Enhanced degradation and biogas production of waste activated sludge by a high-solid anaerobic membrane bioreactor together with in pipe thermal pretreatment process

Enhanced digestion of sludge via co-digestion with food waste in a high-solid anaerobic membrane bioreactor: Performance evaluation and microbial response

A 15 L high-solid mesophilic AnMBR was operated for the digestion of food waste, primary sludge and excess sludge. The digestion performance was evaluated from the perspective of methane generation, permeate quality and organic reduction. Furthermore, the change in the microbial community was investigated by 16S rRNA gene analysis. The results showed that the introduction of sludge decreased the H2S levels in biogas compared with the mono-digestion of food waste and the co-digestion with food waste increased biogas and methane production compared with the mono-digestion of sludge. A substitution ratio of 25 % became a turning point of permeate composition and reaction rates. The energy recovery ratios of the mesophilic AnMBR were over 75 % based on stoichiometric analysis. In reaction kinetics analysis, hydrolysis as the first step of anaerobic digestion was found to be most influenced by the composition of the substrate. Finally, the microbial community structures were stable under tested conditions while the evolutionary relationships within the dominant phyla were observed. In the archaea community, Methanosaeta was the dominant methanogen regardless sludge ratio in the substrate.

Experimental study on the redistribution law of heavy metals in sludge disintegration

Aiming at the problems of large output of excess sludge, difficulty in treatment and disposal, and the potential toxicity of heavy metals restricting its resource utilization, this paper studies the redistribution law of heavy metals in the process of sludge disintegration. The dissertation investigates the distribution law of typical heavy metals such as Cu, Pb, Cd, Zn in the process of microwave and citric acid-microwave cracking sludge under different specific energy and fixed specific energy conditions. The Tessier five-step continuous extraction method was used to extract heavy metals, and the changes in their content and chemical forms were analyzed, which provided certain technical support for the subsequent harmless treatment and resource utilization of excess sludge. The main findings of this paper are as follows: The dissolution rate of heavy metals Cu, Pb, Cd, and Zn increased rapidly during the citric acid-microwave cracking process in the TS specific energy range of 0-45000 kJ/kg, and then gradually tended to be gradual. The maximum dissolution rates of Cu, Pb, Cd, Zn were 8.06%, 16.58%, 14.69%, and 24.11%, respectively. The concentrations of Cu, Pb, Cd, and Zn in the sludge were mainly F4; F3, F4; F2, F3. The proportions of stable states of Cu, Pb, Cd, and Zn in sludge increased to 88.6%, 55.91%, 35.7%, and 31.35%, respectively. When the specific energy was 45000 kJ/kg TS, the concentrations of Pb, Zn, and Cd in the solid phase of the sludge appeared to increase under microwave cracking alone and decrease under the combined action of citric acid and microwave. The concentration of Cu in the solid phase of the sludge increased slightly. The dissolution rates of Pb, Cd, and Zn by microwave alone and citric acid-microwave method were 14.23% and 16.58%, 10.34% and 14.69%, 17.53%, and 24.11%, respectively. The dissolution rates of Cu by both methods were lower. The steady state ratios of Pb and Zn in the citric acid-microwave method increased to 55.91% and 31.25%, respectively; the steady state ratio of Cd in the microwave alone method increased to 39.51%; both methods had no significant effect on the stability of Cu.

Dissimilatory manganese reduction facilitates synergistic cooperation of hydrolysis, acidogenesis, acetogenesis and methanogenesis via promoting microbial interaction during anaerobic digestion of waste activated sludge

Anaerobic digestion (AD) of waste activated sludge (WAS) is commonly limited to poor synergistic cooperation of four stages including hydrolysis, acidogenesis, acetogenesis and methanogenesis. Dissimilatory metal reduction that induced by metal-based conductive materials is promising strategy to regulate anaerobic metabolism with the higher metabolic driving force. In this study, MnO₂ as inducer of dissimilatory manganese reduction (DMnR) was added into WAS-feeding AD system for mediating complicated anaerobic metabolism. The results demonstrated that main operational performances including volatile solid (VS) degradation efficiency and cumulative CH₄ production with MnO₂ dosage of 60 mg/g·VS reached up to maximum 53.6 ± 3.4% and 248.2 ± 10.1 mL/g·VS while the lowest operational performances in control group (38.5 ± 2.8% and 183.5 ± 8.5 mL/g·VS) was originated from abnormal operation of four stages. Furthermore, high-throughput 16 S rRNA pyrosequencing revealed that enrichment of dissimilatory manganese-reducing contributors and methanogens such as Thermovirga, Christensenellaceae_R_7_group and Methanosaeta performed the crucial role in short-chain fatty acids (SCFAs) oxidation and final methanogenesis, which greatly optimized operational environment of hydrolysis, acidogenesis and acetogenesis. More importantly, analysis of functional genes expression proved that abundances of genes encoding enzymes participated in acetate oxidation, direct interspecies electron transfer (DIET) and CO₂ reduction pathway were simultaneously up-regulated with the optimum MnO₂ dosage, suggesting that DMnR with SCFAs oxidation as electron sink could benefit stable operation of four stages via triggering effective DIET-based microbial interaction mode.

Phase separated pretreatment strategies for enhanced waste activated sludge disintegration in anaerobic digestion: An outlook and recent trends

A significant ecological problem was developed on disposing the enormous amounts of waste activated sludge (WAS) produced by traditional wastewater treatment. There have been various attempts recently originated to develop innovative methods for substantial sludge treatment. The most frequently used approach for treating sludge to produces methane and reduces sludge is anaerobic treatment. The hydrolysis phase in WAS limits the breakdown of complex macrobiotic compounds. The presence of extracellular polymeric substances (EPS) in biomass prevents the substrate from being hydrolyzed. Enhancing substrate hydrolysis involves removal of EPS preceded by phase separated pretreatment. Hence, a critical assessment of various phase separated pretreatment that has a remarkable effect on the anaerobic digestion process was documented in detail. Moreover, the economic viability and energy requirement of this treatment process was also discussed. Perspectives and recommendations for methane production were also provided to attain effectual sludge management.

A review on upgrading of the anammox-based nitrogen removal processes: Performance, stability, and control strategies

The anaerobic ammonia oxidation (anammox) process is a promising biological nitrogen removal technology. However, owing to the sensitivity and slow cell growth of anammox bacteria, long startup time and initially low nitrogen removal rate (NRR) are still limiting factors of practical applications of anammox process. Moreover, nitrogen removal efficiency (NRE) is often lower than 88 %. This review summarizes the most common methods for improving NRR by increasing microorganism concentration, and modifying reactor configuration. Recent integrated anammox-based systems were evaluated, including hydroxyapatite (HAP)-enhanced one-stage partial nitritation/anammox (PNA) process for a high NRR of over 2 kg N/m3/d at 25 °C, partial denitrification/anammox (PDA) process, and simultaneous partial nitrification, anammox, and denitrification process for a high NRE of up to 100 %. After discussing the challenges for the application of these systems critically, a combined system of anaerobic digestion, HAP-enhanced one-stage PNA and PDA is proposed in order to achieve a high NRR, high NRE, and phosphorus removal simultaneously.