Accelerated bio-methane production rate in thermophilic digestion of cardboard with appropriate biochar: Dose-response kinetic assays, hybrid synergistic mechanism, and microbial networks analysis

New insights on ecological roles of waste activated sludge in nutrient-stressed co-digestion

There have been extensive applications of waste activated sludge (WAS) in anaerobic co-digestion (AcoD). Nonetheless, mechanisms through which AcoD systems maintain stability, particularly under nutrient-stressed conditions, are under-appreciated. In this study, the role of WAS in a nutrient-stressed WAS-food waste AcoD system was re-evaluated. Our findings demonstrated that WAS-based co-digestion increased methane production (by 20-60%) as WAS bolsters such systems' resilience via establishing a core niche-based microbial balance. The carbon utilization investigation suggested a microbial niche balance is attainable if two conditions are satisfied: 1) hydrolysis efficiency is greater than 50%; and 2) both the acidogenesis-to-hydrolysis and acetogenesis-to-hydrolysis efficiencies surpass 0.5. Metagenomic assembly genome (MAG) analysis indicated that the versatile metabolic characteristics strengthened the microbial niche balance, rendering the system resilient and efficient through a syntrophic mode, contributing to both acidogenesis and acetogenesis. The findings of this study provide new insights into the ecological effects of WAS on AcoD.

Ruminal content biochar supplementation for enhanced biomethanation of rice straw: Focusing on biochar characterization and dose optimization

Anaerobic digestion (AD) of agricultural wastes is a promising approach for energy recovery and crop residue management. However, its recalcitrant chemical structure hinders microbial hydrolysis and reduces biomethane production under AD. Biochar supplementation has been proven to promote the digestibility and biomethanation of lignocellulosic substrates. Therefore, this study investigated the influence of different pyrolysis temperatures (450 °C, 550 °C, and 650 °C) on the physicochemical properties of biochar. Furthermore, the impact of ruminal content biochar supplementation (1 %, 2 %, and 3 %) on the AD of rice straw with rumen fluid as inoculum has been investigated. The ruminal content biochar (RUCB) supplemented reactors showed an increment in biomethane yield and the highest cumulative biomethane yield 243.11 mL/g volatile solids (VS)) was recorded at 2 % RUCB supplementation, followed by 227.12 mL/g VS at 1 % RUCB supplementation and 162.86 mL/g VS at 3 % RUCB supplementation (P > 0.05). Compared to the control reactors (128.68 mL/g VS), RUCB supplemented reactors exhibited 1.88-fold, 1.76-fold, and 1.26-fold increments in biomethane yield due to pH stabilization and facilitation of microbial biofilm formation on the biochar. The correlation analysis showed that biomethane production is positively correlated with VS reduction (R2 = 0.9852). This study proposed a potential strategy to utilize ruminal content waste as a feedstock for biochar production and its application in AD for accelerating the biomethanation of rice straw.

Boosting thermophilic anaerobic digestion with conductive materials: Current outlook and future prospects

Thermophilic anaerobic digestion (TAD) can provide superior process kinetics, higher methane yields, and more pathogen destruction than mesophilic anaerobic digestion (MAD). However, the broader application of TAD is still very limited, mainly due to process instabilities such as the accumulation of volatile fatty acids and ammonia inhibition in the digesters. An emerging technique to overcome the process disturbances in TAD and enhance the methane production rate is to add conductive materials (CMs) to the digester. Recent studies have revealed that CMs can promote direct interspecies electron transfer (DIET) among the microbial community, increasing the TAD performance. CMs exhibited a high potential for alleviating the accumulation of volatile fatty acids and inhibition caused by high ammonia levels. However, the types, properties, sources, and dosage of CMs can influence the process outcomes significantly, along with other process parameters such as the organic loading rates and the type of feedstocks. Therefore, it is imperative to critically review the recent research to understand the impacts of using different CMs in TAD. This review paper discusses the types and properties of CMs applied in TAD and the mechanisms of how they influence methanogenesis, digester start-up time, process disturbances, microbial community, and biogas desulfurization. The engineering challenges for industrial-scale applications and environmental risks were also discussed. Finally, critical research gaps have been identified to provide a framework for future research.

Effects of different types of granular activated carbon on methanogenesis of carbohydrate-rich food waste: Performance, microbial communities and optimization

Granular activated carbon (GAC) supplementation is an efficient method for enhancing methane production during the anaerobic digestion of food waste, but it remains unclear which type of GAC is optimal and what potential mechanisms are involved with different types of GAC, particularly for the methanogenic system of carbohydrate-rich food waste. This study selected three commercial GAC (GAC#1, GAC#2, GAC#3) with very distinct physical and chemical properties, and investigated their impacts on the methanogenesis of carbohydrate-rich food waste with an inoculation/substrate ratio of 1. Results indicated that Fe-doped GAC#3 had a lower specific surface area but higher conductivity, yet exhibited superior performance in facilitating methanogenesis compared with GAC#1 and GAC#2, which possessed larger specific surface areas. The addition of 10 g/L GAC#3 enhanced the methane yield by 10-folds through regulating pH levels, alleviating volatile fatty acids-induced stress, enhancing key enzymatic activity, as well as enriching direct interspecies electron transfer-mediated syntrophic partner of Syntrophomonas with Methanosarcina. Furthermore, GAC#1, which had the largest specific surface area but exhibited the poorest performance, was chemically modified to enhance its ability in promoting methanogenesis. The resulting material, named MGAC#1 (Fe3O4-loaded GAC#1), exhibited superior electro-conductivity and high methane production efficiency. The methane yield of 588 mL/g-VS showed a remarkable increase of 468 % compared with GAC#1, and a modest increase of 13 % compared with GAC#3, surpassing most values reported in literature. These findings suggested that the Fe3O4-loaded GAC with lager specific surface area, was the optimal choice for the methanogenesis of sole readily acidogenic waste, providing valuable insights for the preparation of superior-quality GAC for application in biogas industry.

Microbial response behavior to powdered activated carbon in high-solids anaerobic digestion of kitchen waste: Metabolism and functional prediction analysis

Anaerobic digestion (AD) can not only treat organic waste, but also recycle energy. However, high-solids AD of kitchen waste usually failed due to excessive acidification. In this study, the effect of activated carbon (AC) on kitchen waste AD performance was investigated under high-solids conditions (total solids contents = 15%). The results showed that efficiencies of acidogenesis and methanogenesis were promoted in presence of moderate concentration (50 g/L > AC >5 g/L), but high concentration (AC >70 g/L) weakened AD performance. Moreover, AC addition enhanced the methane production rate from 66.0 mL/g VS to 231.50 mL/g VS, i.e., up to 250.7%. High-throughput sequencing results demonstrated that the abundance of electroactive DMER64 increased from less than 1%-29.7% (20 g/L AC). As AC gradually increased，aceticlastic methanogenesis changed to hydrogenotrophic pathway. Predicted functional analysis indicated that AC can enhance abundances of energy and inorganic ion metabolism, resulting in high methane production.

Dual utilization of aloe peel: Aloe peel-derived carbon quantum dots enhanced anaerobic co-digestion of aloe peel

Carbon materials have been widely used in anaerobic digestion (AD), but the role of zero-dimensional carbon quantum dots (CQDs) in anaerobic co-digestion (AcoD) has not yet been reported. In this work, the effect of aloe peel-derived CQDs (AP-CQDs) on the AcoD system of aloe peel and dairy manure was investigated. The addition of AP-CQDs accelerants increased the cumulative CH₄ yield from 201.14 to 266.92-339.64 mL/g VS and increased total chemical oxygen demand removal efficiency from 34.72 % to 48.77-57.87 %. The use of a digestate with 0.36 wt.% of AP-CQDs resulted in a thermogravimetric mass loss of 47.15 % and a promising total nutrient content of 46.65 g/kg. The excellent electron exchange capacity of AP-CQDs may facilitate direct interspecies electron transfer during the AD process. Moreover, the use of AP-CQDs can enrich methanogenic microorganisms (Methanosarcina and Methanobacterium). These findings provide a viable strategy for improving methane production and create awareness regarding the dual use of biomass waste.

Effect of Addition of Zero-Valent Iron (Fe) and Magnetite (Fe3O4) on Methane Yield and Microbial Consortium in Anaerobic Digestion of Food Wastewater

Direct interspecies electron transfer (DIET), which does not involve mediation by electron carriers, is realized by the addition of conductive materials to an anaerobic digester, which then activates syntrophism between acetogenic and methanogenic microorganisms. This study aimed to investigate the effect of the addition of two conductive materials, zero-valent iron (ZVI) and magnetite, on the methane production and microbial consortium via DIET in the anaerobic digestion of food wastewater. The operation of a batch reactor for food wastewater without the addition of the conductive materials yielded a biochemical methane potential (Bu), maximum methane production rate (Rm), and lag phase time (λ) of 0.380 Nm3 kg−1-VSadded, 15.73 mL day−1, and 0.541 days, respectively. Upon the addition of 1.5% ZVI, Bu and Rm increased significantly to 0.434 Nm3 kg−1-VSadded and 19.63 mL day−1, respectively, and λ was shortened to 0.065 days. Simultaneously, Methanomicrobiales increased from 26.60% to 46.90% and Methanosarcinales decreased from 14.20% to 1.50% as the ZVI input increased from 0% to 1.50%. Magnetite, at an input concentration of 1.00%, significantly increased the Bu and Rm to 0.431 Nm3 kg−1-VSadded and 18.44 mL day−1, respectively. However, although magnetite improves the efficiency of methanogenesis via DIET, the effect thereof on the methanogen community remains unclear.

Response of methanogenic system to long-term polycyclic aromatic hydrocarbon exposure: Adsorption and biodegradation, performance variation, and microbial function assessment

Phenanthrene (PHE) as a typical polycyclic aromatic hydrocarbon (PAH) is prevalent and harmful to organisms in petroleum-polluted sites. The effects of PHE concentration levels on performance, microbial community and functions in methanogenic system were comprehensively investigated by an operation of UASB reactor (198 days) and a series of batch tests. The results found that PHE was prone to accumulate in reactor by sludge adsorption (Final concentration = 12.53 mg/g TS Sludge), which posed significant influences on methanogenic system. The removal of chemical oxygen demand (COD), NH₄⁺-N and volatile fatty acids (VFAs) in reactor were reduced with PHE accumulation. Meanwhile, microbes with higher ATPase secrete more EPS activity to self-protect against PHE toxicity. Sequencing analysis showed that PHE interfered significantly diversity and structure of microbial community. For bacteria, PHE was toxic to Bacteroidetes and Latescibacteria, while syntrophs (f_Syntrophaceae, Syntrophorhabdus, etc.) involved in VFAs oxidation and aromatic organics degradation were tolerant of PHE stress. For archaea, acetoclastic methanogens (Methanosaeta) abundance was continuously diminished by 45.1% under long-term PHE exposure. Further functions analysis suggested that microbial community accelerated amino acid metabolism, energy metabolism and xenobiotics biodegradation & metabolism to satisfy physiological demanding under PHE stress. Combining batch tests of methanogenic metabolism proved that acetoclastic methanogenesis was negatively affected by PHE due to inhibition of functional enzymes (acetate kinase, phosphate acetyltransferase, etc.) expression. These findings may provide the basis for enhancing bioremediation of PAH pollution in anaerobic environment.

Maximizing the energy recovery from rice straw through two-step conversion using eggshell-catalytic pyrolysis followed by enhanced anaerobic digestion using calcium-rich biochar

Anaerobic digestion of lignocelluloses for biogas production is greatly restricted by the poor biomass degradability. Herein, a novel approach is suggested to enhance the energy recovery from rice straw through a two-step conversion using eggshell-based catalytic pyrolysis followed by biochar-based anaerobic co-digestion. Pyrolysis with eggshell significantly enhanced the crude bio-oil yield by 4.6 %. Anaerobic digestion of rice straw using 4 g L^-1 of rice straw biochar (RB) showed the highest recorded biogas yield of 503.7 L kg^-1 VS, with 268.6 L kg^-1 VS biomethane yield. However, 4 g L^-1 of calcium-enriched eggshell rice straw biochar (ERB) enhanced the biomethane yield to 281.8 L kg^-1 VS, which represented 95.6 % higher than the control. It was attributed to enhancement of biomethanation, which resulted in 74.5 % maximum recorded biomethane content at the 7th day of anaerobic digestion. Microbial analysis confirmed that Methanosarciniales was the most dominant Archael group in the control (14.84 %), which increased sharply to 73.91 % and 91.66 % after addition of 4 g L^-1 RB and ERB, respectively. The suggested route enhanced the energy recovery in the form of bio-oil and biomethane by 41.6 %.

Promotion of methane production and degradation of pyrolysis oil during its co-anaerobic digestion process via addition of N-doping hydro-chars

Pyrolysis of wastes usually produces toxic pyrolysis oil (PO), which has complex ingredients, including benzene series and long-chain macromolecule organic pollutants. Co-anaerobic digestion (co-AD) can be an economic and high-efficiency method for PO degradation and recovery of methane simultaneously, but complete degradation of PO has not been achieved yet. Addition of a hydro-char in the process is beneficial to PO degradation and methane production. In this study, to further enhance the effectiveness of the hydro-char, nitrogen (N) was doped into the hydro-char by plasma modification in a NH₃ atmosphere; and the effectiveness of the N-doped hydro-chars for promoting PO degradation and methane production during the co-AD process were evaluated. The experimental results indicated that all the hydro-chars can reduce the biotoxicity of the PO, improve its degradation during the co-AD process, and increase the methane yield. Compared with the plain hydro-char (HC), the hydro-chars modified at ambient temperature (HC-NH₃-P-25) and at 500 °C (HC-NH₃-P-500) can help achieving complete PO degradation and increasing the methane yield more effectively. The anaerobic digestor containing the HC-NH₃-P-500 had the highest apparent methane yield (169.03 mL_CH4/mL_PO) and highest COD removal rate (79.5%). The nitrogen content, specific surface area, and electron transfer capability are found to be the key factors affecting PO degradation and methane yield; and the HC-NH₃-P-500 had the highest N-doping, most specific surface area and electron transfer capability, explaining its best performance. The microbial communities of the digestate with the addition of the hydro-chars were founded to be richer with Clostridia and Methanosarcina, which could enhance the electron transfer between different microorganisms and contribute to the PO degradation.

Varied promotion effects and mechanisms of biochar on anaerobic digestion (AD) under distinct food-to-microorganism (F/M) ratios and biochar dosages

Biochar (BC) promotes the performance of anaerobic digestion (AD) through different routes, such as enriching microbes, buffering pH and promoting electron transfer. However, the mechanisms and processes of AD that enhanced by BC under various food to microorganism (F/M) ratios are still unclear. The organic transformations, bioelectrochemical characteristics and microbial consortia under the different BC dosages and F/M ratios were studied to reveal the role of BC in an AD process. The electron transfer system (ETS) was proportional to BC dosage and considered to be a key for AD promotion. At the F/M ratios of 0.5 and 1.0, BC accelerated methane production mainly by promoting ETS. The most enhanced specific methanation activities (SMAs) were obtained with 10.0 g/L BC, and the promotion efficiency under the F/M ratio of 1.0 was significantly higher (P < 0.05) than that under the F/M ratio of 0.5. Under the higher F/M ratio of 2.0, BC shortened the entire AD duration for 5.0 ∼ 13.0 days and guaranteed the resilience of AD by expanding the thermodynamic window of syntrophic methanogenesis via direct interspecies electron transfer (DIET). The COD balance analysis and the ecological functional profiles of microbes demonstrated that BC promoted both the anabolism and catabolism of anaerobes, and enhanced the DIET by converting hydrotrophic methanogenesis into acetolastic methanogenesis pathway. Besides, excessive BC enhanced SMA and simultaneously triggered superfluous biomass growth and thus decreased CH₄ yield. This study provided an important reference for further application of BC under various F/M ratios and dosages in AD.

Effect of optimized intermittent mixing during high-solids anaerobic co-digestion of food waste and sewage sludge: Simulation, performance, and mechanisms

Inadequate mixing has been proven to be a major cause of anaerobic digester failure. This study revealed the mechanism of mixing intervals on high-solids anaerobic co-digestion (HS-AcoD) of food waste (FW) and sewage sludge (SS). Optimized intermittent mixing time (15 min/h) was determined through computational fluid dynamics (CFD) simulation. Experimental results indicated that the simulated intermittent mixing could shorten digestion time and increase cumulative methane output (366.8 mL/gVS) compared with continuous mixing and unmixing. Mixing could considerably accelerate substrate solubilization and hydrolysis. Maximum rates of acidogenesis (53.35 %) and methanogenesis (49.41 %) were observed with an optimized intermittent mixing (15 min/h). Vigorous mixing induced apoptosis and disrupted syntrophic metabolism, whereas intermittent mixing promoted the syntrophic metabolism between Syntrophomonas and Methanobacterium, and led to an enrichment of genes involved in acidogenic and methanogenic pathways. These findings have important implications for the development of an optimized intermittent mixing strategy for maximizing HS-AcoD efficiency of FW and SS.

Bioconversion of Plastic Waste Based on Mass Full Carbon Backbone Polymeric Materials to Value-Added Polyhydroxyalkanoates (PHAs)

This review article will discuss the ways in which various polymeric materials, such as polyethylene (PE), polypropylene (PP), polystyrene (PS), and poly(ethylene terephthalate) (PET) can potentially be used to produce bioplastics, such as polyhydroxyalkanoates (PHAs) through microbial cultivation. We will present up-to-date information regarding notable microbial strains that are actively used in the biodegradation of polyolefins. We will also review some of the metabolic pathways involved in the process of plastic depolymerization and discuss challenges relevant to the valorization of plastic waste. The aim of this review is also to showcase the importance of methods, including oxidative degradation and microbial-based processes, that are currently being used in the fields of microbiology and biotechnology to limit the environmental burden of waste plastics. It is our hope that this article will contribute to the concept of bio-upcycling plastic waste to value-added products via microbial routes for a more sustainable future.

Insights into the role of biochar on the acidogenic process and microbial pathways in a granular sulfate-reducing up-flow sludge bed reactor

In this study, the effect of biochar on sulfate reduction and anaerobic acidogenic process was explored in a granular sulfate-reducing up-flow sludge bed reactor in both long-term operation and batch tests. Both bioreactors had a high sulfate reduction efficiency of over 95% during the long-term operation, while the reactor with biochar addition showed higher sulfate reduction efficiency and stronger robustness against volatile fatty acids accumulation with a higher organic loading and sulfate loading rate. Batch tests showed that adding biochar significantly lessened the lag phase of the sulfate-reducing process, accelerated the adaption of acidogens, and facilitated both production and utilization of volatile fatty acids. The microbial pathways proved that biochar could regulate the acidification fermentation pathway and facilitate the enrichment of assimilative desulfurization bacteria. Overall, this study revealed that the acidogenic sulfate-reducing metabolic pathway could be enhanced by biochar, offering a potential application for effective sulfate-laden wastewater treatment.

Biochar assisted cellulose anaerobic digestion under the inhibition of dodecyl dimethyl benzyl ammonium chloride: Dose-response kinetic assays, performance variation, potential promotion mechanisms

This study evaluated the inhibitory effect and mitigation strategy of dodecyl dimethyl benzyl ammonium chloride (DDBAC) suppression on anaerobic digestion. With the 12 h-suppression, only 16.64% of anaerobes were alive, and acetotrophic methanogens were significantly inhibited. As for batch test, DDBAC suppression significantly prolonged the start-up of systems and decreased the biogas production. In cellulose semi-continuous digestion process, the DDBAC suppression induced volatile fatty acids accumulation and pH decrease. However, the biochar amended reactor effectively mitigated the DDBAC suppression and achieved 370.5 mL/d·g-chemical-oxygen-demand biogas production. Moreover, 17.8% more protein in extracellular polymeric substances was secreted as the bio-barrier to defense the DDBAC suppression. Furthermore, microbial analysis showed that biochar addition selectively enriched directed interspecies electron transfer (DIET) participant bacteria (Anaerolineaceae and Syntrophomonas) and methanogens (Methanosaeta and Methanobacterium). Meanwhile, the potential metabolic pathway analysis showed that the abundance of amino acids and energy metabolism were increased 28% and 8%, respectively. The abundance of encoding enzyme related to hydrogenotrophic and acetotrophic methanogenesis enriched 1.88 times and 1.48 times, respectively. These results showed the performance and mechanisms involved in DIET establishment with ethanol stimulation biochar addition.

Promotion of granular activated carbon on methanogenesis of readily acidogenic carbohydrate-rich waste at low inoculation ratio

Although granular activated carbon (GAC) supplementation into food waste anaerobic digestion system is an efficient means to enhance methane production. As yet, little is known whether GAC supplementation is suitable for the extreme condition of pH below 4.5, which occurs in the use of readily acidogenic carbohydrate-rich waste (RACW) as methanogenic substrate when at low inoculation/substrate (I/S) ratio. This study investigated the effects of GAC on RACW anaerobic digestion under different inoculation/substrate (I/S) ratios. It was found that the addition of GAC was a preferred alternative method to enhancing I/S ratio for promoting methane production from RACW. The additive dose of 20 g/L was recommended for the methanogenesis of RACW at low I/S of 1:2, and the methane yield was enhanced by 12 times (505 mL/g-VS) compared with that (42 mL/g-VS) from the control. This promotion resulted from the apparently solving the over-acidogenesis problem and the adjustment of pH to the desired range. Further investigation revealed that the added GAC enhanced the activities of acetate kinase and coenzyme F₄₂₀, that engaged in the acidogenic and methanogenic reactions. Meanwhile, the decrease of hydrogenase and increase of c-Cyts implied that the metabolism of direct interspecies electron transfer (DIET) was probably stimulated by GAC. Microbial investigation inferred that the enriched hydrogenotrophic methanogens and DIET-mediated syntrophic partners of Geobacter/Syntrophomonas with Methanosarcina were responsible for the enhanced methane yield.

[Bmim]FeCl4 mediated inhibition and toxicity during anaerobic digestion: Dose-response kinetics, biochar-dependent detoxification and microbial resistance

[Bmim]FeCl₄, or 1‑butyl‑3-methylimidazolium tetrachloroferrate, is a typical ionic liquid (IL). Its recyclable, magnetic, multicomponent, and solvent-free nature makes it a particularly attractive ionic liquid for use in industrial processes. Despite its widespread use, the potential hazards that [Bmim]FeCl₄ might pose to the environment, including productive microorganisms, have not been explored. In this study, the dose-response of [Bmim]FeCl₄ in anaerobic digestion (AD) was investigated to assess the potential toxification and biochar-dependent detoxification in microbial communities, including enzymatic activity and molecule docking dynamics. Our results showed that methane production (31.52 mL_max/gVS) was sharply inhibited following [Bmim]FeCl₄ treatment. Moreover, increasing the dosage of [Bmim]FeCl₄ caused more dissolved organic matter (DOM) to be generated. Interestingly, 0.4 g/L of [Bmim]FeCl₄ could stimulate the high activity of microbial hydrolase and ATPase. However, a higher concentration of 2.65 g/L prevented these enzymatic processes from continuing. At the cellular level, higher concentration of [Bmim]FeCl₄ (>0.4 g/L) increased malondialdehyde (MDA) levels, leading to a higher cell lethal rate and weakening of the secondary structures of protein (especially, the amide I region). At the molecular level, the competitive H-bonding in the active sites caused low activity and consummated more energy. At the community level, structural equation modeling (SEM) revealed that [Bmim]FeCl₄ and biochar were the main drivers for microbial community succession. For instance, high [Bmim]FeCl₄ (8 g/L) benefited the growth of Clostridium sensu_stricto (from ≤1% to 27%). It is worth mentioning that biochar reversed the inhibition with high α-diversity, which caused a resurgence in the activity of previously inhibited ATPase and hydrolase. H₂-trophic methanogens (Methanolinea and Methaofastidisoum) were sensitive to [Bmim]FeCl₄ and decreased linearly while acetoclastic methanogens (Methanosaeta) were unchanged. These findings were consistent with the short-term activity tests and further verified by functional analysis.

The dosage-effect of biochar on anaerobic digestion under the suppression of oily sludge: Performance variation, microbial community succession and potential detoxification mechanisms

This study investigated the dosage-effect of biochar on the suppressed mesophilic digestion of oily sludge (OS) containing naphthalene (recalcitrant compound) and starch (easily bioavailable substrate). Methanogenesis was inhibited in control with OS, where biomethane yield (63.33 mL/gVS) was obviously lower than theoretical yield (260.55 mL/gVS). With adding optimal dose of biochar (0.60 g/gVS OS), the highest CH₄ yield (138.41 mL/gVS) was 2.19 times of control. Meanwhile, the efficiencies of hydrolysis, acidogenesis and acetogenesis were significantly enhanced. However, excessive biochar (4.80 g/gVS OS) caused negative effects with methanogenic efficiency diminished by 32.5% and lag phase prolonged by 5.72 h. Dissolved organic matter (DOM) analysis showed that humic acid-like and fulvic acid-like components percentages of fluorescence regional integration were decreased because of the adsorption of biochar. In addition, biochar mediating interspecies electron transfer selectively enriched electroactive fermentation bacteria (Clostridium and Bacteroides) and acetoclastic Methanosaeta, which was responsible for promoting mesophilic digestion performance. The functional genes related to metabolism and environmental information processing were potentially activated by biochar. Above results indicate that moderate biochar application may mitigate the bio-toxicity suppression of OS, which help to provide a promising pathway for reinforcing oily wastes bio-treatment.

Single and simultaneous effects of naphthalene and salinity on anaerobic digestion: Response surface methodology, microbial community analysis and potential functions prediction

Polycyclic aromatic hydrocarbons (PAHs) are a persistent and prevalent class of pollutants in petroleum-contaminated saline environment, which pose potential harm to organisms. Researches on anaerobic biodegradation of PAHs are gradually emerging, but the response of anaerobic microorganisms to salinity changes and the co-effects of salinity and PAHs in anaerobic digestion (AD) system have seldom been reported. Thus, we investigated the variations of AD system performance and anaerobic microbial community caused by different concentrations of naphthalene (Nap) or/and NaCl based on Box-Behnken Design (0 mg/L ≤ Nap ≤150 mg/L, 0 g/L ≤ NaCl ≤25 g/L). The promoted efficiencies of acidogenesis and methanogenesis were found in presence of moderate NaCl or Nap, but high salinity (NaCl >4.4 g/L) weakened AD performance. Moreover, the high salinity (NaCl >4.4 g/L) and Nap resulted in reduced microbial Ca²⁺ Mg²⁺- ATPase activity, poor EPS secretion and the highest difference of the microbial operational taxonomic units (OTUs), and synergistically inhibited AD process. Microbiological analysis revealed that the relative abundance of Clostridium and acetoclastic Methanosaeta was increased by 2.01 times and 2.17 times in single Nap treated group compared to control. With the simultaneous addition of NaCl and Nap, Proteiniphilum and hydrogenotrophic methanogens (Methanobacterium, Methanofollis, and Methanolinea) occupied the major abundance. Potential functions prediction indicated that high salinity could disrupt the co-metabolism between carbohydrate metabolism and Nap degradation. This study provides basis for anaerobic bioremediation of PAHs-polluted saline environment.

Biological conversion of carbon monoxide and hydrogen by anaerobic culture: Prospect of anaerobic digestion and thermochemical processes combination

Waste biomass is considered a promising renewable energy feedstock that can be converted by anaerobic digestion. However, anaerobic digestion application can be challenging due to the structural complexity of several waste biomass kinds. Therefore, coupling anaerobic digestion with thermochemical processes can offset the limitations and convert the hardly biodegradable waste biomass, including digestate residue, into value-added products: syngas and pyrogas (gaseous mixtures consisting mainly of H₂, CO, CO₂), bio-oil, and biochar for further valorisation. In this review, the utilisation boundaries and benefits of the aforementioned products by anaerobic culture are discussed. First, thermochemical process parameters for an enhanced yield of desired products are summarised. Particularly, the microbiology of CO and H₂ mixture biomethanation and fermentation in anaerobic digestion is presented. Finally, the state-of-the-art biological conversion of syngas and pyrogas to CH₄ mediated by anaerobic culture is adequately described. Extensive research shows the successful selective biological conversion of CO and H₂ to CH₄, acetic acid, and alcohols. The main bottleneck is the gas-liquid mass transfer which can be enhanced appropriately by bioreactors' configurations. A few research groups focus on bio-oil and biochar addition into anaerobic digesters. However, according to the literature review, there has been no research for utilising all value-added products at once in anaerobic digestion published so far. Although synergic effects of such can be expected. In summary, the combination of anaerobic digestion and thermochemical processes is a promising alternative for wide-scale waste biomass utilisation in practice.

Biochar amendment rapidly shifts microbial community structure with enhanced thermophilic digestion activity

Effects of powdered (<0.075 mm) biochar on thermophilic anaerobic digestion were investigated with biochemical methane potential (BMP) assays. The assays had substrate to inoculum ratios (SIR) of 2.2 and 4.4 g-volatile solids (VS)/g-VS and biochar dosing of 6 g/g-total solids (TS)_inoculum. Compared to control, biochar amendment enhanced methane production rates by 94%, 75%, and 20% in assays utilizing substrates of acidified sludge at 70 °C, 55 °C and non-acidified mixed sludge, respectively. All controls experienced acute inhibition with lag phases from 12 - 52 days at SIR of 4.4 g-VS/g-VS, while assays with biochar generated methane from day 4. Biochar addition resulted in a rapid shift in microbial community structure associated with an increase in Methanothermobacteraeae (hydrogenotrophic) and Methanosarcinaceae archaea, as well as various volatile fatty acid (VFA)-degrading and hydrogen-producing bacteria. Biochar presents great potential to tackle VFA accumulation, abbreviate lag phase and increase methane rate, particularly at high organic loadings.

The anaerobic oxidation of methane in paddy soil by ferric iron and nitrate, and the microbial communities involved

The anaerobic oxidation of methane (AOM) mediated by microorganisms is a key process in the reduction of methane emissions, and AOM-coupled electron acceptors have been shown to regulate methane emissions into the atmosphere in marine systems. Paddy fields are a significant source of methane and account for 20% of global methane emissions, but the effect of electron acceptors on the methane emission process in flooded paddy fields has been poorly characterized. This study aimed to determine whether the electron acceptors ferric iron and nitrate, and biochar, acting as an electron shuttle, can regulate the AOM process in paddy soil, with or without interaction between biochar and these two electron acceptors. We also aimed to characterize which microorganisms are actively involved. Here, we added ¹³C-labeled CH₄ (¹³CH₄) into anaerobic microcosms to evaluate the role of electron acceptors by measuring the methane oxidation rate and the enrichment of ¹³C-labeled CO₂ (¹³CO₂). We then combined DNA-stable isotope probing with amplicon sequencing to study the active microorganisms. We found for the first time that, in addition to nitrate, ferric iron can also effectively promote AOM in paddy soil. However, there was no significant effect of biochar. Ferric iron-dependent AOM was mainly carried out by iron-reducing bacteria (Geobacter, Ammoniphilus and Clostridium), and nitrate-dependent AOM was mainly by nitrate-reducing bacteria (Rhodanobacter, Paenibacillus and Planococcus). Our results demonstrate that the AOM process, regulated by the electron acceptors ferric iron and nitrate, can alleviate methane emission from paddy soil. The potentially active microorganisms related to electron acceptor reduction may be crucial for this methane sink and deserve further research.

Food waste and sewage sludge co-digestion amended with different biochars: VFA kinetics, methane yield and digestate quality assessment

This work investigated the impact of the addition of different biochar types on mitigation of volatile fatty acid (VFA) accumulation, methane recovery and digestate quality in mesophilic food waste-sludge co-digestion. Four biochars derived from agricultural and sludge residues under different pyrolysis temperatures were compared. Specific biochar properties such as pH, surface area, chemical properties and presence of surface functional groups likely influenced biochar reactions during digestion, thereby resulting in a varying performance of different biochars. Miscanthus straw biochar addition led to the highest specific methane yield of 307 ± 0.3 mL CH₄/g VS_added versus 241.87 ± 5.9 mL CH₄/g VS_added from control with no biochar addition over 30 days of the co-digestion period. Biochar supplementation led to enhanced process stability which likely resulted from improved syntrophic VFA oxidation facilitated by specific biochar properties. Overall, a 21.4% increase in the overall methane production was obtained with biochar addition as compared to control. The resulting digestate quality was also investigated. Biochar-amended digester generated a digestate rich in macro- and micro-nutrients including K, Mg, Ca, Fe making biochar-amended digestate a potential replacement of agricultural lime fertilizer. This work demonstrated that the addition of specific biochars with desirable properties alleviated VFA accumulation and facilitated enhanced methane recovery, thereby providing a means to achieve process stability even under high organic loading conditions in co-digestions. Moreover, the availability of biochar-enriched digestate with superior characteristics than biochar-free digestate adds further merit to this process.

Improving anaerobic digestion of chicken manure under optimized biochar supplementation strategies

Anaerobic digestion of chicken manure was carried out in this study basing on central composite design to identify the most optimal strategy for biochar supplementation. Model of cumulative methane production (CMP) was established by using response surface methodology. The optimal conditions predicted accordingly, including manure loading of 51.8 g VS/L, biochar dosage of 3.3% VS_manure, and cellulose loading of 98.0 g VS/L, were expected to maximize CMP, i.e., 294 mL/g VS_manure. The results also demonstrated that biochar dosage and its interaction with manure loading were key factors with significant impact on CMP. Biochar dosage higher than 3.5% VS_manure was observed to weaken the transformation of organic substances to methane. Higher dosage of biochar could considerably reduce concentration of organic acids, total ammonia nitrogen, as well as soluble salts. Verification experiment supported validity of the optimal strategy and provided data for cost assessment, which showed positive cost balances from biochar supplementation.

Anaerobic co-digestion of chicken manure and cardboard waste: Focusing on methane production, microbial community analysis and energy evaluation

This study aimed to investigate the synergistic effect and microbial community changes between chicken manure (CM) and cardboard (CB) during anaerobic co-digestion. Meanwhile, the energy balance of biogas engineering was extrapolated based on the batch tests. In batch tests, co-digestion system achieved the highest improvement (14.2%) and produced 319.62 mL CH₄/gVS with a 65:35 ratio of CB: CM. More extracellular polymeric substance secretion promoted the electron transfer for acidogenesis and more hydrolase was provided with 31.6% improvement. The microbial analysis illustrated that higher acetoclastic Methanosaeta abundance was achieved, leading to 211% enhancement of acetoclastic pathway. Moreover, associated network illustrated that the higher methane production was mainly achieved through matching of hydrolytic bacteria and acidogenesis bacteria. As for energy balance, the synergistic effect increased the energy output by 38% and energy recovery to 46.4%.

Insight into sludge anaerobic digestion with granular activated carbon addition: Methanogenic acceleration and methane reduction relief

In this study, the multiple effects of granular activated carbon (GAC) on sludge anaerobic digestion at ambient (16-24 °C), mesophilic (35 °C) and thermophilic (55 °C) temperature were investigated. After GAC addition, although the methane yields of raw sludge were reduced by 6.5%-36.9%, the lag phases of methanogenesis were shortened by 19.3%-30.6% and the reductions of methane yields were declined to only 5.9%-8.1% simultaneously for pretreated sludge. The inhibitory substances like phenols that generated by thermal pretreatment were reduced after GAC addition, which were demonstrated to be responsible for the methanogenic acceleration. Meanwhile, the methane reduction due to the non-selective adsorption by GAC could be mitigated by pretreatment and elevated temperature. Thus, a strategy coupling thermal pretreatment with detoxification by GAC was proposed to improve the methane production rate and avoid the negative effects during sludge anaerobic digestion with GAC addition.

Enhanced hydrolysis and acidification strategy for efficient co-digestion of pretreated corn stover with chicken manure: Digestion performance and microbial community structure

The effect of enhanced hydrolysis and acidification (EHA) strategy on co-digestion performance of pretreated corn stover (CS) with chicken manure (CM) was investigated. The EHA process was applied to the CS pretreated with KOH and liquid fraction of digestate (LFD), prior to anaerobic digestion. The results showed that the efficiencies of hydrolysis and acidification for the pretreated CS group were significantly higher than the CS group. The maximum cumulative biomethane yield of 240.5 mL·gVS^-1 and 242.0 mL·gVS^-1 were obtained for the KOH CS group and LFD CS group during the EHA process at 1 day, showing 26.6% and 27.4% improvement over that of the control, respectively. T₉₀ was shortened by 38.2%-44.1% and 17.7%-38.2%, correspondingly. The synergistic effects and hydrolysis kinetics were also enhanced by the EHA process. The communities of bacteria (Firmicutes, Proteobacteria, and Bacteroidetes) and archaea (Methanosaeta, Methanobacterium, and Methanosarcina) were enriched by the EHA process, and their interactions contributed to the improved digestion performance. Therefore, the EHA process was recommended for efficient biomethane conversion in co-digestion of CS and CM.

Enhancement methane fermentation of Enteromorpha prolifera waste by Saccharomyces cerevisiae: batch kinetic investigation, dissolved organic matter characterization, and synergistic mechanism

With the invasion of green tide, there were millions of tons of Enteromorpha prolifera (Enteromorpha) that need to be disposed of. An efficient microecological system for Enteromorpha fermentation was constructed using Saccharomyces cerevisiae (S. cerevisiae) and granular sludge at mesophilic condition (35 °C). In order to investigate the influence of S. cerevisiae dosage on fermentation, biomethane production and variations in dissolved organic matter (DOM) were investigated. The results indicated that the microecosystem with added S. cerevisiae exhibited improved fermentation capacity. Specifically, biomethane production was improved by 18%, with a maximum methane yield of 331 mL/g VS, and the time required to reach 90% methane yield was reduced by 41%. There were positive linear relationships between S. cerevisiae dosage and the efficiency of hydrolysis, acidogenesis, acetogenesis, and methanogenesis (R² > 0.9). According to theoretical calculations, there was a positive effect of lower S. cerevisiae dosage (less than 0.93 g/g TS) on biomethane production, and excess dosage (more than 0.93 g/g TS) led to a negative effect due to volatile fatty acid (VFA) accumulation. The excitation-emission matrix (EEM) indicated that the humification index (HIX) and fulvic acid (FA) percentage of fluorescence regional integration in the system were decreased because the quinone and ketone groups of the FA accepted electrons from S. cerevisiae. These findings suggested that this microecosystem can accelerate fermentation speed (41%) and increase biomethane output (18.2%). The synergistic effect of Enteromorpha fermentation with Saccharomyces cerevisiae addition.

Effects of biochar parent material and microbial pre-loading in biochar-amended high-solids anaerobic digestion

This study characterises the effect of biochar (pyrolysed biomass) produced from wood pellets, wheat straw and sheep manure on high-solids anaerobic digestion (HSAD) of poultry litter. Also, pre-loading biochar with microorganisms before addition to HSADs was investigated. The addition of wood pellet biochar provides a 32% increase to the methane yield compared with control digesters. The addition of biochar produced from either wheat straw or sheep manure has detrimental effects on digester performance compared with controls. The addition of wood pellet biochar pre-loaded by placing it in a high-solids digester for 90 days provides a 69% increase in the total methane yield, 44% increase in the peak daily methane yield and a 33% reduction in the lag time compared with controls. This study highlighted a need for careful selection of parent material for biochar production and, for the first time, the opportunities to re-use wood pellet biochar for further improvements.

Achievements of biochar application for enhanced anaerobic digestion: A review

Anaerobic digestion (AD) and pyrolysis are two promising technologies used worldwide for waste biomass treatment. Interests on intensification techniques of AD has been increasing to obtain sufficient and sustainable methane production with stable digester performance. For instance, considerable attention has been devoted to the coupling of AD with biochar, which is produced by biomass thermochemical conversion. This manuscript presents a comprehensive review about recent achievements in enhancing AD efficiency with the utilization of biochar. The key roles of biochar include enhancing and equilibrating hydrolysis, acidogenesis-acetogenesis, and methanogenesis, as well as alleviating inhibitor stress were summarized. Biochar can promote biomethane process mainly by serving as a provision for bioelectrical connections between fermentative bacteria and methanogens, a support for microbial colonies, and a reinforcer for buffer capacity. Through an overview of the early applications, this paper aims to pinpoint the potential mechanism and future explorative directions of biochar enhancing AD performance.