Detoxification and safety evaluation of aflatoxin B1 in peanut oil using alkali refining

One-pot green synthesis of ZIF-8/IgG composite for the precise orientation and protection of antibody and its application in purification and detection of aflatoxins in peanut oil

This study presents a novel approach toward the one-pot green synthesis of ZIF-8/IgG composite, focusing on its precise orientation and protection of the anti-aflatoxins antibody. The antibody orientation is achieved through the specific binding of IgG to the Fc region of the antibody, while the antibody protection is accomplished by the structural change restriction of ZIF-8 framework to the antibody. Consequently, the antibody exhibits enhanced target capability and significantly improved tolerance to organic solvents. The ZIF-8/IgG/anti-AFT was employed for the purification and detection of AFTs by coupling with UPLC. Under optimized conditions, the recoveries of spiked AFTs in peanut oils are between 86.1% and 106.4%, with relative standard deviations (RSDs) ranging from 0.8% to 8.8%. The linearity range is 0.5-20.0 ng for AFB1 and AFG1, 0.125-5.0 ng for AFB2 and AFG2, the limit of detection is 0.1 ng for AFB1 and AFG1, 0.03 ng for AFB2 and AFG2.

Instant catapult steam explosion combined with ammonia water: A complex technology for detoxification of aflatoxin-contaminated peanut cake with the aim of producing a toxicity-free and nutrients retention of animal feed

Aflatoxin is one of the most toxic biotoxins found in contaminated agricultural products. It has strong mutagenicity, carcinogenesis and teratogenicity to humans and animals. In this study, instant catapult steam explosion combined with ammonia water was examined for its potential to degrade aflatoxin B1 in peanut cake in order to improve its utilization as a toxic-free animal feed. Incubation of AFB1-containing peanut cake followed by processing with Instant Catapult Steam Explosion (ICSE) led to approximately 79.03 % degradation of AFB1, while the degradation of AFB1 was up to 91.48 % under the treatment of ICSE combined with 4 % NH₃·H₂O at 1.2 MPa in 200 s of process time. After treatment, nutrients in peanut cake were not significantly changed. The toxicity of AFB1 degradation products was evaluated and the results showed that the toxicity of these products were found to be substantially less than that possessed by AFB1. A low chemical pollution, efficient and toxic-free technology system of AFB1 degradation was established, which detoxify aflatoxin-contaminated biomass for sustainable and safe utilization of agricultural biomass as animal feed.

Degradation of Toxins Derived from Foodborne Pathogens by Atmospheric-Pressure Dielectric-Barrier Discharge

Foodborne diseases can be attributed not only to contamination with bacterial or fungal pathogens but also their associated toxins. Thus, to maintain food safety, innovative decontamination techniques for toxins are required. We previously demonstrated that an atmospheric-pressure dielectric-barrier discharge (APDBD) plasma generated by a roller conveyer plasma device is effective at inactivating bacteria and fungi in foods. Here, we have further examined whether the roller conveyer plasma device can be used to degrade toxins produced by foodborne bacterial pathogens, including aflatoxin, Shiga toxins (Stx1 and Stx2), enterotoxin B and cereulide. Each toxin was spotted onto an aluminum plate, allowed to dry, and then treated with APDBD plasma applied by the roller conveyer plasma device for different time periods. Assessments were conducted using a competitive enzyme-linked immunosorbent assay (ELISA) and liquid chromatography-tandem mass spectrometry (LC-MS/MS). The results demonstrate a significant time-dependent decrease in the levels of these toxins. ELISA showed that aflatoxin B1 concentrations were reduced from 308.6 µg/mL to 74.4 µg/mL within 1 min. For Shiga toxins, Stx1 decreased from 913.8 µg/mL to 65.1 µg/mL, and Stx2 from 2309.0 µg/mL to 187.6 µg/mL within the same time frame (1 min). Enterotoxin B levels dropped from 62.67 µg/mL to 1.74 µg/mL at 15 min, and 1.43 µg/mL at 30 min, but did not display a significant decrease within 5 min. LC-MS/MS analysis verified that cereulide was reduced to below the detection limit following 30 min of APDBD plasma treatment. Taken together, these findings highlight that a range of foodborne toxins can be degraded by a relatively short exposure to plasma generated by an APDBD using a roller conveyer device. This technology offers promising advancements in food safety, providing a novel method to alleviate toxin contamination in the food processing industry.

Relevant mycotoxins in oil crops, vegetable oils, de-oiled cake and meals: Occurrence, control, and recent advances in elimination

Mycotoxins in agricultural commodities have always been a concern due to their negative impacts on human and livestock health. Issues associated with quality control, hot and humid climate, improper storage, and inappropriate production can support the development of fungus, causing oil crops to suffer from mycotoxin contamination, which in turn migrates to the resulting oil, de-oiled cake and meals during the oil processing. Related research which supports the development of multi-mycotoxin prevention programs has resulted in satisfactory mitigation effects, mainly in the pre-harvest stage. Nevertheless, preventive actions are unlikely to avoid the occurrence of mycotoxins completely, so removal strategies may still be necessary to protect consumers. Elimination of mycotoxin has been achieved broadly through the physical, biological, or chemical course. In view of the steadily increasing volume of scientific literature regarding mycotoxins, there is a need for ongoing integrated knowledge systems. This work revisited the knowledge of mycotoxins affecting oilseeds, food oils, cake, and meals, focusing more on their varieties, toxicity, and preventive strategies, including the methods adopted in the decontamination, which supplement the available information.

Global systematic review and meta-analysis on prevalence and concentration of aflatoxins in peanuts oil and probabilistic risk assessment

Exposure to mycotoxins in food is largely unavoidable, and concerns about their health effects are growing. Consumption of vegetable oils such as peanuts oil has increased, hence several studies have been conducted on concentration of aflatoxins (AFs) in peanuts oil. Search was performed in Scopus and PubMed databases on prevalence and concentration of AFs in peanuts oil from 1 January 2005 to 15 April 29, 2022. Prevalence and concentration of AFs in peanuts oil was meta-analyzed based on country and type of AFs subgroups. In addition, health risk was calculated using monte carlo simulation method. Pooled prevalence of AFB1 in peanuts oil was 47.9%; AFB2, 46.45%; AFG1, 46.92% and AFG2, 54.01%. The Overall prevalence of AFTs was 49.30%, 95%CI (35.80-62.84%). Pooled concentration of AFB1 in peanuts oil was 2.30 μg/kg; AFB2, 0.77 μg/kg; AFG1, 0.07 μg/kg; AFG1, 0.28 μg/kg. The sort of country based on mean of MOEs in the adults consumers was Japan (47,059) > China (17,670) > Ethiopia (7,398) > Sudan (6,974) > USA (1,012) and sort of country based on mean of MOEs in the children was Japan (120,994) > China (46,991) > Ethiopia (19,251) > Sudan (18,200) > USA (2,620). Therefore, adults consumers were in considerable health risk in Ethiopia, Sudan and USA and for children in USA (MOE < 10,000).

Current physical techniques for the degradation of aflatoxins in food and feed: Safety evaluation methods, degradation mechanisms and products

Aflatoxins are the most toxic natural mycotoxins discovered so far, posing a serious menace to the food safety and trading economy of the world, especially developing countries. How to effectively detoxify has persistently occupied a place on the list of "global hot-point" concerns. Among the developed detoxification methods, physical methods, as the authoritative techniques for aflatoxins degradation, could rapidly induce irreversible denaturation of aflatoxins. This review presents a brief overview of aflatoxins detection and degradation product structure identification methods. Four main safety evaluation methods for aflatoxins and degradation product toxicity assessment are highlighted combined with an update on research of aflatoxins decontamination in the last decade. Furthermore, the latest applications, degradation mechanisms and products of physical aflatoxin decontamination techniques including microwave heating, irradiation, pulsed light, cold plasma and ultrasound are discussed in detail. Regulatory issues related to "detoxification" are also explained. Finally, we put forward the challenges and future work in studying aflatoxin degradation based on the existing research. The purpose of supplying this information is to help researchers have a deeper understanding on the degradation of aflatoxins, break through the existing bottleneck, and further improve and innovate the detoxification methods of aflatoxins.

Isolation and Optimization of Aflatoxin B1 Degradation by Uniform Design and Complete Genome Sequencing of Novel Deep-Sea Kocuria rosea Strain 13

Aflatoxin B1 is a natural carcinogenic mycotoxin. The biological detoxification of aflatoxin could result in less environmental pollution, more moderate conditions, and less impact on food and feed, and be more convenient than physical and chemical methods. In this study, strain 13 with aflatoxin B1 degradation activity (67.47 ± 1.44%) was isolated and identified as Kocuria rosea. A uniform design was applied to optimize the degradation activity using a software Data Processing System, and a quadratic polynomial stepwise regression model was selected to investigate the relationships between the degradation rate and five independent variables. Furthermore, the optimal degradation conditions (culture temperature of 30 °C, culture time of 4.2 days, seawater ratio of 100%, pH of 7.11, and inoculation dosage of 0.09%) were verified with a degradation rate of 88 ± 0.03%, which was well matched with the predicted value (92.97%) of the model. Complete genome sequencing of Kocuria rosea, conducted with a combination of Illumina and single-molecule real-time sequencing, was used to analyze the genomic features and functions of the strain, which were predicted by the annotation based on seven databases, and may provide insights into the potential of Kocuria rosea, as well as providing a reference for degradation gene and protein mining. These results indicate that Kocuria rosea strain 13 has the ability to degrade aflatoxin B1 efficiently, and it also has the potential to provide aflatoxin-degrading enzymes.

Identification and Safety Evaluation of Ochratoxin A Transformation Product in Rapeseed Oil Refining Process

Ochratoxin A (OTA) is an important mycotoxin detected in edible oil, and it can be effectively removed by classical edible oil refining processes. However, the fate of OTA in the refining process has not been reported. In this study, we systematically tracked the OTA changes during the oil refining process by fortifying 100 μg/kg OTA in crude rapeseed oil. Results showed that about 10.57%, 88.85%, and 0.58% of OTA were removed during the degumming, deacidification, and decolorization processes. Among them, 16.25% OTA was transferred to the byproducts, including 9.85% in degumming wastewater, 5.68% in soap stock, 0.14% in deacidification wastewater, and 0.58% in the decolorizer; 83.75% OTA was found to transform into the lactone ring opened OTA (OP-OTA) during the deacidification stage, which is attributed to the hydrolysis of the lactone ring of OTA in the alkali refining. The OP-OTA was verified to distribute in the soap stock, and small amounts of OP-OTA could be transferred to deacidified wastewater when the OTA pollution level reached 500 μg/kg in crude rapeseed oil. The OP-OTA exhibited strong toxicity, especially nephrotoxicity, as reflected by the cell viability assay and in silico toxicity. Therefore, the safety of the soap stock processing products from OTA-contaminated rapeseed deserves attention.

Application of Non-Aflatoxigenic Aspergillus flavus for the Biological Control of Aflatoxin Contamination in China

Biological control through the application of competitive non-aflatoxigenic Aspergillus flavus (A. flavus) to the soil during peanut growth is a practical method for controlling aflatoxin contamination. However, appropriate materials need to be found to reduce the cost of biocontrol products. In this study, a two-year experiment was conducted under field conditions in China, using a native non-aflatoxigenic strain to explore its effect. After three months of storage under high humidity, aflatoxin levels remained low in peanuts from fields treated with the biocontrol agent. Three types of substrates were tested with the biocontrol agent: rice grains, peanut meal (peanut meal fertilizer) and peanut coating. Compared to untreated fields, these formulations resulted in reductions of 78.23%, 67.54% and 38.48%, respectively. Furthermore, the ratios of non-aflatoxigenic A. flavus recovered in the soils at harvest in the treated fields were between 41.11% and 96.67% higher than that in untreated fields (25.00%), indicating that the rice inoculum was the most effective, followed by the peanut meal fertilizer and peanut coating. In 2019, the mean aflatoxin content of freshly harvested peanuts in untreated fields was 19.35 µg/kg higher than that in the fields treated with 7.5 kg/ha rice inoculum, which was 1.37 µg/kg. Moreover, no aflatoxin was detected in the two other plots treated with 10 and 15 kg/ha rice inoculum. This study showed that the native Chinese non-aflatoxigenic strain of A. flavus (18PAsp-zy1) had the potential to reduce aflatoxin contamination in peanuts. In addition, peanut meal can be used as an alternative substrate to replace traditional grains, reducing the cost of biocontrol products.

Identification of Deoxynivalenol and Degradation Products during Maize Germ Oil Refining Process

Deoxynivalenol (DON) contamination in germs and germ oil is posing a serious threat to food and feed security. However, the transformation pathway, the distribution of DON, and its degradation products in edible oil refining have not yet been reported in detail. In this work, we systematically explored the variation of DON in maize germ oil during refining and demonstrated that the DON in germ oil can be effectively removed by refining, during which a part of DON was transferred to the wastes, and another section of DON was degraded during degumming and alkali refining. Moreover, the DON degradation product was identified to be norDON B by using the ultraviolet absorption spectrum, high-performance liquid chromatography (HPLC), ultra-high-performance liquid chromatography-quadrupole time-of-flight mass spectrometry (UPLC-Q-TOF MS), and nuclear magnetic resonance (NMR) methods, and the degradation product was found to be distributed in waste products during oil refining. This study provides a scientific basis and useful reference for the production of non-mycotoxins edible oil by traditional refining.

Burden of Disease Associated with Dietary Exposure to Aflatoxins in China in 2020

Aflatoxins (AFTs), as a group 1 carcinogen, could lead to hepatocellular carcinoma (HCC). Dietary intake is the primary way of AFT exposure in humans. However, the contribution of foodborne AFT intake to the HCC burden remains unknown in recent years in China. Hence, the present study was conducted to estimate the burden of HCC attributed to foodborne AFT exposure by using disability-adjusted life years (DALYs). The risk assessment was used to estimate the incidence of HCC related to AFT exposure. Concentrations of AFTs in peanuts, peanut oil, corn, and corn products were retrieved from literature published between 2010 and 2020 in China. Corresponding daily food consumption data were obtained from two nationwide Chinese surveys. A direct approach was used to calculate DALY and DALY rates to quantify the HCC burden attributed to dietary AFT exposure. The total amount of AFT intake through peanut, peanut oil, corn, and corn products was 4.018 ng/kg bw/day resulting in 0.125 extra HCC cases per year/100,000 persons, corresponding to a DALY number and DALY rate of 21,625.08 and 1.53 per 100,000 population, respectively. Regionally, DALYs were high in Guangxi and Guangdong provinces, corresponding to 5948 and 5595 DALYs. A total of 1.5 DALYs/100,000 were lost due to the AFT exposure. DALYs per 100,000 population were higher in several coastal areas. Though the disease burden of HCC caused by dietary AFTs was low in the Chinese population, a high health risk was found in the residents of some areas with high AFT exposure. AFTs are still a health challenge for the Chinese people.

Spatial analysis of dietary exposure of aflatoxins in peanuts and peanut oil in different areas of China

Peanuts in China are heavily contaminated with aflatoxin, which pose a threaten to human health. To compare the dietary exposure risk of aflatoxins (AFT) in peanuts and peanut oil in different areas of China, the spatial distribution of AFT contamination levels in peanuts and peanut oil from different areas was analyzed. The dietary exposure was calculated by simple distributed risk assessment method before characterizing the health risk using both the margin of exposure (MOE) approach proposed by the European Food Safety Authority (EFSA) and the quantitative liver cancer risk approach proposed by the Joint Food and Agricultural Organization/World Health Organization (FAO/WHO) Expert Committee on Food Additives (JECFA). The results showed that the AFT content in peanuts and peanut oil was high with agglomeration in several provinces of East and South China under a subtropical temperate monsoon climate, and the AFT contamination in peanut oil was more substantial than peanuts. On average, the estimated dietary exposure to AFT from the total of peanuts and peanut oil for Chinese general population ranged from 1.776 to 1.940 ng/kg bw/day (LB-UB), from which the MOE values of 88-96 (UB-LB) and liver cancer risk of 0.055-0.060 cases/100,000 persons/year (LB-UB) were calculated. As for different areas in China, the mean AFT exposure ranged between 0.000 and 17.270 ng/kg bw/day. Moreover, the corresponding health risk was estimated at 10-868759 MOE values and 0.000-0.851 liver cancer cases/100,000 persons/year. Guangdong, Fujian and Jiangxi provinces were at a higher risk rank. The liver cancer risk of AFT exposure from peanuts and peanut oil was far below all-cause liver cancer incidence (18.0 cases/100,000 persons/year) in China, but several areas with relatively high risk should be of concern. Compared with other age groups, children aged 2-6 years should be paid more attention because they have the highest AFT exposure level.

One-step deep eutectic solvent strategy for efficient analysis of aflatoxins in edible oils

BACKGROUND

Aflatoxins, a kind of carcinogen, have attracted increasing attention due to their toxicity and harmfulness to human health. Traditional methods for aflatoxins analysis usually involve tedious extraction steps with a subsequent derivatization process. Herein, a simple and efficient liquid-phase microextraction method based on deep eutectic solvents (DESs) for direct analysis of aflatoxins was developed.

RESULTS

Adopting DESs as the extractant, we surprisingly found out that DESs could either achieve good extraction performance or play a similar role to the derivatization agent, achieving an enhancement of fluorescence intensity for direct analysis of aflatoxins by high-performance liquid chromatography combined with fluorescent detection. Under optimal conditions obtained by response surface methodology, the method provided satisfactory linear ranges (0.01-0.75 μg kg^-1 for AFB1 and AFG1, 0.003-0.25 μg kg^-1 for AFB2 and AFG2) with good determination coefficients (R²  > 0.9988), a low detection limit (0.0005-0.003 μg kg^-1 ), and good recovery rates (72.05-113.54%).

CONCLUSION

These results highlighted superiorities of the one-step DES strategy for analysis of aflatoxins in edible oils, providing insights for future development of efficient methods in food analysis. © 2020 Society of Chemical Industry.

Edible Plant Oil: Global Status, Health Issues, and Perspectives

Edible plant oil (EPO) is an indispensable nutritional resource for human health. Various cultivars of oil-bearing plants are grown worldwide, and the chemical compositions of different plant oils are diverse. The extremely complex components in oils lead to diverse standards for evaluating the quality and safety of different EPOs. The environment poses great challenges to the EPO safety and quality during the entire industrial chain, including plant cultivation, harvesting, oil processing, and storage. Environmental risk factors include heavy metal or pesticide residue pollution, insect or harmful microbial infestation, and rancidity. Here, the diverse components in oil and various oil-producing processes are discussed, including plant species, oil yield, and composition complexity, environmental factors that degrade oil quality. Additionally, we propose a whole-industrial-chain monitoring system instead of current single-link-monitoring approach by monitoring and tracking the quality and safety of EPOs during the entire process of plant cultivation, raw materials harvest, oil process, and EPOs storage. This will provide guidance for monitoring the quality and safety of EPOs, which were challenged by the deteriorating environment.

Application of natural cotton fibers as an extraction sorbent for the detection of trans-resveratrol in adulterated peanut oils

The current study develops an effective, convenient, low-cost, and environmentally friendly method for determining trans-resveratrol (TRA) in peanut oils, the unique proportion of peanut oil, by employing natural cotton fibers without any pretreatment as extraction sorbent and an in-syringe extraction device. The primary factors affecting the extraction recovery are optimized in detail. The condition of 200.0 mg of cotton fibers, six push-pull times, 2.0 mL of n-hexane as washing solvent and 2.0 mL of ethanol as desorption solvent is selected as the best. The linear range is demonstrated to be 10-1000 ng/g with a satisfactory correlation coefficient (R² = 0.9995), while the limit of detection is calculated as 2.47 ng/g. In addition, the recoveries of TRA are obtained in the range of 93.8-104.4% with RSDs less than 5.5%. Finally, the developed method is successfully applied to determine TRA concentrations in commercial peanut oils and other edible oils.

Statistical optimization of cultural variables for enzymatic degradation of aflatoxin B1 by Panus neostrigosus

The aim of this study is to determine the best aflatoxin B₁ degradation conditions which was optimized using a combination of the Plackett-Burman and Box-Behnken methods with Panus neostrigosus culture filtrate. Panus neostrigosus was grown in a modified Kirk Broth medium to determine optimal degradation conditions. As a result, aflatoxin B₁ was degraded under varying culture conditions. The Plackett-Burman method was designed after sixteen different experiments with fifteen variables. The three most effective variables (Sucrose, yeast extract, wheat bran) were chosen for the Box-Behnken methodology. The aflatoxin B₁ degradation rate was 49% in just 1 h exposure to culture filtrate which was obtained under optimal growth conditions; (g-ml/L) sucrose 10, yeast extract 3, wheat bran 3, soytone 5, KH₂PO₄ 2, MgSO₄.7H₂O 0.5, CaCl₂.H₂O 0.1, ammonium tartrate 2, trace element solution 10; 28 °C of incubation temperature, medium pH 5, 7.5% inoculum rate, 125 rpm of agitation speed, and a twelve-day incubation period. The SDS-PAGE studies show that the enzyme responsible for AFB₁ degradation has 38 kDa molecular weight and has no laccase or MnP activity. To the best of our knowledge, this is the first report for AFB₁ degradation by Panus neostrigosus.

A New Laccase of Lac 2 from the White Rot Fungus Cerrena unicolor 6884 and Lac 2-Mediated Degradation of Aflatoxin B1

Aflatoxin B₁ (AFB₁) is a known toxic human carcinogen and can be detoxified by laccases, which are multicopper oxidases that convert several environmental pollutants and toxins. In this study, a new laccase that could catalyze AFB₁ degradation was purified and identified from the white-rot fungus Cerrena unicolor 6884. The laccase was purified using (NH₄)₂SO₄ precipitation and anion exchange chromatography, and then identified as Lac 2 through zymogram and UHPLC-MS/MS based on the Illumina transcriptome analysis of C. unicolor 6884. Six putative laccase protein sequences were obtained via functional annotation. The lac 2 cDNA encoding a full-length protein of 512 amino acids was cloned and sequenced to expand the fungus laccase gene library for AFB₁ detoxification. AFB₁ degradation by Lac 2 was conducted in vitro at pH 7.0 and 45 °C for 24 h. The half-life of AFB₁ degradation catalyzed by Lac 2 was 5.16 h. Acetosyringone (AS), Syrinagaldehyde (SA) and [2,2' -azino-bis-(3-ethylbenzothiazoline-6-sulfonic acid)] (ABTS) at 1 mM concentration seemed to be similar mediators for strongly enhancing AFB₁ degradation by Lac 2. The product of AFB₁ degradation catalyzed by Lac 2 was traced and identified to be Aflatoxin Q₁ (AFQ₁) based on mass spectrometry data. These findings are promising for a possible application of Lac 2 as a new aflatoxin oxidase in degrading AFB₁ present in food and feeds.

Antifungal Effect of Camellia Seed Cake Extract on Aspergillus flavus

HIGHLIGHTS

The antifungal effect of the active substance in camellia seed cake is evaluated on Aspergillus flavus. The n-butanol phase exhibited an apparent antagonistic effect on A. flavus. A reference and a guide for natural antifungal agents is provided. Knowledge of the utilization of the by-products of camellia seed is broadened.

Oxidase or peptidase? A computational insight into a putative aflatoxin oxidase from Armillariella tabescens

Aflatoxin oxidase (AFO), an enzyme isolated from Armillariella tabescens, has been reported to degrade aflatoxin B1 (AFB1). However, recent studies reported sequence and structure similarities with the dipeptidyl peptidase III (DPP III) family of enzymes and confirmed peptidase activity toward DPP III substrates. In light of these investigations, an extensive computational study was performed in order to improve understanding of the AFO functions. Steered MD simulations revealed long-range domain motions described as protein opening, characteristic for DPPs III and necessary for substrate binding. Newly identified open and partially open forms of the enzyme closely resemble those of the human DPP III orthologue. Docking of a synthetic DPP III substrate Arg₂ -2-naphthylamide revealed a binding mode similar to the one found in crystal structures of human DPP III complexes with peptides with the S1 and S2 subsites' amino acid residues conserved. On the other hand, no energetically favorable AFB1 binding mode was detected, suggesting that aflatoxins are not good substrates of AFO. High plasticity of the zinc ion coordination sphere within the active site, consistent with that of up to date studied DPPs III, was observed as well. A detailed electrostatic analysis of the active site revealed a predominance of negatively charged regions, unsuitable for the binding of the neutral AFB1. The present study is in line with the most recent experimental study on this enzyme, both suggesting that AFO is a typical member of the DPP III family.

Aflatoxins in peanut oil: food safety concerns

Aflatoxins are widely recognised as important natural contaminants of a wide range of foods, including maize and peanuts (groundnuts), which form part of the staple diet in many countries of the developing world, especially in Africa. There is a frequent misconception based on solubility considerations and developed market surveys that aflatoxins do not occur in peanut oil. Thus, the use of peanut oil in human food is frequently overlooked as a source of aflatoxin exposure, yet artisanal oil extraction from contaminated peanuts in local facilities in the developing world results in carryover of these mycotoxins into the oil. Consequently, these peanut oils can have high contamination levels. This review highlights food safety concerns and addresses inter alia the analytical adaptations required to determine the polar aflatoxins in peanut oil. The determination of aflatoxins in peanut oil was first achieved by thin-layer chromatography, which was later mostly superseded by high-performance liquid chromatography (HPLC) with fluorescence detection, or later, by mass spectrometric detection. More recently, a specially modified HPLC method with immunoaffinity column clean-up and fluorescence detection has achieved official method status at AOAC International. In addition, the review deals with toxicology, occurrence and detoxification of contaminated oil. Although various methods have been reported for detoxification of peanut oil, the toxicity of degradation products, the removal of beneficial constituents and the effect on its organoleptic properties need to be considered. This review is intended to draw attention to this often overlooked area of food safety.