Thermal expansion of substrate may affect adhesion of Chinese hamster fibroblasts to surfaces during freezing

Cryopreservation-induced delayed injury and cell-type-specific responses during the cryopreservation of endothelial cell monolayers

The cryopreservation of endothelial cell monolayers is an important step that bridges the cryopreservation of cells in suspension to that of tissues. Previous studies have identified clear distinctions in freezing mechanisms between cells in suspension and in monolayers, as well as developed novel protocols for monolayer cryopreservation. Recently, our group has shown that human umbilical vein endothelial cell (HUVEC) and porcine corneal endothelial cell (PCEC) monolayers grown on Rinzl plastic substrate can be cryopreserved in 5% dimethyl sulfoxide, 6% hydroxyethyl starch, and 2% chondroitin sulfate, following a slow-cooling protocol (-1 °C/min) with rapid plunge into liquid nitrogen from -40 °C. However, membrane integrity assessments were done immediately post thaw, which may result in an overestimation of cell viability due to possible delayed injury responses. Here, we show that for the optimal protocol condition of plunge at the -40 °C interrupt temperature, HUVEC and PCEC monolayers exhibited no significant immediate post-thaw injuries nor delayed injury responses during the 24-h post-thaw overnight culture period. HUVEC monolayers experienced no significant impact to their natural growth rate during the post-thaw culture, while PCEC monolayers experienced significantly higher growth than the unfrozen controls. The difference in the low-temperature responses between HUVEC and PCEC monolayers was further shown under high temperature plunge conditions. At these suboptimal plunge temperatures, HUVEC monolayers exhibited moderate immediate membrane injury but a pronounced delayed injury response during the 24-h post-thaw culture, while PCEC monolayers showed significant immediate membrane injury but no additional delayed injury response during the same period. Therefore, we provide further validation of our group's previously designed endothelial monolayer cryopreservation protocol for HUVEC and PCEC monolayers, and we identify several cell-type-specific responses to the freezing process.

Preclinical characterization of macrophage-adhering gadolinium micropatches for MRI contrast after traumatic brain injury in pigs

The choroid plexus (ChP) of the brain plays a central role in orchestrating the recruitment of peripheral leukocytes into the central nervous system (CNS) through the blood-cerebrospinal fluid (BCSF) barrier in pathological conditions, thus offering a unique niche to diagnose CNS disorders. We explored whether magnetic resonance imaging of the ChP could be optimized for mild traumatic brain injury (mTBI). mTBI induces subtle, yet influential, changes in the brain and is currently severely underdiagnosed. We hypothesized that mTBI induces sufficient alterations in the ChP to cause infiltration of circulating leukocytes through the BCSF barrier and developed macrophage-adhering gadolinium [Gd(III)]-loaded anisotropic micropatches (GLAMs), specifically designed to image infiltrating immune cells. GLAMs are hydrogel-based discoidal microparticles that adhere to macrophages without phagocytosis. We present a fabrication process to prepare GLAMs at scale and demonstrate their loading with Gd(III) at high relaxivities, a key indicator of their effectiveness in enhancing image contrast and clarity in medical imaging. In vitro experiments with primary murine and porcine macrophages demonstrated that GLAMs adhere to macrophages also under shear stress and did not affect macrophage viability or functions. Studies in a porcine mTBI model confirmed that intravenously administered macrophage-adhering GLAMs provide a differential signal in the ChP and lateral ventricles at Gd(III) doses 500- to 1000-fold lower than those used in the current clinical standard Gadavist. Under the same mTBI conditions, Gadavist did not offer a differential signal at clinically used doses. Our results suggest that macrophage-adhering GLAMs could facilitate mTBI diagnosis.

A highly active mineral-based ice nucleating agent supports in situ cell cryopreservation in a high throughput format

Cryopreservation of biological matter in microlitre scale volumes of liquid would be useful for a range of applications. At present, it is challenging because small volumes of water tend to supercool, and deep supercooling is known to lead to poor post-thaw cell viability. Here, we show that a mineral ice nucleator can almost eliminate supercooling in 100 µl liquid volumes during cryopreservation. This strategy of eliminating supercooling greatly enhances cell viability relative to cryopreservation protocols with uncontrolled ice nucleation. Using infrared thermography, we demonstrate a direct relationship between the extent of supercooling and post-thaw cell viability. Using a mineral nucleator delivery system, we open the door to the routine cryopreservation of mammalian cells in multiwell plates for applications such as high throughput toxicology testing of pharmaceutical products and regenerative medicine.

Recent Advances and Challenges Toward Application of Fibers and Textiles in Integrated Photovoltaic Energy Storage Devices

Flexible microelectronic devices have seen an increasing trend toward development of miniaturized, portable, and integrated devices as wearable electronics which have the requirement for being light weight, small in dimension, and suppleness. Traditional three-dimensional (3D) and two-dimensional (2D) electronics gadgets fail to effectively comply with these necessities owing to their stiffness and large weights. Investigations have come up with a new family of one-dimensional (1D) flexible and fiber-based electronic devices (FBEDs) comprising power storage, energy-scavenging, implantable sensing, and flexible displays gadgets. However, development and manufacturing are still a challenge owing to their small radius, flexibility, low weight, weave ability and integration in textile electronics. This paper will provide a detailed review on the importance of substrates in electronic devices, intrinsic property requirements, fabrication classification and applications in energy harvesting, energy storage and other flexible electronic devices. Fiber- and textile-based electronic devices for bulk/scalable fabrications, encapsulation, and testing are reviewed and presented future research ideas to enhance the commercialization of these fiber-based electronics devices.

Pollen derived macromolecules serve as a new class of ice-nucleating cryoprotectants

Cryopreservation of biological material is vital for existing and emerging biomedical and biotechnological research and related applications, but there remain significant challenges. Cryopreservation of cells in sub-milliliter volumes is difficult because they tend to deeply supercool, favoring lethal intracellular ice formation. Some tree pollens are known to produce polysaccharides capable of nucleating ice at warm sub-zero temperatures. Here we demonstrated that aqueous extractions from European hornbeam pollen (pollen washing water, PWW) increased ice nucleation temperatures in 96-well plates from ≈ − 13 °C to ≈ − 7 °C. Application of PWW to the cryopreservation of immortalized T-cells in 96-well plates resulted in an increase of post-thaw metabolic activity from 63.9% (95% CI [58.5 to 69.2%]) to 97.4% (95% CI [86.5 to 108.2%]) of unfrozen control. When applied to cryopreservation of immortalized lung carcinoma monolayers, PWW dramatically increased post-thaw metabolic activity, from 1.6% (95% CI [− 6.6 to 9.79%]) to 55.0% (95% CI [41.6 to 68.4%]). In contrast to other ice nucleating agents, PWW is soluble, sterile and has low cytotoxicity meaning it can be readily incorporated into existing cryopreservation procedures. As such, it can be regarded as a unique class of cryoprotectant which acts by inducing ice nucleation at warm temperatures.

Adherent cell thawing by infrared radiation

Cryopreservation of adherent cells is crucial for commercial cell therapy technology, including effective distribution and storage. Fast thawing has been shown to increase cell recovery in vitrified samples. Previously, radiofrequency (RF) has been investigated as a heating source on large samples, either with or without magnetic particles. Also, laser heating with the aid of dye or nanoparticles has been utilized on sub-millimeter samples successfully. For slow freezing cryopreservation methods, the influence of rate of thawing on viability is less clear. Cryopreservation of surface adhered cells result in many cases in detachment from the surface. We illustrate how intense infrared radiation from a focused halogen illuminator accelerates thawing. We show that two epithelial cell lines, retinal pigment epithelium cells and heterogeneous human epithelial colorectal adenocarcinoma cells, can be effectively cryopreserved and recovered using a combination of slow freezing and fast thawing under infrared illumination. We were able to successfully thaw samples, of 2-4 mm thick, including the media, on the order of a second, providing a heating rate of thousands of Kelvin per minute. Under optimal conditions, we observed higher post-thawing cell viability rates and higher cell adhesion with infrared thawing than with water bath thawing. We suggest that bulk warming with infrared radiation has an advantage over surface warming of surface-attached cells, as it alleviates cell stress during the process of thawing. These findings will pave the way for novel approaches to treating substrate-adhered cells and 3D scaffolds with cells and organoids. This technology may serve as a crucial component in lab-on-chip systems for medical testing and therapeutic use.

Cryopreservation of human cerebral microvascular endothelial cells and astrocytes in suspension and monolayers

The blood-brain barrier (BBB) keeps pathogens and toxins out of the brain but also impedes the entry of pharmaceuticals. Human cerebral microvascular endothelial cells (hCMECs) and astrocytes are the main functional cell components of the BBB. Although available commercially as cryopreserved cells in suspension, improvements in their cryopreservation and distribution as cryopreserved monolayers could enhance BBB in vitro studies. Here, we examined the response to slow cooling and storage in liquid nitrogen of immortalized hCMEC/D3 cells and human primary astrocytes in suspension and in monolayers. HCMEC/D3 cells in suspension cryopreserved in 5% dimethyl sulfoxide (DMSO) and 95% fetal bovine serum or in 5% DMSO and 6% hydroxyethyl starch (HES) showed post-thaw membrane integrities above 90%, similar to unfrozen control. Cryopreservation did not affect the time-dependent ability of hCMEC/D3 cells to form tubes on Matrigel. Primary astrocytes in suspension cryopreserved in the presence of 5% DMSO and 6% HES had improved viability over those cryopreserved in 10% DMSO. Monolayers of single cultures or co-cultures of hCMEC/D3 cells and astrocytes on fibronectin-coated Rinzl coverslips retained membrane integrities and metabolic function, after freezing in 5% DMSO, 6% HES, and 2% chondroitin sulfate, that were comparable to those of unfrozen controls even after overnight incubation. Rinzl is better than glass or Thermanox as an underlying solid substrate for cryopreserving hCMEC/D3 monolayers. Cryopreserved hCMEC/D3 monolayers expressed the junction proteins ZO-1 and claudin-5 similar to their unfrozen counterparts. Hence, we describe improved cryopreservation protocols for hCMEC/D3 cells and astrocytes in suspension, and a novel protocol for the cryopreservation of monolayers of hCMEC/D3 cells and astrocytes as single cultures or co-cultures that could expand their distribution for research on disease modeling, drug screening, and targeted therapy pertaining to the BBB.

Cryopreservation of a cell-based biosensor chip modified with elastic polymer fibers enabling ready-to-use on-site applications

An efficient preservation of a cell-based biosensor chip to achieve a ready-to-use on-site system is still very challenging as the chip contains a living component such as adherent mammalian cells. Herein, we propose a strategy called on-sensor cryopreservation (OSC), which enables the adherent cells to be preserved by freezing (-80 °C) on a biosensor surface, such as the light-addressable potentiometric sensor (LAPS). Adherent cells on rigid surfaces are prone to cryo-injury; thus, the surface was modified to enhance the cell recovery for OSC. It relies on i) the integration of elastic electrospun fibers composed of polyethylene vinyl acetate (PEVA), which has a high thermal expansion coefficient and low glass-transition temperature, and ii) the treatment with O₂ plasma. The modified sensor is integrated into a microfluidic chip system not only to decrease the thermal mass, which is critical for fast thawing, but also to provide a precisely controlled micro-environment. This novel cryo-chip system is effective for keeping cells viable during OSC. As a proof-of-concept for the applicability of a ready-to-use format, the extracellular acidification of cancer cells (CHO-K1) was evaluated by differential LAPS measurements after thawing. Results show, for the first time, that the OSC strategy using the cryo-chip allows label-free and quantitative measurements directly after thawing, which eliminates additional post-thaw culturing steps. The freezing of the chips containing cells at the manufacturing stage and sending them via a cold-chain transport could open up a new possibility for a ready-to-use on-site system.

Protocol for Cryopreservation of Endothelial Monolayers

One of the major challenges in the preservation of complex tissues is the cryosensitivity of the endothelium, the single layer of cells lining blood vessels, corneas, and other tissues. The increasing importance of endothelial monolayers in tissue-engineered constructs for transplantation and research warrants the need to develop protocols for the successful cryopreservation of cells in monolayers. In this chapter, we describe a recently published cryopreservation protocol that we developed based on examination of various factors that influence the post-thaw recovery of endothelial monolayers. To efficiently investigate cryopreservation protocol parameters, we employed an interrupted slow-cooling procedure (graded freezing) that allows dissecting loss of cell viability into contributions from slow-cooling injury and rapid-cooling injury. Our optimized protocol involves culturing cells on Rinzl plastic coverslips, using a combination of a penetrating cryoprotectant (5% dimethyl sulfoxide) and a non-penetrating cryoprotectant (6% hydroxyethyl starch), addition of 2% chondroitin sulfate, controlled cooling at 0.2 °C/min or 1 °C/min, and removal of cryoprotectant immediately after thaw. The protocol has been validated for human umbilical vein and porcine corneal endothelial cell monolayers.

Establishment, characterization, and cryopreservation of cell lines derived from red-rumped agouti (Dasyprocta leporina Linnaeus, 1758) - A study in a wild rodent

Somatic cells can be used for rescuing wild mammals of ecological and economic importance, such as red-rumped agouti, through their application in advanced technologies. Thus, appropriate cell isolation, culture, and storage through cryopreservation can ensure the future safe use of these cells. We aimed to establish and evaluate the effects of culture time (second, fifth, and eighth passages) and cryopreservation on the morphology, viability, metabolism, proliferative activity, reactive oxygen species (ROS) levels, mitochondrial membrane potential (ΔΨm), and apoptosis on somatic cells derived from red-rumped agouti skin. Initially, we identified six dermal fibroblast lines by morphology, immunophenotyping, and karyotyping assays. In vitro culture after the second, fifth, and eighth passages, as well as the cryopreservation conditions used did not affect the metabolism or level of apoptosis. Nevertheless, cells in the fifth passage featured a reduction in proliferative activity and an increase in ROS levels when compared to second and eighth passage cells. Moreover, cryopreservation resulted in reduced ΔΨm when compared to non-cryopreserved cells. Additionally, cryopreserved cells showed a reduction in viability immediately after thawing; nevertheless, the viability of these cells was re-established after 11 days of in vitro culture and was similar to that of non-cryopreserved cells. In conclusion, we have shown that viable fibroblasts can be obtained from red-rumped agouti skin, featuring minimal changes after eight passages in in vitro culture systems. Additionally, adjustments to the cryopreservation protocol are necessary to reduce cellular oxidative stress caused by low temperatures.

Transient loss of membrane integrity following intracellular ice formation in dimethyl sulfoxide-treated hepatocyte and endothelial cell monolayers

Immediate post-thaw evaluation of membrane integrity has proven to yield overestimates of cell survival under conditions that preclude intracellular ice formation (IIF). However, prominent theories on the mechanisms of intracellular nucleation suggest a damaged membrane can reseal, prompting us to evaluate whether immediate post-thaw assessments of membrane integrity can in fact underestimate cell survival under conditions that promote IIF. HUVEC and HepG2 monolayers were treated with 1.4 M DMSO and frozen to -25 °C under conditions that formed either 0% or 100% IIF. Membrane integrity was evaluated both immediately and 24 h post-thaw, with metabolic activity assessments performed 24 h post-thaw as a secondary measure of survival. Treatment with 1.4 M DMSO and nucleation of 100% IIF resulted in a drastic increase in the relative percent of membrane intact cells following a 24 h culture period (HUVEC: 90.2% ± 0.7%; HepG2: 70.4% ± 4.0%), which correlated with 24 h post-thaw metabolic activity. These differences between the immediate and 24 h post-thaw membrane integrity assessments were significantly more than those seen in the absence of either IIF or DMSO treatment. Therefore, a high incidence of IIF in DMSO-treated monolayers may lead to erroneous underestimates of cell survival when conducting immediate post-thaw assessments of membrane integrity.

Cryopreservation of primary cultures of mammalian somatic cells in 96-well plates benefits from control of ice nucleation

Cryopreservation of mammalian cells has to date typically been conducted in cryovials, but there are applications where cryopreservation of primary cells in multiwell plates would be advantageous. However excessive supercooling in the small volumes of liquid in each well of the multiwell plates is inevitable without intervention and tends to result in high and variable cell mortality. Here, we describe a technique for cryopreservation of adhered primary bovine granulosa cells in 96-well plates by controlled rate freezing using controlled ice nucleation. Inducing ice nucleation at warm supercooled temperatures (less than 5 °C below the melting point) during cryopreservation using a manual seeding technique significantly improved post-thaw recovery from 29.6% (SD = 8.3%) where nucleation was left uncontrolled to 57.7% (9.3%) when averaged over 8 replicate cultures (p < 0.001). Detachment of thawed cells was qualitatively observed to be more prevalent in wells which did not have ice nucleation control which suggests cryopreserved cell monolayer detachment may be a consequence of deep supercooling. Using an infra-red thermography technique we showed that many aliquots of cryoprotectant solution in 96-well plates can supercool to temperatures below −20 °C when nucleation is not controlled, and also that the freezing temperatures observed are highly variable despite stringent attempts to remove contaminants acting as nucleation sites. We conclude that successful cryopreservation of cells in 96-well plates, or any small volume format, requires control of ice nucleation.

Cryopreservation of human umbilical vein and porcine corneal endothelial cell monolayers

Cryopreservation of endothelium is one of the major challenges in the cryopreservation of complex tissues. Human umbilical vein endothelial cells (HUVECs) in suspension are available commercially and recently their post-thaw cell membrane integrity was significantly improved by cryopreservation in 5% dimethyl sulfoxide (Me₂SO) and 6% hydroxyethyl starch (HES). However, cryopreservation of cells in monolayers has been elusive. The exact mechanisms of damage during cell monolayer cryopreservation are still under investigation. Here, we show that a combination of different factors contribute to significant progress in cryopreservation of endothelial monolayers. The addition of 2% chondroitin sulfate to 5% Me₂SO and 6% HES and cooling at 0.2 or 1 °C/min led to high membrane integrity (97.3 ± 3.2%) immediately after thaw when HUVECs were cultured on a substrate with a coefficient of thermal expansion similar to that of ice. The optimized cryopreservation protocol was applied to monolayers of primary porcine corneal endothelial cells, and resulted in high post-thaw viability (95.9 ± 3.7% membrane integrity) with metabolic activity 12 h post-thaw comparable to unfrozen control.