Validation of low-volume enrichment protocols for detection of Escherichia coli O157 in raw ground beef components, using commercial kits

Evaluation of post-contamination survival and persistence of applied attenuated E. coli O157:H7 and naturally-contaminating E. coli O157:H7 on spinach under field conditions and following postharvest handling

This study determined the variability in population uniformity of an applied mixture of attenuated E. coli O157:H7 (attEcO157) on spinach leaves as impacted by sampling mass and detection technique over spatial and temporal conditions. Opportunistically, the survival and distribution of naturally contaminating pathogenic E. coli O157:H7 (EcO157), in a single packaged lot following commercial postharvest handling and washing, was also evaluated. From the main study outcomes, differences in the applied inoculum dose of 100-fold, resulted in indistinguishable population densities of approximately Log 1.1 CFU g^-1 by 14 days post-inoculation (DPI). Composite leaf samples of 150 g and the inclusion of the spinach petiole resulted in the greatest numerical sensitivity of detection of attEcO157 when compared to 25 and 150 g samples without petioles (P < 0.05). Differences in population density and protected-site survival and potential leaf internalization were observed between growing seasons and locations in California (P < 0.05). A Double Weibull model best described and identified two distinct populations with different inactivation rates of the inoculated attEcO157. Linear die-off rates varied between 0.14 and 0.29 Log/Day irrespective of location. Detection of EcO157- stx1-negative and stx2-positive, resulting from a natural contamination event, was observed in 11 of 26 quarantined commercial units of washed spinach by applying the 150 g sample mass protocol. The capacity to detect EcO157 varied between commercial test kits and non-commercial qPCR. Our findings suggest the need for modifications to routine pathogen sampling protocols employed for lot acceptance of spinach and other leafy greens.

The physiologic state of Escherichia coli O157:H7 does not affect its detection in two commercial real-time PCR-based tests

Multiplex real-time PCR detection of Escherichia coli O157:H7 is an efficient molecular tool with high sensitivity and specificity for meat safety assurance. The Biocontrol GDS(®) and DuPont Qualicon BAX(®)-RT rapid detection systems are two commercial tests based on real-time PCR amplification with potential applications for quantification of specific E. coli O157:H7 gene targets in enriched meat samples. However, there are arguments surrounding the use of these tests to predict pre-enrichment concentrations of E. coli O157:H7, as well as arguments pertaining to the influence of non-viable cells causing false positive results. The present study attempts to illustrate the effects of different bacterial physiologic states and the presence of non-viable cells on the ability of these systems to accurately measure contamination levels of E. coli O157:H7 in ground beef. While the PCR threshold cycle (C(T)) values of these assays showed a direct correlation with the number of bacteria present in pure cultures, this was not the case for ground beef samples spiked with various levels of injured or healthy cells. Furthermore, comparison of post-enrichment cell densities of bacteria did not correlate with injured or healthy cell numbers inoculated before enrichment process. Ground beef samples spiked with injured or healthy cells at different doses could not be distinguished by C(T) values from either assay. In addition, the contribution of nonviable cells in generating positive real-time PCR signals was investigated using both assays on pre-enriched and post-enriched beef samples, but only if inoculated at levels of 10(6) cells/sample or higher, which are levels not typically seen in ground beef.

Inoculation of beef with low concentrations of Escherichia coli O157:H7 and examination of factors that interfere with its detection by culture isolation and rapid methods

Currently used industry testing programs require the ability to detect Escherichia coli O157:H7 in samples of beef trim or ground beef at levels as low as 1 CFU/375 g. We present a reliable protocol for generating a control inoculum for verification testing at this low concentration and evaluate its use. Results show that half of all samples received no cells when 1 CFU was the target concentration and that targets greater than 3 CFU were much more reliable. Detection by culture isolation and two commercial assays, Qualicon BAX-MP and BioControl GDS, detected 94% ± 11%, 92% ± 10%, and 92% ± 7% of samples inoculated with 5.4 CFU (range 1 to 9 CFU), respectively. We also examined the effect of background aerobic plate count (APC) bacteria and fat content effects on the detection of E. coli O157:H7. At APC concentrations below 6 log CFU/g, the rapid methods detected all beef trim samples inoculated with 26 CFU of E. coli O157:H7 per 65 g. At an APC of 6.7 log CFU/g, culture, BAX-MP, and GDS detected 100, 75, and 13%, respectively, of inoculated samples. Neither commercial method detected E. coli O157:H7 in the samples when APC was 7.7 log CFU/g, whereas culture was able to detect 63% of E. coli O157:H7 in the samples when APC was at this concentration. Increased fat content correlated with decreasing recovery of immunomagnetic separation beads, but this was not observed to interfere with detection of E. coli O157:H7.

Comparative evaluation of practical functionality of rapid test format kits for detection of Escherichia coli O157:H7 on lettuce and leafy greens

Multistate outbreaks of Escherichia coli O157:H7 infection in 2005 and 2006 associated with fresh and especially minimally processed produce greatly escalated the application of rapid pathogen detection systems to safety management in this food category. Pathogen testing was rapidly integrated into preharvest qualification for field lots, incoming raw produce, or final product. The raw produce and final product were incorporated into test-and-hold programs, typically within a 10-h time frame. To enhance consumer safety and provide guidance for the industry, an assessment of selected kits in comparison to a culture-based method was undertaken. Four primary kits were compared: the Neogen Reveal, SDI RapidChek, BioControl GDS O157, and Qualicon BAX O157 MP. Nine different leafy greens were freshly harvested and inoculated with a five-isolate mixture of E. coli O157:H7 at 10 CFU/25 g of sample, and cultures were enriched following the specified protocol. The PCR method was most consistent for identifying the presence of the inoculated pathogen in the shortest period of time. For the red-pigmented leafy vegetables red butter lettuce, curly endive, red lettuce, and lollo rosa, 13, 38, 88, and 100% false-negative results, respectively, were obtained with the immunoassays, but PCR detection was minimally affected. Immunoassays were negatively affected by delays in achieving critical threshold populations during the allowed enrichment period. Leafy green type, temperature abuse, and preharvest environment were unlikely to affect the results of PCR-based kits. Findings strongly suggest that product testing systems using 8-h detection cutoffs may give false-negative results. These issues become very important in high-throughput testing and retest protocols for presumptive pathogen-positive lots of produce.