YeastFab: High-Throughput Genetic Parts Construction, Measurement, and Pathway Engineering in Yeast

Isolation and evaluation of strong endogenous promoters for the heterologous expression of proteins in Pichia pastoris

BACKGROUND

The heterologous expression of biosynthetic pathway genes for pharmaceutical or fine chemical production usually requires to express more than one gene in the host cells. In eukaryotes, the pathway flux is typically balanced by controlling the transcript levels of the genes involved. It is difficult to balance the stoichiometric fine-tuning of the reaction steps of the pathway by acting on one or two promoters. Furthermore, the promoter used should not be identical to avoid loss of inserted genes by recombination or dilute its transcription factors.

RESULTS

Based on RNA-seq data, 18 candidate genes with the highest transcription levels at three carbon sources (glucose, glycerol and methanol) were selected and their promoter regions were isolated from GS115 genome. The performance of these promoters on the level of protein production was evaluated using LacZ and EGFP genes as the reporters, respectively. These isolated promoters all exhibited activity to express LacZ gene. Using LacZ as a reporter, of the 18 promoter candidates, 9 promoters showed higher expression levels for the reporter compare to pGAP, a strong promoter widely used for constitutive expression of heterologous proteins in Pichia pastoris. These promoters with high expression levels were further employed to evaluate secreted expression using EGFP as a reporter. 6 promoters exhibited stronger protein expression compare to pGAP. Interestingly, the protein expression driven by pFDH1 was slightly higher than that of commonly used pAOX1 at methanol, and methanol-induced expression of pFDH1 was not repressed by glycerol.

CONCLUSION

The various promoters identified in this study could be used for heterologous expression of biosynthetic pathway genes for pharmaceutical or fine chemical production. the methanol-induced pFDH1 that is not repressed by glycerol is an attractive alternative to pAOX1 and may provide a novel way to produce heterologous proteins in Pichia pastoris.

Screening and evaluation of the strong endogenous promoters in Pichia pastoris

Background

Due to its ability to perform fast and high-density fermentation, Pichia pastoris is not only used as an excellent host for heterologous protein expression but also exhibits good potential for efficient biosynthesis of small-molecule compounds. However, basic research on P. pastoris lags far behind Saccharomyces cerevisiae, resulting in a lack of available biological elements. Especially, fewer strong endogenous promoter elements available for foreign protein expression or construction of biosynthetic pathways were carefully evaluated in P. pastoris. Thus, it will be necessary to identify more available endogenous promoters from P. pastoris.

Results

Based on RNA-seq and LacZ reporter system, eight strong endogenous promoters contributing to higher transcriptional expression levels and β-galactosidase activities in three frequently-used media were screened out. Among them, the transcriptional expression level contributed by P₀₀₁₉, P₀₁₀₇, P₀₂₃₀, P₀₃₉₂, or P₀₇₈₅ was basically unchanged during the logarithmic phase and stationary phase of growth. And the transcriptional level contributed by P₀₂₀₈ or P₀₆₂₇ exhibited a growth-dependent characteristic (a lower expression level during the logarithmic phase and a higher expression level during the stationary phase). After 60 h growth, the β-galactosidase activity contributed by P₀₂₀₈, P₀₆₂₇, P₀₀₁₉, P₀₄₀₇, P₀₃₉₂, P₀₂₃₀, P₀₇₈₅, or P₀₁₀₇ was relatively lower than P_GAP but higher than P_ACT1. To evaluate the availability of these promoters, several of them were randomly applied to a heterogenous β-carotene biosynthetic pathway in P. pastoris, and the highest yield of β-carotene from these mutants was up to 1.07 mg/g. In addition, simultaneously using the same promoter multiple times could result in a notable competitive effect, which might significantly lower the transcriptional expression level of the target gene.

Conclusions

The novel strong endogenous promoter identified in this study adds to the number of promoter elements available in P. pastoris. And the competitive effect observed here suggests that a careful pre-evaluation is needed when simultaneously and multiply using the same promoter in one yeast strain. This work also provides an effective strategy to identify more novel biological elements for engineering applications in P. pastoris.

Supplementary Information

The online version contains supplementary material available at 10.1186/s12934-021-01648-6.

Use YeastFab to Construct Genetic Parts and Multicomponent Pathways for Metabolic Engineering

Budding yeast, as a eukaryotic model organism, has well-defined genetic information and a highly efficient recombination system, making it a good host to produce exogenous chemicals. Since most metabolic pathways require multiple genes to function in coordination, it is usually laborious and time-consuming to construct a working pathway. To facilitate the construction and optimization of multicomponent exogenous pathways in yeast, we recently developed a method called YeastFab Assembly, which includes three steps: (1) make standard and reusable genetic parts, (2) construct transcription units from characterized parts, and (3) assemble a complete pathway. Here we describe a detailed protocol of this method.