Purification and identification of components of gamma-oryzanol in rice bran Oil

The effects of hydroxycinnamic acid derivatives on adiponectin secretion

Adiponectin is positively correlated with insulin sensitivity. Hydroxycinnamic acid derivatives (HADs), observed ubiquitously in plants, have some physiological functions. In this study, we investigated the effect of HADs on serum adiponectin concentrations in mice and on adiponectin secretion of 3T3-L1 adipocytes. In mice, serum adiponectin concentrations were increased by gamma-oryzanol administration. CAPE, curcumin, and trans-ferulic acid markedly enhanced the adiponectin secretion of 3T3-L1 adipocytes, but not gamma-oryzanol. To clarify the effects of gamma-oryzanol in mice or the effects of HADs on the underlying mechanisms of adiponectin secretion, we further investigated the effect of HADs on adiponectin secretion in the NF-kappaB activation state. Although the adiponectin secretion was reduced in the presence of lipopolysaccharide plus TNF-alpha and IFN-gamma, only gamma-oryzanol supported the activity of adiponectin secretion under NF-kappaB activated condition. The results indicate that these HADs might regulate adiponectin secretion by the inhibition of NF-kappaB activation. HADs might be effective for ameliorating type 2 diabetes.

Lipophilic and hydrophilic antioxidants and their antioxidant activities in purple rice bran

Purple rice bran was separated and collected at two different milling periods, resulting in two bran (outer and inner layer) fractions. The distribution of lipophilic and hydrophilic antioxidants and their antioxidant activities in the two fractions were studied. The bran fractions were extracted with hexane followed by methanol to obtain lipophilic and hydrophilic extracts, respectively. The total phenolic content and free radical scavenging activity of the extracts were determined and compared. The lipophilic extract from the outer bran fraction (OBF) exhibited a lower level of total tocols and gamma-tocols, compared with the inner bran fraction (IBF), while the levels of gamma-oryzanol in both fractions were not different. However, the lipophilic phenolic content and free radial scavenging activity of the OBF were 6.0 microg catechin equivalent (CE)/g and 5.6 micromol trolox equivalent (TE)/g and higher than those of the IBF, respectively. For the hydrophilic extracts, the level of anthocyanins in the IBF (29.0 mg/g) was 8 times higher than that in the OBF. Also, the hydrophilic phenolic content and free radical scavenging activity of the IBF were 489.1 microg CE/g and 433.6 micromol TE/g, respectively, while they were 113.9 microg CE/g and 78.2 micromol TE/g in the OBF. Both hydrophilic extracts showed significantly higher phenolic content and free radical scavenging activity than any lipophilic extract. The results of this study indicated that the activity of purple rice bran hydrophilic antioxidants was much greater than that of its lipophilic antioxidants and anthocyanins and gamma-tocols largely located in the inner portion of purple rice bran.

Metabolite profiling of germinating rice seeds

A metabolite profiling approach based on gas chromatography-mass spectrometry (GC-MS) was used to investigate time-dependent metabolic changes in the course of the germination of rice. Brown rice kernels were soaked and incubated for a total of 96 h under ambient conditions. Samples taken during the germination process were subjected to an extraction and fractionation procedure covering a broad spectrum of lipophilic (e.g., fatty acid methyl esters, hydrocarbons, fatty alcohols, sterols) and hydrophilic (e.g., sugars, acids, amino acids, amines) low molecular weight rice constituents. Investigation of the obtained fractions by GC resulted in the detection of 615 distinct peaks, of which 174 were identified by means of MS. Statistical assessment of the data via principal component analysis demonstrated that the metabolic changes during the germination process are reflected by time-dependent shifts of the scores, which were similar for the three rice materials investigated. Analysis of the corresponding loadings showed that polar metabolites were major contributors to the separation along the first principal component. Relative quantifications based on standardized peak heights revealed dynamic changes of the metabolites in the course of the germination.

The effect of trans-ferulic acid and gamma-oryzanol on ethanol-induced liver injury in C57BL mouse

The effects of the oral administration of trans-ferulic acid and gamma-oryzanol (mixture of steryl ferulates) with ethanol (5.0 g per kg) for 30 days to c57BL mice on ethanol-induced liver injury were investigated. Preventions of ethanol-induced liver injury by trans-ferulic acid and gamma-oryzanol were reflected by markedly decreased serum activities of plasma aspartate aminotransferase, alanine aminotransferase and significant decreases in hepatic lipid hydroperoxide and TBARS levels. Furthermore, the trans-ferulic acid- and gamma-oryzanol-treated mice recovered ethanol-induced decrease in hepatic glutathione level together with enhancing superoxide dismutase activity. These results demonstrate that both trans-ferulic acid and gamma-oryzanol exert a protective action on liver injury induced by chronic ethanol ingestion.

Determination of antioxidant components in rice bran oil extracted by microwave-assisted method

Rice bran oil was extracted by microwave-assisted extraction with isopropanol and hexane using a solvent-to-rice bran ratio of 3:1 (w/w). The experiments were done in triplicate at 40, 60, 80, 100, and 120 degrees C with a total extraction time of 15 min/sample. The oil components were separated by normal-phase HPLC and quantified with a fluorescence detector. The radical scavenging capability of the oil was tested with DPPH and was expressed as mumol Trolox Equivalent Antioxidant Activity. The increase in total vitamin E with temperature from 40 to 120 degrees C was 59.63% for isopropanol and 342.01% for hexane. Isopropanol was the best solvent for the extraction of gamma-tocopherol and gamma-tocotrienol as compared with hexane for both microwave-assisted and conventional solvent extraction. Isopropanol was better for oil yield extraction at high temperatures. Samples extracted with isopropanol at 120 degrees C had higher antioxidant activity. No differences in oil yield, total vitamin E, and antioxidant activity of oil was noticed between the two methods (microwave-assisted and solvent extractions), at 40 degrees C. No degradation of alpha-tocopherol was noticed during the process.

Anti-inflammatory effects of phytosteryl ferulates in colitis induced by dextran sulphate sodium in mice

BACKGROUND AND PURPOSE

We have recently reported that phytosteryl ferulates isolated from rice bran inhibit nuclear factor-kappaB (NF-kappaB) activity in macrophages. In the present study, we investigated the effect of gamma-oryzanol (gamma-ORZ), a mixture of phytosteryl ferulates, cycloartenyl ferulate (CAF), one of the components of gamma-ORZ, and ferulic acid (FA), a possible metabolite of gamma-ORZ in vivo, on a model of colitis in mice.

EXPERIMENTAL APPROACH

We induced colitis with dextran sulphate sodium (DSS) in mice and monitored disease activity index (DAI), histopathology score, tissue myeloperoxidase (MPO) activity, mRNA expressions of cytokines and COX-2, colon length, antioxidant potency and NF-kappaB activity in colitis tissue.

KEY RESULTS

Both DAI and histopathology score revealed that DSS induced a severe mucosal colitis, with a marked increase in the thickness of the muscle layer, distortion and loss of crypts, depletion of goblet cells and infiltration of macrophages, granulocytes and lymphocytes. MPO activity, pro-inflammatory cytokines and COX-2 levels, NF-kappaB p65 nuclear translocation and inhibitory protein of nuclear factor-kappaB-alpha degradation levels were significantly increased in DSS-induced colitis tissues. gamma-ORZ (50 mg kg(-1) day(-1) p.o.) markedly inhibited these inflammatory reactions and CAF had a similar potency. In vitro assay demonstrated that gamma-ORZ and CAF had strong antioxidant effects comparable to those of alpha-tocopherol.

CONCLUSIONS AND IMPLICATIONS

Phytosteryl ferulates could be new potential therapeutic and/or preventive agents for gastrointestinal inflammatory diseases. Their anti-inflammatory effect could be mediated by inhibition of NF-kappaB activity, which was at least partly due to the antioxidant effect of the FA moiety in the structure of phytosteryl ferulates.

The effect of cetyl palmitate crystallinity on physical properties of gamma-oryzanol encapsulated in solid lipid nanoparticles

This present study was aimed at investigating the effect of the crystallinity of cetyl palmitate based solid lipid nanoparticles (SLNs) on the physical properties of γ-oryzanol-loaded SLNs. SLNs consisting of varying ratios of cetyl palmitate and γ-oryzanol were prepared. Their hydrodynamic diameters were in the range 210-280 nm and the zeta potentials were in the range -27 to -35 mV. The size of SLNs increased as the amount of cetyl palmitate decreased whereas no significant change of zeta potentials was found. Atomic force microscopy pictures indicated the presence of disc-like particles. The crystallinity of SLNs, determined by differential scanning calorimetry and powder x-ray diffraction, was directly dependent on the ratio of cetyl palmitate to γ-oryzanol and decreased with decreasing cetyl palmitate content in the lipid matrix. Varying this ratio in the lipid mix resulted in a shift in the melting temperature and enthalpy, although the SLN structure remained unchanged as an orthorhombic lamellar lattice. This has been attributed to a potential inhibition by γ-oryzanol during lipid crystal growth as well as a less ordered structure of the SLNs. The results revealed that the crystallinity of the SLNs was mainly dependent on the solid lipid, and that the crystallinity has an important impact on the physical characteristics of active-loaded SLNs.

Fractionation of the rice bran layer and quantification of vitamin E, oryzanol, protein, and rice bran saccharide

Value-added processing with respect to rice milling has traditionally treated the rice bran layer as a homogenous material that contains significant concentrations of high-value components of interest for pharmaceutical and nutraceutical applications. Investigators have shown that high-value components in the rice bran layer vary from differences in kernel-thickness, bran fraction, rice variety, and environmental conditions during the growing season. The objectives of this study were to quantify the amount of rice bran removed at pre-selected milling times and to correlate the amount of rice bran removed at each milling time with the concentration of vitamin E, gamma-oryzanol, rice bran saccharide, and protein obtained. The ultimate goal of this research is to show that rice bran fractionation is a useful method to obtain targeted, nutrient-rich bran samples for value-added processing. Two long grain rice cultivars, Cheniere and Cypress, were milled at discrete times between 3 and 40 seconds using a McGill mill to obtain bran samples for analysis. Results showed that the highest oryzanol and protein concentrations were found in the outer portion of the rice bran layer, while the highest rice bran saccharide concentration was found in the inner portion of the bran layer. Vitamin E concentration showed no significant difference across the bran layer within a variety, though the highest magnitude of concentration occurs within the first 10 seconds of milling for both varieties. To extract the higher concentration of oryzanol and protein only the outer portion of the bran layer requires processing, while to extract the higher concentration of rice bran saccharide, only the inner portion of the bran layer requires processing. Rice bran fractionation allows for the selective use of portions of the bran layer and is advantageous for two reasons: (1) bran fractions contain higher concentrations of components of interest with respect to the overall bran layer average, and (2) less bran needs to be processed to obtain components of interest.

A new method for simultaneous estimation of unsaponifiable constituents of rice bran oil using HPTLC

Rice bran oil (RBO) is rich in a variety of bioactive phytochemicals otherwise known as unsaponifiable constituents (USC). Oryzanols, phytosterols, tocols, etc. are the major USC in RBO; the methods presently used for their estimation involve different techniques and require pretreatment of the sample. In this paper standardization of a simple method for simultaneous estimation of USC directly from RBO using HPTLC is presented. The method involves a two-stage separation of USC on a precoated silica gel 60 F(254 )TLC plate viz.: TLC-1 to separate sterols, oryzanols and tocols; TLC-2 to separate steryl esters, wax, and squalene. Calibration plots using the respective standards were made to determine LOD, LOQ, and linear regression equations. Recovery studies were also conducted and the values ranged from 93.45 to 101.97%. The LOD and LOQ values showed the sensitivity of the method. The instrumental precision was found to be in the range of 0.30 to 1.18 CV%. Quantitative estimation of USC in crude RBO and refined RBO using this method gave a concentration of 52.80 mg/g of USC in the crude and 33.48 mg/g in the refined oil. The present method for estimation of USC using HPTLC is fast, simple, accurate, precise, and sensitive, as demonstrated here.

Characterization of antioxidant compounds of red and white rice and changes in total antioxidant capacity during processing

Although most rice cultivars have whitish kernel, some varieties have a red testa. Aim of this work was to compare the total antioxidant capacity (TAC) and the antioxidant chemical composition (namely tocols, gamma-oryzanols, and polyphenols) of red and white rices. In addition, the effect of milling and cooking on antioxidants was investigated in both rices. Dehulled red rice showed a TAC more than three times greater than dehulled white rice and its high TAC was essentially characterized by the presence of proanthocyanidins (PA) and associated phenolics. Milling caused a significant loss of TAC, even if red rice maintained a higher TAC. Cooking caused a further loss of antioxidants, but when there was a full uptake of cooking water by the grains ("risotto") this loss was limited. Thus, the consumption of whole or partially milled rice cooked as risotto would be preferred to preserve its nutritional properties.

A 90-day safety study in Wistar rats fed genetically modified rice expressing snowdrop lectin Galanthus nivalis (GNA)

Genetically modified plants expressing insecticidal traits offer a new strategy for crop protection, but at the same time present a challenge in terms of food safety assessment. The present 90-day feeding study was designed to assess the safety of a rice variety expressing the snowdrop Galanthus nivalis lectin (GNA lectin), and forms part of a EU-funded project where the objective has been to develop and validate sensitive and specific methods to assess the safety of genetically modified foods. Male and female Wistar rats were given a purified diet containing either 60% genetically modified or parental rice for 90 days. This corresponds to a mean daily GNA lectin intake of approximately 58 and 67mg/kg body weight for males and females, respectively. Prior to the animal study comprehensive analytical characterization of both rice materials was performed. The chemical analyses showed a number of statistically significant differences, with the majority being within the ranges reported in the literature. In the animal study a range of clinical, biological, immunological, microbiological and pathological parameters were examined. A number of significant differences were seen between groups fed the two diets, but none of them were considered to be adverse. In conclusion, the design of the present animal study did not enable us to conclude on the safety of the GM food. Additional group(s) where the expressed gene products have been spiked to the diet should be included in order to be able to distinguish whether the observed effects were due to the GNA lectin per se or to secondary changes in the GM rice.

Safety testing of GM-rice expressing PHA-E lectin using a new animal test design

The 90-day animal study is the core study for the safety assessment of genetically modified foods in the SAFOTEST project. The model compound tested in the 90-day study was a rice variety expressing the kidney bean Phaseolus vulgaris lectin agglutinin E-form (PHA-E lectin). Female Wistar rats were given a nutritionally balanced purified diet with 60% parental rice, 60% PHA-E rice or 60% PHA-E rice spiked with 0.1% recombinant PHA-E lectin for 90 days. This corresponded to a mean daily PHA-E lectin intake of approximately 0, 30 and 100mg/kg body weight for each group, respectively. The spiking was used to increase the specificity and to demonstrate the sensitivity of the study. A range of biological, biochemical, microbiological and pathological parameters were examined and significant differences in weight of small intestine, stomach and pancreas and plasma biochemistry were seen between groups. Included in this paper are also data from the molecular characterisation and chemical analysis of the PHA-E rice, from the construction and production of the PHA-E lectin, and from the preceding 28-day in vivo study where the toxicity of the pure PHA-E lectin was determined. In conclusion, the combined use of information from the compositional analysis, the 28-day study and the characterisation of the PHA-E rice and the PHA-E lectin has improved the design of the 90-day study. The spiking procedure has facilitated the interpretation of the results of the study and transferred it into a valuable tool for the future safety testing of genetically modified foods.

A 90-day safety study of genetically modified rice expressing Cry1Ab protein (Bacillus thuringiensis toxin) in Wistar rats

An animal model for safety assessment of genetically modified foods was tested as part of the SAFOTEST project. In a 90-day feeding study on Wistar rats, the transgenic KMD1 rice expressing Cry1Ab protein was compared to its non-transgenic parental wild type, Xiushui 11. The KMD1 rice contained 15mg Bt toxin/kg and based on the average feed consumption the daily intake was 0.54mg Bt toxin/kg body weight. No adverse effects on animal behaviour or weight gain were observed during the study. Blood samples collected one week prior to sacrifice were analyzed and compared for standard haematological and biochemical parameters. A few parameters were significantly different, but all within the normal reference intervals for rats of this breed and age and not in relation to any other findings, thus not considered treatment related. Upon sacrifice a large number of organs were weighed, macroscopic and histopathological examinations were performed with only minor changes to report. The aim of the study was to use a known animal model in performance of safety assessment of a GM crop, in this case KMD1 rice. The results show no adverse or toxic effects of KMD1 rice when tested in the design used in this 90-day study. Nevertheless the experiences from this study lead to the overall conclusion that safety assessment for unintended effects of a GM crop cannot be done without additional test group(s).

Simultaneous determination of carotenoids, tocopherols, and gamma-oryzanol in crude rice bran oil by liquid chromatography coupled to diode array and mass spectrometric detection employing silica C30 stationary phases

Crude rice bran oil contains tocopherols (vitamin E), carotenoids (vitamin A), and phytosterols, which possess antioxidant activities and show promising effects as preventive and therapeutic agents. The aim of this work was to establish methods and to compare C18 and C30 silica stationary phases in order to separate and detect tocopherols, carotenoids, and gamma-oryzanol in one single run. Comparing RP-LC on silica C18 and C30, higher resolution between all target compounds was obtained using the C30 stationary phase. Methanol was used as eluent and the elution strength was increased by the addition of tert-butyl methyl ether for highly hydrophobic analytes such as gamma-oryzanol. Detection was accomplished by diode array detection from 200 to 500 nm. Absorbance maxima were found at 295 nm for tocopherols, 324 nm for gammaoryzanol, and 450 nm for carotenoids. Furthermore, compounds were characterized and identified on the basis of their UV-spectra. Both RP systems were coupled to MS (LC-MS) by using an atmospheric pressure chemical ionization interface.

Phenolics in cereals, fruits and vegetables: Occurrence, extraction and analysis

Consumption of plant foods, particularly fruits, vegetables and cereal grains is encouraged because they render beneficial health effects. Phenolics and polyphenolics are among the most desirable food bioactives because of their antioxidant activity, brought about by a number of pathways, or due to other mechanisms. The analysis of phenolics and polyphenolics requires their extraction possible purification and structure elucidation. This overview provides a cursory account of the source, extraction and analysis of phenolics in fruits, vegetables and cereals.

Antioxidant activity of gamma-oryzanol: mechanism of action and its effect on oxidative stability of pharmaceutical oils

Gamma-oryzanol, a phytosteryl ferulate mixture extracted from rice bran oil, has a wide spectrum of biological activities; in particular, it has antioxidant properties and is often used in cosmetic formulations as a sunscreen. The first objective of the present investigation was to elucidate the molecular mechanism(s) of the antioxidant activity of gamma-oryzanol by utilising different in vitro model systems, such as scavenging of stable DPPH radical, OH and O2- radicals scavenging, and azocompound AMVN-initiated lipid peroxidation. The effect of gamma-oryzanol on the oxidative stability of vegetable oils of pharmaceutical and cosmetic interest was then evaluated in a oxidation accelerate test and compared with the effect of the well-known antioxidants BHA and BHT. Our results demonstrate that gamma-oryzanol is an organic radical scavenger able to prevent AMVN-triggered lipoperoxidation. Moreover, when added to oils at concentrations ranging between 2.5 and 10 mmol/kg, gamma-oryzanol shows a dose-dependent increase of the induction times; in particular, it improved the oxidative stability of oils very prone to lipoperoxidation because of their high content of polyunsaturated fatty acids. On the ground of our results, we can conclude that gamma-oryzanol may have a potential application for the stabilization of lipidic raw materials.

Off-line coupling of non-aqueous reversed-phase and silver ion high-performance liquid chromatography–mass spectrometry for the characterization of rice oil triacylglycerol positional isomers

The determination of the triacylglycerol (TAG) profile in real world matrices is rather difficult as these compounds present a complex composition and are characterized by similar physico-chemical properties. This investigation is based on the high-performance liquid chromatography (HPLC) multidimensional determination of the TAG profile in terms of TAG species and positional isomers in a rice oil sample. The off-line bi-dimensional system was attained through the coupling of non-aqueous reversed-phase HPLC and silver ion (Ag)-HPLC. The primary column eluate was fractionated and the fractions of interest were then injected onto the secondary column, allowing the separation of several TAG positional isomers, unresolved in the first dimension. Peak assignment was carried out by combining retention data with atmospheric pressure chemical ionisation (APCI) MS spectra information. The fatty acid distribution along the glycerol backbone, determined by Ag-HPLC, was confirmed through diglyceride ion ratios derived from APCI-MS analysis. Method validation, where both precision and accuracy were measured, was carried out in preliminary applications on standard compounds. The analytical results obtained show that rice oil TAGs follow a distribution which can be considered typical for vegetable oils.