Digestibility of amino acids, fiber, and energy by growing pigs, and concentrations of digestible and metabolizable energy in yellow dent corn, hard red winter wheat, and sorghum may be influenced by extrusion

Nutritional guide to feeding wheat and wheat co-products to swine: a review

Inclusion of wheat grain can offer feeding opportunities in swine diets because of its high starch, crude protein (CP), amino acid (AA), and phosphorus (P) content. High concentrations of starch within wheat grain makes it a good energy source for swine. Mean energy content of wheat was 4,900 and 3,785 kcal/kg dry matter (DM) for digestible energy and metabolizable energy, respectively. CP concentration can vary based on the class of wheat which include hard red winter, hard red spring, soft red winter, hard white, soft white, and durum. The average CP of all wheat data collected in this review was 12.6% with a range of 8.5% to 17.6%. The AA concentration of wheat increases with increasing CP with the mean Lys content of 0.38% with a standardized ileal digestibility (SID) of 76.8%. As CP of wheat increases, the SID of AA in wheat also increases. Mean P of wheat was 0.27% and median P was 0.30%. Off-quality wheat is often associated with sprouts, low-test weight, or mycotoxin-contamination. Sprouted and low-test weight wheat are physical abnormalities associated with decreased starch within wheat kernel that leads to reductions in energy. The assumed energy value of wheat grain may need to be reduced by up to 10% when the proportion of sprouted to non-sprouted wheat is up to 40% whereas above 40%, wheat's energy may need to be reduced by 15% to 20%. Low-test weight wheat appears to not influence pig performance unless it falls below 644 kg/m3 and then energy value should be decreased by 5% compared to normal wheat. Deoxynivalenol (DON) contamination is most common with wheat grain. When content is above the guidance level of 1 mg/kg of DON in the complete diet, each 1 mg/kg increase in a DON-contaminated wheat-based diet will result in a 11% and 6% reduction in ADG and ADFI for nursery pigs, and a 2.7% and 2.6% reduction in ADG and ADFI, in finishing pigs, respectively. Wheat co-products are produced from the flour milling industry. Wheat co-products include wheat bran middlings, millrun, shorts, and red dog. Wheat co-products can be used in swine diets, but application may change because of differences in the final diet energy concentration due to changes in the starch and fiber levels of each wheat co-product. However, feeding wheat co-products are being evaluated to improve digestive health. Overall, wheat and wheat co-products can be fed in all stages of production if energy and other nutrient characteristics are considered.

Effect of extrusion on available energy and amino acid digestibility of barley, wheat, sorghum, and broken rice in growing pigs

OBJECTIVE

The main objective of this study was to determine available energy and nutritional digestibility of extruded cereals and the effect of extrusion on the nutritional value of feed ingredients, aiming to provide scientific basis for efficient application of extrusion in the diets of growing pigs.

METHODS

In Exp. 1, 48 crossbred growing pigs (Duroc×Landrace×Yorkshire) with an initial body weight (BW) of 34.6±2.2 kg were selected and fed with eight diets (non-extrusion or extrusion) to determine the digestible energy (DE), metabolizable energy (ME), and nutrients digestibility. Eight diets included extruded grains (barley, wheat, sorghum, or broken rice), while four had unprocessed grains. In Exp. 2, 9 diets were formulated including 4 cereals with extrusion or non-extrusion and a N-free diet. In addition, 9 growing pigs (BW = 22.3±2.8 kg) were fitted with T-cannula in the distal ileum and arranged in a 9×6 Youden square design.

RESULTS

Results show that apparent total tract digestibility of gross energy, dry matter, organic meal, ether extract, neutral and acid detergent fiber was not affected by the extrusion process and there was no interaction between cereal type and extrusion treatment on DE, ME. However, the apparent total tract digestibility for crude protein (CP) increased markedly (p<0.05). The standardized ileal digestibility (SID) of all amino acids (AA) except for leucine remarkably increased by extrusion (p<0.05). There was an interaction on the SID of arginine, leucine, isoleucine, methionine, phenylalanine, cystine, and tyrosine in growing pigs between type of grain and extrusion treatment (p<0.05).

CONCLUSION

Extrusion increased the ileal digestibility of CP and most AA in cereals, however, the DE and ME of cereals were not affected in growing pigs.

Germination: A Powerful Way to Improve the Nutritional, Functional, and Molecular Properties of White- and Red-Colored Sorghum Grains

This study explored the effects of the germination of red and white sorghum grains (Sorghum bicolor [Moench (L.)]) for up to seven days on various properties of the grain. Germination enriched sorghum's nutritional and sensory qualities while mitigating existing anti-nutritional factors. The study employed Fourier-transformed infrared spectroscopy (FT-IR) and scanning electron microscopy techniques to support its findings. Germination increased protein and lipid content but decreased starch content. White sorghum grains showed elevated calcium and magnesium but decreased iron, potassium, and zinc. Red sorghum grains showed a consistent decrease in mineral content during germination. Germination also increased fiber and lignin values in both sorghum varieties. The results of the FT-IR analysis demonstrate that germination induced significant changes in the molecular structure of white sorghum samples after 24 h, whereas this transformation was observed in red sorghum samples at four days. Total phenolic content (TPC) in red sorghum ranged from 136.64 ± 3.76 mg GAE/100 g to 379.5 ± 6.92 mg GAE/100 g. After 72 h of germination, the germinated seeds showed a threefold increase in TPC when compared to ungerminated seeds. Similarly, the TPC of white sorghum significantly increased (p < 0.05) from 52.84 ± 3.31 mg GAE/100 g to 151.76 mg GAE/100 g. Overall, during the 7-day germination period, all parameters showed an increase, and the germination process positively impacted the functional properties that contributed to the health benefits of white and red sorghum samples.

In vitro determination of the protein quality of maize varieties cultivated in Malawi using the INFOGEST digestion method

There is an urgent need to alleviate protein deficiencies in low-income countries where cereal-based diets dominate. The objective of this study was to use the INFOGEST static digestion method and a recently established analytical workflow to determine the in vitro amino acid digestibility and protein quality of seven maize varieties grown in Malawi. Protein quality was measured using the in vitro digestible indispensable amino acid score (DIAAS). Amino acid digestibility was higher for the dehulled, low fibre, provitamin A maize flour (66%), compared to whole grain maize flours (51-61%), suggesting that the presence of fibre reduced digestibility (p < 0.05). Lysine was the limiting amino acid in all varieties, with the following DIAAS values for each variety; Provitamin A maize - 24, SC 719 - 32, Mtsikinya - 37, SC 167 - 39, Quality protein maize (QPM) - 40, Bantum - 40, SC 403 - 44. In addition to the variety of maize, protein quality was dependent on the level of processing and the agronomic practice applied with higher protein quality for the SC 403 variety in which zinc enriched fertilizer was applied. Comparing protein quality data with published in vivo data showed that DIAAS data were in closer agreement than amino acid digestibility data, which was slightly lower than published values, with mean in vitro amino acid digestibilities of 56-70% compared to a mean in vivo value of 77%. Overall, the in vitro method was able to correctly predict both the direction and magnitude of response. The INFOGEST digestion method coupled with the new analytical workflow will therefore be useful in the screening of high protein cereal crops and subsequent development of cereal-based foods with high protein quality.

Effects of Processing Methods and Conditioning Temperatures on the Cassava Starch Digestibility and Growth Performance of Broilers

As an important food crop, cassava is rich in nutrients and high in starch content and is widely used in the production of industrial raw materials. However, the utilization value of cassava is limited due to the reduction of planting area and the existence of anti-nutritional factors. Therefore, we evaluated in vitro cassava starch digestibility and in vivo growth performance of broilers in a 3 × 3 factorial arrangement of treatments using three processing methods (mechanical crushing (MC), steam conditioning (SC), and puffing conditioning (PU)) and three conditioning temperatures (60, 75, and 90 °C) to screen for the optimal processing method and conditioning temperature to improve the utilization of cassava. In the in vitro cassava starch digestion study, the digestibility and digestion rate (p < 0.01) were higher at conditioned 90 °C than that at 60 or 75 °C, and PU was higher than SC and MC (p < 0.01) (0.25-2 h). The amylose content and amylose/amylopectin at conditioned 60 °C or PU were lower (p < 0.01) than that of 75 or 90 °C or SC, whereas the opposite was true for amylopectin content (p < 0.01). The resistant starch content of SC or PU was lower (p < 0.01) than MC. In the in vivo study, broilers fed diets conditioned at 60 °C or SC had a lower (p < 0.05) feed-to-gain ratio than those fed diets conditioned at 90 °C or PU diets. The ileum apparent digestibility of starch and AME were higher (p < 0.05) for broilers fed SC diets than for those fed MC diets. These results indicate that cassava starch promoted starch digestion rate by reducing amylose content and amylose/amylose under PU combined with a conditioning temperature of 60 °C, ileum digestibility of starch in broilers fed SC diets was higher than MC diets regardless of conditioning temperature, and SC diets increased AME and decreased F/G to promote growth performance of broilers.

Effects of corn hardness and drying temperature on digestibility of energy and nutrients in diets fed to growing pigs

Two experiments were conducted to test the hypothesis that corn kernel hardness and drying temperature influence the ileal digestibility of starch and amino acids (AA), as well as apparent total tract digestibility (ATTD) of gross energy (GE) and total dietary fiber (TDF) in diets for growing pigs. Two corn varieties with average or hard endosperm were grown and harvested under similar conditions, and after harvest, each variety was divided into 2 batches that were dried at 35 and 120 °C, respectively. Therefore, four batches of corn were used. In experiment 1, 10 pigs (67.00 ± 2.98 kg) with a T-cannula installed in the distal ileum were allotted to a replicated 5 × 5 Latin square design with 5 diets and 5 periods giving 10 replicates per diet. A nitrogen-free diet and four diets containing each source of corn as the only AA source were formulated. Results indicated that neither variety of corn nor drying temperature influenced apparent ileal digestibility of starch in the grain. The standardized ileal digestibility of most AA was less (P < 0.05) in corn dried at 120 °C compared with corn dried at 35 °C resulting in concentrations of most standardized ileal digestible AA being less (P < 0.05) in corn dried at 120 °C than in corn dried at 35 °C. In experiment 2, 40 pigs (20.82 ± 1.74 kg) were housed in metabolism crates and allotted to 4 diets with 10 replicate pigs per diet. The four corn-based diets used in experiment 1 were also used in experiment 2. Feces and urine were collected using the marker-to-marker approach with 5-d adaptation and 4-d collection periods. Results indicated that diets containing hard endosperm corn had greater (P < 0.05) ATTD of TDF than diets containing average endosperm corn. The ATTD of GE in hard endosperm corn was also greater (P < 0.05), and concentrations of digestible energy and metabolizable energy in hard endosperm corn were greater (P < 0.01) than in average endosperm corn. Diets containing corn dried at 120 °C had greater (P < 0.05) ATTD of TDF compared with diets containing corn dried at 35 °C; however, drying temperature did not influence the ATTD of GE. In conclusion, endosperm hardness did not influence the digestibility of AA and starch; however, drying corn at 120 °C reduced digestible AA concentrations. Hard endosperm corn had greater ATTD of GE and TDF, but drying temperature did not influence energy digestibility.

Effects of different processing techniques of broken rice on processing quality of pellet feed, nutrient digestibility, and gut microbiota of weaned piglets

The present study was conducted to assess the effect of different processing techniques of broken rice on processing quality of pellet feed, growth performance, nutrient digestibility, blood biochemical parameters, and fecal microbiota of weaned piglets. A total of 400 crossbred piglets (Duroc × Landrace × Yorkshire) with a mean initial body weight (BW) of 7.24 ± 0.52 kg were used in a 28-d experiment. Piglets were randomly distributed to one of 4 treatment and 10 replicate pens per treatment, with 10 piglets per pen. The dietary treatments were as follows: CON, corn as the main cereal type in the dietary; BR, 70% of the corn replaced by broken rice; ETBR, 70% of the corn replaced by extruded broken rice; EPBR, 70% of the corn replaced by expanded broken rice. Extruded broken rice and expanded broken rice supplementation significantly (P < 0.05) increased hardness, pellet durability index, crispness, and starch gelatinization degree. Extruded broken rice and expanded broken rice generated a higher (P < 0.05) average daily feed intake, increased (P < 0.05) average daily gain, decreased (P < 0.05) feed conversion ratio, and lowered (P < 0.05) the diarrhea rate. Piglets fed extruded broken rice displayed high apparent total tract digestibility levels of dry matter (P < 0.05), gross energy (P < 0.05), crude protein (P < 0.05), and organic matter (P < 0.05). In addition, extruded broken rice and expanded broken rice supplementation had increased Lactobacillus and Bifidobacterium levels in gut, whereas a lower abundance of the potential pathogens Clostridium_sensu_strictio_1 and Streptococcus was observed. Dietary supplementation of extruded broken rice and expanded broken rice failed to show significant effects on blood biochemical parameters. Combined, 70% corn substituted with broken rice failed to show significant effects. Collectively, extruded broken rice and expanded broken rice supplementation had positively enhanced the pellet quality, growth performance, nutrient digestibility, and gut microbiota of weaned piglets.

Metabolizable energy and apparent total tract digestibility of energy and nutrients differ among samples of sunflower meal and sunflower expellers fed to growing pigs

An experiment was conducted to test the hypothesis that there are no differences among samples of sunflower coproducts in apparent total tract digestibility (ATTD) of gross energy (GE), crude protein (CP), and acid hydrolyzed ether extract (AEE), total dietary fiber (TDF), insoluble dietary fiber, soluble dietary fiber (SDF), or in metabolizable energy (ME) regardless of where the ingredient was produced. Six samples of sunflower meal (SFM) were obtained from the United States (two samples), Ukraine (two samples), Hungary, and Italy. A sample of sunflower expellers (SFE) from the United States was also used. A corn-based control diet and 7 diets containing corn and each sample of sunflower coproducts were formulated. Sixty-four barrows (initial weight = 31.5 ± 3.2 kg) were allotted to 8 diets using a randomized complete block design with four blocks of pigs from four different weaning groups. Pigs were housed individually in metabolism crates and feed was provided at three times energy requirement for maintenance. Feces and urine were collected for four days after seven days of adaptation to diets. Results indicated that the ATTD of GE and CP in SFE was less (P < 0.05) than in SFM, but ATTD of AEE in SFE was greater (P < 0.05) compared with SFM. No difference in ME between SFM and SFE was observed. The ATTD of GE and TDF in SFM from Ukraine and Hungary was greater (P < 0.05) than in SFM from the United States or Italy. The ATTD of AEE did not differ among SFM samples with the exception that ATTD of AEE in the U.S. 2 sample was greater (P < 0.05) than in the other samples. The ATTD of SDF was less (P < 0.05) in the U.S. 1 sample and the sample from Italy than in the other samples. The ATTD of TDF was greater in the Ukraine 2 sample of SFM (P < 0.05) than in the two U.S. samples. The ME in the SFM samples from Ukraine and in the SFM from Hungary was greater (P < 0.05) than in the U.S. 1 sample and the SFM from Italy. In conclusion, ATTD of GE and nutrients differed between SFM and SFE, but the ATTD of TDF and the ME in SFM was not different from value for SFE. Among SFM samples, relatively small variations in ATTD of GE, AEE, and CP were observed, but ME and digestibility of TDF varied.

Combined Thermomechanical-Biological Treatment for Corn By-Product Valorization into Added-Value Food (Feed) Material

The aim of this study was to apply the combined thermomechanical-biological treatment for corn processing by-product (CPBP) valorization to added-value food and feed material. The mechanical-thermal pre-treatment was performed by applying the extrusion technique. Extruded CPBPs (14, 16, and 18% moisture) were further biodegraded with Lactiplantibacillus plantarum-LUHS122 (Lpl), Liquorilactobacillus uvarum-LUHS245 (Lu), Lacticaseibacillus casei-LUHS210 (Lc), and Lacticaseibacillus paracasei-LUHS244 (Lpa). Acidity parameters, microbial characteristics, sugars concentration, amino and fatty acids profile, biogenic amines (BA), and antibacterial and antifungal properties of CPBP were analyzed. Fermented CPBP had a reduced count of mould/yeast. A significantly lower (p ≤ 0.05) count of total enterobacteria was found in most of the extruded-fermented CPBP. Fermentation of extruded CPBP (moisture of 16 and 18%) increased valine and methionine content. Cadaverine and spermidine were not found after treatment of CPBP, and the lowest content of BA was found in the extruded-fermented (Lpa, moisture 18%) CPBP. Applied treatment had a significant effect on most of the fatty acids. CPBP fermented with Lpl, Lu, and Lpa displayed inhibition properties against 3 of the 10 tested pathogenic/opportunistic bacterial strains. Extruded-fermented (Lu, Lc, and Lpa moisture of 14 and 18%) CPBP showed antifungal activity against Rhizopus. Extruded-fermented (14% moisture, Lpl) CPBP inhibited Rhizopus and Aspergillus fumigatus. In conclusion, combined treatment can improve certain parameters and properties of CPBP in order to produce safer and more nutritious ingredients for food and feed industries.

Time-course effects of different fiber-rich ingredients on energy values, microbiota composition and SCFA profile in growing pigs

This study was to investigate time-course effects of different types of dietary fiber on the energy values, fecal microbiota and short-chain fatty acid (SCFA) concentration in growing pigs. A total of 24 barrows (initial body weight, 19.8 ± 0.5 kg) were assigned to 4 dietary treatments based on body weight (BW) in a completely randomized design, including a basal diet (CON) and 3 fiber-rich diets replacing corn, soybean meal and soybean oil in the CON diet with 20% sugar beet pulp (SBP), defatted rice bran (DFRB) or soybean hull (SBH), respectively. Fresh feces were sampled on d 7, 14 and 21, followed by 5 d total feces and urine collections. The results showed that there were no differences in DE and ME between any of the fiber ingredients on d 7, 14 or 21. However, fiber inclusion decreased the DE and ME of the diet (P < 0.05) regardless of the time effect. Principal coordinate analysis (PCoA) revealed distinctly different microbial communities on the DFRB diet and SBH diet across different times (P < 0.05) and the fecal microbiota of the 4 diet groups demonstrated notably distinct clusters at each time point (P < 0.05). With adaptation time increased from 7 to 21 d, cellulose-degrading bacteria and SCFA-producing bacteria (e.g., Ruminococcaceae _UCG-014, Rikenellaceae _RC9_gut_group and Bifidobacterium) increased in the fiber inclusion diets, and pathogenic genera (e.g., Streptococcus and Selenomonas) were increased in the basal diet (P < 0.05). Furthermore, the gut microbiota of growing pigs adapted more easily and quickly to the SBP diet compared to the DFRB diet, as reflected by the concentration of propionate, butyrate, isovalerate and total SCFA which increased with time for growing pigs fed the DFRB diet (P < 0.05). Collectively, our results indicated at least 7 d adaptation was required to evaluate the energy values of fiber-rich ingredients, as the hindgut microbiota of growing pigs may need more time to adapt to a high fiber diet, especially for insoluble dietary fiber.

Nutrient digestibility of extruded canola meal in ileal-cannulated growing pigs and effects of its feeding on diet nutrient digestibility and growth performance in weaned pigs

Canola meal (CM) contains less crude protein (CP) and more fiber and anti-nutritional factors such as glucosinolates than soybean meal (SBM) and consequently has a lower nutrient digestibility. Therefore, processing strategies that may increase the feeding value of CM warrant study. In two experiments, the effects of extrusion of Brassica napus CM on apparent (AID) and standardized ileal digestibility (SID) of amino acids (AA), apparent total tract digestibility (ATTD) of gross energy (GE) in growing pigs, and growth performance and diet digestibility in weaned pigs were assessed. Solvent-extracted CM was extruded using a single-screw extruder at three screw speeds: 250 (CM-250), 350 (CM-350), or 450 (CM-450) rpm. In exp. 1, in a double 4 × 4 Latin square, eight ileal-cannulated barrows (initial body weight [BW], 68.1 kg) were fed corn starch-based diets containing 50% CM or extruded CM. The CM sample contained 43.2% CP, 33.2% total dietary fiber (TDF), and 8.9 µmol of total glucosinolates/g on a dry matter (DM) basis. Extrusion increased (P < 0.05) the AID of CP, reduced (P < 0.05) apparent hindgut fermentation of CP, and decreased (P < 0.05) predicted net energy (NE) value of diets. Extrusion increased diet AID and CM SID of most indispensable AA by 3.1 to 5.3%-units. In exp. 2, 200 weaned pigs (initial BW, 8.3 kg) were fed diets containing 20% SBM, CM, or extruded CM starting 2 wk postweaning for 3 wk. The CM sample contained 42.7% CP, 28.3% TDF, and 5.3 µmol total glucosinolates/g DM. Wheat-based diets provided 2.3 Mcal NE/kg and 5.1 g SID Lys/Mcal NE. Dietary inclusion of extruded CM replacing SBM decreased (P < 0.05) diet ATTD of DM, GE and CP, and DE value. Average daily feed intake, average daily gain (ADG), and gain:feed (G:F) of pigs did not differ between extruded CM and SBM diets and were not affected by extrusion, but increasing extruder screw speed linearly increased (P < 0.05) ADG for day 1 to 7 and G:F for the entire trial. In conclusion, extrusion increased diet AID and CM SID of AA but not DE and predicted NE values of CM. However, increasing extruder speed did not further increase the SID of most of the AA of CM in growing pigs. Dietary inclusion of 20% CM or extruded CM did not affect the growth performance in weaned pigs.

Using Nutritional Strategies to Shape the Gastro-Intestinal Tracts of Suckling and Weaned Piglets

This is a comprehensive review on the use of nutritional strategies to shape the functioning of the gastro-intestinal tract in suckling and weaned piglets. The progressive development of a piglet's gut and the associated microbiota and immune system offers a unique window of opportunity for supporting gut health through dietary modulation. This is particularly relevant for large litters, for which sow colostrum and milk are insufficient. The authors have therefore proposed the use of supplemental milk and creep feed with a dual purpose. In addition to providing nutrients to piglets, supplemental milk can also serve as a gut modulator in early life by incorporating functional ingredients with potential long-term benefits. To prepare piglets for weaning, it is important to stimulate the intake of solid feed before weaning, in addition to stimulating the number of piglets eating. The use of functional ingredients in creep feed and a transition diet around the time of weaning helps to habituate piglets to solid feed in general, while also preparing the gut for the digestion and fermentation of specific ingredients. In the first days after weaning (i.e., the acute phase), it is important to maintain high levels of feed intake and focus on nutritional strategies that support good gastric (barrier) function and that avoid overloading the impaired digestion and fermentation capacity of the piglets. In the subsequent maturation phase, the ratio of lysine to energy can be increased gradually in order to stimulate piglet growth. This is because the digestive and fermentation capacity of the piglets is more mature at this stage, thus allowing the inclusion of more fermentable fibres. Taken together, the nutritional strategies addressed in this review provide a structured approach to preparing piglets for success during weaning and the period that follows. The implementation of this approach and the insights to be developed through future research can help to achieve some of the most important goals in pig production: reducing piglet mortality, morbidity and antimicrobial use.

Extrusion of soybean hulls does not increase digestibility of amino acids or concentrations of digestible and metabolizable energy when fed to growing pigs

Two experiments were conducted to determine effects of extrusion on energy and nutrient digestibility in soybean hulls. One source of soybean hulls was ground and divided into two batches. One batch was used without further processing, whereas the other batch was extruded. In Exp. 1, four diets were formulated to determine crude protein (CP) and amino acid (AA) digestibility in soybean hulls. A soybean meal-based diet in which soybean meal provided all the CP and AA was formulated. Two diets were formulated to contain 30% nonextruded or extruded soybean hulls and 18% soybean meal. An N-free diet that was used to determine the endogenous losses of CP and AA was also used. Eight growing barrows (initial body weight = 37.0 ± 3.9 kg) had a T-cannula installed in the distal ileum and were allotted to a replicated 4 × 4 Latin square design. Each experimental period lasted 7 d with the initial 5 d being the adaptation period and ileal digesta were collected for 8 h on day 6 and 7. Results indicated that extrusion of soybean hulls did not change the standardized ileal digestibility (SID) of CP and most AA with the exception that the SID of Ile and Leu tended (P < 0.10) to be greater in extruded than nonextruded soybean hulls. In Exp. 2, three diets were formulated to determine energy digestibility in soybean hulls. One corn-soybean meal based basal diet, and two diets that contained corn, soybean meal, and 32% extruded or nonextruded soybean hulls were formulated. Twenty-four growing barrows (initial body weight = 59.9 ± 3.4 kg) were allotted to a randomized complete block design. Pigs were housed individually in metabolism crates and feces and urine were collected separately for 4 d after 5 d of adaptation. The apparent total tract digestibility (ATTD) of gross energy (GE) and the digestible energy (DE) and metabolizable energy (ME) were reduced (P < 0.05) in diets containing nonextruded or extruded soybean hulls compared with the basal diet. However, the ATTD of GE and values for DE and ME in soybean hulls were not improved by extrusion. Likewise, extrusion did not change the concentration of total dietary fiber in soybean hulls. In conclusion, there were no effects of extrusion of soybean hulls on SID of AA, energy digestibility, or ME concentration in soybean hulls.

Digestibility of amino acids and concentrations of metabolizable energy and net energy are greater in high-shear dry soybean expellers than in soybean meal when fed to growing pigs

Soybean expellers may be produced by dry extrusion and mechanical oil pressing of soybeans, but there is limited information about the nutritional value of expellers produced via this procedure. Therefore, 2 experiments were conducted to test the hypothesis that standardized ileal digestibility (SID) of CP and amino acids (AA), apparent total tract digestibility (ATTD) of energy and total dietary fiber (TDF), and concentrations of DE, ME, and NE are greater in soybean expellers than in soybean meal (SBM) when fed to growing pigs. Pigs were the offspring of Line 359 boars mated to Camborough females (Pig Improvement Company, Hendersonville, TN). In experiment 1, nine growing barrows (initial BW: 55.98 kg ± 13.75 kg) with T-cannulas installed in the distal ileum were allotted to 1 of 3 diets using a triplicated 3 × 3 Latin square design with 3 periods. Two diets were formulated to contain 35% soybean expellers or 33% SBM as the sole source of AA. A N-free diet was used to determine basal endogenous losses of AA. Ileal digesta were collected on days 6 and 7 of each 7-d period. Results indicated that the SID of most indispensable and dispensable AA were greater (P < 0.05) or tended (P < 0.10) to be greater in soybean expellers than in SBM. In experiment 2, a corn-based diet and 2 diets based on corn and each of the 2 soybean products were formulated. Twenty-four growing barrows (initial BW: 44.88 kg ± 2.17 kg) were allotted to 1 of the 3 diets with 8 pigs per diet. Urine and fecal samples were collected for 4 d after 5 d of adaptation. Results indicated that the ATTD of energy and TDF was not different between soybean expellers and SBM, but the ATTD of TDF in the 2 soybean products was greater (P < 0.05) than in corn. Concentrations of DE and ME in soybean expellers were greater (P < 0.05) compared with corn or SBM. Soybean expellers had greater (P < 0.05) calculated NE compared with SBM, but there was no difference in NE between corn and soybean expellers. In conclusion, values for SID of most AA and DE, ME, and NE in soybean expellers were greater than in SBM.