1
|
Romero-Cedillo L, Poggi-Varaldo HM, Santoyo-Salazar J, Escamilla-Alvarado C, Matsumoto-Kuwabara Y, Ponce-Noyola MT, Bretón-Deval L, García-Rocha M. Biological synthesis of iron nanoparticles using hydrolysates from a waste-based biorefinery. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2020; 27:28649-28669. [PMID: 32347480 DOI: 10.1007/s11356-020-08729-w] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/28/2019] [Accepted: 04/02/2020] [Indexed: 06/11/2023]
Abstract
The purpose of this work was to produce iron nanoparticles (Fe-NP) by microbial pathway from anaerobic bacteria grown in anaerobic fluidized bed reactors (AnFBRs) that constitute a new stage of a waste-based biorefinery. Bioparticles from biological fluidized bed reactors from a biorefinery of organic fraction of municipal solid wastes (that produces hydrolysates rich in reducing sugars) were nanodecorated (embedded nanobioparticle or nanodecorated bioparticle, ENBP) by biological reduction of iron salts. Factors "origin of bioparticles" (either from hydrogenogenic or methanogenic fluidized bed reactor) and "type of iron precursor salt" (iron chloride or iron citrate) were explored. SEM and high-resolution transmission electron microscopy (HRTEM) showed amorphous distribution of nanoparticles (NP) on the bioparticles surface, although small structures that are nanoparticle-like could be seen in the SEM micrographs. Some agglomeration of NPs was confirmed by DLS. Average NP size was lower in general for NP in ENBP-M than ENBP-H according to HRTEM. The factors did not have a significant influence on the specific surface area of NPs, which was high and in the range 490 to 650 m2 g-1. Analysis by EDS displayed consistent iron concentration 60-65% iron in nanoparticles present in ENBP-M (bioparticles previously grown in methanogenic bioreactor), whereas the iron concentration in NPs present in ENBP-H (bioparticles previously grown in hydrogenogenic bioreactor) was more variable in a range from 8.5 to 62%, depending on the iron salt. X-ray diffraction patterns showed the typical peaks for magnetite at 35° (3 1 1), 43° (4 0 0), and 62° (4 0 0); moreover, siderite diffraction pattern was found at 26° (0 1 2), 38° (1 1 0), and 42° (1 1 3). Results of infrared analysis of ENBP in our work were congruent with presence of magnetite and occasionally siderite determined by XRD analysis as well as presence of both Fe+2 and F+3 (and selected satellite signal peaks) observed by XPS. Our results on the ENBPs hold promise for water treatment, since iron NPs are commonly used in wastewater technologies that treat a wide variety of pollutants. Finally, the biological production of ENBP coupled to a biorefinery could become an environmentally friendly platform for nanomaterial biosynthesis as well as an additional source of revenues for a waste-based biorefinery.
Collapse
Affiliation(s)
- Leticia Romero-Cedillo
- Programa de Doctorado en Nanociencias y Nanotecnología, CINVESTAV del IPN, P.O. Box 17-740, 07000, Mexico City, Mexico
- Environmental Biotechnology and Renewable Energies Group, CINVESTAV del IPN, P.O. Box 14-740, 07000, Mexico City, Mexico
| | - Héctor M Poggi-Varaldo
- Programa de Doctorado en Nanociencias y Nanotecnología, CINVESTAV del IPN, P.O. Box 17-740, 07000, Mexico City, Mexico.
- Environmental Biotechnology and Renewable Energies Group, CINVESTAV del IPN, P.O. Box 14-740, 07000, Mexico City, Mexico.
| | - Jaime Santoyo-Salazar
- Programa de Doctorado en Nanociencias y Nanotecnología, CINVESTAV del IPN, P.O. Box 17-740, 07000, Mexico City, Mexico
| | - Carlos Escamilla-Alvarado
- Centre for Research on Biotechnology and Nanotechnology (CIByN), Faculty of Chemical Sciences, Engineering and Sustainable Bioprocesses Group, UANL, Parque de Investigación e Innovación Tecnológica, km 10 Autopista al Aeropuerto Internacional Mariano Escobedo, 66629, Apodaca, Nuevo León, Mexico
| | - Yasuhiro Matsumoto-Kuwabara
- Programa de Doctorado en Nanociencias y Nanotecnología, CINVESTAV del IPN, P.O. Box 17-740, 07000, Mexico City, Mexico
| | - M Teresa Ponce-Noyola
- Departamento de Biotecnología y Bioingeniería, CINVESTAV del IPN, Mexico City, Mexico
| | - Luz Bretón-Deval
- Cátedras Conacyt - Instituto de Biotecnología, UNAM, Av. Universidad 2001, Chamilpa, 62210, Cuernavaca, Morelos, Mexico
| | - Miguel García-Rocha
- Programa de Doctorado en Nanociencias y Nanotecnología, CINVESTAV del IPN, P.O. Box 17-740, 07000, Mexico City, Mexico
| |
Collapse
|
2
|
Sotelo-Navarro PX, Poggi-Varaldo HM, Turpin-Marion SJ, Vázquez-Morillas A, Beltrán-Villavicencio M, Espinosa-Valdemar RM. Biohydrogen production from used diapers: Evaluation of effect of temperature and substrate conditioning. WASTE MANAGEMENT & RESEARCH : THE JOURNAL OF THE INTERNATIONAL SOLID WASTES AND PUBLIC CLEANSING ASSOCIATION, ISWA 2017; 35:267-275. [PMID: 28097956 DOI: 10.1177/0734242x16677334] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/06/2023]
Abstract
This research assessed the viability to use disposable diapers as a substrate for the production of biohydrogen, a valuable clean-energy source. The important content of cellulose of disposable diapers indicates that this waste could be an attractive substrate for biofuel production. Two incubation temperatures (35 °C and 55 °C) and three diaper conditioning methods (whole diapers with faeces, urine, and plastics, WD; diapers without plastic components, with urine and faeces, DWP; diapers with urine but without faeces and plastic, MSD) were tested in batch bioreactors. The bioreactors were operated in the solid substrate anaerobic hydrogenogenic fermentation with intermittent venting mode (SSAHF-IV). The batch reactors were loaded with the substrate at ca. 25% of total solids and 10% w/w inoculum. The average cumulative bioH2 production followed the order WD > MSD > DWP. The bio-H2 production using MSD was unexpectedly higher than DWP; the presence of plastics in the first was expected to be associated to lower degradability and H2 yield. BioH2 production at 55 °C was superior to that of 35 °C, probably owing to a more rapid microbial metabolism in the thermophilic regime. The results of this work showed low yields in the production of H2 at both temperatures compared with those reported in the literature for municipal and agricultural organic waste. The studied process could improve the ability to dispose of this residue with H2 generation as the value-added product. Research is ongoing to increase the yield of biohydrogen production from waste disposable diapers.
Collapse
Affiliation(s)
- P X Sotelo-Navarro
- 1 Department of Energy, Sustainable Technologies Laboratory, México City, Mexico
| | - H M Poggi-Varaldo
- 2 Department of Biotechnology and Bioengineering, CINVESTAV del IPN, México City, Mexico
| | - S J Turpin-Marion
- 1 Department of Energy, Sustainable Technologies Laboratory, México City, Mexico
| | - A Vázquez-Morillas
- 1 Department of Energy, Sustainable Technologies Laboratory, México City, Mexico
| | | | | |
Collapse
|
3
|
del Rio-Chanona EA, Dechatiwongse P, Zhang D, Maitland GC, Hellgardt K, Arellano-Garcia H, Vassiliadis VS. Optimal Operation Strategy for Biohydrogen Production. Ind Eng Chem Res 2015. [DOI: 10.1021/acs.iecr.5b00612] [Citation(s) in RCA: 25] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
Affiliation(s)
- Ehecatl Antonio del Rio-Chanona
- Department
of Chemical Engineering and Biotechnology, University of Cambridge, Pembroke Street, Cambridge CB2 3RA, United Kingdom
| | - Pongsathorn Dechatiwongse
- Department
of Chemical Engineering, Imperial College London, South Kensington Campus, London SW7 2AZ, United Kingdom
| | - Dongda Zhang
- Department
of Chemical Engineering and Biotechnology, University of Cambridge, Pembroke Street, Cambridge CB2 3RA, United Kingdom
| | - Geoffrey C. Maitland
- Department
of Chemical Engineering, Imperial College London, South Kensington Campus, London SW7 2AZ, United Kingdom
| | - Klaus Hellgardt
- Department
of Chemical Engineering, Imperial College London, South Kensington Campus, London SW7 2AZ, United Kingdom
| | - Harvey Arellano-Garcia
- School
of Engineering, University of Bradford, Richmond Road, Bradford, Yorkshire BD7
1DP, United Kingdom
| | - Vassilios S. Vassiliadis
- Department
of Chemical Engineering and Biotechnology, University of Cambridge, Pembroke Street, Cambridge CB2 3RA, United Kingdom
| |
Collapse
|
4
|
Barca C, Soric A, Ranava D, Giudici-Orticoni MT, Ferrasse JH. Anaerobic biofilm reactors for dark fermentative hydrogen production from wastewater: A review. BIORESOURCE TECHNOLOGY 2015; 185:386-398. [PMID: 25746594 DOI: 10.1016/j.biortech.2015.02.063] [Citation(s) in RCA: 17] [Impact Index Per Article: 1.9] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/19/2014] [Revised: 02/12/2015] [Accepted: 02/13/2015] [Indexed: 06/04/2023]
Abstract
Dark fermentation is a bioprocess driven by anaerobic bacteria that can produce hydrogen (H2) from organic waste and wastewater. This review analyses a relevant number of recent studies that have investigated dark fermentative H2 production from wastewater using two different types of anaerobic biofilm reactors: anaerobic packed bed reactor (APBR) and anaerobic fluidized bed reactor (AFBR). The effect of various parameters, including temperature, pH, carrier material, inoculum pretreatment, hydraulic retention time, substrate type and concentration, on reactor performances was investigated by a critical discussion of the results published in the literature. Also, this review presents an in-depth study on the influence of the main operating parameters on the metabolic pathways. The aim of this review is to provide to researchers and practitioners in the field of H2 production key elements for the best operation of the reactors. Finally, some perspectives and technical challenges to improve H2 production were proposed.
Collapse
Affiliation(s)
- Cristian Barca
- Aix-Marseille Université, Centrale Marseille, CNRS, M2P2 UMR 7340, Europôle de l'Arbois, 13545 Aix en Provence Cedex 4, France
| | - Audrey Soric
- Aix-Marseille Université, Centrale Marseille, CNRS, M2P2 UMR 7340, Europôle de l'Arbois, 13545 Aix en Provence Cedex 4, France; CNRS, Aix Marseille Université, BIP UMR 7281, 13009 Marseille, France.
| | - David Ranava
- CNRS, Aix Marseille Université, BIP UMR 7281, 13009 Marseille, France
| | | | - Jean-Henry Ferrasse
- Aix-Marseille Université, Centrale Marseille, CNRS, M2P2 UMR 7340, Europôle de l'Arbois, 13545 Aix en Provence Cedex 4, France
| |
Collapse
|