Removal of Alternaria mycotoxins from aqueous solution by inactivated yeast powder

Degradation of Alternaria mycotoxins by UV-C irradiation: Effect of selected process and exposure to food components

Alternariol (AOH) and alternariol monomethyl ether (AME) are two Alternaria mycotoxins with high occurrence rates in food systems. This study aimed to investigate the photodegradation of AOH and AME by ultraviolet-C (UV-C) irradiation. The effect of UV-C intensity, pH, treatment time, solvents and the exposure of food components were evaluated. After treated by UV-C irradiation at 3500 μW/cm² for 90 min, AOH samples in methanol, aqueous solution and solid state were degraded by 89.1%, 72.9% and 53.2%, respectively, while the degradation percentages of AME were 86.6%, 50.1% and 11.1%, respectively. Increasing irradiation intensity and prolonging irradiation time could significantly facilitate the degradation of AOH and AME. An alkaline environment (pH = 11) was more conducive to the degradation of toxins. In addition, 2.5 mg mL^-1 citric acid or malic acid increased the photodegradation of AOH and AME to 94.6% and 95.3%, 93.2% and 70.5%, respectively. However, protein, polyphenols and vitamin C exerted inhibitory effects on the degradation, while 10% glucose or sucrose reduced the photodegradation of AOH and AME to 65.9% and 40.3%. UV-C treatment could effectively reduce the content of AOH and AME, with the highest efficiency achieved in methanol and alkaline environment. By contrast, UV-C irradiation is more effective in degrading toxins in some liquid foods rich in organic acids but lacking in protein. The utilization of UV-C radiation appears to be a potentially useful approach for decreasing the underlying risk of Alternaria mycotoxin contamination in foods.

Removal of Alternaria mycotoxins exposed to different food components by cold plasma

Alternariol (AOH) and alternariol monomethyl ether (AME), the two Alternaria mycotoxins with the highest outbreak rates in food systems, could be effectively reduced by cold plasma. This research evaluated the impact of food components on the plasma removal of AOH and AME. The results showed that 6% whey protein or ovalbumin almost completely inhibited the reduction of AOH or AME. Polyphenols inhibited the removal of AOH and AME by up to 90.8% and 83.4%, respectively. Organic acids and Vc reduced AME removal by up to 43.4% and 31.9%, respectively, but had little effect on AOH removal. Sugars and amino acids could decrease both toxin removal by less than 10%. Proteins exhibited the most inhibitory effect on plasma removal of AOH and AME, followed by polyphenols, while the effect of other components was relatively small. AOH and AME removal by cold plasma was highly related to H₂O₂ produced during plasma discharge.

Microbiological Decontamination of Mycotoxins: Opportunities and Limitations

The contamination of food and feeds with mycotoxins poses a global health risk to humans and animals, with major economic consequences. Good agricultural and manufacturing practices can help control mycotoxin contamination. Since these actions are not always effective, several methods of decontamination have also been developed, including physical, chemical, and biological methods. Biological decontamination using microorganisms has revealed new opportunities. However, these biological methods require legal regulations and more research before they can be used in food production. Currently, only selected biological methods are acceptable for the decontamination of feed. This review discusses the literature on the use of microorganisms to remove mycotoxins and presents their possible mechanisms of action. Special attention is given to Saccharomyces cerevisiae yeast and lactic acid bacteria, and the use of yeast cell wall derivatives.