Influence of Egg Shell Embryonic Incubation Temperature and Broiler Breeder Flock Age on Posthatch Growth Performance and Carcass Characteristics

Pathogeny of Fatigued Walking Condition in Pekin Ducks

Fatigued walking condition (FWC) in ducks is an important welfare and processing issue during the loading/unloading to the processing plant that can be related to heart and bone development. An experiment was conducted to evaluate the effects of incubation conditions on duck embryo bone and heart development and their subsequent effects on ducks showing FWC at market age. Four groups of 2500 Pekin duck eggs were subjected to combinations of two incubation temperature profiles (elevated [E] and normal [N]) and two eggshell conductance profiles (G) (reduced [GR] and normal [GN]). At hatch 10 ducklings from each treatment combination were sampled for heart, liver, residual yolk, and total body weight as well as relative weights (organ percentage of whole body weight). Femur, tibia, and tarsus length and weight were also obtained, and relative asymmetry (RA) was calculated for each leg section. At 35 days of age during unloading of the truck at the slaughter plant, five hens and five drakes demonstrating normal walking and FWC were sampled. Body, heart, and ventricular weights were obtained along with femur, tibia and tarsus length, weight, and RA. Bone strength was evaluated using a three-point bending test, and tibia ash content was assessed. At hatch duckling bone characteristics and organ weights were found to be primarily affected by GR conditions, while heart development in older ducks was mainly impacted by E incubation temperatures. Tibia and relative weight at 35 days were also increased by GR and E. Fatigued ducks presented heavier tibias with more RA and cortical thickness but lower ash percentage. In conclusion, the changes in bone development during incubation and posthatch life were related to duck FWC presence during transportation to the processing plant.

Temperature during the last week of incubation. II. Effects on first week broiler development and performance

Little is known about applying various eggshell temperatures (EST) during the last week of incubation. In particular, the effect of an EST below 37.8°C during the last week of incubation is poorly investigated. Therefore, we investigated effects of EST of 35.6, 36.7, 37.8, or 38.9°C applied from d of incubation (E) 15, E17, or E19 on first week broiler development and performance. A total of 2,850 first grade eggs of a 43 wk old Ross 308 broiler breeder flock were incubated at an EST of 37.8°C until E15. From E15, E17, or E19 onward, eggs were incubated at an EST of 35.6, 36.7, 37.8, or 38.9°C. Chick quality was determined at placement in the broiler house and organ development was measured at d 7. BW was determined at placement, d4, and d7. Feed intake (FI) was measured at d4 and d7 and G:F was calculated between placement and d4, and between d4 and d7. Chick quality at placement was higher at an EST of 35.6°C compared to all other EST treatments, expressed by a longer chick length and highest prevalence of closed navels. BW d 7 was higher at an EST of 36.7°C compared to all other EST treatments, which was not caused by a higher FI during the first week. A higher G:F between d 0 and d 7 was found at an EST of 36.7°C compared to 35.6 and 38.9°C. At d 7, a higher relative heart weight was found at an EST of 35.6 compared to 38.9°C. This study indicates that an EST of 38.9°C applied from E15 onward negatively affected chick quality, organ development, and G:F until d 7 compared to 37.8°C. Moreover, an EST of 36.7°C had a clear positive effect on chick quality, organ development, G:F, and growth performance until d 7. An EST of 35.6°C resulted in equal or higher chick quality and organ weights compared to 36.7°C, but this was not reflected in performance parameters.

Relationships of eggshell, air cell, and cloacal temperatures of embryonated broiler hatching eggs during incubation

The relationships of eggshell, air cell, and embryo cloacal temperatures in Ross × Ross 708 broiler hatching eggs were determined. Twenty eggs were weighed and set on each of 3 tray levels of a single incubator. Eggshell temperature (EST) of the eggs were recorded once in the morning (AM) and afternoon (PM) between 0 and 19 d of incubation (DOI) using an infrared thermometer (IRT). All eggs were candled and a transponder was implanted in the air cell of eggs containing live embryos (12 per tray level) at 12 DOI. At 19 DOI, transponders were implanted in the cloaca of live embryos from those same eggs. Air cell temperature (ACT) and EST readings were recorded once in the AM and PM between 12 and 19 DOI, and ACT and cloaca temperature (CLT) readings were recorded every 6 h between 19 and 21 DOI. The EST and ACT readings between 13 and 19 DOI were positively correlated. However, their respective mean temperatures between 13 and 19 DOI differed. The EST and ACT were not significantly influenced by tray level. Nevertheless, a main effect due to location (eggshell vs. air cell), and an interaction between DOI and time of day (AM and PM) in the 13 to 19 DOI interval were observed. Furthermore, an interaction was observed between location (air cell and cloaca) and the 6 h sequential time periods in the 19 to 21 DOI interval. However, across the entire 19 to 21 DOI interval, mean ACT and CLT were not significantly different, and were positively correlated. These data suggest that ACT readings are higher than those of EST during the last half of incubation, and that between 13 and 19 DOI, ACT readings may have the potential for use as a minimally invasive method by which to more accurately estimate the true core body temperature of broiler embryos. The effects of this method on hatchability and post-hatch performance need determination to better establish its practicality.

Immediate and long-term transcriptional response of hind muscle tissue to transient variation of incubation temperature in broilers

Background

In oviparous species accidental variation of incubation temperatures may occur under natural conditions and mechanisms may have evolved by natural selection that facilitate coping with these stressors. However, under controlled artificial incubation modification of egg incubation temperature has been shown to have a wide-ranging impact on post-hatch development in several poultry species. Because developmental changes initiated in-ovo can affect poultry production, understanding the molecular routes and epigenetic alterations induced by incubation temperature differences may allow targeted modification of phenotypes.

Results

In order to identify molecular pathways responsive to variable incubation temperature, broiler eggs were incubated at a lower or higher temperature (36.8 °C, 38.8 °C) relative to control (37.8 °C) over two developmental intervals, embryonic days (E) 7–10 and 10–13. Global gene expression of M. gastrocnemius was assayed at E10, E13, and slaughter age [post-hatch day (D) 35] (6 groups; 3 time points; 8 animals each) by microarray analysis and treated samples were compared to controls within each time point. Transcript abundance differed for between 113 and 738 genes, depending on treatment group, compared to the respective control. In particular, higher incubation temperature during E7-10 immediately affected pathways involved in energy and lipid metabolism, cell signaling, and muscle development more so than did other conditions. But lower incubation temperature during E10-13 affected pathways related to cellular function and growth, and development of organ, tissue, and muscle as well as nutrient metabolism pathways at D35.

Conclusion

Shifts in incubation temperature provoke specific immediate and long-term transcriptional responses. Further, the transcriptional response to lower incubation temperature, which did not affect the phenotypes, mediates compensatory effects reflecting adaptability. In contrast, higher incubation temperature triggers gene expression and has long-term effects on the phenotype, reflecting considerable phenotypic plasticity.

Electronic supplementary material

The online version of this article (doi:10.1186/s12864-016-2671-9) contains supplementary material, which is available to authorized users.

Effect of post-hatch transportation duration and parental age on broiler chicken quality, welfare, and productivity

Broiler chicks are transported to production sites within one to 2 d post-hatch. Possible effects of this transportation are poorly understood and could vary among chicks from breeder flocks of different ages. The aim of the present study was to investigate the effects of transportation duration and parental flock age on chick welfare, productivity, and quality. After hatch in a commercial hatchery, 1,620 mixed-sex chicks from 29-wk old (young) and 1,620 chicks from 60-wk old (old) breeders were subjected to transportation of 1.5 h or 11 h duration. After transportation, 2,800 chicks were divided among 100 pens, with each pen containing 28 chicks from one transportation crate (2 or 3 pens per crate). From the remaining chicks, on average 6 chicks (min 4, max 8) per crate (n = 228) were randomly selected and assessed for chick quality, weighed, and culled for yolk sac weighing (one d). Chicks that had not been assigned to pens or were not used for post-transportation measurements, were removed from the experiment (n = 212). Mortality, ADG, BW, and feed conversion ( FC: ) of the experimental chicks were recorded until 41 d. Meat quality was measured for breast fillets (n = 47). No interaction effect of parental age and transportation duration was found for any variables. BW and yolk sac weight at one d were lower for chicks transported 11 h than 1.5 h and for chicks from young versus old breeders. The effect of parental flock age on BW persisted until slaughter. Additionally, parental age positively affected ADG until slaughter. Chick quality was lower in chicks from old versus young breeders. Chick quality and productivity were not affected by transportation duration. Mortality and meat quality were not affected by either parental age or transportation duration. To conclude, no long-term detrimental effects were found from long post-hatch transportation in chicks from young or old parent flocks. Based on these results, we suggest that 11 h post-hatch transportations under similar conditions do not impose long-term welfare or productivity risks.

Mild heat stress enhances differentiation and proliferation of Japanese quail myoblasts and enhances slow muscle fiber characteristics

The objective of this study was to investigate the effect of mild heat stress on muscle fiber hyperplastic and hypertrophic growth in quail primary myogenic cells to better understand the mechanisms leading to increased skeletal muscle development in avian embryos incubated at a higher temperature. Compared to control cultures maintained at 37°C, incubation at 39°C enhanced myotube length (P < 0.01) and diameter (P < 0.001) at 3 days after differentiation (D3). This enlargement of the myotubes incubated at 39°C can be explained by differences in the fusion index (56.7 vs. 46.2%, P < 0.05) and nuclei number per myotube (18.1 vs. 10.8, P < 0.001) compared to the control cells at D3. Additionally, a higher density of myotubes at D3 in cultures exposed to a higher temperature were related to higher levels of Pax-7 (P < 0.05) compared to the control cells incubated continuously at 37°C. These results indicated a higher proliferative capacity in cells exposed to mild heat stress compared to the control cells. On the other hand, mild heat stress enhanced protein levels of slow myosin heavy chain isoform (P < 0.01) and cytochrome c oxidase subunit IV (P < 0.01) compared to the control cells at D3. These discrepancies in protein expression indicated maintenance of slow muscle fiber type characteristics in myotubes incubated at 39°C. Our results suggest that mild heat stress plays a significant role in myogenic mechanisms related to muscle mass and development.

Thermal emissivity of avian eggshells

The hypothesis has been tested that evolution has resulted in lower thermal emissivity of eggs of birds breeding openly in cold climates than of eggs of birds that nest under protective covering or in warmer climates. Directional thermal emissivity has been estimated from directional-hemispherical reflectance spectra. Due to several methodological difficulties the absolute emissivity is not accurately determined, but differences between species are obvious. Most notably, small waders of the genus Calidris, breeding in cold climates on the tundra, and in most cases with uniparental nest attendance, have low directional emissivity of their eggshells, about 0.92 when integration is carried out for wavelengths up to 16μm. Species belonging to Galloanserinae have the highest directional emissivity, about 0.96, of their eggs. No differences due to climate or breeding conditions were found within this group. Eggs of most other birds tested possess intermediate emissivity, but the values for Pica pica and Corvus corone cornix are as low as for Calidris. Large species-dependent differences in spectral reflectance were found at specific wavelengths. For instance, at 4.259μm the directional-hemispherical reflectance for galliforms range from 0.05 to 0.09, while for Fratercula arctica and Fulmarus glacialis it is about 0.3. The reflection peaks at 6.5 and 11.3μm due to calcite are differentially attenuated in different species. In conclusion, the hypothesis that evolution has resulted in lower thermal emissivity of bird eggs being exposed in cold climates is not supported by our results. The emissivity is not clearly related to nesting habits or climate, and it is unlikely that the small differences observed are ecologically important. The spectral differences between eggs that nevertheless exist should be taken into account when using infrared thermometers for estimating the surface temperature of avian eggs.

Effects of thermal manipulations during embryogenesis of broiler chickens on developmental stability, hatchability and chick quality

Stress based on high temperature and humidity reduces the production performance of fast-growing broilers and causes high mortality. Temperatures higher than optimum have been applied to broilers in the embryonic period in order to overcome thermal stress. This study was conducted to investigate the effects of exposure to two long-term high-thermal environments on the developmental stability of embryonic growth, hatchability and chick quality. For this purpose, 600 broiler eggs were incubated. Treatments consisted of eggs incubated at 37.8°C at 55% relative humidity throughout (control), heated to 39.6°C at 60% relative humidity for 6 h daily from 0 to 8th day, and heated to 39.6°C at 60% relative humidity for 6 h daily from the 10 to 18th day. Embryo weights and lengths of face, wing, femur, tibia and metatarsus were measured daily between the 10th and 21st day of the experiment. Daily relative asymmetry values of bilateral traits were estimated. The hatchability, the weight of the 1-day-old chicks and chick quality were determined. In conclusion, no negative effects of the treatments of the long-term high-thermal environment in the early and late stages of incubation for epigenetic adaptation were determined on the embryo morphology, development stability and weight of the chick. Moreover, regressed hatchability of embryos that were exposed to a long-term high-thermal environment was detected. Especially between the 10 and 18th day, the thermal manipulation considerably reduced the quality of the chicks. Acclimation treatments of high temperature on the eggs from cross-breeding flocks should not be made long term; instead, short-term treatments should be made by determining the stage that generates epigenetic adaptation.

Can feeding the broiler breeder improve chick quality and offspring performance?

The impact of nutrition on the performance of broiler breeders in terms of bodyweight profile, egg production, egg size and shell quality, mortality, fertility and hatchability has been well documented. However, studies on the direct effects of breeder nutrition on subsequent chick quality and offspring performance are limited. The present paper reviews the nutritional factors in broiler breeders that may improve chick quality and progeny performance. Recent research has suggested that the feeding of low crude protein and medium to high energy breeder diets in both rearing and laying period will not only have a positive impact on egg production, egg size, breeder fertility, hatchability and embryonic livability, but also on offspring performance. Improvements include better chick quality, higher chick weight, lower mortality, increased immune responses, enhanced litter quality and broiler growth. Breast-meat yield in the progeny can be improved as the energy to protein ratio increases from the rearing phase to the laying phase, indicating that nutrition of pullets can also affect growth and yields. The effects of maternal diet on offspring performance may depend on the sex of the progeny, with male broilers responding more than female broilers to breeders’ dietary protein and energy concentrations. However, little work has been conducted on the effects of individual amino acids in breeder diets on the subsequent generation. There seems to be some benefits with the use of long-chain poly-unsaturated fats in breeder diets on carcass quality of offspring, but these effects appear inconsistent at this stage. There is substantial evidence that confirms the direct effects of vitamin D and E, and trace minerals, especially in organic form, such as selenium, zinc and manganese, on chick quality and progeny performance. In fact, the impact of breeder nutrition on progeny performance in the field is more likely to be greater under conditions of poor breeder-flock uniformity, low vitamin and trace mineral contents or certain types of stress in the broiler house.

Effects of maternal dietary EPA and DHA supplementation and breeder age on embryonic and post-hatch performance of broiler offspring: age and n-3 pufa affect embryonic and post-hatch performance

Breeder age and nutrition are amongst the most important factors affecting progeny growth and development. The present experiment was carried out to evaluate the effects of n-3 fatty acid (FA), with special emphasis on the ratio of eicosapentaenoic (EPA, 20:5 n-3) and docosahexaenoic (DHA, 22:6 n-3) acid, provided to the diet of ageing broiler breeder hens at different ratios, on the incubation parameters and the performance of the offspring. Four hundred and eighty Ross-308 broiler breeder hens were fed one of four different diets (120/treatment), with an equal fat content. The control diet was a basal diet, rich in n-6 FAs (CON). Blends of fish oil were used to enrich the three other diets in n-3 FA and to obtain different EPA/DHA ratios of 1/1 (EPA=DHA), 1/2 (DHA) or 2/1 (EPA). Every 5 weeks, incubation parameters were assessed. Every 15 weeks, offspring was reared until slaughter age on a standard diet. Breeder age affected almost all incubation and post-hatch parameters, whereas n-3 FA treatment only lowered egg weight (p < 0.0001) and consequently hatched chick weight (p < 0.0001). Supplementation of EPA resulted in a higher proportional liver weight (p = 0.0219) at hatch, a lower body weight up to 28 days post-hatch (p = 0.0418), a lower daily weight gain (p = 0.0498) and a higher feed conversion ratio (p = 0.0395) during the starter period (p = 0.0498), resulting in a higher overall offspring feed conversion ratio (p = 0.0317) compared to the control diet. DHA supplementation, on the other hand, resulted in a lower residual yolk weight (p = 0.0220) and a higher overall offspring mortality (p = 0.0125). In conclusion, supplementation of n-3 FA could not counter the adverse effect of breeder flock age, but did not harm incubation or improve post-hatch performance, either. EPA and DHA affected offspring development differently during early post-hatch life.

Incubation temperature influences trade-off between structural size and energy reserves in mallard hatchlings

The reproductive success of precocial birds depends on investments in clutch formation and incubation. Egg quality strongly affects the phenotypic traits correlated with survival of the hatchling, but parental ability to maintain incubation temperature can also influence hatchling outcomes. The effect of incubation temperature on hatchling phenotype has been widely studied in reptiles but not in birds. The aim of this study was to explore the effects of egg mass and incubation temperature on the incubation period, hatchability, and hatchling phenotype of the mallard (Anas platyrhynchos). Mallard eggs were incubated under six constant incubation temperatures (ranging from 35.0° to 39.0°C). Hatchlings were weighed, and their structural size was measured. Some hatchlings were used for an examination of residual yolk sac mass and basic chemical composition of the yolk-free body. All investigated phenotypic traits except for chemical composition were positively correlated with egg mass. Incubation temperature did not affect hatchling body mass, but increased temperatures led to a decreased yolk-free body mass and structural size of hatchlings and to increased yolk sac mass. Our results suggest that there is a trade-off between the yolk-free body size and energetic reserves in the form of the yolk sac and that this trade-off is modulated by incubation temperature.

Influence of temperature and humidity manipulation on chicken embryonic development

Background

Temperature and relative humidity (RH) are very important factors affecting embryo development, hatchability, and posthatch performance. This study aimed at characterizing embryonic metabolic and behavioural response to a harsh incubation environment generated by manipulations (elevations and drops) in these two key factors. This study was aimed at establishing patterns of metabolic and behavioural response, as well as mortality and the development of malformations, all of which can potentially be used in monitoring incubating operations and diagnosing problems with faulty equipment.

Results

Of all the parameters monitored throughout embryonic development the ones shown to be most affected were: albumen-weight to egg-weight ratio (AR); yolk-weight to egg-weight ratio (YR); embryo-weight to egg-weight ratio (ER); heart rate (HR); voluntary movements per minute (VMM); mortality rates; malformation prevalence and type.

The most significant changes in the evolution of AR and YR throughout incubation involved delay and reduction in the amplitude of the expected drop in albumen and yolk levels, reflecting lower nutrient consumption by the embryo. ER tended to grow more slowly and remain lower than the established normal, especially in embryos challenged with temperature treatments. HR and VMM were considered to be strong indicators of embryonic stress, as all treatments applied resulted in elevated heart rate and decreased embryo movement.

Mortality rates for both temperature-related treatments were higher during the first four days of incubation. Changes in relative humidity have produced less radical effects on mortality. Malformation rates were higher for embryos subjected to high incubation temperatures and were most prominently related to the abdominal wall, head, skull and limbs.

Overall, manipulations in environmental (incubator) temperature during incubation produced more drastic changes in embryo development than humidity-related manipulations, especially where mortality and malformation rates were concerned.

Conclusions

This paper describes changes in embryonic metabolism and behaviour, as well as in mortality and malformation rates, in response to manipulations in environmental temperature and relative humidity. Together with further studies, these patterns may prove helpful in the diagnosis of equipment malfunctions relating to temperature or relative humidity.

A meta-analysis of experiments linking incubation conditions with subsequent leg weakness in broiler chickens

A series of incubation and broiler growth studies were conducted using one strain of broiler chicken (fast feathering dam line) observing incubation effects on femoral bone ash % at hatch and the ability of the bird to remain standing at 6 weeks of age (Latency-To-Lie). Egg shell temperatures during incubation were consistently recorded. Parsimonious models were developed across eight studies using stepwise multiple linear regression of egg shell temperatures over 3-day periods and both bone ash at hatch and Latency-To-Lie. A model for bone ash at hatch explained 70% of the variation in this factor and revealed an association with lower egg shell temperatures during days 4–6 and 13–15 and higher egg shell temperatures during days 16–18 of incubation. Bone ash at hatch and subsequent Latency-To-Lie were positively correlated (r = 0.57, P<0.05). A model described 66% of the variation Latency-To-Lie showing significant association of the interaction of femoral ash at hatch and lower average egg shell temperatures over the first 15 days of incubation. Lower egg shell temperature in the early to mid incubation process (days 1–15) and higher egg shell temperatures at a later stage (days 16–18) will both tend to delay the hatch time of incubating eggs. Incubation profiles that resulted in later hatching chicks produced birds which could remain standing for a longer time at 6 weeks of age. This supports a contention that the effects of incubation observed in many studies may in fact relate more to earlier hatching and longer sojourn of the hatched chick in the final stage incubator. The implication of these outcomes are that the optimum egg shell temperature during incubation for broiler leg strength development may be lower than that regarded as ideal (37.8°C) for maximum hatchability and chick growth.

Effects of breeder feeding restriction programs and incubation temperatures on progeny footpad development

Footpad dermatitis begins early in life, and there is evidence of individual susceptibility. An experiment was conducted to evaluate the carryover effects of breeder feed restriction programs and incubation temperatures (TEM) on progeny footpad development at hatch, and 7 and 22 d. Cobb 500 fast feathering breeders were subjected to 2 dietary feed restriction programs during rearing: skip-a-day (SAD) and every-day feeding (EDF). At 60 wk of age, eggs from each group were collected and incubated according to 2 TEM, standard (S) eggshell temperature (38.1°C) and early-low late-high (LH). This second profile had low (36.9°C) eggshell temperature for the first 3 d, and standard temperature until the last 3 d when eggs were subjected to elevated (38.9°C) eggshell temperature. At hatch, 15 chicks from each treatment combination were sampled to obtain footpads for histological analysis. Seventy-two chicks per treatment were placed in 48 cages (6/cage), and raised to 22 d. At 7 and 22 d, 1 and 2 chickens, respectively, were sampled for footpads. The BW and group feed intake were recorded to obtain BW gain and feed conversion ratio at 7 and 21 d. Histological analysis assessed thickness and total area of stratus corneum (SC), epidermis, and dermis, and total papillae height. Data were analyzed as randomized complete block design in a 2 × 2 factorial arrangement of treatments. There was a negative effect of LH TEM on performance at both ages. An interaction effect on SC area and papillae height was observed at hatch. Additionally, SAD treatment increased thickness and area of footpad dermis. At 7 d, the SC parameters of the SAD progeny were increased. Epidermis thickness was affected by treatment interaction. Furthermore, LH TEM decreased epidermis thickness and dermis area. At 22 d, interaction effects were observed in thickness and area of SC and epidermis. Incubation S TEM increased thickness and area of dermis. It was concluded that breeder feed restriction programs and incubation TEM profiles may have carryover effects on histomorphological traits of footpads.

The effects of different eggshell temperatures on embryonic development, hatchability, chick quality, and first-week broiler performance

The aim of the current study was to determine the effects of different eggshell temperatures (EST) during 10 to 18 d of incubation on embryonic development, hatchability, chick quality, first-week broiler performance. The EST were maintained within the temperature ranges of 33.3 to 36.7, 37.8 to 38.2, and 38.9 to 40.0°C for the low, control, and high EST treatments, respectively. From d 15 to 18, embryo weight and relative embryo weight were found to be similar in the low and high EST groups. Salable chicks and hatchability of total eggs was found to be higher in the control EST group. Between d 10 and 17 of incubation, embryonic mortality in low, control, and high EST groups was determined to be 1.6, 0.8, and 2.0%, respectively. From d 18 to hatch, embryonic mortality and rate of dead and cull chicks were found to be significantly different. Hatching in high EST group was completed 26 h early, although hatching in low EST group was completed 10 h later than the control EST group. On the of hatching day, chick weight and length were found to be 39.5, 41.0, and 42.5 g, and 18.5, 21.4, and 19.1 cm in low, control, and high EST groups, respectively. The highest residual yolk sac weight and relative residual yolk sac weight were observed in high EST group as 7.7 g and 18.7%. Yolk-free chick weight and relative yolk-free chick weight were highest in the control EST group. At 1 wk of age, the BW in low, control, and high EST groups were determined as 131.1, 140.0, and 140.8 g, respectively. No significant difference was found for feed intake and feed conversion among treatments for wk 1. The mortality during the first week did not differ among groups; however, a higher mortality rate was observed numerically in the high EST group. In conclusion, embryo development, incubation parameters, chick quality, and the first week performance are affected by small changes in the EST.

Effect of transportation duration of 1-day-old chicks on postplacement production performances and pododermatitis of broilers up to slaughter age

This experiment studied the effect of transportation duration of 1-d-old chicks on dehydration, mortality, production performance, and pododermatitis during the growout period. Eggs from the same breeder flock (Ross PM3) were collected at 35, 45, and 56 wk of age, for 3 successive identical experiments. In each experiment, newly hatched chicks received 1 of 3 transportation duration treatments from the hatchery before placement in the on-site rearing facility: no transportation corresponding to direct placement in less than 5 min (T00), or 4 (T04) or 10 h (T10) of transportation. The chicks were housed in 35-m(2) pens (650 birds each) and reared until 35 d old. Hematocrit and chick BW were measured on sample chicks before and after transportation. During the growout period, bird weight, feed uptake, and feed conversion ratio were measured weekly until slaughter. Transportation duration affected BW; T00 groups had a significantly higher BW than T04 and T10 transported birds but this effect lasted only until d 21. No clear effect on hematocrit, feed uptake, feed conversion ratio, or mortality was observed for birds transported up to 10 h. The decrease in weight in T10 birds was associated with less severe pododermatitis. Increasing age of the breeder flock was correlated with reduced egg fertility and hatchability, and also with higher quality and BW of hatched chicks. Chicks from older breeders also exhibited reduced mortality during the growout period.

Application of computed tomography to assess the effect of egg yolk ratio on body composition in chickens of different genotype and gender at hatch and during the rearing period

1. Computed tomography was used for the in vivo determination of yolk ratio in 7000 domestic hen eggs, originated from two markedly different genotypes, in order to examine the effect of egg yolk ratio, gender and genotype on the development of hatched chicks. 2. Eggs with extremely low, average and extremely high yolk ratio were chosen for further investigation (n = 350 in each group in both genotypes). After incubating the selected eggs, hatched birds were reared and slaughtered at 11 weeks of age. 3. The yolk ratio of eggs significantly affected the body composition of the chickens at hatching and during rearing to 8-9 weeks of age. 4. Chickens of a genotype selected partly for weight gain had significantly higher live weight from hatching to the end of the rearing period and had better slaughter characteristics than those of the dual purpose TETRA-H genotype. 5. At hatching, only the dry matter content of the body was affected by the gender of the birds. The effect of gender on the live weight and body composition of chickens was evident from the 5th week of age to the time of slaughter. 6. It was concluded that eggs with a low yolk ratio were most beneficial for broiler production, because chickens hatched from these eggs had the highest slaughter weight and muscle index and the lowest fat index for their body mass.

Perinatal broiler physiology between hatching and chick collection in 2 hatching systems

Little is known about physiological responses of early- versus late-hatching chicks to early posthatch conditions in broiler practice. We investigated effects of hatching time on perinatal broiler physiology in 2 hatching systems, differing in conditions: a conventional hatcher, where chicks are deprived of feed and water between hatching and the moment of chick pulling (d E21.5), and a patio system, in which the hatching and brooding phase are combined, and chicks have immediate posthatch feed and water access. Climate conditions in patio also differ with about 3°C lower temperature and 20% lower RH compared with conventional hatchers. At E18, fertile eggs were transferred to either a hatcher or the patio until the end of incubation. From each system, 50 newly hatched chicks were collected at 3 hatching times: at 468 h (early), 483 h (midterm), and 498 h (late) of incubation, of which 25 chicks were decapitated for analyses of physiological parameters. The other 25 chicks were returned to the hatching system for analyses after 515 h of incubation (E21.5). At hatch, weights of the heart, lungs, stomach, and intestine increased with hatching time, concurrent with a decrease in residual yolk weight, regardless of hatching system, and indicating that later hatching chicks are more matured. Weights of the heart, liver, stomach, and intestines were lower in hatcher than in patio chicks. Between hatch and E21.5, residual yolk weight decreased, whereas organ weights increased in both fasted hatcher and fed patio chicks, but at a higher rate in the latter. At E21.5, plasma glucose and triiodothyronine had increased with time after hatch in patio chicks, whereas levels were similar among hatching times and lower in hatcher chicks. Early feed and water access seems to enable early hatching chicks to compensate for their apparent disadvantage in development at hatching, whereas chicks subjected to fasting show metabolic adaptations to preserve nutrients. Chick physiology at chick pulling time was shown to vary with time after hatching and posthatch conditions, especially feed access.

Energy utilization and heat production of embryos from eggs originating from young and old broiler breeder flocks

Two experiments were conducted to study the interaction between breeder age and egg size on the energy utilization (experiment 1) and heat production (experiment 2) of broiler embryos. In experiment 1, a total of 4,800 Ross-308 hatching eggs from 2 breeder ages (29 and 53 wk of age, or young and old) and, within each age, 2 egg sizes (57 to 61 g and 66 to 70 g, or small and large) were used. In experiment 2, a total of 240 Ross-308 hatching eggs from 2 breeder flocks at 29 (young) and 53 (old) wk of age, and which were selected from the same egg weight range (58 to 61 g), were tested in 2 replicate chambers. In experiment 1, it was shown that the amount of yolk relative to albumen was higher in the old flock eggs, and this effect was more pronounced in the large eggs. The old flock eggs, especially the larger egg size, contained more energy as a result of a greater yolk size. Energy utilization of the embryos was positively related to yolk size and the amount of energy transferred to yolk-free body (YFB) was largely determined by the available egg energy. The efficiency of converting egg energy into chick body energy (E(YFB)) was equal for both egg sizes and both breeder age groups. Chick YFB weight of young and old flock eggs was equal. However, dry YFB weight of chicks from old flock eggs was higher than in chicks from young flock eggs, which was associated with more protein and fat content and thus more energy accumulated into YFB. As a consequence, embryos derived from old flock eggs produced more heat from d 16 of incubation onward than those of the young flock eggs. In conclusion, the higher energy deposition into chick YFB of old flock eggs, leading to higher embryonic heat production, is the result of a higher amount of available energy in the egg and is not due to changes in E(YFB).

Early life experiences affect the adaptive capacity of rearing hens during infectious challenges

This study aimed to investigate whether pre- and early postnatal experiences of rearing hens contribute to the ability to cope with infectious challenges at an older age. In a 2 × 2 factorial arrangement, 352 Lohmann Brown chicks were exposed to either suboptimal or optimized incubation plus hatch conditions, and to cage or enriched rearing from week 0 to 7 of age. After week 7 all rearing conditions were similar until the end of the experiment. The development of adaptive capacity to infectious challenges was investigated by introducing an Eimeria and Infectious Bronchitis (IB) infection on day 53 and day 92, respectively. BW gain and feed intake during the infections, duodenal lesions and amount of positive stained CD4+ T cells, CD8+ T cells and macrophages at day 4 and day 7 after Eimeria infection, as well as the IB antibody titer throughout the experimental period were determined. The results showed a significant interaction between incubation plus hatch and rearing environment. Optimized incubation plus hatch conditions followed by an enriched rearing environment resulted in the least weight loss (P < 0.05) and the highest feed intake (P < 0.01) from day 3 to day 7 after the Eimeria infection (day 56 to 60 of age), compared with all other treatments. In addition, the optimized × enriched chicks had the highest BW gain from day 7 to day 14 after IB infection (day 99 to 106 of age), compared with chicks housed in a cage environment (P < 0.01). Besides the interaction, optimized incubation plus hatch alone resulted in reduced macrophage numbers in the duodenal tissue at day 4 after Eimeria infection, compared with suboptimal incubation plus hatch, whereas the enriched rearing environment stimulated the recovery of intestinal damage caused by Eimeria (P < 0.05) and reduced the production of specific antibodies after IB infection (P < 0.05), compared with the cage environment. In conclusion, this study shows that early life experiences can indeed affect the capacity of rearing hens to cope with an Eimeria and IB infection at an older age, in which performance of chicks is best maintained after optimized incubation plus hatch followed by enriched rearing. This suggests that the development of adaptive capacity to infectious challenges can be influenced with management during a short period in pre- or early postnatal life, but that effects last for a considerable time after cessation of the specific management.

Fuzzy modeling to predict chicken egg hatchability in commercial hatchery

Experimental studies have shown that hatching rate depends, among other factors, on the main physical characteristics of the eggs. The physical parameters used in our work were egg weight, eggshell thickness, egg sphericity, and yolk per albumen ratio. The relationships of these parameters in the incubation process were modeled by Fuzzy logic. The rules of the Fuzzy modeling were based on the analysis of the physical characteristics of the hatching eggs and the respective hatching rate using a commercial hatchery by applying a trapezoidal membership function into the modeling process. The implementations were performed in software. Aiming to compare the Fuzzy with a statistical modeling, the same data obtained in the commercial hatchery were analyzed using multiple linear regression. The estimated parameters of multiple linear regressions were based on a backward selection procedure. The results showed that the determination coefficient and the mean square error were higher using the Fuzzy method when compared with the statistical modeling. Furthermore, the predicted hatchability rates by Fuzzy Logic agreed with hatching rates obtained in the commercial hatchery.

Physiological relationships of the early posthatch performance of broilers to their embryo and eggshell characteristics

Relationships between physiological parameters of early posthatch chicks with their corresponding egg and embryo parameters were examined in progeny of young broiler breeders. Four hundred and 80 broiler hatching eggs that were obtained from a 29-wk-old Ross 308 breeder flock were incubated on 8 replicate tray levels of an incubator until hatch. Between 10.5 and 18.5 d of incubation, internal (T(emb)) and external (T(ext)) egg temperatures were recorded twice daily using temperature transponders. Beginning at 18.5 d, the eggs were individually monitored for hatch every 12 h. Average T(emb), T(ext), and average daily incubational egg weight loss (EWL) for the 10.5- to 18.5-d incubation period were used to calculate eggshell water vapor conductance (G(H2O)), specific G(H2O) (g(H2O); G(H2O) adjusted to 100 g of set egg weight basis), and a G(H2O) constant (K(H2O)) for each egg. Chicks were grown out for 10 d in pens of a single battery brooder. In each pen, on d 3 posthatch, carcasses, yolk sac, liver, and pipping muscle samples were collected from at least 2 chicks that hatched from eggs implanted with transponders for determination of their relative weights and moisture concentrations. Livers and pipping muscles were also analyzed for glucose, glycogen, fat, and protein concentrations. Yolk sac weight as a percentage of chick BW (YW) and its moisture concentration (YSM) were positively correlated with T(emb). Egg g(H2O) was positively correlated with chick carcass moisture concentration and its relative weight as a percentage of set egg weight, but it was negatively correlated with YW. The positive functional relationship between T(emb) and incubation length may be mediated via their common positive relationships to YSM. A negative correlation was observed between percentage EWL and relative BW on d 0 and 0.5 posthatch for chicks hatched from unimplanted eggs. The results suggest that a higher g(H2O) results in an increased metabolism of the broiler embryo, which subsequently increases growth and yolk sac absorption in broiler chicks through 3 d posthatch.

Comparative evaluation of air cell and eggshell temperature measurement methodologies used in broiler hatching eggs during late incubation

The current study was conducted to compare and contrast the uses of 2 devices (temperature transponder or infrared thermometer) and their locations (inner air cell membrane or outer eggshell surface) in Ross × Ross 708 broiler hatching eggs. The air cells of 14 embryonated and 10 nonembryonated eggs were implanted with temperature transponders on d 13.5 of incubation. Likewise, for these same eggs, eggshell surface temperature was detected with the use of transponders and an infrared thermometer. Temperatures were recorded every 12 h between 14.5 and 18 d of incubation, and graphs and corresponding regression values were used to track the temperatures over these time periods. The temperature readings using all methods in embryonated and nonembryonated eggs were positively correlated. In nonembryonated eggs, temperatures in the air cell and on the eggshell surface using transponders were higher than those on the eggshell surface using an infrared thermometer. Mean air cell temperature readings of embryonated eggs using transponders were higher than those of the eggshell, as determined with the use of transponders or an infrared thermometer. Furthermore, the differences in air cell temperature using transponders and eggshell temperature using an infrared thermometer in embryonated eggs increased with embryonic age. These readings confirmed increased embryo heat production during the incubational period examined. It was further concluded that when compared with actual embryo body temperatures determined in previous studies, the use of transponders in the air cells of broiler hatching eggs detected a higher and closer temperature than eggshell surface temperature. It is suggested that the air cell transponders in embryonated eggs circumvented the confounding effects of the thermal barrier properties of the eggshell and the flow of air across its surface.

The effects of genotype on embryonic development in eggs from divergent turkey genotypes

Unique turkey genotypes and reciprocal crosses of these lines were used to study the relationship between egg size, posthatch growth potential, and selected aspects of embryonic development. A line of turkeys selected for increased egg production (E), its randombred control line (RBC1), a line selected for increased 16-wk BW (F line), and its randombred control line (RBC2) were the pure lines used in each of 2 experiments. In experiment 1, a sample of E-line hens were mated to either E line (E/E) or RBC1 toms (RBC1/E), and RBC1 hens were mated to RBC1 toms (RBC1/RBC1). Egg weight at set and at 25 d of incubation was significantly lower in the E/E and RBC1/E crosses compared with that of the RBC1/RBC1 eggs. On d 21 and 25 of incubation and at hatch, the yolk-free wet embryo weights of E/E and RBC1/E embryos were similar, and both weighed significantly less than the RBC1/RBC1 embryos (P ≤ 0.001). Similar observations were observed for the residual yolk sac weight at each of those developmental ages. In experiment 2, embryos from the F line, RBC2, RBC1, E, and 2 reciprocal crosses (RBC1/E, E/RBC1) were compared at various time points during the course of incubation. Egg weight was consistently highest in the F line and lowest in the E line and intermediate in the RBC1 and RBC2 lines. Egg weight followed the maternal genotype in the E/RBC1 and RBC1/E reciprocal crosses. On embryonic d 19, 23, and 26, the order of yolk-free weight embryo weights followed closely the pattern observed for egg weight. In summary, egg weight and embryonic development is largely controlled by the maternal genotype. This should be considered when making inference to posthatch selection effects on embryonic development.

Adaptive response to Eimeria acervulina in rearing hens is affected by suboptimal incubation temperature and heat exposure in later life

This study aimed to investigate whether suboptimal incubation (SI) temperature in weeks 1 and 3 of layer embryo incubation affects their development and post-hatch adaptive capacity during infectious challenges, by using Eimeria as a model infection under normal and immediately after more challenging environmental conditions of 72 h heat exposure. Eggs (n = 160 per treatment) were incubated at optimal (OI = 37.8°C continuously) or suboptimal eggshell temperature (36.7°C, 37.8°C and 38.9°C in weeks 1, 2 and 3, respectively). At day 33 of age, half the chickens of each incubation treatment were exposed to 72 h heat (35°C), whereas the other half remained under control conditions (21°C). At day 36 of age, all chickens were inoculated with 1 ml of a phosphate buffer saline solution containing 25 000 sporulated Eimeria acervulina oocysts/ml. The adaptive response to E. acervulina was measured by BW gain and FI from days 0 to 3 post infection (p.i.), days 3 to 5 p.i. and days 5 to 7 p.i., and by oocyst production (days 4 and 7 p.i.) and lesion scores in the duodenum (day 3, 4 and 7 p.i.). Our results demonstrated that SI temperatures in weeks 1 and 3 of incubation resulted in a reduction in yolk-free BW, chick length and navel condition. Moreover, SI temperature appeared to reduce the adaptive capacity to E. acervulina. This was demonstrated by tendencies to lower FI (P = 0.07) and BW gain (P = 0.08), more duodenal lesions (P = 0.09) and higher oocyst production (P = 0.02) after inoculation of E. acervulina. Higher lesion scores and faecal oocyst numbers were especially found when suboptimal incubation was combined with heat exposure preceding the infection. In conclusion, SI layer chickens tend to be less able to cope with an infectious challenge post hatch.

Yolk absorption and embryo development of small and large eggs originating from young and old breeder hens

To evaluate the effect of breeder age and egg size on yolk absorption and embryo development, a total of 4,800 Ross 308 hatching eggs were subjected to 4 treatments arranged in a 2 × 2 factorial randomized complete block design using 2 breeder ages (29 and 53 wk of age, or young and old) and 2 egg sizes (57-61 g and 66-70 g, or small and large). A significant interaction between breeder age and egg size was found for egg composition. Yolk weight increased with flock age, whereas a larger egg size resulted in higher albumen content. A significant interaction between breeder age and egg size was found for yolk-free body (YFB) weight only at d 7. Until the fourteenth day of incubation, eggs from the old flock yielded greater YFB weight than did eggs from the young flock. At hatch, chicks of both age groups had comparable wet YFB weight, chick weight, wet and dry residual yolk weight, and chick length. Dry YFB weight of chicks from the old flock was higher than that of chicks from the young flock. Compared with the small eggs, embryos and chicks of the large eggs had greater YFB weight from d 14 to hatching. At hatch, these chicks were also heavier, longer, and had higher wet and dry YFB and residual yolk weight. Yolk absorption at d 18 and at hatch of embryos and chicks of the old flock was higher than that of the young flock, both in absolute values and percentages. Rates of absolute and percentage yolk absorption through d 18 and percentage yolk absorption at hatch were higher in the small eggs than in the large eggs. It can be concluded that egg size influences chick length at hatch and embryo development when expressed in terms of total and YFB weight. Although yolk availability and rate of absorption may have influenced dry YFB weight, they did not influence hatching chick length or total and YFB weight.

High eggshell temperatures during incubation decrease growth performance and increase the incidence of ascites in broiler chickens

High eggshell temperatures (EST; ≥38.9°C) during the second half of incubation are known to decrease the body and organ development of broiler hatchlings. In particular, relative heart weights are decreased by a high EST, and this may increase the incidence of metabolic disorders that are associated with cardiovascular development, such as ascites. The current study investigated the effects of a high EST on chick quality, subsequent performance, and the incidence of ascites later in life. Eggs were incubated at a normal (37.8°C) or high (38.9°C) EST from d 7 of incubation onward. After hatching, the chickens were housed per EST in pens, and a normal or cold temperature schedule was applied during the grow-out period. Hatchability, hatchling quality, BW, feed conversion ratio, total mortality, mortality associated with ascites, slaughter characteristics, and ascites susceptibility at 6 wk of age were evaluated. Except for total ventricle weight, no interaction was found between EST and the grow-out temperature. Hatchability was comparable between the EST treatments, but the percentage of second-grade chickens was 0.7% higher at the high EST. Yolk-free body mass was 3.0 g lower, and heart weights were 26% lower at hatch in the high compared with the normal EST treatment. Body weight continued to be less during the grow-out period after the high EST incubation. However, breast meat yield was 1.0% higher in the high than in the normal EST. Feed conversion ratio did not differ between EST treatments. Total mortality was 4.1% higher and mortality associated with ascites was 3.8% higher in the high compared with the normal EST treatment. The ratio between the right and total ventricle was 1.1% higher in the high compared with the normal EST treatment at slaughter age. In conclusion, a high EST from d 7 of incubation onward decreased hatchling quality and growth performance, but increased breast meat yield. Furthermore, high EST incubation increased the incidence of ascites, which may be related to the reduced heart development at hatch.

Effect of incubation temperature on nutrient transporters and small intestine morphology of broiler chickens

This study evaluated the effects of elevated incubation temperature on posthatch nutrient transporter gene expression, integrity of the intestinal epithelium, organ development, and performance in Ross 308 broiler chickens. Ross × Ross 308 fertile eggs (n = 900) were incubated at different eggshell temperatures during development. From embryonic day (ED) 1 to ED12, all eggs were incubated at 37.1°C, whereas from ED13 to ED21, the eggs were divided into 2 groups for incubation at 37.4°C (S) or 39.6°C (H). Performance characteristics were measured at day of hatch (DOH) and d 7, 14, 21, 30, and 42. Small intestine and residual yolk sacs were collected at DOH and d 2, 4, 6, and 10 and weighed individually. Intestinal samples from the duodenum, jejunum, and ileum were evaluated for mucosal morphology and relative nutrient transporter gene expression. No significant differences were found in performance or organ weights. The intestinal morphology results showed a temperature × age interaction in duodenum villus height (P = 0.02) and crypt depth (P = 0.05) and in ileum villus height-to-crypt depth ratios (P = 0.02). There was a main effect of temperature, resulting in deeper crypts (P = 0.02) in the jejunum of chicks incubated at H compared with S. In the nutrient gene expression evaluation, peptide transporter (PepT1) showed a temperature × age interaction. On DOH and d 2, 4, and 10, PepT1 expression was similar between chicks incubated at S and H. However, on d 6, chicks incubated at S had significantly higher expression of PepT1 than those incubated at H. This study presents the effects of elevated incubation temperature on small intestine morphology and relative expression of nutrient transporter mRNA in high-yield broiler chicks, which can be important for the availability of nutrients and distribution of energy.

Hatching egg characteristics, chick quality, and broiler performance at 2 breeder flock ages and from 3 egg weights

The objective of this study was to determine the effects of flock age and egg weight on hatching egg characteristics, fertility, hatchability, salable chick production, and broiler performance using a commercial Cobb 500 broiler breeder flock. Hatching eggs from the same breeder flock in 3 weight categories (light, average, and heavy) were obtained from a commercial hatchery when the birds were 29 and 59 wk of age. One group of eggs per age and weight category was selected to assess specific gravity and was broken open to weigh egg components. Another group of eggs was incubated for 21.5 d and incubation parameters were measured. At hatching, all salable chicks were individually weighed and placed in floor pens, where they were grown out for 41 d. Daily mortality, weekly feed consumption, and individual BW at 21 and 41 d were recorded. Irrespective of flock age and egg weight, all eggs had a specific gravity lower than 1.080, the commercial set value. Eggs from the young flock age had a smaller proportion of yolk and a greater proportion of albumen. Age affected fertility, with a lower value observed at 29 wk of age. Chicks from the flock at 59 wk hatched earlier than chicks from the flock at 29 wk, and light eggs hatched earlier than both average and heavy eggs. Broilers from the 29-wk-old breeders had a lower final BW than broilers from the 59-wk-old breeders. The smaller proportion of yolk in eggs from 29-wk-old broiler breeders may be associated with the low final BW observed in their offspring. This could mean that chicks hatching from young broiler breeders, which produce eggs with small yolks, may be at a disadvantage when reared under the same conditions as chicks produced by older broiler breeders whose eggs have larger yolks.

High- and low-temperature manipulation during late incubation: effects on embryonic development, the hatching process, and metabolism in broilers

Temperatures continuously higher and lower than the standard incubation temperature by 3°C from embryonic d 16 until embryonic d 18.5 result in differential effects on embryonic development, the hatching process, and embryonic metabolism. Embryos in the high-temperature group were forced into a state of malnutrition by the temperature treatment, as reflected by reduced embryo growth and yolk consumption, resulting in a significantly lower chick weight at hatch. In addition, altered air cell and blood gases as well as a retarded hatching process further indicated reduced growth of embryos exposed to higher incubation temperatures during the latter part of incubation. In addition, hatchability was significantly reduced by the high-temperature treatment due to higher embryonic mortality during the treatment period and the hatching process. Levels of blood glucose, lactate, liver glycogen, plasma triglycerides, and nonesterified fatty acids indicated an altered carbohydrate and lipid metabolism for the high-temperature group. Although the hatching process of embryos exposed to lower incubation temperatures was also significantly retarded, their embryonic development and growth were strikingly similar to those of the control group.

Computational study of the heat transfer of an avian egg in a tray

The development of an embryo in an avian egg depends largely on its temperature. The embryo temperature is affected by its environment and the heat produced by the egg. In this paper, eggshell temperature and the heat transfer characteristics from one egg in a tray toward its environment are studied by means of computational fluid dynamics (CFD). Computational fluid dynamics simulations have the advantage of providing extensive 3-dimensional information on velocity and eggshell temperature distribution around an egg that otherwise is not possible to obtain by experiments. However, CFD results need to be validated against experimental data. The objectives were (1) to find out whether CFD can successfully simulate eggshell temperature from one egg in a tray by comparing to previously conducted experiments, (2) to visualize air flow and air temperature distribution around the egg in a detailed way, and (3) to perform sensitivity analysis on several variables affecting heat transfer. To this end, a CFD model was validated using 2 sets of temperature measurements yielding an effective model. From these simulations, it can be concluded that CFD can effectively be used to analyze heat transfer characteristics and eggshell temperature distribution around an egg. In addition, air flow and temperature distribution around the egg are visualized. It has been observed that temperature differences up to 2.6 degrees C are possible at high heat production (285 mW) and horizontal low flow rates (0.5 m/s). Sensitivity analysis indicates that average eggshell temperature is mainly affected by the inlet air velocity and temperature, flow direction, and the metabolic heat of the embryo and less by the thermal conductivity and emissivity of the egg and thermal emissivity of the tray.