New yeast expression platforms based on methylotrophic Hansenula polymorpha and Pichia pastoris and on dimorphic Arxula adeninivorans and Yarrowia lipolytica - a comparison

Catabolite repression of Aox in Pichia pastoris is dependent on hexose transporter PpHxt1 and pexophagy

In this work, the identification and characterization of two hexose transporter homologs in the methylotrophic yeast Pichia pastoris, P. pastoris Hxt1 (PpHxt1) and PpHxt2, are described. When expressed in a Saccharomyces cerevisiae hxt-null mutant strain that is unable to take up monosaccharides, either protein restored growth on glucose or fructose. Both PpHXT genes are transcriptionally regulated by glucose. Transcript levels of PpHXT1 are induced by high levels of glucose, whereas transcript levels of PpHXT2 are relatively lower and are fully induced by low levels of glucose. In addition, PpHxt2 plays an important role in glycolysis-dependent fermentative growth, since PpHxt2 is essential for growth on glucose or fructose when respiration is inhibited. Notably, we firstly found that the deletion of PpHXT1, but not PpHXT2, leads to the induced expression of the alcohol oxidase I gene (AOX1) in response to glucose or fructose. We also elucidated that a sharp dropping of the sugar-induced expression level of Aox at a later growth phase is caused mainly by pexophagy, a degradation pathway in methylotrophic yeast. The sugar-inducible AOX1 promoter in an Deltahxt1 strain may be promising as a host for the expression of heterologous proteins. The functional analysis of these two hexose transporters is the first step in elucidating the mechanisms of sugar metabolism and catabolite repression in P. pastoris.

Establishment of cyanophycin biosynthesis in Pichia pastoris and optimization by use of engineered cyanophycin synthetases

Two strains of the methylotrophic yeast Pichia pastoris were used to establish cyanophycin (multi-L-arginyl-poly-L-aspartic acid [CGP]) synthesis and to explore the applicability of this industrially widely used microorganism for the production of this polyamide. Therefore, the CGP synthetase gene from the cyanobacterium Synechocystis sp. strain PCC 6308 (cphA(6308)) was expressed under the control of the alcohol oxidase 1 promoter, yielding CGP contents of up to 10.4% (wt/wt), with the main fraction consisting of the soluble form of the polymer. To increase the polymer contents and to obtain further insights into the structural or catalytic properties of the enzyme, site-directed mutagenesis was applied to cphA(6308) and the mutated gene products were analyzed after expression in P. pastoris and Escherichia coli, respectively. CphA(6308)Delta1, which was truncated by one amino acid at the C terminus; point mutated CphA(6308)C595S; and the combined double-mutant CphA(6308)Delta1C595S protein were purified. They exhibited up to 2.5-fold higher enzyme activities of 4.95 U/mg, 3.20 U/mg, and 4.17 U/mg, respectively, than wild-type CphA(6308) (2.01 U/mg). On the other hand, CphA proteins truncated by two (CphA(6308)Delta2) or three (CphA(6308)Delta3) amino acids at the C terminus showed similar or reduced CphA enzyme activity in comparison to CphA(6308). In flask experiments, a maximum of 14.3% (wt/wt) CGP was detected after the expression of CphA(6308)Delta1 in P. pastoris. For stabilization of the expression plasmid, the his4 gene from Saccharomyces cerevisiae was cloned into the expression vector used and the constructs were transferred to histidine auxotrophic P. pastoris strain GS115. Parallel fermentations at a one-to-one scale revealed 26 degrees C and 6.0 as the optimal temperature and pH, respectively, for CGP synthesis. After optimization of fermentation parameters, medium composition, and the length of the cultivation period, CGP contents could be increased from 3.2 to 13.0% (wt/wt) in cells of P. pastoris GS115 expressing CphA(6308) and up to even 23.3% (wt/wt) in cells of P. pastoris GS115 expressing CphA(6308)Delta1.

Adaptation of Hansenula polymorpha to methanol: a transcriptome analysis

BACKGROUND

Methylotrophic yeast species (e.g. Hansenula polymorpha, Pichia pastoris) can grow on methanol as sole source of carbon and energy. These organisms are important cell factories for the production of recombinant proteins, but are also used in fundamental research as model organisms to study peroxisome biology. During exponential growth on glucose, cells of H. polymorpha typically contain a single, small peroxisome that is redundant for growth while on methanol multiple, enlarged peroxisomes are present. These organelles are crucial to support growth on methanol, as they contain key enzymes of methanol metabolism.In this study, changes in the transcriptional profiles during adaptation of H. polymorpha cells from glucose- to methanol-containing media were investigated using DNA-microarray analyses.

RESULTS

Two hours after the shift of cells from glucose to methanol nearly 20% (1184 genes) of the approximately 6000 annotated H. polymorpha genes were significantly upregulated with at least a two-fold differential expression. Highest upregulation (> 300-fold) was observed for the genes encoding the transcription factor Mpp1 and formate dehydrogenase, an enzyme of the methanol dissimilation pathway. Upregulated genes also included genes encoding other enzymes of methanol metabolism as well as of peroxisomal beta-oxidation.A moderate increase in transcriptional levels (up to 4-fold) was observed for several PEX genes, which are involved in peroxisome biogenesis. Only PEX11 and PEX32 were higher upregulated. In addition, an increase was observed in expression of the several ATG genes, which encode proteins involved in autophagy and autophagy processes. The strongest upregulation was observed for ATG8 and ATG11.Approximately 20% (1246 genes) of the genes were downregulated. These included glycolytic genes as well as genes involved in transcription and translation.

CONCLUSION

Transcriptional profiling of H. polymorpha cells shifted from glucose to methanol showed the expected downregulation of glycolytic genes together with upregulation of the methanol utilisation pathway. This serves as a confirmation and validation of the array data obtained. Consistent with this, also various PEX genes were upregulated. The strong upregulation of ATG genes is possibly due to induction of autophagy processes related to remodeling of the cell architecture required to support growth on methanol. These processes may also be responsible for the enhanced peroxisomal beta-oxidation, as autophagy leads to recycling of membrane lipids. The prominent downregulation of transcription and translation may be explained by the reduced growth rate on methanol (td glucose 1 h vs td methanol 4.5 h).

An engineered yeast efficiently secreting penicillin

This study aimed at developing an alternative host for the production of penicillin (PEN). As yet, the industrial production of this beta-lactam antibiotic is confined to the filamentous fungus Penicillium chrysogenum. As such, the yeast Hansenula polymorpha, a recognized producer of pharmaceuticals, represents an attractive alternative. Introduction of the P. chrysogenum gene encoding the non-ribosomal peptide synthetase (NRPS) delta-(L-alpha-aminoadipyl)-L-cysteinyl-D-valine synthetase (ACVS) in H. polymorpha, resulted in the production of active ACVS enzyme, when co-expressed with the Bacillus subtilis sfp gene encoding a phosphopantetheinyl transferase that activated ACVS. This represents the first example of the functional expression of a non-ribosomal peptide synthetase in yeast. Co-expression with the P. chrysogenum genes encoding the cytosolic enzyme isopenicillin N synthase as well as the two peroxisomal enzymes isopenicillin N acyl transferase (IAT) and phenylacetyl CoA ligase (PCL) resulted in production of biologically active PEN, which was efficiently secreted. The amount of secreted PEN was similar to that produced by the original P. chrysogenum NRRL1951 strain (approx. 1 mg/L). PEN production was decreased over two-fold in a yeast strain lacking peroxisomes, indicating that the peroxisomal localization of IAT and PCL is important for efficient PEN production. The breakthroughs of this work enable exploration of new yeast-based cell factories for the production of (novel) beta-lactam antibiotics as well as other natural and semi-synthetic peptides (e.g. immunosuppressive and cytostatic agents), whose production involves NRPS's.

Improved gene disruption method and Cre-loxP mutant system for multiple gene disruptions in Hansenula polymorpha

In H. polymorpha, there is still a lack of a highly efficient gene disruption method. To help address this issue, we presented a simple and efficient method for both single and multiple gene disruptions in H. polymorpha. The knockout system combined a variation of sticky-end polymerase chain reaction method (SEP), split marker deletion method, co-transformation of single-stranded DNA and mutant Cre-loxP system. Using a slightly modified LiAc/SS-DNA/PEG procedure, the co-transformation double-stranded split marker constructs together with single-stranded split marker constructs resulted in at least 70% homologous recombination events when the homologous genomic DNA fragment had a size of approximately 500bp. Our evidence suggested that single-stranded DNA may be responsible for the increased gene disruption efficiency. We demonstrated the effectiveness of the method for gene disruption by constructing both single and double gene disruptions at the ALG3 and URA5 loci in the same genetic background. The method described here presents an improved strategy for gene disruption and a potential application for investigation of biological processes in other yeast strains.

Establishment of a simple and effective isolation method for cyanophycin from recombinant Saccharomyces cerevisiae

An efficient, time-saving, and cost-effective method for isolation of the polyamide cyanophycin from recombinant Saccharomyces cerevisiae was established. Due to its simple procedure, this isolation method may be also applicable at industrial scale and also to other intracellular compounds in this yeast. Production of cyanophycin gained preferential interest in the past, as degradation products thereof are of pharmaceutical and technical interest. Recently, it was shown that Saccharomyces cerevisiae represents a putative candidate for cyanophycin synthesis at industrial scale. For identification of optimal isolation procedures, several parameters such as heat stress, freeze drying, and freeze/thaw cycles of transgenic yeast cells were compared for their effectiveness of cyanophycin isolation. Additionally, optimal resuspension solutions for the applied cells and minimal required materials or chemicals were determined to make the process most environmentally and economically friendly. Maximal cyanophycin granule polypeptide yields of 21% (w/w) were obtained after incubation of dry cells at 70 degrees C or 80 degrees C and precipitation of the polymer with two volumes of ethanol.

The respiratory complexes I from the mitochondria of two Pichia species

NADH:ubiquinone oxidoreductase (complex I) is an entry point for electrons into the respiratory chain in many eukaryotes. It couples NADH oxidation and ubiquinone reduction to proton translocation across the mitochondrial inner membrane. Because complex I deficiencies occur in a wide range of neuromuscular diseases, including Parkinson's disease, there is a clear need for model eukaryotic systems to facilitate structural, functional and mutational studies. In the present study, we describe the purification and characterization of the complexes I from two yeast species, Pichia pastoris and Pichia angusta. They are obligate aerobes which grow to very high cell densities on simple medium, as yeast-like, spheroidal cells. Both Pichia enzymes catalyse inhibitor-sensitive NADH:ubiquinone oxidoreduction, display EPR spectra which match closely to those from other eukaryotic complexes I, and show patterns characteristic of complex I in SDS/PAGE analysis. Mass spectrometry was used to identify several canonical complex I subunits. Purified P. pastoris complex I has a particularly high specific activity, and incorporating it into liposomes demonstrates that NADH oxidation is coupled to the generation of a protonmotive force. Interestingly, the rate of NADH-induced superoxide production by the Pichia enzymes is more than twice as high as that of the Bos taurus enzyme. Our results both resolve previous disagreement about whether Pichia species encode complex I, furthering understanding of the evolution of complex I within dikarya, and they provide two new, robust and highly active model systems for study of the structure and catalytic mechanism of eukaryotic complexes I.

Expression of bovine follicle-stimulating hormone subunits in a Hansenula polymorpha expression system increases the secretion and bioactivity in vivo

Bovine follicle-stimulating hormone (bFSH), a pituitary gonadotropin, is a heterodimer hormone that consists of a common alpha-subunit non-covalently associated with the hormone-specific beta-subunit. Unfortunately, expression levels of recombinant bFSH or its subunits are invariably low. We report here the secretory expression of biologically active bFSHalpha and bFSHbeta subunit in the methylotrophic yeast Hansenula polymorpha. A slightly higher level of expression of recombinant bFSH subunits was achieved by using the Saccharomyces cerevisiae-derived calnexin (ScCne1) as a chaperone in engineered H. polymorpha strains. The preliminary data also suggested that bFSH subunits expressed in H. polymorpha appeared to be less-glycosylated. This isoform had been shown to be 80% increase in in vivo bioactivity compared with the hyperglycosylated Pichia pastoris-derived recombinant bFSHalpha/beta. More sophisticated applications of bFSH would profit from the assembled less-glycosylated heterodimer.

Metabolic engineering of Saccharomyces cerevisiae for production of novel cyanophycins with an extended range of constituent amino acids

Cyanophycin (multi-l-arginyl-poly-l-aspartic acid; also known as cyanophycin grana peptide [CGP]) is a putative precursor for numerous biodegradable technically used chemicals. Therefore, the biosynthesis and production of the polymer in recombinant organisms is of special interest. The synthesis of cyanophycin derivatives consisting of a wider range of constituents would broaden the applications of this polymer. We applied recombinant Saccharomyces cerevisiae strains defective in arginine metabolism and expressing the cyanophycin synthetase of Synechocystis sp. strain PCC 6308 in order to synthesize CGP with citrulline and ornithine as constituents. Strains defective in arginine degradation (Car1 and Car2) accumulated up to 4% (wt/wt) CGP, whereas strains defective in arginine synthesis (Arg1, Arg3, and Arg4) accumulated up to 15.3% (wt/wt) of CGP, which is more than twofold higher than the previously content reported in yeast and the highest content ever reported in eukaryotes. Characterization of the isolated polymers by different analytical methods indicated that CGP synthesized by strain Arg1 (with argininosuccinate synthetase deleted) consisted of up to 20 mol% of citrulline, whereas CGP from strain Arg3 (with ornithine carbamoyltransferase deleted) consisted of up to 8 mol% of ornithine, and CGP isolated from strain Arg4 (with argininosuccinate lyase deleted) consisted of up to 16 mol% lysine. Cultivation experiments indicated that the incorporation of citrulline or ornithine is enhanced by the addition of low amounts of arginine (2 mM) and also by the addition of ornithine or citrulline (10 to 40 mM), respectively, to the medium.

Process development in Hansenula polymorpha and Arxula adeninivorans, a re-assessment

A range of industrial H. polymorpha-based processes exist, most of them for the production of pharmaceuticals. The established industrial processes lean on the use of promoters derived from MOX and FMD, genes of the methanol metabolism pathway. In Hansenula polymorpha these promoters are de-repressed upon depletion of a range of carbon sources like glucose and glycerol instead of being induced by methanol as reported for other methylotrophs. Due to these characteristics screening and fermentation modes have been defined for strains harbouring such expression control elements that lean on a limited supplementation of glycerol or glucose to a culture medium. For fermentation of H. polymorpha a synthetic minimal medium (SYN6) has been developed. No industrial processes have been developed so far based on Arxula adeninivorans and only a limited range of strong promoter elements exists, suitable for heterologous gene expression. SYN6 originally designed for H. polymorpha provided a suitable basis for the initial definition of fermentation conditions for this dimorphic yeast. Characteristics like osmo- and thermotolerance can be addressed for the definition of culture conditions.

Synthesis and accumulation of cyanophycin in transgenic strains of Saccharomyces cerevisiae

Cyanophycin [multi-L-arginyl-poly(L-aspartic acid) (CGP)] was, for the first time, produced in yeast. As yeasts are very important production organisms in biotechnology, it was determined if CGP can be produced in two different strains of Saccharomyces cerevisiae. The episomal vector systems pESC (with the galactose-inducible promoter GAL1) and pYEX-BX (with the copper ion-inducible promoter CUP1) were chosen to express the cyanophycin synthetase gene from the cyanobacterium Synechocystis sp. strain PCC 6308 (cphA(6308)) in yeast. Expression experiments with transgenic yeasts revealed that the use of the CUP1 promoter is much more efficient for CGP production than the GAL1 promoter. As observed by electrophoresis of isolated CGP in sodium dodecyl sulfate-polyacrylamide gels, the yeast strains produced two different types of polymer: the water-soluble and the water-insoluble CGP were observed as major and minor forms of the polymer, respectively. A maximum CGP content of 6.9% (wt/wt) was detected in the cells. High-performance liquid chromatography analysis showed that the isolated polymers consisted mainly of the two amino acids aspartic acid and arginine and that, in addition, a minor amount (2 mol%) of lysine was present. Growth of transgenic yeasts in the presence of 15 mM lysine resulted in an incorporation of up to 10 mol% of lysine into CGP. Anti-CGP antibodies generated against CGP isolated from Escherichia coli TOP10 harboring cphA(6308) reacted with insoluble CGP but not with soluble CGP, if applied in Western or dot blots.

Uricase production by a recombinant Hansenula polymorpha strain harboring Candida utilis uricase gene

Uricase is an important medical enzyme which can be used to determine urate in clinical analysis, to therapy gout, hyperuricemia, and tumor lysis syndrome. Uricase of Candida utilis was successfully expressed in Hansenula polymorpha under the control of methanol oxidase promoter using Saccharomyces cerevisiae alpha-factor signal peptide as the secretory sequence. Recombinant H. polymorpha MU200 with the highest extracellular uricase production was characterized with three copies of expression cassette and selected for process optimization for the production of recombinant enzyme. Among the parameters investigated in shaking flask cultures, the pH value of medium and inoculum size had great influence on the recombinant uricase production. The maximum extracellular uricase yield of 2.6 U/ml was obtained in shaking flask culture. The yield of recombinant uricase was significantly improved by the combined use of a high cell-density cultivation technique and a pH control strategy of switching culture pH from 5.5 to 6.5 in the induction phase. After induction for 58 h, the production of recombinant uricase reached 52.3 U/ml (about 2.1 g/l of protein) extracellularly and 60.3 U/ml (about 2.4 g/l) intracellularly in fed-batch fermentation, which are much higher than those expressed in other expression systems. To our knowledge, this is the first report about the heterologous expression of uricase in H. polymorpha.

Yeast expression platforms

Yeasts provide attractive expression platforms. They combine ease of genetic manipulations and the option for a simple fermentation design of a microbial organism with the capabilities of an eukaryotic organism to secrete and to modify a protein according to a general eukaryotic scheme. For platform applications, a range of yeast species has been developed during the last decades. We present in the following review a selection of established and newly defined expression systems. The review is concluded by the description of a wide-range vector system that allows the assessment of the selected organisms in parallel for criteria like secretion or appropriate processing and modification in a given case.

Production of interleukin-6 inArxula adeninivorans, Hansenula polymorphaandSaccharomyces cerevisiaeby applying the wide-range yeast vector (CoMed™) system to simultaneous comparative assessment

A wide-range yeast vector (CoMed) system has been applied to the comparative assessment of three different yeast platforms for the production of human interleukin-6. A vector equipped with an rRNA gene targeting sequence and an Arxula adeninivorans-derived LEU2 gene was used for simultaneous transformation of auxotrophic A. adeninivorans, Hansenula polymorpha and Saccharomyces cerevisiae strains. IL6 was expressed under control of the strong constitutive A. adeninivorans-derived TEF1 promoter, which is functional in all yeast species analyzed so far. Secreted IL-6 was found to be correctly processed from an MFalpha1-IL6 precursor in A. adeninivorans only, whereas N-terminally truncated proteins were observed in H. polymorpha and S. cerevisiae.

A Saccharomyces cerevisiae autoselection system for optimised recombinant protein expression

Yeasts are attractive organisms for recombinant protein production. They combine highly developed genetic systems and ease of use with reductions in time and costs. We describe an autoselection system for recombinant protein expression in Saccharomyces cerevisiae which increases yields 5-10-fold compared to conditional selection for expression plasmids. Multicopy expression plasmids encoding essential MOB1 or CDC28 genes are absolutely necessary for the viability of host cells with mob1 or cdc28 deletions in their genomes. Such plasmids are stably maintained, even in rich medium, so optimising biomass production and yields of recombinant protein. Plasmid copy numbers are also increased by limiting selective MOB1 and CDC28 gene expression prior to induction. GST- or 6His-tagged proteins are produced for affinity purification and are expressed from a conditional GAL1-10 promoter to avoid potentially toxic effects of recombinant proteins on growth. Autoselection systems for expressing single or pairs of proteins are described. We demonstrate the versatility of this system by expressing proteins from a number of organisms and include several large and problematic products. The in vitro reconstruction of a step in mitotic regulation shows how this expression system can be successfully applied to the detailed analysis of complex metabolic pathways.

The Arxula adeninivorans ATAL gene encoding transaldolase-gene characterization and biotechnological exploitation

The yeast Arxula adeninivorans provides an attractive expression platform and can be exploited as gene source for biotechnologically interesting proteins. In the following study, a striking example for the combination of both aspects is presented. The transaldolase-encoding A. adeninivorans ATAL gene, including its promoter and terminator elements, was isolated and characterized. The gene includes a coding sequence of 963 bp encoding a putative 321 amino acid protein of 35.0 kDa. The enzyme characteristics analyzed from isolates of native strains and recombinant strains overexpressing the ATAL gene revealed a molecular mass of ca. 140 kDa corresponding to a tetrameric structure, a pH optimum of ca. 5.5, and a temperature optimum of 20 degrees C. The preferred substrates for the enzyme include D-erythrose-4-phosphate and D-fructose-6-phosphate, whereas D-glyceraldehyde is not converted. The ATAL expression level under salt-free conditions was observed to increase in media supplemented with 5% NaCl rendering the ATAL promoter attractive for moderate heterologous gene expression under high-salt conditions. Its suitability was assessed for the expression of a human serum albumin (HSA) reporter gene.

Structural Genomics

Drug discovery based on structural knowledge has proven useful as several structure-based medicines are already on the market. Structural genomics aims at studying a large number of gene products including whole genomes, topologically similar proteins, protein families and protein subtypes in parallel. Particularly, therapeutically relevant targets have been selected for structural genomics initiatives. In this context, integral membrane proteins, which represent 60–70% of the current drug targets, have been of major interest. Paradoxically, membrane proteins present the last frontier to conquer in structural biology as some 100 high resolution structures among the 30,000 entries in public structural databases are available. The modest success rate on membrane proteins relates to the difficulties in their expression, purification and crystallography. To facilitate technology development large networks providing expertise in molecular biology, protein biochemistry and structural biology have been established. The privately funded MePNet program has studied 100 G protein-coupled receptors, which resulted in high level expression of a large number of receptors at structural biology compatible levels. Currently, selected GPCRs have been purified and subjected to crystallization attempts

Glucose-induced production of recombinant proteins in Hansenulapolymorpha mutants deficient in catabolite repression

The most commonly used expression platform for production of recombinant proteins in the methylotrophic yeast Hansenula polymorpha relies on the strong and strictly regulated promoter from the gene encoding peroxisomal enzyme alcohol (or methanol) oxidase (P(MOX)). Expression from P(MOX) is induced by methanol and is partially derepressed in glycerol or xylose medium, whereas in the presence of hexoses, disaccharides or ethanol, it is repressed. The need for methanol for maximal induction of gene expression in large-scale fermentation is a significant drawback, as this compound is toxic, flammable, supports a slow growth rate and requires extensive aeration. We isolated H. polymorpha mutants deficient in glucose repression of P(MOX) due to an impaired HpGCR1 gene, and other yet unidentified secondary mutations. The mutants exhibited pronounced defects in P(MOX) regulation only by hexoses and xylose, but not by disaccharides or ethanol. With one of these mutant strains as hosts, we developed a modified two-carbon source mode expression platform that utilizes convenient sugar substrates for growth (sucrose) and induction of recombinant protein expression (glucose or xylose). We demonstrate efficient regulatable by sugar carbon sources expression of three recombinant proteins: a secreted glucose oxidase from the fungus Aspergillus niger, a secreted mini pro-insulin, and an intracellular hepatitis B virus surface antigen in these mutant hosts. The modified expression platform preserves the favorable regulatable nature of P(MOX) without methanol, making a convenient alternative to the traditional system.

Application of a wide-range yeast vector (CoMed) system to recombinant protein production in dimorphic Arxula adeninivorans, methylotrophic Hansenula polymorpha and other yeasts

BACKGROUND

Yeasts provide attractive expression platforms in combining ease of genetic manipulation and fermentation of a microbial organism with the capability to secrete and to modify proteins according to a general eukaryotic scheme. However, early restriction to a single yeast platform can result in costly and time-consuming failures. It is therefore advisable to assess several selected systems in parallel for the capability to produce a particular protein in desired amounts and quality. A suitable vector must contain a targeting sequence, a promoter element and a selection marker that function in all selected organisms. These criteria are fulfilled by a wide-range integrative yeast expression vector (CoMed) system based on A. adeninivorans- and H. polymorpha-derived elements that can be introduced in a modular way.

RESULTS

The vector system and a selection of modular elements for vector design are presented. Individual single vector constructs were used to transform a range of yeast species. Various successful examples are described. A vector with a combination of an rDNA sequence for genomic targeting, the E. coli-derived hph gene for selection and the A. adeninivorans-derived TEF1 promoter for expression control of a GFP (green fluorescent protein) gene was employed in a first example to transform eight different species including Hansenula polymorpha, Arxula adeninivorans and others. In a second example, a vector for the secretion of IL-6 was constructed, now using an A. adeninivorans-derived LEU2 gene for selection of recombinants in a range of auxotrophic hosts. In this example, differences in precursor processing were observed: only in A. adeninivorans processing of a MFalpha1/IL-6 fusion was performed in a faithful way.

CONCLUSION

rDNA targeting provides a tool to co-integrate up to 3 different expression plasmids by a single transformation step. Thus, a versatile system is at hand that allows a comparative assessment of newly introduced metabolic pathways in several organisms or a comparative co-expression of bottleneck genes in cases where production or secretion of a certain product is impaired.

Yeast and filamentous fungi as model organisms in microbody research

Yeast and filamentous fungi are important model organisms in microbody research. The value of these organisms as models for higher eukaryotes is underscored by the observation that the principles of various aspects of microbody biology are strongly conserved from lower to higher eukaryotes. This has allowed to resolve various peroxisome-related functions, including peroxisome biogenesis disorders in man. This paper summarizes the major advances in microbody research using fungal systems and specifies specific properties and advantages/disadvantages of the major model organisms currently in use.

The significance of peroxisomes in methanol metabolism in methylotrophic yeast

The capacity to use methanol as sole source of carbon and energy is restricted to relatively few yeast species. This may be related to the low efficiency of methanol metabolism in yeast, relative to that of prokaryotes. This contribution describes the details of methanol metabolism in yeast and focuses on the significance of compartmentalization of this metabolic pathway in peroxisomes.

Construction of an Arxula adeninivorans host-vector system based on trp1 complementation

A host/vector expression system based on an Arxula adeninivorans Delta atrp1 gene disruption mutant has been constructed. For this purpose the ATRP1 gene encoding a phosphoribosyl anthranilate isomerase was isolated from the yeast A. adeninivorans and its genome locus was characterized. The Delta atrp1 mutant was generated applying an amplified DNA fragment containing the ALEU2m gene flanked by ATRP1 gene sequences of some 750 bp. The generated auxotrophic host strain was transformed with the plasmid pAL-ATRP1-amyA, which contains the ATRP1 gene as selection marker and the 25S rDNA for targeting. For expression assessment, the plasmid was equipped with an expression cassette consisting of the Bacillus amyloliquefaciens-derived amyA gene fused to the constitutive A. adeninivorans-derived TEF1 promoter and Saccharomyces cerevisiae-derived PHO5 terminator. Transformants contained a single chromosomal copy of the heterologous DNA and were found to be mitotically stable. In initial fermentation trials on a 200 ml shake flask scale maximal alpha-amylase product levels of ca. 300 nkat ml(-1) were observed after 72 h of cultivation with more than 95% of the recombinant alpha-amylase accumulated in the culture medium.

Select what you need: a comparative evaluation of the advantages and limitations of frequently used expression systems for foreign genes

The expression of heterologous proteins in microorganisms using genetic recombination is still the high point in the development and exploitation of modern biotechnology. People can produce bioactive proteins from relatively cheap culture medium instead of expensive extraction. Host cell systems for the expression of heterologous genes are generally prokaryotic or eukaryotic systems, both of which have inherent advantages and drawbacks. An optimal expression system can be selected only if the productivity, bioactivity, purpose, and physicochemical characteristics of the interest protein are taken into consideration, together with the cost, convenience and safety of the system itself. Here, we concisely review the most frequently used prokaryotic, yeast, insect and mammalian expression systems, as well as expression in eukaryote individuals. The merits and demerits of these systems are discussed.

Assessment of Hansenula polymorpha and Arxula adeninivorans-derived rDNA-targeting elements for the design of Arxula adeninivorans expression vectors

Different targeting sequences derived from the Arxula adeninivorans and Hansenula polymorpha rDNA clusters were tested in A. adeninivorans integration/expression vectors. For element identification, the rDNA unit of A. adeninivorans (accession number ) was first isolated and characterized in addition to the known H. polymorpha unit. The rDNA is a cluster of some forty 7653-bp units without the 5S rDNA gene. The selected elements were integrated into a set of A. adeninivorans expression/integration vectors harbouring a TEF1 promoter - amyA ORF - PHO5 terminator sequence as reporter gene. No differences in mitotic stability, copy number and transformation frequency were observed. All transformants harboured a single copy integrated into the rDNA by a homologous recombination. In contrast, the choice of the rDNA targeting sequence was found to be of impact on productivity. Use of ETS-18S-5.8S fragments from both organisms resulted in a more than 50% increase in comparison to the use of other elements, independent of the orientation within the vector.