Dose-dependent effects of a microbial phytase on phosphorus digestibility of common feedstuffs in pigs

Evaluation of the responses of broiler chickens to varying concentrations of phytate phosphorus and phytase. Ⅱ. Grower phase (day 12-23 post hatching)

A randomized complete block design study used 768 male broiler chickens to investigate the effects of phytate P (PP) and a novel consensus bacterial phytase variant (PhyG) concentration on growth performance, bone mineralization, apparent ileal digestibility (AID), and total tract retention (TTR) of nutrients in broiler chickens. Treatments were arranged in a 1 + 3 × 5 factorial with a nutrient-adequate positive control diet (PC) with 2.8 g PP/kg, 3 nutrient-reduced negative control diets (NC: PC minus 88 kcal/kg ME, 0.8 g/kg dig. Lys, 2.0 g/kg available P, 2.0 g/kg Ca and 0.5 g/kg Na) with varying PP (g/kg) levels, mainly from rice bran, at 2.3 (NC1), 2.8 (NC2), or 3.3 (NC3) and 5 PhyG doses at 0, 500, 1,000, 2,000, or 4,000 FTU/kg. All treatments had 6 replicate cages with 8 birds/cage. A commercial starter diet was fed from d 0 to 12 and the experimental diets from d 12 to 23 post hatching. Birds fed the NC2 diet without phytase had lower (P < 0.01) BW, BW gain, and feed intake (FI) as compared with birds fed the PC with the same PP level. With increasing phytate, there was a decrease (P < 0.05) in BW, BW gain, and FI. Phytase increased (P < 0.01) BW and feed efficiency of broiler chickens. An interaction (P < 0.05) between PP and phytase concentrations was observed on the AID of Met, Cys, and Thr. Linear decrease (P < 0.01) in the AID and TTR of P and Ca with increasing PP concentrations were observed. Phytase supplementation increased (P ≤ 0.05) the AID of P, Ca, and all AA. The TTR of P, Ca, and Zn was linearly increased (P < 0.01) by 112, 123, and 46%, respectively, when birds fed NC diets with 0 and 4,000 FTU/kg were compared. In conclusion, phytate reduced the growth performance and nutrient utilization of broiler chickens from d 12 to 23 post hatching while phytase ameliorated these negative effects.

Evaluation of the responses of broiler chickens to varying concentrations of phytate phosphorus and phytase. Ⅰ. Starter phase (day 1-11 post hatching)

Growth performance, tibia ash, apparent ileal digestibility (AID), and total tract retention (TTR) of nutrients responses of broiler chickens fed diets containing varying concentrations of phytate P (PP) and a novel consensus bacterial 6-phytase variant (PhyG) from d 1 to 11 post hatching were evaluated with 1,152 broiler chicks. Diets were a nutrient-adequate positive control diet (PC) with 2.8 g PP/kg or one of 15 nutrient-reduced negative control (NC: PC minus 88 kcal/kg ME, 0.8 g/kg dig. Lys, 2.0 g/kg available P, 1.8 g/kg Ca and 0.5 g/kg Na) diets with 3 PP (g/kg) levels, mainly from rice bran, at 2.3 (NC1), 2.8 (NC2), or 3.3 (NC3) and 5 PhyG supplementation at 0, 500, 1,000, 2,000, or 4,000 FTU/kg in a 1 + 3 × 5 factorial. All treatments had 6 replicate cages with 12 birds per cage. Despite comparable PP levels, birds fed the PC diet had greater (P ≤ 0.01) body weight (BW), feed intake (FI), tibia ash, AID of energy, AA, P, and Ca as compared with birds fed the NC2 without phytase. There was no interaction between PP and phytase for all responses. Increasing PP concentrations linearly decreased (P < 0.01) BW, FI, AID, and TTR of P and Ca. With phytase supplementation, there was a quadratic response (P < 0.05) in BW, FI, tibia ash, and a linear increase (P < 0.05) in the AID of energy, nitrogen, and all the measured AA. Increasing phytase dose from 0 to 4,000 FTU/kg increased (P < 0.01) AID of P and Ca by 88 and 18%, respectively. There was also a quadratic response (P ≤ 0.05) on TTR of P and Ca with increasing phytase dose. In conclusion, increasing levels of PP reduced growth performance and most nutrient utilization responses of broiler chickens while phytase supplementation positively impacted the responses of broiler chickens during d 1 to 11 post hatching.

Effects of a novel E. coli phytase expressed in Pseudomonas fluorescens on growth, bone mineralization, and nutrient digestibility in pigs fed corn-soybean meal diets

Two studies were conducted to determine the effects of a novel Escherichia coli phytase expressed in Pseudomonas fluorescens on growth performance, bone mineralization, and nutrient digestibility in pigs fed corn-soybean meal diets. In experiment 1, 160 nursery pigs (9.79 ± 1.22 kg) were randomly allotted to one of four treatments with 10 pens per treatment and four pigs per pen. Phase I and phase II diets were provided from d 0 to d 14 and d 14 to d 28, respectively. Treatments included: positive control (PC) with all nutrients meeting requirements; negative control (NC) with standardized total tract digestible (STTD) P reduced by 0.15% and 0.14% compared with PC in phase I and phase II, respectively; and NC diets containing 250 or 500 units of phytase (FTU) per kilogram. Results demonstrated that pigs fed PC had greater (P < 0.01) ADG and G:F for the overall experimental period, and greater (P < 0.01) bone ash and P concentrations, compared with pigs fed NC or diets with phytase supplementation. Pigs fed diets containing phytase had greater (P < 0.01) ADG and G:F for the overall experimental period compared with pigs fed the NC diet without phytase, and bone ash and P weights were increased (P < 0.01) as well. In experiment 2, 63 growing barrows (56.25 ± 2.54 kg) were blocked by BW and randomly allotted to one of seven treatments with nine pens per treatment and one pig per pen. A basal corn–soybean meal diet was formulated to meet nutrient requirements for growing pigs with the exception that STTD P was reduced by 0.18% compared with the requirement, and Ca was included to achieve a Ca:STTD P ratio of 2.15. Six additional diets were formulated by adding 250, 500, 750, 1,000, 1,500, or 2,000 FTU/kg of phytase to the basal diet. Pigs were fed experimental diets for 12 d with 7 d of adaptation and 5 d of fecal sample collection. Results indicated that there was a linear (P < 0.01) increase in apparent total tract digestibility of ash and ether extract, and STTD of Ca and P also increased (linear, P < 0.05) in response to increasing doses of phytase. Increasing phytase levels in the diets resulted in increase (quadratic, P < 0.05) in apparent ileal digestibility of Arg, His, Ile, Lys, Trp, Asp, and Glu. In conclusion, the novel E. coli phytase was effective in increasing growth performance, bone mineralization, and Ca and P digestibility in pigs fed corn–soybean meal-based diets. Results also indicated that this phytase had the potential to enhance the digestibility of fat and certain AA.

Nutritional evaluation of different varieties of sorghum and the effects on nursery pig growth performance

Five experiments were conducted to determine the standardized total tract digestibility (STTD) of P, digestible energy (DE), metabolizable energy (ME), and standardized ileal digestibility (SID) of amino acids (AA) in three sorghum varieties compared with corn and to determine the effects of sorghum varieties on nursery pig growth. In exp. 1, 48 barrows (initially 18.6 kg) were housed individually in metabolism crates. Treatments were arranged in a 2 × 4 factorial evaluating two levels of microbial phytase (0 or 500 units/kg) and four grain sources (corn, high-lysine, red, or white sorghum). Added phytase improved (P < 0.05) STTD of P in all ingredients, but was not different among the grains. In exp. 2, the DE and ME in the three sorghum varieties were not different from corn. In exp. 3, 10 growing barrows (initially 25.9 kg) with a T-cannula in the terminal ileum were used. Standardized ileal digestible Lys, Met, Thr, and Val were greater (P < 0.05) in corn than in the sorghum-based diets with no differences among the sorghum varieties. In exp. 4, 160 pigs (initially 6.3 kg) were randomly allotted to one of four dietary treatments with five pigs per pen and eight replicate pens per treatment in a 20-d experiment. Dietary treatments included corn or the three sorghum varieties, where the varieties of sorghum replaced corn on an SID Lys basis. No differences among treatments were observed in any growth performance parameters. In exp. 5, treatments consisted of a corn-based diet, a diet based on conventional sorghum (a mixture of red and white sorghum), and four diets with high-lysine sorghum containing increasing amounts of feed-grade AA, replacing soybean meal. Overall, pigs fed the high-lysine sorghum diet with the greatest amount of added feed-grade AA had the poorest gain:feed ratio (G:F; P < 0.05) compared with pigs fed all the other experimental diets. Within those fed the high-lysine sorghum and feed-grade AA, average daily gain, final body weight (linear, P < 0.10), and G:F (linear, P < 0.01) decreased as feed-grade AA increased. In summary, no differences in STTD of P or in DE and ME were observed among the grain sources. The SID AA values for the three sorghum varieties were not different; however, they were all lower than for corn. These results indicate that these varieties of sorghum can successfully replace corn in nursery pig diets if diets are formulated to account for differences in AA digestibility.

Effect of microbial phytase supplementation on P digestibility in pigs: a meta-analysis

The objectives of this meta-analysis were to determine to which extent phosphorus (P) digestibility and digestible P concentration in pig diets were increased by phytase supplementation and to quantify factors that potentially influence effects of phytase supplementation. A data set with a total of 547 data lines was compiled from 88 experiments published in 74 peer-reviewed papers between 2007 and April 2019. An exponential model was determined as more suitable to describe the response of P digestibility to phytase supplementation than a polynomial model. Phytase supplementation increased P digestibility by 25.6 percentage points (standard error (SE) = 1.54) to a plateau at 64.9% (SE = 1.82). The digestible P concentration was increased by phytase supplementation in the order of 1.01 g/kg (SE = 0.102) to a plateau at 2.62 g/kg (SE = 0.122). Goodness-of-fit criteria were R² = 0.780 and root mean square error = 7.55% for P digestibility, and R² = 0.691 and root mean square error = 0.48 g/kg for digestible P concentration. Consideration of further factors such as mineral P supplementation (yes or no), ad libitum vs. restrictive feeding, mixed diets vs. single feed ingredients, sex and age of pigs did not increase the accuracy of prediction in this data set. Some of these traits exhibited responses, but they likely are artefacts generated through the imbalanced structure of the data set. Effects of dietary total P, phytate (InsP₆), InsP₆-P to total P ratio, and Ca on the effect of supplemented phytase were not quantifiable. The present meta-analysis showed that responses to phytase supplementation can be well predicted although variation in P digestibility and digestible P concentration in the data set was high. Overall, predicted effects of phytase on P digestibility well corresponded to predictions made 25 years ago.

Growth performance, gastrointestinal weight, microbial metabolites and apparent retention of components in broiler chickens fed up to 11% rice bran in a corn-soybean meal diet without or with a multi-enzyme supplement

We investigated the effects of adding up to 11% rice bran (RB) in corn-soybean meal diets fed to broiler chickens without or with a multi-enzyme supplement (MES). The MES supplied xylanase, β-glucanase, invertase, protease, cellulase, α-amylase and mannanase with targeted activity of 2,500, 300, 700, 10,000, 1,200, 24,000, and 20 U/kg of feed, respectively. The study used a two-phase feeding program (starter, d 0 to 24; finisher, d 25 to 35) with RB added at 5% and 11%, respectively creating 4 diets in each phase. Diets were iso-caloric and iso-nitrogenous and contained phytase (500 FTU/kg) and TiO₂ as a digestibility marker. Three hundred and sixty d-old male Ross 708 broiler chicks were placed in cages based on BW (15 birds/cage) and allocated to 4 diets (n = 6). Birds had free access to feed and water. Body weight and feed intake were recorded. Excreta samples were collected 3 d prior to the end of each phase for apparent retention (AR) of components. Samples of birds were sacrificed on d 24 and 35 for gut weight and ceca digesta for organic acid content. There was no interaction (P > 0.10) between RB and MES on BWG and FCR in starter or finisher phase. In finisher phase, birds fed MES had better BWG (961 versus 858 g) and FCR (1.69 versus 1.86) than birds fed non-MES diets (P < 0.01). Feeding RB reduced (P = 0.02) BWG in finisher phase resulting in lower d 35 BW. Birds fed RB had higher (P ≤ 0.01) gizzard weight on d 24 and 35 than non-RB birds. An interaction (P ≤ 0.01) between RB and MES on concentrations of propionic and iso-butyric acids in ceca digesta showed that MES reduced these acids in non-RB diet. The AR of gross energy was higher (P < 0.02) for MES versus non-MES birds in starter and finisher phases. In conclusion, independently, RB increased gizzard weight and reduced final BW whereas MES improved growth and energy utilization.