Enumeration of Salmonella and Escherichia coli O157:H7 in ground beef, cattle carcass, hide and faecal samples using direct plating methods†

Prevalence and characteristics of Salmonella in the beef chain in the Republic of Ireland

The study investigated the prevalence, concentration and characteristics of Salmonella spp. in the Irish beef chain. A total of 900 samples including bovine hides, carcasses and ground beef were examined for the pathogen over a 2-year study (July 2007-June 2009). Salmonella prevalence was low in all sample types; bovine hide (0.75%, 3 of 400); carcasses (0.25%, 1 of 400); and ground beef (3%, 3 of 100). All positive samples contained the pathogen in low concentrations (<10 CFU per cm(2) or per g). Serovars recovered were S. Dublin from hide and carcasses and S. Braenderup in ground beef. All isolates were susceptible to 13 anti-microbials. The study highlights that Salmonella can be found at low levels at all stages of beef chain production, processing and retail and that there is a need for multiple hurdle interventions and practices along the beef chain, which will reduce consumer exposure to this pathogen.

Evaluation of target sequences for the polymerase chain reaction-based detection of Salmonella in artificially contaminated beef

Salmonella is a major cause of foodborne diseases worldwide, which has fueled the demand for the development and evaluation of sensitive, specific, and rapid detection methodologies, such as polymerase chain reaction (PCR). In this study, six primer pairs for the detection of Salmonella were evaluated by PCR with isolates of Salmonella spp. (115) and other bacteria (104). The primers designed for the sifB gene provided the best performance regarding specificity and sensitivity (100%). These primers were selected and used to develop a PCR assay for Salmonella detection during the enrichment steps of the conventional detection method in spiked beef samples. The enrichment steps were: buffered peptone water (BPW), Rappaport-Vassiliadis soya broth (RVS) and at the Müller-Kauffmann tetrathionate novobiocin broth (MKTTn), after 18 h (BPW) and 24 h (RVS and MKTTn) of incubation. The initial concentrations of the Salmonella inocula were 10¹, 10², and 10³ colony-forming units/25 g. The protocol was able to detect Salmonella at all concentrations in the enrichment steps, but not in the nonenriched samples. These results indicated that the proposed protocol was suitable to detect Salmonella in beef during the intermediate stages of the conventional isolation protocol, substantially reducing the time required to obtain the final results.

Fate of naturally occurring Escherichia coli O157:H7 and other zoonotic pathogens during minimally managed bovine feedlot manure composting processes

Reducing Escherichia coli O157:H7 in livestock manures before application to cropland is critical for reducing the risk of foodborne illness associated with produce. Our objective was to determine the fate of naturally occurring E. coli O157:H7 and other pathogens during minimally managed on-farm bovine manure composting processes. Feedlot pen samples were screened to identify E. coli O157:H7-positive manure. Using this manure, four piles of each of three different composting formats were constructed in each of two replicate trials. Composting formats were (i) turned piles of manure plus hay and straw, (ii) static stockpiles of manure, and (iii) static piles of covered manure plus hay and straw. Temperatures in the tops, toes, and centers of the conical piles (ca. 6.0 m(3) each) were monitored. Compost piles that were turned every 2 weeks achieved higher temperatures for longer periods in the tops and centers than did piles that were left static. E. coli O157:H7 was not recovered from top samples of turned piles of manure plus hay and straw at day 28 and beyond, but top samples from static piles were positive for the pathogen up to day 42 (static manure stockpiles) and day 56 (static covered piles of manure plus hay and straw). Salmonella, Campylobacter spp., and Listeria monocytogenes were not found in top or toe samples at the end of the composting period, but E. coli O157:H7 and Listeria spp. were recovered from toe samples at day 84. Our findings indicate that some minimally managed composting processes can reduce E. coli O157:H7 and other pathogens in bovine manure but may be affected by season and/or initial levels of indigenous thermophilic bacteria. Our results also highlight the importance of adequate C:N formulation of initial mixtures for the production of high temperatures and rapid composting, and the need for periodic turning of the piles to increase the likelihood that all parts of the mass are subjected to high temperatures.

Characterization of Escherichia coli O157:H7 strains isolated from supershedding cattle

Previous reports have indicated that a small proportion of cattle shedding high levels of Escherichia coli O157:H7 is the main source for transmission of this organism between animals. Cattle achieving a fecal shedding status of 10(4) CFU of E. coli O157:H7/gram or greater are now referred to as supershedders. The aim of this study was to investigate the contribution of E. coli O157:H7 strain type to supershedding and to determine if supershedding was restricted to a specific set of E. coli O157:H7 strains. Fecal swabs (n = 5,086) were collected from cattle at feedlots or during harvest. Supershedders constituted 2.0% of the bovine population tested. Supershedder isolates were characterized by pulsed-field gel electrophoresis (PFGE), phage typing, lineage-specific polymorphism assay (LSPA), Stx-associated bacteriophage insertion (SBI) site determination, and variant analysis of Shiga toxin, tir, and antiterminator Q genes. Isolates representing 52 unique PFGE patterns, 19 phage types, and 12 SBI clusters were obtained from supershedding cattle, indicating that there is no clustering to E. coli O157:H7 genotypes responsible for supershedding. While being isolated directly from cattle, this strain set tended to have higher frequencies of traits associated with human clinical isolates than previously collected bovine isolates with respect to lineage and tir allele, but not for SBI cluster and Q type. We conclude that no exclusive genotype was identified that was common to all supershedder isolates.

Highly sensitive detection of pathogen Escherichia coli O157:H7 by electrochemical impedance spectroscopy

The presence of enterohemorrhagic Escherichia coli bacteria in food can cause serious foodborne disease outbreaks. Early detection and identification of these pathogens is extremely important for public health and safety. Here we present a highly sensitive label-free immunosensor for the detection of pathogenic E. coli O157:H7. Anti-E. coli antibodies were covalently immobilised onto gold electrodes via a self-assembled monolayer (SAM) of mercaptohexadecanoic acid and the pathogenic bacteria were detected by electrochemical impedance spectroscopy (EIS). Surface Plasmon Resonance (SPR) was used to monitor the antibody immobilisation protocol and antibody patterned surfaces were used to demonstrate the specificity of the antibody coated surfaces against the pathogenic bacteria. The immunosensor showed a very low limit of detection (2CFU/mL) and a large linear range (3 × 10-3 × 10(4)CFU/mL). Finally, the selectivity of the sensor was demonstrated and no significant adsorption of Salmonella typhimurium was observed.

Efficacy of hypobromous acid as a hide-on carcass antimicrobial intervention

Escherichia coli O157:H7 and Salmonella on cattle hides at slaughter are the main source of beef carcass contamination by these foodborne pathogens during processing. Hypobromous acid (HOBr) has been approved for various applications in meat processing, but the efficacy of HOBr as a hide antimicrobial has not been determined. In this study, the antimicrobial properties of HOBr were determined by spraying cattle hides at either of two concentrations, 220 or 500 ppm. Treatment of hides with 220 ppm of HOBr reduced the prevalence of E. coli O157:H7 on hides from 25.3 to 10.1% (P < 0.05) and reduced the prevalence of Salmonella from 28.3 to 7.1% (P < 0.05). Treatment of hides with 500 ppm of HOBr reduced (P < 0.05) the prevalence of E. coli O157:H7 on hides from 21.2 to 10.1% and the prevalence of Salmonella from 33.3 to 8.1%. The application of 220 ppm of HOBr reduced (P < 0.05) aerobic plate counts, total coliform counts, and E. coli counts on hides by 2.2 log CFU/ 100 cm(2). The use of 500 ppm of HOBr resulted in reductions (P < 0.05) of aerobic plate counts, total coliform counts, and E. coli counts by 3.3, 3.7, and 3.8 log CFU/100 cm(2), respectively, demonstrating that the use of higher concentrations of HOBr on hides resulted in additional antimicrobial activity. These results indicate that the adoption of a HOBr hide wash will reduce hide concentrations of spoilage bacteria and pathogen prevalence, resulting in a lower risk of carcass contamination.

Determination of low-density Escherichia coli and Helicobacter pylori suspensions in water

Determination of low-density of bacteria, especially those of pathogenic strains in water, has proven difficult and challenging. Here, we developed and evaluated a lanthanum-based concentration method coupled with quantitative real-time PCR to concentrate and detect selected bacteria (Escherichia coli and Helicobacter pylori) in water. To improve qPCR efficiency, the flocs with enmeshed bacteria after chemical flocculation need to be dissolved before PCR detection. Ethylenediaminetetraacetic acid (EDTA) salt successfully dissolved the flocs from a lanthanum-based flocculation process, but not those from the traditional processes using chemicals such as FeCl(3) or Al(2)(SO(4))(3). Lanthanum-based concentration coupled with real-time PCR successfully determined E. coli at a concentration of 15 cells/mL in raw and finished water and H. pylori at a concentration of about 1 cell/mL in the finished water prior to disinfection. The H. pylori detection sensitivity could be easily increased to 60 cells/L by reducing the final volume of the DNA samples from 3 mL to 60 μL. With the elimination of membrane-clogging problem that is often encountered in direct membrane filtration, the lanthanum-based chemical flocculation coupled with qPCR is a promising method for determination of low-density of microbial suspensions in water.

Microbiological Analysis of Bovine Lymph Nodes for the Detection of Salmonella enterica†

Bovine peripheral lymph nodes (LNs) have been identified as a potential source of Salmonella when trim containing these nodes is incorporated into ground beef. Studies examining the prevalence of Salmonella in peripheral LNs of cattle are few in number, and the microbiological methods used for these analyses have not been validated. Given that Salmonella contamination may be found on postintervention carcasses, it is important to understand the extent to which Salmonella contamination from surrounding adipose tissue is transferred to LN samples during sample preparation. To better understand the potential for cross-contamination, 906 LN samples were collected from postintervention carcasses and these, along with the corresponding adipose trim (AT), were analyzed for the presence of Salmonella. The results showed that the Salmonella prevalence in LNs and on AT was 0.8 and 5%, respectively, but that it was possible to find AT positive for Salmonella contamination while the corresponding LNs were negative and vice versa. In order to examine the dynamics of cross-contamination between surface adipose tissue and LNs in the trimming process, inoculation studies were performed. The efficacy of LN submersion in boiling water as a means of surface sterilization and the effect of boiling on the viability of Salmonella contained within LN samples were also examined. The results showed that, on average, 23 to 43% of the inoculated LN samples in this study were cross-contaminated by Salmonella on surrounding adipose tissue when present in the range of 101 to 102 CFU per sample; however, surface decontamination methods were very effective at removing Salmonella cross-contaminants in this range.

Prevalence, enumeration, serotypes, and antimicrobial resistance phenotypes of salmonella enterica isolates from carcasses at two large United States pork processing plants

The objective of this study was to characterize Salmonella enterica contamination on carcasses in two large U.S. commercial pork processing plants. The carcasses were sampled at three points, before scalding (prescald), after dehairing/polishing but before evisceration (preevisceration), and after chilling (chilled final). The overall prevalences of Salmonella on carcasses at these three sampling points, prescald, preevisceration, and after chilling, were 91.2%, 19.1%, and 3.7%, respectively. At one of the two plants, the prevalence of Salmonella was significantly higher (P < 0.01) for each of the carcass sampling points. The prevalences of carcasses with enumerable Salmonella at prescald, preevisceration, and after chilling were 37.7%, 4.8%, and 0.6%, respectively. A total of 294 prescald carcasses had Salmonella loads of >1.9 log CFU/100 cm(2), but these carcasses were not equally distributed between the two plants, as 234 occurred at the plant with higher Salmonella prevalences. Forty-one serotypes were identified on prescald carcasses with Salmonella enterica serotypes Derby, Typhimurium, and Anatum predominating. S. enterica serotypes Typhimurium and London were the most common of the 24 serotypes isolated from preevisceration carcasses. The Salmonella serotypes Johannesburg and Typhimurium were the most frequently isolated serotypes of the 9 serotypes identified from chilled final carcasses. Antimicrobial susceptibility was determined for selected isolates from each carcass sampling point. Multiple drug resistance (MDR), defined as resistance to three or more classes of antimicrobial agents, was identified for 71.2%, 47.8%, and 77.5% of the tested isolates from prescald, preevisceration, and chilled final carcasses, respectively. The results of this study indicate that the interventions used by pork processing plants greatly reduce the prevalence of Salmonella on carcasses, but MDR Salmonella was isolated from 3.2% of the final carcasses sampled.

Influence of vitamin D on fecal shedding of Escherichia coli O157:H7 in naturally colonized cattle

Three experiments were conducted to evaluate the influence of vitamin D on fecal shedding of Escherichia coli O157:H7 in cattle. In the first experiment, two groups of cattle (beef and dairy) were assigned to a control treatment or to receive 0.5 × 10(6) IU vitamin D per day via oral bolus for 10 days. Fecal samples were collected before and throughout the dosing period for culture of E. coli O157:H7. No differences were observed for fecal shedding of E. coli O157:H7 among treatments for either beef or dairy animals. Serum concentrations of vitamin D were markedly higher (P < 0.0001) in treated beef cattle but only tended to be higher (P = 0.09) in the dairy cattle. In the second experiment, three successive vitamin D dosages (2,400, 4,800, and 9,600 IU/day; 14 days each) were administered to 14 dairy steers (7 steers served as controls), fecal samples were collected daily, and serum samples were collected weekly throughout the 42-day experimental period. No significant differences in fecal prevalence or serum vitamin D concentrations were observed for any of the vitamin D dosages. A third experiment sampled feedlot cattle (winter and summer) to determine whether serum vitamin D concentrations were correlated with fecal shedding of E. coli O157:H7. A fecal sample and a blood sample were obtained in each season from 60 randomly selected animals (total of 120 fecal samples and 120 corresponding blood samples). As expected, season was highly correlated (r = 0.66) with serum vitamin D concentration with higher concentrations (P < 0.01) observed in the summer. E. coli O157:H7 prevalence (percentage of positive samples) was not highly correlated (r = 0.16) with season, although the correlation tended to be significant (P = 0.08). The proportion of cattle shedding E. coli O157:H7 was 16.7 and 6.7% for the summer and winter collections, respectively. Results of this research do not support a correlation between vitamin D intake and E. coli O157:H7 shedding in cattle.

Impact of reducing the level of wet distillers grains fed to cattle prior to harvest on prevalence and levels of Escherichia coli O157:H7 in feces and on hides

Cattle fed finishing diets with wet distillers grains with solubles (WDGS) have been shown to harbor increased Escherichia coli O157:H7 populations in the feces and on the hides. To determine if feeding a lower level of WDGS at the end of the feeding period reduces E. coli O157:H7 load at harvest, 608 heifers were sorted into one of five treatments and fed 0, 40, or 70% WDGS (dry matter basis). For three of the treatments, WDGS was reduced midway through the study. Treatment 0W0W heifers (positive control) were fed a corn grain-based diet continuously, and 40W40W heifers (negative control) were fed 40% WDGS continuously. Heifers subjected to treatments 40W0W, 40W15W, and 70W15W were fed either 40 or 70% WDGS for the first 56 days and switched to 0 or 15% WDGS, respectively, for the last 56 days. Prior to the switch in diets, animals fed diets with 40 or 70% had higher prevalence and percent enumerable fecal samples for E. coli O157:H7. After the dietary switch, animals fed 40W0W, 40W15W, and 70W15W diets had fecal prevalence and percent enumerable samples (33.4 and 6.3%, 31.0 and 9.7%, and 34.9 and 8.4%, respectively) similar to those of animals fed 0W0W diets (10.2 and 3.2%, respectively; P > 0.05), whereas animals fed 40W40W had the highest fecal prevalence and percent enumerable samples (70.1 and 29.2%, respectively; P < 0.05). Similar relationships between the treatments were observed for hide samples. Time after dietary switch was important, as animals fed lower levels had significantly lower fecal prevalence and percent enumerable samples after 56 days, but not after 28 days. The study indicates that cattle can be switched to lower levels of dietary WDGS (15% or less) 56 days prior to harvest to significantly reduce E. coli O157:H7 in feces and on hides.

Survival of Escherichia coli O157:H7 on cattle hides

The objective of this study was to determine the time period that Escherichia coli O157:H7 survives on the hides of cattle. Extensive research has been conducted and is ongoing to identify and develop novel preharvest intervention strategies to reduce the presence of E. coli O157:H7 on live cattle and subsequent transfer to processed carcasses. If a reduction of E. coli O157:H7 levels in feces can be achieved through preharvest intervention, it is not known how long it would take for such reductions to be seen on the hide. In the study presented herein, three trials were conducted to follow E. coli O157:H7 hide prevalence over time. For each trial, 36 animals were housed in individual stanchions to minimize or prevent hide contamination events. Through prevalence determination and isolate genotyping with pulsed-field gel electrophoresis, survival of E. coli O157:H7 on the hides of live cattle was determined to be short lived, with an approximate duration of 9 days or less. The results of this study suggest that any preharvest interventions that are to be administered at the end of the finishing period will achieve maximum effect in reducing E. coli O157:H7 levels on cattle hides if given 9 days before the cattle are presented for processing. However, it should be noted that interventions reducing pathogen shedding would also contribute to decreasing hide contamination through lowering the contamination load of the processing plant lairage environment, regardless of the time of application.

Multiplex PCR detection of Shiga toxin-producing Escherichia coli strains belonging to serogroups O157, O103, O91, O113, O145, O111, and O26 experimentally inoculated in beef carcass swabs, beef trim, and ground beef

Numerous foodborne outbreaks are attributed to Shiga toxin-producing Escherichia coli (STEC) and have been recognized for causing gastrointestinal disease in humans. Beef products have been considered the principal source of STEC. A multiplex PCR assay enabling simultaneous detection of STEC O103, O91, O113, O145, O111, O157, and O26 was developed and evaluated in artificially contaminated beef carcass swabs, beef trim, and ground beef after overnight enrichment. Individual serogroups were experimentally inoculated at low (1 to 10 CFU/ml) and high (11 to 100 CFU/ml) levels, and with a cocktail of strains belonging to two, four, and six serogroups. There was no significant difference in detecting single STEC strains under the different conditions. Only when strains were combined were there significant differences in detection of all cocktail isolates in some of the beef products. To address this issue, four serogroups were experimentally inoculated together at three different estimated levels (10, 10(2), and 10(3) CFU/ml) in all three beef products. Results yielded no significant difference in detecting STEC at the three inoculation levels (10, 10(2), and 10(3) CFU/ml) in trim and carcass swabs, but there was a significant difference in detecting STEC at the lowest levels (10 and 10(2) CFU/ml) in the 80:20 nonirradiated ground beef, and in the detection of STEC in irradiated ground beef. The findings from this study could provide industry and government agencies with a tool to evaluate the prevalence and incidence of STEC in beef products and their processing environments.

Label-free capacitive immunosensor based on quartz crystal Au electrode for rapid and sensitive detection of Escherichia coli O157:H7

A label-free capacitive immunosensor based on quartz crystal Au electrode was developed for rapid and sensitive detection of Escherichia coli O157:H7. The immunosensor was fabricated by immobilizing affinity-purified anti-E. coli O157:H7 antibodies onto self-assembled monolayers (SAMs) of 3-mercaptopropionic acid (MPA) on the surface of a quartz crystal Au electrode. Bacteria suspended in solution became attached to the immobilized antibodies when the immunosensor was tested in liquid samples. The change in capacitance caused by the bacteria was directly measured by an electrochemical detector. An equivalent circuit was introduced to simulate the capacitive immunosensor. The immunosensor was evaluated for E. coli O157:H7 detection in pure culture and inoculated food samples. The experimental results indicated that the capacitance change was linearly correlated with the cell concentration of E. coli O157:H7. The immunosensor was able to discriminate between cellular concentrations of 10(2)-10(5) cfu mL(-1) and has applications in detecting pathogens in food samples. Cyclic voltammetry (CV) and electrochemical impedance spectroscopy (EIS) were also employed to characterize the stepwise assembly of the immunosensor.

In vivo and ex vivo evaluations of bacteriophages e11/2 and e4/1c for use in the control of Escherichia coli O157:H7

This study investigated the effect of bacteriophages (phages) e11/2 and e4/1c against Escherichia coli O157:H7 in an ex vivo rumen model and in cattle in vivo. In the ex vivo rumen model, samples were inoculated with either 10³ or 10⁶ CFU/ml inoculum of E. coli O157:H7 and challenged separately with each bacteriophage. In the presence of phage e11/2, the numbers of E. coli O157:H7 bacteria were significantly (P < 0.05) reduced to below the limit of detection within 1 h. Phage e4/1c significantly (P < 0.05) reduced E. coli O157:H7 numbers within 2 h of incubation, but the number of surviving E. coli O157:H7 bacteria then remained unchanged over a further 22-h incubation period. The ability of a phage cocktail of e11/2 and e4/1c to reduce the fecal shedding of E. coli O157:H7 in experimentally inoculated cattle was then investigated in two cattle trials. Cattle (yearlings, n = 20 for trial one; adult fistulated cattle, n = 2 for trial two) were orally inoculated with 10(10) CFU of E. coli O157:H7. Animals (n = 10 for trial one; n = 1 for trial two) were dosed daily with a bacteriophage cocktail of 10(11) PFU for 3 days postinoculation. E. coli O157:H7 and phage numbers in fecal and/or rumen samples were determined over 7 days postinoculation. E. coli O157:H7 numbers rapidly declined in all animals within 24 to 48 h; however, there was no significant difference (P > 0.05) between the numbers of E. coli O157:H7 bacteria shed by the phage-treated or control animals. Phages were recovered from the rumen but not from the feces of the adult fistulated animal in trial two but were recovered from the feces of the yearling animals in trial one. While the results from the rumen model suggest that phages are effective in the rumen, further research is required to improve the antimicrobial effectiveness of phages for the elimination of E. coli O157:H7 in vivo.

Soil versus Pond Ash Surfacing of Feedlot Pens: Occurrence of Escherichia coli O157:H7 in Cattle and Persistence in Manure

Reducing Escherichia coli O157:H7 in cattle and their manure is critical for reducing the risk for human foodborne and waterborne illness. The objective of this study was to evaluate the effects of soil and pond ash surfaces for feedlot pens on the prevalence, levels, and/or persistence of naturally occurring E. coli O157:H7 and total E. coli in cattle (feces and hides) and manure. Cattle (128 beef heifers) were sorted among 16 pens: 8 surfaced with soil and 8 surfaced with pond ash. The prevalence of E. coli O157:H7 in feces decreased (P < 0.0001) during the study from 57.0% on day 0 to 3.9% on day 84 but did not differ (P > or = 0.05) between cattle on soil and on pond ash pens at any sampling period. The prevalence of the pathogen on hides and in feedlot surface material (FSM) also decreased (P < 0.0001), with no effect of soil or pond ash surface (P > or = 0.05). Similarly, levels of E. coli in FSM did not differ (P > or = 0.05) at any sampling period, and there were no clear trends for survival differences of E. coli O157:H7 or E. coli in FSM between pond ash and soil surfaces, although E. coli populations survived at 5.0 log CFU/g of FSM on the pen surfaces 6 weeks after the cattle were removed. These results indicate that housing cattle on pens surfaced with pond ash versus pens surfaced with soil does not affect E. coli O157:H7 in cattle or their manure.

Lanthanum-based concentration and microrespirometric detection of microbes in water

Rapid concentration and detection of microorganisms, particularly pathogens, are important but remain a challenge. In this research, lanthanum chloride (LaCl(3)) was used to concentrate E. coli in water and the results were compared with those obtained using traditional flocculants, such as ferric sulfate and aluminum sulfate. A turbidimetric assay and a microrespirometric assay were employed to enumerate the bacteria in water samples by monitoring the absorbance of bacteria and the oxygen-based fluorescence intensity, respectively. The microrespirometric method requires less time than the turbidimetric assay. Both assays could linearly enumerate the bacteria at the concentration range from 10(1) to 10(9)cells/mL. Based on the turbidimetric assay, the relative concentration efficiencies of the three flocculants were 75% (LaCl(3)), 40% (FeCl(3)) and 33% (Al(2)(SO(4))(3)), while for the microrespirometric assay, the concentration efficiencies were 85% (LaCl(3)), 34% (FeCl(3)) and 32% (Al(2)(SO(4))(3)). The microbial recovery rates, defined as the ratio of cell number in the sediment after coagulation/flocculation to that of the controls, were 94% (LaCl(3)), 69% (FeCl(3)) and 51% (Al(2)(SO(4))(3)) from the turbidimetric assay. The results demonstrate that compared with traditional flocculants, LaCl(3) has higher relative concentration and recovery efficiencies and thus possesses the potential for microbial concentration in water samples.

Evaluation of a direct-fed microbial product effect on the prevalence and load of Escherichia coli O157:H7 in feedlot cattle

Direct-fed microbials (DFM) have been identified as potential preharvest interventions for the reduction of foodborne bacterial pathogens such as Escherichia coli O157:H7. This study evaluated the efficacy of a DFM consisting of Bacillus subtilis strain 166 as an antimicrobial intervention strategy for the reduction of prevalence and load of E. coli O157:H7 in feces and on hides of feedlot cattle. Cattle (n = 526) were divided among 16 feedlot pens. Half of the pens received the DFM, and the other half did not. Hide and fecal samples were collected from each animal on days 28, 63, and 84 of the feeding trial. Over the course of the 84-day feeding period, there were no significant differences observed between treatments for either hide or fecal prevalence of E. coli O157:H7, or for the percentage of animals that were shedding E. coli O157:H7 at high levels (> or =200 CFU/g) in their feces or harboring E. coli O157:H7 at high levels (> or =40 CFU/cm(2)) on their hides. In addition, there was no significant difference between the average daily gains for the treated and control groups, with both groups averaging 1.3 kg/day. We concluded that the DFM tested would not be an effective preharvest intervention against E. coli O157:H7.

Escherichia coli O157:H7: recent advances in research on occurrence, transmission, and control in cattle and the production environment

Escherichia coli O157:H7 is a zoonotic pathogen that is an important cause of human foodborne and waterborne disease, with a spectrum of illnesses ranging from asymptomatic carriage and diarrhea to the sometimes fatal hemolytic uremic syndrome. Outbreaks of E. coli O157:H7 disease are often associated with undercooked beef, but there are other sources of transmission, including water, produce, and animal contact, which can often be linked directly or indirectly to cattle. Thus, preharvest control of this pathogen in cattle production should have a large impact on reducing the risk of human foodborne illness. In this review, we will summarize preharvest research on E. coli O157:H7 in cattle and the production environment, focusing on factors that may influence the transmission, prevalence, and levels of this pathogen, such as season, diet, high-level shedders, and animal stress. In addition, we will discuss recent research on the reduction of this pathogen in cattle production, including vaccination, probiotics, bacteriophage, and manure treatments.

Lyophilization prior to direct DNA extraction from bovine feces improves the quantification of Escherichia coli O157:H7 and Campylobacter jejuni

Lyophilization was used to concentrate bovine feces prior to DNA extraction and analysis using real-time PCR. Lyophilization significantly improved the sensitivity of detection compared to that in fresh feces and was associated with reliable quantification of both Escherichia coli O157:H7 and Campylobacter jejuni bacteria present in feces at concentrations ranging between 2 log(10) and 6 log(10) CFU g(-)(1).

Impacts of individual animal response to heat and handling stresses on Escherichia coli and E. coli O157:H7 fecal shedding by feedlot cattle

The reduction of foodborne pathogens in cattle destined for human consumption will require knowledge of the factors that impact the carriage and shedding of these organisms. The objective of this work was to investigate the effects of heat and handling stress levels on the fecal shedding of Escherichia coli O157:H7 and generic E. coli by feedlot cattle. In year 1, 128 feedlot heifers were evaluated for heat tolerance five times per week during the 84-day finishing period from May through August. Heat stress measurements included respiration rate, panting score, and visual assessments. In year 2, panting scores were taken for a group of 256 finishing feedlot heifers on days in July and August for which the temperature humidity index (THI) was predicted to be in the "emergency" category (THI > or = 84). For both years, animals were weighed and temperament scored to assess handling stress on a 28-day schedule. At the same time, rectal fecal samples were collected from each animal individually. The presence and concentrations of E. coli O157:H7 and concentrations of generic E. coli in feces were determined. There were no clear trends between the heat stress levels or temperament scores (as an indicator of response to handling) with either fecal generic E. coli concentrations or E. coli O157:H7 concentrations or prevalence in feces, indicating that neither heat nor handling stress contributes to the food safety risk associated with E. coli O157:H7-positive cattle.

Influence of beta-agonists (ractopamine HCl and zilpaterol HCl) on fecal shedding of Escherichia coli O157:H7 in feedlot cattle

Ractopamine HCl and zilpaterol HCl, beta-agonists recently approved for use in feedlot cattle to improve performance traits and carcass leanness, were examined for their effects on fecal shedding of Escherichia coli O157:H7 in feedlot cattle. Fecal samples (n = 2,454) were obtained from four experiments (one ractopamine HCl, three zilpaterol HCl) over the course of a 3-year period, either by rectal palpation (ractopamine HCl experiment) or from pen-floor fecal pats. Samples were cultured quantitatively and qualitatively for E. coli O157:H7. No significant treatment differences were detected for fecal prevalence of E. coli O157:H7 in the ractopamine HCl experiment. Zilpaterol HCl feeding had no effect (P > 0.20) on fecal shedding in the first or second experiments, with overall E. coli O157:H7 prevalence relatively low (<7%). In the third zilpaterol HCl experiment, the percentage of fecal samples that were E. coli O157:H7 positive following qualitative culture was higher (P < 0.05) in the zilpaterol HCl treatment (10.3%) than for the control (6.1%). The current research showed minimal effects of beta-agonists on fecal shedding of E. coli O157:H7 and indicated that these compounds (fed immediately prior to slaughter) are not a cause for concern from a food safety standpoint.

Assessment of Shiga toxin-producing Escherichia coli isolates from wildlife meat as potential pathogens for humans

A total of 140 Shiga toxin-producing Escherichia coli (STEC) strains from wildlife meat (deer, wild boar, and hare) isolated in Germany between 1998 and 2006 were characterized with respect to their serotypes and virulence markers associated with human pathogenicity. The strains grouped into 38 serotypes, but eight O groups (21, 146, 128, 113, 22, 88, 6, and 91) and four H types (21, 28, 2, and 8) accounted for 71.4% and 75.7% of all STEC strains from game, respectively. Eighteen of the serotypes, including enterohemorrhagic E. coli (EHEC) O26:[H11] and O103:H2, were previously found to be associated with human illness. Genes linked to high-level virulence for humans (stx(2), stx(2d), and eae) were present in 46 (32.8%) STEC strains from game. Fifty-four STEC isolates from game belonged to serotypes which are frequently found in human patients (O103:H2, O26:H11, O113:H21, O91:H21, O128:H2, O146:H21, and O146:H28). These 54 STEC isolates were compared with 101 STEC isolates belonging to the same serotypes isolated from farm animals, from their food products, and from human patients. Within a given serotype, most STEC strains were similar with respect to their stx genotypes and other virulence attributes, regardless of origin. The 155 STEC strains were analyzed for genetic similarity by XbaI pulsed-field gel electrophoresis. O103:H2, O26:H11, O113:H21, O128:H2, and O146:H28 STEC isolates from game were 85 to 100% similar to STEC isolates of the same strains from human patients. By multilocus sequence typing, game EHEC O103:H2 strains were attributed to a clonal lineage associated with hemorrhagic diseases in humans. The results from our study indicate that game animals represent a reservoir for and a potential source of human pathogenic STEC and EHEC strains.

Longitudinal study of Escherichia coli O157:H7 in a beef cattle feedlot and role of high-level shedders in hide contamination

The objectives of the study described here were (i) to investigate the dynamics of Escherichia coli O157:H7 fecal and hide prevalence over a 9-month period in a feedlot setting and (ii) to determine how animals shedding E. coli O157:H7 at high levels affect the prevalence and levels of E. coli O157:H7 on the hides of other animals in the same pen. Cattle (n = 319) were distributed in 10 adjacent pens, and fecal and hide levels of E. coli O157:H7 were monitored. When the fecal pen prevalence exceeded 20%, the hide pen prevalence was usually (25 of 27 pens) greater than 80%. Sixteen of 19 (84.2%) supershedder (>10(4) CFU/g) pens had a fecal prevalence greater than 20%. Significant associations with hide and high-level hide (>/=40 CFU/100 cm(2)) contamination were identified for (i) a fecal prevalence greater than 20%, (ii) the presence of one or more high-density shedders (>/=200 CFU/g) in a pen, and (iii) the presence of one or more supershedders in a pen. The results presented here suggest that the E. coli O157:H7 fecal prevalence should be reduced below 20% and the levels of shedding should be kept below 200 CFU/g to minimize the contamination of cattle hides. Also, large and unpredictable fluctuations within and between pens in both fecal and hide prevalence of E. coli O157:H7 were detected and should be used as a guide when preharvest studies, particularly preharvest intervention studies, are designed.

Prevalence and level of Escherichia coli O157:H7 in feces and on hides of feedlot steers fed diets with or without wet distillers grains with solubles

The objective of this study was to determine if wet distillers grains with solubles (WDGS) from corn in diets affected Escherichia coli O157:H7 in growing and finishing cattle; steers (n = 603) were randomly assigned to diets with or without WDGS. Hide and fecal samples were collected monthly (October through June) from each animal for enumeration and enrichment of E. coli O157:H7. In the growing phase (0 or 13.9% WDGS diets), fecal prevalence for E. coli O157:H7 in steers fed a diet with WDGS was twice that of the prevalence in control steers (P < 0.001). In the finishing phase (0 or 40% WDGS diets), the average prevalence in feces (P < 0.001) and on hides (P < 0.001) was higher for cattle fed WDGS. The average percentage of fecal E. coli O157:H7 enumerable samples during the finishing phase for cattle fed WDGS was 2.7% compared with 0.1% for control steers (P < 0.001). The average percentage of E. coli O157:H7 enumerable hide samples was not different between diets, but the cattle fed WDGS had higher levels (P < 0.05) of the pathogen. Animals fed WDGS had higher levels of E. coli (P < 0.001), higher pH values (P < 0.001), and lower concentrations of L-lactate (P < 0.001) in feces than those values of the control steers. These results indicate that feeding 40% WDGS could increase the level and prevalence of E. coli O157:H7 in and on feedlot cattle when E. coli O157:H7 is seasonally low.

Prevalence and enumeration of Escherichia coli O157:H7 and Salmonella in U.S. abattoirs that process fewer than 1000 head of cattle per day

A significant portion (15 to 20%) of beef in the United States is produced in small beef processing plants that harvest fewer than 1000 cattle per day. However, there are little data on the prevalence and levels of Escherichia coli O157:H7 and Salmonella in these processing plants. To address this lack of data, hides (n=1995) and carcasses (n=1995) of cattle at seven small processing plants located across the United States were analyzed for E. coli O157:H7 and Salmonella. Across all plants, hide prevalence of E. coli O157:H7 and Salmonella was 71 and 91%, respectively. Twelve percent of hides had E. coli O157:H7 at enumerable levels (> or =40 CFU/100 cm2), while 36% of hides had Salmonella at enumerable levels. Across all plants, the prevalence of E. coli O157:H7 on preevisceration carcasses was 33%, with 2% at an enumerable level (> or = 0.8 CFU/ 100 cm2). Across all plants, Salmonella prevalence on preevisceration carcasses was 58%, with 8% at an enumerable level. Significant plant-to-plant variations in levels and prevalence of pathogens on carcasses were detected. Reduced levels of pathogens on carcasses were noted among small processors that had incorporated a hide-directed intervention. The results obtained are comparable to those observed previously for larger processors, showing that smaller beef processors face and address the same challenges as do larger beef processors.

Prevalence and characterization of salmonellae in commercial ground beef in the United States

Commercially produced ground beef samples (n = 4,136) were collected from seven regions of the United States over a 24-month period (July 2005 to June 2007) and analyzed for the presence of Salmonella enterica by using methods that concurrently provided total prevalence and enumerable levels. The overall prevalence of Salmonella strains was 4.2%. Enumeration showed that 94.2% were present at levels below 2 CFU/g. Regional monthly prevalences of Salmonella strains varied from 1.8% to 6.5% but were not statistically different (P > 0.05). All Salmonella isolates were serotyped and their antibiotic susceptibilities determined and analyzed by pulsed-field gel electrophoresis (PFGE). The most common serotypes identified were Salmonella enterica serotypes Montevideo, Anatum, Muenster, and Mbandaka, with these accounting for one-half of the isolates obtained. The prevalence of multidrug-resistant (MDR) Salmonella was determined to be 0.6%. The most common MDR serotypes were Salmonella enterica serotypes Dublin, Reading, and Typhimurium. MDR strains had resistance to between 2 and 10 antibiotics. There were no regional differences in prevalence of MDR Salmonella. PFGE analysis revealed that indistinguishable XbaI and AvrII restriction digest patterns (RDPs) could be observed in isolates of the same serotype found in different regions and months of sampling. The RDPs of 19 Salmonella strains were compared to RDPs in the PulseNet USA database. Thirteen were indistinguishable from existing patterns, and the number of records for each ranged from 1 to 478. These data show that Salmonella prevalence in commercial ground beef is low and suggest that attempts to identify sources contributing to Salmonella in ground beef by serotype, antibiogram, and PFGE cannot be made without additional documented evidence.

Evaluation of the 'GeneDisc' real-time PCR system for detection of enterohaemorrhagic Escherichia coli (EHEC) O26, O103, O111, O145 and O157 strains according to their virulence markers and their O- and H-antigen-associated genes

AIMS

To evaluate the GeneDisc multiplex real-time PCR assay for detection of enterohaemorrhagic Escherichia coli (EHEC) O26, O103, O111, O145 and O157 strains.

METHODS AND RESULTS

GeneDiscs for detection of genes encoding Shiga toxins (stx), intimins (eae), E. coli O157 (rfbE(O157)) and H7 (fliC(H7)) antigens as well as genes specific for EHEC O26 (wzx(O26)), O103 (wzx(O103)), O111 (wbd1(O111)), O145 (ihp1(O145)) and O157 (ihp1(O157)) were evaluated. The assay was run with native bacteria in 1 h in a GeneDisc Cycler. All genotypes of stx and eae, except stx(2f) and eae-rho, were identified. Escherichia coli strains belonging to O-groups O26, O103, O111, O157 as well as EHEC O145:[H28] strains were specifically detected with this assay. The ihp1(O157) gene was not found specific for EHEC O157. O-rough mutants of EHEC and non-motile EHEC O157 strains were reliably identified with the GeneDisc assay. Two to three colonies of EHEC strains were still detectable in a lawn of 50 000 apathogenic E. coli from agar plates.

CONCLUSIONS

The GeneDisc assay is a specific and reliable assay for detection of major EHEC strains. It is robust enough to detect few EHEC colonies in mixed cultures of bacteria.

SIGNIFICANCE AND IMPACT OF THE STUDY

The assay is promising for its use in EHEC diagnostics and for EHEC monitoring with different kinds of samples.

Effectiveness of 1,3-dibromo-5,5 dimethylhydantoin on reduction of Escherichia coli O157:H7- and Salmonella-inoculated fresh meat

1,3-Dibromo-5,5-dimethylhydantoin (DBDMH; 25 degrees C) and hot water (85 degrees C) spray treatments were evaluated for efficacy in decontamination of pathogenic bacteria attached to beef carcass surfaces represented by cutaneous trunci (CT) muscle sections and beef hearts. Treatments were evaluated using two different systems, a commercial carcass wash cabinet and a model carcass washer. The effects were measured immediately after treatment and again after 48 h of storage at 4 degrees C. Section of CT and beef hearts were inoculated with bovine fecal solution containing approximately 6 log CFU/cm2 of Escherichia coli O157:H7 and Salmonella. After DBDMH or hot water spray treatments, bacterial populations were enumerated immediately and after storage for 48 h at 4 degrees C. DBDMH treatments reduced aerobic plate counts, Enterobacteriaceae, E. coli O157: H7, and Salmonella by the same or slightly lower amounts relative to hot water treatment. DBDMH reduced aerobic plate counts and Enterobacteriaceae by 2.8 to 3.6 log CFU/cm2, E. coli O157:H7 by 1.6 to 2.1 log CFU/cm2, and Salmonella by 0.7 to 2.3 log CFU/cm2 on CT sections and beef hearts. Hot water treatment reduced aerobic plate counts and Enterobacteriaceae by 3.0 to 4.1 log CFU/cm2, E. coli O157:H7 by 1.8 to 2.3 log CFU/cm2, and Salmonella by 2.5 to 2.8 log CFU/cm2. After 48 h of storage, the reductions of organisms by DBDMH and hot water treatments were not different. This study demonstrated that DBDMH spray washing could be effective as an antimicrobial intervention for beef carcasses and variety meats.

A direct plating method for estimating populations of Escherichia coli O157 in bovine manure and manure-based materials

Escherichia coli O157:H7 outbreaks associated with produce consumption have brought attention to livestock manures and manure-based soil amendments as potential sources of pathogens for the contamination of these crops. Procedures for enumeration of E. coli O157:H7 are needed to assess the risks of transmission from these manures and their by-products. A direct plating method employing spiral plating onto CHROMagar O157 was investigated for enumeration of E. coli O157:H7 in feedlot surface material, aged bovine manure, bovine manure compost, and manure-amended soil. In studies utilizing samples spiked with a five-strain cocktail of E. coli O157:H7 at levels ranging from 102 to 10(5) CFU/g of sample, there were strong correlations between the observed and predicted levels of this pathogen. Although the addition of 2.5 mg/liter potassium tellurite and 5 mg/liter novobiocin made the medium more restrictive, these amendments enhanced the ability to identify and enumerate E. coli O157:H7 in feedlot surface material, which contained a higher proportion of fresh feces than did the other three sample types and therefore higher levels of interfering bacterial microflora. The spiral plating method was further assessed to determine its ability to enumerate E. coli O157:H7 in naturally contaminated feedlot surface material. Comparison of E. coli O157:H7 counts in feedlot surface material obtained by the spiral plating method and a most probable number technique were well correlated. We conclude that direct spiral plating onto CHROMagar O157 is effective for estimating E. coli O157:H7 levels in a variety of manures and manure-containing sample types to a lower detection limit of 200 CFU/g. The method has application for determining E. coli O157:H7 concentrations in manures and composts before their sale and use as soil amendments and for measuring the effectiveness of manure treatment processes to reduce or inactivate this pathogen.

Source tracking of Escherichia coli O157:H7 and Salmonella contamination in the lairage environment at commercial U.S. beef processing plants and identification of an effective intervention

Transportation from the feedlot and lairage at the processing plant have been identified as potential sources of Escherichia coli O157:H7 and Salmonella hide contamination. The objective of this study was to perform a comprehensive tracking analysis of E. coli O157:H7 and Salmonella associated with beef cattle from the feedlot through processing. Cattle (n = 581) were sampled in a feedlot, then transported in multiple lots to three commercial, fed beef processing plants in the United States, where they were sampled again. Samples were collected from the tractor trailers prior to loading cattle and from the lairage environment spaces prior to entry of the study cattle. Pathogen prevalence on cattle hides increased on every lot of cattle between exiting the feedlot and beginning processing. Prior to loading cattle, E. coli O157:H7 was found in 9 (64%) of 14 tractor trailers. E. coli O157:H7 was detected in over 60% of the samples from each lairage environment area, while Salmonella was detected in over 70% of the samples from each lairage environment area. E. coli O157:H7 and Salmonella isolates (n = 3,645) were analyzed using pulsed-field gel electrophoresis. The results of the pulsed-field gel electrophoresis tracking indicate that the transfer of bacteria onto cattle hides that occurs in the lairage environments of U.S beef processing plants accounts for a larger proportion of the hide and carcass contamination than does the initial bacterial population found on the cattle exiting the feedlot. Finally, the results of this study indicate that hide wash cabinets are effective in removing contamination derived from the lairage environment.

Salmonella and Escherichia coli O157:H7 contamination on hides and carcasses of cull cattle presented for slaughter in the United States: an evaluation of prevalence and bacterial loads by immunomagnetic separation and direct plating methods

The hide and carcass hygiene of cull cattle at slaughter in four geographically distant regions of the United States was examined from July 2005 to April 2006 by measuring the aerobic plate counts (APC) and the prevalences and loads of Salmonella and Escherichia coli O157:H7. The geometric mean log(10) APC CFU/100 cm(2) levels on hides and preevisceration and postintervention carcasses ranged from 6.17 to 8.19, 4.24 to 6.47, and 1.46 to 1.96, respectively, and were highest in the summer (P < 0.0001). The average prevalences of Salmonella on hides and preevisceration and postintervention carcasses were 89.6% (95% confidence interval [CI], 85.1 to 94.0), 50.2% (95% CI, 40.9 to 59.5), and 0.8% (95% CI, 0.18 to 1.42), respectively. The prevalences of E. coli O157:H7 were 46.9% (95% CI, 37.3 to 56.6) and 16.7% (95% CI, 9.8 to 23.6) on hides and preevisceration carcasses, respectively. Examination of the concomitant incidence of Salmonella and E. coli O157:H7 showed that, on average, 33.3% (95% CI, 15.9 to 69.8) of cattle hide and 4.1% (95% CI, 0.98 to 17.3) of preevisceration carcass samples were contaminated with both pathogens. The pathogen prevalence on hides and carcasses was not significantly affected by the season; however, significant differences were observed between plants with respect to the incoming pathogen load and the ability to mitigate hide-to-carcass transfer. In spite of these differences, postintervention carcass contamination was significantly reduced (P < 0.001), likely as a result of the use of one or more of the processing interventions employed at each of the four processing plants examined.

Prevalence and characterization of Salmonella in bovine lymph nodes potentially destined for use in ground beef

A potential source of pathogenic bacteria in ground beef is the lymphatic system, specifically the lymph nodes. Bacteria have been isolated from the lymph nodes of cattle at slaughter; however, most studies have dealt with mesenteric lymph nodes, which are not normally incorporated into ground beef. The objective of the current study was to determine the prevalence and multidrug-resistance status of Salmonella in bovine lymph nodes associated with lean and fat trimmings that might be utilized in ground beef production. Bovine lymph nodes (n = 1,140) were collected from commercial beef processing plants. Half of the lymph nodes sampled were obtained from cull cow and bull processing plants, and the remainder were obtained from fed beef processing plants. Lymph nodes located in chuck and flank adipose tissue were collected for this study. Salmonella prevalence in the lymph node samples was low, with an overall prevalence of 1.6% and a 95% confidence interval of 0.85 to 2.3%. Lymph nodes from cull cattle carcasses had a higher prevalence of Salmonella than did those from fed cattle carcasses. Lymph nodes from the flanks of cow and bull carcasses had the highest prevalence at 3.86%, whereas lymph nodes from the chuck region of fed cattle carcasses had the lowest prevalence at 0.35%. Three of the 18 Salmonella-positive lymph node samples contained multidrug-resistant Salmonella, and all 3 samples were from cull cattle.

Interventions to reduce/eliminate Escherichia coli O157:H7 in ground beef

The Escherichia coli O157:H7 (E. coli O157:H7) outbreak in the Northwestern United States ushered in an era that has dramatically changed the way beef processors in the United States convert live cattle into meat. Unprecedented cooperation among the beef processors and massive investment in research by the US government and the beef industry have resulted in an acceptable level of control of E. coli O157:H7 in ground beef. The evidence to support the progress in control of E. coli O157:H7 is the CDC data for reduction in human illness as well as the dramatic reduction in the number of E. coli O157:H7-positive samples in USDA-FSIS ground beef monitoring. This manuscript highlights some of the recent findings from our laboratory on the control of E. coli O157:H7 in ground beef. We have also summarized the key events/decisions/milestones that have contributed to the control of E. coli O157:H7 in ground beef in the United States. While there is much to be done to bring E. coli O157:H7 under complete control in the beef sector of the food industry, E. coli O157:H7 also is becoming a major issue in the fresh vegetable sector, as evidenced by the 2006 outbreaks in the United States. We have discussed how the fresh vegetable industry can benefit from the beef industry's experience to expedite the control of E. coli O157:H7 in their products.