Formation of microbial products by activated sludge in the presence of a metabolic uncoupler o-chlorophenol in long-term operated sequencing batch reactors

Significant in situ sludge yield reduction in an acidic activated sludge system

Minimizing sludge generation in activated sludge systems is critical to reducing the operational cost of wastewater treatment plants (WWTPs), particularly for small plants where bioenergy is not recovered. This study introduces a novel acidic activated sludge technology for in situ sludge yield reduction, leveraging acid-tolerant ammonia-oxidizing bacteria (Candidatus Nitrosoglobus). The observed sludge yield (Yobs) was calculated based on the cumulative sludge generation and COD removal during 400 d long-term operation. The acidic process achieved a low Yobs of 0.106 ± 0.004 gMLSS/gCOD at pH 4.6 to 4.8 and in situ free nitrous acid (FNA) of 1 to 3 mg/L, reducing sludge production by 58 % compared to the conventional neutral-pH system (Yobs of 0.250 ± 0.003 gMLSS/gCOD). The acidic system also maintained effective sludge settling and organic matter removal over long-term operation. Mechanism studies revealed that the acidic sludge displayed higher endogenous respiration, sludge hydrolysis rates, and higher soluble microbial products and loosely-bounded extracellular polymer substances, compared to the neutral sludge. It also selectively enriched several hydrolytic genera (e.g., Chryseobacterium, Acidovorax, and Ottowia). Those results indicate that the acidic pH and in situ FNA enhanced sludge disintegration, hydrolysis, and cryptic growth. Besides, a lower intracellular ATP content was observed for acidic sludge than neutral sludge, suggesting potential decoupling of catabolism and anabolism in the acidic sludge. These findings collectively demonstrate that the acidic activated sludge technology could significantly reduce sludge yield, contributing to more cost- and space-effective wastewater management.

Carbon metabolism characteristics of quorum quenching bacteria Rhodococcus sp. BH4 determine the bioaugmentation efficiency under different carbon source conditions

Carbon sources are critical factors influencing bacterial bioaugmentation, however, the underlying mechanisms, particularly the metabolic characteristics of bioaugmented bacteria remain poorly understood. The bioaugmented bacterium Rhodococcus sp. BH4 secretes the quorum quenching (QQ) enzyme QsdA to disrupt the quorum sensing (QS) in the activated sludge (AS) process, reducing AS yield in-situ. This study investigated the carbon metabolic characteristics of BH4 and explored the effects on bioaugmentation with different influent carbon sources. Because of the absence of glucose-specific phosphoenol phosphotransferase system (PTS), BH4 prefers sodium acetate to glucose. However, the lactones produced during extracellular glucose metabolism enhance BH4 qsdA expression. Moreover, BH4 possess carbon catabolite repression (CCR), acetate inhibits glucose utilization. BH4 microbeads were added to reactors with different carbon sources (R1: sodium acetate; R2: glucose; R3: a mixture of sodium acetate and glucose) for in-situ AS yield reduction. During operation, AS reduction efficiency decreased in the following order: R1 > R3 > R2. R2 and R3 microbeads exhibited similar QQ activity to R1, with less BH4 biomass at 5 d. 13C labeling and Michaelis-Menten equation showed that, due to differences in the competitiveness of carbon sources, R1 BH4 obtained the most carbon, whereas R2 BH4 obtained the least carbon. Moreover, acetate inhibited glucose utilization of R3 BH4. Transcriptome analysis showed that R1 BH4 qsdA expression was the lowest, R2 BH4 was the most serious form of programmed cell death, and the R3 BH4 PTS pathway was inhibited. At 10 d, R1 BH4 biomass and microbead QQ activity were higher than that in R3, and the R2 BH4 lost viability and QQ activity. This study provides new insights into bioaugmentation from the perspectives of carbon source competitiveness, carbon metabolism pathways, and CCR.

Achieving simultaneous nitrification and endogenous denitrifying phosphorus removal in anaerobic/intermittently-aerated moving bed biofilm reactor for low carbon-to-nitrogen ratio wastewater treatment

In this study, an anaerobic/intermittently-aerated moving bed biofilm reactor (AnIA-MBBR) was proposed to realize simultaneous nitrification and endogenous denitrifying phosphorus removal (SNEDPR) in treating low carbon-to-nitrogen (C/N) ratio wastewater. The effect of different intermittent aeration modes (short and long aeration) on nutrients' removal was investigated. With the C/N ratio around 3, the removal efficiencies of total nitrogen and phosphorus were 90% and 74%, 88% and 59%, respectively, for short aeration and long aeration. The different aeration time also altered the nutrients' degradation pathway, biofilm characteristics, microbial community, and functional metabolic pathways. The results confirmed the occurrence of aerobic denitrifiers, anoxic denitrifiers, phosphorus accumulating organisms, glycogen accumulating organisms in AnIA-MBBR systems and their synergistic performance induced the SNEDPR. These results indicated that the application of AnIA in MBBR systems was an effective strategy to achieve SNEDPR, providing better simultaneous removal performance of nitrogen and phosphorus from low C/N ratio wastewater.

The response of nitrifying activated sludge to chlorophenols: Insights from metabolism and redox homeostasis

The specialized wastewater treatment plants for the chemical industry are rapidly developed in China and many other countries. But there is a common bottleneck in that the toxic pollutants in chemical wastewater often cause shock impacts on biological nitrogen removal systems, which directly affects the stability and cost of operation. As the research on nitrification inhibition characteristics is not sufficient till now, there is a great lack of theoretical guidance on the control of the inhibition. This study investigated the response of nitrifying activated sludge to chlorophenols (CPs) inhibition in terms of metabolism disorder and oxidative stress. At the initial stage of reaction (i.e., 1 h), reactive oxygen species (ROS)-induced membrane damage which might account for declining nitrification performance. Simultaneously excessive extracellular polymeric substances (EPS) were secreted to alleviate oxidative stress injury and protected microorganisms to some extent. In particular tyrosine-like substances in LB-EPS with a Fmax increase of 242.30% were confirmed to efficiently resist phenols inhibition. Thus, as the inhibition proceeded, metabolism disorder replaced oxidative stress as the main cause of nitrification inhibition. The affected metabolic processes include weakened enzyme catalysis, restricted electron transport and lessened energy generation. At 4 h, nitrifying production of sludge amended with 5 mg/L chlorophenols was 89.27 ± 9.51%-98.15 ± 9.60% lower than blank, the inhibition could be attributed to comprehensively affected metabolism. The structural equation modeling indicated that phenols restricted nitrification enzymes and bacterial electron transport efficiency which was critical to nitrification performance. Moreover, the lessened energy generation weakens enzyme activity to further suppress nitrification. These findings enriched our knowledge of nitrifiers' responses to CPs inhibition and provided the basis for addressing nitrification inhibition.

Recovery of phosphorus from wastewater containing humic substances through vivianite crystallization: Interaction and mechanism analysis

Vivianite crystallization has been regarded as a suitable option for recovering phosphorus (P) from P-containing wastewater. However, the presence of humic substances (HS) would inevitably affect the formation of vivianite crystals. Therefore, the influences of HS on vivianite crystallization and the changes in the harvested vivianite crystals were investigated in this study. The results suggested the inhibition effect of 70 mg/L HS on vivianite crystallization reached 12.24%, while it could be attenuated by increasing the pH and Fe/P ratio of the solution. Meanwhile, the addition of HS altered the size, purity, and morphology of recovered vivianite crystals due to the blockage of the growth sites on the crystal surface. Additionally, the formation of phosphate ester group, hydrogen bonding, and COOH-Fe²⁺ complexes are the potential mechanisms of HS interaction with vivianite crystals. The results obtained herein will help to elucidate the underlying mechanism of HS on vivianite crystallization from P-containing wastewater.

Mechanism insights into enhanced treatment of wasted activated sludge by hydrogen-mediated anaerobic digestion

In the current study, different forms of added gas including H₂, CO₂, and mixed gas (V_H2:V_CO2 = 4:1), as well as different hydrogen partial pressures (0.10, 0.30, and 0.50 atm) were investigated for the influence on anaerobic performance in waste activated sludge (WAS) treatment. The mixed gas significantly improved methane production by over 20%, which positively correlated with the hydrogen partial pressure. However, pure H₂ (0.5 atm) heavily inhibited methane production by 76.5%. Combined with the microbial metabolic activity study, H₂ accelerated the hydrolysis process. Afterward, mixing with CO₂ accelerated H₂ and organic consumption, thus promoting WAS degradation and methane production. Based on the most extra release of organics, the mixed group exerted the superior performance with hydrogen partial pressure at 0.3 atm. The microbial community analysis evidenced that mixed gas enriched proteolytic and homoacetogenic bacteria and hybrid-trophic methanogens. By metagenomics study, hydrolysis, acetogenic, and methanogenesis pathways were all enhanced via the exogenous addition of H₂ and CO₂, sustainably transforming WAS towards CH₄. This study discovered the mechanism of the enhanced conversion from WAS to CH₄ by exogenous H₂ and provided a promising approach for WAS reduction and energy recovery.

Re-circulation of Fe/persulfate regulated sludge fermentation products for sewage treatment: Focus on pollutant removal efficiency, microbial community and metabolic activity

Persulfate (PS)-based technologies have been demonstrated as efficient methods for enhancing the performance of waste activated sludge (WAS) anaerobic fermentation. Except for volatile fatty acids (VFAs), however, some exogenous substances would be also released during this process, which might affect its application as a carbon source for sewage treatment. To fill this knowledge gap, the feasibility of sludge fermentation liquid regulated by Fe/persulfate (PS) (PS-FL) as a carbon source for sewage treatment was investigated in this study. Results indicated that PS-FL exhibits distinct effects on the pollutants removal compared with commercial sodium acetate. It facilitates PO₄^3--P removal but slightly inhibited COD removal & denitrification, and sludge settleability was also decreased. The mechanistic analysis demonstrated that PS-FL could stimulate the enrichment of phosphorus-accumulating bacteria (i.e. Candidatus Accumulibacter) and the enhancement of their metabolic activities (i.e. PKK), thereby enhancing the biological PO₄^3--P removal. Moreover, Fe ions in PS-FL could combine with PO₄^3--P to form a precipitate and thus further contributed to PO₄^3--P removal. Conversely, the sulfate reduction process induced by SO₄^2- in PS-FL inhibits denitrification by reducing the abundance of denitrifying bacteria (i.e. Dechloromonas) and metabolic activities (i.e. narG). Additionally, PS-FL also decreased the abundance of flocculation bacteria (i.e. Flavobacterium) and down-regulated the expression of functional genes responsible for COD removal, by which it exhibited certain negative effects on COD removal and sludge settleability. Overall, this work demonstrated that PS-FL can re-circulation as a carbon source for sewage treatment, which provides a new approach to recovering valuable carbon sources from WAS.

Nitrogen removal by Rhodococcus sp. SY24 under linear alkylbenzene sulphonate stress: Carbon source metabolism activity, kinetics, and optimum culture conditions

Artificial intervention combined with stress acclimation was used to screen a heterotrophic nitrifying-aerobic denitrifying (HN-AD) bacterial, strain Rhodococcus SY24, resistant to linear alkylbenzenesulfonic acid (LAS) stress. When LAS was<15 mg/L, strain SY24 performed better cell growth and carbon source metabolism activity. The maximum nitrification and denitrification rates of SY24 under LAS stress could reach 1.18 mg/L/h and 1.05 mg/L/h, respectively, which were 13.80 % and 8.81 % higher than those of the original strain CPZ24. Higher LAS tolerance was seen in the functional genes (amoA, nxrA, napA, narG, nirK, nirS, norB, and nosZ). Response surface modeling revealed that 2 mg/L LAS, sodium succinate as a carbon source, 190 rams, and carbon/nitrogen 11 were the ideal culture conditions for SY24 to nitrogen removal under the LAS environment. This study offered a new screening strategy for the functional species, and strain SY24 showed significant LAS tolerance and HN-AD potential.

Sludge reduction and microbial community evolution of activated sludge induced by metabolic uncoupler o-chlorophenol in long-term anaerobic-oxic process

Excess sludge management is a restrictive factor for the development of municipal wastewater treatment plants. The addition of metabolic uncouplers has been proven to be effective in sludge reduction. However, the long-term effect of metabolic uncoupler o-chlorophenol (oCP) on the biological wastewater treatment system operated in anaerobic-oxic mode is still unclear. To this end, two parallel reactors operated in anaerobic-oxic mode with and without 10 mg/L of oCP addition were investigated for 91 days. The results showed that 56.1 ± 2.3% of sludge reduction was achieved in the oCP-added system, and the nitrogen and phosphorus removal ability were negatively affected. Dosing oCP stimulated the formation of microbial products and increased the DNA concentration, but resulted in a decrease in the electronic transport activity of activated sludge. Microbial community analysis further demonstrated that a significant reduction of bacterial richness and diversity occurred after oCP dosing. However, after stopping oCP addition, the pollutant removal ability of activated sludge was gradually increased, but the sludge yield, as well as species richness and diversity, did not recover to the previous level. This study will provide insightful guidance on the long-term application of metabolic uncouplers in the activated sludge system.

Investigation of an intermittently-aerated moving bed biofilm reactor in rural wastewater treatment under low dissolved oxygen and C/N condition

An intermittently-aerated moving bed biofilm reactor (MBBR) was proposed for nitrogen and carbon removal from low C/N synthetic rural wastewater. In purposes of low energy consumption and costs, the intermittent aeration modes were changed and the dissolved oxygen was reduced gradually during the operation. The results showed that effluent concentrations of ammonia nitrogen and chemical oxygen demand were lower than 15 and 50 mg/L, respectively, even under microaerobic condition (0.1-1.0 mg/L). Meanwhile, the simultaneous nitrification-denitrification was achieved by intermittent aeration. The activity of functional bacteria was still high and the proportion of autotrophic biomass increased significantly under intermittent micro-aeration mode, which improved the nitrification performance. Aerobic denitrifier Hydrogenophaga, anoxic denitrifier Thiothrix, and heterotrophic nitrifier such as Rhodobacter were enriched in the intermittently micro-aerated MBBR, which will provide an applicable solution for rural wastewater treatment under low C/N and costs.

Effects of the metabolic uncoupler TCS on residual sludge treatment: Analyses of the microbial community and sludge dewaterability potential

Residual sludge is a by-product with a large volume and complex composition from wastewater treatment plants. It is significant to reduce sludge volume to decrease the negative effects of sludge on environmental pollution and needless land use. We investigated the effects of uncoupler 3, 3', 4', 5-tetrachlorosalicylanilide (TCS) on the properties of sludge. After adding 0.12 g TCS/g VSS with 24 h mixing, the sludge concentration and total ATP content decreased by 51.1% and 60.8%, respectively. At the same time, the microbial community also changed significantly, leading to the decrease of richness and diversity. Additionally, the secretion of extracellular polymeric substances (EPS) reduced approximately 43% under the addition of 0.12 g/g VSS compared with the control. The decrement of EPS may be explained by the decreased relative abundance of functional bacteria (i.e. Chloroflexi reduced about 60% and Nitrospirota reduced about 31%). Notably, the addition of TCS before coagulation conditioning (FeCl₃) promoted the adhesion of sludge flocs according to the theory of Extended Derjaguin Landau Verwey Overbee (XDLVO), leading to the increased hydrophobicity of the residual sludge. Therefore, energy uncoupling has the potential of improving sludge dewaterability.

Insight investigation of the on-site activated sludge reduction induced by metabolic uncoupler: Effects of 2,6-dichlorophenol on soluble microbial products, microbial activity, and environmental impact

Metabolic uncoupling technology was one of the methods widely used to on-site control the production of excess sludge in wastewater treatment processes. However, the uncoupler effects on soluble microbial products (SMP), microbial activity, and environment impact have few been reported. This study showed that sludge yield was reduced by 33.3% at 2,6-dichlorophenol (2,6-DCP) concentrations of 10 mg/L. The addition of 2,6-DCP also reduced the content of polysaccharide and protein in SMP, and the three-dimension excitation emission matrix (3D-EEM) suggested that the fluorescence intensities of humic acid-like, fulvic acid-like, and tryptophan protein-like substances decreased, proving that 2,6-DCP addition will weaken the interaction between microorganisms and the environmental matrix. Moreover, 2,6-DCP addition will change the microbial morphology and community of activated sludge. The active or respiring bacteria portion was lessened, and sludge flocs become dispersed, but it will not affect its settling performance. Surprisingly, 2,6-DCP has certain biodegradability and could be used as an environmentally friendly metabolic uncoupler under low-concentration dosing conditions. This study systematically evaluated the effect of 2,6-DCP on sludge production, SMP contents, microbial morphology, microbial community, demonstrating the environmental impact and application feasibility in the wastewater treatment systems.

Biological-based control strategies for MBR membrane biofouling: a review

Membrane bioreactor (MBR) technology has been paid extensive attention for wastewater treatment because of its advantages of high effluent quality and minimized occupation space and sludge production. However, the membrane fouling is always an inevitable problem, which causes high operation and maintenance costs and prevents the wide use of MBR technology. The membrane biofouling is the most complicated and has relatively slow progress among all types of fouling. In recent years, many membrane biofouling control methods have been developed. Different from the physical or chemical methods, the biological-based strategies are not only more effective for membrane biofouling control, but also milder and more environment-friendly and, therefore, have been increasingly employed. This paper mainly focuses on the mechanism, unique advantages and development of biological-based control strategies for MBR membrane biofouling such as quorum quenching, uncoupling, flocculants and so on. The paper summarizes the up-to-date development of membrane biofouling control strategies, emphasizes the advantages and promising potential of biological-based ones, and points out the direction for future studies.

Influence of polyether sulfone microplastics and bisphenol A on anaerobic granular sludge: Performance evaluation and microbial community characterization

The retention of polyether sulfone (PES) and bisphenol A (BPA) in wastewater has received extensive attention. The effects of PES and BPA on the removal of organic matter by anaerobic granular sludge were investigated. We also analyzed the changes in the electron transport system and the effects on the composition of extracellular polymeric substances (EPS), as well as alternations of the microbial community in the anaerobic granular sludge. In the experimental groups which received BPA, the removal of the chemical oxygen demand (COD) were significantly suppressed, which an average removal efficiency of less than 65%, 30% lower than that of the control group. In the loosely-bound EPS (LB-EPS) excitation-emission matrix (EEM) spectra, the absorption peak of tryptophan disappeared when the BPA pollutants was added, which it was present in the control group without added pollutants. The addition of PES and BPA also affected protease, acetate kinase, and coenzyme F₄₂₀ activities in the anaerobic granular sludge. Especially, the coenzyme F₄₂₀ reduced from 0.0045 to 0.0017 μmol/L in the presence of PES and BPA. The relative abundance of Spirochaetes decreased in the presence of PES and BPA, while the relative abundance of Bacteroidetes increased from 12.98% to 22.87%. At the genus level, in the presence of PES and BPA, the relative abundance of Acinetobacter increased from 2.20% to 9.64% and Hydrogenophaga decreased sharply from 15.58% to 0.12%.

Deterioration of biological pollutants removal induced by linear alkylbenzene sulphonates in sequencing batch reactors: Insight of sludge characteristics, microbial community and metabolic activity

Linear alkylbenzene sulfonates (LAS) are widely detected in wastewater, and pose potential risks to environment. The influences of LAS on the typical pollutants removal in sequencing batch reactors (SBRs) were evaluated. The results indicated that the removal efficiency of COD, NH₄⁺ and PO₄^3- was respectively reduced by 10.5-27.5%, 5.4-7.3% and11.6-28.9% with the exposure of 10-50 mg/L LAS. Mechanisms investigation found that LAS disrupted the sludge structure and reduced the biomass in reactors due to the saponification effects. Also, the presence of LAS altered the microbial community of activated sludge, and reduced the abundances of functional bacterial responsible for pollutants removal (i.e.Candidatus Accumulibacter, Nitrospira, Denitratisoma and etc.). Moreover, the LAS exhibited negative impacts on the microbial activity with increased LDH release but decreased ATP concentration. The genes expressions for microbial metabolism (i.e. carbohydrate metabolisms, energy metabolism) and typical pollutants removal (i.e. electron transport, phosphonate transport) were all downregulated in LAS-exposed SBRs.

Nitrifying biomass can retain its acclimation to 2,4,6-trichlorophenol

Many municipal wastewater treatment plants in China receive industrial wastewater that contains inhibitory organic chemicals, such as chlorinated phenols. For the common aerobic biological treatment, nitrification is a key step, but nitrifying bacteria are notably sensitive to inhibition by chlorinated phenols. In this work, normal activated sludge (containing nitrifying biomass) was acclimated to 2,4,6-trichlorophenol (TCP). The acclimated biomass had more than 2-fold faster nitrification kinetics than normal biomass when exposed to TCP, and it also achieved effective TCP removal in parallel. When suddenly exposed to TCP after as much as two months without TCP input, the acclimated nitrifying biomass retained effective nitrification and TCP biodegradation: The nitrification rate and TCP removal rate were 0.325 mM/h and 0.049 mM/h for the acclimated biomass, compared to only 0.165 mM/h and 0.001 mM/h for normal biomass. Resistance to TCP inhibition also was retained for 5 generations of sub-culturing without TCP exposure. High-throughput sequencing confirmed that the acclimated biomass contained nitrifying bacteria and heterotrophic bacteria capable of degrading TCP, although the key genera changed during sub-culturing.

Examination of Photocatalyzed Chlorophenols for Sequential Photocatalytic-Biological Treatment Optimization

Given the known adverse effect of chlorophenols for the aquatic environments which they can reach, the development of efficient methods both technically and economically to remove them has gained increasing attention over time. The combination of photocatalytic oxidation with biological treatment can lead to high removal efficiencies of chlorophenols, while reducing the costs associated with the need to treat large volumes of aqueous solutions. Therefore, the present paper had as its main objective the identification of the minimum photocatalytic oxidation period during which the aqueous solutions of 4-chlorophenol and 2,4-dichlorophenol can be considered as readily biodegradable. Thus, the results of photocatalytic oxidation and biodegradability tests showed that, regardless of the concentration of chlorophenol and its type, the working solutions become readily biodegradable after up to 120 min of irradiation in ultraviolet light. At this irradiation time, the maximum organic content of the aqueous solution is less than 40%, and the biochemical oxygen demand and chemical oxygen demand (BOD/COD) ratio is much higher than 0.4. The maximum specific heterotrophic growth rate of activated sludge has an average value of 4.221 d−1 for 4-chlorophenol, and 3.126 d−1 for 2,4-dichlorophenol. This irradiation period represents at most half of the total irradiation period necessary for the complete mineralization of the working solutions. The results obtained were correlated with the intermediates identified during the photocatalytic oxidation. It seems that, working solutions initially containing 4-chlorophenol can more easily form readily biodegradable intermediates.

Enhanced anaerobic digestion performance by two artificially constructed microbial consortia capable of woody biomass degradation and chlorophenols detoxification

Catalpa sawdust (CSW) is a promising biomass-based biofuel. However, the complex lignocellulosic structure limits its efficient utilization in biorefinery applications. It is even more so when chlorophenols (CPs), highly toxic organic substances widely used as wood preservatives, are present. Hence, it is crucial to develop effective and eco-friendly approaches to attain deconstruction of lignocellulose and chlorophenols simultaneously as well as to improve methane (CH4) production efficiently. This study might be the first to explore the performance of the novel constructed microbial consortia CS-5 and BC-4 on woody biomass degradation and CPs detoxification simultaneously with CH4 production. After the degradation of CSW and CPs for 15 days by C5-5 or BC-4, significant reduction in lignocellulosic components and CPs mixture was realized with a total weight loss of 69.2 and 56.3 % and CPs degradation of 89 and 95 %, respectively. The toxicity of individual or mixed CPs after 15 days of degradation was reduced by approximately 90 %. The synergistic action of CS-5 and BC-4 enhanced biogas and CH4 yields over 76 and 64 % respectively, higher than control. Furthermore, CH4 production increased by 113.7 % at the peak phase of AD process. Methanosataceae represented 45.1 % of the methanogenic Archaea in digester G-III.