1
|
Liu C, Gao J, Jiang H, Sun J, Gao X, Mao X. Value-added utilization technologies for seaweed processing waste in a circular economy: Developing a sustainable modern seaweed industry. Compr Rev Food Sci Food Saf 2024; 23:e70027. [PMID: 39379297 DOI: 10.1111/1541-4337.70027] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/30/2024] [Revised: 09/05/2024] [Accepted: 09/06/2024] [Indexed: 10/10/2024]
Abstract
The global seaweed industry annually consumes approximately 600,000 tons of dried algal biomass to produce algal hydrocolloids, yet only 15-30% of this biomass is utilized, with the remaining 70-85% discarded or released as scum or wastewater during the hydrocolloid extraction process. This residual biomass is often treated as waste and not considered for further commercial use, which contradicts the principles of sustainable development. In reality, the residual algal biomass could be employed to extract additional biochemical components, such as pigments, proteins, and cellulose, and these ingredients have important application prospects in the food sector. According to the biorefinery concept, recycling various products alongside the principal product enhances overall biomass utilization. Transitioning from traditional single-product processes to multi-product biorefineries, however, raises operating costs, presenting a significant challenge. Alternatively, developing value-added utilization technologies that target seaweed waste without altering existing processes is gaining traction among industry practitioners. Current advancements include methods such as separation and extraction of residual biomass, anaerobic digestion, thermochemical conversion, enzymatic treatment, functionalized modification of algal scum, and efficient utilization through metabolic engineering. These technologies hold promise for converting seaweed waste into alternative proteins, dietary supplements, and bioplastics for food packaging. Combining multiple technologies may offer the most effective strategy for future seaweed waste treatment. Nonetheless, most research on value-added waste utilization remains at the laboratory scale, necessitating further investigation at pilot and commercial scales.
Collapse
Affiliation(s)
- Chunhui Liu
- State Key Laboratory of Marine Food Processing and Safety Control, College of Food Science and Engineering, Ocean University of China, Qingdao, PR China
- Qingdao Key Laboratory of Food Biotechnology, Qingdao, PR China
- Key Laboratory of Biological Processing of Aquatic Products, China National Light Industry, Qingdao, PR China
| | - Jiale Gao
- State Key Laboratory of Marine Food Processing and Safety Control, College of Food Science and Engineering, Ocean University of China, Qingdao, PR China
- Qingdao Key Laboratory of Food Biotechnology, Qingdao, PR China
- Key Laboratory of Biological Processing of Aquatic Products, China National Light Industry, Qingdao, PR China
| | - Hong Jiang
- State Key Laboratory of Marine Food Processing and Safety Control, College of Food Science and Engineering, Ocean University of China, Qingdao, PR China
- Qingdao Key Laboratory of Food Biotechnology, Qingdao, PR China
- Key Laboratory of Biological Processing of Aquatic Products, China National Light Industry, Qingdao, PR China
- Sanya Ocean Research Institute, Ocean University of China, Sanya, China
| | - Jianan Sun
- State Key Laboratory of Marine Food Processing and Safety Control, College of Food Science and Engineering, Ocean University of China, Qingdao, PR China
- Qingdao Key Laboratory of Food Biotechnology, Qingdao, PR China
- Key Laboratory of Biological Processing of Aquatic Products, China National Light Industry, Qingdao, PR China
- Sanya Ocean Research Institute, Ocean University of China, Sanya, China
| | - Xin Gao
- State Key Laboratory of Marine Food Processing and Safety Control, College of Food Science and Engineering, Ocean University of China, Qingdao, PR China
- Qingdao Key Laboratory of Food Biotechnology, Qingdao, PR China
- Key Laboratory of Biological Processing of Aquatic Products, China National Light Industry, Qingdao, PR China
- Sanya Ocean Research Institute, Ocean University of China, Sanya, China
| | - Xiangzhao Mao
- State Key Laboratory of Marine Food Processing and Safety Control, College of Food Science and Engineering, Ocean University of China, Qingdao, PR China
- Qingdao Key Laboratory of Food Biotechnology, Qingdao, PR China
- Key Laboratory of Biological Processing of Aquatic Products, China National Light Industry, Qingdao, PR China
- Sanya Ocean Research Institute, Ocean University of China, Sanya, China
- Laboratory for Marine Drugs and Bioproducts, Qingdao Marine Science and Technology Center, Qingdao, PR China
| |
Collapse
|
2
|
ADOU KE, KOUAKOU AR, EHOUMAN AD, TYAGI RD, DROGUI P, ADOUBY K. Coupling anaerobic digestion process and electrocoagulation using iron and aluminium electrodes for slaughterhouse wastewater treatment. SCIENTIFIC AFRICAN 2022. [DOI: 10.1016/j.sciaf.2022.e01238] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/15/2022] Open
|
3
|
Maragoudaki L, Atsonios K, Kourkoumpas DS, Grammelis P. Process integration and scale up considerations of Typha domingensis macrophyte bioconversion into ethanol. Biochem Eng J 2022. [DOI: 10.1016/j.bej.2022.108404] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/02/2022]
|
4
|
Pocha CKR, Chia SR, Chia WY, Koyande AK, Nomanbhay S, Chew KW. Utilization of agricultural lignocellulosic wastes for biofuels and green diesel production. CHEMOSPHERE 2022; 290:133246. [PMID: 34906526 DOI: 10.1016/j.chemosphere.2021.133246] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/21/2021] [Revised: 11/21/2021] [Accepted: 12/08/2021] [Indexed: 06/14/2023]
Abstract
The ever-growing human population has resulted in the expansion of agricultural activity; evident by the deforestation of rainfoamrests as a means of acquiring fertile land for crops. The crops and fruits produced by such means should be utilized completely; however, there are still losses and under-exploitation of these produces which has resulted in wastes being mounted in landfills. These underutilized agricultural wastes including vegetables and fruits can serve as a potential source for biofuels and green diesel. This paper discusses the main routes (e.g., biological and thermochemical) for producing biofuels such as bioethanol, biodiesel, biogas, bio-oil and green diesel from underutilized crops by emphasizing recent technological innovations for improving biofuels and green diesel yields. The future prospects of a successful production of biofuels and green diesel by this source are also explained. Underutilized lignocelluloses including fruits and vegetables serve as a prospective biofuel and green diesel generation source for the future prosperity of the biofuel industry.
Collapse
Affiliation(s)
- Chaitanya Kumar Reddy Pocha
- School of Energy and Chemical Engineering, Xiamen University Malaysia, Jalan Sunsuria, Bandar Sunsuria, 43900, Sepang, Selangor, Malaysia
| | - Shir Reen Chia
- Institute of Sustainable Energy, Universiti Tenaga Nasional (UNITEN), Jalan IKRAM-UNITEN, 43000, Kajang, Selangor, Malaysia
| | - Wen Yi Chia
- Department of Chemical and Environmental Engineering, Faculty of Science and Engineering, University of Nottingham Malaysia, Jalan Broga, 43500, Semenyih, Selangor Darul Ehsan, Malaysia
| | - Apurav Krishna Koyande
- Department of Chemical and Environmental Engineering, Faculty of Science and Engineering, University of Nottingham Malaysia, Jalan Broga, 43500, Semenyih, Selangor Darul Ehsan, Malaysia
| | - Saifuddin Nomanbhay
- Institute of Sustainable Energy, Universiti Tenaga Nasional (UNITEN), Jalan IKRAM-UNITEN, 43000, Kajang, Selangor, Malaysia
| | - Kit Wayne Chew
- School of Energy and Chemical Engineering, Xiamen University Malaysia, Jalan Sunsuria, Bandar Sunsuria, 43900, Sepang, Selangor, Malaysia; College of Chemistry and Chemical Engineering, Xiamen University, Xiamen, 361005, Fujian, China.
| |
Collapse
|
5
|
Shahid MA, Maqbool N, Khan SJ. An integrated investigation on anaerobic membrane-based thickening of fecal sludge and the role of extracellular polymeric substances (EPS) in solid-liquid separation. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2022; 305:114350. [PMID: 34974220 DOI: 10.1016/j.jenvman.2021.114350] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/21/2021] [Revised: 11/21/2021] [Accepted: 12/18/2021] [Indexed: 06/14/2023]
Abstract
Pre-thickening or primary treatment of fecal sludge (FS) is a major bottleneck in designing fecal sludge treatment plants. This research demonstrates a practical analysis to improve the thickening efficiency of FS using woven fiber microfiltration membrane. A laboratory-scale anaerobic membrane-based thickening tank (MBTT) was investigated. Firstly, the system was operated with unconditioned FS at a flux range of 1-3 L/m2h. Secondly, the system was operated at an optimized flux of 2 L/m2h with conditioners, chitosan, and charcoal dust, at their optimized dosages reported in previous studies. It was observed that the solids accumulation in MBTT was linear and was specific to net solids accumulation. Feed FS was thickened to around 15% of total solids (TS) in 9-14 days. The overall solids accumulation rate was higher with conditioned FS. The less EPS accumulation and higher dewaterability in conditioned FS reduced the brushing frequency of the membrane and consequently, the average filtration duration per cycle was increased. Strong correlations of dewatering time with floc size, EPS, and electrical conductivity, indicated that higher EPS in FS tends to form flocs which can increase the dewatering rate in unstabilized FS. In permeate, the average TS and CODt removal observed were 72-78% and 87-91%, respectively.
Collapse
Affiliation(s)
- Muhammad Arslan Shahid
- Institute of Environmental Sciences and Engineering, School of Civil and Environmental Engineering, National University of Sciences and Technology (NUST), Sector H-12, Islamabad, Pakistan
| | - Nida Maqbool
- Institute of Environmental Sciences and Engineering, School of Civil and Environmental Engineering, National University of Sciences and Technology (NUST), Sector H-12, Islamabad, Pakistan
| | - Sher Jamal Khan
- Institute of Environmental Sciences and Engineering, School of Civil and Environmental Engineering, National University of Sciences and Technology (NUST), Sector H-12, Islamabad, Pakistan.
| |
Collapse
|
6
|
Jadhav P, Khalid ZB, Zularisam AW, Krishnan S, Nasrullah M. The role of iron-based nanoparticles (Fe-NPs) on methanogenesis in anaerobic digestion (AD) performance. ENVIRONMENTAL RESEARCH 2022; 204:112043. [PMID: 34543635 DOI: 10.1016/j.envres.2021.112043] [Citation(s) in RCA: 4] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/16/2021] [Revised: 08/25/2021] [Accepted: 08/26/2021] [Indexed: 06/13/2023]
Abstract
Several strategies have been proposed to improve the performance of the anaerobic digestion (AD) process. Among them, the use of various nanoparticles (NPs) (e.g. Fe, Ag, Cu, Mn, and metal oxides) is considered one of the most effective approaches to enhance the methanogenesis stage and biogas yield. Iron-based NPs (zero-valent iron with paramagnetic properties (Fe0) and iron oxides with ferromagnetic properties (Fe3O4/Fe2O3) enhance microbial activity and minimise the inhibition effect in methanogenesis. However, comprehensive and up-to-date knowledge on the function and impact of Fe-NPs on methanogens and methanogenesis stages in AD is frequently required. This review focuses on the applicative role of iron-based NPs (Fe-NPs) in the AD methanogenesis step to provide a comprehensive understanding application of Fe-NPs. In addition, insight into the interactions between methanogens and Fe-NPs (e.g. role of methanogens, microbe interaction and gene transfer with Fe-NPs) beneficial for CH4 production rate is provided. Microbial activity, inhibition effects and direct interspecies electron transfer through Fe-NPs have been extensively discussed. Finally, further studies towards detecting effective and optimised NPs based methods in the methanogenesis stage are reported.
Collapse
Affiliation(s)
- Pramod Jadhav
- Faculty of Civil Engineering Technology, Universiti Malaysia Pahang (UMP), Lebuhraya Tun Razak, Gambang, Kuantan, Pahang, 26300, Malaysia
| | - Zaied Bin Khalid
- Faculty of Civil Engineering Technology, Universiti Malaysia Pahang (UMP), Lebuhraya Tun Razak, Gambang, Kuantan, Pahang, 26300, Malaysia
| | - A W Zularisam
- Faculty of Civil Engineering Technology, Universiti Malaysia Pahang (UMP), Lebuhraya Tun Razak, Gambang, Kuantan, Pahang, 26300, Malaysia
| | - Santhana Krishnan
- Centre of Environmental Sustainability and Water Security (IPASA), Research Institute of Sustainable Environment (RISE), Faculty of Engineering, Universiti Teknologi Malaysia (UTM), Johor Bahru, 81310, Malaysia; PSU Energy Systems Research Institute, Department of Civil Engineering, Faculty of Engineering, Prince of Songkla University, Hat Yai, Songkhla, 90110, Thailand
| | - Mohd Nasrullah
- Faculty of Civil Engineering Technology, Universiti Malaysia Pahang (UMP), Lebuhraya Tun Razak, Gambang, Kuantan, Pahang, 26300, Malaysia.
| |
Collapse
|
7
|
Repurposing anaerobic digestate for economical biomanufacturing and water recovery. Appl Microbiol Biotechnol 2022; 106:1419-1434. [PMID: 35122155 DOI: 10.1007/s00253-022-11804-6] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/15/2021] [Revised: 01/18/2022] [Accepted: 01/23/2022] [Indexed: 11/02/2022]
Abstract
Due to mounting impacts of climate change, particularly increased incidence of drought, hence water scarcity, it has become imperative to develop new technologies for recovering water from nutrient-rich, water-replete effluents other than sewage. Notably, anaerobic digestate could be harnessed for the purpose of water recovery by repurposing digestate-borne minerals as nutrients in fermentative processes. The high concentrations of ammonium, phosphate, sulfate, and metals in anaerobic digestate are veritable microbial nutrients that could be harnessed for bio-production of bulk and specialty chemicals. Tethering nutrient sequestration from anaerobic digestate to bio-product accumulation offers promise for concomitant water recovery, bio-chemical production, and possible phosphate recovery. In this review, we explore the potential of anaerobic digestate as a nutrient source and as a buffering agent in fermentative production of glutamine, glutamate, fumarate, lactate, and succinate. Additionally, we discuss the potential of synthetic biology as a tool for enhancing nutrient removal from anaerobic digestate and for expanding the range of products derivable from digestate-based fermentations. Strategies that harness the nutrients in anaerobic digestate with bio-product accumulation and water recovery could have far-reaching implications on sustainable management of nutrient-rich manure, tannery, and fish processing effluents that also contain high amounts of water. KEY POINTS: • Anaerobic digestate may serve as a source of nutrients in fermentation. • Use of digestate in fermentation would lead to the recovery of valuable water.
Collapse
|
8
|
Kim JR, Karthikeyan KG. Effects of severe pretreatment conditions and lignocellulose-derived furan byproducts on anaerobic digestion of dairy manure. BIORESOURCE TECHNOLOGY 2021; 340:125632. [PMID: 34332440 DOI: 10.1016/j.biortech.2021.125632] [Citation(s) in RCA: 9] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/20/2021] [Revised: 07/16/2021] [Accepted: 07/17/2021] [Indexed: 05/22/2023]
Abstract
Dairy manure subjected to four pretreatments (acid, alkaline, sulfite (SPORL), alkaline hydrogen peroxide (AHP)) at high chemical dosages (termed severe conditions) were evaluated for enhancements in biogas production and inhibitory effects due to concomitant generation of furan byproducts. All four pretreatments enhanced solubilization of carbohydrates, but only alkaline and AHP resulted in higher methane yield (356 and 333 mL/g-VS, respectively) relative to moderate pretreatment conditions (311 and 261 mL/g-VS, respectively). Methane yield of severe-SPORL pretreatment (233 mL/g-VS) was greater than that of untreated manure (116 mL/g-VS), but lower than that of moderate-SPORL (353 mL/g-VS). Severe-acid pretreatment showed early termination in biogas production likely due to inhibitory effects of furfural and 5-hydroxymethyl furfural. Both experimental data and kinetic modeling indicated that severe-acid pretreatment led to degradation of carbohydrates to furfural, which reduced biogas production due to direct toxicity rather than competitive inhibitory effects. Pretreatment conditions (severity and byproduct levels) for dairy manure biomass may be optimized based on the current findings.
Collapse
Affiliation(s)
- Joonrae Roger Kim
- Department of Biological Systems Engineering, University of Wisconsin-Madison, 460 Henry Mall, Madison, WI 53706, United States
| | - K G Karthikeyan
- Department of Biological Systems Engineering, University of Wisconsin-Madison, 460 Henry Mall, Madison, WI 53706, United States.
| |
Collapse
|