Chitosan-encapsulated niosomes for enhanced oral delivery of atorvastatin

Self-nanoemulsifying drug delivery system for nebulization: fabrication and evaluation for systemic delivery of atorvastatin

The study undertakes the development of an atorvastatin-loaded self-nanoemulsifying drug delivery system (SNEDDS) to improve its bioavailability. The SNEDDS were fabricated using oleic acid, Tween 80, and Span 80 by spontaneous emulsification. The SNEDDS were assessed for their particle size distribution, zeta potential, morphology, drug content, surface tension, viscosity, and drug release. The aerodynamic performance of the SNEDDS was evaluated using an Andersen cascade impactor, while the lipid-lowering potential of the SNEDDS was determined in Wistar rats using the analyzer "Microlab 300." The particle size of the SNEDDS ranged from 36 to 311 nm, with a polydispersity index (PDI) of 0.25-0.40. The zeta potential of the SNEDDS fluctuated from - 29.22 to - 38.26 mV, which declined to - 4.55 mV in the case of F5. The chitosan-coated formulation (F5) exhibited a higher viscosity (22.12 mPa s) and lower surface tension (0.056 dyne/cm) than other formulations (F1-F4). The non-coated formulation exhibited a significantly higher burst drug release, followed by a sustained drug release pattern (p ≤ 0.05) as compared to the coated formulation (F5). The nebulized SNEDDS achieved a dispersed fraction of 87 to 97%, where notably higher aerosol dispersion from F4 was attributed to its smaller particle size and circularity. The inhaled fraction of nebulized SNEDDS was 74-87%. The size of the SNEDDS droplets was the primary determinant affecting the aerodynamic performance of the SNEDDS during nebulization. The chitosan-coated SNEDDS achieved a higher antihyperlipidemic effect than marketed tablets, which shows the suitability of F5 for effective systemic delivery of atorvastatin through the lung.

Bilosomal Co-Encapsulated Tamoxifen and Propranolol for Potentiated Anti-Breast Cancer Efficacy: In Vitro and In Vivo Investigation

Background/Objectives: Tamoxifen (TAM) is an anti-breast cancer drug suffering from acquired resistance development, prompting cancer relapse. Propranolol (PRO)'s repurposing for cancer therapy has gained interest. This work aimed to investigate combined TAM/PRO therapy for potentiating the anti-breast cancer activity of TAM. The work probed bilosomes versus standard noisome for simultaneous oral and intratumor delivery of TAM and PRO. Methods: Bilosomes comprising Span60, cholesterol, and increasing concentrations of bile salts were prepared together with bile salts containing free standard niosomes. The vesicular size and morphology were characterized. The entrapment and release efficiencies of TAM and PRO from the tailored vesicles were determined. The in vivo investigations of anti-tumor activity of TAM with or without PRO employed the solid Ehrlich carcinoma model. Results: The vesicles of all fabricated dispersions were spherical and negatively charged, with a size ranging from 104 to 182 nm. The entrapment efficiency depended on the nature of the drug, recording values ranging from 87.5% to 97.8% for TAM and from 31.0% to 46.8% for PRO. Incorporation of bile salts into vesicles increased TAM and PRO release compared to standard niosomes. Oral administration of combined TAM/PRO bilosomes showed a significant reduction in tumor growth volume compared to that recorded following naked drug administration. Histopathological investigations reflected a significant decline in tumor giant cells and mitotic figures, implying the in vivo capability of the TAM/PRO combination to interfere with cancer cell proliferation and persistence. Conclusions: The overall results demonstrated the impact of repurposed PRO to enhance the anti-breast cancer activity of TAM when both were co-encapsulated into bilosomes.

Glyceroniosomes for enhanced intestinal absorption of hydrochlorothiazide and lisinopril in their fixed dose combination

The objective was to investigate the effect of co-administration of hydrochlorothiazide and lisinopril as fixed dose combination on their intestinal absorption. The scope was extended to enhance intestinal absorption of both drugs. In situ rabbit intestinal absorption through the duodenum and jejuno-ileum was used to monitor membrane permeability of both drugs when perfused alone or in combination. Niosomes containing glycerols (glyceroniosomes) were loaded with both drugs. Glyceroniosomes comprised Span 60 or Tween 40 in combination with cholesterol and glycerol were prepared by bath sonication. Glyceroniosomes were characterized with respect to vesicle size, drug entrapment efficiency and were examined using transmission electron microscope (TEM). The prepared vesicles were nanosized spherical vesicles with average size of 202.4 nm and 108.8 nm for span free and span containing glyceroniosomes, respectively. The recorded Zeta potential values suggested good stability of the prepared formulations. Intestinal absorption studies reflected incomplete absorption of hydrocholothiazide and lisinopril correlating with their categorization as class IV and III drugs, respectively. Co-perfusion of both drugs reduced the intestinal absorption of lisinopril. Simultaneous encapsulation in glyceroniosomes enhanced the intestinal absorption of both drugs. Tween based systems were more efficient. The study introduced glyceroniosomes as carriers of simultaneous delivery of hydrochlorothiazide and lisinopril.

Olive oil and flaxseed oil incorporating niosomes for enhanced in vivo anti-diabetic efficacy of canagliflozin

BACKGROUND

Canagliflozin (CFZ) is broadly implicated for the management of type 2 diabetes mellitus. Unfortunately, it has low oral bioavailability due to poor solubility behavior and restricted membrane permeability.

OBJECTIVE

The current work focuses on development of CFZ encapsulated niosomes for enhanced oral anti-diabetic efficacy.

METHODOLOGY

Niosomes comprising Span 60 and cholesterol were formulated both in absence and presence of olive oil or flaxseed oil. These were evaluated in vitro for average vesicular size, structural morphology, CFZ entrapment efficiency, and drug release. Additionally, the oral hypoglycemic effect of CFZ encapsulated niosomes was explored in diabetic rats.

RESULTS

The fabricated niosomes were negatively charged spherical vesicles with a size range of 103.0-141.7 nm. These entrapped CFZ with efficiency ranging from 92.3% to 96.0%. Drug release investigations reflected that incorporating CFZ into niosomes significantly sustained drug release compared to the aqueous drug dispersion. Oral administration of niosomal formulations significantly enhanced the oral antidiabetic effect of CFZ. Comparing the tested niosomes, similar efficiency was shown eliminating the effect of composition.

CONCLUSION

The enhanced oral bioavailability of niosomes' encapsulated drugs is related to niosomal vesicular structure which allows intact niosomes absorption. The study presented niosomes as promising carriers for improved oral anti-diabetic activity of CFZ.

Desosomes and desimicelles - a novel vesicular and micellar system for enhanced oral delivery of poorly soluble drug: Optimization of in vitro characteristics and in vivo performance

This study introduces two innovative nanocarrier systems to improve oral drug delivery. Desosomes and desimicelles combine Deep eutectic solvent (DES) with vesicular or micellar nanosystems, respectively. These novel nanosystems integrate the DES solubilization potency for administering drugs with low aqueous solubility and the vesicular and micellar systems to bypass physiological barriers and improve poor drug bioavailability. Lornoxicam (LRX) is a BCS class II anti-inflammatory with limited aqueous solubility and rapid clearance. Desosomes and desimicelles were prepared and successfully optimized. The optimization depended on particle size, zetapotential, entrapment efficiency, and solubility. The optimized desosomes (LRX-DES-V) and desimicelles (LRX-DES-M) were pictured by transmission electron microscope. Differential scanning calorimetry (DSC) and FTIR analysis indicated the successful inclusion of LRX inside each system. Invitro LRX release profiles revealed controlled release of LRX-DES-V and LRX-DES-M, with more sustained release by the later one. In-vivo study, inflammation was induced using a carrageenan rat model, and the anti-inflammatory effect of LRX-pure, marketed product, traditional niosomes, LRX-DES-V & LRX-DES-M were determined using inhibition %, serum inflammatory cytokines, and histopathology. After 4 h of induction, LRX-DES-M (68.05%) showed a significant inhibition compared to LRX-DES-V (63.57%). LRX-DES-M also showed a better reduction in COX2, PGE2, and TNF-α (1.25-fold, 1.24-fold, and 1.36-fold inhibition), respectively, compared to LRX-DES-V. We can conclude that LRX-DES-V and LRX-DES-M showed better effects than all other groups and that LRX-DES-M might be more effective than LRX-DES-V.

Surface entrenched β-sitosterol niosomes for enhanced cardioprotective activity against isoproterenol induced cardiotoxicity in rats

Cardiotoxicity (CT) is a severe condition that negatively impacts heart function. β-sitosterol (BS) is a group of phytosterols and known for various pharmacological benefits, such as managing diabetes, cardiac protection, and neuroprotection. This study aims to develop niosomes (NS) containing BS, utilizing cholesterol as the lipid and Tween 80 as the stabilizer. The research focuses on designing and evaluating both conventional BS-NS and hyaluronic acid (HA) modified NS (BS-HA-NS) to enhance the specificity and efficacy of BS within cardiac tissue. The resulting niosomal formulation was spherical, with a size of about 158.51 ± 0.57 nm, an entrapment efficiency of 93.56 ± 1.48 %, and a drug loading of 8.07 ± 1.62 %. To evaluate cytotoxicity on H9c2 heart cells, the MTT assay was used. The cellular uptake of BS-NS and BS-HA-NS was confirmed by confocal microscopy on H9c2 cardiac cells. Administering BS-NS and BS-HA-NS intravenously at a dose of 10 mg/kg showed the ability to significantly decrease the levels of cardiac troponin-I (cTn-I), creatine kinase-MB (CK-MB), lactate dehydrogenase (LDH), aspartate aminotransferase (AST), and lipid peroxidation (MDA). Tissue histopathology indicated a substantial potential for repairing cardiac tissue after treatment with BS-NS and BS-HA-NS and strong cardioprotection against ISO induced myocardial tissue damages. Thus, enhancing BS's therapeutic effectiveness through niosome surface modification holds promise for mitigating cardiac damage resulting from CT.

Niosomal formulation of mefenamic acid for enhanced cancer targeting; preparation, characterization and biodistribution study using radiolabeling technique

BACKGROUND

This work aimed to prepare niosomal formulations of an anticancer agent [mefenamic acid (MEF)] to enhance its cancer targeting. 131I was utilized as a radiolabeling isotope to study the radio-kinetics of MEF niosomes.

METHODS

niosomal formulations were prepared by the ether injection method and assessed for entrapment efficiency (EE%), zeta potential (ZP), polydispersity index (PDI) and particle size (PS). MEF was labeled with 131I by direct electrophilic substitution reaction through optimization of radiolabeling-related parameters. In the radio-kinetic study, the optimal 131I-MEF niosomal formula was administered intravenously (I.V.) to solid tumor-bearing mice and compared to I.V. 131I-MEF solution as a control.

RESULTS

the average PS and ZP values of the optimal formulation were 247.23 ± 2.32 nm and - 28.3 ± 1.21, respectively. The highest 131I-MEF labeling yield was 98.7 ± 0.8%. The biodistribution study revealed that the highest tumor uptake of 131I-MEF niosomal formula and 131I-MEF solution at 60 min post-injection were 2.73 and 1.94% ID/g, respectively.

CONCLUSION

MEF-loaded niosomes could be a hopeful candidate in cancer treatment due to their potent tumor uptake. Such high targeting was attributed to passive targeting of the nanosized niosomes and confirmed by radiokinetic evaluation.

Chitosan-Coated Niosomes Loaded with Ellagic Acid Present Antiaging Activity in a Skin Cell Line

The polyphenol compound ellagic acid (EA) extracted from pomegranate has potential bioactivity against different types of chronic diseases. Skin aging is a long-term physiological process caused by many environmental factors, the most important of which is exposure to sun ultraviolet (UV) radiation. UV-induced chronic photodamage of the skin results in extrinsic aging. This study aimed to evaluate the photoprotective effects of EA on the human fibroblast skin cell line HFB4 and investigate its capacity to protect collagen from UV-induced deterioration. EA was encapsulated into chitosan-coated niosomes to reduce the skin aging effect of UV radiation in vitro. The tested formulations (niosomes loaded with EA and chitosan-coated niosomes loaded with EA) were characterized using transmission electron microscopy, dynamic light scattering, and scanning electron microscopy. Furthermore, the in vitro release of EA was determined. The HFB4 cell line samples were split into five groups: control, UV, UV-EA, UV-NIO-EA, and UV-CS-NIO-EA. UV irradiation was applied to the cell line groups via a UV-emitting lamp for 1 h, and then cell viability was measured for each group. The expression of genes implicated in skin aging (Co1A1, TERT, Timp3, and MMP3) was also assessed to quantify the impact of the loaded EA. The findings showed that EA-loaded chitosan-coated niosomes improved cell survival, upregulated Col1A1, TERT, and Timp3 genes, and downregulated MMP3. Thus, nanoparticles encapsulating EA are potent antioxidants that can preserve collagen levels and slow down the aging process in human skin.

Tumor microenvironment penetrating chitosan nanoparticles for elimination of cancer relapse and minimal residual disease

Chitosan and its derivatives are among biomaterials with numerous medical applications, especially in cancer. Chitosan is amenable to forming innumerable shapes such as micelles, niosomes, hydrogels, nanoparticles, and scaffolds, among others. Chitosan derivatives can also bring unprecedented potential to cross numerous biological barriers. Combined with other biomaterials, hybrid and multitasking chitosan-based systems can be realized for many applications. These include controlled drug release, targeted drug delivery, post-surgery implants (immunovaccines), theranostics, biosensing of tumor-derived circulating materials, multimodal systems, and combination therapy platforms with the potential to eliminate bulk tumors as well as lingering tumor cells to treat minimal residual disease (MRD) and recurrent cancer. We first introduce different formats, derivatives, and properties of chitosan. Next, given the barriers to therapeutic efficacy in solid tumors, we review advanced formulations of chitosan modules as efficient drug delivery systems to overcome tumor heterogeneity, multi-drug resistance, MRD, and metastasis. Finally, we discuss chitosan NPs for clinical translation and treatment of recurrent cancer and their future perspective.

Novel Mucoadhesive Chitosomes as a Platform for Enhanced Oral Bioavailability of Cinnarizine

PURPOSE

Cinnarizine (CIN) is a class II BSC drug, suffering from erratic bioavailability due to its pH-dependent solubility. It has preferential absorption in the stomach. In this study, new chitosan (CS) coated niosomes of CIN (CIN-loaded chitosomes) have been developed to extend the gastric retention and ameliorate CIN oral bioavailability.

METHODS

Various CIN-loaded niosomes were fabricated by thin-film hydration technique and fully characterized. Based on the predetermined criteria of low particle size (PS) and high entrapment efficiency percent (EE%), niosomal formulation F1 was selected and further coated with different CS concentrations. The optimized chitosomal formulation (C2) was evaluated through solid state characterization and mucoadhesive efficiency testing. It was also subjected to cytotoxicity study on Caco-2 cells; besides, in vitro drug release, stability and pharmacokinetic studies were assessed.

RESULTS

The optimized chitosomal formulation (C2) exhibited an EE% of 58.30±2.75%, PS of 440 ±13.03 nm, PDI of 0.335±0.21 and ZP of +28.1±0.10 mv. Solid state characterization results revealed the compatibility between the vesicle components and the entrapment of CIN within niosomal vesicles. C2 formulation demonstrated favorable mucoadhesive efficiency. The cytotoxicity study on Caco-2 cells manifested the safety of the optimized chitosomal formulation (C2) over the free drug. Additionally, it displayed a remarkable sustaining of CIN in vitro release up to 8 h and exhibited a good stability at the refrigerated temperature up to 3 months. In vivo pharmacokinetic assessment revealed that the CIN bioavailability from the optimized chitosomal formulation C2 was enhanced by 2.79 and 1.92 folds compared to the free drug and uncoated niosomal formulation F1, respectively. The priority of the chitosomal formulation (C2) over the niosomal one (F1) was also conferred.

CONCLUSION

Novel formulation of chitosan coated niosomes (chitosomes) could be presented as a promising platform to improve the oral bioavailability of drugs with narrow absorption window.

Menthol augmented niosomes for enhanced intestinal absorption of lopinavir

Lopinavir is effective in treatment of HIV infection but experiences low oral bioavailability due to poor solubility, pre-systemic metabolism, and P-gp intestinal efflux. Co-processing with menthol enhanced its dissolution and intestinal permeability. Niosomes comprising Span 60, cholesterol and poloxamer 407 were formulated in absence and presence of menthol. These were evaluated for size, morphology, entrapment efficiency (EE%), lopinavir release and intestinal absorption. The later employed in situ rabbit intestinal absorption model. Niosomes were spherical with vesicle size of 140.2 ± 23 and 148.2 ± 27nm for standard and menthol containing niosomes, respectively. The EE% values were 94.4% and 96.3% for both formulations, respectively. Niosomes underwent slow release during the time course of absorption with menthol hastening lopinavir release, but the release did not exceed 9%. Niosmoal encapsulation enhanced lopinavir intestinal absorption compared with drug solution. This was reflected from the fraction absorbed from duodenum which was 24.15%, 73.09% and 83.23% for solution, standard niosomes and menthol containing vesicles, respectively. These values were 34.32%, 80.8% and 86.56% for the same formulations in case of jejuno-ileum. Lopinavir absorption from niosomes didn't depend on release supporting intact vesicle absorption. The study introduced menthol containing niosomes as carriers for enhanced lopinavir intestinal absorption.

Advanced Drug Delivery Micro- and Nanosystems for Cardiovascular Diseases

Advanced drug delivery micro- and nanosystems have been widely explored due to their appealing specificity/selectivity, biodegradability, biocompatibility, and low toxicity. They can be applied for the targeted delivery of pharmaceuticals, with the benefits of good biocompatibility/stability, non-immunogenicity, large surface area, high drug loading capacity, and low leakage of drugs. Cardiovascular diseases, as one of the primary mortalities cause worldwide with significant impacts on the quality of patients’ life, comprise a variety of heart and circulatory system pathologies, such as peripheral vascular diseases, myocardial infarction, heart failure, and coronary artery diseases. Designing novel micro- and nanosystems with suitable targeting properties and smart release behaviors can help circumvent crucial challenges of the tolerability, low stability, high toxicity, and possible side- and off-target effects of conventional drug delivery routes. To overcome different challenging issues, namely physiological barriers, low efficiency of drugs, and possible adverse side effects, various biomaterials-mediated drug delivery systems have been formulated with reduced toxicity, improved pharmacokinetics, high bioavailability, sustained release behavior, and enhanced therapeutic efficacy for targeted therapy of cardiovascular diseases. Despite the existing drug delivery systems encompassing a variety of biomaterials for treating cardiovascular diseases, the number of formulations currently approved for clinical use is limited due to the regulatory and experimental obstacles. Herein, the most recent advancements in drug delivery micro- and nanosystems designed from different biomaterials for the treatment of cardiovascular diseases are deliberated, with a focus on the important challenges and future perspectives.

Sustained transdermal delivery of human growth hormone from niosomal gel: in vitro and in vivo studies

Human growth hormone (hGH) is widely used to treat several diseases for decades. However, the current treatment regime requires frequent injections via subcutaneous route due to short in vivo half-life, which leads to pain and poor patient compliance. In this study, a novel transdermal (non-invasive) hGH loaded niosomes gel was prepared to reduce the frequency of subcutaneous injections and to improve the patient compliance. Niosomes were prepared by film hydration technique at three levels of cholesterol. The particle size and entrapment efficiency increases with an increase in the level of cholesterol. Transmission electron microscopy images confirmed the spherical shape of niosomes without aggregation. Texture profiles analysis indicates that the niosomal gel has the required mechanical properties for transdermal application. The ex vivo permeation profile showed sustain hGH release for 4 days from the niosomal gel compared to 24 h from the control gel without niosomes. A rabbit skin irritation study showed no sign of irritation after application of niosomal gel. The pharmacokinetic parameters in the rat model showed 7.22-fold higher bioavailability with niosomal gel compared to control gel. In conclusion, the study demonstrated the potential of niosomal gel as an effective long-term sustained release strategy for hGH delivery to replace traditional subcutaneous injections.