of low inocula (10(4) CFU/25 g). One-milliliter portions of the extracts were serially diluted, plated on XLT4 agar, and used for RNA extraction with the Qiagen RNeasy Mini Kit. RT-PCR was carried out using SYBR Green I one-step RT-PCR with previously described invA gene primers and an internal amplification control. Detection limits were 10(4) CFU/25 g (approximately 10(2) CFU/g) and 10(7) CFU/25 g (approximately 10(5) CFU/g) Salmonella from enriched and unenriched inoculated peppers, respectively. Even though this method included a 6-h incubation period, the results were still obtainable in 1 day. This method shows promise for applications in routine surveillance and during outbreaks.

Immunocapture and real-time PCR to detect Campylobacter spp

In this work, the feasibility of using a large-volume immunocapture system as a sample pretreatment before detection of Campylobacter was studied. Real-time PCR was used for detection of captured cells after immunocapture. This immunocapture system is able to process high-volume samples by recirculation, increasing the possibility of capturing cells in low numbers. After 30 min of recirculation, the sample is concentrated from 250 ml to 200 microl. In this study, different parameters were compared in order to improve cell capture. The analysis of inoculated chicken skin showed that detection of Campylobacter at levels of 10(3) CFU/25 g was possible after 8 h of enrichment. The low recovery of Campylobacter cells (< 1%) makes this separation method qualitative rather than quantitative. The detection limit of the entire protocol was increased due to the low cell recovery of the sample pretreatment. Therefore, this immunoseparation is able to recover cells present in high concentration after enrichment but not cells present in low concentration. Isolation of Campylobacter cells is achievable using this separation method rather than rapid detection.

Recirculating immunomagnetic separation and optimal enrichment conditions for enhanced detection and recovery of low levels of Escherichia coli O157:H7 from fresh leafy produce and surface water

The objective of this study was to develop a rapid, simple method for enhanced detection and isolation of low levels of Escherichia coli O157:H7 from leafy produce and surface water using recirculating immunomagnetic separation (RIMS) coupled with real-time PCR and a standard culture method. The optimal enrichment conditions for the method also were determined. Analysis of real-time PCR data (C(T) values) suggested that incubation of lettuce and spinach leaves rather than rinsates provides better enrichment of E. coli O157:H7. Enrichment of lettuce or spinach leaves at 42 degrees C for 5 h provided better detection than enrichment at 37 degrees C. Extended incubation of surface water for 20 h at 42 degrees C did not improve the detection. The optimized enrichment conditions were also employed with modified Moore swabs, which were used to sample flowing water sites. Positive isolation rates and real-time PCR results indicated an increased recovery of E. coli O157:H7 from all samples following the application of RIMS. Under these conditions, the method provided detection and/or isolation of E. coli O157:H7 at levels as low as 0.07 CFU/g of lettuce, 0.1 CFU/g of spinach, 6 CFU/100 ml of surface water, and 9 CFU per modified Moore swab. During a 6-month field study, modified Moore swabs yielded high isolation rates when deployed in natural watershed sites. The method used in this study was effective for monitoring E. coli O157:H7 in the farm environment, during postharvest processing, and in foodborne outbreak investigations.

Detection of salmonella by flow-through immunocapture real-time PCR in selected foods within 8 hours

This study investigated flow-through immunocapture (FTI), using the Pathatrix device, followed by plating on xylose lysine desoxycholate (XLD) agar (FTI-XLD) or analysis by real-time PCR (FTI-PCR) for the detection of Salmonella on smooth tomato surfaces and in potato salad and ground beef within 8 h. Food samples were inoculated with an appropriate dilution of a five-serovar Salmonella cocktail and enriched for 5 h. Following enrichment, samples were analyzed by the FTI-XLD and FTI-PCR methods. Food samples were also analyzed by a modified U.S. Food and Drug Administration Bacteriological Analytical Manual (BAM) Salmonella culture method for comparison. Salmonella inoculated at 10(0) CFU per tomato or 10(0) CFU/25 g was detected by the FTI-XLD method in 6, 8, and 4 of 10 samples for tomatoes, potato salad, and ground beef, respectively. Salmonella inoculated at 10(0) CFU per tomato or 10(0) CFU/25 g was detected by the FTI-PCR method in 8, 9, and 9 of 10 samples for tomatoes, potato salad, and ground beef, respectively. The FTI-PCR method achieved significantly higher (P < 0.05) detection of Salmonella on tomatoes, whereas the FTI-XLD method achieved significantly lower (P < 0.05) detection of Salmonella in ground beef when compared with the modified BAM Salmonella culture method; however, all other comparisons to the modified BAM method were not significantly different. The FTI-XLD method demonstrated the ability to isolate presumptive Salmonella colonies up to 48 hfaster than did the modified BAM Salmonella culture method.