1
|
Rennison AP, Prestel A, Westh P, Møller MS. Comparative biochemistry of PET hydrolase-carbohydrate-binding module fusion enzymes on a variety of PET substrates. Enzyme Microb Technol 2024; 180:110479. [PMID: 39047349 DOI: 10.1016/j.enzmictec.2024.110479] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/17/2024] [Revised: 07/10/2024] [Accepted: 07/13/2024] [Indexed: 07/27/2024]
Abstract
Enzyme-driven recycling of PET has now become a fully developed industrial process. With the right pre-treatment, PET can be completely depolymerized within workable timeframes. This has been realized due to extensive research conducted over the past decade, resulting in a large set of engineered PET hydrolases. Among various engineering strategies to enhance PET hydrolases, fusion with binding domains has been used to tune affinity and boost activity of the enzymes. While fusion enzymes have demonstrated higher activity in many cases, these results are primarily observed under conditions that would not be economically viable at scale. Furthermore, the wide variation in PET substrates, conditions, and combinations of PET hydrolases and binding domains complicates direct comparisons. Here, we present a self-consistent and thorough analysis of two leading PET hydrolases, LCCICCG and PHL7. Both enzymes were evaluated both without and with a substrate-binding domain across a range of industrially relevant PET substrates. We demonstrate that the presence of a substrate-binding module does not significantly affect the affinity of LCCICCG and PHL7 for PET. However, significant differences exist in how the fusion enzymes act on different PET substrates and solid substrate loading, ranging from a 3-fold increase in activity to a 6-fold decrease. These findings could inform the tailoring of enzyme choice to different industrial scenarios.
Collapse
Affiliation(s)
- Andrew Philip Rennison
- Department of Biotechnology and Biomedicine, Technical University of Denmark, Søltofts Plads, Building 221, Kgs Lyngby DK-2800, Denmark
| | - Andreas Prestel
- Department of Biology, Section for Biomolecular Sciences, University of Copenhagen, Ole Maaløes Vej, København N 2200, Denmark
| | - Peter Westh
- Department of Biotechnology and Biomedicine, Technical University of Denmark, Søltofts Plads, Building 221, Kgs Lyngby DK-2800, Denmark
| | - Marie Sofie Møller
- Department of Biotechnology and Biomedicine, Technical University of Denmark, Søltofts Plads, Building 221, Kgs Lyngby DK-2800, Denmark.
| |
Collapse
|
2
|
Carr CM, Göttsch F, de Oliveira BFR, Murcia PAS, Jackson SA, Wei R, Clarke DJ, Bornscheuer UT, Dobson ADW. Identification and expression of MarCE, a marine carboxylesterase with synthetic ester-degrading activity. Microb Biotechnol 2024; 17:e14479. [PMID: 38881500 PMCID: PMC11180994 DOI: 10.1111/1751-7915.14479] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/24/2024] [Revised: 04/15/2024] [Accepted: 04/30/2024] [Indexed: 06/18/2024] Open
Abstract
Carboxylic ester hydrolases with the capacity to degrade polyesters are currently highly sought after for their potential use in the biological degradation of PET and other chemically synthesized polymers. Here, we describe MarCE, a carboxylesterase family protein identified via genome mining of a Maribacter sp. isolate from the marine sponge Stelligera stuposa. Based on phylogenetic analysis, MarCE and its closest relatives belong to marine-associated genera from the Cytophaga-Flavobacterium-Bacteroides taxonomic group and appear evolutionarily distinct to any homologous carboxylesterases that have been studied to date in terms of structure or function. Molecular docking revealed putative binding of BHET, a short-chain PET derivative, onto the predicted MarCE three-dimensional structure. The synthetic ester-degrading activity of MarCE was subsequently confirmed by MarCE-mediated hydrolysis of 2 mM BHET substrate, indicated by the release of its breakdown products MHET and TPA, which were measured, respectively, as 1.28 and 0.12 mM following 2-h incubation at 30°C. The findings of this study provide further insight into marine carboxylic ester hydrolases, which have the potential to display unique functional plasticity resulting from their adaptation to complex and fluctuating marine environmentsw.
Collapse
Affiliation(s)
- Clodagh M. Carr
- School of MicrobiologyUniversity College CorkCorkIreland
- SSPC‐SFI Research Centre for PharmaceuticalsUniversity College CorkCorkIreland
| | - Frederike Göttsch
- Department of Biotechnology and Enzyme Catalysis, Institute of BiochemistryUniversity of GreifswaldGreifswaldGermany
| | | | - Pedro A. Sánchez Murcia
- Laboratory of Computer‐Aided Molecular Design, Division of Medicinal Chemistry, Otto‐Loewi Research CenterMedical University of GrazGrazAustria
- BioTechMed‐GrazGrazAustria
| | - Stephen A. Jackson
- School of MicrobiologyUniversity College CorkCorkIreland
- SSPC‐SFI Research Centre for PharmaceuticalsUniversity College CorkCorkIreland
- Environmental Research InstituteUniversity College CorkCorkIreland
| | - Ren Wei
- Department of Biotechnology and Enzyme Catalysis, Institute of BiochemistryUniversity of GreifswaldGreifswaldGermany
| | - David J. Clarke
- School of MicrobiologyUniversity College CorkCorkIreland
- SSPC‐SFI Research Centre for PharmaceuticalsUniversity College CorkCorkIreland
- APC Microbiome IrelandUniversity College CorkCorkIreland
| | - Uwe T. Bornscheuer
- Department of Biotechnology and Enzyme Catalysis, Institute of BiochemistryUniversity of GreifswaldGreifswaldGermany
| | - Alan D. W. Dobson
- School of MicrobiologyUniversity College CorkCorkIreland
- SSPC‐SFI Research Centre for PharmaceuticalsUniversity College CorkCorkIreland
- Environmental Research InstituteUniversity College CorkCorkIreland
| |
Collapse
|
3
|
Schubert SW, Thomsen TB, Clausen KS, Malmendal A, Hunt CJ, Borch K, Jensen K, Brask J, Meyer AS, Westh P. Relationships of crystallinity and reaction rates for enzymatic degradation of poly (ethylene terephthalate), PET. CHEMSUSCHEM 2024; 17:e202301752. [PMID: 38252197 DOI: 10.1002/cssc.202301752] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/24/2023] [Revised: 01/12/2024] [Accepted: 01/15/2024] [Indexed: 01/23/2024]
Abstract
Biocatalytic degradation of plastic waste is anticipated to play an important role in future recycling systems. However, enzymatic degradation of crystalline poly (ethylene terephthalate) (PET) remains consistently poor. Herein, we employed functional assays to elucidate the molecular underpinnings of this limitation. This included utilizing complementary activity assays to monitor the degradation of PET disks with varying crystallinity (XC), as well as determining enzymatic kinetic parameters for soluble PET fragments. The results indicate that an efficient PET-hydrolase, LCCICCG, operates through an endolytic mode of action, and that its activity is limited by conformational constraints in the PET polymer. Such constraints become more pronounced at high XC values, and this limits the density of productive sites on the PET surface. Endolytic chain-scissions are the dominant reaction type in the initial stage, and this means that little or no soluble organic product are released. However, endolytic cuts gradually and locally promote chain mobility and hence the density of attack sites on the surface. This leads to an upward concave progress curve; a behavior sometimes termed lag-phase kinetics.
Collapse
Affiliation(s)
- Sune W Schubert
- Department of Biotechnology and Biomedicine, Technical University of Denmark, Søltofts Plads, DK-2800, Kgs. Lyngby, Denmark
| | - Thore B Thomsen
- Department of Biotechnology and Biomedicine, Technical University of Denmark, Søltofts Plads, DK-2800, Kgs. Lyngby, Denmark
| | - Kristine S Clausen
- Department of Biotechnology and Biomedicine, Technical University of Denmark, Søltofts Plads, DK-2800, Kgs. Lyngby, Denmark
| | - Anders Malmendal
- Institute of Natural Science and Environmental Chemistry., Roskilde University, Universitetsvej 1, 28 C.1, DK-4000, Roskilde, Denmark
| | - Cameron J Hunt
- Department of Biotechnology and Biomedicine, Technical University of Denmark, Søltofts Plads, DK-2800, Kgs. Lyngby, Denmark
| | - Kim Borch
- Novozymes A/S, Biologiens Vej 2, DK-2800, Kgs. Lyngby, Denmark
| | - Kenneth Jensen
- Novozymes A/S, Biologiens Vej 2, DK-2800, Kgs. Lyngby, Denmark
| | - Jesper Brask
- Novozymes A/S, Biologiens Vej 2, DK-2800, Kgs. Lyngby, Denmark
| | - Anne S Meyer
- Department of Biotechnology and Biomedicine, Technical University of Denmark, Søltofts Plads, DK-2800, Kgs. Lyngby, Denmark
| | - Peter Westh
- Department of Biotechnology and Biomedicine, Technical University of Denmark, Søltofts Plads, DK-2800, Kgs. Lyngby, Denmark
| |
Collapse
|
4
|
Bell EL, Rosetto G, Ingraham MA, Ramirez KJ, Lincoln C, Clarke RW, Gado JE, Lilly JL, Kucharzyk KH, Erickson E, Beckham GT. Natural diversity screening, assay development, and characterization of nylon-6 enzymatic depolymerization. Nat Commun 2024; 15:1217. [PMID: 38336849 PMCID: PMC10858056 DOI: 10.1038/s41467-024-45523-5] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/10/2023] [Accepted: 01/24/2024] [Indexed: 02/12/2024] Open
Abstract
Successes in biocatalytic polyester recycling have raised the possibility of deconstructing alternative polymers enzymatically, with polyamide (PA) being a logical target due to the array of amide-cleaving enzymes present in nature. Here, we screen 40 potential natural and engineered nylon-hydrolyzing enzymes (nylonases), using mass spectrometry to quantify eight compounds resulting from enzymatic nylon-6 (PA6) hydrolysis. Comparative time-course reactions incubated at 40-70 °C showcase enzyme-dependent variations in product distributions and extent of PA6 film depolymerization, with significant nylon deconstruction activity appearing rare. The most active nylonase, a NylCK variant we rationally thermostabilized (an N-terminal nucleophile (Ntn) hydrolase, NylCK-TS, Tm = 87.4 °C, 16.4 °C higher than the wild-type), hydrolyzes 0.67 wt% of a PA6 film. Reactions fail to restart after fresh enzyme addition, indicating that substrate-based limitations, such as restricted enzyme access to hydrolysable bonds, prohibit more extensive deconstruction. Overall, this study expands our understanding of nylonase activity distribution, indicates that Ntn hydrolases may have the greatest potential for further development, and identifies key targets for progressing PA6 enzymatic depolymerization, including improving enzyme activity, product selectivity, and enhancing polymer accessibility.
Collapse
Affiliation(s)
- Elizabeth L Bell
- Renewable Resources and Enabling Sciences Center, National Renewable Energy Laboratory, Golden, CO, 80401, USA
- BOTTLE Consortium, Golden, CO, 80401, USA
| | - Gloria Rosetto
- Renewable Resources and Enabling Sciences Center, National Renewable Energy Laboratory, Golden, CO, 80401, USA
| | - Morgan A Ingraham
- Renewable Resources and Enabling Sciences Center, National Renewable Energy Laboratory, Golden, CO, 80401, USA
- BOTTLE Consortium, Golden, CO, 80401, USA
| | - Kelsey J Ramirez
- Renewable Resources and Enabling Sciences Center, National Renewable Energy Laboratory, Golden, CO, 80401, USA
- BOTTLE Consortium, Golden, CO, 80401, USA
| | - Clarissa Lincoln
- Renewable Resources and Enabling Sciences Center, National Renewable Energy Laboratory, Golden, CO, 80401, USA
- BOTTLE Consortium, Golden, CO, 80401, USA
| | - Ryan W Clarke
- Renewable Resources and Enabling Sciences Center, National Renewable Energy Laboratory, Golden, CO, 80401, USA
- BOTTLE Consortium, Golden, CO, 80401, USA
| | - Japheth E Gado
- Renewable Resources and Enabling Sciences Center, National Renewable Energy Laboratory, Golden, CO, 80401, USA
- BOTTLE Consortium, Golden, CO, 80401, USA
| | - Jacob L Lilly
- Battelle Memorial Institute, Columbus, OH, 43201, USA
| | | | - Erika Erickson
- Renewable Resources and Enabling Sciences Center, National Renewable Energy Laboratory, Golden, CO, 80401, USA
- BOTTLE Consortium, Golden, CO, 80401, USA
| | - Gregg T Beckham
- Renewable Resources and Enabling Sciences Center, National Renewable Energy Laboratory, Golden, CO, 80401, USA.
- BOTTLE Consortium, Golden, CO, 80401, USA.
| |
Collapse
|
5
|
Kimura Y, Fukuda Y, Otsu R, Yu J, Mino S, Misawa S, Maruyama S, Ikeda Y, Miyamachi R, Noguchi H, Kato S, Yamamoto Y, Sawabe T. A lesson from polybutylene succinate plastisphere to the discovery of novel plastic degrading enzyme genes in marine vibrios. Environ Microbiol 2023; 25:2834-2850. [PMID: 37775475 DOI: 10.1111/1462-2920.16512] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/27/2023] [Accepted: 09/19/2023] [Indexed: 10/01/2023]
Abstract
Polybutylene succinate (PBS) is an eco-friendly green plastic. However, PBS was shown as being non-biodegradable in marine environments, and up until now, only a limited number of PBS-degrading marine microbes have been discovered. We first set up in vitro PBS- and PBSA (polybutylene succinate adipate)-plastispheres to characterize novel PBS-degrading marine microbes. Microbial growth and oxygen consumption were observed in both PBS- and PBSA-plastispheres enriched with natural seawater collected from Usujiri, Hokkaido, Japan, and Vibrionaceae and Pseudoalteromonadaceae were significantly enriched on these films. Further gene identification indicated that vibrios belonging to the Gazogenes clade possess genes related to a PBS degrading enzyme (PBSase). The PBS degradation assay for six Gazogenes clade vibrios identified Vibrio ruber, Vibrio rhizosphaerae, and Vibrio spartinae as being capable of degrading PBS. We further identified the gene responsible for PBSase from the type strain of V. ruber, and the purified recombinant vibrio PBSase was found to have low-temperature adaptation and was active under high NaCl concentrations. We also provided docking models between the vibrio PBSase and PBS and PBSA units to show how vibrio PBSase interacts with each substrate compared to the Acidovorax PBSase. These results could contribute to a more sustainable society through further utilization of PBS in marine environments and plastic recycling.
Collapse
Affiliation(s)
- Yutaro Kimura
- Laboratory of Microbiology, Faculty of Fisheries Sciences, Hokkaido University, Hakodate, Japan
| | - Yutaka Fukuda
- Laboratory of Microbiology, Faculty of Fisheries Sciences, Hokkaido University, Hakodate, Japan
| | - Rumi Otsu
- Laboratory of Microbiology, Faculty of Fisheries Sciences, Hokkaido University, Hakodate, Japan
| | - Juwanen Yu
- Laboratory of Microbiology, Faculty of Fisheries Sciences, Hokkaido University, Hakodate, Japan
| | - Sayaka Mino
- Laboratory of Microbiology, Faculty of Fisheries Sciences, Hokkaido University, Hakodate, Japan
| | - Satoru Misawa
- Medical Core Project Dept, Mitsubishi Chemical Corporation, Yokohama, Japan
| | - Satoshi Maruyama
- Yokohama Basic Chemicals Lab, Mitsubishi Chemical Corporation, Yokohama, Japan
| | - Yuta Ikeda
- Food Core Project Dept, Mitsubishi Chemical Corporation, Yokohama, Japan
| | - Remi Miyamachi
- Organic Materials Lab, Mitsubishi Chemical Corporation, Yokohama, Japan
| | - Hiroshi Noguchi
- Organic Materials Lab, Mitsubishi Chemical Corporation, Yokohama, Japan
| | - Satoshi Kato
- Research and Consulting Div, Mitsubishi Chemical Research Corporation, Tokyo, Japan
| | - Yasuhito Yamamoto
- Yokohama Basic Chemicals Lab, Mitsubishi Chemical Corporation, Yokohama, Japan
| | - Tomoo Sawabe
- Laboratory of Microbiology, Faculty of Fisheries Sciences, Hokkaido University, Hakodate, Japan
| |
Collapse
|
6
|
Howard SA, Carr CM, Sbahtu HI, Onwukwe U, López MJ, Dobson ADW, McCarthy RR. Enrichment of native plastic-associated biofilm communities to enhance polyester degrading activity. Environ Microbiol 2023; 25:2698-2718. [PMID: 37515381 PMCID: PMC10947123 DOI: 10.1111/1462-2920.16466] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/01/2022] [Accepted: 06/30/2023] [Indexed: 07/30/2023]
Abstract
Plastic pollution is an increasing worldwide problem urgently requiring a solution. While recycling rates are increasing globally, only 9% of all plastic waste has been recycled, and with the cost and limited downstream uses of recycled plastic, an alternative is needed. Here, we found that expanded polystyrene (EPS) promoted high levels of bacterial biofilm formation and sought out environmental EPS waste to characterize these native communities. We demonstrated that the EPS attached communities had limited plastic degrading activity. We then performed a long-term enrichment experiment where we placed a robust selection pressure on these communities by limiting carbon availability such that the waste plastic was the only carbon source. Seven of the resulting enriched bacterial communities had increased plastic degrading activity compared to the starting bacterial communities. Pseudomonas stutzeri was predominantly identified in six of the seven enriched communities as the strongest polyester degrader. Sequencing of one isolate of P. stutzeri revealed two putative polyesterases and one putative MHETase. This indicates that waste plastic-associated biofilms are a source for bacteria that have plastic-degrading potential, and that this potential can be unlocked through selective pressure and further in vitro enrichment experiments, resulting in biodegradative communities that are better than nature.
Collapse
Affiliation(s)
- Sophie A. Howard
- Centre for Inflammation Research and Translational Medicine, Division of Biosciences, Department of Life Sciences, College of Health and Life SciencesBrunel University LondonUxbridgeUK
| | - Clodagh M. Carr
- School of MicrobiologyUniversity College CorkCorkIreland
- SSPC‐SFI Research Centre for PharmaceuticalsUniversity College CorkCorkIreland
| | - Habteab Isaack Sbahtu
- Centre for Inflammation Research and Translational Medicine, Division of Biosciences, Department of Life Sciences, College of Health and Life SciencesBrunel University LondonUxbridgeUK
| | - Uchechukwu Onwukwe
- Experimental Techniques Centre, College of Engineering, Design and Physical SciencesBrunel University LondonUxbridgeUK
| | - Maria J. López
- Department of Biology and Geology, CITE II‐BUniversity of Almería, Agrifood Campus of International Excellence ceiA3, CIAIMBITALAlmeriaSpain
| | - Alan D. W. Dobson
- School of MicrobiologyUniversity College CorkCorkIreland
- SSPC‐SFI Research Centre for PharmaceuticalsUniversity College CorkCorkIreland
| | - Ronan R. McCarthy
- Centre for Inflammation Research and Translational Medicine, Division of Biosciences, Department of Life Sciences, College of Health and Life SciencesBrunel University LondonUxbridgeUK
| |
Collapse
|
7
|
Qu Z, Chen K, Zhang L, Sun Y. Computation-Based Design of Salt Bridges in PETase for Enhanced Thermostability and Performance for PET Degradation. Chembiochem 2023; 24:e202300373. [PMID: 37639367 DOI: 10.1002/cbic.202300373] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/19/2023] [Revised: 08/28/2023] [Accepted: 08/28/2023] [Indexed: 08/31/2023]
Abstract
Polyethylene terephthalate (PET) is one of the most widely used plastics, and the accumulation of PET poses a great threat to the environment. IsPETase can degrade PET rapidly at moderate temperatures, but its application is greatly limited by the low stability. Herein, molecular dynamics (MD) simulations combined with a sequence alignment strategy were adopted to introduce salt bridges into the flexible region of IsPETase to improve its thermal stability. In the designed variants, the Tm values of IsPETaseI168R/S188D and IsPETaseI168R/S188E were 7.4 and 8.7 °C higher than that of the wild type, respectively. The release of products degraded by IsPETaseI168R/S188E was 4.3 times that of the wild type. Tertiary structure characterization demonstrated that the structure of the variants IsPETaseI168R/S188D and IsPETaseI168R/S188E became more compact. Extensive MD simulations verified that a stable salt bridge was formed between the residue R168 and D186 in IsPETaseI168R/S188D , while in IsPETaseI168R/S188E an R168-D186-E188 salt bridge network was observed. These results confirmed that the proposed computation-based salt bridge design strategy could efficiently generate variants with enhanced thermal stability for the long-term degradation of PET, which would be helpful for the design of enzymes with improved stability.
Collapse
Affiliation(s)
- Zhi Qu
- Department of Biochemical Engineering, School of Chemical Engineering and Technology and, Key Laboratory of Systems Bioengineering and, Frontiers Science Center for Synthetic Biology (Ministry of Education), Tianjin University, Tianjin, 300350, China
| | - Kun Chen
- Department of Biochemical Engineering, School of Chemical Engineering and Technology and, Key Laboratory of Systems Bioengineering and, Frontiers Science Center for Synthetic Biology (Ministry of Education), Tianjin University, Tianjin, 300350, China
| | - Lin Zhang
- Department of Biochemical Engineering, School of Chemical Engineering and Technology and, Key Laboratory of Systems Bioengineering and, Frontiers Science Center for Synthetic Biology (Ministry of Education), Tianjin University, Tianjin, 300350, China
| | - Yan Sun
- Department of Biochemical Engineering, School of Chemical Engineering and Technology and, Key Laboratory of Systems Bioengineering and, Frontiers Science Center for Synthetic Biology (Ministry of Education), Tianjin University, Tianjin, 300350, China
| |
Collapse
|
8
|
Arnal G, Anglade J, Gavalda S, Tournier V, Chabot N, Bornscheuer UT, Weber G, Marty A. Assessment of Four Engineered PET Degrading Enzymes Considering Large-Scale Industrial Applications. ACS Catal 2023; 13:13156-13166. [PMID: 37881793 PMCID: PMC10594578 DOI: 10.1021/acscatal.3c02922] [Citation(s) in RCA: 19] [Impact Index Per Article: 19.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/27/2023] [Revised: 09/13/2023] [Indexed: 10/27/2023]
Abstract
In recent years, enzymatic recycling of the widely used polyester polyethylene terephthalate (PET) has become a complementary solution to current thermomechanical recycling for colored, opaque, and mixed PET. A large set of promising hydrolases that depolymerize PET have been found and enhanced by worldwide initiatives using various methods of protein engineering. Despite the achievements made in these works, it remains difficult to compare enzymes' performance and their applicability to large-scale reactions due to a lack of homogeneity between the experimental protocols used. Here, we pave the way for a standardized enzymatic PET hydrolysis protocol using reaction conditions relevant for larger scale hydrolysis and apply these parameters to four recently reported PET hydrolases (LCCICCG, FAST-PETase, HotPETase, and PES-H1L92F/Q94Y). We show that FAST-PETase and HotPETase have intrinsic limitations that may not permit their application on larger reaction scales, mainly due to their relatively low depolymerization rates. With 80% PET depolymerization, PES-H1L92F/Q94Y may be a suitable candidate for industrial reaction scales upon further rounds of enzyme evolution. LCCICCG outperforms the other enzymes, converting 98% of PET into the monomeric products terephthalic acid (TPA) and ethylene glycol (EG) in 24 h. In addition, we optimized the reaction conditions of LCCICCG toward economic viability, reducing the required amount of enzyme by a factor of 3 and the temperature of the reaction from 72 to 68 °C. We anticipate our findings to advance enzymatic PET hydrolysis toward a coherent assessment of the enzymes and materialize feasibility at larger reaction scales.
Collapse
Affiliation(s)
- Grégory Arnal
- Carbios, Parc Cataroux—Bâtiment
B80, 8 Rue de la Grolière, 63100 Clermont-Ferrand, France
| | - Julien Anglade
- Toulouse
Biotechnology Institute, TBI, Université
de Toulouse, CNRS, INRAE, INSA, 135 Avenue de Rangueil, 31077 Toulouse Cedex 4, France
| | - Sabine Gavalda
- Carbios, Parc Cataroux—Bâtiment
B80, 8 Rue de la Grolière, 63100 Clermont-Ferrand, France
| | - Vincent Tournier
- Carbios, Parc Cataroux—Bâtiment
B80, 8 Rue de la Grolière, 63100 Clermont-Ferrand, France
| | - Nicolas Chabot
- Carbios, Parc Cataroux—Bâtiment
B80, 8 Rue de la Grolière, 63100 Clermont-Ferrand, France
| | - Uwe T. Bornscheuer
- Institute
of Biochemistry, Biotechnology & Enzyme Catalysis, University of Greifswald, Felix-Hausdorff-Str. 4, 17487 Greifswald, Germany
| | - Gert Weber
- Macromolecular
Crystallography, Helmholtz-Zentrum Berlin
für Materialien und Energie, Albert-Einstein-Straße 15, 12489 Berlin, Germany
| | - Alain Marty
- Carbios, Parc Cataroux—Bâtiment
B80, 8 Rue de la Grolière, 63100 Clermont-Ferrand, France
| |
Collapse
|
9
|
Sui B, Wang T, Fang J, Hou Z, Shu T, Lu Z, Liu F, Zhu Y. Recent advances in the biodegradation of polyethylene terephthalate with cutinase-like enzymes. Front Microbiol 2023; 14:1265139. [PMID: 37849919 PMCID: PMC10577388 DOI: 10.3389/fmicb.2023.1265139] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/22/2023] [Accepted: 09/15/2023] [Indexed: 10/19/2023] Open
Abstract
Polyethylene terephthalate (PET) is a synthetic polymer in the polyester family. It is widely found in objects used daily, including packaging materials (such as bottles and containers), textiles (such as fibers), and even in the automotive and electronics industries. PET is known for its excellent mechanical properties, chemical resistance, and transparency. However, these features (e.g., high hydrophobicity and high molecular weight) also make PET highly resistant to degradation by wild-type microorganisms or physicochemical methods in nature, contributing to the accumulation of plastic waste in the environment. Therefore, accelerated PET recycling is becoming increasingly urgent to address the global environmental problem caused by plastic wastes and prevent plastic pollution. In addition to traditional physical cycling (e.g., pyrolysis, gasification) and chemical cycling (e.g., chemical depolymerization), biodegradation can be used, which involves breaking down organic materials into simpler compounds by microorganisms or PET-degrading enzymes. Lipases and cutinases are the two classes of enzymes that have been studied extensively for this purpose. Biodegradation of PET is an attractive approach for managing PET waste, as it can help reduce environmental pollution and promote a circular economy. During the past few years, great advances have been accomplished in PET biodegradation. In this review, current knowledge on cutinase-like PET hydrolases (such as TfCut2, Cut190, HiC, and LCC) was described in detail, including the structures, ligand-protein interactions, and rational protein engineering for improved PET-degrading performance. In particular, applications of the engineered catalysts were highlighted, such as improving the PET hydrolytic activity by constructing fusion proteins. The review is expected to provide novel insights for the biodegradation of complex polymers.
Collapse
Affiliation(s)
- Beibei Sui
- School of Biological Science, Jining Medical University, Jining, Shandong, China
| | - Tao Wang
- School of Biological Science, Jining Medical University, Jining, Shandong, China
| | - Jingxiang Fang
- Rizhao Administration for Market Regulation, Rizhao, Shandong, China
| | - Zuoxuan Hou
- School of Biological Science, Jining Medical University, Jining, Shandong, China
| | - Ting Shu
- School of Biological Science, Jining Medical University, Jining, Shandong, China
| | - Zhenhua Lu
- College of Chemical and Biological Engineering, Zhejiang University, Hangzhou, Zhejiang, China
| | - Fei Liu
- School of Biological Science, Jining Medical University, Jining, Shandong, China
| | - Youshuang Zhu
- School of Biological Science, Jining Medical University, Jining, Shandong, China
| |
Collapse
|
10
|
Carr CM, Keller MB, Paul B, Schubert SW, Clausen KSR, Jensen K, Clarke DJ, Westh P, Dobson ADW. Purification and biochemical characterization of SM14est, a PET-hydrolyzing enzyme from the marine sponge-derived Streptomyces sp. SM14. Front Microbiol 2023; 14:1170880. [PMID: 37250061 PMCID: PMC10213408 DOI: 10.3389/fmicb.2023.1170880] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/21/2023] [Accepted: 04/21/2023] [Indexed: 05/31/2023] Open
Abstract
The successful enzymatic degradation of polyester substrates has fueled worldwide investigation into the treatment of plastic waste using bio-based processes. Within this realm, marine-associated microorganisms have emerged as a promising source of polyester-degrading enzymes. In this work, we describe the hydrolysis of the synthetic polymer PET by SM14est, a polyesterase which was previously identified from Streptomyces sp. SM14, an isolate of the marine sponge Haliclona simulans. The PET hydrolase activity of purified SM14est was assessed using a suspension-based assay and subsequent analysis of reaction products by UV-spectrophotometry and RP-HPLC. SM14est displayed a preference for high salt conditions, with activity significantly increasing at sodium chloride concentrations from 100 mM up to 1,000 mM. The initial rate of PET hydrolysis by SM14est was determined to be 0.004 s-1 at 45°C, which was increased by 5-fold to 0.02 s-1 upon addition of 500 mM sodium chloride. Sequence alignment and structural comparison with known PET hydrolases, including the marine halophile PET6, and the highly efficient, thermophilic PHL7, revealed conserved features of interest. Based on this work, SM14est emerges as a useful enzyme that is more similar to key players in the area of PET hydrolysis, like PHL7 and IsPETase, than it is to its marine counterparts. Salt-tolerant polyesterases such as SM14est are potentially valuable in the biological degradation of plastic particles that readily contaminate marine ecosystems and industrial wastewaters.
Collapse
Affiliation(s)
- Clodagh M. Carr
- School of Microbiology, University College Cork, Cork, Ireland
- SSPC-SFI Research Centre for Pharmaceuticals, University College Cork, Cork, Ireland
| | - Malene B. Keller
- Department of Biotechnology and Biomedicine, Technical University of Denmark, Lyngby, Denmark
| | - Bijoya Paul
- Department of Biotechnology and Biomedicine, Technical University of Denmark, Lyngby, Denmark
| | - Sune W. Schubert
- Department of Biotechnology and Biomedicine, Technical University of Denmark, Lyngby, Denmark
| | - Kristine S. R. Clausen
- Department of Biotechnology and Biomedicine, Technical University of Denmark, Lyngby, Denmark
| | | | - David J. Clarke
- School of Microbiology, University College Cork, Cork, Ireland
- APC Microbiome Ireland, University College Cork, Cork, Ireland
| | - Peter Westh
- Department of Biotechnology and Biomedicine, Technical University of Denmark, Lyngby, Denmark
| | - Alan D. W. Dobson
- School of Microbiology, University College Cork, Cork, Ireland
- SSPC-SFI Research Centre for Pharmaceuticals, University College Cork, Cork, Ireland
- Environmental Research Institute, University College Cork, Cork, Ireland
| |
Collapse
|