Mathematical modeling and assessment of microbial migration during the sprouting of alfalfa in trays in a nonuniformly contaminated seed batch using Enterobacter aerogenes as a surrogate for Salmonella Stanley

Survival of Salmonella and the surrogate Enterococcus faecium in cooking of moisture enhanced reconstructed comminuted chicken patties by double pan-broiling

This study compares kinetic parameters of Salmonella and Enterococcus faecium in moisture enhanced, reconstructed comminuted chicken patties prepared with different pump rates during double pan-broiling with various set-up temperatures. Fresh 1.5-kg chicken breast meat was course grounded, inoculated with S. Typhimurium and Tennessee, or E. faecium, followed by adding NaCl (2.0%) + Na-tripolyphosphate (0.5%) solutions to achieve pump rates of 1%, 5%, or 11.1%. Meat samples were manually manufactured into patties with the thickness of 2.1 cm and diameter of 10.4 cm. Patties were packaged with polyvinyl chloride films in the foam-tray stored at 4°C for 42 h before double pan-broiling set at 200°, 300°, or 425°F for 0 to 420 s. Counts of pathogens were analyzed on xylose-lysine-Tergitol-4 and bile esculin agars with tryptic soy agar layers. Microbial data and kinetic parameters (n = 9, United States Department of Agriculture [USDA]-Integrated-Predictive-Modeling-Program/USDA-Global-Fit software) were analyzed by the Mixed Model Procedure (SAS). Double pan-broiling reduced >5-log₁₀ CFU/g (P < 0.05) of Salmonella after 360 (200°F), 180 to 225 (300°F), and 150 to 165s (425°F), and of E. faecium after 270 s (300°F), and 180 s (425°F) across all samples. D-values (Mafart-Weibull model) of Salmonella and E. faecium in 1% moisture enhanced samples cooked at 200 to 425°F (102.7-248.2 and 115.5-271.0 s) were lower (P < 0.05) than 11.1% samples (119.8-263.7 and 122.5-298.3 s). Salmonella were more susceptible (P < 0.05) to heat than E. faecium. "Shoulder-time" (Buchanan-Two-Phase model) of Salmonella cooking at 200° to 425°F increased (P < 0.05) from 82.3-229.0 to 116.6-246.2 s as pump rate increased from 1 to 11.1%, whereas this phenomenon was not shown for E. faecium. Results indicate that Salmonella were resistant to heat in chicken patties with greater pump rate. E. faecium can be used as a surrogate for Salmonella to validate thermal inactivation in chicken products.

Selection of Surrogate Bacteria for Use in Food Safety Challenge Studies: A Review

Nonpathogenic surrogate bacteria are prevalently used in a variety of food challenge studies in place of foodborne pathogens such as Listeria monocytogenes, Salmonella, Escherichia coli O157:H7, and Clostridium botulinum because of safety and sanitary concerns. Surrogate bacteria should have growth characteristics and/or inactivation kinetics similar to those of target pathogens under given conditions in challenge studies. It is of great importance to carefully select and validate potential surrogate bacteria when verifying microbial inactivation processes. A validated surrogate responds similar to the targeted pathogen when tested for inactivation kinetics, growth parameters, or survivability under given conditions in agreement with appropriate statistical analyses. However, a considerable number of food studies involving putative surrogate bacteria lack convincing validation sources or adequate validation processes. Most of the validation information for surrogates in these studies is anecdotal and has been collected from previous publications but may not be sufficient for given conditions in the study at hand. This review is limited to an overview of select studies and discussion of the general criteria and approaches for selecting potential surrogate bacteria under given conditions. The review also includes a list of documented bacterial pathogen surrogates and their corresponding food products and treatments to provide guidance for future studies.

Control of Salmonella on Sprouting Mung Bean and Alfalfa Seeds by Using a Biocontrol Preparation Based on Antagonistic Bacteria and Lytic Bacteriophages

The following reports on the application of a combination of antagonistic bacteria and lytic bacteriophages to control the growth of Salmonella on sprouting mung beans and alfalfa seeds. Antagonistic bacteria were isolated from mung bean sprouts and tomatoes by using the deferred plate assay to assess anti-Salmonella activity. From the isolates screened, an Enterobacter asburiae strain (labeled “JX1”) exhibited stable antagonistic activity against a broad range of Salmonella serovars (Agona, Berta, Enteritidis, Hadar, Heidelberg, Javiana, Montevideo, Muenchen, Newport, Saint Paul, and Typhimurium). Lytic bacteriophages against Salmonella were isolated from pig or cattle manure effluent. A bacteriophage cocktail prepared from six isolates was coinoculated with E. asburiae JX1 along with Salmonella in broth culture. The combination of E. asburiae JX1 and bacteriophage cocktail reduced the levels of Salmonella by 5.7 to 6.4 log CFU/ml. Mung beans inoculated with Salmonella and sprouted over a 4-day period attained levels of 6.72 ± 0.78 log CFU/g. In contrast, levels of Salmonella were reduced to 3.31 ± 2.48 or 1.16 ± 2.14 log CFU/g when the pathogen was coinoculated with bacteriophages or E. asburiae JX1, respectively. However, by using a combination of E. asburiae JX1and bacteriophages, the levels of Salmonella associated with mung bean sprouts were only detected by enrichment. The biocontrol preparation was effective at controlling the growth of Salmonella under a range of sprouting temperatures (20 to 30°C) and was equally effective at suppressing the growth of Salmonella on sprouting alfalfa seeds. The combination of E. asburiae JX1 and bacteriophages represents a promising, chemical-free approach for controlling the growth of Salmonella on sprouting seeds.