A novel approach for harvesting of the microalgae Chlorella vulgaris with Moringa oleifera extracts microspheres by Buoy-bead flotation method

A novel approach for harvesting the microalgae Chlorella vulgaris with sodium alginate microspheres using buoy-bead flotation method

In order to reduce the residue of buoy-beads and solve the problem of pollution caused by high flocculant consumption, SAMs¹(sodium alginate microspheres) with sodium alginate were used as the raw material to harvest microalgae for the first time. In addition, during the manufacturing of SAMs, the re-frying oil was used as the dispersion system, which not only reduced the cost, but also provided new ideas for the treatment of re-frying oil. Response surface methodology was used to explore the influence of different factors and the interaction of variables, and the harvesting process was optimized using the multi-objective optimization. Based upon the calculation of XDLVO (extended Derjaguin-Laudau-Verwey-Overbeek) theory and the characterization of Fourier Transform Infrared Spectroscopy, the harvesting mechanism of buoy-bead flotation method was clarified. The results showed that the combination of SAMs and a small amount of aluminum sulfate could replace air flotation and traditional buoy-bead flotation with solid particles as buoy-beads to harvest C. vulgaris (Chlorella vulgaris). For the multi-objective optimization with harvesting efficiency as the priority, the predicted pH, the concentrations of aluminum sulfate and buoy-beads and the dilution factor had values of 8.25, 56.09 mg/L, 17.46 mL/L, and 2.15, respectively. In the validation experiment, the harvesting efficiency and the enrichment ratio of C. vulgaris could reach the values of 97.51 % and 1.97 %, respectively. For the validation experiment of reverse optimization with focusing on enrichment ratio, the harvesting efficiency and the enrichment ratio of C. vulgaris had the values of 93.78 % and 2.65 %, respectively. The essence of improving the harvesting mechanism was the combination of carboxyl and hydroxyl groups between C. vulgaris and SAMs and the adsorption of positive ions by specific proteins on the surface of C. vulgaris to reduce electrostatic repulsion.

Usage of Moringa oleifera residual seeds promotes efficient flocculation of Tetradesmus dimorphus biomass

Bio-flocculation is a sustainable low-cost harvesting technique for microalgae biomass production; however, it is generally less efficient than chemical flocculants. This study aims to investigate the efficiency of Moringa oleifera seeds as a bio-flocculant for harvesting Tetradesmus dimorphus biomass. Four extracts from integral and residual (seeds without lipids) biomass of M. oleifera seeds using salt or aqueous solutions were used at four concentrations (100, 200, 300, and 400 ppm). Flocculation efficiency (FE) increased as the pH decreased. The addition of the extracts reduced the pH of the cultures, dispensing pH adjustment after dosing the flocculating agent. Salt extracts exhibited higher flocculation efficiency than aqueous extracts. The highest flocculation efficiency (~ 98%) was obtained using a salt extract of residual biomass of seeds in any concentration varying from 100 to 400 ppm. The predicted values obtained from a data modeling using response surface methodology approached the real values (r 2 = 0.9382), resulting in an adequate optimization of the flocculant concentration of ~ 335 ppm and pH 5.6 for a predicted FE of ~ 106%. The findings of the present study confirmed that the salt extract from residual biomass of M. oleifera seeds is an effective bio-flocculant for T. dimorphus biomass harvesting.

Assessing the prospects of Zygnema heydrichii, a filamentous Chlorophyte, as a biodiesel feedstock

This research aimed to investigate the suitability of the filamentous microalga Zygnema heydrichii as a biodiesel feedstock. Under ambient culture conditions, biomass yield, lipid content, and fatty acid composition were measured. The effects of nutrient deprivation, pH, and salinity on biomass and lipid production were also investigated. Z. heydrichii under nutrient-enriched medium showed specific growth rate (µ) 0.31 day^-1 and lipid content 14.75% DW. The most abundant fatty acids were C16:0, C18:1, C18:2 and C18:3, all of which are considered appropriate for biodiesel production. Nitrogen and phosphorus depletion from the growth medium further increased lipid content to 21.45% and 15.35% DW, respectively. The N depletion of the medium remarkably increased TAG content of the culture. Z. heydrichii possess great ability to grow in salty water (40 Mm NaCl). A low-cost, semi-continuous outdoor culture yielded biomass and lipid productivity of 0.208 g day^-1and 0.038 g L^-1 day^-1, respectively.