Long-term physico-chemical stability of standard parenteral nutritions for neonates

Capillary electrophoresis in parenteral nutrition control - validation of two analytical methods: Amino acids/glucose/glucose-1-phosphate and K/Na/Ca/Mg

OBJECTIVES

Production of parenteral nutrition bags (PNBs) involves many nutrients: complete control of the production process decreases the risk of error. This study aimed to develop and validate two analytical methods by capillary electrophoresis (CE) for simultaneous detection of: glucose, amino acids (Primene®) and glucose-1-phosphate (Phocytan®) (anionic method, AM) on one hand; and on the other hand potassium, sodium, calcium and magnesium (cationic method, CM).

METHODS

Methods were developed using capillary electrophoresis with diode array detection (CE-DAD) (CE 7100, Agilent), indirect photometric detection, 56 cm long capillary and two different buffers (pH=12.1 for AM and pH=3.2 for CM). These methods were validated according to guidelines from the Société Française des Sciences et Techniques Pharmaceutiques (SFSTP).Analytical parameters were optimised: temperature was regulated at 15°C and the current settled to - 15kV, for a 21 minute analysis time for AM. Conditions were settled to 25°C and 30kV for CM so the analysis time dropped to 7 minutes.Accuracy profiles were established and recovery rates (RR), Repeatability and Reproducibility Coefficient of Variation (respectively RaCV and RoCV) were calculated.Capability was also calculated for each nutrient and concentration range according to guidelines from the Evaluation and Research Group on Protection in a Controlled Atmosphere (GERPAC).

RESULTS

Methods were successfully validated with: RR between 99.2 and 101.9%, RaCV between 1.5 and 3.1%, and RoCV between 2.4 and 4.1% for AM, and RR between 97.5 and 102.7%, RaCV between 0.5 and 2.3%, and RoCV between 0.6 and 2.8% for CM.Accuracy profiles were established with 95% β probability, except for glucose-1-phosphate (90%). Acceptance limits were settled to ±1 0% of target value. Capabilities are defined as "good" or "very good".

CONCLUSIONS

The methods developed by this research will ensure the composition of PNB is compliant to PNB formulas. These results show CE is an appropriate method for PNB quantitative control.CE utilisation for controlling other hospital preparations seems to be a relevant alternative to conventional methods such as liquid chromatography.

[Review of parenteral nutrition practices in four university hospital's pharmacies in Auvergne-Rhône-Alpes region]

OBJECTIVES

To carry out an assessment of parenteral nutrition (PN) practices in hospital pharmacies of the Auvergne-Rhône-Alpes region in order to explore a harmonisation of practices and a collaboration between the different centres.

METHODS

Status of practices was carried out on the basis of an observational study inspired by the survey of the General Inspectorate of Social Affairs. It was carried out in Auvergne-Rhône-Alpes region in four university hospital pharmacies with a production unit of PN. It focused on the different stages of the PN process: prescription, formulation, compounding and quality control. It also covered the support processes such as the quality assurance system and the management of premises and equipment.

RESULTS

Most preparations made in the region are individualized parenteral nutritional admixtures for paediatric and neonatal hospitalization departments. The production units of PN of each centre are located in premises in compliance with Good Preparation Practices. However, compounding equipment and raw materials used are heterogeneous in the four centres. All centres control the quality of their finished preparations. But, the performance of analytical control is disparate in terms of equipment and specifications.

CONCLUSION

This assessment explains the similarities and differences in PN practices between various university hospitals in the Auvergne-Rhône-Alpes region and thus makes possible to provide a collective regional work to harmonise practices.

Stability of lipid emulsion in total parenteral nutrition: An overview of literature

BACKGOUND AND AIMS

Total parenteral nutrition (TPN) is an extremely complex mixture. The multitude of chemical compounds involved can give rise to numerous reactions that condition its stability. We set out to review the existing literature on different issues related to stability, and which are still of concern in the hospital environment; such as the stability of the lipid emulsion. In addition, we analyse other related factors and parameters that allow us to predict the stability of TPN based on the composition.

MATERIAL AND METHODS

we searched PubMed and Google Scholar, over the date range 1995-2019 for relevant studies about TPN stability. We included experimental studies where the physical stability of the lipid emulsion in TPN had been analysed. We applied specific exclusion criteria.

RESULTS

we included 20 papers in this review of TPN stability. The studies combined different analytical techniques to assess the stability. In all the studies, the mean droplet diameter (MDD) is measured and the stability analysis is completed with other measurements. Temperature and components concentration are also considered.

CONCLUSIONS

studies on the stability of TPN used differing components with different chemical characteristics and their results can be difficult to extrapolate. There is no clear consensus about the composition of the mixtures and there is also great variety in the analytical techniques that were used to analyse stability. It is necessary to conduct new studies to update information on TPN stability.

Nanomedicine: a new paradigm to overcome drug incompatibilities

OBJECTIVES

Drug incompatibilities may compromise the safety and effectiveness of combined drugs and result in mild-to-serious clinical complications, such as catheter obstruction, loss of drug efficacy, formation of toxic derivatives and embolism. Various preventive strategies have been implemented to overcome drug incompatibilities with limited success. This review presents an innovative approach to prevent drug incompatibilities via isolating the incompatible drugs into nanostructures.

KEY FINDINGS

Several examples of incompatible drugs may be loaded separately into nanostructures of various types. Physicochemical characteristics and biocompatibility of the nanomaterials that are being utilized to prevent physicochemical incompatibilities should be carefully considered.

CONCLUSIONS

There is a new era of exploiting nanomaterials in overcoming various types of physicochemical incompatibilities, with additional benefits of further improvements in pharmacokinetic profiles and pharmacological actions of the administered drugs.

The effect of UV-protected ethylene vinyl acetate (EVA) bags on the physicochemical stability of pediatric parenteral nutrition admixtures

BACKGROUND

The safe administration of parenteral admixtures should be considered under the headings of physical and chemical stability. Vitamins are considered to be most susceptible to chemical degradation.

OBJECTIVES

To evaluate the protective effect of UV-protected monolayer ethylene vinyl acetate (EVA) bags in comparison with that of EVA bags without UV protection, on the physicochemical characteristics and stability of the light sensitive vitamins in pediatric parenteral admixtures stored under various temperature and light conditions.

METHODS

Four different parenteral pediatric admixtures (with trace elements and vitamins) in two types of ethylenovinylacetate (EVA) monolayer containers (with - yellow one and without - transparent one UV protection) were assessed. The physicochemical analyses such as visual inspection, pH and potential zeta measurements, lipid globules size distribution and vitamins concentration were performed at 0 h, 24 h, 8 days and 8 days+24 h after the preparation of the TPN admixtures. In order to quantify ascorbic acid, thiamine and pyridoxine levels, HPLC was used.

RESULTS

No differences (p < 0.05) in physicochemical stability of TPN admixtures were noted between two types of EVA bags, with the compositions assessed; stored 8 days (4 °C ± 2) without light plus 24 h at room temperature and light exposure. However significant differences were noticed in ascorbic acid, thiamine and pyridoxine content after 8 days+24 h in comparison with t = 0. This was noted for both for UV-protected bags and bags without UV-protection, Nevertheless, amounts were still within the pharmacopeial range.

CONCLUSIONS

Both EVA bags under test (with and without UV-protection) ensure physicochemical stability up 8 days at 4 °C ± 2 °C without light exposure and then 24 h at room temperature with light exposure for the total pediatric parenteral admixtures, intended for home parenteral nutrition. Graphical abstract Scheme of physicochemical analysis of parenteral admixtures.

A new alternative for intravenous lipid emulsion 20% w/w from superolein oil and its effect on lipid and liver profiles in an animal model

PURPOSE

Intravenous lipid emulsion (IVLE) was first used to prevent essential fatty acids deficiency. IVLE with α-tocopherol was reported to provide protection against parenteral nutrition-associated liver disease. This study aims to determine the optimal parameters and conditions in developing a physically stable IVLE from superolein palm oil (SoLE 20%) and its effect on lipid and liver profiles in an animal model.

METHODS

SoLE 20% was prepared using superolein oil and MCT oil (1:1), stabilized with egg lecithin and homogenized using a high pressure homogenizer. Mean droplet size was used as the response variable and was measured using laser diffraction and dynamic light scattering method. Physical stability at 4 °C, 25 °C and 40 °C storage temperatures were determined based on particle size and distribution, polydispersity index, zeta potential, viscosity, vitamin E contents and pH. Sterility and pyrogenicity were also investigated. Rabbits were administered with 1.0 g/kg SoLE 20% for 5 h and repeated daily for 3 days to investigate its effect on blood lipid and liver enzymes profile.

RESULTS

SoLE 20% was succesfully prepared using the optimized parameters of 800 psi, 7 cycles and 1.2 g lecithin. The IVLE prepared had a particle size of 252.60 ± 4.88 nm and was physically stable for 4 weeks at different storage temperatures. SoLE 20% had a high content of natural vitamin E, remained sterile and pyrogen free. It was also safe for intravenous administration and did not alter the blood lipid (p > 0.05) and liver enzymes profiles (p > 0.05) of the rabbits.

CONCLUSION

The optimal parameters to develop a stable superolein based IVLE are 800 psi homogenization pressure, 7 homogenization cycles and using 1.2 g lecithin as the emulsifier. SoLE 20% is safe for intravenous administration and does not significantly alter lipid and liver enzymes profiles of the rabbits.

Production and stability study of a hospital parenteral nutrition solution for neonates

Standard parenteral nutrition solutions are mixtures comprising interacting components that may degrade themselves over time. The objective of this study was to investigate the physicochemical and microbiological stability of a hospital preparation for parenteral nutrition in neonatology. The analyses were performed throughout the storage of the preparations at 2-8 °C (up to 4 months). The extent of stability was based on the determination of amino acids dosage, visual and physicochemical properties (glucose and electrolytes concentrations, pH and osmolality measurements, particle counting) and microbiological analysis (sterility test). A thermal degradation of ascorbic acid was conducted to evaluate the antioxidant properties of the parenteral mixture. Physicochemical and microbiological controls were found to comply with the specifications. Amino acids showed a good stability throughout the 4months storage except for cysteine, which was progressively degraded to cystine, conferring a yellow coloration to parenteral solutions. Parenteral nutrition standards solutions remain stable for 4 months at 2-8 °C, ensuring safe administration in preterm infants.

Development of a Stability Indicating Method for Simultaneous Analysis of Five Water-Soluble Vitamins by Liquid Chromatography

Background

Water-soluble vitamins are often included simultaneously in pharmaceutical formulations as food complements or in parenteral nutrition mixtures. Given their sensitivity to heat, light or pH variations, it is important to study their stability using validated stability indicating methods. We thus aimed to validate a liquid chromatography (LC) stability-indicating method for the simultaneous quantification of 5 water-soluble vitamins.

Methods

We analyzed four water-soluble B vitamins (nicotinamide, pyridoxine, folic acid, cyanocobalamin) and ascorbic acid using a LC method with diode array detector. They were separated on a C18 stationary phase under gradient elution of solvent A [0.2 % of metaphosphoric acid in water and acetonitrile 98:2] and solvent B (100 % acetonitrile). All vitamins were subjected to forced degradation conditions and we showed that the obtained degradation products didn’t interfere with the vitamins.

Results

The method allows the separation of the 5 water-soluble vitamins in a 30 minute run without any interference from the breakdown products obtained with acid/alkaline solutions, hydrogen peroxide, temperature and light. It meets all the qualitative and quantitative criteria for validation with an acceptable accuracy and good linearity.

Conclusions

This stability-indicating method can be used for carrying out stability studies of water-soluble vitamins in pharmaceutical preparations.

Physicochemical stable standard all-in-one parenteral nutrition admixtures for infants and children in accordance with the ESPGHAN/ESPEN guidelines

OBJECTIVE

Because there are almost no standard all-in-one parenteral nutrition admixtures available for infants and children, the aim was to develop standard two-compartment parenteral nutrition bags for different weight categories based on the ESPGHAN/ESPEN (European Society of Paediatric Gastroenterology, Hepatology and Nutrition/European Society for Clinical Nutrition and Metabolism) guidelines. The 1 g/kg/d lipid version for the 3 to 10 kg weight category (PED1) was assessed for short- and long-term physicochemical stability with the ability to add additional electrolytes (PED1+E).

METHODS

The lipid compartment A and the all-in-one admixture of A + B + vitamins + trace elements were assessed physically by visual inspection, Sudan red test, pH measurement, and lipid droplet size distribution. Chemical stability for compartment A was evaluated by quantitative analyses of non-esterified fatty acids and peroxide content. The glucose-amino acid-electrolyte compartment B was evaluated physically by visual inspection, measuring particle contamination and pH. Chemical stability was assessed by discoloration, quantitative analyses of glucose, and the amino acids L-cysteine, L-tyrosine, and L-tryptophan.

RESULTS

No phase separation or coalescence occurred, and the mean droplet size diameter did not exceed 0.5 µm. Peroxide content and non-esterified fatty acids concentration of compartment A remained well below the limit of acceptation. No precipitation was detected for compartment B; only a slight yellow discoloration was noted at 80 d. Concentrations of glucose, L-tyrosine, and L-tryptophan remained stable; only L-cysteine decreased significantly from its initial concentration.

CONCLUSION

The two-compartment PED1 and PED1+E admixtures are stable up to 80 d 2° to 8°C + 24 h room temperature (RT) with an additional 7 d 2° to 8°C + 48 h RT after mixing and addition of vitamins and trace elements.

Stability of hydrophilic vitamins mixtures in the presence of electrolytes and trace elements for parenteral nutrition: a nuclear magnetic resonance spectroscopy investigation

In total parenteral nutrition (TPN), especially in the case of preterm infants, simultaneous administration of vitamins and trace elements is still a problematic issue: guidelines put in evidence the lack of specific documentation. In this work NMR spectroscopy was applied to the study of vitamins (pyridoxine hydrochloride, thiamine nitrate, riboflavin-5'-phosphate and nicotinamide) stability in presence of salts and trace elements. Vitamins in D2O were first analyzed by (1)H NMR spectroscopy in absence of salts and trace elements; changes in chemical shifts or in diffusion coefficients, measured by NMR DOSY technique, were analyzed. The effects of salts and trace elements on single vitamins and on their admixtures were then investigated by performing quantitative analyses during 48h. Selected vitamins are subject to intermolecular interactions. No degradative effects were observed in presence of salts and trace elements. Only riboflavin-5'-phosphate is subject to precipitation in presence of divalent cations; however, at low concentration and in presence of other vitamins this effect was not observed. Solutions analyzed, in the condition of this study, are stable for at least 48h and vitamins and trace elements can be administered together in TPN.

Standardised neonatal parenteral nutrition formulations - an Australasian group consensus 2012

Standardised parenteral nutrition formulations are routinely used in the neonatal intensive care units in Australia and New Zealand. In 2010, a multidisciplinary group was formed to achieve a consensus on the formulations acceptable to majority of the neonatal intensive care units. Literature review was undertaken for each nutrient and recommendations were developed in a series of meetings held between November 2010 and April 2011. Three standard and 2 optional amino acid/dextrose formulations and one lipid emulsion were agreed by majority participants in the consensus. This has a potential to standardise neonatal parenteral nutrition guidelines, reduce costs and prescription errors.

Pharmaceutical point of view on parenteral nutrition

Parenteral nutrition--a form of administering nutrients, electrolytes, trace elements, vitamins, and water--is a widely used mode of therapy applied in many diseases, in patients of different ages both at home and in hospital. The success of nutritional therapy depends chiefly on proper determination of the patient's energetic and electrolytic needs as well as preparation and administration of a safe nutritional mixture. As a parenterally administered drug, it is expected to be microbiologically and physicochemically stable, with all of the components compatible with each other. It is very difficult to obtain a stable nutritional mixture due to the fact that it is a complex, two-phase drug. Also, the risk of incompatibility between mixture components and packaging should be taken into consideration and possibly eliminated. Since parenteral nutrition is a part of therapy, simultaneous use of drugs may cause pharmacokinetic and pharmacodynamic interactions as well as those with the pharmaceutical phase. The aim of this paper is to discuss such aspects of parenteral nutrition as mixture stability, methodology, and methods for determining the stability of nutritional mixtures and drugs added to them.

Probability-based compatibility curves for calcium and phosphates in parenteral nutrition formulations

BACKGROUND

The information content of the calcium phosphate compatibility curves for adult parenteral nutrition (PN) solutions may benefit from a more sophisticated statistical treatment. Binary logistic regression analyses were evaluated as part of an alternate method for generating formulation compatibility curves.

MATERIALS AND METHODS

A commercial PN solution was challenged with a systematic array of calcium and phosphate concentrations. These formulations were then characterized for particulates by visual inspection, light obscuration, and filtration followed by optical microscopy. Logistic regression analyses of the data were compared with traditional treatments for generating compatibility curves.

RESULTS

Assay-dependent differences were observed in the compatibility curves and associated probability contours; the microscopic method of precipitate detection generated the most robust results. Calcium and phosphate compatibility data generated from small-volume glass containers reasonably predicted the observed compatibility of clinically relevant flexible containers.

CONCLUSIONS

The published methods for creating calcium and phosphate compatibility curves via connecting the highest passing or lowest failing calcium concentrations should be augmented or replaced by probability contours of the entire experimental design to determine zones of formulation incompatibilities. We recommend researchers evaluate their data with logistic regression analysis to help build a more comprehensive probabilistic database of compatibility information.

Particle condition change in emulsion admixture evaluated by in situ flow particle imaging analysis

We evaluated the particle state change in emulsion admixtures using in situ flow particle imaging analysis (FPIA). Ropion® intravenous (flurbiprofen axetil: Ropion®) served as the model emulsion formulation. A binary mixture of Ropion® and normal saline (NS), and a ternary admixture of Ropion®, NS, and Gaster® injection (famotidine: Gaster®) or Primperan® injection (metoclopramide hydrochloride: Primperan®) were prepared and the change in emulsion particle state was analyzed using FPIA under in situ condition. The effect of storage on pH change and the chemical stability of flurbiprofen axetil were also investigated. In Ropion®, various particle images (mean diameter: 2.4 µm) were obtained. From our analysis of changes in scattergrams and particle images, changing behaviors of emulsion particles as a function of storage time depended on the systems of admixture samples. In Ropion®/NS and Ropion®/Gaster®/NS systems, mean particle size and particle number increased with lengthening storage time; however, these values were dramatically increased beyond 6 h in the Ropion®/Primperan®/NS system, corresponding to a decrease in measured pH. The decomposition of flurbiprofen axetil due to incompatibility was not observed in all systems. Detailed information on the change in emulsion particle state was obtained using FPIA, indicating that this method is useful to evaluate state changes in emulsion admixtures under in situ condition.

Extending total parenteral nutrition hang time in the neonatal intensive care unit: is it safe and cost effective?

AIM

To investigate the effects of prolonging hang time of total parenteral nutrition (TPN) fluid on central line-associated blood stream infection (CLABSI), TPN-related cost and nursing workload.

METHODS

A before-after observational study comparing the practice of hanging TPN bags for 48 h (6 February 2009-5 February 2010) versus 24 h (6 February 2008-5 February 2009) in a tertiary neonatal intensive care unit was conducted. The main outcome measures were CLABSI, TPN-related expenses and nursing workload.

RESULTS

One hundred thirty-six infants received 24-h TPN bags and 124 received 48-h TPN bags. Median (inter-quartile range) gestation (37 weeks (33,39) vs. 36 weeks (33,39)), mean (±standard deviation) admission weight of 2442 g (±101) versus 2476 g (±104) and TPN duration (9.7 days (±12.7) vs. 9.9 days (±13.4)) were similar (P > 0.05) between the 24- and 48-h TPN groups. There was no increase in CLABSI with longer hang time (0.8 vs. 0.4 per 1000 line days in the 24-h vs. 48-h group; P < 0.05). Annual cost saving using 48-h TPN was AUD 97,603.00. By using 48-h TPN, 68.3% of nurses indicated that their workload decreased and 80.5% indicated that time spent changing TPN reduced.

CONCLUSION

Extending TPN hang time from 24 to 48 h did not alter CLABSI rate and was associated with a reduced TPN-related cost and perceived nursing workload. Larger randomised controlled trials are needed to more clearly delineate these effects.

Influence of the relative composition of trace elements and vitamins in physicochemical stability of total parenteral nutrition formulations for neonatal use

OBJECTIVE

The present study aimed to evaluate the influence of the relative composition of trace elements and vitamins in physicochemical stability of neonatal parenteral nutrition.

MATERIAL AND METHODS

Three formulations for neonatal administration were selected; the main variable was the presence of trace elements and vitamins. The analyses where carried out immediately after preparation and at 24 h, 48 h, 72 h and 7 days after preparation. Three methods were selected to determine globule size: light obscuration, dynamic light scattering and optical microscopy. Complementary evaluation including visual inspection, determination of pH and osmolarity, peroxide levels and measurements of zeta potential were also performed.

RESULTS

There was an observable alteration in color and phase separation in the PN stored at 25°C and 40°C. Neither globule size pattern, nor any other physicochemical characteristic evaluated appeared to be considerably altered in any of the analyzed formulations even after 7 days of storage at 5°C. Globule size in all the PN studied was consistent with the established limit, below 500 nm by DLS measurement, and PFAT5 was below 0.05% under all storage temperatures.

CONCLUSION

Concomitant presence of trace elements and vitamins in the same neonatal formulation did not alter the evaluated aspects of stability.