1
|
Foerster I, Seames W, Oleksik J, Kubatova A, Ross A. A Comprehensive Study of Techniques to Optimize the Extraction of Lipids from the Autotrophic Strain of the Microalgae Chlorella vulgaris. Life (Basel) 2023; 13:1997. [PMID: 37895378 PMCID: PMC10608289 DOI: 10.3390/life13101997] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/31/2023] [Revised: 09/14/2023] [Accepted: 09/27/2023] [Indexed: 10/29/2023] Open
Abstract
Microalgae represent a promising source of triglycerides and free fatty acids, synthesized in the form of lipids, for use in renewable fuels and chemicals. One challenge is the ability to efficiently recover the lipids from within the microalgae cell. Although various techniques have been studied individually, a comprehensive study of extraction techniques using consistent experimental and analytical methodology is missing. This study aims to provide this unifying comparison using the common microalgae strain Chlorella vulgaris. The factors that were surveyed and then optimized to achieve maximum extraction efficiency included the solvent type; mechanical pre-treatment using a ball mill at a variety of grinding speeds; microalgae-to-solvent ratio; extraction facilitated by microwave; extraction facilitated by sonication; extraction facilitated using increased temperature; and extraction facilitated by in situ transesterification to convert the lipids into esters prior to extraction. The optimum conditions determined during these studies were utilizing methanol as the solvent, with ball mill pretreatment at a grinding speed of 500 rpm, and a 1:9 microalgae to solvent ratio. When used in combination with microwave-assisted extraction at a temperature of 140 °C, approximately 24 wt% of the initial lipids were recovered. Recoveries of over 70 wt% were obtained without a microwave at extraction temperatures of over 200 °C.
Collapse
Affiliation(s)
- Ian Foerster
- Chemical Engineering Department, University of North Dakota, 243 Centennial Drive Stop 7101, Grand Forks, ND 58202, USA;
| | - Wayne Seames
- Chemical Engineering Department, University of North Dakota, 243 Centennial Drive Stop 7101, Grand Forks, ND 58202, USA;
| | - Jasmine Oleksik
- Energy & Environmental Research Center, University of North Dakota, 15 N. 23rd St., Grand Forks, ND 58202, USA;
| | - Alena Kubatova
- Chemistry Department, University of North Dakota, 151 Cornell Street Stop 9024, Grand Forks, ND 58202, USA;
| | - Andrew Ross
- School of Chemical and Process Engineering, University of Leeds, 209 Clarendon Road, Leeds LS2 9JT, UK;
| |
Collapse
|
2
|
Ghodousi-Dehnavi E, Arjmand M, Akbari Z, Aminzadeh M, Haji Hosseini R. Anti-Cancer Effect of Dorema Ammoniacum Gum by Targeting Metabolic Reprogramming by Regulating APC, P53, KRAS Gene Expression in HT-29 Human Colon Cancer Cells. Rep Biochem Mol Biol 2023; 12:127-135. [PMID: 37724146 PMCID: PMC10505474 DOI: 10.52547/rbmb.12.1.127] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/16/2023] [Accepted: 02/16/2023] [Indexed: 09/20/2023]
Abstract
Background Colorectal cancer is a heterogeneous disease that leads to metabolic disorders due to multiple upstream genetic and molecular changes and interactions. The development of new therapies, especially herbal medicines, has received much global attention. Dorema ammoniacum is a medicinal plant. Its gum is used in healing known ailments. Studying metabolome profiles based on nuclear magnetic resonance 1HNMR as a non-invasive and reproducible tool can identify metabolic changes as a reflection of intracellular fluxes, especially in drug responses. This study aimed to investigate the anti-cancer effects of different gum extracts on metabolic changes and their impact on gene expression in HT-29 cell. Methods Extraction of Dorema ammoniacum gum with hexane, chloroform, and dichloromethane organic solvents was performed. Cell inhibition growth percentage and IC50 were assessed. Following treating the cells with dichloromethane extract, p53, APC, and KRAS gene expression were determined. 1HNMR spectroscopy was conducted. Eventually, systems biology software tools interpreted combined metabolites and genes simultaneously. Results The lowest determined IC50 concentration was related to dichloromethane solvent, and the highest was hexane and chloroform. The expression of the KRAS oncogene gene decreased significantly after treatment with dichloromethane extract compared to the control group, and the expression of tumor suppressor gene p53 and APC increased significantly. Most gene-altered convergent metabolic phenotypes. Conclusion This study's results indicate that the dichloromethane solvent of Dorema ammoniacum gum exhibits its antitumor properties by altering the expression of genes involved in HT-29 cells and the consequent change in downstream metabolic reprogramming.
Collapse
Affiliation(s)
| | - Mohammad Arjmand
- Metabolomics Lab. Department of Biochemistry, Pasteur Institute of Iran, Pasteur Avenue, Tehran, Iran.
| | - Ziba Akbari
- Metabolomics Lab. Department of Biochemistry, Pasteur Institute of Iran, Pasteur Avenue, Tehran, Iran.
| | - Mansour Aminzadeh
- Metabolomics Lab. Department of Biochemistry, Pasteur Institute of Iran, Pasteur Avenue, Tehran, Iran.
| | - Reza Haji Hosseini
- Department of Biology, Faculty of Science, Payame Noor University, Tehran, Iran.
| |
Collapse
|
3
|
Mittal R, Ranade VV. Intensifying extraction of biomolecules from macroalgae using vortex based hydrodynamic cavitation device. ULTRASONICS SONOCHEMISTRY 2023; 94:106347. [PMID: 36870099 PMCID: PMC9996097 DOI: 10.1016/j.ultsonch.2023.106347] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 11/30/2022] [Revised: 02/11/2023] [Accepted: 02/24/2023] [Indexed: 06/18/2023]
Abstract
Macroalgae have a tremendous potential to become an important renewable resource for valuable biomolecules and chemicals. New and improved ways of cell disruption and of enhancing rate as well as yield of extraction of valuable products from macroalgae are needed to fully realise this potential. In this work, hydrodynamic cavitation (HC) was used for intensifying rate and yield of extraction of phycoerythrin, proteins and carbohydrates from marine macroalgae Palmaria palmata. We use vortex-based HC devices which do not use small restrictions like orifice-based HC devices or moving parts like rotor-stator based HC devices. A bench scale setup with a nominal slurry flow rate of 20 LPM was established. Dried and powdered macroalgae was used. Influence of key operating parameters like pressure drop and number of passes on extraction performance (the rate and yield) was measured. A simple, yet effective model was developed and used for interpreting and describing experimental data. The results indicate that there exists an optimum pressure drop across the device at which extraction performance is maximum. The extraction performance with HC was found to be significantly better than the stirred vessels. HC has resulted in 2 to 20 times improvement in the rate of extraction of phycoerythrin (R-PE), proteins and carbohydrates. Based on the results obtained in this work, pressure drop of 200 kPa and number of passes through the HC devices of about 100 were found to be most effective for HC-assisted intensified extraction from macroalgae. The presented results and model will be useful for harnessing vortex-based HC devices for intensifying the extraction of valuable products from macroalgae.
Collapse
Affiliation(s)
- Rochak Mittal
- Multiphase Flows, Reactors and Intensification Group, Bernal Institute, University of Limerick, Ireland
| | - Vivek V Ranade
- Multiphase Flows, Reactors and Intensification Group, Bernal Institute, University of Limerick, Ireland.
| |
Collapse
|
4
|
Dolganyuk V, Andreeva A, Sukhikh S, Kashirskikh E, Prosekov A, Ivanova S, Michaud P, Babich O. Study of the Physicochemical and Biological Properties of the Lipid Complex of Marine Microalgae Isolated from the Coastal Areas of the Eastern Water Area of the Baltic Sea. MOLECULES (BASEL, SWITZERLAND) 2022; 27:molecules27185871. [PMID: 36144605 PMCID: PMC9506268 DOI: 10.3390/molecules27185871] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 07/17/2022] [Revised: 08/31/2022] [Accepted: 09/07/2022] [Indexed: 11/17/2022]
Abstract
The Baltic Sea algae species composition includes marine euryhaline, freshwater euryhaline, and true brackish water forms. This study aimed to isolate a lipid–pigment complex from microalgae of the Baltic Sea (Kaliningrad region) and investigate its antimicrobial activity against Gram-positive and Gram-negative bacteria. Microalgae were sampled using a box-shaped bottom sampler. Sequencing was used for identification. Spectroscopy and chromatography with mass spectroscopy were used to study the properties of microalgae. Antibiotic activity was determined by the disc diffusion test. Lipids were extracted using the Folch method. Analysis of the results demonstrated the presence of antimicrobial activity of the lipid–pigment complex of microalgae against E. coli (the zone diameter was 17.0 ± 0.47 mm and 17.0 ± 0.21 mm in Chlorella vulgaris and Arthrospira platensis, respectively) and Bacillus pumilus (maximum inhibition diameter 16.0 ± 0.27 mm in C. vulgaris and 16.0 ± 0.22 mm in A. platensis). The cytotoxic and antioxidant activities of the lipid complexes of microalgae C. vulgaris and A. platensis were established and their physicochemical properties and fatty acid composition were studied. The results demonstrated that the lipid–pigment complex under experimental conditions was the most effective against P. pentosaceus among Gram-positive bacteria. Antimicrobial activity is directly related to the concentration of the lipid–pigment complex. The presence of antibacterial activity in microalgae lipid–pigment complexes opens the door to the development of alternative natural preparations for the prevention of microbial contamination of feed. Because of their biological activity, Baltic Sea microalgae can be used as an alternative to banned antibiotics in a variety of fields, including agriculture, medicine, cosmetology, and food preservation.
Collapse
Affiliation(s)
- Vyacheslav Dolganyuk
- SEC “Applied Biotechnologies”,, Immanuel Kant Baltic Federal University, A. Nevskogo Street 14, 236016 Kaliningrad, Russia
- Department of Bionanotechnology, Kemerovo State University, Krasnaya Street 6, 650043 Kemerovo, Russia
| | - Anna Andreeva
- SEC “Applied Biotechnologies”,, Immanuel Kant Baltic Federal University, A. Nevskogo Street 14, 236016 Kaliningrad, Russia
| | - Stanislav Sukhikh
- SEC “Applied Biotechnologies”,, Immanuel Kant Baltic Federal University, A. Nevskogo Street 14, 236016 Kaliningrad, Russia
| | - Egor Kashirskikh
- SEC “Applied Biotechnologies”,, Immanuel Kant Baltic Federal University, A. Nevskogo Street 14, 236016 Kaliningrad, Russia
| | - Alexander Prosekov
- Laboratory of Biocatalysis, Kemerovo State University, Krasnaya Street 6, 650043 Kemerovo, Russia
| | - Svetlana Ivanova
- Natural Nutraceutical Biotesting Laboratory, Kemerovo State University, Krasnaya Street 6, 650043 Kemerovo, Russia
- Department of General Mathematics and Informatics, Kemerovo State University, Krasnaya Street 6, 650043 Kemerovo, Russia
- Correspondence: (S.I.); (P.M.); Tel.: +7-384-239-6832 (S.I.); +33-473407425 (P.M.)
| | - Philippe Michaud
- Institut Pascal, Université Clermont Auvergne, CNRS, Clermont Auvergne INP, F-63000 Clermont-Ferrand, France
- Correspondence: (S.I.); (P.M.); Tel.: +7-384-239-6832 (S.I.); +33-473407425 (P.M.)
| | - Olga Babich
- SEC “Applied Biotechnologies”,, Immanuel Kant Baltic Federal University, A. Nevskogo Street 14, 236016 Kaliningrad, Russia
| |
Collapse
|
5
|
Bioconversion of the Brown Tunisian Seaweed Halopteris scoparia: Application to Energy. ENERGIES 2022. [DOI: 10.3390/en15124342] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 01/27/2023]
Abstract
The brown Tunisian seaweed Halopteris scoparia was used as a feedstock for producing renewable bioethanol, biogas, and biodiesel to demonstrate the proof of concept for the North African energy sector. A quantitative and qualitative quantification of H. scoparia composition using different colorimetric methods was completed to highlight its bioconversion potential. These substrate inputs were subjected to anaerobic fermentation by Saccharomyces cerevisiae to produce bioethanol. The materials were also used to generate bio-hydrogen and volatile fatty acids during dark fermentation by a bacterial consortium and using the oleaginous yeast Yarrowia lipolytica. The lipids were extracted and trans-esterified to Fatty Acid Methyl Esters (FAMEs), and their profiles were then analyzed with gas chromatography (GC). A significant ratio of the bioethanol, e.g., 0.35 g ethanol/g DW substrate, was produced without pretreatment, consistent with the theoretical Gay-Lussac yield. The production of the biohydrogen and lipids were up to 1.3 mL H2/g DW substrate and 0.04 g/g DW substrate, respectively, from the raw biomass. These results were higher than those reported for other well-studied seaweeds such as L. japonica. Overall, this work contributes to the current investigations in Tunisia for producing alternative energies from algae and finding new solutions to the current energy situation and environmental challenges in Maghreb.
Collapse
|
6
|
Vimali E, Gunaseelan S, Chitra Devi V, Mothil S, Arumugam M, Ashokkumar B, Ganesh Moorthy IM, Pugazhendhi A, Varalakshmi P. Comparative study of different catalysts mediated FAME conversion from macroalga Padina tetrastromatica biomass and hydrothermal liquefaction facilitated bio-oil production. CHEMOSPHERE 2022; 292:133485. [PMID: 34979211 DOI: 10.1016/j.chemosphere.2021.133485] [Citation(s) in RCA: 7] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/30/2021] [Revised: 12/15/2021] [Accepted: 12/29/2021] [Indexed: 06/14/2023]
Abstract
Marine macroalgae offer an endurable source of renewable biomass, which do not require cultivable area, fertilizers for cultivation for bioproducts production. In this study, marine brown macroalga Padina tetrastromatica as an alternate sustainable feedstock for the production of liquid fuels. Padina tetrastromatica biomass was collected from Mandapam; the coastal region of Rameswaram, Tamil Nadu, India. and the algal oil was extracted using sequential extractions using various solvents. Petroleum ether (PE) and dichloromethane (DCM) solvent fractions were found to have high lipids and further utilized for biodiesel production, wherein four different heterogeneous nanocatalysts (TiO2, Bio-Fe, GO, and MgO) and commercial homogeneous catalysts (HCl and NaOH) were employed for the transesterification. High fatty acid methyl ester (FAME) recovery (92.3%) was achieved from TiO2 mediated transesterification than the other conventional catalysts. Further, the conversion of algal biomass into bio-oil and by-products was carried out using hydrothermal liquefaction (HTL). Subsequently, the compounds were characterized by FT-IR and GC-MS analysis. The quality parameters of liquid biofuels were examined and they are in accordance with the international fuel standards. Thus, brown macroalga Padina tetrastromatica may be considered as an alternate feedstock for biofuel and other bioproducts production and TiO2 would be a suitable catalyst for the conversion of FAME.
Collapse
Affiliation(s)
- Elamathi Vimali
- Department of Molecular Microbiology, School of Biotechnology, Madurai Kamaraj University, Madurai, 625021, Tamil Nadu, India.
| | - Sathaiah Gunaseelan
- Department of Molecular Microbiology, School of Biotechnology, Madurai Kamaraj University, Madurai, 625021, Tamil Nadu, India.
| | - Venkatachalam Chitra Devi
- Department of Food Technology, Kongu Engineering College, Perundurai, Erode, 638060, Tamil Nadu, India
| | - Sengottian Mothil
- Department of Chemical Engineering, Kongu Engineering College, Perundurai, Erode, 638060, Tamil Nadu, India
| | - Muthu Arumugam
- Microbial Processes and Technology Division, CSIR-National Institute for Interdisciplinary Science and Technology (NIIST), Thiruvananthapuram, 695019, Kerala, India
| | - Balasubramaniem Ashokkumar
- Department of Genetic Engineering, School of Biotechnology, Madurai Kamaraj University, Madurai, 625021, Tamil Nadu, India
| | - Innasi Muthu Ganesh Moorthy
- Department of Biotechnology, Kamaraj College of Engineering and Technology, Vellakulam, 625701, Tamil Nadu, India
| | - Arivalagan Pugazhendhi
- School of Renewable Energy, Maejo University, Chiang Mai, 50290, Thailand; College of Medical and Health Science, Asia University, Taichung, Taiwan.
| | - Perumal Varalakshmi
- Department of Molecular Microbiology, School of Biotechnology, Madurai Kamaraj University, Madurai, 625021, Tamil Nadu, India.
| |
Collapse
|
7
|
Selection of Indigenous Algal Species for Potential Biodiesel Production. JOURNAL OF PURE AND APPLIED MICROBIOLOGY 2021. [DOI: 10.22207/jpam.15.2.40] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/20/2022] Open
Abstract
Currently, India utilizes an enormous amount of fossil fuels and a major quantity of fossil fuels are imported from other countries. It’s a giant load on the Indian Economy. The burning of fossil fuels causes global warming. Carbon neutral, renewable fuels are essential for environmental protection and it’s economically sustainable for India. Biofuels attention day by day due to a rise in energy demands and environmental concerns. Biodiesel produced from algal oil a possible renewable and carbon-neutral substitute to fossil fuels. The feasibility of the algal-based biodiesel industry depends on the selection of adequate species regarding commercial oil yields and oil quality. Present research work to bioprospecting and screening of 19 algal and blue-green algal species, the oil percentage and the fatty acid profiles, used for analyzing the biodiesel fuel properties. Oil from Tolypothrix phyllophila algal strain and compared it with another eighteen algal and blue-green algal strains from different literature. Tolypothrix phyllophila algal strain contains approximately 12.6% lipid on a dry weight basis. We also compared the FAME profile of 19 algal and blue-green algal strains and calculated and compared the fuel properties such as cetane number, Iodine Value, etc. of the biodiesel derived from these algal and blue-green algal oils based on chain length and saturation. We also investigated the 19 algal and blue-green algal fatty acid profiles and its suitability for biodiesel production and strains selection through PROMETHEE (Preference Ranking Organization Method for Enrichment Evaluations) and GAIA (geometrical analysis for interactive aid) analysis.
Collapse
|
8
|
Karpagam R, Jawaharraj K, Gnanam R. Review on integrated biofuel production from microalgal biomass through the outset of transesterification route: a cascade approach for sustainable bioenergy. THE SCIENCE OF THE TOTAL ENVIRONMENT 2021; 766:144236. [PMID: 33422843 DOI: 10.1016/j.scitotenv.2020.144236] [Citation(s) in RCA: 17] [Impact Index Per Article: 5.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/21/2020] [Revised: 11/10/2020] [Accepted: 11/24/2020] [Indexed: 06/12/2023]
Abstract
In recent years, microalgal feedstocks have gained immense potential for sustainable biofuel production. Thermochemical, biochemical conversions and transesterification processes are employed for biofuel production. Especially, the transesterification process of lipid molecules to fatty acid alkyl esters (FAAE) is being widely employed for biodiesel production. In the case of the extractive transesterification process, biodiesel is produced from the extracted microalgal oil. Whereas In-situ (reactive) transesterification allows the direct conversion of microalgae to biodiesel avoiding the sequential steps, which subsequently reduces the production cost. Though microalgae have the highest potential to be an alternate renewable feedstock, the minimization of biofuel production cost is still a challenge. The biorefinery approaches that rely on simple cascade processes involving cost-effective technologies are the need of an hour for sustainable bioenergy production using microalgae. At the same time, combining the biorefineries for both (i) high value-low volume (food and health supplements) and (ii) low value- high volume (waste remediation, bioenergy) from microalgae involves regulatory and technical problems. Waste-remediation and algal biorefinery were extensively reviewed in many previous reports. On the other hand, this review focuses on the cascade processes for efficient utilization of microalgae for integrated bioenergy production through the transesterification. Microalgal biomass remnants after the transesterification process, comprising carbohydrates as a major component (process flow A) or the carbohydrate fraction after bio-separation of pretreated microalgae (process flow B) can be utilized for bioethanol production. Therefore, this review concentrates on the cascade flow of integrated bioprocessing methods for biodiesel and bioethanol production through the transesterification and biochemical routes. The review also sheds light on the recent combinatorial approaches of transesterification of microalgae. The applicability of spent microalgal biomass residue for biogas and other applications to bring about zero-waste residue are discussed. Furthermore, techno-economic analysis (TEA), life cycle assessment (LCA) and challenges of microalgal biorefineries are discussed.
Collapse
Affiliation(s)
- Rathinasamy Karpagam
- Department of Plant Biotechnology, Centre for Plant Molecular Biology and Biotechnology (CPMB & B), Tamil Nadu Agricultural University, Coimbatore 641003, Tamil Nadu, India.
| | - Kalimuthu Jawaharraj
- Department of Civil and Environmental Engineering, South Dakota Mines, Rapid City 57701, SD, United States
| | - Ramasamy Gnanam
- Department of Plant Molecular Biology and Bioinformatics, Centre for Plant Molecular Biology and Biotechnology (CPMB & B), Tamil Nadu Agricultural University, Coimbatore 641003, Tamil Nadu, India
| |
Collapse
|
9
|
Padhan B, Poddar K, Sarkar D, Sarkar A. Production, purification, and process optimization of intracellular pigment from novel psychrotolerant Paenibacillus sp. BPW19. ACTA ACUST UNITED AC 2021; 29:e00592. [PMID: 33537212 PMCID: PMC7840853 DOI: 10.1016/j.btre.2021.e00592] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/31/2020] [Revised: 12/16/2020] [Accepted: 01/10/2021] [Indexed: 01/01/2023]
Abstract
Pigment producing Paenibacillus sp. BPW19 was identified by phylogenetic analysis. Optimization of culture conditions for maximum biomass production. Psychrotolerant property of Paenibacillus sp. BPW19 was evaluated. Erucic acid occurred as major component in the extracted intracellular pigment.
A pink pigment-producing bacterial strain was isolated from wastewater and identified as Paenibacillus sp. BPW19. The motile bacterial strain was Gram-positive, acid fermenting, glucose, sucrose utilizing and rod-shaped with an average cell length of 1.55 μm as studied under the Environmental Scanning Electron Microscope. Even though being psychrotolerant, the cell growth condition of BPW19 was optimized as 25 ºC along with pH 8, and 2.25% inoculum concentration considering the operational ease of the production. Sonication assisted solvent extraction produced 5.41% crude pigment which showed zones of exclusion against gram-negative strains Escherichia coli DH5α, Enterobacter sp. EtK3, and Klebsiella sp. SHC1. Gas Chromatography-Mass Spectrometry analysis of the crude pigment exhibited the dominant presence of major compounds as dotriacontane; 3,7 dimethyl 7 octanal; 1-eicosene and erucic acid. While column chromatography (ethanol:chloroform in 1:4 (v/v) ratio) purified pigment was identified as erucic acid using Nuclear Magnetic Resonance with a net yield of 3.06%.
Collapse
Affiliation(s)
- Bhagyashree Padhan
- Department of Biotechnology and Medical Engineering, National Institute of Technology Rourkela, Odisha, 769008, India
| | - Kasturi Poddar
- Department of Biotechnology and Medical Engineering, National Institute of Technology Rourkela, Odisha, 769008, India
| | - Debapriya Sarkar
- Department of Biotechnology and Medical Engineering, National Institute of Technology Rourkela, Odisha, 769008, India
| | - Angana Sarkar
- Department of Biotechnology and Medical Engineering, National Institute of Technology Rourkela, Odisha, 769008, India
| |
Collapse
|
10
|
Current Pretreatment/Cell Disruption and Extraction Methods Used to Improve Intracellular Lipid Recovery from Oleaginous Yeasts. Microorganisms 2021; 9:microorganisms9020251. [PMID: 33513696 PMCID: PMC7910848 DOI: 10.3390/microorganisms9020251] [Citation(s) in RCA: 10] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/30/2020] [Revised: 11/23/2020] [Accepted: 12/10/2020] [Indexed: 12/18/2022] Open
Abstract
The production of lipids from oleaginous yeasts involves several stages starting from cultivation and lipid accumulation, biomass harvesting and finally lipids extraction. However, the complex and relatively resistant cell wall of yeasts limits the full recovery of intracellular lipids and usually solvent extraction is not sufficient to effectively extract the lipid bodies. A pretreatment or cell disruption method is hence a prerequisite prior to solvent extraction. In general, there are no recovery methods that are equally efficient for different species of oleaginous yeasts. Each method adopts different mechanisms to disrupt cells and extract the lipids, thus a systematic evaluation is essential before choosing a particular method. In this review, mechanical (bead mill, ultrasonication, homogenization and microwave) and nonmechanical (enzyme, acid, base digestions and osmotic shock) methods that are currently used for the disruption or permeabilization of oleaginous yeasts are discussed based on their principle, application and feasibility, including their effects on the lipid yield. The attempts of using conventional and “green” solvents to selectively extract lipids are compared. Other emerging methods such as automated pressurized liquid extraction, supercritical fluid extraction and simultaneous in situ lipid recovery using capturing agents are also reviewed to facilitate the choice of more effective lipid recovery methods.
Collapse
|
11
|
Macroalgae-A Sustainable Source of Chemical Compounds with Biological Activities. Nutrients 2020; 12:nu12103085. [PMID: 33050561 PMCID: PMC7601163 DOI: 10.3390/nu12103085] [Citation(s) in RCA: 65] [Impact Index Per Article: 16.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/17/2020] [Revised: 10/02/2020] [Accepted: 10/06/2020] [Indexed: 12/15/2022] Open
Abstract
Nowadays, one of the most important research directions that concerns the scientific world is to exploit the earth’s resources in a sustainable way. Considering the increasing interest in finding new sources of bioactive molecules and functional products, many research studies focused their interest on demonstrating the sustainability of exploiting marine macroalgal biomass as feedstock for wastewater treatment and natural fertilizer, conversion into green biofuels, active ingredients in pharmaceutical and nutraceutical products, or even for the production of functional ingredients and integration in the human food chain. The objective of the present paper was to provide an overview on the recent progress in the exploitation of different macroalgae species as a source of bioactive compounds, mainly emphasizing the latter published data regarding their potential bioactivities, health benefits, and industrial applications.
Collapse
|
12
|
Gorte O, Hollenbach R, Papachristou I, Steinweg C, Silve A, Frey W, Syldatk C, Ochsenreither K. Evaluation of Downstream Processing, Extraction, and Quantification Strategies for Single Cell Oil Produced by the Oleaginous Yeasts Saitozyma podzolica DSM 27192 and Apiotrichum porosum DSM 27194. Front Bioeng Biotechnol 2020; 8:355. [PMID: 32391350 PMCID: PMC7193083 DOI: 10.3389/fbioe.2020.00355] [Citation(s) in RCA: 13] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/12/2020] [Accepted: 03/31/2020] [Indexed: 12/14/2022] Open
Abstract
Single cell oil (SCO) produced by oleaginous yeasts is considered as a sustainable source for biodiesel and oleochemicals since its production does not compete with food or feed and high yields can be obtained from a wide variety of carbon sources, e.g., acetate or lignocellulose. Downstream processing is still costly preventing the broader application of SCO. Direct transesterification of freeze-dried biomass is widely used for analytical purposes and for biodiesel production but it is energy intensive and, therefore, expensive. Additionally, only fatty acid esters are produced limiting the subsequent applications. The harsh conditions applied during direct esterification might also damage high-value polyunsaturated fatty acids. Unfortunately, universal downstream strategies effective for all yeast species do not exist and methods have to be developed for each yeast species due to differences in cell wall composition. Therefore, the aim of this study was to evaluate three industrially relevant cell disruption methods combined with three extraction systems for the SCO extraction of two novel, unconventional oleaginous yeasts, Saitozyma podzolica DSM 27192 and Apiotrichum porosum DSM 27194, based on cell disruption efficiency, lipid yield, and oil quality. Bead milling (BM) and high pressure homogenization (HPH) were effective cell disruption methods in contrast to sonification. By combining HPH (95% cell disruption efficiency) with ethanol-hexane-extraction 46.9 ± 4.4% lipid/CDW of S. podzolica were obtained which was 2.7 times higher than with the least suitable combination (ultrasound + Folch). A. porosum was less affected by cell disruption attempts. Here, the highest disruption efficiency was 74% after BM and the most efficient lipid recovery method was direct acidic transesterification (27.2 ± 0.5% fatty acid methyl esters/CDW) after freeze drying. The study clearly indicates cell disruption is the decisive step for SCO extraction. At disruption efficiencies of >90%, lipids can be extracted at high yields, whereas at lower cell disruption efficiencies, considerable amounts of lipids will not be accessible for extraction regardless of the solvents used. Furthermore, it was shown that hexane-ethanol which is commonly used for extraction of algal lipids is also highly efficient for yeasts.
Collapse
Affiliation(s)
- Olga Gorte
- Institute of Process Engineering in Life Science 2: Technical Biology, Karlsruhe Institute of Technology, Karlsruhe, Germany
| | - Rebecca Hollenbach
- Institute of Process Engineering in Life Science 2: Technical Biology, Karlsruhe Institute of Technology, Karlsruhe, Germany
| | - Ioannis Papachristou
- Institute for Pulsed Power and Microwave Technology, Karlsruhe Institute of Technology, Karlsruhe, Germany
| | - Christian Steinweg
- Institute of Process Engineering in Life Science 3: Bioprocess Engineering, Karlsruhe Institute of Technology, Karlsruhe, Germany
| | - Aude Silve
- Institute for Pulsed Power and Microwave Technology, Karlsruhe Institute of Technology, Karlsruhe, Germany
| | - Wolfgang Frey
- Institute for Pulsed Power and Microwave Technology, Karlsruhe Institute of Technology, Karlsruhe, Germany
| | - Christoph Syldatk
- Institute of Process Engineering in Life Science 2: Technical Biology, Karlsruhe Institute of Technology, Karlsruhe, Germany
| | - Katrin Ochsenreither
- Institute of Process Engineering in Life Science 2: Technical Biology, Karlsruhe Institute of Technology, Karlsruhe, Germany
| |
Collapse
|
13
|
Temperate-zone cultivation of Oedogonium in municipal wastewater effluent to produce cellulose and oxygen. ACTA ACUST UNITED AC 2020; 47:251-262. [DOI: 10.1007/s10295-020-02260-0] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/09/2019] [Accepted: 01/09/2020] [Indexed: 01/13/2023]
Abstract
Abstract
Cultivation of the filamentous chlorophyte Oedogonium in municipal wastewater effluent is known to improve water quality and yield lipid- and protein-rich biomass for industrial applications. Chlorophyte celluloses, whose molecular organization and physical traits differ from those of plants, represent yet another valuable extractive, and algal oxygen production is of economic value in wastewater treatment. Consequently, we explored cellulose and oxygen production from Oedogonium biomass batch-cultivated in treated secondary municipal wastewater effluent. We compared biomass, cellulose, and oxygen production outside and within an adjacent greenhouse, under differing dissolved CO2 and pH conditions, and during temperate-zone seasonal change from summer through fall. Overall production did not differ within or outside the greenhouse, but outside production was higher in summer and lower in fall as air temperatures declined. Batch cultivation offered advantages, but high levels of mixing and CO2 were essential to maintain neutral pH for optimal algal growth and oxygen production.
Collapse
|