1
|
Achuoth MP, Mudalungu CM, Ochieng BO, Mokaya HO, Kibet S, Maharaj VJ, Subramanian S, Kelemu S, Tanga CM. Unlocking the Potential of Substrate Quality for the Enhanced Antibacterial Activity of Black Soldier Fly against Pathogens. ACS OMEGA 2024; 9:8478-8489. [PMID: 38405442 PMCID: PMC10882654 DOI: 10.1021/acsomega.3c09741] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 12/06/2023] [Revised: 01/15/2024] [Accepted: 01/30/2024] [Indexed: 02/27/2024]
Abstract
Globally, antibiotics are facing fierce resistance from multidrug-resistant bacterial strains. There is an urgent need for eco-friendly alternatives. Though insects are important targets for antimicrobial peptides, it has received limited research attention. This study investigated the impact of waste substrates on the production of antibacterial agents in black soldier fly (Hermetia illucens L.) larvae (HIL) and their implications in the suppression of pathogens [Bacillus subtilis (ATCC 6051), Staphylococcus aureus (ATCC 25923), Pseudomonas aeruginosa (ATCC 27853), and Escherichia coli (ATCC 25922)]. The 20% acetic acid (AcOH) extract from market waste had the highest antibacterial activity with an inhibition zone of 17.00 mm, followed by potato waste (15.02 mm) against S. aureus. Hexane extract from HIL raised on market waste also showed a significant inhibitory zone (13.06 mm) against B. subtilis. .Minimum inhibitory concentration (MIC) values recorded were 25 mg/mL against all test pathogens. The fastest time-kill of 20% AcOH extract was 4 h againstB. subtilis, E. coli, ,andP. aeruginosa. Lauric acid was also identified as the dominant component of the various hexane extracts with concentrations of 602.76 and 318.17 μg/g in HIL reared on potato and market waste, respectively. Energy from the market waste substrate correlated significantly (r = 0.97) with antibacterial activities. This study highlights the key role of substrate quality and extraction methods for enhancing the production of antibacterial agents in HIL, thus providing new insights into the development of potential drugs to overcome the alarming concerns of antimicrobial resistance.
Collapse
Affiliation(s)
- Mach P. Achuoth
- International
Centre of Insects Physiology and Ecology, P.O. Box 30772-00100 Nairobi, Kenya
- Biodiscovery
Center, Department of Chemistry, Faculty of Natural and Agricultural
Sciences, University of Pretoria, Private Bag X20, Hatfield 0028, South Africa
- Department
of Chemistry, College of Science and Technology, Dr John Garang Memorial University of Science and Technology-Bor, P.O. Box 436 Juba, South Sudan
| | - Cynthia M. Mudalungu
- International
Centre of Insects Physiology and Ecology, P.O. Box 30772-00100 Nairobi, Kenya
- School
of Chemistry and Material Science, The Technical
University of Kenya (TUK), P.O. Box 52428-00100 Nairobi, Kenya
| | - Brian O. Ochieng
- International
Centre of Insects Physiology and Ecology, P.O. Box 30772-00100 Nairobi, Kenya
| | - Hosea O. Mokaya
- International
Centre of Insects Physiology and Ecology, P.O. Box 30772-00100 Nairobi, Kenya
| | - Shadrack Kibet
- International
Centre of Insects Physiology and Ecology, P.O. Box 30772-00100 Nairobi, Kenya
| | - Vinesh J. Maharaj
- Biodiscovery
Center, Department of Chemistry, Faculty of Natural and Agricultural
Sciences, University of Pretoria, Private Bag X20, Hatfield 0028, South Africa
| | - Sevgan Subramanian
- International
Centre of Insects Physiology and Ecology, P.O. Box 30772-00100 Nairobi, Kenya
| | - Segenet Kelemu
- International
Centre of Insects Physiology and Ecology, P.O. Box 30772-00100 Nairobi, Kenya
| | - Chrysantus M. Tanga
- International
Centre of Insects Physiology and Ecology, P.O. Box 30772-00100 Nairobi, Kenya
| |
Collapse
|
2
|
Li T, Khan S, Wei M, Li H, Wen T, Guo J, Jin D. Utilizing Black Soldier Fly Larvae to Improve Bioconversion and Reduce Pollution: A Sustainable Method for Efficient Treatment of Mixed Wastes of Wet Distiller Grains and Livestock Manure. Molecules 2023; 28:5735. [PMID: 37570704 PMCID: PMC10421123 DOI: 10.3390/molecules28155735] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/05/2023] [Revised: 07/25/2023] [Accepted: 07/27/2023] [Indexed: 08/13/2023] Open
Abstract
Widespread environmental contamination caused by huge amounts of wastes generated by human activities has become a critical global concern that requires urgent action. The black soldier fly (BSFL) has gradually been used to treat different wastes due to high efficiency and low cost. However, little information is available regarding the treatment of mixed wastes by BSFLs. The impact of BSFLs on conversion of cow manure (COM) and pig manure (PM) via the incorporation of wet distiller grains (WDG) was assessed. Results demonstrate that the waste reduction rate was increased by 20% by incorporating 45% WDG to COM and PM. The bioconversion rate of BSFLs in COM and PM also increased from 1.20 ± 0.02% and 0.92 ± 0.02% to 10.54 ± 0.06% and 10.05 ± 0.11%, respectively. Total nitrogen content and δ15N/14N ratios of WDG + COM and WDG + PM were found to be significantly lower than those of COM and PM alone (p < 0.01). The organic matter changes during manure degradation were further analyzed by combing ultraviolet-visible spectrum (UV-vis) with excitation-emission matrix (EEM) spectroscopy techniques and fluorescence area integration (FRI) method. The UV-vis spectra results indicate that the addition of WDG to manures resulted in the decreased aromaticity and molecular weight of the waste. EEM spectra demonstrated that the accumulative Pi,n values of regions III and V in COM, COM + WDG, PM, and PM + WDG were 58%, 49%, 52% and 63%, respectively. These results not only provide new insights into the potential of mixed wastes for BSFL treatment but also contribute to the basis for the formulation of effective management measurements that reduce and/or reuse these wastes.
Collapse
Affiliation(s)
- Tao Li
- Institute of Entomology, Guizhou University, Guiyang 550025, China; (T.L.); (S.K.); (M.W.); (H.L.)
- Scientific Observing and Experimental Station of Crop Pest in Guiyang, Ministry of Agriculture and Rural Affairs, Guiyang 550025, China
| | - Samiullah Khan
- Institute of Entomology, Guizhou University, Guiyang 550025, China; (T.L.); (S.K.); (M.W.); (H.L.)
- Scientific Observing and Experimental Station of Crop Pest in Guiyang, Ministry of Agriculture and Rural Affairs, Guiyang 550025, China
| | - Mao Wei
- Institute of Entomology, Guizhou University, Guiyang 550025, China; (T.L.); (S.K.); (M.W.); (H.L.)
- Scientific Observing and Experimental Station of Crop Pest in Guiyang, Ministry of Agriculture and Rural Affairs, Guiyang 550025, China
| | - Haiyin Li
- Institute of Entomology, Guizhou University, Guiyang 550025, China; (T.L.); (S.K.); (M.W.); (H.L.)
- Scientific Observing and Experimental Station of Crop Pest in Guiyang, Ministry of Agriculture and Rural Affairs, Guiyang 550025, China
| | - Tingchi Wen
- State Key Laboratory Breeding Base of Green Pesticide and Agricultural Bioengineering, Key Laboratory of Green Pesticide and Agricultural Bioengineering, Ministry of Education, Guizhou University, Guiyang 550025, China;
| | - Jianjun Guo
- Institute of Entomology, Guizhou University, Guiyang 550025, China; (T.L.); (S.K.); (M.W.); (H.L.)
- Scientific Observing and Experimental Station of Crop Pest in Guiyang, Ministry of Agriculture and Rural Affairs, Guiyang 550025, China
| | - Daochao Jin
- Institute of Entomology, Guizhou University, Guiyang 550025, China; (T.L.); (S.K.); (M.W.); (H.L.)
- Scientific Observing and Experimental Station of Crop Pest in Guiyang, Ministry of Agriculture and Rural Affairs, Guiyang 550025, China
| |
Collapse
|
3
|
Liew CS, Mong GR, Lim JW, Raksasat R, Rawindran H, Hassan MA, Lam MK, Khoo KS, Zango ZU. Low-temperature thermal pre-treated sewage sludge for feeding of black soldier fly (Hermetia illucens) larvae: Protein, lipid and biodiesel profile and characterization. RENEWABLE AND SUSTAINABLE ENERGY REVIEWS 2023; 178:113241. [DOI: 10.1016/j.rser.2023.113241] [Citation(s) in RCA: 3] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/30/2023]
|
4
|
Grossule V, Zanatta S, Modesti M, Lavagnolo MC. Treatment of food waste contaminated by bioplastics using BSF larvae: Impact and fate of starch-based bioplastic films. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2023; 330:117229. [PMID: 36621322 DOI: 10.1016/j.jenvman.2023.117229] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/21/2022] [Revised: 12/22/2022] [Accepted: 01/03/2023] [Indexed: 06/17/2023]
Abstract
The use of Black Soldier Fly (BSF) larvae in the treatment of biowaste, including food waste, represents a promising new (waste) treatment option. In line with an increasing use of starch-based bioplastics in food packaging, (e.g. shopper films), food waste contamination by these polymers is expected to rise, but the fate of these materials and impact produced on the BSF treatment process remain to be clarified. In the present study, food waste contaminated by starch-based bioplastic film was treated using a BSF larvae process with the aim of investigating both the effect of bioplastics on process performance and the effect of BSF larvae on bioplastic degradation. Larvae treatment performance was assessed by monitoring substrate degradation process and larvae growth in terms of weight variation and development time. Bioplastic degradation (both in the larvae process and in a larvae-free control test) was assessed by means of visual inspection, Scanning Electron Microscopy (SEM), Fourier Transform InfraRed spectroscopy (FTIR), Differential Scanning Calorimetry (DSC) and ThermoGravimetric Analysis (TGA). The results obtained highlighted the absence of negative impacts of bioplastics on the BSF process, revealing a modestly higher degree of degradation in the larvae process compared to control test. The process however failed to achieve complete degradation of bioplastics, suggesting the need for additional post-processing treatments.
Collapse
Affiliation(s)
- Valentina Grossule
- DICEA, Department of Civil, Architectural and Environmental Engineering, University of Padova. Via Marzolo 9, 35131, Padova, Italy.
| | - Silvia Zanatta
- DII, Department of Industrial Engineering, University of Padova. Via Gradenigo 6, 35131, Padova, Italy
| | - Michele Modesti
- DII, Department of Industrial Engineering, University of Padova. Via Gradenigo 6, 35131, Padova, Italy
| | - Maria Cristina Lavagnolo
- DICEA, Department of Civil, Architectural and Environmental Engineering, University of Padova. Via Marzolo 9, 35131, Padova, Italy
| |
Collapse
|
5
|
Rehman KU, Hollah C, Wiesotzki K, Rehman RU, Rehman AU, Zhang J, Zheng L, Nienaber T, Heinz V, Aganovic K. Black soldier fly, Hermetia illucens as a potential innovative and environmentally friendly tool for organic waste management: A mini-review. WASTE MANAGEMENT & RESEARCH : THE JOURNAL OF THE INTERNATIONAL SOLID WASTES AND PUBLIC CLEANSING ASSOCIATION, ISWA 2023; 41:81-97. [PMID: 35730793 PMCID: PMC9925914 DOI: 10.1177/0734242x221105441] [Citation(s) in RCA: 24] [Impact Index Per Article: 24.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/13/2021] [Indexed: 05/24/2023]
Abstract
The application of black soldier fly (BSF), Hermetia illucens based technology to process organic wastes presents a practical option for organic waste management by producing feed materials (protein, fat), biodiesel, chitin and biofertilizer. Therefore, BSF organic wastes recycling is a sustainable and cost-effective process that promotes resource recovery, and generates valuable products, thereby creating new economic opportunities for the industrial sector and entrepreneurs. Specifically, we discussed the significance of BSF larvae (BSFL) in the recycling of biowaste. Despite the fact that BSFL may consume a variety of wastes materials, whereas, certain lignocellulosic wastes, such as dairy manure, are deficient in nutrients, which might slow BSFL development. The nutritional value of larval feeding substrates may be improved by mixing in nutrient-rich substrates like chicken manure or soybean curd residue, for instance. Similarly, microbial fermentation may be used to digest lignocellulosic waste, releasing nutrients that are needed for the BSFL. In this mini-review, a thorough discussion has been conducted on the various waste biodegraded by the BSFL, their co-digestion and microbial fermentation of BSFL substrate, as well as the prospective applications and safety of the possible by-products that may be generated at the completion of the treatment process. Furthermore, this study examines the present gaps and challenges on the direction to the efficient application of BSF for waste management and the commercialization of its by-products.
Collapse
Affiliation(s)
- Kashif ur Rehman
- Department of Microbiology,
Faculty of Veterinary and Animal Sciences, Th Islamia University of
Bahawalpur, Pakistan
- Poultry Research Institute
Rawalpindi, Livestock and Dairy Development Department, Punjab,
Pakistan
- State Key Laboratory of
Agricultural Microbiology, National Engineering Research Center of Microbial
Pesticides, College of Life Science and Technology, Huazhong Agricultural
University, Wuhan, PR China
| | - Clemens Hollah
- DIL Deutsches Institut für
Lebensmitteltechnik e. V. – German Institute of Food Technologies,
Quakenbruck, Germany
| | - Karin Wiesotzki
- DIL Deutsches Institut für
Lebensmitteltechnik e. V. – German Institute of Food Technologies,
Quakenbruck, Germany
| | - Rashid ur Rehman
- Khwaja Fareed University of
Engineering and Information Technology, Rahim Yar Khan, Pakistan
| | | | - Jibin Zhang
- State Key Laboratory of
Agricultural Microbiology, National Engineering Research Center of Microbial
Pesticides, College of Life Science and Technology, Huazhong Agricultural
University, Wuhan, PR China
| | - Longyu Zheng
- State Key Laboratory of
Agricultural Microbiology, National Engineering Research Center of Microbial
Pesticides, College of Life Science and Technology, Huazhong Agricultural
University, Wuhan, PR China
| | - Theresa Nienaber
- DIL Deutsches Institut für
Lebensmitteltechnik e. V. – German Institute of Food Technologies,
Quakenbruck, Germany
| | - Volker Heinz
- DIL Deutsches Institut für
Lebensmitteltechnik e. V. – German Institute of Food Technologies,
Quakenbruck, Germany
| | - Kemal Aganovic
- DIL Deutsches Institut für
Lebensmitteltechnik e. V. – German Institute of Food Technologies,
Quakenbruck, Germany
| |
Collapse
|
6
|
Grossule V, Fang D, Yue D, Lavagnolo MC. Treatment of wastewater using black soldier fly larvae, under different degrees of biodegradability and oxidation of organic content. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2022; 319:115734. [PMID: 35982556 DOI: 10.1016/j.jenvman.2022.115734] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/03/2022] [Revised: 07/05/2022] [Accepted: 07/09/2022] [Indexed: 06/15/2023]
Abstract
The biological treatment process based on the metabolism of Black Soldier Fly (BSF) larvae proved to be a highly promising technique for the treatment of high organic content (HOC) wastewater, such as sewage from food industries, leachate from municipal solid waste (MSW) landfill, etc. The present study was aimed at achieving a better understanding of how biodegradability and degree of oxidation of organic content might influence treatment performance and biomass quality. Six leachates characterised by similar COD (Chemical Oxygen Demand) but different BOD5/COD (Biochemical Oxygen demand/COD) and TOC/COD (Total Organic Carbon/COD) ratios were tested. By combining these ratios, the BOD5/TOC ratio was introduced to take into account the effect of both leachate properties (biodegradability and oxidation degree). Process treatment performance was significantly influenced by the quality of organic substances. Higher BOD5/TOC values (higher biodegradability and lower oxidation degree) resulted in a greater and faster larvae growth, with final wet weight of between 49.2 and 91.9mg/larva; lower mortality between 5 and 32%; higher prepupation percentages ranging from 4 to 21% and higher specific substrate consumption rate with values varying from 0.051 to 0.063 mgTOC/mg larva/d, up to 3-fold higher than values obtained using conventional activated sludge based on COD consumption. Conversely, no significant differences were detected in larvae protein and lipid contents, including the profiling of fatty acids.
Collapse
Affiliation(s)
- Valentina Grossule
- DICEA, Department of Civil, Architectural and Environmental Engineering, University of Padova, Via Marzolo 9, 35131, Padova, Italy.
| | - Ding Fang
- School of Environment, Tsinghua University, Beijing, 100084, PR China
| | - Dongbei Yue
- School of Environment, Tsinghua University, Beijing, 100084, PR China
| | - Maria Cristina Lavagnolo
- DICEA, Department of Civil, Architectural and Environmental Engineering, University of Padova, Via Marzolo 9, 35131, Padova, Italy
| |
Collapse
|
7
|
Lumanlan JC, Williams M, Jayasena V. Edible Insects: Environmentally Friendly Sustainable Future Food Source. Int J Food Sci Technol 2022. [DOI: 10.1111/ijfs.16006] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/30/2022]
Affiliation(s)
| | - Mark Williams
- School of Science, Western Sydney University, Bourke St Richmond NSW 2753
| | - Vijay Jayasena
- School of Science, Western Sydney University, Bourke St Richmond NSW 2753
| |
Collapse
|
8
|
Liew CS, Mong GR, Abdelfattah EA, Raksasat R, Rawindran H, Kiatkittipong W, Mohamad M, Ramli A, Yunus NM, Lam MK, Da Oh W, Lim JW. Correlating black soldier fly larvae growths with soluble nutrients derived from thermally pre-treated waste activated sludge. ENVIRONMENTAL RESEARCH 2022; 210:112923. [PMID: 35150716 DOI: 10.1016/j.envres.2022.112923] [Citation(s) in RCA: 10] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/18/2021] [Revised: 01/23/2022] [Accepted: 02/07/2022] [Indexed: 06/14/2023]
Abstract
Black soldier fly larvae (BSFL) have been deployed to valorize various organic wastes. Nonetheless, its growth rate whilst being offered with waste activated sludge (WAS) is not promising, likely by virtue of the presence of extracellular polymeric substances' structure in WAS. In this work, the WAS were first thermally pre-treated under different treatment temperatures and durations before being administered as the feeding substrates for BSFL. The results showed the thermal pre-treatment could improve WAS palatability and subsequently, enhance the growth of BSFL especially after the pre-treatments at 75 °C and above. The highest larva weight gained was recorded at 2.16 mg/larva for the WAS sample being pre-treated at 90 °C and 16 h. Furthermore, the samples pre-treated above 75 °C also achieved higher degradation rates, indicating that the 75 °C was a threshold temperature to effectively hydrolyze the WAS. The changes of WAS characteristics, namely, (i) soluble chemical oxygen demand (SCOD), (ii) soluble carbohydrate, (iii) soluble protein, (iv) humic substances and (v) total soluble protein and humic substances, after the thermal pre-treatments were also studied in correlating with the BSFL growth. Accordingly, a model was successfully developed with the highest R2 value attained at 0.95, evidencing the SCOD was the most suitable WAS characteristic to accurately predict the BSFL growth behavior.
Collapse
Affiliation(s)
- Chin Seng Liew
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia
| | - Guo Ren Mong
- School of Energy and Chemical Engineering, Xiamen University Malaysia, Jalan Sunsuria, Bandar Sunsuria, 43900, Sepang, Selangor, Malaysia
| | | | - Ratchaprapa Raksasat
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia
| | - Hemamalini Rawindran
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia
| | - Worapon Kiatkittipong
- Department of Chemical Engineering, Faculty of Engineering and Industrial Technology, Silpakorn University, Nakhon Pathom, 73000, Thailand.
| | - Mardawani Mohamad
- Faculty of Bioengineering and Technology, Universiti Malaysia Kelantan, Jeli Campus, 17600, Jeli, Kelantan, Malaysia
| | - Anita Ramli
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia
| | - Normawati M Yunus
- Centre of Research in Ionic Liquids (CORIL), Department of Fundamental and Applied Sciences, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia
| | - Man Kee Lam
- Department of Chemical Engineering, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia
| | - Wen Da Oh
- School of Chemical Sciences, Universiti Sains Malaysia, 11800, Penang, Malaysia
| | - Jun Wei Lim
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia.
| |
Collapse
|
9
|
Improving the Lipid Profile of Black Soldier Fly (Hermetia illucens) Larvae for Marine Aquafeeds: Current State of Knowledge. SUSTAINABILITY 2022. [DOI: 10.3390/su14116472] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 02/04/2023]
Abstract
The replacement of fish meal and fish oil by insect-based ingredients in the formulation of marine aquafeeds can be an important step towards sustainability. To pursue this goal, the modulation of the lipid profile of black soldier fly larvae (Hermetia illucens) has received great attention. While its nutritional profile can shift with diet, the ability to modulate its lipidome is yet to be understood. The present work provides an overview of the lipid modulation of H. illucens larvae through its diet, aiming to produce a more suitable ingredient for marine aquafeeds. Marine-based substrates significantly improve the lipid profile of H. illucens larvae, namely its omega-3 fatty acids profile. An improvement of approximately 40% can be achieved using fish discards. Substantial levels of eicosapentaenoic acid (EPA) and docosahexaenoic acid (DHA), two essential fatty acids for marine fish and shrimp species, were recorded in H. illucens larvae fed on fish discards and coffee silverskin with Schyzochytrium sp. Unfortunately, these improvements are still deeply connected to marine-based bioresources, some still being too costly for use at an industrial scale (e.g., microalgae). New approaches using solutions from the biotechnology toolbox will be decisive to make H. illucens larvae a feasible alternative ingredient for marine aquafeeds without having to rely on marine bioresources.
Collapse
|
10
|
Liew CS, Wong CY, Abdelfattah EA, Raksasat R, Rawindran H, Lim JW, Kiatkittipong W, Kiatkittipong K, Mohamad M, Yek PNY, Setiabudi HD, Cheng CK, Lam SS. Fungal Fermented Palm Kernel Expeller as Feed for Black Soldier Fly Larvae in Producing Protein and Biodiesel. J Fungi (Basel) 2022; 8:jof8040332. [PMID: 35448563 PMCID: PMC9025283 DOI: 10.3390/jof8040332] [Citation(s) in RCA: 6] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/17/2022] [Revised: 03/16/2022] [Accepted: 03/21/2022] [Indexed: 02/06/2023] Open
Abstract
Being the second-largest country in the production of palm oil, Malaysia has a massive amount of palm kernel expeller (PKE) leftover. For that purpose, black soldier fly larvae (BSFL) are thus employed in this study to valorize the PKE waste. More specifically, this work elucidated the effects of the pre-fermentation of PKE via different amounts of Rhizopus oligosporus to enhance PKE palatability for the feeding of BSFL. The results showed that fermentation successfully enriched the raw PKE and thus contributed to the better growth of BSFL. BSFL grew to be 34% heavier at the optimum inoculum volume of 0.5 mL/10 g dry weight of PKE as compared to the control. Meanwhile, excessive fungal inoculum induced competition between BSFL and R. oligosporus, resulting in a reduction in BSFL weight. Under optimum feeding conditions, BSFL also registered the highest lipid yield (24.7%) and protein yield (44.5%). The biodiesel derived from BSFL lipid had also shown good compliance with the European biodiesel standard EN 14214. The high saturated fatty acid methyl esters (FAMEs) content (C12:0, C14:0, C16:0) in derived biodiesel made it highly oxidatively stable. Lastly, the superior degradation rate of PKE executed by BSFL further underpinned the sustainable conversion process in attaining valuable larval bioproducts.
Collapse
Affiliation(s)
- Chin Seng Liew
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, Seri Iskandar 32610, Perak Darul Ridzuan, Malaysia; (C.S.L.); (C.Y.W.); (R.R.); (H.R.)
| | - Chung Yiin Wong
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, Seri Iskandar 32610, Perak Darul Ridzuan, Malaysia; (C.S.L.); (C.Y.W.); (R.R.); (H.R.)
| | - Eman A. Abdelfattah
- Entomology Department, Faculty of Science, Cairo University, Cairo 12613, Egypt;
| | - Ratchaprapa Raksasat
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, Seri Iskandar 32610, Perak Darul Ridzuan, Malaysia; (C.S.L.); (C.Y.W.); (R.R.); (H.R.)
| | - Hemamalini Rawindran
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, Seri Iskandar 32610, Perak Darul Ridzuan, Malaysia; (C.S.L.); (C.Y.W.); (R.R.); (H.R.)
| | - Jun Wei Lim
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, Seri Iskandar 32610, Perak Darul Ridzuan, Malaysia; (C.S.L.); (C.Y.W.); (R.R.); (H.R.)
- Correspondence: (J.W.L.); (W.K.)
| | - Worapon Kiatkittipong
- Department of Chemical Engineering, Faculty of Engineering and Industrial Technology, Silpakorn University, Nakhon Pathom 73000, Thailand
- Correspondence: (J.W.L.); (W.K.)
| | - Kunlanan Kiatkittipong
- Department of Chemical Engineering, School of Engineering, King Mongkut’s Institute of Technology Ladkrabang, Bangkok 10520, Thailand;
| | - Mardawani Mohamad
- Faculty of Bioengineering and Technology, Universiti Malaysia Kelantan, Jeli Campus, Jeli 17600, Kelantan, Malaysia;
| | - Peter Nai Yuh Yek
- Centre for Research of Innovation and Sustainable Development, Department of Engineering and Technology, University College of Technology Sarawak, Sibu 96000, Sarawak, Malaysia;
- Henan Province Engineering Research Center for Biomass Value-Added Products, School of Forestry, Henan Agricultural University, Zhengzhou 450002, China;
| | - Herma Dina Setiabudi
- Faculty of Chemical and Process Engineering Technology, College of Engineering Technology, Universiti Malaysia Pahang, Lebuhraya Tun Razak, Gambang, Kuantan 26300, Pahang, Malaysia;
| | - Chin Kui Cheng
- Center for Catalysis and Separation (CeCaS), Department of Chemical Engineering, College of Engineering, Khalifa University of Science and Technology, Abu Dhabi P.O. Box 127788, United Arab Emirates;
| | - Su Shiung Lam
- Henan Province Engineering Research Center for Biomass Value-Added Products, School of Forestry, Henan Agricultural University, Zhengzhou 450002, China;
- Pyrolysis Technology Research Group, Higher Institution Centre of Excellence (HICoE), Institute of Tropical Aquaculture and Fisheries (AKUATROP), Universiti Malaysia Terengganu, Kuala Nerus 21030, Terengganu, Malaysia
| |
Collapse
|
11
|
Li X, Dong Y, Sun Q, Tan X, You C, Huang Y, Zhou M. Growth and Fatty Acid Composition of Black Soldier Fly Hermetia illucens (Diptera: Stratiomyidae) Larvae Are Influenced by Dietary Fat Sources and Levels. Animals (Basel) 2022; 12:486. [PMID: 35203193 PMCID: PMC8868361 DOI: 10.3390/ani12040486] [Citation(s) in RCA: 12] [Impact Index Per Article: 6.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/07/2022] [Revised: 02/14/2022] [Accepted: 02/14/2022] [Indexed: 02/05/2023] Open
Abstract
A 16-day rearing trial was performed to investigate the influence of two supplemental levels (5% and 10%) of six dietary fat sources (linseed oil, peanut oil, coconut oil, soybean oil, lard oil and fish oil) on the growth, development and nutrient composition of black solider fly larvae. Our results demonstrated that the pre-pupa rate of larvae was linearly influenced by dietary C18:0, C18:3n-3 and C18:2n-6 content (pre-pupa rate = 0.927 × C18:0 content + 0.301 × C18:3n-3 content-0.258 × C18:2n-6 content p < 0.001)), while final body weight was linearly influenced by that of C16:0 (final body weight = 0.758 × C16:0 content, p = 0.004). Larval nutrient composition was significantly affected by dietary fat sources and levels, with crude protein, fat and ash content of larvae varying between 52.0 and 57.5, 15.0 and 23.8, and 5.6 and 7.2% dry matter. A higher level of C12:0 (17.4-28.5%), C14:0 (3.9-8.0%) and C16:1n-9 (1.3-4.3%) was determined in larvae fed the diets containing little of them. In comparison, C16:0, C18:1n-9, C18:2n-6 and C18:3n-3 proportions in larvae were linearly related with those in diets, with the slope of the linear equations varying from 0.39 to 0.60. It can be concluded that sufficient C16:0, C18:0 and C18:3n-3 supply is beneficial for larvae growth. Larvae could produce and retain C12:0, C14:0, and C16:1n-9 in vivo, but C16:0, C18:1n-9, C18:2n-6 and C18:3n-3 could only be partly incorporated from diets and the process may be enhanced by a higher amount of dietary fat. Based on the above observation, an accurately calculated amount of black soldier fly larvae could be formulated into aquafeed as the main source of saturated fatty acids and partial source of mono-unsaturated and poly-unsaturated fatty acids to save fish oil.
Collapse
Affiliation(s)
| | | | | | | | | | - Yanhua Huang
- Key Laboratory of Aquatic Animal Diseases and Waterfowl Breeding, Provincial Water Environment and Aquatic Products Security Engineering Technology Research Center, CInnovative Institute of Animal Healthy Breeding, Guangzhou Guangdong College of Animal Sciences and Technology, Zhongkai University of Agriculture and Engineering, Guangzhou 510225, China; (X.L.); (Y.D.); (Q.S.); (X.T.); (C.Y.)
| | - Meng Zhou
- Key Laboratory of Aquatic Animal Diseases and Waterfowl Breeding, Provincial Water Environment and Aquatic Products Security Engineering Technology Research Center, CInnovative Institute of Animal Healthy Breeding, Guangzhou Guangdong College of Animal Sciences and Technology, Zhongkai University of Agriculture and Engineering, Guangzhou 510225, China; (X.L.); (Y.D.); (Q.S.); (X.T.); (C.Y.)
| |
Collapse
|
12
|
Liu Z, Najar-Rodriguez AJ, Morel PCH, Minor MA. Reproduction of Black Soldier Fly (Diptera: Stratiomyidae) Under Different Adult Densities and Light Regimes. JOURNAL OF ECONOMIC ENTOMOLOGY 2022; 115:37-45. [PMID: 34850041 DOI: 10.1093/jee/toab225] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/23/2021] [Indexed: 06/13/2023]
Abstract
The black soldier fly (BSF) Hermetia illucens (L.) (Diptera: Stratiomyidae) has been recognized as a promising insect species for sustainable management of organic waste and by-products. Indoor breeding of BSF with artificial lighting has been proved successful, but efforts are still needed to optimize BSF reproductive output. Increasing adult density seems an option to exploit space, whereas decreasing artificial lighting duration may reduce unnecessary power consumption. This study aimed at investigating the effects of adult density (10, 25, and 50 pairs per 30 × 30 × 30 cm cage; i.e., 370, 926, and 1,852 pairs/m3), light regime (8:16, 12:12, and 16:8 [L:D] h), and their possible interactions, on some BSF life history traits relevant to reproduction. The results show that the overall BSF reproductive output increased with increasing adult density but was not affected by light regimes per se. With the highest BSF adult density tested, an average of more than 20,000 neonate larvae were produced from a cage within 10 d. At this density, increasing photoperiod increased neonate production, but also decreased the number of neonates per watt used for artificial illumination. The temporal oviposition patterns, mean individual female reproductive output, mating success, egg hatching rate, and insect survival rate were not affected by adult density or light regime as simple effects. However, the interaction between adult density and light regime was significant for the first oviposition peak, mean individual female reproductive output, and insect survival rate. The possible mechanisms behind our results are discussed.
Collapse
Affiliation(s)
- Zhongyi Liu
- Wildlife & Ecology Group, School of Agriculture and Environment, Massey University, Private Bag 11 222, Palmerston North 4442, New Zealand
| | - Adriana J Najar-Rodriguez
- The New Zealand Institute for Plant and Food Research, Canterbury Agriculture & Science Center, Lincoln 7608, New Zealand
| | - Patrick C H Morel
- Monogastric Research Centre, School of Agriculture and Environment, Massey University, Private Bag 11 222, Palmerston North 4442, New Zealand
| | - Maria A Minor
- Wildlife & Ecology Group, School of Agriculture and Environment, Massey University, Private Bag 11 222, Palmerston North 4442, New Zealand
| |
Collapse
|
13
|
Li X, Zhou Z, Zhang J, Zhou S, Xiong Q. Conversion of Mixtures of Soybean Curd Residue and Kitchen Waste by Black Soldier Fly Larvae ( Hermetia illucens L.). INSECTS 2021; 13:23. [PMID: 35055866 PMCID: PMC8779397 DOI: 10.3390/insects13010023] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 12/02/2021] [Revised: 12/15/2021] [Accepted: 12/20/2021] [Indexed: 12/22/2022]
Abstract
The production of insect biomass from organic waste is a major challenge in terms of reducing the environmental impacts of waste and maintaining feed and food security. The feasibility of the co-conversion of soybean curd residue (SCR) and kitchen waste (KW) to breed black soldier fly (BSF, Hermetia illucens) larvae was evaluated so as to enhance biomass conversion efficiency and supply animal feed and allow it to be used in biodiesel production. Co-digestion was found to significantly increase larval yield, bioconversion rate, and bioaccumulation of lipid. Partial least squares regression showed that the conversion of 30% SCR with 70% KW is an appropriate proportion. The appropriate performance parameters of BSF were: survival rate (98.75%), prepupal rate (88.61%), larval biomass (30.32 g fresh and 11.38 g dry mass), bioconversion rate (18.45%), efficiency conversion of ingested food (ECI) (28.30%), and FCR (2.51). Our results show that conversion of mixtures (e.g., SCR with KW) by BSF larvae (BSFL) could play an important role in various organic materials management.
Collapse
Affiliation(s)
- Xinfu Li
- College of Food Science and Light Industry, Nanjing Tech University, No. 30 Puzhu Road South, Nanjing 211800, China; (X.L.); (S.Z.); (Z.Z.)
| | - Zhihao Zhou
- College of Food Science and Light Industry, Nanjing Tech University, No. 30 Puzhu Road South, Nanjing 211800, China; (X.L.); (S.Z.); (Z.Z.)
| | - Jing Zhang
- College of Biotechnology and Pharmaceutical Engineering, Nanjing Tech University, No. 30 Puzhu Road South, Nanjing 211800, China;
| | - Shen Zhou
- College of Food Science and Light Industry, Nanjing Tech University, No. 30 Puzhu Road South, Nanjing 211800, China; (X.L.); (S.Z.); (Z.Z.)
| | - Qiang Xiong
- College of Food Science and Light Industry, Nanjing Tech University, No. 30 Puzhu Road South, Nanjing 211800, China; (X.L.); (S.Z.); (Z.Z.)
| |
Collapse
|
14
|
Abstract
Black soldier fly (BSF) larvae may play a role in a circular economy by upcycling low-value organic streams into high value biomass. In this paper, the capacity of BSF larvae to process 12 organic side-streams (mono-streams) and two standard substrates (chicken start mash and Gainesville diet) was investigated. Survival, larval mass, feed conversion ratio, and waste reduction were evaluated in relation to the proximate composition of the side-streams used. Survival rates larger than 80% were observed for 10 of the organic mono-streams and the two standard substrates. Maximum mean larval weight ranged from 38.3 mg up to 176.4 mg regardless of high survival and was highly correlated with substrate crude protein content. Feed conversion ratio (range 1.58–8.90) and waste reduction (range 17.0–58.9%) were similar to values reported in other studies in the literature. On low protein substrates (e.g., apple pulp), survival rates remained high, however, possibly due to protein deficiency, limited larval growth was observed. It is concluded that several low value organic side-streams can successfully be processed by BSF larvae, thereby opening the possibility of lowering the costs of BSF farming. Potentially mixing nutritionally distinct mono-streams into a mixed substrate might improve BSF performance. However, more research is needed for optimizing diets to guarantee production of BSF larvae of constant yield and quality.
Collapse
|
15
|
Growth Performance, Waste Reduction Efficiency and Nutritional Composition of Black Soldier Fly ( Hermetia illucens) Larvae and Prepupae Reared on Coconut Endosperm and Soybean Curd Residue with or without Supplementation. INSECTS 2021; 12:insects12080682. [PMID: 34442248 PMCID: PMC8396427 DOI: 10.3390/insects12080682] [Citation(s) in RCA: 12] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 07/07/2021] [Revised: 07/24/2021] [Accepted: 07/27/2021] [Indexed: 12/04/2022]
Abstract
Simple Summary Black soldier fly (BSF, Hermetia illucens) larvae have a high potential to convert organic waste into high-value products. However, the growth performance, waste reduction efficiency, and chemical composition of BSF larvae are greatly influenced by the rearing substrate. This study focused on investigating the growth performance, waste reduction efficiency, and nutritional composition of BSF larvae reared on different ratios of coconut endosperm (C) and soybean curd residue (S), with or without supplementation, compared to standard diets (Gainesville: G and starter chicken diet: CK). The results showed that BSF larvae fed CK has the highest larval weight, followed by those fed coconut endosperm and soybean curd residue at a ratio of 20:80 (C20S80), and coconut endosperm and soybean curd residue at a ratio of 50:50 (C50S50) without supplementation. The greatest waste reduction efficiency was observed in the G, C50S50, and C20S80 groups without supplementation. The highest crude protein content in larvae was presented in the G and C20S80 groups followed by the CK and C50S50 groups. Therefore, equal proportions of C and S without supplementation is likely the best formulation for growth performance, waste reduction efficiency, and nutritional composition of BSF larvae when compared with standard diets. Abstract Black soldier fly (BSF, Hermetia illucens) larvae are considered as insects with a high potential to convert organic waste into high-value products. The objective of this study was to investigate the growth performance, waste reduction efficiency, and nutritional composition of BSF reared on different ratios of coconut endosperm (C) and soybean curd residue (S), with or without supplementation, compared to standard diets (Gainesville: G and starter chicken diet: CK). Seven-day-old larvae were randomly divided into eight experimental groups (G, CK, and three different ratios of C and S with or without supplementation) with three replicates with an equal weight of larvae. The supplement contained calcium, phosphorus, amino acids, and a mineral–vitamin premix which was formulated to correlate with CK. Each replicate was terminated, measured, and evaluated when 40% of larvae had reached prepupal stage. The highest larval weight gain was presented in BSF fed CK, followed by those fed coconut endosperm and soybean curd residue at a ratio of 20:80 (C20S80), and coconut endosperm and soybean curd residue at a ratio of 50:50 (C50S50) without supplementation (numbers after C and S represent their percentage in the formulation; p < 0.001). Harvesting was delayed in the BSF fed C80S20 with and without supplementation (p < 0.001). The number of total larvae and prepupae was not significantly different between groups (p > 0.05). The greatest waste reduction efficiency was observed in the G, C50S50, and C20S80 groups without supplementation (p < 0.001). All groups with supplementation had a higher proportion of ash in both larvae and prepupae compared to non-supplemented groups (p < 0.001), but lower growth performance. The highest percentage of crude protein in larvae was presented in the Gainesville and C20S80 groups followed by the CK and C50S50 groups (p < 0.001). Equal proportions of C and S without supplementation are suggested as a rearing substrate. However, growth performance was lower than for CK; therefore, further studies could investigate cost-efficient techniques to promote this parameter.
Collapse
|
16
|
Queiroz LS, Regnard M, Jessen F, Mohammadifar MA, Sloth JJ, Petersen HO, Ajalloueian F, Brouzes CMC, Fraihi W, Fallquist H, de Carvalho AF, Casanova F. Physico-chemical and colloidal properties of protein extracted from black soldier fly (Hermetia illucens) larvae. Int J Biol Macromol 2021; 186:714-723. [PMID: 34274399 DOI: 10.1016/j.ijbiomac.2021.07.081] [Citation(s) in RCA: 18] [Impact Index Per Article: 6.0] [Reference Citation Analysis] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/03/2021] [Revised: 07/11/2021] [Accepted: 07/12/2021] [Indexed: 01/14/2023]
Abstract
The black soldier fly larvae (BSFL), Hermetia illucens (Linnaeus), has been largely utilized for animal feed. Due to its interesting composition, BSFL has great potential to be further implemented in the human diet. Herein we compared the flour and protein extract composition based on their moisture, ash, amino acids, mineral, and protein content. To have wide knowledge on protein profile and behavior, SDS-page electrophoresis, Fourier-transform infrared spectroscopy (FTIR) and differential scanning calorimetry (DSC) were used to give information about protein structure and thermal stability, respectively. The flour and protein extract contained respectively 37.3% and 61.1% of protein. DSC graph reported a glass transition temperature around 30 °C, recognizable by a shift in the curve, and an endothermic peak for solid melting at around 200 °C. FTIR analysis showed the main amide bands (A, B, I, II, III) for the flour and protein extract. The foam properties of BSFL protein extract were explored under different temperatures treatment, and the best foam stability was reached at 85 °C with 15 min of treatment. The data highlight the promising techno-functional properties of BSFL protein extract, and that the nutritional composition might be suitable for further use of BSFL as food fortification system.
Collapse
Affiliation(s)
- Lucas Sales Queiroz
- Departamento de Tecnologia de Alimentos, Universidade Federal de Viçosa (UFV), 36570-900 Viçosa, Minas Gerais, Brazil
| | - Marine Regnard
- Research Group for Food Production Engineering, National Food Institute, Technical University of Denmark, SøltoftsPlads, 2800 Kongens Lyngby, Denmark; Agrocampus Ouest, UMR 1253, F-35042 Rennes, France
| | - Flemming Jessen
- Research Group for Food Production Engineering, National Food Institute, Technical University of Denmark, SøltoftsPlads, 2800 Kongens Lyngby, Denmark
| | - Mohammad Amin Mohammadifar
- Research Group for Food Production Engineering, National Food Institute, Technical University of Denmark, SøltoftsPlads, 2800 Kongens Lyngby, Denmark
| | - Jens J Sloth
- Research Group for Analytical Food Chemistry, Technical University of Denmark, Kemitorvet, 2800 Kongens Lyngby, Denmark
| | - Heidi Olander Petersen
- Research Group for Food Production Engineering, National Food Institute, Technical University of Denmark, SøltoftsPlads, 2800 Kongens Lyngby, Denmark
| | - Fatemeh Ajalloueian
- Center for Intelligent Drug Delivery and Sensing Using Microcontainers and Nanomechanics (IDUN), Department of Health Technology, Technical University of Denmark, 2800 Kongens Lyngby, Denmark
| | | | - Wael Fraihi
- nextProtein, Genopôle Campus 3, 4 Rue Pierre Fontaine, 91000 Evry-Courcouronnes, France
| | - Heather Fallquist
- nextProtein, Genopôle Campus 3, 4 Rue Pierre Fontaine, 91000 Evry-Courcouronnes, France
| | - Antonio Fernandes de Carvalho
- Departamento de Tecnologia de Alimentos, Universidade Federal de Viçosa (UFV), 36570-900 Viçosa, Minas Gerais, Brazil
| | - Federico Casanova
- Research Group for Food Production Engineering, National Food Institute, Technical University of Denmark, SøltoftsPlads, 2800 Kongens Lyngby, Denmark.
| |
Collapse
|
17
|
Lawal KG, Kavle RR, Akanbi TO, Mirosa M, Agyei D. Enrichment in specific fatty acids profile of Tenebrio molitor and Hermetia illucens larvae through feeding. FUTURE FOODS 2021. [DOI: 10.1016/j.fufo.2021.100016] [Citation(s) in RCA: 7] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/23/2022] Open
|
18
|
Chiam Z, Lee JTE, Tan JKN, Song S, Arora S, Tong YW, Tan HTW. Evaluating the potential of okara-derived black soldier fly larval frass as a soil amendment. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2021; 286:112163. [PMID: 33618320 DOI: 10.1016/j.jenvman.2021.112163] [Citation(s) in RCA: 6] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/28/2020] [Revised: 01/04/2021] [Accepted: 02/08/2021] [Indexed: 06/12/2023]
Abstract
Bioconversion of organic waste by the black soldier fly (BSF) larva yields a by-product commonly known as 'frass'. Although BSF larval frass has often been marketed as a biofertilizer, few studies have evaluated this claim. In this study, BSF larvae reared on a pure okara diet achieved an 85% waste reduction in the fresh weight of the okara. Subsequently, the frass was mixed with soil at concentrations of 10, 20, and 30% (vol/vol), and used to cultivate lettuce plants. At 10% concentration, the lettuce plants had biomasses comparable to those of the controls. Higher frass concentrations stunted the growth of the lettuce, likely because of the low C:N ratio of larval frass resulting from the rapid mineralization of nutrients. Larval frass was also found to be able to provide sufficient nutrients for lettuce growth as fertilizer application was only necessary after the first growth cycle, suggesting its suitability as a soil amendment. Analyses of the microbial community of all the growing media showed that the growth medium treatments with BSF larval frass tended to have a lower number of microbial species than the controls. Inherently higher micronutrient levels present in the frass resulted in the growth of lettuce plants. More importantly, the microbial analysis revealed that common foodborne pathogens were absent in the BSF larval frass and elemental analysis also indicated no heavy metal pollutants present. Overall, BSF larval frass was found to be a suitable soil amendment and more in-depth studies could facilitate its sensible use in agriculture.
Collapse
Affiliation(s)
- Zhongyu Chiam
- Department of Biological Sciences, National University of Singapore, 16 Science Drive 4, 117558, Singapore.
| | - Jonathan Tian En Lee
- Environmental Research Institute, National University of Singapore, Temasek Laboratories Building, 5A Engineering Drive 1, 117311, Singapore; Energy and Environmental Sustainability for Megacities (E2S2) Phase II, Campus for Research Excellence and Technological Enterprise (CREATE), 1 Create Way, Singapore, 138602, Singapore.
| | - Jonathan Koon Ngee Tan
- Department of Biological Sciences, National University of Singapore, 16 Science Drive 4, 117558, Singapore.
| | - Shuang Song
- Department of Biological Sciences, National University of Singapore, 16 Science Drive 4, 117558, Singapore.
| | - Srishti Arora
- Environmental Research Institute, National University of Singapore, Temasek Laboratories Building, 5A Engineering Drive 1, 117311, Singapore; Energy and Environmental Sustainability for Megacities (E2S2) Phase II, Campus for Research Excellence and Technological Enterprise (CREATE), 1 Create Way, Singapore, 138602, Singapore.
| | - Yen Wah Tong
- Energy and Environmental Sustainability for Megacities (E2S2) Phase II, Campus for Research Excellence and Technological Enterprise (CREATE), 1 Create Way, Singapore, 138602, Singapore; Department of Chemical and Biomolecular Engineering, 4 Engineering Drive 4, 117585, Singapore.
| | - Hugh Tiang Wah Tan
- Department of Biological Sciences, National University of Singapore, 16 Science Drive 4, 117558, Singapore.
| |
Collapse
|
19
|
El-Dakar MA, Ramzy RR, Wang D, Ji H. Sustainable management of Se-rich silkworm residuals by black soldier flies larvae to produce a high nutritional value and accumulate ω-3 PUFA. WASTE MANAGEMENT (NEW YORK, N.Y.) 2021; 124:72-81. [PMID: 33610113 DOI: 10.1016/j.wasman.2021.01.040] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/31/2020] [Revised: 01/25/2021] [Accepted: 01/27/2021] [Indexed: 06/12/2023]
Abstract
Waste disposal and utilisation of its important components are pioneering goals for achieving sustainable development and a clean environment. Silkworm pupae (SWP) are considered a by-product of the sericulture industry and may contain a high concentration of selenium (Se) in some regions, making them a potentially hazardous waste posing health risks. This study examined six treatments of Se-rich SWP (0-100%) as a substrate for black soldier fly (BSF) larvae. Growth performance and protein content of BSF larvae were not affected by increasing SWP content. The total fat, mono-, and poly-unsaturated fatty acids in BSF pre-pupae increased with increasing SWP inclusion in the substrate, from P0 (pre-pupae fed control treatment) through P100 (pre-pupae fed 100% SWP treatment), by 18.83, 61.14, and 62.42%, respectively. The results of significance were: (1) BSF pre-pupae did not accumulate Se, maintaining the same amount of Se in their bodies (~0.18 mg/kg); (2) omega-3 fatty acids represented by linolenic acid in BSF increased by 1,223.35% from P0 to P100, with 70.65% recovered from the SWP; (3) valine percentage increased in BSF compared with the percentage of SWP by 25.30%; and (4) BSF larvae were observed reducing SWP waste by more than one-third. BSF larvae can reduce the waste from sericulture industry and exploit the beneficial properties and components of SWP, converting them into safe and highly nutritious products.
Collapse
Affiliation(s)
- Marco A El-Dakar
- College of Animal Science and Technology, Northwest A&F University, Yangling, Shaanxi, China.
| | - Remondah R Ramzy
- College of Animal Science and Technology, Northwest A&F University, Yangling, Shaanxi, China
| | - Dun Wang
- Institute of Entomology, Northwest A&F University, Yangling, Shaanxi, China
| | - Hong Ji
- College of Animal Science and Technology, Northwest A&F University, Yangling, Shaanxi, China.
| |
Collapse
|
20
|
Rhizopus oligosporus-Assisted Valorization of Coconut Endosperm Waste by Black Soldier Fly Larvae for Simultaneous Protein and Lipid to Biodiesel Production. Processes (Basel) 2021. [DOI: 10.3390/pr9020299] [Citation(s) in RCA: 10] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/21/2023] Open
Abstract
Coconut endosperm waste (CEW) was treated by Rhizopus oligosporus via in situ and ex situ fermentations together with bioconversion into valuable black soldier fly larval biomass. The ex situ fermentation could overall enrich the nutritional compositions of CEW by hydrolyzing its complex organic polymers and exuding assimilable nutrients to enhance the black soldier fly larvae (BSFL) growth. Nevertheless, the larval gut bacteria were competing with Rhizopus oligosporus in in situ fermentation, derailing the hydrolysis processes and larval growth. Accordingly, the highest growth rates achieved were around 0.095 g/day, as opposed to only 0.065 g/day whilst using 0.5 wt% of Rhizopus oligosporus to perform ex situ and in situ fermentations, respectively. These were also underpinned by the greater amount of total CEW consumed when employing ex situ fermentation, with comparable metabolic costs to feeding on in situ-fermented CEW. The mature BSFL were subsequently harvested and the amounts of protein and lipid produced were assessed in terms of their feasibility for biodiesel production. While the statistical analyses showed that the larval protein yields derived from both fermentation modes were insignificant, the BSFL could attain higher lipid and protein productivities upon feeding with ex situ- rather than in situ-fermented CEW mediums. Better yet, the larval biodiesel quality measured in terms of the fatty acid methyl ester composition were not varied significantly by Rhizopus oligosporus through the fermentation process. Thereby, the presence of 1.0 wt% Rhizopus oligosporus was considered optimum to perform ex situ fermentation, giving rise to the acceptable growth of BSFL loaded with the highest lipid yield and productivity for producing biodiesel and protein simultaneously.
Collapse
|
21
|
Blended Sewage Sludge–Palm Kernel Expeller to Enhance the Palatability of Black Soldier Fly Larvae for Biodiesel Production. Processes (Basel) 2021. [DOI: 10.3390/pr9020297] [Citation(s) in RCA: 16] [Impact Index Per Article: 5.3] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/15/2022] Open
Abstract
Black soldier fly larvae (BSFL) have been employed for valorizing organic waste materials as the larvae are able to consume organic waste and transform it into valuable larval biomass. In this study, BSFL were found to potentially reduce blended sewage sludge. The addition of palm kernel expeller (PKE) fortified the protein and lipid content in blended sewage sludge substrates, leading to larval growth enhancement. In addition, the larval weight also influenced the lipid yield and fatty acid methyl ester (FAME) profile. However, the optimum ratio of sewage sludge to PKE had to be determined as excess PKE content could become a threat to larval growth by contributing to the reduction of non-fiber carbohydrates content in the feed, thereby resulting in the decrease in lipid yield and FAME content. In this work, a sewage sludge to PKE ratio of 2:3 proffered the highest larval weight gained at 46.99 ± 2.09 mg/larva. Meanwhile, a proportion of 3:2 of sewage sludge to PKE was able provide the highest lipid yield of 17 ± 1.77%. Furthermore, the FAME profile revealed the presence of a significant amount of saturated and monosaturated fatty acids, indicating a good quality biodiesel. Thus, BSFL-based biodiesel fed with blended sewage sludge and PKE could be utilized for producing a high quality biodiesel. However, further improvement on the amount of lipid yield and FAME content should be further investigated.
Collapse
|
22
|
Galassi G, Jucker C, Parma P, Lupi D, Crovetto GM, Savoldelli S, Colombini S. Impact of Agro-industrial Byproducts on Bioconversion, Chemical Composition, in vitro Digestibility, and Microbiota of the Black Soldier Fly (Diptera: Stratiomyidae) Larvae. JOURNAL OF INSECT SCIENCE (ONLINE) 2021; 21:8. [PMID: 33480429 PMCID: PMC7820701 DOI: 10.1093/jisesa/ieaa148] [Citation(s) in RCA: 15] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/03/2020] [Indexed: 05/20/2023]
Abstract
The interest in using byproducts from agro-food industries as a rearing substrate for insects is increasing rapidly. We investigated the influence of byproducts of vegetal origin (okara-a byproduct of soy milk production, maize distillers with solubles, brewer's grains), used as rearing diet for black soldier fly larvae (BSFL), on the following parameters: biomass production, substrate reduction (SR), nutritional profile and in vitro digestibility, and larval gut microbiota. Hen diet was used as a control substrate. The highest larval biomass was collected on maize distillers, whereas the highest SR was observed on okara. The rearing substrate affected ash, ether extract, and chitin larval content. The BSFL reared on okara were characterized by a lower lauric acid content (17.6% of total fatty acids). Diets also influenced in vitro crude protein digestibility (%) for monogastrics, with the highest values for BSFL reared on maize distillers (87.8), intermediate for brewer's grains and okara BSFL, and the lowest for hen BSFL (82.7). The nutritive value for ruminants showed a lower Net Energy for lactation for BSFL reared on hen diet than okara and dried maize distillers BSFL. The different byproducts showed an influence on the larval gut microbiota, with a major bacterial complexity observed on larvae fed with the hen diet. The neutral detergent fiber concentration of dietary substrate was negatively correlated with Firmicutes and Actinobacteria relative abundance. Insects valorized byproducts converting them into high-value larval biomass to be used for feed production. The results evidenced the effects of the tested byproducts on the measured parameters, underling the chemical composition importance on the final insect meal quality.
Collapse
Affiliation(s)
- Gianluca Galassi
- Department of Agricultural and Environmental Sciences—Production, Landscape, Agroenergy (DiSAA)
| | - Costanza Jucker
- Department of Food, Environmental and Nutritional Sciences (DeFENS), University of Milan, Milan, Italy
| | - Pietro Parma
- Department of Agricultural and Environmental Sciences—Production, Landscape, Agroenergy (DiSAA)
| | - Daniela Lupi
- Department of Food, Environmental and Nutritional Sciences (DeFENS), University of Milan, Milan, Italy
| | - Gianni Matteo Crovetto
- Department of Agricultural and Environmental Sciences—Production, Landscape, Agroenergy (DiSAA)
| | - Sara Savoldelli
- Department of Food, Environmental and Nutritional Sciences (DeFENS), University of Milan, Milan, Italy
| | - Stefania Colombini
- Department of Agricultural and Environmental Sciences—Production, Landscape, Agroenergy (DiSAA)
| |
Collapse
|
23
|
Guo H, Jiang C, Zhang Z, Lu W, Wang H. Material flow analysis and life cycle assessment of food waste bioconversion by black soldier fly larvae (Hermetia illucens L.). THE SCIENCE OF THE TOTAL ENVIRONMENT 2021; 750:141656. [PMID: 32858299 DOI: 10.1016/j.scitotenv.2020.141656] [Citation(s) in RCA: 24] [Impact Index Per Article: 8.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/04/2020] [Revised: 08/10/2020] [Accepted: 08/10/2020] [Indexed: 06/11/2023]
Abstract
This study provided a systematic analysis on material flow and environmental impacts of a food waste (FW) bioconversion plant using black soldier fly larvae (BSFL), with a daily capacity of 15 tons of FW (wet weight). Food waste feed (FWF) used for BSFL bioconversion consisted of 80% FW (collected from households, restaurants, and canteens) and 20% rice hull powder. Material flow analysis conducted on a dry weight basis showed that 6% of FWF was transformed into BSF pre-pupae, 51% was stored in matured compost, and 43% was emitted to the air. Emissions of high environmental concern such as methane, nitrous oxide and ammonia (NH3) were sampled and quantified by laboratory analysis. The life cycle assessment revealed that the overall impact was 17.36 kg CO2-eq/t FW for global warming potential, 5.54 kg SO2-eq/t FW for acidification, 24.05 mol N-eq/t FW for terrestrial eutrophication, 0.54 kg N-eq NH3/t FW for marine eutrophication, and 0.18 kg PM2.5-eq/t FW of particulate matter up to 2.5 μm diameter. Moreover, emissions from post-composting, energy consumptions of drying and chemical fertilizer substitution ratio were detected by contribution analysis as the main contributors to those impacts. Finally, sensitivity analysis indicated that the substitution ratio of mineral fertilizer and protein feed as well as energy consumption were the most influential parameters, therefore control of the post-composting process of residual material should be closely monitored because it was responsible for significant environmental load caused by N-related emissions.
Collapse
Affiliation(s)
- Hanwen Guo
- School of Environment, Tsinghua University, 100084 Beijing, China
| | - Chengliang Jiang
- College of Environmental and Resource Sciences, Zhejiang University, 310058 Hangzhou, China
| | - Zhijian Zhang
- College of Environmental and Resource Sciences, Zhejiang University, 310058 Hangzhou, China; Hangzhou Gusheng Biotechnology Co., Ltd, 311108 Hangzhou, China
| | - Wenjing Lu
- School of Environment, Tsinghua University, 100084 Beijing, China.
| | - Hongtao Wang
- School of Environment, Tsinghua University, 100084 Beijing, China
| |
Collapse
|
24
|
Pang W, Hou D, Nowar EE, Chen H, Zhang J, Zhang G, Li Q, Wang S. The influence on carbon, nitrogen recycling, and greenhouse gas emissions under different C/N ratios by black soldier fly. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2020; 27:42767-42777. [PMID: 32720023 DOI: 10.1007/s11356-020-09909-4] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/16/2019] [Accepted: 06/26/2020] [Indexed: 06/11/2023]
Abstract
Currently, sustainable utilization, including recycling and valorization, is becoming increasingly popular in waste management. Black soldier fly larvae (BSFL) can convert the carbon (C) and nitrogen (N) from organic waste into biomass and improve properties of the substrate to reduce greenhouse gas and NH3 emissions. In this study, the recycling of C and N and the emissions of greenhouse gas and NH3 during BSFL bio-treatment of mixtures of pig manure and corncob were investigated under different C/N ratios. The results indicated that initial C/N ratios of feedstock are a crucial parameter affecting the biomass generation of larvae. The BSFL recycled approximately 4.17-6.61% of C and 17.45-23.73% of N from raw materials under different C/N ratios. Cumulative CO2, CH4, NH3, and N2O emissions at the different C/N ratios ranging from 15 to 35 were 107.92-151.68, 0.08-0.76, 0.14-1.17, and 0.91-1.18 mg kg-1, respectively. Compared with conventional composting, BSFL treatment could reduce the total greenhouse gas emissions by over 90%. The study showed that bio-treatment of mixtures of pig manure and corncob with a proper C/N ratio by BSFL could become an avenue to achieve higher nutrient recycling, which is an eco-friendly process.
Collapse
Affiliation(s)
- Wancheng Pang
- State Key Laboratory of Agricultural Microbiology, College of Science, Huazhong Agricultural University, Wuhan, 430070, China
| | - Dejia Hou
- State Key Laboratory of Agricultural Microbiology, College of Science, Huazhong Agricultural University, Wuhan, 430070, China
- College of Engineering, Huazhong Agricultural University, Wuhan, 430070, China
| | - Elhosseny E Nowar
- Plant Protection Department, Faculty of Agriculture, Benha University, Moshtohor, Kaluybia, 13736, Egypt
| | - Huanchun Chen
- State Key Laboratory of Agricultural Microbiology, College of Science, Huazhong Agricultural University, Wuhan, 430070, China
| | - Jibin Zhang
- State Key Laboratory of Agricultural Microbiology, College of Science, Huazhong Agricultural University, Wuhan, 430070, China
| | - Guoping Zhang
- College of Physical Science and Technology, Central China Normal University, Wuhan, 430079, China
| | - Qing Li
- State Key Laboratory of Agricultural Microbiology, College of Science, Huazhong Agricultural University, Wuhan, 430070, China.
| | - Shucai Wang
- College of Engineering, Huazhong Agricultural University, Wuhan, 430070, China
| |
Collapse
|
25
|
Surendra KC, Tomberlin JK, van Huis A, Cammack JA, Heckmann LHL, Khanal SK. Rethinking organic wastes bioconversion: Evaluating the potential of the black soldier fly (Hermetia illucens (L.)) (Diptera: Stratiomyidae) (BSF). WASTE MANAGEMENT (NEW YORK, N.Y.) 2020; 117:58-80. [PMID: 32805602 DOI: 10.1016/j.wasman.2020.07.050] [Citation(s) in RCA: 82] [Impact Index Per Article: 20.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/01/2020] [Revised: 07/15/2020] [Accepted: 07/24/2020] [Indexed: 06/11/2023]
Abstract
Population growth and unprecedented economic growth and urbanization, especially in low- and middle-income countries, coupled with extreme weather patterns, the high-environmental footprint of agricultural practices, and disposal-oriented waste management practices, require significant changes in the ways we produce food, feed and fuel, and manage enormous amounts of organic wastes. Farming insects such as the black soldier fly (BSF) (Hermetia illucens) on diverse organic wastes provides an opportunity for producing nutrient-rich animal feed, fuel, organic fertilizer, and biobased products with concurrent valorization of wastes. Inclusion of BSF larvae/pupae in the diets of poultry, fish, and swine has shown promise as a potential substitute of conventional feed ingredients such as soybean meal and fish meal. Moreover, the bioactive compounds such as antimicrobial peptides, medium chain fatty acids, and chitin and its derivatives present in BSF larvae/pupae, could also add values to the animal diets. However, to realize the full potential of BSF-based biorefining, more research and development efforts are necessary for scaling up the production and processing of BSF biomass using more mechanized and automated systems. More studies are also needed to ensure the safety of the BSF biomass grown on various organic wastes for animal feed (also food) and legalizing the feed application of BSF biomass to wider categories of animals. This critical review presents the current status of the BSF technology, identifies the research gaps, highlights the challenges towards industrial scale production, and provides future perspectives.
Collapse
Affiliation(s)
- K C Surendra
- Department of Molecular Biosciences and Bioengineering, University of Hawai'i at Mānoa, Honolulu, HI 96822, USA
| | - Jeffery K Tomberlin
- Department of Entomology, Texas A&M University, College Station, TX, 77843, USA
| | - Arnold van Huis
- Laboratory of Entomology, Wageningen University & Research, Wageningen, the Netherlands
| | - Jonathan A Cammack
- Department of Entomology, Texas A&M University, College Station, TX, 77843, USA
| | | | - Samir Kumar Khanal
- Department of Molecular Biosciences and Bioengineering, University of Hawai'i at Mānoa, Honolulu, HI 96822, USA.
| |
Collapse
|
26
|
Bessa LW, Pieterse E, Marais J, Hoffman LC. Why for feed and not for human consumption? The black soldier fly larvae. Compr Rev Food Sci Food Saf 2020; 19:2747-2763. [DOI: 10.1111/1541-4337.12609] [Citation(s) in RCA: 28] [Impact Index Per Article: 7.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/14/2020] [Revised: 07/08/2020] [Accepted: 07/09/2020] [Indexed: 12/15/2022]
Affiliation(s)
- Leah W. Bessa
- Department of Animal SciencesUniversity of Stellenbosch Stellenbosch South Africa
| | - Elsje Pieterse
- Department of Animal SciencesUniversity of Stellenbosch Stellenbosch South Africa
| | - Jeannine Marais
- Department of Food ScienceStellenbosch University Stellenbosch South Africa
| | - Louwrens C. Hoffman
- Department of Animal SciencesUniversity of Stellenbosch Stellenbosch South Africa
- Centre for Nutrition and Food SciencesQueensland Alliance for Agriculture and Food InnovationUniversity of Queensland, Coopers Plains Queensland Australia
| |
Collapse
|
27
|
Hasnol S, Lim JW, Wong CY, Lam MK, Ntwampe SKO. Liminal presence of exo-microbes inoculating coconut endosperm waste to enhance black soldier fly larval protein and lipid. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2020; 27:24574-24581. [PMID: 32350833 DOI: 10.1007/s11356-020-09034-2] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/06/2020] [Accepted: 04/22/2020] [Indexed: 06/11/2023]
Abstract
The anaerobic decomposition of coconut endosperm waste (CEW), residue derived from cooking, has been insidiously spewing greenhouse gasses. Thus, the bioconversion of CEW via in situ fermentation by exo-microbes from commercial Rid-X and subsequent valorization by black soldier fly larvae (BSFL) was the primary objective of the current study to gain sustainable larval lipid and protein. Accordingly, various concentrations of exo-microbes were separately homogenized with CEW to perform fermentation amidst feeding to BSFL. It was found that 2.50% of exo-microbes was the threshold amount entailed to assuage competition between exo-microbes and BSFL for common nutrients. The presence of remnant nutrients exuded from the fermentation using 2.50% of exo-microbes was confirmed to promote BSFL growth measured as maximum larval weight gained and growth rate. Although the BSFL could accumulate the highest protein (16 mg/larva) upon feeding with CEW containing 2.50% of exo-microbes, more lipid (13 mg/larva) was stored in employing 0.10% of exo-microbes because of minimum loss to metabolic processes while prolonging the BSFL in its 5th instar stage.
Collapse
Affiliation(s)
- Sabrina Hasnol
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia
| | - Jun Wei Lim
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia.
| | - Chung Yiin Wong
- Department of Fundamental and Applied Sciences, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia
| | - Man Kee Lam
- Department of Chemical Engineering, HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia
| | - Seteno K O Ntwampe
- School of Chemical and Minerals Engineering, North-West University, Private Bag X1290, Potchefstroom, 2520, South Africa
| |
Collapse
|
28
|
Potential of Black Soldier Fly Production for Pacific Small Island Developing States. Animals (Basel) 2020; 10:ani10061038. [PMID: 32560146 PMCID: PMC7341329 DOI: 10.3390/ani10061038] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/09/2020] [Revised: 06/02/2020] [Accepted: 06/12/2020] [Indexed: 12/24/2022] Open
Abstract
Organic waste such as food waste and livestock manure is a serious concern in the Pacific Islands, where landfills are overflowing and illegal dumping of waste threatens the fragile ecosystems. Organic waste also attracts filth flies, some of which are vectors for pathogens that cause human disease. The black soldier fly, Hermetia illucens, has tremendous potential for the Pacific Islands. Capable of digesting almost any organic matter and converting it into insect biomass, black soldier flies are already being used around the world to process organic waste into larvae. The system can be adapted to large-scale municipal composting as well as small sizes for individual livestock farms or even urban households. The larvae can be fed live to fish or poultry, processed into feed comparable to fishmeal or soy meal, or even used to generate biofuel. Thus, the fly not only eliminates waste, but also can improve the sustainability of livestock production. The Pacific Small Island Developing States stand to benefit immensely from black soldier fly bioconversion facilities, used primarily as a means to compost organic waste; however, several knowledge gaps must first be addressed. We reviewed the state of black soldier flies in the Pacific and identified where their use shows the most promise. Research priorities for the field include fly surveys and bioconversion assays using Pacific crop waste.
Collapse
|
29
|
Wong CY, Lim JW, Chong FK, Lam MK, Uemura Y, Tan WN, Bashir MJK, Lam SM, Sin JC, Lam SS. Valorization of exo-microbial fermented coconut endosperm waste by black soldier fly larvae for simultaneous biodiesel and protein productions. ENVIRONMENTAL RESEARCH 2020; 185:109458. [PMID: 32247911 DOI: 10.1016/j.envres.2020.109458] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/24/2020] [Revised: 03/19/2020] [Accepted: 03/27/2020] [Indexed: 06/11/2023]
Abstract
The conventional practice in enhancing the larvae growths is by co-digesting the low-cost organic wastes with palatable feeds for black soldier fly larvae (BSFL). In circumventing the co-digestion practice, this study focused the employment of exo-microbes in a form of bacterial consortium powder to modify coconut endosperm waste (CEW) via fermentation process in enhancing the palatability of BSFL to accumulate more larval lipid and protein. Accordingly, the optimum fermentation condition was attained by inoculating 0.5 wt% of bacterial consortium powder into CEW for 14-21 days. The peaks of BSFL biomass gained and growth rate were initially attained whilst feeding the BSFL with optimum fermented CEW. These were primarily attributed by the lowest energy loss via metabolic cost, i.e., as high as 22% of ingested optimum fermented CEW was effectively bioconverted into BSFL biomass. The harvested BSFL biomass was then found containing about 40 wt% of lipid, yielding 98% of fatty acid methyl esters of biodiesel upon transesterification. Subsequently, the protein content was also analyzed to be 0.32 mg, measured from 20 harvested BSFL with a corrected-chitin of approximately 8%. Moreover, the waste reduction index which represents the BSFL valorization potentiality was recorded at 0.31 g/day 20 BSFL. The benefit of fermenting CEW was lastly unveiled, accentuating the presence of surplus acid-producing bacteria. Thus, it was propounded the carbohydrates in CEW were rapidly hydrolysed during fermentation, releasing substantial organic acids and other nutrients to incite the BSFL assimilation into lipid for biodiesel and protein productions simultaneously.
Collapse
Affiliation(s)
- Chung Yiin Wong
- Department of Fundamental and Applied Sciences, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia; HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia
| | - Jun Wei Lim
- Department of Fundamental and Applied Sciences, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia; HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia.
| | - Fai Kait Chong
- Department of Fundamental and Applied Sciences, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia
| | - Man Kee Lam
- HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia; Department of Chemical Engineering, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia
| | - Yoshimitsu Uemura
- HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Universiti Teknologi PETRONAS, 32610, Seri Iskandar, Perak Darul Ridzuan, Malaysia; NPO Kuramae Bioenergy, 3-3-6 Shibaura, Minato-ku, Tokyo, 108-0023, Japan
| | - Wen Nee Tan
- Chemistry Section, School of Distance Education, Universiti Sains Malaysia, 11800, Minden, Penang, Malaysia
| | - Mohammed J K Bashir
- Department of Environmental Engineering, Faculty of Engineering and Green Technology (FEGT), Universiti Tunku Abdul Rahman, 31900, Kampar, Perak Darul Ridzuan, Malaysia
| | - Sze Mun Lam
- Department of Environmental Engineering, Faculty of Engineering and Green Technology (FEGT), Universiti Tunku Abdul Rahman, 31900, Kampar, Perak Darul Ridzuan, Malaysia
| | - Jin Chung Sin
- Department of Petrochemical Engineering, Faculty of Engineering and Green Technology (FEGT), Universiti Tunku Abdul Rahman, 31900, Kampar, Perak Darul Ridzuan, Malaysia
| | - Su Shiung Lam
- Pyrolysis Technology Research Group, Institute of Tropical Aquaculture and Fisheries (Akuatrop) & Institute of Tropical Biodiversity and Sustainable Development (Bio-D Tropika), Universiti Malaysia Terengganu, 21030, Kuala Terengganu, Terengganu, Malaysia; Henan Province Engineering Research Center for Biomass Value-added Products, School of Forestry, Henan Agricultural University, Zhengzhou, 450002, China.
| |
Collapse
|
30
|
A Review on Insights for Green Production of Unconventional Protein and Energy Sources Derived from the Larval Biomass of Black Soldier Fly. Processes (Basel) 2020. [DOI: 10.3390/pr8050523] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/16/2022] Open
Abstract
The purpose of this review is to reveal the lipid and protein contents in black soldier fly larvae (BSFL) for the sustainable production of protein and energy sources. It has been observed from studies in the literature that the larval lipid and protein contents vary with the rearing conditions as well as the downstream processing employed. The homogenous, heterogenous and microbial-treated substrates via fermentation are used to rear BSFL and are compared in this review for the simultaneous production of larval protein and biodiesel. Moreover, the best moisture content and the aeration rate of larval feeding substrates are also reported in this review to enhance the growth of BSFL. As the downstream process after harvesting starts with larval inactivation, various related methods have also been reviewed in relation to its impact on the quality/quantity of larval protein and lipids. Subsequently, the other downstream processes, namely, extraction and transesterification to biodiesel, are finally epitomized from the literature to provide a comprehensive review for the production of unconventional protein and lipid sources from BSFL feedstock. Incontrovertibly, the review accentuates the great potential use of BSFL biomass as a green source of protein and lipids for energy production in the form of biodiesel. The traditional protein and energy sources, preponderantly fishmeal, are unsustainable naturally, pressingly calling for immediate substitutions to cater for the rising demands. Accordingly, this review stresses the benefits of using BSFL biomass in detailing its production from upstream all the way to downstream processes which are green and economical at the same time.
Collapse
|
31
|
Potential Protein and Biodiesel Sources from Black Soldier Fly Larvae: Insights of Larval Harvesting Instar and Fermented Feeding Medium. ENERGIES 2019. [DOI: 10.3390/en12081570] [Citation(s) in RCA: 51] [Impact Index Per Article: 10.2] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 01/05/2023]
Abstract
Primarily produced via transesterification of lipid sources, fatty acid methyl ester (FAME) of biodiesel derived from insect larvae has gained momentum in a great deal of research done over other types of feedstock. From the self-harvesting nature of black soldier fly larvae (BSFL), research had, however, only concentrated on the harvest of BSFL on sixth instar. Through rearing BSFL on coconut endosperm waste (CEW), 100 BSFL were harvested at the fifth and sixth instar, then modification on CEW with mixed-bacteria powder was carried out. It was found that the fifth instar BSFL had 34% lipid content, which was 8% more than the sixth instar. Both instars had similar corrected protein contents around 35–38%. The sixth instar BSFL contained around 19% of chitin, which was about 11% more than the fifth instar. Biodiesel products from both instars showed no differences in terms of FAME content. With modification on CEW, at 0.5 wt% of mixed-bacteria powder concentration, the maximum waste-to-biomass conversion (WBC) and protein conversion (PC) were achieved at 9% and 60%, respectively. Moreover, even with the shorter fermentation time frame of CEW, it did not affect the development of BSFL in terms of its WBC and PC when fed with 14 and 21 days fermented medium. FAME from all groups set, which predominantly constituted about C12:0 at around 60%, followed by C14:0 at around 15%, C16:0, and C18:1 both at 10% on average. Lastly, the FAME yield from BSFL was improved from 25% (sixth instar) to 33% (fifth instar) and showed its highest at 38.5% with modification on raw CEW with 0.5 wt% mixed-bacteria powder and fermented for 21 days. Thus, harvesting BSFL at earlier instar is more beneficial and practical, as it improves the FAME yield from the BSFL biomass.
Collapse
|