1
|
Yu Q, Sun C, Cao W, Liu R, Abd-Alla MH, Rasmey AHM. Rumen fluid pretreatment promotes anaerobic methane production: revealing microbial dynamics driving increased acid yield from different concentrations of corn straw. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2024:10.1007/s11356-024-33615-0. [PMID: 38733442 DOI: 10.1007/s11356-024-33615-0] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/05/2023] [Accepted: 05/05/2024] [Indexed: 05/13/2024]
Abstract
In this work, the corn straw (CS) with concentrations of 3%, 6%, and 9% (w/v) were pretreated by rumen fluid (RF) and then used for batched mesophilic biogas production. The results showed that after a 6-day pretreatment, volatile fatty acid (VFAs) production of 3.78, 8.27, and 10.4 g/L could be found in 3%, 6%, and 9%, respectively. When concerning with biogas production, the highest accumulative methane production of 149.1 mL CH4/g volatile solid was achieved by 6% pretreated CS, which was 22% and 45% higher than 3% and 9%, respectively. Also, it was 3.6 times higher than the same concentration of unpretreated CS. The results of the microbial community structure analysis revealed that the 6% CS pretreatment not only maintained a microbial community with the highest richness and diversity, but also exhibited the highest relative abundance of Firmicutes (45%) and Euryarchaeota (3.9%). This high abundance was conducive to its elevated production of VFAs and methane. These findings provide scientific reference for the utilization of CS and support the development of agricultural waste resource utilization and environmental protection.
Collapse
Affiliation(s)
- Qing Yu
- School of Chemistry and Chemical Engineering, Zhejiang Sci-Tech University, Hangzhou, 310018, People's Republic of China
- College of Biological, Chemical Science and Engineering, Jiaxing University, Jiaxing, 314001, People's Republic of China
| | - Chen Sun
- College of Biological, Chemical Science and Engineering, Jiaxing University, Jiaxing, 314001, People's Republic of China.
| | - Weixing Cao
- College of Biological, Chemical Science and Engineering, Jiaxing University, Jiaxing, 314001, People's Republic of China
| | - Ronghou Liu
- Biomass Energy Engineering Research Centre, School of Agriculture and Biology, Shanghai Jiao Tong University, Shanghai, 200240, People's Republic of China
| | - Mohamed Hemida Abd-Alla
- Botany and Microbiology Department, Faculty of Science, Assiut University, Assiut, 71516, Egypt
| | - Abdel-Hamied M Rasmey
- Botany and Microbiology Department, Faculty of Science, Suez University, Suez, 43518, Egypt
| |
Collapse
|
2
|
Wang N, Xiao M, Zhang S, Chen X, Shi J, Fu S, Shi J, Liu L. Evaluating the potential of different bioaugmented strains to enhance methane production during thermophilic anaerobic digestion of food waste. ENVIRONMENTAL RESEARCH 2024; 245:118031. [PMID: 38157970 DOI: 10.1016/j.envres.2023.118031] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/01/2023] [Revised: 12/21/2023] [Accepted: 12/22/2023] [Indexed: 01/03/2024]
Abstract
Bioaugmentation technology for improving the performance of thermophilic anaerobic digestion (TAD) of food waste (FW) treatment is gaining more attention. In this study, four thermophilic strains (Ureibacillus suwonensis E11, Clostridium thermopalmarium HK1, Bacillus thermoamylovorans Y25 and Caldibacillus thermoamylovorans QK5) were inoculated in the TAD of FW system, and the biochemical methane potential (BMP) batch study was conducted to assess the potential of different bioaugmented strains to enhance methane production. The results showed that the cumulative methane production in groups inoculated with E11, HK1, Y25 and QK5 improved by 2.05%, 14.54%, 19.79% and 9.17%, respectively, compared with the control group with no inoculation. Moreover, microbial community composition analysis indicated that the relative abundance of the main hydrolytic bacteria and/or methanogenic archaea was increased after bioaugmentation, and the four strains successfully became representative bacterial biomarkers in each group. The four strains enhanced methane production by strengthening starch, sucrose, galactose, pyruvate and methane metabolism functions. Further, the correlation networks demonstrated that the representative bacterial genera had positive correlations with the differential metabolic functions in each bioaugmentation group. This study provides new insights into the TAD of FW with bioaugmented strains.
Collapse
Affiliation(s)
- Na Wang
- Shanghai Advanced Research Institute, Chinese Academy of Sciences, Shanghai, 201210, China; University of Chinese Academy of Sciences, Beijing, 100049, China
| | - Mengyao Xiao
- Shanghai Advanced Research Institute, Chinese Academy of Sciences, Shanghai, 201210, China; University of Chinese Academy of Sciences, Beijing, 100049, China
| | - Siying Zhang
- Shanghai Advanced Research Institute, Chinese Academy of Sciences, Shanghai, 201210, China; University of Chinese Academy of Sciences, Beijing, 100049, China
| | - Xiaomiao Chen
- Shanghai Advanced Research Institute, Chinese Academy of Sciences, Shanghai, 201210, China
| | - Jingjing Shi
- Shanghai Advanced Research Institute, Chinese Academy of Sciences, Shanghai, 201210, China; University of Chinese Academy of Sciences, Beijing, 100049, China
| | - Shanfei Fu
- Qingdao Institute of Bioenergy and Bioprocess Technology, Chinese Academy of Sciences, Qingdao, 266101, China
| | - Jiping Shi
- Shanghai Advanced Research Institute, Chinese Academy of Sciences, Shanghai, 201210, China.
| | - Li Liu
- Shanghai Advanced Research Institute, Chinese Academy of Sciences, Shanghai, 201210, China; Shanghai Engineering Research Center of Biotransformation of Organic Solid Waste, Shanghai, 200241, China.
| |
Collapse
|
3
|
Liang J, Zhang R, Chang J, Chen L, Nabi M, Zhang H, Zhang G, Zhang P. Rumen microbes, enzymes, metabolisms, and application in lignocellulosic waste conversion - A comprehensive review. Biotechnol Adv 2024; 71:108308. [PMID: 38211664 DOI: 10.1016/j.biotechadv.2024.108308] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/03/2023] [Revised: 12/14/2023] [Accepted: 01/04/2024] [Indexed: 01/13/2024]
Abstract
The rumen of ruminants is a natural anaerobic fermentation system that efficiently degrades lignocellulosic biomass and mainly depends on synergistic interactions between multiple microbes and their secreted enzymes. Ruminal microbes have been employed as biomass waste converters and are receiving increasing attention because of their degradation performance. To explore the application of ruminal microbes and their secreted enzymes in biomass waste, a comprehensive understanding of these processes is required. Based on the degradation capacity and mechanism of ruminal microbes and their secreted lignocellulose enzymes, this review concentrates on elucidating the main enzymatic strategies that ruminal microbes use for lignocellulose degradation, focusing mainly on polysaccharide metabolism-related gene loci and cellulosomes. Hydrolysis, acidification, methanogenesis, interspecific H2 transfer, and urea cycling in ruminal metabolism are also discussed. Finally, we review the research progress on the conversion of biomass waste into biofuels (bioethanol, biohydrogen, and biomethane) and value-added chemicals (organic acids) by ruminal microbes. This review aims to provide new ideas and methods for ruminal microbe and enzyme applications, biomass waste conversion, and global energy shortage alleviation.
Collapse
Affiliation(s)
- Jinsong Liang
- School of Energy & Environmental Engineering, Hebei University of Technology, Tianjin 300130, China
| | - Ru Zhang
- Beijing Key Lab for Source Control Technology of Water Pollution, College of Environmental Science and Engineering, Beijing Forestry University, Beijing 100083, China
| | - Jianning Chang
- Beijing Key Lab for Source Control Technology of Water Pollution, College of Environmental Science and Engineering, Beijing Forestry University, Beijing 100083, China
| | - Le Chen
- Beijing Key Lab for Source Control Technology of Water Pollution, College of Environmental Science and Engineering, Beijing Forestry University, Beijing 100083, China
| | - Mohammad Nabi
- Beijing Key Lab for Source Control Technology of Water Pollution, College of Environmental Science and Engineering, Beijing Forestry University, Beijing 100083, China
| | - Haibo Zhang
- College of Resources and Environment, Shanxi Agricultural University, Taigu 030801, China
| | - Guangming Zhang
- School of Energy & Environmental Engineering, Hebei University of Technology, Tianjin 300130, China.
| | - Panyue Zhang
- Beijing Key Lab for Source Control Technology of Water Pollution, College of Environmental Science and Engineering, Beijing Forestry University, Beijing 100083, China.
| |
Collapse
|
4
|
Kim D, Cha J, Lee C. Enhanced methane production with co-feeding spent coffee grounds using spare capacity of existing anaerobic food waste digesters. Sci Rep 2024; 14:4472. [PMID: 38396086 PMCID: PMC10891051 DOI: 10.1038/s41598-024-54610-y] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/25/2023] [Accepted: 02/14/2024] [Indexed: 02/25/2024] Open
Abstract
With increasing coffee consumption worldwide, the efficient and sustainable management of spent coffee grounds (SCG) has become increasingly challenging. This study investigated the anaerobic co-digestion of small amounts of SCG with food waste (FW) at increasing co-feeding ratios of 1:100-1:10 (volatile solids basis) to assess the possibility of SCG treatment using the spare capacity of existing anaerobic digesters. Co-feeding SCG increased methane production compared to FW mono-digestion in the tested range of co-feeding ratios without compromising process stability. Methane yield did not further increase when the SCG/FW ratio increased above 4%, and process failure occurred at a 1:10 co-feeding ratio without trace element supplementation. The enhanced methanogenic performance was attributed to increased protein removal efficiency, which was potentially related to the promotion of peptide hydrolysis. The overall results suggest that co-feeding appropriate small amounts of SCG to FW digesters can be a realistic sustainable option for SCG management.
Collapse
Affiliation(s)
- Danbee Kim
- Department of Urban and Environmental Engineering, Ulsan National Institute of Science and Technology (UNIST), 50 UNIST-Gil, Eonyang-Eup, Ulju-Gun, Ulsan, 44919, Republic of Korea
- Gwangju Clean Energy Research Center, Korea Institute of Energy Research, 25, Samso-Ro 270Beon-Gil, Buk-Gu, Gwangju, 61003, Republic of Korea
| | - Junho Cha
- Department of Urban and Environmental Engineering, Ulsan National Institute of Science and Technology (UNIST), 50 UNIST-Gil, Eonyang-Eup, Ulju-Gun, Ulsan, 44919, Republic of Korea
| | - Changsoo Lee
- Department of Urban and Environmental Engineering, Ulsan National Institute of Science and Technology (UNIST), 50 UNIST-Gil, Eonyang-Eup, Ulju-Gun, Ulsan, 44919, Republic of Korea.
- Graduate School of Carbon Neutrality, Ulsan National Institute of Science and Technology (UNIST), 50 UNIST-Gil, Eonyang-Eup, Ulju-Gun, Ulsan, 44919, Republic of Korea.
| |
Collapse
|
5
|
Mu L, Wang Y, Xu F, Li J, Tao J, Sun Y, Song Y, Duan Z, Li S, Chen G. Emerging Strategies for Enhancing Propionate Conversion in Anaerobic Digestion: A Review. Molecules 2023; 28:3883. [PMID: 37175291 PMCID: PMC10180298 DOI: 10.3390/molecules28093883] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/31/2023] [Revised: 04/18/2023] [Accepted: 04/27/2023] [Indexed: 05/15/2023] Open
Abstract
Anaerobic digestion (AD) is a triple-benefit biotechnology for organic waste treatment, renewable production, and carbon emission reduction. In the process of anaerobic digestion, pH, temperature, organic load, ammonia nitrogen, VFAs, and other factors affect fermentation efficiency and stability. The balance between the generation and consumption of volatile fatty acids (VFAs) in the anaerobic digestion process is the key to stable AD operation. However, the accumulation of VFAs frequently occurs, especially propionate, because its oxidation has the highest Gibbs free energy when compared to other VFAs. In order to solve this problem, some strategies, including buffering addition, suspension of feeding, decreased organic loading rate, and so on, have been proposed. Emerging methods, such as bioaugmentation, supplementary trace elements, the addition of electronic receptors, conductive materials, and the degasification of dissolved hydrogen, have been recently researched, presenting promising results. But the efficacy of these methods still requires further studies and tests regarding full-scale application. The main objective of this paper is to provide a comprehensive review of the mechanisms of propionate generation, the metabolic pathways and the influencing factors during the AD process, and the recent literature regarding the experimental research related to the efficacy of various strategies for enhancing propionate biodegradation. In addition, the issues that must be addressed in the future and the focus of future research are identified, and the potential directions for future development are predicted.
Collapse
Affiliation(s)
- Lan Mu
- School of Mechanical Engineering, Tianjin University of Commerce, Tianjin 300134, China; (L.M.)
| | - Yifan Wang
- School of Biotechnology and Food Science, Tianjin University of Commerce, Tianjin 300134, China
| | - Fenglian Xu
- School of Biotechnology and Food Science, Tianjin University of Commerce, Tianjin 300134, China
| | - Jinhe Li
- Tianjin Capital Environmental Protection Group Co., Ltd., Tianjin 300133, China
| | - Junyu Tao
- School of Mechanical Engineering, Tianjin University of Commerce, Tianjin 300134, China; (L.M.)
| | - Yunan Sun
- School of Mechanical Engineering, Tianjin University of Commerce, Tianjin 300134, China; (L.M.)
| | - Yingjin Song
- School of Environmental Science and Engineering, Tianjin University, Tianjin 300072, China;
| | - Zhaodan Duan
- School of Mechanical Engineering, Tianjin University of Commerce, Tianjin 300134, China; (L.M.)
| | - Siyi Li
- School of Mechanical Engineering, Tianjin University of Commerce, Tianjin 300134, China; (L.M.)
| | - Guanyi Chen
- School of Mechanical Engineering, Tianjin University of Commerce, Tianjin 300134, China; (L.M.)
| |
Collapse
|
6
|
Duc LV, Nagao S, Mojarrad M, Miyagawa Y, Li ZY, Inoue D, Tajima T, Ike M. Bioaugmentation with marine sediment-derived microbial consortia in mesophilic anaerobic digestion for enhancing methane production under ammonium or salinity stress. BIORESOURCE TECHNOLOGY 2023; 376:128853. [PMID: 36898569 DOI: 10.1016/j.biortech.2023.128853] [Citation(s) in RCA: 3] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/20/2023] [Revised: 03/06/2023] [Accepted: 03/06/2023] [Indexed: 06/18/2023]
Abstract
Ammonium (NH4+) and salinity (NaCl) inhibit CH4 production in anaerobic digestion. However, whether bioaugmentation using marine sediment-derived microbial consortia can relieve the inhibitory effects of NH4+ and NaCl stresses on CH4 production remains unclear. Thus, this study evaluated the effectiveness of bioaugmentation using marine sediment-derived microbial consortia in alleviating the inhibition of CH4 production under NH4+ or NaCl stress and elucidated the underlying mechanisms. Batch anaerobic digestion experiments under 5 gNH4-N/L or 30 g/L NaCl were performed with or without augmentation using two marine sediment-derived microbial consortia pre-acclimated to high NH4+ and NaCl. Compared with non-bioaugmentation, bioaugmentation reinforced CH4 production. Network analysis revealed the joint effects of microbial connections by Methanoculleus, which promoted the efficient consumption of propionate accumulated under NH4+ and NaCl stresses. In conclusion, bioaugmentation with pre-acclimated marine sediment-derived microbial consortia can mitigate the inhibition under NH4+ or NaCl stress and enhance CH4 production in anaerobic digestion.
Collapse
Affiliation(s)
- Luong Van Duc
- Division of Sustainable Energy and Environmental Engineering, Osaka University, 2-1 Yamadaoka, Suita, Osaka 565-0871, Japan
| | - Shintaro Nagao
- Division of Sustainable Energy and Environmental Engineering, Osaka University, 2-1 Yamadaoka, Suita, Osaka 565-0871, Japan
| | - Mohammad Mojarrad
- Unit of Biotechnology, Graduate School of Integrated Sciences for Life, Hiroshima University, 1-3-1 Kagamiyama, Higashi-Hiroshima, Hiroshima 739-8530, Japan
| | - Yuta Miyagawa
- Division of Sustainable Energy and Environmental Engineering, Osaka University, 2-1 Yamadaoka, Suita, Osaka 565-0871, Japan
| | - Zi-Yan Li
- Division of Sustainable Energy and Environmental Engineering, Osaka University, 2-1 Yamadaoka, Suita, Osaka 565-0871, Japan
| | - Daisuke Inoue
- Division of Sustainable Energy and Environmental Engineering, Osaka University, 2-1 Yamadaoka, Suita, Osaka 565-0871, Japan
| | - Takahisa Tajima
- Unit of Biotechnology, Graduate School of Integrated Sciences for Life, Hiroshima University, 1-3-1 Kagamiyama, Higashi-Hiroshima, Hiroshima 739-8530, Japan
| | - Michihiko Ike
- Division of Sustainable Energy and Environmental Engineering, Osaka University, 2-1 Yamadaoka, Suita, Osaka 565-0871, Japan.
| |
Collapse
|
7
|
Wang G, Liu G, Yao G, Fu P, Sun C, Li Y, Li Q, Li YY, Chen R. Biochar-assisted anaerobic membrane bioreactor towards high-efficient energy recovery from swine wastewater: Performances and the potential mechanisms. BIORESOURCE TECHNOLOGY 2023; 369:128480. [PMID: 36513307 DOI: 10.1016/j.biortech.2022.128480] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/19/2022] [Revised: 12/07/2022] [Accepted: 12/08/2022] [Indexed: 06/17/2023]
Abstract
A high-efficient energy recovery system of biochar-assisted anaerobic membrane bioreactor (BC-AnMBR) was established for swine wastewater treatment. Comparing with a conventional AnMBR, biochar addition accelerated volatile fatty acids (VFA) degradation during start-up stage, thereby shortened start-up duration by 44.0 %. Under a high organic loading rate (OLR) of 21.1 gCOD/L/d, BC-AnMBR promoted COD removal efficiency from 90.1 % to 95.2 %, and maintained a high methane production rate of 4.8L CH4/L/d. The relative abundance of Methanosaeta declined from 53.9 % in conventional AnMBR to 21.0 % in BC-AnMBR, whereas that of Methanobrevibacter dramatically increased from 10.3 % to 70.9 %, respectively. Metabolic pathway analysis revealed that biochar not only strengthened hydrogenotrophic methanogenesis pathway, but also upregulated the genes encoding electron transfer carriers and riboflavin metabolism, suggesting the role of biochar facilitating direct interspecies electron transfer for syntrophic methanogenesis. The excellent energy yield performances under high OLR confirmed BC-AnMBR as an advanced system for high-strength swine wastewater treatment.
Collapse
Affiliation(s)
- Gaojun Wang
- Key Lab of Environmental Engineering (Shaanxi Province), School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, No.13 Yanta Road, Xi'an 710055, PR China; International S&T Cooperation Center for Urban Alternative Water Resources Development, Key Laboratory of Northwest Water Resource, Environment and Ecology (Ministry of Education), Xi'an University of Architecture and Technology, No.13 Yanta Road, Xi'an 710055, PR China
| | - Guohao Liu
- Key Lab of Environmental Engineering (Shaanxi Province), School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, No.13 Yanta Road, Xi'an 710055, PR China
| | - Gaofei Yao
- Key Lab of Environmental Engineering (Shaanxi Province), School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, No.13 Yanta Road, Xi'an 710055, PR China
| | - Peng Fu
- Key Lab of Environmental Engineering (Shaanxi Province), School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, No.13 Yanta Road, Xi'an 710055, PR China
| | - Changxi Sun
- Key Lab of Environmental Engineering (Shaanxi Province), School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, No.13 Yanta Road, Xi'an 710055, PR China
| | - Yu Li
- Key Lab of Environmental Engineering (Shaanxi Province), School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, No.13 Yanta Road, Xi'an 710055, PR China
| | - Qian Li
- Key Lab of Environmental Engineering (Shaanxi Province), School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, No.13 Yanta Road, Xi'an 710055, PR China; International S&T Cooperation Center for Urban Alternative Water Resources Development, Key Laboratory of Northwest Water Resource, Environment and Ecology (Ministry of Education), Xi'an University of Architecture and Technology, No.13 Yanta Road, Xi'an 710055, PR China; Department of Civil and Environmental Engineering, Graduate School of Engineering, Tohoku University, 6-6-06 Aza-Aoba, Aramaki, Aoba-ku, Sendai, Miyagi 980-8579, Japan
| | - Yu-You Li
- Department of Civil and Environmental Engineering, Graduate School of Engineering, Tohoku University, 6-6-06 Aza-Aoba, Aramaki, Aoba-ku, Sendai, Miyagi 980-8579, Japan
| | - Rong Chen
- Key Lab of Environmental Engineering (Shaanxi Province), School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, No.13 Yanta Road, Xi'an 710055, PR China; International S&T Cooperation Center for Urban Alternative Water Resources Development, Key Laboratory of Northwest Water Resource, Environment and Ecology (Ministry of Education), Xi'an University of Architecture and Technology, No.13 Yanta Road, Xi'an 710055, PR China.
| |
Collapse
|
8
|
Mercado JV, Koyama M, Nakasaki K. Complexity of acclimatization substrate affects anaerobic digester microbial community response to organic load shocks. ENVIRONMENTAL RESEARCH 2023; 216:114722. [PMID: 36343710 DOI: 10.1016/j.envres.2022.114722] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/21/2021] [Revised: 10/15/2022] [Accepted: 11/01/2022] [Indexed: 06/16/2023]
Abstract
This study elucidated the changes in the short-term response to organic load shocks of the anaerobic digestion (AD) microbiome acclimatized to a simple substrate and a complex substrate. Batch vial reactors were inoculated with AD sludge acclimatized to either a simple (starch and hipolypeptone) or a complex (dog food and starch) substrate, both with carbon-to-nitrogen ratio of 25. Organic loads in the form of an easily degradable substrate mix (starch and hipolypeptone) with concentrations varying from 0 to 5 g VS/L were applied to the reactors. Runs utilizing the inoculum acclimatized to a complex substrate sustained its methane productivity despite the high organic load shocks which the inoculum acclimatized to a simple substrate was unable to handle efficiently. The alpha-diversity of the microbiome decreased with increase in organic load for inoculum acclimatized with a simple substrate but was unaffected for the case of the inoculum acclimatized with a complex substrate. LactobacillalesandCloacimonadales were inferred to be major players in starch degradation pathways for the inoculum acclimatized using a simple substrate as predicted by the bioinformatics package PICRUSt2. However, acclimatizing using a complex substrate did not support their growth and were replaced by Coriobacteriales which provided higher flexibility in terms of the predicted regulated metabolic functions. The predicted functional regulation of Synergistales and Syntrophales increased with acclimatization using a complex substrate which also showed increase in the flexibility of the microbiome towards handling organic load shocks. Acetoclastic pathway was upregulated with increase in organic load regardless of the acclimatization substrate while the hydrogenotrophic pathway was downregulated. Overall, acclimatization using a complex substrate increased the robustness and flexibility of the microbiome towards organic load shocks.
Collapse
Affiliation(s)
- Jericho Victor Mercado
- School of Environment and Society, Tokyo Institute of Technology, 2-12-1 Ookayama, Meguro-ku, Tokyo 152-8550, Japan
| | - Mitsuhiko Koyama
- School of Environment and Society, Tokyo Institute of Technology, 2-12-1 Ookayama, Meguro-ku, Tokyo 152-8550, Japan.
| | - Kiyohiko Nakasaki
- School of Environment and Society, Tokyo Institute of Technology, 2-12-1 Ookayama, Meguro-ku, Tokyo 152-8550, Japan.
| |
Collapse
|
9
|
Blasco L, Kahala M, Ervasti S, Tampio E. Dynamics of microbial community in response to co-feedstock composition in anaerobic digestion. BIORESOURCE TECHNOLOGY 2022; 364:128039. [PMID: 36182013 DOI: 10.1016/j.biortech.2022.128039] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/12/2022] [Revised: 09/22/2022] [Accepted: 09/23/2022] [Indexed: 06/16/2023]
Abstract
To enable the utilization of seasonal biomasses in e.g., farm-scale biogas plants, the process should be flexible and ensure stable gas production. However, information about microbial community dynamics in long-term co-digestion with versatile co-feedstocks is lacking. This study investigated the effects of co-feedstock changes on the performance and evolution of microbial consortia during 428-day anaerobic digestion of cow slurry. Co-feedstocks consisted of hydrocarbon-, protein- and lipid-rich materials. A high throughput 16S ribosomal RNA gene sequencing was used to analyze the taxonomic profile of microbial communities. Due to the low loading rate, the changes were subtle in bacteria, but a shift on archaeal genera in response to different and changing feedstock compositions was observed. Despite drastic changes in co-feedstock composition, stable and flexible anaerobic digestion with relatively constant core microbiome can be achieved with cautious operation of the process.
Collapse
Affiliation(s)
- Lucia Blasco
- Natural Resources Institute Finland (Luke), Production Systems, Myllytie 1, FI-31600 Jokioinen, Finland.
| | - Minna Kahala
- Natural Resources Institute Finland (Luke), Production Systems, Myllytie 1, FI-31600 Jokioinen, Finland
| | - Satu Ervasti
- Natural Resources Institute Finland (Luke), Production Systems, Ounasjoentie 6, FI-96200 Rovaniemi, Finland
| | - Elina Tampio
- Natural Resources Institute Finland (Luke), Production Systems, Latokartanonkaari 9, FI-00790 Helsinki, Finland
| |
Collapse
|
10
|
Lee JTE, Lim EY, Zhang L, Tsui TH, Tian H, Yan M, Lim S, Abdul Majid MB, Jong MC, Zhang J, Wang CH, Ok YS, Tong YW. Methanosarcina thermophila bioaugmentation and its synergy with biochar growth support particles versus polypropylene microplastics in thermophilic food waste anaerobic digestion. BIORESOURCE TECHNOLOGY 2022; 360:127531. [PMID: 35764284 DOI: 10.1016/j.biortech.2022.127531] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/28/2022] [Revised: 06/22/2022] [Accepted: 06/23/2022] [Indexed: 06/15/2023]
Abstract
Both biochar supplementation as well as bioaugmentation have been shown in literature to improve the methane yield of anaerobic digestion. In this study, the combination of both are evaluated by growing Methanosarcina thermophila on biochar support particles prior to augmentation of thermophilic food waste anaerobic digestion. Biochar stand alone, bioaugmentation solely, a combination of both added separately or grown together, and utilizing polypropylene (PP) microplastics as growth support instead were all tested when starting up a thermophilic process from mesophilic inoculum. Methanosarcina thermophila and biochar supplementation displayed synergy, with 5% M. thermophila on 1 g/L biochar presenting a 32% increase in specific methane yield over the control. Double the bioaugmentation dosage/concentration was also trialled with a thermophilic inoculum, and 10% M. thermophila grown on 2 g/L biochar displayed the best results with a 20% increase specific methane yield from its control standard.
Collapse
Affiliation(s)
- Jonathan T E Lee
- Environmental Research Institute, National University of Singapore, Singapore; Energy and Environmental Sustainability for Megacities (E2S2) Phase II, Campus for Research Excellence and Technological Enterprise (CREATE), 1 Create Way, Singapore 138602, Singapore
| | - Ee Yang Lim
- Department of Chemical & Biomolecular Engineering, NUS, Singapore
| | - Le Zhang
- Environmental Research Institute, National University of Singapore, Singapore; Energy and Environmental Sustainability for Megacities (E2S2) Phase II, Campus for Research Excellence and Technological Enterprise (CREATE), 1 Create Way, Singapore 138602, Singapore
| | - To-Hung Tsui
- Environmental Research Institute, National University of Singapore, Singapore; Energy and Environmental Sustainability for Megacities (E2S2) Phase II, Campus for Research Excellence and Technological Enterprise (CREATE), 1 Create Way, Singapore 138602, Singapore
| | - Hailin Tian
- Key Laboratory for City Cluster Environmental Safety and Green Development of the Ministry of Education, School of Ecology, Environment and Resources, Guangdong University of Technology, Guangzhou 510006, China
| | - Miao Yan
- Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences, Guangzhou 510640, China
| | - Shuhan Lim
- Department of Chemical & Biomolecular Engineering, NUS, Singapore
| | | | - Mui-Choo Jong
- Environmental Research Institute, National University of Singapore, Singapore
| | - Jingxin Zhang
- China-UK Low Carbon College, Shanghai Jiao Tong University, Shanghai, China
| | - Chi-Hwa Wang
- Energy and Environmental Sustainability for Megacities (E2S2) Phase II, Campus for Research Excellence and Technological Enterprise (CREATE), 1 Create Way, Singapore 138602, Singapore; Department of Chemical & Biomolecular Engineering, NUS, Singapore
| | - Yong Sik Ok
- Korea Biochar Research Center, APRU Sustainable Waste Management & Division of Environmental Science and Ecological Engineering, Korea University, Seoul, 02841, South Korea
| | - Yen Wah Tong
- Energy and Environmental Sustainability for Megacities (E2S2) Phase II, Campus for Research Excellence and Technological Enterprise (CREATE), 1 Create Way, Singapore 138602, Singapore; Department of Chemical & Biomolecular Engineering, NUS, Singapore.
| |
Collapse
|
11
|
Mercado JV, Koyama M, Nakasaki K. Co-occurrence network analysis reveals loss of microbial interactions in anaerobic digester subjected to repeated organic load shocks. WATER RESEARCH 2022; 221:118754. [PMID: 35759844 DOI: 10.1016/j.watres.2022.118754] [Citation(s) in RCA: 7] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/28/2022] [Revised: 06/11/2022] [Accepted: 06/13/2022] [Indexed: 06/15/2023]
Abstract
Fluctuations in the anaerobic digestion (AD) organic loading rate (OLR) cause shocks to the AD microbiome, which lead to unstable methane productivity. Managing these fluctuations requires a larger digester, which is impractical for community-scale applications, limiting the potential of AD in advancing a circular economy. To allow operation of small-scale AD while managing OLR fluctuations, we need to tackle the issue through elucidation of the microbial community dynamics via 16S rRNA gene sequencing. This study elucidated the interrelation of the AD performance and the dynamics of the microbial interactions within its microbiome in response to repeated high OLR shocks at different frequencies. The OLR shocks were equivalent to 4 times the baseline OLR of 2 g VS/L/d. We found that less frequent organic load shocks result to deterioration of methane productivity. Co-occurrence network analysis shows that this coincides with the breakdown of the microbiome network structure. This suggests loss of microbial interactions necessary in maintaining stable AD. Identification of species influencing the network structure revealed that a species under the genus Anaerovorax has the greatest influence, while orders Spirochaetales and Synergistales represent the greatest number of the influential species. We inferred that the impact imposed by the OLR shocks shifted the microbiome activity towards biochemical pathways that are not contributing to methane production. Establishing a small-scale AD system that permits OLR fluctuations would require developing an AD microbiome resilient to infrequent organic loading shocks.
Collapse
Affiliation(s)
- Jericho Victor Mercado
- School of Environment and Society, Tokyo Institute of Technology, 2-12-1 Ookayama, Meguro-ku, Tokyo 152-8550, Japan
| | - Mitsuhiko Koyama
- School of Environment and Society, Tokyo Institute of Technology, 2-12-1 Ookayama, Meguro-ku, Tokyo 152-8550, Japan
| | - Kiyohiko Nakasaki
- School of Environment and Society, Tokyo Institute of Technology, 2-12-1 Ookayama, Meguro-ku, Tokyo 152-8550, Japan.
| |
Collapse
|
12
|
Kim D, Choi H, Yu H, Kim H, Baek G, Lee C. Potential treatment of aged cow manure using spare capacity in anaerobic digesters treating a mixture of food waste and pig manure. WASTE MANAGEMENT (NEW YORK, N.Y.) 2022; 148:22-32. [PMID: 35653950 DOI: 10.1016/j.wasman.2022.05.016] [Citation(s) in RCA: 4] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/11/2022] [Revised: 05/11/2022] [Accepted: 05/17/2022] [Indexed: 06/15/2023]
Abstract
With the increasing production of cow manure (CM) and the continuing decrease in the demand for manure compost, CM management has become an urgent and challenging task in Korea. In most cattle farms in Korea, CM mixed with bedding materials is left in pens exposed to the open air for several months before treatment, which makes CM an unsuitable feedstock for anaerobic digestion. This study examined the co-digestion of aged CM with a mixture of food waste and pig manure as the base substrate to assess the possibility of treating and valorizing CM using spare capacity in existing anaerobic digesters dealing with other wastes. The duplicate digesters initially fed with the base substrate were subjected to the addition of increasing amounts of CM (3-10% in the feed, w/v) over nine months. Co-feeding CM up to 5% in the feed (w/v) did not compromise the methanogenic degradation of the substrates, but adding more CM led to a significant performance deterioration likely related to the buildup of inhibitory free ammonia and H2S. Adding CM substantially influenced the digester microbial communities, especially methanogenic communities, and induced a dominance shift from aceticlastic Methanothrix to hydrogenotrophic methanogens as the CM fraction increased. The overall results suggest that the CM fraction should not exceed 5% in the feed (w/v) for its stable treatment with the base substrate in the experimental digesters. Although further studies are needed, anaerobic treatment using spare capacity in existing digesters can be a useful strategy for the management of aged CM.
Collapse
Affiliation(s)
- Danbee Kim
- School of Urban and Environmental Engineering, Ulsan National Institute of Science and Technology (UNIST), 50 UNIST-gil, Eonyang-eup, Ulju-gun, Ulsan 44919, Republic of Korea
| | - Hyungmin Choi
- School of Urban and Environmental Engineering, Ulsan National Institute of Science and Technology (UNIST), 50 UNIST-gil, Eonyang-eup, Ulju-gun, Ulsan 44919, Republic of Korea
| | - Hyeonjung Yu
- School of Urban and Environmental Engineering, Ulsan National Institute of Science and Technology (UNIST), 50 UNIST-gil, Eonyang-eup, Ulju-gun, Ulsan 44919, Republic of Korea
| | - Hanwoong Kim
- School of Urban and Environmental Engineering, Ulsan National Institute of Science and Technology (UNIST), 50 UNIST-gil, Eonyang-eup, Ulju-gun, Ulsan 44919, Republic of Korea
| | - Gahyun Baek
- Enrivonmental Research Group, Research Institute of Industrial Science and Technology (RIST), 67 Cheongam-ro, Nam-gu, Pohang-si, Gyeongsangbuk-do 37673, Republic of Korea
| | - Changsoo Lee
- School of Urban and Environmental Engineering, Ulsan National Institute of Science and Technology (UNIST), 50 UNIST-gil, Eonyang-eup, Ulju-gun, Ulsan 44919, Republic of Korea.
| |
Collapse
|
13
|
Shin SG, Kim SI, Hwang S. Startup of Demo-Scale Anaerobic Digestion Plant Treating Food Waste Leachate: Process Instability and Recovery. INTERNATIONAL JOURNAL OF ENVIRONMENTAL RESEARCH AND PUBLIC HEALTH 2022; 19:ijerph19116903. [PMID: 35682486 PMCID: PMC9180266 DOI: 10.3390/ijerph19116903] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 04/05/2022] [Revised: 06/01/2022] [Accepted: 06/02/2022] [Indexed: 02/05/2023]
Abstract
A demo-scale (600 m3 working volume) anaerobic digester treating food waste leachate was monitored during its startup period. The operation strategy was adjusted twice (i.e., three distinct phases) during the operation to recover the process from instability. During the first phase, the organic loading rate (OLR) > 2.7 kg chemical oxygen demand (COD)/m3∙day corresponded to volatile fatty acid (VFA) accumulation along with a decreasing pH, resulting in the drop in biogas yield to 0.43 ± 0.9 m3/kg CODin. During phase 2, fast recovery of this process was aimed at using a sequencing batch operation. One batch cycle (5 to 2 days) consisted of the combined drawing and feeding step (5 h), the reacting step (91 to 17 h), and the settling step (24 h). The duration of the reacting step was determined for each cycle such that (1) the biogas production ceased before the cycle end and (2) the residual VFA concentration was < 1 g/L. In total, 11 cycles were operated with a gradual increase in biogas yield to 0.55 m3/kg CODin with the absence of any sign of system disturbance. After phase 2, the digester was fed at the designed OLR of 4.1 ± 0.3 kg COD/m3∙day. The biogas yield was elevated to 0.58 ± 0.2 m3/kg CODin during phase 3 with the residual VFA concentration maintained at 2.2 ± 0.6 g/L. Methanogen populations, as determined by real-time PCR, did not change significantly throughout the period. These results imply that the adaptation of this process to the OLR of ca. 4 kg COD/m3∙day was not due to the increase in methanogen population but due to the elevation of its activity. Overall, this study suggests that the sequencing batch operation with adjustable cycle duration can be one successful recovery strategy for biogas plants under system instability.
Collapse
Affiliation(s)
- Seung Gu Shin
- Department of Energy Engineering, Future Convergence Technology Research Institute, Gyeongsang National University, 33 Dongjin-ro, Jinju 52828, Korea;
- Department of Energy System Engineering, Gyeongsang National University, 33 Dongjin-ro, Jinju 52828, Korea
| | - Su In Kim
- Division of Environmental Science and Engineering, Pohang University of Science and Technology, 77 Cheongam-ro, Pohang 37673, Korea;
| | - Seokhwan Hwang
- Division of Environmental Science and Engineering, Pohang University of Science and Technology, 77 Cheongam-ro, Pohang 37673, Korea;
- Institute for Convergence Research and Education in Advanced Technology (I-CREATE), Yonsei University, 85 Songdogwahak-ro, Yeonsu-gu, Incheon 21983, Korea
- Correspondence:
| |
Collapse
|
14
|
Mercado JV, Koyama M, Nakasaki K. Short-term changes in the anaerobic digestion microbiome and biochemical pathways with changes in organic load. THE SCIENCE OF THE TOTAL ENVIRONMENT 2022; 813:152585. [PMID: 34953835 DOI: 10.1016/j.scitotenv.2021.152585] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/23/2021] [Revised: 12/16/2021] [Accepted: 12/17/2021] [Indexed: 06/14/2023]
Abstract
Fluctuations in organic loading rate are frequently experienced in practical-scale anaerobic digestion systems. These impose shocks to the microbiome leading to process instability and failure. This study elucidated the short-term changes in biochemical pathways and the contributions of microbial groups involved in anaerobic digestion with varying organic load shocks. A mixture of starch and hipolypeptone corresponding to a carbon-to‑nitrogen ratio of 25 was used as substrate. Batch vial reactors were run using acclimatized sludge fed with organic load varying from 0 to 5 g VS/L. Methane yield decreased with increasing organic load. The microbiome alpha diversity represented as the number of operational taxonomic units (OTUs) and the Shannon index both decreased with organic load indicating microbiome specialization. The biochemical pathways predicted using PICRUSt2 were analyzed along with the corresponding contributions of microbial groups leading to a proposed pathway of substrate utilization. Genus Trichococcus (order Lactobacillales) increased in contribution to starch degradation pathways with increase in organic load while genus Macellibacteroides (order Bacteroidales) was prominent in contribution to bacterial anaerobic digestion pathways. Strictly acetoclastic Methanosaeta increased in prominence over hydrogenotrophic Methanolinea with increase in organic load. Results from this study provide better understanding of how anaerobic digesters respond to organic load shocks.
Collapse
Affiliation(s)
- Jericho Victor Mercado
- School of Environment and Society, Tokyo Institute of Technology, 2-12-1 Ookayama, Meguro-ku, Tokyo 152-8550, Japan
| | - Mitsuhiko Koyama
- School of Environment and Society, Tokyo Institute of Technology, 2-12-1 Ookayama, Meguro-ku, Tokyo 152-8550, Japan
| | - Kiyohiko Nakasaki
- School of Environment and Society, Tokyo Institute of Technology, 2-12-1 Ookayama, Meguro-ku, Tokyo 152-8550, Japan.
| |
Collapse
|