Development and characterization of solid dispersion for dissolution improvement of furosemide by cogrinding method

Development and Characterization of an Amorphous Solid Dispersion of Furosemide in the Form of a Sublingual Bioadhesive Film to Enhance Bioavailability

Administered by an oral route, Furosemide (FUR), a diuretic used in several edematous states and hypertension, presents bioavailability problems, reported as a consequence of an erratic gastrointestinal absorption due to various existing polymorphic forms and low and pH-dependent solubility. A mucoadhesive sublingual fast-dissolving FUR based film has been developed and evaluated in order to optimize the bioavailability of FUR by increasing solubility and guaranteeing a good dissolution reproducibility. The Differential Scanning Calorimetry (DSC) analyses confirmed that the film prepared using the solvent casting method entrapped FUR in the amorphous state. As a solid dispersion, FUR increases its solubility up to 28.36 mg/mL. Drug content, thickness, and weight uniformity of film were also evaluated. The measured Young's Modulus, yield strength, and relative elongation of break percentage (EB%) allowed for the classification of the drug-loaded film as an elastomer. Mucoadhesive strength tests showed that the force to detach film from mucosa grew exponentially with increasing contact time up to 7667 N/m². FUR was quickly discharged from the film following a trend well fitted with the Weibull kinetic model. When applied on sublingual mucosa, the new formulation produced a massive drug flux in the systemic compartment. Overall, the proposed sublingual film enhances drug solubility and absorption, allowing for the prediction of a rapid onset of action and reproducible bioavailability in its clinical application.

Characterization and Bioavailability of Wogonin by Different Administration Routes in Beagles

Background

With the gradually accumulating research on pharmacological activity of wogonin, the in vitro analysis research on wogonin has become more and more popular, but there are very few reports about in vivo detection, and there are no solid dispersions (SDs) of Wogonin. The aim of this study was to explore the formation of solid dispersions (SDs) of wogonin. The reasons for the low bioavailability were studied through different routes of administration.

Material/Methods

SDs was formulated using the solvent evaporation method via polyvinylpyrrolidone K30 (PVP). The characterization of the drug and its carrier was detected by X-ray diffraction (XRD) and differential scanning calorimetry (DSC). The serum concentrations of Wogonin were detected using the LC-MS/MS method. Six beagles were fed 3 different formulations of wogonin in 3 cycles.

Results

The SDs of wogonin had a higher solubility than the physical mixtures. Based on XRD and DSC, wogonin was transformed from a crystalline morphology to an amorphous structure. The main pharmacokinetic parameters of i.g. administration (crude material and SD) and i.v. route were as follows: C_max (2.5±1.1), (7.9±3.3), and (6838.7±1322.1) μg/L, t_max (0.7±0.3) and (0.3±0.2) h for the former, AUC_0-t (7.1±2.0), (21.0±3.2) and (629.7±111.8) μg·h/L. The absolute bioavailability of native wogonin and wogonin arginine solution were (0.59±0.35)% and (3.65±2.60)%. Further research showed that the low bioavailability of wogonin might be associated with low solubility and rapid combination with glucuronic acid in vivo.

Conclusions

The significantly increased solubility of SDs and the further preparation of arginine solution could significantly increase the bioavailability of wogonin.