Integrated Fixed Film Activated Sludge (IFAS) membrane BioReactor: The influence of the operational parameters

Comparative Analysis of Bacterial Information of Biofilms and Activated Sludge in Full-Scale MBBR-IFAS Systems

This study extensively analyzed the bacterial information of biofilms and activated sludge in oxic reactors of full-scale moving bed biofilm reactor-integrated fixed-film activated sludge (MBBR-IFAS) systems. The bacterial communities of biofilms and activated sludge differed statistically (R = 0.624, p < 0.01). The denitrifying genera Ignavibacterium, Phaeodactylibacter, Terrimonas, and Arcobacter were more abundant in activated sludge (p < 0.05), while comammox Nitrospira was more abundant in biofilms (p < 0.05), with an average relative abundance of 8.13%. Nitrospira and Nitrosomonas had weak co-occurrence relationships with other genera in the MBBR-IFAS systems. Potential function analysis revealed no differences in pathways at levels 1 and 2 based on the Kyoto Encyclopedia of Genes and Genomes (KEGG) between biofilms and activated sludge. However, in terms of pathways at level 3, biofilms had more potential in 26 pathways, including various organic biodegradation and membrane and signal transportation pathways. In comparison, activated sludge had more potential in only five pathways, including glycan biosynthesis and metabolism. With respect to nitrogen metabolism, biofilms had greater potential for nitrification (ammonia oxidation) (M00528), and complete nitrification (comammox) (M00804) concretely accounted for methane/ammonia monooxygenase (K10944, K10945, and K10946) and hydroxylamine dehydrogenase (K10535). This study provides a theoretical basis for MBBR-IFAS systems from the perspective of microorganisms.

Research progress of anaerobic ammonium oxidation (Anammox) process based on integrated fixed-film activated sludge (IFAS)

The integrated fixed-film activated sludge (IFAS) process is considered one of the cutting-edge solutions to the traditional wastewater treatment challenges, allowing suspended sludge and attached biofilm to grow in the same system. In addition, the coupling of IFAS with anaerobic ammonium oxidation (Anammox) can further improve the efficiency of biological denitrification. This paper summarises the research progress of IFAS coupled with the anammox process, including partial nitrification anammox, simultaneous partial nitrification anammox and denitrification, and partial denitrification anammox technologies, and describes the factors that limit the development of related processes. The effects of dissolved oxygen, influent carbon source, sludge retention time, temperature, microbial community, and nitrite-oxidising bacteria inhibition methods on the anammox of IFAS are presented. At the same time, this paper gives an outlook on future research focus and engineering practice direction of the process.

Enhanced biological phosphorus removal by high concentration powder carrier bio-fluidized bed (HPB): Phosphorus distribution, cyclone separation, and metagenomics

This study provides a comparative investigation of phosphorus removal between anaerobic-anoxic-oxic (AAO) and high-concentration powder carrier bio-fluidized bed (HPB) in the same full-scale wastewater treatment plant. The results showed that the total phosphorus removal of HPB was 71.45%-96.71%. Compared with AAO, the total phosphorus removal of HPB can be increased by a maximum of 15.73%. The mechanisms of enhanced phosphorus removal by HPB include the followings. Biological phosphorus removal was significant. The anaerobic phosphorus release capacity of HPB was enhanced and polyphosphate (Poly-P) in the excess sludge of HPB was 1.5 times higher than that of AAO. The relative abundance of Candidatus Accumulibacter was 5 times higher than that of AAO, and oxidative phosphorylation and butanoate metabolism were enhanced. The analysis of phosphorus distribution showed that cyclone separation increased the chemical phosphorus precipitation (Chem-P) in the excess sludge by 16.96% to avoid accumulation in the biochemical tank. The phosphorus adsorbed by extracellular polymeric substance (EPS) in the recycled sludge was stripped, and the EPS bound-P in the excess sludge increased by 1.5 times. This study demonstrated the feasibility of HPB to improve the phosphorus removal efficiency for domestic wastewater.

Triclocarban-contaminated wastewater treatment by innovative hybrid moving entrapped bead activated sludge reactor (HyMER): Continuous performance and computational dynamic simulation analysis

Triclocarban (TCC) has been used in consumer products and is a widespread contaminant in municipal wastewater treatment systems that ultimately accumulates in natural receiving water and soil. This work aims to apply an innovative hybrid moving entrapped bead activated sludge reactor (named "HyMER") that integrates entrapped TCC-degrading microbes and freely suspended activated sludge to treat TCC-contaminated wastewater. A previously isolated TCC-degrading bacterium (Pseudomonas fluorescens strain MC46, called MC46) and barium alginate entrapment were applied. The synthetic TCC-contaminated wastewater treatment (with TCC concentration of 10 mg/L) was performed using 20-cycle fed-batch reactor operation with feeding times of 12 and 24 h and cycle times of 13 and 25 h. The results indicated that the HyMER effectively reduced chemical oxygen demand by up to 80 and 95 % and TCC by up to 53 and 83 %, respectively, with feeding times of 12 and 24 h. Three TCC degradation intermediate products were found-3,4-dichloroaniline, 4-chloroaniline, and aniline. Scanning electron microscopic analysis revealed shorter cells and bacterial appendage development as cell adaptations against TCC and its intermediates. The live/dead assay indicated high survival of entrapped MC46 in toxic conditions, with up to 84 % viable cells. Based on computational fluid dynamic analysis, no entrapped cell agglomeration showed in the reactor, indicating the potential application of HyMER for real wastewater treatment. These results exhibit the feasibility of HyMER and its applicability for future toxic wastewater treatment.

COD/TN ratios shift the microbial community assembly of a pilot-scale shortcut nitrification-denitrification process for biogas slurry treatment

In this study, effects of carbon to nitrogen (COD/TN) ratios of biogas slurry on shortcut nitrification-denitrification in a pilot-scale integrated fixed film activated sludge (IFAS) system were investigated. Lowering the COD/TN ratio from 11.7 to 6.2 exerted a negative impact on shortcut nitrification-denitrification performance. Accordingly, the NH₃-N and TN removal rates decreased from 94.4 to 91.2% and 92.3 to 85.9%, respectively. The dynamics of microbial assembly was analyzed by MiSeq sequencing, and the denitrifying functional genes were quantified by qPCR. The results showed that ammonia oxidizing bacteria and amoA gene were more abundant on the biofilm of oxic tank, indicating they play a key role in NH₃-N removal. Autotrophic, endogenous, and fast heterotrophic kinetics denitrifiers were coexisted and enriched in the IFAS system with a decreasing of COD/TN ratio. TN removal was mainly affected by denitrifiers (including Arenimonas, Acidovorax, and Thaurea) harboring narG and nirS genes. Canonical correspondence analysis proved that COD/TN ratio was the most critical factor driving the succession of microbial community. Dissolved oxygen (DO) and pH were found positively correlated with denitrifiers at low COD/TN ratio conditions. As a result, NH₃-N and TN removal were effectively enhanced when the DO level in the oxic tank of IFAS system was increased to 1.0-3.0 mg/L.

Optimization nutrient removal at different volume ratio of anoxic-to-aerobic zone in integrated fixed-film activated sludge (IFAS) system

This study evaluated the influence of different volume ratios of the anoxic-to-aerobic zone (V_ano/V_aer) on the enhancement of nitrogen and phosphorus removal in an integrated fixed-film activated sludge (IFAS) system. As the V_ano/V_aer increased from 1:2 to 2:1, the removal of organic carbon, nitrogen and phosphorus nutrients of the IFAS system was improved. At V_ano/V_aer = 1:1, the removal effect of nitrogen and phosphorus nutrients was optimal, and the average removal rates of COD, NH₄⁺-N, TN, and TP of the system reached 90 ± 3.2%, 98.2 ± 1.4%, 88.9 ± 2.2%, and 89.1 ± 2.7%, respectively. As the volume of the anoxic zone continued to increase, the denitrifying phosphate-accumulating capacity of the system was enhanced, and the highest ratio of specific anoxic and aerobic phosphorus uptake rate could reach 65.3%. Analysis of the molecular evaluation showed that, the proportion of nitrifying bacteria in the biofilm gradually increased as V_ano increased. Moreover, denitrifying phosphate-accumulating organisms (DNPAOs), ammonia-oxidizing archaea (AOA), and anaerobic ammonium oxidizing (Anammox) bacteria were all enriched all showed enrichment in the biofilm of fiber carriers, which further strengthened the system's synergistic removal of nitrogen and phosphorus.