1
|
Sha S, Bhatia H, Yoon S. An RNA-seq based transcriptomic investigation into the productivity and growth variants with Chinese hamster ovary cells. J Biotechnol 2018; 271:37-46. [DOI: 10.1016/j.jbiotec.2018.02.008] [Citation(s) in RCA: 18] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/13/2017] [Revised: 01/26/2018] [Accepted: 02/19/2018] [Indexed: 02/06/2023]
|
2
|
Zou W, Edros R, Al-Rubeai M. The relationship of metabolic burden to productivity levels in CHO cell lines. Biotechnol Appl Biochem 2017; 65:173-180. [PMID: 28681393 DOI: 10.1002/bab.1574] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/26/2017] [Accepted: 06/29/2017] [Indexed: 01/08/2023]
Abstract
The growing demand for recombinant therapeutics has driven biotechnologists to develop new production strategies. One such strategy for increasing the expression of heterologous proteins has focused on enhancing cell-specific productivity through environmental perturbations. In this work, the effects of hypothermia, hyperosmolarity, high shear stress, and sodium butyrate treatment on growth and productivity were studied using three (low, medium, and high producing) CHO cell lines that differed in their specific productivities of monoclonal antibody. In all three cell lines, the inhibitory effect of these parameters on proliferation was demonstrated. Additionally, compared to the control, specific productivity was enhanced under all conditions and exhibited a consistent cell line specific pattern, with maximum increases (50-290%) in the low producer, and minimum increases (7-20%) in the high producer. Thus, the high-producing cell line was less responsive to environmental perturbations than the low-producing cell line. We hypothesize that this difference is most likely due to the bottleneck associated with a higher metabolic burden caused by higher antibody expression. Increased recombinant mRNA levels and pyruvate carboxylase activities due to low temperature and hyperosmotic stress were found to be positively associated with the metabolic burden.
Collapse
Affiliation(s)
- Wu Zou
- School of Chemical and Bioprocess Engineering, and Conway Institute of Biomolecular and Biomedical Research, University College Dublin, Dublin, Ireland
| | - Raihana Edros
- School of Chemical and Bioprocess Engineering, and Conway Institute of Biomolecular and Biomedical Research, University College Dublin, Dublin, Ireland
| | - Mohamed Al-Rubeai
- School of Chemical and Bioprocess Engineering, and Conway Institute of Biomolecular and Biomedical Research, University College Dublin, Dublin, Ireland
| |
Collapse
|
3
|
Vishwanathan N, Le H, Le T, Hu WS. Advancing biopharmaceutical process science through transcriptome analysis. Curr Opin Biotechnol 2014; 30:113-9. [DOI: 10.1016/j.copbio.2014.06.011] [Citation(s) in RCA: 19] [Impact Index Per Article: 1.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/01/2014] [Revised: 06/13/2014] [Accepted: 06/13/2014] [Indexed: 01/02/2023]
|
4
|
Brodsky AN, Caldwell M, Bae S, Harcum SW. Glycosylation-related genes in NS0 cells are insensitive to moderately elevated ammonium concentrations. J Biotechnol 2014; 187:78-86. [PMID: 25062658 PMCID: PMC4197068 DOI: 10.1016/j.jbiotec.2014.07.018] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.4] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/14/2014] [Revised: 07/05/2014] [Accepted: 07/15/2014] [Indexed: 10/25/2022]
Abstract
NS0 and Chinese hamster ovary (CHO) cell lines are used to produce recombinant proteins for human therapeutics; however, ammonium accumulation can negatively impact cell growth, recombinant protein production, and protein glycosylation. To improve product quality and decrease costs, the relationship between ammonium and protein glycosylation needs to be elucidated. While ammonium has been shown to adversely affect glycosylation-related gene expression in CHO cells, NS0 studies have not been performed. Therefore, this study sought to determine if glycosylation in NS0 cells were ammonium-sensitive at the gene expression level. Using a DNA microarray that contained mouse glycosylation-related and housekeeping genes, these genes were analyzed in response to various culture conditions - elevated ammonium, elevated salt, and elevated ammonium with proline. Surprisingly, no significant differences in gene expression levels were observed between the control and these conditions. Further, the elevated ammonium cultures were analyzed using real-time quantitative reverse transcriptase PCR (qRT-PCR) for key glycosylation genes, and the qRT-PCR results corroborated the DNA microarray results, demonstrating that NS0 cells are ammonium-insensitive at the gene expression level. Since NS0 are known to have elevated nucleotide sugar pools under ammonium stress, and none of the genes directly responsible for these metabolic pools were changed, consequently cellular control at the translational or substrate-level must be responsible for the universally observed decreased glycosylation quality under elevated ammonium.
Collapse
Affiliation(s)
- Arthur Nathan Brodsky
- Department of Bioengineering, 301 Rhodes Research Center, Clemson University, Clemson, SC 29634-0905, USA.
| | - Mary Caldwell
- Department of Bioengineering, 301 Rhodes Research Center, Clemson University, Clemson, SC 29634-0905, USA.
| | - Sooneon Bae
- Department of Bioengineering, 301 Rhodes Research Center, Clemson University, Clemson, SC 29634-0905, USA.
| | - Sarah W Harcum
- Department of Bioengineering, 301 Rhodes Research Center, Clemson University, Clemson, SC 29634-0905, USA.
| |
Collapse
|
5
|
Nasseri SS, Ghaffari N, Braasch K, Jardon MA, Butler M, Kennard M, Gopaluni B, Piret JM. Increased CHO cell fed-batch monoclonal antibody production using the autophagy inhibitor 3-MA or gradually increasing osmolality. Biochem Eng J 2014. [DOI: 10.1016/j.bej.2014.06.027] [Citation(s) in RCA: 12] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/17/2022]
|
6
|
Azevedo NF, Bragança SM, Simões LC, Cerqueira L, Almeida C, Keevil CW, Vieira MJ. Proposal for a method to estimate nutrient shock effects in bacteria. BMC Res Notes 2012; 5:422. [PMID: 22873690 PMCID: PMC3490807 DOI: 10.1186/1756-0500-5-422] [Citation(s) in RCA: 11] [Impact Index Per Article: 0.9] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/07/2012] [Accepted: 07/12/2012] [Indexed: 11/10/2022] Open
Abstract
BACKGROUND Plating methods are still the golden standard in microbiology; however, some studies have shown that these techniques can underestimate the microbial concentrations and diversity. A nutrient shock is one of the mechanisms proposed to explain this phenomenon. In this study, a tentative method to assess nutrient shock effects was tested. FINDINGS To estimate the extent of nutrient shock effects, two strains isolated from tap water (Sphingomonas capsulata and Methylobacterium sp.) and two culture collection strains (E. coli CECT 434 and Pseudomonas fluorescens ATCC 13525) were exposed both to low and high nutrient conditions for different times and then placed in low nutrient medium (R2A) and rich nutrient medium (TSA).The average improvement (A.I.) of recovery between R2A and TSA for the different times was calculated to more simply assess the difference obtained in culturability between each medium. As expected, A.I. was higher when cells were plated after the exposition to water than when they were recovered from high-nutrient medium showing the existence of a nutrient shock for the diverse bacteria used. S. capsulata was the species most affected by this phenomenon. CONCLUSIONS This work provides a method to consistently determine the extent of nutrient shock effects on different microorganisms and hence quantify the ability of each species to deal with sudden increases in substrate concentration.
Collapse
Affiliation(s)
- Nuno F Azevedo
- LEPAE, Department of Chemical Engineering, Faculty of Engineering, University of Porto, Rua Roberto Frias, 4200-465, Porto, Portugal
- IBB-Institute for Biotechnology and Bioengineering, Centre for Biological Engineering, Universidade do Minho, Campus de Gualtar, 4710-057, Braga, Portugal
| | - Sofia M Bragança
- IBB-Institute for Biotechnology and Bioengineering, Centre for Biological Engineering, Universidade do Minho, Campus de Gualtar, 4710-057, Braga, Portugal
| | - Lúcia C Simões
- IBB-Institute for Biotechnology and Bioengineering, Centre for Biological Engineering, Universidade do Minho, Campus de Gualtar, 4710-057, Braga, Portugal
| | - Laura Cerqueira
- IBB-Institute for Biotechnology and Bioengineering, Centre for Biological Engineering, Universidade do Minho, Campus de Gualtar, 4710-057, Braga, Portugal
| | - Carina Almeida
- LEPAE, Department of Chemical Engineering, Faculty of Engineering, University of Porto, Rua Roberto Frias, 4200-465, Porto, Portugal
- IBB-Institute for Biotechnology and Bioengineering, Centre for Biological Engineering, Universidade do Minho, Campus de Gualtar, 4710-057, Braga, Portugal
| | - Charles W Keevil
- Environmental Healthcare Unit, Microbiology Group, School of Biological Sciences, University of Southampton, Bassett Crescent East, Southampton, SO16 7PX, United Kingdom
| | - Maria J Vieira
- IBB-Institute for Biotechnology and Bioengineering, Centre for Biological Engineering, Universidade do Minho, Campus de Gualtar, 4710-057, Braga, Portugal
| |
Collapse
|
7
|
Carinhas N, Oliveira R, Alves PM, Carrondo MJ, Teixeira AP. Systems biotechnology of animal cells: the road to prediction. Trends Biotechnol 2012; 30:377-85. [DOI: 10.1016/j.tibtech.2012.03.004] [Citation(s) in RCA: 33] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/17/2012] [Revised: 03/11/2012] [Accepted: 03/14/2012] [Indexed: 12/26/2022]
|
8
|
Wuest DM, Harcum SW, Lee KH. Genomics in mammalian cell culture bioprocessing. Biotechnol Adv 2012; 30:629-38. [PMID: 22079893 PMCID: PMC3718848 DOI: 10.1016/j.biotechadv.2011.10.010] [Citation(s) in RCA: 34] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/28/2011] [Revised: 09/20/2011] [Accepted: 10/30/2011] [Indexed: 12/14/2022]
Abstract
Explicitly identifying the genome of a host organism including sequencing, mapping, and annotating its genetic code has become a priority in the field of biotechnology with aims at improving the efficiency and understanding of cell culture bioprocessing. Recombinant protein therapeutics, primarily produced in mammalian cells, constitute a $108 billion global market. The most common mammalian cell line used in biologic production processes is the Chinese hamster ovary (CHO) cell line, and although great improvements have been made in titer production over the past 25 years, the underlying molecular and physiological factors are not well understood. Confident understanding of CHO bioprocessing elements (e.g. cell line selection, protein production, and reproducibility of process performance and product specifications) would significantly improve with a well understood genome. This review describes mammalian cell culture use in bioprocessing, the importance of obtaining CHO cell line genetic sequences, and the current status of sequencing efforts. Furthermore, transcriptomic techniques and gene expression tools are presented, and case studies exploring genomic techniques and applications aimed to improve mammalian bioprocess performance are reviewed. Finally, future implications of genomic advances are surmised.
Collapse
Affiliation(s)
- Diane M. Wuest
- Chemical Engineering and Delaware Biotechnology Institute, University of Delaware, 15 Innovation Way, Newark, DE 19711, USA
| | - Sarah W. Harcum
- Bioengineering, Clemson University, 301 Rhodes Research Center, Clemson, SC 29634, USA
| | - Kelvin H. Lee
- Chemical Engineering and Delaware Biotechnology Institute, University of Delaware, 15 Innovation Way, Newark, DE 19711, USA
| |
Collapse
|
9
|
Dahodwala H, Nowey M, Mitina T, Sharfstein ST. Effects of clonal variation on growth, metabolism, and productivity in response to trophic factor stimulation: a study of Chinese hamster ovary cells producing a recombinant monoclonal antibody. Cytotechnology 2012; 64:27-41. [PMID: 21822681 PMCID: PMC3261449 DOI: 10.1007/s10616-011-9388-z] [Citation(s) in RCA: 14] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/25/2011] [Accepted: 07/27/2011] [Indexed: 10/17/2022] Open
Abstract
The growth, metabolism, and productivity of five Chinese hamster ovary (CHO) clones were explored in response to stimulation with insulin (5 mg/L) and LONG(®)R(3)IGF-I (20 μg/L or 100 μg/L). All five clones were derived from the same parental CHO cell line (DG44) and produced the same recombinant monoclonal antibody, with varying specific productivities. There was no uniform response among the clones to stimulation with the different trophic factors. One of the high productivity clones (clone D) exhibited significantly better growth in response to LONG(®)R(3)IGF-I; whereas the other clones showed equivalent or slightly better growth in the presence of insulin. Three out of the five clones had higher specific productivities in the presence of insulin (although not statistically significant); one was invariant, and the final clone exhibited slightly higher specific productivity in the presence of LONG(®)R(3)IGF-I. Total product titers exhibited moderate variation between culture conditions, again with neither trophic factor being clearly superior. Overall product titers were affected by variations in both integrated viable cell density and specific productivity. Nutrient uptake and metabolite generation patterns varied strongly between clones and much less with culture conditions. These results point to the need for careful clonal analysis when selecting clones, particularly for platform processes where media and culture conditions are predetermined.
Collapse
Affiliation(s)
- Hussain Dahodwala
- Biochemistry and Biophysics Program, Center for Biotechnology and Interdisciplinary Studies, Rensselaer Polytechnic Institute, Troy, NY, 12180, USA
| | | | | | | |
Collapse
|
10
|
Dietmair S, Nielsen LK, Timmins NE. Mammalian cells as biopharmaceutical production hosts in the age of omics. Biotechnol J 2011; 7:75-89. [DOI: 10.1002/biot.201100369] [Citation(s) in RCA: 39] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/01/2011] [Revised: 10/31/2011] [Accepted: 10/31/2011] [Indexed: 12/11/2022]
|
11
|
Fucose content of monoclonal antibodies can be controlled by culture medium osmolality for high antibody-dependent cellular cytotoxicity. Cytotechnology 2011; 64:249-65. [PMID: 21870215 DOI: 10.1007/s10616-011-9377-2] [Citation(s) in RCA: 33] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/02/2011] [Accepted: 07/15/2011] [Indexed: 12/17/2022] Open
Abstract
Antibody-dependent cellular cytotoxicity (ADCC) is dependent on the fucose content of oligosaccharides bound to monoclonal antibodies (MAbs). As MAbs with a low fucose content exhibit high ADCC activity, it is important to control the defucosylation levels (deFuc%) of MAbs and to analyze the factors that affect deFuc%. In this study, we observed that the deFuc% was inversely related to culture medium osmolality for MAbs produced in the rat hybridoma cell line YB2/0, with r (2) values as high as 0.92. Moreover, deFuc% exhibited the same correlation irrespective of the type of compound used for regulating osmolality (NaCl, KCl, fucose, fructose, creatine, or mannitol) at a culture scale ranging from 1 to 400 L. We succeeded in controlling MAb deFuc% by maintaining a constant medium osmolality in both perfusion and fed-batch cultures. In agreement with these observations, reverse transcription PCR analyses revealed decreased transcription of genes involved in glycolysis, GDP-fucose supply, and fucose transfer under hypoosmotic conditions.
Collapse
|
12
|
Hyperosmolarity enhances transient recombinant protein yield in Chinese hamster ovary cells. Biotechnol Lett 2010; 32:1587-92. [PMID: 20574835 DOI: 10.1007/s10529-010-0331-8] [Citation(s) in RCA: 19] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/06/2010] [Accepted: 06/14/2010] [Indexed: 10/19/2022]
Abstract
The effect of hyperosmolarity on transient recombinant protein production in Chinese hamster ovary (CHO) cells was investigated. Addition of 90 mM NaCl to the production medium ProCHO5 increased the volumetric yield of recombinant antibody up to 4-fold relative to transfection in ProCHO5 alone. Volumetric yields up to 50 mg l(-1) were achieved in a 6 day batch culture of 3 l. In addition, hyperosmolarity reduced cell growth and increased cell size. The addition of salt to cultures of transiently transfected CHO cells is a simple and cost-effective method to increase TGE yields in this host.
Collapse
|
13
|
Dragosits M, Stadlmann J, Graf A, Gasser B, Maurer M, Sauer M, Kreil DP, Altmann F, Mattanovich D. The response to unfolded protein is involved in osmotolerance of Pichia pastoris. BMC Genomics 2010; 11:207. [PMID: 20346137 PMCID: PMC2867824 DOI: 10.1186/1471-2164-11-207] [Citation(s) in RCA: 64] [Impact Index Per Article: 4.6] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/05/2009] [Accepted: 03/26/2010] [Indexed: 12/29/2022] Open
Abstract
BACKGROUND The effect of osmolarity on cellular physiology has been subject of investigation in many different species. High osmolarity is of importance for biotechnological production processes, where high cell densities and product titers are aspired. Several studies indicated that increased osmolarity of the growth medium can have a beneficial effect on recombinant protein production in different host organisms. Thus, the effect of osmolarity on the cellular physiology of Pichia pastoris, a prominent host for recombinant protein production, was studied in carbon limited chemostat cultures at different osmolarities. Transcriptome and proteome analyses were applied to assess differences upon growth at different osmolarities in both, a wild type strain and an antibody fragment expressing strain. While our main intention was to analyze the effect of different osmolarities on P. pastoris in general, this was complemented by studying it in context with recombinant protein production. RESULTS In contrast to the model yeast Saccharomyces cerevisiae, the main osmolyte in P. pastoris was arabitol rather than glycerol, demonstrating differences in osmotic stress response as well as energy metabolism. 2D Fluorescence Difference Gel electrophoresis and microarray analysis were applied and demonstrated that processes such as protein folding, ribosome biogenesis and cell wall organization were affected by increased osmolarity. These data indicated that upon increased osmolarity less adaptations on both the transcript and protein level occurred in a P. pastoris strain, secreting the Fab fragment, compared with the wild type strain. No transcriptional activation of the high osmolarity glycerol (HOG) pathway was observed at steady state conditions. Furthermore, no change of the specific productivity of recombinant Fab was observed at increased osmolarity. CONCLUSION These data point out that the physiological response to increased osmolarity is different to S. cerevisiae. Increased osmolarity resulted in an unfolded protein response (UPR) like response in P. pastoris and lead to pre-conditioning of the recombinant Fab producing strain of P. pastoris to growth at high osmolarity. The current data demonstrate a strong similarity of environmental stress response mechanisms and recombinant protein related stresses. Therefore, these results might be used in future strain and bioprocess engineering of this biotechnologically relevant yeast.
Collapse
Affiliation(s)
- Martin Dragosits
- Department of Biotechnology, BOKU-University of Natural Resources and Applied Life Sciences, Vienna, Austria
| | | | | | | | | | | | | | | | | |
Collapse
|
14
|
Shen D, Kiehl TR, Khattak SF, Li ZJ, He A, Kayne PS, Patel V, Neuhaus IM, Sharfstein ST. Transcriptomic responses to sodium chloride-induced osmotic stress: A study of industrial fed-batch CHO cell cultures. Biotechnol Prog 2010; 26:1104-15. [DOI: 10.1002/btpr.398] [Citation(s) in RCA: 18] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/10/2022]
|
15
|
Kantardjieff A, Nissom PM, Chuah SH, Yusufi F, Jacob NM, Mulukutla BC, Yap M, Hu WS. Developing genomic platforms for Chinese hamster ovary cells. Biotechnol Adv 2009; 27:1028-1035. [DOI: 10.1016/j.biotechadv.2009.05.023] [Citation(s) in RCA: 40] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/23/2023]
|
16
|
Transcriptome and proteome analysis of Chinese hamster ovary cells under low temperature and butyrate treatment. J Biotechnol 2009; 145:143-59. [PMID: 19770009 DOI: 10.1016/j.jbiotec.2009.09.008] [Citation(s) in RCA: 121] [Impact Index Per Article: 8.1] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/13/2009] [Revised: 09/02/2009] [Accepted: 09/11/2009] [Indexed: 11/23/2022]
Abstract
Recombinant Chinese hamster ovary (CHO) cells selected for high productivity are capable of secreting immunoglobulin G (IgG) molecules at a level that rivals plasma cells in vivo. Following butyrate treatment at 33 degrees C, further increases in productivity are observed. To better understand the mechanisms by which this increased productivity is incurred, the transcriptional response of an antibody-producing cell line undergoing these treatments was investigated using oligo-DNA microarrays. Using distance calculations, more than 900 genes were identified as kinetically differentially expressed between the butyrate-treated 33 degrees C culture and the untreated culture. Furthermore, transcript levels of the heavy and light chain IgG genes increased following treatment. Using stable isotope labeling (SILAC), the secretion rate of IgG was investigated by tracking the decay of the isotope label upon switching to unlabeled medium. Both treated and untreated cultures exhibited very similar IgG secretion kinetics. In contrast, the intracellular IgG content was found to be elevated following treatment. This result suggests that increased productivity under treatment is attributable to elevated cellular secretory capacity, rather than shorter holding times in the secretory pathway. This hypothesis is further supported by the results of gene set enrichment analysis (GSEA), which revealed that elements of the secretory pathway, including Golgi apparatus, cytoskeleton protein binding and small GTPase-mediated signal transduction are enriched and thus may play a role in the increased recombinant protein production observed under butyrate treatment at 33 degrees C.
Collapse
|
17
|
Khoo SHG, Al-Rubeai M. Metabolic characterization of a hyper-productive state in an antibody producing NS0 myeloma cell line. Metab Eng 2009; 11:199-211. [DOI: 10.1016/j.ymben.2009.02.001] [Citation(s) in RCA: 35] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/10/2008] [Revised: 12/10/2008] [Accepted: 02/10/2009] [Indexed: 11/28/2022]
|
18
|
Yee JC, Gerdtzen ZP, Hu WS. Comparative transcriptome analysis to unveil genes affecting recombinant protein productivity in mammalian cells. Biotechnol Bioeng 2009; 102:246-63. [DOI: 10.1002/bit.22039] [Citation(s) in RCA: 79] [Impact Index Per Article: 5.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/14/2022]
|
19
|
Yee JC, de Leon Gatti M, Philp RJ, Yap M, Hu WS. Genomic and proteomic exploration of CHO and hybridoma cells under sodium butyrate treatment. Biotechnol Bioeng 2008; 99:1186-204. [DOI: 10.1002/bit.21665] [Citation(s) in RCA: 100] [Impact Index Per Article: 6.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/12/2022]
|
20
|
Stansfield SH, Allen EE, Dinnis DM, Racher AJ, Birch JR, James DC. Dynamic analysis of GS-NS0 cells producing a recombinant monoclonal antibody during fed-batch culture. Biotechnol Bioeng 2007; 97:410-24. [PMID: 17115445 DOI: 10.1002/bit.21263] [Citation(s) in RCA: 33] [Impact Index Per Article: 1.9] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/18/2022]
Abstract
In this study we have analyzed the dynamic covariation of the mammalian cell proteome with respect to functional phenotype during fed-batch culture of NS0 murine myeloma cells producing a recombinant IgG(4) monoclonal antibody. GS-NS0 cells were cultured in duplicate 10 L bioreactors (36.5 degrees C, 15% DOT, pH 7.0) for 335 h and supplemented with a continuous feed stream after 120 h. Cell-specific growth rate declined continuously after 72 h of culture. Cell-specific recombinant monoclonal antibody production rate (qP) varied sixfold through culture. Whilst qP correlated with relative recombinant heavy chain mRNA abundance up to 216 h, qP subsequently declined, independent of recombinant heavy chain or light chain mRNA abundance. GS-NS0 cultures were sampled at 48 h intervals between 24 and 264 h of culture for proteomic analyses. Total protein abundance and nascent polypeptide synthesis was determined by 2D PAGE of unlabeled proteins visualized by SYPRO Ruby and autoradiography of (35)S-labeled polypeptides, respectively. Covariation of nascent polypeptide synthesis and abundance with biomass-specific cell growth, glucose and glutamate consumption, lactate and Mab production rates were then examined using two partial least squares regression models. Most changes in polypeptide synthesis or abundance for proteins previously identified by mass spectrometry were positively correlated with biomass-specific growth rate. We conclude that the substantial transitions in cell physiology and qP that occur during culture utilize a relatively constant complement of the most abundant host cell machines that vary primarily with respect to induced changes in cell growth rate.
Collapse
|
21
|
Griffin TJ, Seth G, Xie H, Bandhakavi S, Hu WS. Advancing mammalian cell culture engineering using genome-scale technologies. Trends Biotechnol 2007; 25:401-8. [PMID: 17681628 DOI: 10.1016/j.tibtech.2007.07.004] [Citation(s) in RCA: 57] [Impact Index Per Article: 3.4] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/05/2007] [Revised: 05/21/2007] [Accepted: 07/18/2007] [Indexed: 11/23/2022]
Abstract
Mammalian cell-derived protein therapeutic production has changed the landscape of human healthcare in the past two decades. The importance of protein therapeutics has motivated the search for more cost-effective and efficient cell lines capable of producing high quality protein products. The factors contributing to optimal producer cell lines are often complex, and not simply conferred by one gene or gene product, which makes an understanding of system-wide properties for better engineering of optimized cell lines essential. Genome-scale technologies (genomics, transcriptomics and proteomics) enable such engineering studies. However, the use of these technologies in cell culture engineering is still in its infancy. Here, we summarize current knowledge of cell properties important for the design of efficient protein-producing mammalian cell lines, and highlight relevant studies to-date that use genome-scale technologies in these cell systems. We also provide a focused review of relevant alternative and emerging technologies, which have seen limited use in cell culture engineering, but hold great potential for significant advancements in protein therapeutic production.
Collapse
Affiliation(s)
- Timothy J Griffin
- Department of Biochemistry, Molecular Biology and Biophysics, University of Minnesota, Minneapolis, MN 55455, USA.
| | | | | | | | | |
Collapse
|
22
|
Gupta P, Lee KH. Genomics and proteomics in process development: opportunities and challenges. Trends Biotechnol 2007; 25:324-30. [PMID: 17475353 DOI: 10.1016/j.tibtech.2007.04.005] [Citation(s) in RCA: 56] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/29/2007] [Revised: 03/19/2007] [Accepted: 04/19/2007] [Indexed: 02/05/2023]
Abstract
Global gene expression profiling by genomic and proteomic analyses has changed the face of drug discovery and biological research in the past few years. The benefit of these technologies in the area of process development for recombinant protein production has been increasingly realized. This review discusses the application of genome-wide expression profiling tools in the design and optimization of bioprocesses, with the emphasis on the effect on process development of mammalian cell culture. Despite the lack of genome sequence information for most of the relevant mammalian cell lines used, these technologies can be applied during various process development steps. Although there are only a few examples in the literature that present a major improvement in productivity based on genomics and proteomics, further advances in analytical tools and genome sequencing technologies will greatly increase our knowledge at the molecular level and will drive the design of future bioprocesses.
Collapse
Affiliation(s)
- Prateek Gupta
- School of Chemical and Biomolecular Engineering, Cornell University, 120 Olin Hall, Ithaca, NY 14853, USA
| | | |
Collapse
|
23
|
Kuystermans D, Krampe B, Swiderek H, Al-Rubeai M. Using cell engineering and omic tools for the improvement of cell culture processes. Cytotechnology 2007; 53:3-22. [PMID: 19003186 DOI: 10.1007/s10616-007-9055-6] [Citation(s) in RCA: 40] [Impact Index Per Article: 2.4] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/12/2006] [Accepted: 01/25/2007] [Indexed: 12/26/2022] Open
Abstract
Significant strides have been made in mammalian cell based biopharmaceutical process and cell line development over the past years. With several established mammalian host cell lines and expression systems, optimization of selection systems to reduce development times and improvement of glycosylation patterns are only some of the advances being made to improve cell culture processes. In this article, the advances pertaining to cell line development and cell engineering strategies are discussed. An overview of the cell engineering strategies to enhance cellular characteristics by genetic manipulation are illustrated, focusing on the use of genomics and proteomics tools and their application in such endeavors. Included in this review are some of the early studies using the 'omic' technique to understand cellular mechanisms of product synthesis and secretion, apoptosis, cell proliferation and the influence of the physicochemical environment. The article highlights the significance of integrating genomics and proteomics data with the vast amounts of bioprocess data for improved analysis of the biological pathways involved. Further improvements of the techniques and methodologies used are needed but ultimately, the new cell engineering strategies should provide great insight into the regulatory networks within the cell in a bioprocess environment and how to manipulate them to increase overall productivity.
Collapse
Affiliation(s)
- Darrin Kuystermans
- School of Chemical and Bioprocess Engineering and Centre for Synthesis and Chemical Biology, University College Dublin, Belfield, Dublin 4, Ireland
| | | | | | | |
Collapse
|
24
|
Ju J, Zou K, Xie H. Downregulation of NFAT5 by RNA interference reduces monoclonal antibody productivity of hybridoma cells. Cell Res 2007; 17:264-70. [PMID: 17310218 DOI: 10.1038/cr.2007.3] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/08/2022] Open
Abstract
Hybridoma cells display an increase in antibody productivity following exposure to hypertonic conditions. However, the underlying mechanism is not well understood. In the present study, we hypothesize that the nuclear factor of activated T cells 5 (NFAT5)/tonicity enhancer binding protein (TonEBP) functions to increase the antibody productivity of hybridoma cells. NFAT5 is an osmosensitive mammalian transcription factor. However, its ubiquitous expression in various organs that are not bathed in hypertonic milieu suggests that NFAT5 may also regulate cell growth and function under isotonic conditions. In this study, we examined the expression of NFAT5 in hybridoma cells by Western blot analysis, and found that it increased significantly in hypertonic medium. To further define the function of NFAT5 in hybridoma cells, RNA interference technique was used to downregulate the expression of NFAT5 in SGB-8 cells (a hybridoma cell line). In isotonic medium, antibody productivity of hybridoma cells was reduced by downregulation of NFAT5 while cell proliferation was not influenced. The results presented here demonstrate that NFAT5 not only plays an important role in osmotic stress response pathway in hybridoma cells but also is essential for optimal antibody productivity.
Collapse
Affiliation(s)
- Jihang Ju
- Institute of Biochemistry and Cell Biology, Shanghai Institutes for Biological Sciences, Chinese Academy of Sciences, Shanghai 200031, China
| | | | | |
Collapse
|
25
|
|
26
|
Dorai H, Li K, Huang CC, Bittner A, Galindo J, Carmen A. Genome-Wide Analysis of Mouse Myeloma Cell Lines Expressing Therapeutic Antibodies. Biotechnol Prog 2007. [DOI: 10.1002/bp0700051] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/19/2022]
|
27
|
Swiderek H, Al-Rubeai M. Functional genome-wide analysis of antibody producing NS0 cell line cultivated at different temperatures. Biotechnol Bioeng 2007; 98:616-30. [PMID: 17421047 DOI: 10.1002/bit.21445] [Citation(s) in RCA: 20] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/07/2022]
Abstract
Lowering culture temperature has been reported as a significant factor in the improvement of mammalian cell productivity. To determine the physiological changes which take place at different temperature cultivations, an NS0 cell line producing human-mouse chimeric antibody was cultured at 22, 34 and 37 degrees C. Various cellular parameters such as viability, productivity, metabolism, apoptosis and cell cycle were studied and notable changes were shown to be accompanied by changes in metabolic rates. Reduction of the temperature to 22 degrees C resulted in a decrease in the growth rate, inhibition of antibody production, arrest of cell cycle in G2 phase and delay in apoptosis. A slight increase in antibody production was observed at 34 degrees C due to the increase of growth rate and prolonged stationary phase. To better understand and explore the mechanisms underpinning these biological alterations and to identify the genes involved in the genetic reprogramming, genome-wide analyses were performed using GeneChip Mouse Genome arrays. The examination of differential gene expression induced by temperature reduction demonstrated a specific pattern of gene expression in NS0 cells in response to temperature stress. The effect of temperature on transcription induced changes within a wide range of genes involved in metabolic and signalling pathways. Most deregulated genes involved in essential metabolic pathways (i.e. glycolysis/gluconeogenesis, pentose phosphate pathway and inositol metabolism) were repressed in cells cultured at 22 degrees C. By combining gene expression and physiological changes at different temperatures it was possible to provide greater understanding of cell response to hypothermic conditions.
Collapse
Affiliation(s)
- Halina Swiderek
- UCD School of Chemical and Bioprocess Engineering, University College Dublin, Belfield, Dublin 4, Ireland
| | | |
Collapse
|
28
|
Toward genomic cell culture engineering. Cytotechnology 2006; 50:121-40. [PMID: 19003075 DOI: 10.1007/s10616-006-9004-9] [Citation(s) in RCA: 8] [Impact Index Per Article: 0.4] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/07/2006] [Accepted: 03/24/2006] [Indexed: 12/14/2022] Open
Abstract
Genomic and proteomic based global gene expression profiling has altered the landscape of biological research in the past few years. Its potential impact on cell culture bioprocessing has only begun to emanate, partly due to the lack of genomic sequence information for the most widely used industrial cells, Chinese hamster ovary (CHO) cells. Transcriptome and proteome profiling work for species lacking extensive genomic resources must rely on information for other related species or on data obtained from expressed sequence tag (EST) sequencing projects, for which burgeoning efforts have only recently begun. This article discusses the aspects of EST sequencing in those industrially important, genomic resources-poor cell lines, articulates some of the unique features in employing microarray in the study of cultured cells, and highlights the infrastructural needs in establishing a platform for genomics based cell culture research. Recent experience has revealed that generally, most changes in culture conditions only elicit a moderate level of alteration in gene expression. Nevertheless, by broadening the conventional scope of microarray analysis to consider estimated levels of transcript abundance, much physiological insight can be gained. Examples of the application of microarray in cell culture are discussed, and the utility of pattern identification and process diagnosis are highlighted. As genomic resources continue to expand, the power of genomic tools in cell culture processing research will be amply evident. The key to harnessing the immense benefit of these genomic resources resides in the development of physiological understanding from their application.
Collapse
|