Cleaning and Disinfecting Gastrointestinal Endoscopy Equipment

Evaluation of plasma activated liquids for the elimination of mixed species biofilms within endoscopic working channels

The use of reusable flexible endoscopes has increased dramatically over the past decade, however despite improvements in endoscope reprocessing, the continued emergence of endoscopy-associated outbreaks as a result of multi-drug resistant bacteria has highlighted the need for a new approach to disinfection. Here, the use of plasma activated liquids (PALs) for the elimination of mixed species biofilm contamination within the working channels of endoscopes was evaluated. Cold atmospheric pressure plasma was used to chemically activate water and a commercially available pH buffered peracetic acid to create PALs. Polytetrafluoroethylene endoscope surrogate test pieces were contaminated with clinically relevant mixed species biofilms. The efficacy of PALs for the decontamination of narrow lumens was compared against the commercial disinfectant. Plasma activation was found to increase the antibiofilm capabilities of pH buffered peracetic acid by introducing reactive chemical species into the solution. Disinfection of endoscopic test pieces with plasma activated disinfectant (PAD) resulted in a 7.30 log10 reduction of biofilm contamination in 5 min, surpassing the 4.39 log10 reduction observed with the currently used endoscope disinfection method. PAD also resulted in reduced regrowth and recolonization of the surface of the endoscopic test pieces. Minimal changes to the surface morphology and composition were observed following exposure to PAD in comparison to the commercial disinfectant, suggesting the developed approach is no more aggressive than current disinfection approaches.

A New Drying Method of Thermolabile Flexible Endoscope Channels by Laminar and Turbulent Airflow: A Prospective, Randomized-Controlled, Single-Center, Proof-of-Concept Trial

INTRODUCTION

International guidelines suggest different possibilities for drying of endoscopes during reprocessing. Clinical results of these available drying methods are not satisfactory. The aim of this study was to compare the drying cycle of a standard endoscope washer-disinfector (EWD) (standard drying method [SD]) with a shortened mandatory drying by the EWD followed by a special drying device using laminar and turbulent air flow (novel drying method [ND]).

METHODS

Sixty endoscopes (duodenoscopes, colonoscocopes, and gastroscopes) from 3 different manufacturers underwent high-level disinfection and drying depending on the randomization group. Operational time of drying was measured for both groups. Residual fluid in the channels was measured using a laboratory scale. After a 14-day storage period, a sample of the endoscope channels was obtained to determine bacterial contamination.

RESULTS

ND had significantly fewer residual water in endoscope channels (SD: 90% vs ND: 0%; P < 0.001) after high-level disinfection and drying and less bacterial contamination after storage for 14 days (SD: 47% vs ND: 20%; P = 0.028). Time consumed for drying in ND was also significantly shorter (SD: 16 minutes 4 seconds vs ND: 5 minutes 59 seconds; P < 0.001).

DISCUSSION

Drying with a special automatic drying device was superior compared with an EWD's drying program as evidenced by no measurable residual water, reduced microbiological contamination, and a more than 2-fold decrease in operational time. Thus, drying by laminar and turbulent airflow may represent an attractive alternative to the currently used standard approach in the reprocessing process of flexible endoscopes.

UV-C side-emitting optical fiber-based disinfection: a promising approach for infection control in tight channels

The growth of pathogenic bacteria in moist and wet surfaces and tubing of medically relevant devices results in serious infections in immunocompromised patients. In this study, we investigated and demonstrated the successful implementation of a UV-C side-emitting optical fiber in disinfecting medically relevant pathogenic bacteria (Pseudomonas aeruginosa and Methicillin-resistant Staphylococcus aureus [MRSA]) within tight channels of polytetrafluoroethylene (PTFE). PTFE is a commonly used material both in point-of-use (POU) water treatment technologies and medical devices (dental unit water line [DUWL], endoscope). For a 1-m-long PTFE channel, up to ≥6 log inactivation was achieved using a 1-m-long UV side-emitting optical fiber (SEOF) with continuous 16-h exposure of low UV-C radiation ranging from ~0.23 to ~29.30 μW/cm2. Furthermore, a linear model was used to calculate the inhibition zone constant (k`), which enables us to establish a correlation between UV dosage and the extent of inactivated surface area (cm2) for surface-bound Escherichia coli on a nutrient-rich medium. The k` value for an irradiance ranging from ~150 to ~271.50 μW/cm2 was calculated to be 0.564 ± 0.6 cm·cm2/mJ. This study demonstrated the efficacy of SEOFs for disinfection of medically relevant microorganisms present in medically and domestically relevant tight channels. The impact of the results in this study extends to the optimization of operational efficiency in pre-existing UV surface disinfection setups that currently operate at UV dosages exceeding the optimal levels.IMPORTANCEGermicidal UV radiation has gained global recognition for its effectiveness in water and surface disinfection. Recently, various works have illustrated the benefit of using UV-C side-emitting optical fibers (SEOFs) for the disinfection of tight polytetrafluoroethylene (PTFE) channels. This study now demonstrates its impact for disinfection of medically relevant organisms and introduces critical design calculations needed for its implementation. The flexible geometry and controlled emission of light in these UV-SEOFs make them ideal for light distribution in tight channels. Moreover, the results presented in this manuscript provide a novel framework that can be employed in various applications, addressing microbial contamination and the disinfection of tight channels.

Effectiveness of a training program on health-care professionals' knowledge and practices regarding thermo-sensitive reusable medical devices disinfection: A quasi-experimental study

INTRODUCTION

Appropriate knowledge of healthcare professionals (HCPs) on the various aspects of disinfection and reuse of medical devices is a basic requirement to ensure proper disinfection and to minimize the risk of healthcare associated infections. In this regard this study aimed to assess the effectiveness of a training intervention on knowledge and practices regarding thermosensitive reusable medical devices (TRMD) disinfection among HCPs.

METHODS

This was a quasi-experimental study including a pre-test, an intervention (workshops, demonstrations, posters), and a post-test evaluation of the HCPs' knowledge and practices regarding the disinfection of TRMD. It was conducted between February and July 2022 at Hedi Chaker University hospital, Sfax, Southern Tunisia.

RESULTS

Overall, 31 participants were females (54.4%). The global Knowledge Score (KS) had significantly risen from pre-to post-training test (61.0 ± 9 vs 74.0 ± 12.5; p < 0.001). According to the disinfection type, the KS of non-critical and critical TRMD disinfection had significantly increased between pre and post-intervention (60 (IQR = [40.0-80.0]) vs 80 (IQR = [40.0-80.0]), p < 0.001) and (66.6 (IQR = [50.0-66.6]) vs 83.3 (IQR = [66.6-100.0]); p < 0.001) respectively. The mean change in global KS of TRMD disinfection was statistically higher among females (17.5 ± 11.2 vs 8.5 ± 3.2; p = 0.006) and medical staff (18.9 ± 11.9 vs 7.1 ± 3.9; p = 0.019). Conformity scores did not significantly change after the training program (58.1 ± 22.7 vs 63.7 ± 19.6; p = 0.678).

CONCLUSION

This study highlighted the effectiveness of the training intervention on HCP knowledge. However, practices were not improved. Conducting ongoing audits with on-the-job training is extremely needed.

How biofilm changes our understanding of cleaning and disinfection

Biofilms are ubiquitous in healthcare settings. By nature, biofilms are less susceptible to antimicrobials and are associated with healthcare-associated infections (HAI). Resistance of biofilm to antimicrobials is multifactorial with the presence of a matrix composed of extracellular polymeric substances and eDNA, being a major contributing factor. The usual multispecies composition of environmental biofilms can also impact on antimicrobial efficacy. In healthcare settings, two main types of biofilms are present: hydrated biofilms, for example, in drains and parts of some medical devices and equipment, and environmental dry biofilms (DSB) on surfaces and possibly in medical devices. Biofilms act as a reservoir for pathogens including multi-drug resistant organisms and their elimination requires different approaches. The control of hydrated (drain) biofilms should be informed by a reduction or elimination of microbial bioburden together with measuring biofilm regrowth time. The control of DSB should be measured by a combination of a reduction or elimination in microbial bioburden on surfaces together with a decrease in bacterial transfer post-intervention. Failure to control biofilms increases the risk for HAI, but biofilms are not solely responsible for disinfection failure or shortcoming. The limited number of standardised biofilm efficacy tests is a hindrance for end users and manufacturers, whilst in Europe there are no approved standard protocols. Education of stakeholders about biofilms and ad hoc efficacy tests, often academic in nature, is thus paramount, to achieve a better control of biofilms in healthcare settings.

Criteria for the Use, Processing, and Disposal of Flexible Endoscope Cleaning Brushes

Objectives: To ensure effectiveness in the endoscope channel cleaning process, using functional brushes that are in good condition is necessary. This study sought to identify the criteria for acquiring, using, and disposing of cleaning brushes at endoscopy facilities in Brazil. We further sought to evaluate the conditions of the cleaning brushes in use in the facilities. Methods: This cross-sectional study was conducted between July 2021 and January 2022. Personnel responsible for processing endoscopes were interviewed regarding the use, processing, and disposal of flexible endoscope cleaning brushes. In addition, the brushes used to clean the equipment were inspected. Results: All participants interviewed reported the practice of brushing endoscope channels. Of them, 60% noted the use of disposable brushes, with 40% using reusable brushes. None of the facilities interviewed reported discarding disposable brushes after use. The protocols for disposal of brushes included disposing due to bristle wear (70%), disposal at the end of the day (20%), and an absence of disposal protocols (10%). In addition, 30% of facilities did not clean the bristles before reintroducing them into the channel/lumen, and no facility had an established routine for cleaning brushes between uses. Inspection of brushes revealed that only 20% of facilities had new brushes with no signs of wear or damage. Conclusion: The use of inappropriate brushes/sponges for cleaning endoscope channels and the lack of criteria for the reuse and disposal of brushes increases the risk of cross-contamination, internal damage to channels, and biofilm formation.

Recent Advances in Endoscope Disinfection: Where Do We Stand in the COVID era?

Over 16 million cases worldwide, severe acute respiratory syndrome coronavirus 2 has profoundly affected healthcare as we know it. Given reports of gastrointestinal involvement and viral shedding in the stool, it is unsurprising there are concerns that endoscopic equipment may be a potential vector of viral transmission. Here, we provide an overview of existing practices for endoscope reprocessing, recent developments in the field, and challenges in the COVID-19 environment. Current multi-society guidelines do not advise any change to endoscope disinfection protocols but emphasize strict adherence to recommended practices. However, endoscopy reprocessing staff may benefit from supplemental personal protective equipment measures, especially in high risk situations. Because thorough endoscope reprocessing is highly operator dependent, adequate training of personnel is critical for proper manual cleaning and disinfection of endoscopes that have potential to harbor virus. Bacterial contamination of duodenoscopes has caused outbreaks of infection from multidrug-resistant organisms, highlighting vulnerable areas. The emphasis of current studies is on optimization of disinfection and drying, minimization of simethicone use, and on quality control of endoscope reprocessing with sampling and microbiological culturing. Recent advances include novel approaches to endoscope sterilization, infection barrier methods, and design of partially or fully disposable duodenoscopes. Overall, the available data indicate that, when correctly executed, current reprocessing practices are sufficient in preventing SARS-COV-2 transmission.