Reassessment of the succession of lactic acid bacteria in commercial cucumber fermentations and physiological and genomic features associated with their dominance

Whole-genome sequences of fermentative and spoilage-associated lactic acid bacteria, Lysinibacillus capsici and a Serratia marcescens isolated from commercial cucumber fermentations

We report the annotated, whole-genome sequences of 16 bacteria isolated from commercial cucumber fermentations. The collection consists of nine fermentative and two spoilage-associated lactic acid bacteria, four Lysinibacillus strains, and a Serratia marcescens. Half the genome assemblies have fewer than 10 contigs, and the remainder have fewer than 30.

Enhancement of γ-aminobutyric acid in fermented cucumbers

The effects of brine acidification, glutamate addition, and starter culture on γ-aminobutyric acid (GABA) content of fermented cucumber were investigated. GABA is a nonprotein amino acid with antihypertensive, antianxiety, and immunomodulatory properties. It is produced during cucumber fermentation but is limited by the low intrinsic concentration of free glutamate. Glutamine is 10-fold more abundant than glutamate in fresh cucumber and could provide additional substrate if converted to glutamate by glutaminase. Cucumbers were fermented in triplicate in acidified (pH 4.7-4.8) or nonacidified (pH 6.6) cover brines with 2% (342 mM) sodium chloride (NaCl) and 0 or 10 mM added glutamate. Indigenous and starter culture-assisted fermentations were conducted for each treatment at 28°C. The starter culture included lactobacilli containing gene sequences that encode for glutaminase (Lactobacillus gasseri ATCC 33323) and glutamate decarboxylase (Lactiplantibacillus plantarum WCFS1 ATCC BAA-793). GABA, glutamate, and glutamine were quantified by liquid chromatography triple quadrupole mass spectrometry. Both indigenous and starter culture-assisted fermentations effectively metabolized intrinsic and added glutamate, resulting in 10.4 ± 2.2 mM to 14.9 ± 0.7 mM GABA in glutamate supplemented fermentations compared with only 1.1 ± 0.2 mM in indigenous ferments. No additional increases in glutamate or downstream formation of GABA were observed in nonacidified brines with or without starter cultures, indicating that glutaminase production by L. gasseri and the indigenous microbiota was minimal or absent under these conditions. Glutamate addition to reduced salt cucumber fermentations generated ready-to-eat pickles that can deliver clinically relevant levels of GABA in a typical serving size. PRACTICAL APPLICATION: Research was conducted to explore ways to increase the production of the health-promoting compound, γ-aminobutyric acid (GABA), in fermented cucumber pickles. Cucumbers were fermented in reduced salt cover brines with or without added glutamate and/or acetic acid. Both natural and starter culture-assisted fermentations effectively converted the intrinsic and added glutamate to GABA, producing ready-to-eat pickles that can deliver clinically relevant levels of GABA in a typical serving size.

Influence of the initial microbiota on eggplant shibazuke pickle and eggplant juice fermentation

The present study aimed to investigate the effects of the initial microbiota on microbial succession and metabolite transition during eggplant fermentation. Samples of traditional Japanese eggplant pickles, shibazuke, which were spontaneously fermented by plant-associated microbiota, were used for the analysis. Microbiota analysis indicated two successional patterns: early dominance of lactic acid bacteria superseded by aerobic bacteria and early dominance of lactic acid bacteria maintained to the end of the production process. Next, shibazuke production was modeled using filter-sterilized eggplant juice, fermenting the average composition of the initial shibazuke microbiota, which was artificially constructed from six major species identified during shibazuke production. In contrast to shibazuke production, all batches of eggplant juice fermentation showed almost identical microbial succession and complete dominance of Lactiplantibacillus plantarum in the final microbiota. These findings revealed the fate of initial microbiota under shibazuke production conditions: the early dominance of lactic acid bacteria that was maintained throughout, with L. plantarum ultimately predominating the microbiota. Furthermore, a comparison of the results between shibazuke production and eggplant juice fermentation suggested that L. plantarum is involved in the production of lactic acid, alanine, and glutamic acid during eggplant fermentation regardless of the final microbiota.

IMPORTANCE

The findings shown in this study provide insight into the microbial succession during spontaneous pickle fermentation and the role of Lactiplantibacillus plantarum in eggplant pickle production. Moreover, the novel method of using filter-sterilized vegetable juice with an artificial microbiota to emulate spontaneous fermentation can be applied to other spontaneously fermented products. This approach allows for the evaluation of the effect of specific initial microbiota in the absence of plant-associated bacteria from raw materials potentially promoting a greater understanding of microbial behavior in complex microbial ecosystems during vegetable fermentation.

Analysis of Pickled Cucumber Products, Based on Microbial Diversity and Flavor Substance Detection

Changes to the microbial community during pickled cucumber fermentation were studied using the 16S rDNA technique. The changes of volatile organic compounds (VOCs) during pickled cucumber fermentation were studied by gas chromatograph-ion mobility spectrometry. At the phylum level, Cyanophyta and Proteobacteria were the dominant flora in the natural fermentation group, and Firmicutes were the dominant flora in the added-bacteria fermentation group. At the generic level, the addition of Lactobacillus led to changes in the community of the bacteria in the added-bacterial fermentation group and decreased the species abundance of other bacteria. In total, 75 volatile organic compounds were identified from naturally fermented pickled cucumber, and 60 volatile organic compounds were identified from fermented pickled cucumber with bacterial addition. The main metabolites were esters, aldehydes, acids, alcohols, ketones, alkanes, nitriles, and alkenes. These metabolites will bring their unique aroma components to the pickled cucumber. Metabolomic analysis of the O2PLS model showed that Weissella and Lactobacillus were closely and positively correlated with nine alcohols, six esters, five aldehydes, four acids, three ketones, and one pyrazine. Pseudomonas and norank_f_Mitochondria show a close positive correlation with four kinds of alcohols, two kinds of esters, one kind of aldehyde, and one kind of nitrile.

Tasting of traditional Polish fermented cucumbers: Microbiology, morpho-textural features, and volatilome

In the present study, naturally fermented and unpasteurized cucumbers (Cucumis sativus L.) collected from 4 producers located in different regions of Poland were studied. The fermented cucumbers were characterized by significant nutritional features in terms of polyphenols content and antioxidant activity. Microbiological analyses revealed active bacterial populations of lactococci, thermophilic cocci, lactobacilli, and coagulase-negative cocci. The microbiological characterization of cucumber and brine samples through metataxonomic analysis allowed the dominant species to be detected, being Lactococcus and Streptococcus in cucumbers, and Lactiplantibacillus, Leuconostoc, Pediococcus, Secundilactobacillus, and Lentilactobacillus in brine. The isolation activity offered a clear picture of the main active lactic acid bacteria at the end of fermentation, being Pediococcus parvulus and Lactiplantibacillus plantarum group. All the studied isolates showed a good attitude in fermenting a cucumber-based broth, thus suggesting their potential application as starter or adjunct cultures for guided cucumber fermentation. Moreover, for the same isolates, strong aminopeptidase activity (due to leucine arylamidase and valine arylamidase) was observed, with potential effect on the definition of the final sensory traits of the product. Only a few isolates showed the ability to produce exopolysaccharides in synthetic medium. Of note, the presence of the hdcA gene in some Pediococcus ethanolidurans isolates also confirmed the need for a thorough characterization of starter candidates to avoid undesired adverse effects on consumer's health. No isolate showed the production of bacteriocins against Listeria innocua used as surrogate for Listeria monocytogenes. Based on the results of Headspace Solid-Phase Microextraction-Gas Chromatography/Mass Spectrometry analysis, a rich and complex volatilome, composed by more than 80 VOCs, was recognized and characterized. In more detail, the detected compounds belonged to 9 main classes, being oxygenated terpenes, alcohols, terpenes, ketones, acids, aldehydes, esters, sulfur, and sesquiterpenes.

An overview of fermentation in the food industry - looking back from a new perspective

Fermentation is thought to be born in the Fertile Crescent, and since then, almost every culture has integrated fermented foods into their dietary habits. Originally used to preserve foods, fermentation is now applied to improve their physicochemical, sensory, nutritional, and safety attributes. Fermented dairy, alcoholic beverages like wine and beer, fermented vegetables, fruits, and meats are all highly valuable due to their increased storage stability, reduced risk of food poisoning, and enhanced flavor. Over the years, scientific research has associated the consumption of fermented products with improved health status. The fermentation process helps to break down compounds into more easily digestible forms. It also helps to reduce the amount of toxins and pathogens in food. Additionally, fermented foods contain probiotics, which are beneficial bacteria that help the body to digest food and absorb nutrients. In today's world, non-communicable diseases such as cardiovascular disease, type 2 diabetes, cancer, and allergies have increased. In this regard, scientific investigations have demonstrated that shifting to a diet that contains fermented foods can reduce the risk of non-communicable diseases. Moreover, in the last decade, there has been a growing interest in fermentation technology to valorize food waste into valuable by-products. Fermentation of various food wastes has resulted in the successful production of valuable by-products, including enzymes, pigments, and biofuels.

Characterization of the Bacterial Composition of 47 Fermented Foods in Sweden

Fermentation has long been utilized to preserve and enhance the flavor and nutritional value of foods. Recently, fermented foods have gained popularity, reaching new consumer groups due to perceived health benefits. However, the microbial composition of many fermented foods re-mains unknown. Here, we characterized the bacterial composition, diversity, and richness of 47 fermented foods available in Sweden, including kombucha, water kefir, milk kefir, yogurt, plant-based yogurt alternatives, kimchi, sauerkraut, and fermented vegetables. Via 16S rRNA gene sequencing, we identified 2497 bacteria (amplicon sequence variants). The bacterial composition was strongly associated with the type of fermented food, and lactic acid bacteria and/or acetic acid bacteria dominated most samples. However, each fermented food had a unique composition, with kombucha and water kefir having the highest diversity across and within samples. Few bacteria were abundant in multiple foods and food groups. These were Streptococcus thermophilus in yogurts and plant-based yoghurts; Lactococcus lactis in milk kefirs and one water kefir; and Lactiplantibacillus plantarum in kimchi, sauerkraut, and fermented cucumber. The broad range of fermented foods included in this study and their diverse bacterial communities warrant further investigation into the implications of microbial compositions for product traits and potential impact on human health.

Genome-Wide Comparative Analysis of Lactiplantibacillus pentosus Isolates Autochthonous to Cucumber Fermentation Reveals Subclades of Divergent Ancestry

Lactiplantibacillus pentosus, commonly isolated from commercial cucumber fermentation, is a promising candidate for starter culture formulation due to its ability to achieve complete sugar utilization to an end pH of 3.3. In this study, we conducted a comparative genomic analysis encompassing 24 L. pentosus and 3 Lactiplantibacillus plantarum isolates autochthonous to commercial cucumber fermentation and 47 lactobacillales reference genomes to determine species specificity and provide insights into niche adaptation. Results showed that metrics such as average nucleotide identity score, emulated Rep-PCR-(GTG)₅, computed multi-locus sequence typing (MLST), and multiple open reading frame (ORF)-based phylogenetic trees can robustly and consistently distinguish the two closely related species. Phylogenetic trees based on the alignment of 587 common ORFs separated the L. pentosus autochthonous cucumber isolates from olive fermentation isolates into clade A and B, respectively. The L. pentosus autochthonous clade partitions into subclades A.I, A.II, and A.III, suggesting substantial intraspecies diversity in the cucumber fermentation habitat. The hypervariable sequences within CRISPR arrays revealed recent evolutionary history, which aligns with the L. pentosus subclades identified in the phylogenetic trees constructed. While L. plantarum autochthonous to cucumber fermentation only encode for Type II-A CRISPR arrays, autochthonous L. pentosus clade B codes for Type I-E and L. pentosus clade A hosts both types of arrays. L. pentosus 7.8.2, for which phylogeny could not be defined using the varied methods employed, was found to uniquely encode for four distinct Type I-E CRISPR arrays and a Type II-A array. Prophage sequences in varied isolates evidence the presence of adaptive immunity in the candidate starter cultures isolated from vegetable fermentation as observed in dairy counterparts. This study provides insight into the genomic features of industrial Lactiplantibacillus species, the level of species differentiation in a vegetable fermentation habitat, and diversity profile of relevance in the selection of functional starter cultures.

Molecular Detection and Identification of Plant-Associated Lactiplantibacillus plantarum

Lactiplantibacillus plantarum is a lactic acid bacterium often isolated from a wide variety of niches. Its ubiquity can be explained by a large, flexible genome that helps it adapt to different habitats. The consequence of this is great strain diversity, which may make their identification difficult. Accordingly, this review provides an overview of molecular techniques, both culture-dependent, and culture-independent, currently used to detect and identify L. plantarum. Some of the techniques described can also be applied to the analysis of other lactic acid bacteria.

Genomic diversity in Fructobacillus spp. isolated from fructose-rich niches

The Fructobacillus genus is a group of obligately fructophilic lactic acid bacteria (FLAB) that requires the use of fructose or another electron acceptor for their growth. In this work, we performed a comparative genomic analysis within the genus Fructobacillus by using 24 available genomes to evaluate genomic and metabolic differences among these organisms. In the genome of these strains, which varies between 1.15- and 1.75-Mbp, nineteen intact prophage regions, and seven complete CRISPR-Cas type II systems were found. Phylogenetic analyses located the studied genomes in two different clades. A pangenome analysis and a functional classification of their genes revealed that genomes of the first clade presented fewer genes involved in the synthesis of amino acids and other nitrogen compounds. Moreover, the presence of genes strictly related to the use of fructose and electron acceptors was variable within the genus, although these variations were not always related to the phylogeny.

Prevention of microbes-induced spoilage in sodium chloride-free cucumber fermentations employing preservatives

This study evaluated preservatives to stabilize sodium chloride (NaCl)-free-cucumber fermentations. The brining of air-purged laboratory cucumber fermentations with 100.0 mM calcium chloride (CaCl₂ ) and 25.0 mM acetic acid resulted in immediate rises in pH, the chemical reduction of the medium, and malodors. Supplementation with 3.0 mM sodium benzoate or 3.0 mM potassium sorbate enabled a decline in pH, a continuous oxidative state of the medium, and delayed rising pH spoilage. However, lactic and acetic acids eventually disappeared in fermentations supplemented with preservatives. The amount of preservatives needed to suppress growth of brined-cucumber-spoilage microbes was determined in Fermented Cucumber Juice Medium (FCJM). Supplementation of FCJM with 10.0 mM sodium benzoate was inhibitory for the spoilage yeasts, Issatchenkia occidentalis and Pichia manshurica, and the lactobacilli, Lentilactobacillus buchneri and Lentilactobacillus parafarraginis, but not of Zygosaccharomyces globiformis. Potassium sorbate inhibited the spoilage yeasts at 15.0 mM in FCJM but not the lactobacilli. Supplementation of FCJM with 20.0 mM fumaric acid had a bactericidal effect on the spoilage-associated lactobacilli. As expected, NaCl-free-commercial cucumber fermentations brined with 100 mM CaCl₂ , no acetic acid, and 6 mM potassium sorbate resulted in complete fermentations, but supported rising pH, microbially induced spoilage during long-term storage. Post-fermentation supplementation with 12 mM sodium benzoate, 10 mM fumaric acid, a combination of the two, or 10 mM fumaric acid and 2 mM AITC prevented microbial activity during long-term bulk storage. PRACTICAL APPLICATION: Several preservative-based strategies for stabilizing NaCl-free cucumber fermentation in a commercial production setting were developed, enabling the implementation of a processing technology that reduces wastewater volumes and environmental impact.

Growth of ɣ-Proteobacteria in Low Salt Cucumber Fermentation Is Prevented by Lactobacilli and the Cover Brine Ingredients

This study investigated the ability of ɣ-proteobacteria, indigenous to fresh cucumber, to grow in the expressed fruit juice (CJM) and fermentation. It was hypothesized that fresh cucumbers can support prolific growth of ɣ-proteobacteria but that the cover brine composition and acid production by the competing lactobacilli in the fermentation of the fruit act as inhibitory agents. The ɣ-proteobacteria proliferated in CJM with an average maximum growth rate (μmax) of 0.3895 ± 0.0929 and doubling time (Td) of 1.885 ± 0.465/h. A significant difference was found between the ɣ-proteobacteria μmax and Td relative to Lactiplantibacillus pentosus LA0445 (0.2319 ± 0.019; 2.89/h) and Levilactobacillus brevis 7.2.43 (0.221 ± 0.015; 3.35/h) but not Lactiplantibacillus plantarum 3.2.8 (0.412 ± 0.119; 1.87/h). While inoculation level insignificantly altered the μmax and Td of the bacteria tested; it impacted the length of lag and stationary phases for the lactobacilli. Unlike the lactobacilli, the ɣ-proteobacteria were inhibited in CJM supplemented with a low salt fermentation cover brine containing calcium chloride, acetic acid and potassium sorbate. The ɣ-proteobacteria, P. agglomerans, was unable to proliferate in cucumber fermentations brined with calcium chloride at a pH of 6.0 ± 0.1 and the population of Enterobacteriaceae was outcompeted by the lactobacilli within 36 h. Together these observations demonstrate that the prolific growth of ɣ-proteobacteria in CJM is not replicated in cucumber fermentation. While the ɣ-proteobacteria growth rate is faster that most lactobacilli in CJM, their growth in cucumber fermentation is prevented by the cover brine and the acid produced by the indigenous lactobacilli. Thus, the lactobacilli indigenous to cucumber and cover brine composition influence the safety and quality of fermented cucumbers. IMPORTANCE While the abundance of specific ɣ-proteobacteria species varies among vegetable type, several harbor Enterobacteriaceae and Pseudomonadaceae that benefit the plant system. It is documented that such bacterial populations decrease in density early in vegetable fermentations. Consequently, it is assumed that they do not contribute to the quality of finished products. This study explored the viability of ɣ-proteobacteria in CJM, used as a model system, CJM supplemented with fermentation cover brine and cucumber fermentation, which are characterized by an extremely acidic endpoint pH (3.23 ± 0.17; n = 391). The data presented demonstrates that fresh cucumbers provide the nutrients needed by ɣ-proteobacteria to proliferate and reduce pH to 4.47 ± 0.12. However, ɣ-proteobacteria are unable to proliferate in cucumber fermentation. Control of ɣ-proteobacteria in fermentations depends on the cover brine constituents and the indigenous competing lactobacilli. This knowledge is of importance when developing guidelines for the safe fermentation of vegetables, particularly with low salt.

Genome Sequences for Levilactobacillus brevis Autochthonous to Commercial Cucumber Fermentations

We report the whole-genome sequences, along with annotations, of 11 Levilactobacillus brevis isolates from commercial cucumber fermentations performed in North Carolina (n = 9) and Minnesota (n = 2), USA.

Changes in the free amino acid profile of pickling cucumber during lactic acid fermentation

Free amino acid (FAA) profiles of fresh, acidified, naturally fermented, and starter culture fermented cucumbers were analyzed by liquid chromatography triple quadrupole mass spectrometry. Fermented cucumbers contained more total FAA than acidified cucumbers (1,302 ± 102 mg/kg and 635 ± 35 mg/kg, respectively). Total FAA content of fermented cucumber was similar regardless of brine salt levels (2-6% NaCl) and starter culture addition. Glutamine (1491.4 ± 69.3 mg/kg), γ-aminobutyric acid (GABA, 269.6 ± 21.4 mg/kg), asparagine (113.0 ± 6.4 mg/kg), and citrulline (110.3 ± 8.5 mg/kg) were the most abundant FAA in fresh pickling cucumber, whereas GABA (181.3 ± 21.5 mg/kg), isoleucine (165.2 ± 11.2 mg/kg), leucine (129.8 ± 10.9 mg/kg), and lysine (110.9 ± 5.0 mg/kg) were the most abundant in fermented cucumber. GABA and ornithine were produced during fermentation, indicating glutamate decarboxylase and arginine deiminase activities. Notably, ornithine was significantly higher in natural (63.3 ± 31.5 mg/kg) versus starter culture fermented cucumbers (3.0 ± 0.7 mg/kg). This new information on FAA composition of fresh and fermented pickling cucumbers shows the impact of fermentation conditions on cucumber amino acid profiles while providing insight for manipulating fermentations for health promotion and consumer acceptance. PRACTICAL APPLICATION: This study reports changes in the free amino acid profiles of raw, fermented and acidified cucumbers, which may be valuable for understanding the impact of these foods on human health and nutrition. This information is useful for food microbiologists studying the metabolism of lactic acid bacteria during fermentation and/or designing starter cultures and could contribute to the development of novel fermented cucumber pickle products with enhanced nutritional value.

Whole-Genome Sequencing and Annotation of Selected Lactobacillales Isolated from Commercial Cucumber Fermentation

We report the whole-genome sequences and annotations of 42 Lactobacillales isolated from commercial cucumber fermentations performed in North Carolina (n = 34) and Minnesota (n = 9), USA. The isolates include representatives from 12 acid-producing species.

Time Evolution of Microbial Composition and Metabolic Profile for Biogenic Amines and Free Amino Acids in a Model Cucumber Fermentation System Brined with 0.5% to 5.0% Sodium Chloride

Salt concentrations in brine and temperature are the major environmental factors that affect activity of microorganisms and, thus may affect formation of biogenic amines (BAs) during the fermentation process. A model system to ferment cucumbers with low salt (0.5%, 1.5% or 5.0% NaCl) at two temperatures (11 or 23 °C) was used to study the ability of indigenous microbiota to produce biogenic amines and metabolize amino acid precursors. Colony counts for presumptive Enterococcus and Enterobacteriaceae increased by 4 and up to 2 log of CFU∙mL⁻¹, respectively, and remained viable for more than 10 days. 16S rRNA sequencing showed that Lactobacillus and Enterobacter were dominant in fermented cucumbers with 0.5% and 1.5% salt concentrations after storage. The initial content of BAs in raw material of 25.44 ± 4.03 mg∙kg⁻¹ fluctuated throughout experiment, but after 6 months there were no significant differences between tested variants. The most abundant BA was putrescine, that reached a maximum concentration of 158.02 ± 25.11 mg∙kg⁻¹. The Biogenic Amines Index (BAI) calculated for all samples was significantly below that needed to induce undesirable effects upon consumption. The highest value was calculated for the 23 °C/5.0% NaCl brine variant after 192 h of fermentation (223.93 ± 54.40). Results presented in this work indicate that possibilities to control spontaneous fermentation by changing salt concentration and temperature to inhibit the formation of BAs are very limited.

The effects of vegetable pickling conditions on the dynamics of microbiota and metabolites

Background

Salting is a traditional procedure for producing pickled vegetables. Salting can be used as a pretreatment, for safe lactic acid fermentation and for salt stock preparation. This study aimed to provide valuable knowledge to improve pickle production by investigating the dynamics of microbiota and metabolites during the pretreatment and salt stock preparation processes, which have previously been overlooked. The differences in these process conditions would be expected to change the microbiota and consequently influence the content of metabolites in pickles.

Methods

Samples, collected from eight commercial pickle manufacturers in Japan, consisted of the initial raw materials, pickled vegetables and used brine. The microbiota were analyzed by 16S rRNA sequencing and the metabolites quantified by liquid chromatograph-mass spectrometry. Statistical analyses helped to identify any significant differences between samples from the initial raw materials, pretreatment process and salt stock preparation process groups.

Results

Under pretreatment conditions, aerobic and facultative anaerobic bacteria were predominant, including Vibrio, a potentially undesirable genus for pickle production. Under salt stock preparation conditions, the presence of halophilic bacteria, Halanaerobium, suggested their involvement in the increase in pyruvate derivatives such as branched-chain amino acids (BCAA). PICRUSt analysis indicated that the enhanced production of BCAA in salt stock was caused not by quantitative but by qualitative differences in the biosynthetic pathway of BCAA in the microbiota.

Conclusion

The differences in the microbiota between pretreatment and previously studied lactic acid fermentation processes emphasized the importance of anaerobic conditions and low pH under moderate salinity conditions for assuring safe pickle production. The results from the salt stock preparation process suggested that the Halanaerobium present may provide a key enzyme in the BCAA biosynthetic pathway which prefers NADH as a coenzyme. This feature can enhance BCAA production under anaerobic conditions where NADH is in excess. The effects shown in this study will be important for adjusting pickling conditions by changing the abundance of bacteria to improve the quality of pickled vegetables.

Biochemical changes and microbial community dynamics during spontaneous fermentation of Zhacai, a traditional pickled mustard tuber from China

Zhacai is a traditional fermented vegetable that has been consumed in China for centuries. It is currently manufactured by spontaneous fermentation and therefore mostly relies on the activities of autochthonous microorganisms. Here, we characterized microbial community dynamics and associated biochemical changes in 12% salted Zhacai during a 90-day spontaneous fermentation process using high-throughput sequencing and chromatography-based approaches to identify associations between microorganisms and fermentation characteristics. Amplicon sequencing targeting bacterial 16S rRNA genes revealed that bacterial communities were dominated by halophilic bacteria (HAB, i.e., Halomonas and Idiomarina) and lactic acid bacteria (LAB, i.e., Lactobacillus-related genera and Weissella) after 30 days of fermentation. In addition, the relative abundances of the fungal genera Debaryomyces, Sterigmatomyces, and Sporidiobolus increased as fermentation progressed. Concomitantly, pH decreased while titratable acidity increased during fermentation, along with associated variation in biochemical profiles. Overall, the levels of organic acids (i.e., lactic and acetic acid), free amino acids (i.e., alanine, lysine, and glutamic acid), and volatiles (i.e., alcohols, esters, aldehydes, and ketones) increased in mature Zhacai. In addition, the abundances of Lactobacillus-related species, Halomonas spp., Idiomarina loihiensis, as well as that of the yeast Debaryomyces hansenii, were strongly correlated with increased concentrations of organic acids, amino acids, biogenic amines, and volatiles. This study provides new detailed insights into the succession of microbial communities and their potential roles in Zhacai fermentation.

Gas chromatography-mass spectrometry-based metabolomics analysis of metabolites in commercial and inoculated pickles

BACKGROUND

Starter cultures are nowadays more and more used to make inoculated pickles (IPs), but it remains unclear whether there are differences in flavors between IPs and naturally fermented pickles. In this study 16 commercial pickles (CPs) produced by spontaneous fermentation method were purchased from markets in Sichuan province and Chongqing. Ten strains of three lactic acid bacteria species - Lactobacillus plantarum, Leuconostoc mesenteroides and Pediococcus ethanolidurans - were selected as single starter cultures to produce IPs.

RESULTS

Differences in flavor components between the CPs and IPs were monitored using a combination of gas chromatography-mass spectrometry and multivariate statistical methods. Higher levels of nonvolatile substances such as glucose, fructose, tagatose, sucrose, lactic acid and mannitol were detected in most IPs than in the CPs. The values of flavor characteristics such as sweetness, umami and astringency, which were correlated positively with consumers' overall preferences for pickles, were higher in the IPs than in the CPs. Volatile compounds such as geranyl acetate, dimethyl trisulfide, eucalyptol and linalool were distinguished as the main compounds that contributed to the flavor characteristics of the CPs. In addition to dimethyl trisulfide, dimethyl disulfide was also an odor contributor to the IPs.

CONCLUSIONS

The CPs and IPs had different flavor characteristics, especially in the composition and content of volatile components, and the inoculation method reflected some fermentation advantages, which could reduce the bitterness and increase umami and lead to a higher score of sensory preference. This will be helpful for industrial production. © 2020 Society of Chemical Industry.

Identification of potential causative agents of the CO2-mediated bloater defect in low salt cucumber fermentation

Development of bloater defect in cucumber fermentations is the result of carbon dioxide (CO₂) production by the indigenous microbiota. The amounts of CO₂ needed to cause bloater defect in cucumber fermentations brined with low salt and potential microbial contributors of the gas were identified. The carbonation of acidified cucumbers showed that 28.68 ± 6.04 mM (12%) or higher dissolved CO₂ induces bloater defect. The microbiome and biochemistry of cucumber fermentations (n = 9) brined with 25 mM calcium chloride (CaCl₂) and 345 mM sodium chloride (NaCl) or 1.06 M NaCl were monitored on day 0, 2, 3, 5, 8, 15 and 21 using culture dependent and independent microbiological techniques and High-Performance Liquid Chromatography. Changes in pH, CO₂ concentrations and the incidence of bloater defect were also followed. The enumeration of Enterobacteriaceae on Violet Red Bile Glucose agar plates detected a cell density of 5.2 ± 0.7 log CFU/g on day 2, which declined to undetectable levels by day 8. A metagenomic analysis identified Leuconostocaceae in all fermentations at 10 to 62%. The presence of both bacterial families in fermentations brined with CaCl₂ and NaCl coincided with a bloater index of 24.0 ± 10.3 to 58.8 ± 23.9. The prevalence of Lactobacillaceae in a cucumber fermentation brined with NaCl with a bloater index of 41.7 on day 5 suggests a contribution to bloater defect. This study identifies the utilization of sugars and malic acid by the cucumber indigenous Lactobacillaceae, Leuconostocaceae and Enterobacteriaceae as potential contributors to CO₂ production during cucumber fermentation and the consequent bloater defect.

The relationships between microbiota and the amino acids and organic acids in commercial vegetable pickle fermented in rice-bran beds

The microbial community during fermented vegetable production has a large impact on the quality of the final products. Lactic acid bacteria have been well-studied in such processes, but knowledge about the roles of non-lactic acid bacteria is limited. This study aimed to provide useful knowledge about the relationships between the microbiota, including non-lactic acid bacteria, and metabolites in commercial pickle production by investigating Japanese pickles fermented in rice-bran. The samples were provided by six manufacturers, divided into two groups depending on the production conditions. The microbiological content of these samples was investigated by high-throughput sequencing, and metabolites were assessed by liquid chromatography-mass spectrometry and enzymatic assay. The data suggest that Halomonas, halophilic Gram-negative bacteria, can increase glutamic acid content during the pickling process under selective conditions for bacterial growth. In contrast, in less selective conditions, the microbiota consumed glutamic acid. Our results indicate that the glutamic acid content in fermented pickle is influenced by the microbiota, rather than by externally added glutamic acid. Our data suggest that both lactic acid bacteria and non-lactic acid bacteria are positive key factors in the mechanism of commercial vegetable fermentation and affect the quality of pickles.

Genotypic and phenotypic diversity among Lactobacillus plantarum and Lactobacillus pentosus isolated from industrial scale cucumber fermentations

The Lactobacillus plantarum and Lactobacillus pentosus genotypes existing in industrial-scale cucumber fermentations were defined using rep-PCR-(GTG)5. The ability of each genotype to ferment cucumbers under various conditions was evaluated. Rep-PCR-(GTG)5 was the technique capable of illustrating the most intraspecies discrimination compared to the sequencing of housekeeping genes (recA, dnaK, pheS and rpoA), MLST and RAPD with primers LP1, OPL5, M14 and COC. Ten genotypic clusters were defined for the 199 L. pentosus tested and three for the 17 L. plantarum clones. The ability of the 216 clones genotyped and 37 additional cucumber fermentation isolates, of the same species, to rapidly decrease the pH of cucumber juice medium under various combinations of sodium chloride (0 or 6%), initial pH (4.0 or 5.2) and temperatures (15 or 30 °C) was determined using a fractional factorial screening design. A reduced fermentation ability was observed for the L. plantarum strains as compared to L. pentosus, except for clone 3.2.8, which had a ropy phenotype and aligned to genotypic cluster A. L. pentosus strains belonging to three genotypic clusters (B, D and J) were more efficient in cucumber juice fermentation as compared to most L. plantarum strains. This research identified three genetically diverse L. pentosus strains and one L. plantarum as candidates for starter cultures for commercial cucumber fermentations.

Characterization of robust Lactobacillus plantarum and Lactobacillus pentosus starter cultures for environmentally friendly low-salt cucumber fermentations

Seven candidates for starter cultures for cucumber fermentations belonging to the Lactobacillus pentosus and Lactobacillus plantarum species were characterized based on physiological features desired for pickling. The isolates presented variable carbohydrate utilization profile on API^® 50CHL test strips. The L. pentosus strains were unable to utilize d-xylose in MRS broth or the M medium. The lactobacilli were unable to produce histamine, tyramine, putrescine, and cadaverine in biogenic amine broth containing the necessary precursors. Production of d-lactic acid by the lactobacilli, detected enzymatically, was stimulated by growth in MRS broth as compared to cucumber juice medium (CJM). The lactobacilli utilized malic acid in the malate decarboxylase medium. Exopolyssacharide biosynthesis related genes were amplified from the lactobacilli. A sugar type-dependent-ropy phenotype was apparent for all the cultures tested in MRS and CJM. The genes associated with bacteriocin production were detected in the lactobacilli, but not the respective phenotypes. The antibiotic susceptibility profile of the lactobacilli mimics that of other L. plantarum starter cultures. It is concluded that the lactobacilli strains studied here are suitable starter cultures for cucumber fermentation. PRACTICAL APPLICATION: The availability of such starter cultures enables the implementation of low salt cucumber fermentations that can generate products with consistent biochemistry and microbiological profile.

Bacteriophages Infecting Gram-Negative Bacteria in a Commercial Cucumber Fermentation

Cucumber fermentations are one of the most important vegetable fermentations in the United States. The fermentation is usually driven by lactic acid bacteria (LAB) indigenous to fresh cucumbers. But LAB are greatly outnumbered by many Gram-negative bacteria on fresh cucumbers, which may influence the growth of LAB and the incidence of bloater defect (hollow cavities formed inside fermented cucumbers) leading to serious economic loss to the pickle industry. Rapid elimination of Gram-negative bacteria is crucial to the dominance of LAB and the reduction of bloater defect in the fermentation. Various factors can affect the viability of Gram-negative bacteria in cucumber fermentation. Bacteriophages (phages) may be one of such factors. This study explored the abundance, diversity, and functional role of phages infecting Gram-negative bacteria in a commercial cucumber fermentation. Cover brine samples were taken from a commercial fermentation tank over a 30-day period. On day 1 and day 3 of the fermentation, 39 Gram-negative bacteria and 26 independent phages were isolated. Nearly 67% of Gram-negative bacterial isolates were susceptible to phage infection. Phage hosts include Enterobacter, Citrobacter, Escherichia, Pantoea, Serratia, Leclercia, Providencia, and Pseudomonas species. About 88% of the isolated phages infected the members in the family Enterobacteriaceae and 58% of phages infected Enterobacter species. Eight phages with unique host ranges were characterized. These phages belong to the Myoviridae, Siphoviridae, or Podoviridae family and showed distinct protein profiles and DNA fingerprints. The infectivity of a phage against Enterobacter cancerogenus was evaluated in cucumber juice as a model system. The phage infection at the multiplicity of infection 1 or 100 resulted in a 5-log reduction in cell concentration within 3 h and rapidly eliminated its host. This study revealed the abundance and variety of phages infecting Gram-negative bacteria, particularly Enterobacteriaceae, in the commercial cucumber fermentation, suggesting that phages may play an important role in the elimination of Gram-negative bacteria, thereby facilitating the dominance of LAB and minimizing bloater defect. To our knowledge, this is the first report on the ecology of phages infecting Gram-negative bacteria in commercial cucumber fermentations.

Purification and biochemical characteristics of the extracellular protease from Pediococcus pentosaceus isolated from Harbin dry sausages

This study investigated the purification and biochemical characteristics of the protease produced by Pediococcus pentosaceus isolated from Harbin dry sausages. The optimized fermented conditions were as follows: fermentation time 36 h, initial pH 5 and fermentation temperature 30 °C. A 29.6 kDa extracellular protease was purified using ammonium sulphate deposition, ion exchange layer system and gel filtration. The protease produced by P. pentosaceus had a certain pH and thermal stability at pH 6 and 30 °C. The microbial protease activity could be inhibited by ethylene diamine tetraacetic acid disodium salt (EDTA). V_max and K_m of the protease were 43.9 mg/min and 8.3 mg/mL, respectively. Sodium dodecyl sulphate-polyacrylamide gel electrophoresis (SDS-PAGE) reflected the ability of the protease to hydrolyse sarcoplasmic and myofibrillar proteins, particularly those of myosin heavy chain, paramyosin, actin, phosphorylase and creatine kinase-M types. 3D structure modelling of the P. pentosaceus protease found two domains in the protease protein and the correlation of the active sites with protease properties and substrate specificity. In conclusion, P. pentosaceus can be used as a starter culture or enzyme producing strain for inoculation in Harbin dry sausages.

Purification and biochemical characteristics of the microbial extracellular protease from Lactobacillus curvatus isolated from Harbin dry sausages

This study investigates the purification and biochemical characteristics of the protease secreted by Lactobacillus curvatus R5, which was isolated from Harbin dry sausages. The optimized fermentation conditions were fermentation time 36 h, initial pH 6 and fermentation temperature 37 °C. An extracellular protease was purified using ammonium sulfate precipitation, ion-exchange layer and gel filtration. Sodium dodecyl sulphate-polyacrylamide gel electrophoresis (SDS-PAGE) analysis showed that molecular weight of the purified protease was 45.3 kDa. Protease produced by L. curvatus R5 reached a higher relative protease activity at pH 6, 40 °C, and the purified protease exhibited pH and thermal stability at pH 6 and 40 °C. The microbial protease activity can be inhibited by ethylene diamine tetraacetic acid disodium salt (EDTA). The V_max and K_m of the protease were 53 mg/min and 15.9 mg/mL, respectively. SDS-PAGE reflects the ability of the protease to hydrolyse myofibrillar protein and sarcoplasmic protein, especially on myosin heavy chain, actin, myosin light chain and phosphorylase. The 3D structure and the Ramachandran plot of L. curvatus R5 protease was obtained by homology modelling. The Ramachandran plot analysis revealed that the purified protease was composed of 366 amino acids, and its residues in favoured, allowed, generously allowed and disallowed regions were 84.6%, 11.3%, 3.2% and 0.9% residues, respectively. Molecular docking showed that the substrate actin bound to the protease active site by hydrogen bonding and hydrophobic interaction. This research provides a basis for understanding the enzymatic properties of L. curvatus R5 protease. In conclusion, L. curvatus R5 can be used as a starter culture or protease-producing strain to inoculate Harbin dry sausages.

Microbial Ecology of Fermented Vegetables and Non-Alcoholic Drinks and Current Knowledge on Their Impact on Human Health

Fermented foods are currently experiencing a re-discovery, largely driven by numerous health benefits claims. While fermented dairy, beer, and wine (and other alcoholic fermented beverages) have been the subject of intensive research, other plant-based fermented foods that are in some case widely consumed (kimchi/sauerkraut, pickles, kombucha) have received less scientific attention. In this chapter, the current knowledge on the microbiology and potential health benefits of such plant-based fermented foods are presented. Kimchi is the most studied, characterized by primarily acidic fermentation by lactic acid bacteria. Anti-obesity and anti-hypertension properties have been reported for kimchi and other pickled vegetables. Kombucha is the most popular non-alcoholic fermented drink. Kombucha's microbiology is remarkable as it involves all fermenters described in known fermented foods: lactic acid bacteria, acetic acid bacteria, fungi, and yeasts. While kombucha is often hyped as a "super-food," only antioxidant and antimicrobial properties toward foodborne pathogens are well established; and it is unknown if these properties incur beneficial impact, even in vitro or in animal models. The mode of action that has been studied and demonstrated the most is the probiotic one. However, it can be expected that fermentation metabolites may be prebiotic, or influence host health directly. To conclude, plant-based fermented foods and drinks are usually safe products; few negative reports can be found, but more research, especially human dietary intervention studies, are warranted to substantiate any health claim.

Carrot Juice Fermentations as Man-Made Microbial Ecosystems Dominated by Lactic Acid Bacteria

Spontaneous vegetable fermentations, with their rich flavors and postulated health benefits, are regaining popularity. However, their microbiology is still poorly understood, therefore raising concerns about food safety. In addition, such spontaneous fermentations form interesting cases of man-made microbial ecosystems. Here, samples from 38 carrot juice fermentations were collected through a citizen science initiative, in addition to three laboratory fermentations. Culturing showed that Enterobacteriaceae were outcompeted by lactic acid bacteria (LAB) between 3 and 13 days of fermentation. Metabolite-target analysis showed that lactic acid and mannitol were highly produced, as well as the biogenic amine cadaverine. High-throughput 16S rRNA gene sequencing revealed that mainly species of Leuconostoc and Lactobacillus (as identified by 8 and 20 amplicon sequence variants [ASVs], respectively) mediated the fermentations in subsequent order. The analyses at the DNA level still detected a high number of Enterobacteriaceae, but their relative abundance was low when RNA-based sequencing was performed to detect presumptive metabolically active bacterial cells. In addition, this method greatly reduced host read contamination. Phylogenetic placement indicated a high LAB diversity, with ASVs from nine different phylogenetic groups of the Lactobacillus genus complex. However, fermentation experiments with isolates showed that only strains belonging to the most prevalent phylogenetic groups preserved the fermentation dynamics. The carrot juice fermentation thus forms a robust man-made microbial ecosystem suitable for studies on LAB diversity and niche specificity.

IMPORTANCE The usage of fermented food products by professional chefs is steadily growing worldwide. Meanwhile, this interest has also increased at the household level. However, many of these artisanal food products remain understudied. Here, an extensive microbial analysis was performed of spontaneous fermented carrot juices which are used as nonalcoholic alternatives for wine in a Belgian Michelin star restaurant. Samples were collected through an active citizen science approach with 38 participants, in addition to three laboratory fermentations. Identification of the main microbial players revealed that mainly species of Leuconostoc and Lactobacillus mediated the fermentations in subsequent order. In addition, a high diversity of lactic acid bacteria was found; however, fermentation experiments with isolates showed that only strains belonging to the most prevalent lactic acid bacteria preserved the fermentation dynamics. Finally, this study showed that the usage of RNA-based 16S rRNA amplicon sequencing greatly reduces host read contamination.

Lactobacillus plantarum with Functional Properties: An Approach to Increase Safety and Shelf-Life of Fermented Foods

Lactobacillus plantarum (widespread member of the genus Lactobacillus) is one of the most studied species extensively used in food industry as probiotic microorganism and/or microbial starter. The exploitation of Lb. plantarum strains with their long history in food fermentation forms an emerging field and design of added-value foods. Lb. plantarum strains were also used to produce new functional (traditional/novel) foods and beverages with improved nutritional and technological features. Lb. plantarum strains were identified from many traditional foods and characterized for their systematics and molecular taxonomy, enzyme systems (α-amylase, esterase, lipase, α-glucosidase, β-glucosidase, enolase, phosphoketolase, lactase dehydrogenase, etc.), and bioactive compounds (bacteriocin, dipeptides, and other preservative compounds). This review emphasizes that the Lb. plantarum strains with their probiotic properties can have great effects against harmful microflora (foodborne pathogens) to increase safety and shelf-life of fermented foods.