The use of calcium carbonate beads containing gentamicin in the second stage septic revision of total knee arthroplasty reduces reinfection rate

Limitations and modifications in the clinical application of calcium sulfate

Calcium sulfate and calcium sulfate-based biomaterials have been widely used in non-load-bearing bone defects for hundreds of years due to their superior biocompatibility, biodegradability, and non-toxicity. However, lower compressive strength and rapid degradation rate are the main limitations in clinical applications. Excessive absorption causes a sharp increase in sulfate ion and calcium ion concentrations around the bone defect site, resulting in delayed wound healing and hypercalcemia. In addition, the space between calcium sulfate and the host bone, resulting from excessively rapid absorption, has adverse effects on bone healing or fusion techniques. This issue has been recognized and addressed. The lack of sufficient mechanical strength makes it challenging to use calcium sulfate and calcium sulfate-based biomaterials in load-bearing areas. To overcome these defects, the introduction of various inorganic additives, such as calcium carbonate, calcium phosphate, and calcium silicate, into calcium sulfate is an effective measure. Inorganic materials with different physical and chemical properties can greatly improve the properties of calcium sulfate composites. For example, the hydrolysis products of calcium carbonate are alkaline substances that can buffer the acidic environment caused by the degradation of calcium sulfate; calcium phosphate has poor degradation, which can effectively avoid the excessive absorption of calcium sulfate; and calcium silicate can promote the compressive strength and stimulate new bone formation. The purpose of this review is to review the poor properties of calcium sulfate and its complications in clinical application and to explore the effect of various inorganic additives on the physicochemical properties and biological properties of calcium sulfate.

Outcomes in revision knee arthroplasty: Preventing reoperation for infection Keynote lecture - BASK annual congress 2023

Revision total knee arthroplasty (TKA) patients have a lower survival rate and lower post-surgical outcomes compared to primary TKA patients. Infection and aseptic loosening are the most common reasons for revision and re-revision TKAs, with infection accounting for nearly half of re-revision cases. To prevent infection, patient optimization addressing obesity, diabetes, malnutrition, and smoking cessation is crucial. Advancements in irrigation solutions, antibiotic-impregnated bone fillers, bacteriophage therapy, and electrochemical therapy hold promise for preventing infection. Technical strategies such as obtaining sufficient component fixation, joint line restoration, and using robot assistance may improve revision TKA outcomes. As the burden of revision TKA continues to rise, substantial efforts remain for mitigating future revision TKAs and their associated complications.

Impact of scaffold granule size use in Masquelet technique on periosteal reaction: a study in rat femur critical size bone defect model

Purpose

The Masquelet technique for the treatment of large bone defects is a two-stage procedure based on an induced membrane. Compared to mature periosteum, the induced membrane differs significantly. However, both play a crucial role in bone regeneration. As part of a histological and radiological post-evaluation of an earlier project, we analyzed the influence of the granule size of the bone void filler Herafill^® on development of periosteum regrowth in a critical size defect.

Methods

We compared three different sizes of Herafill^® granules (Heraeus Medical GmbH, Wehrheim) in vivo in a rat femoral critical size defect (10 mm) treated with the induced membrane technique. After 8 weeks healing time, femurs were harvested and taken for histological and radiological analysis.

Results

A significantly increased regrowth of periosteum into the defect was found when small granules were used. Large granules showed significantly increased occurrence of bone capping. Small granules lead to significant increase in callus formation in the vicinity to the membrane.

Conclusion

The size of Herafill^® granules has significant impact on the development of periosteal-like structures around the defect using Masquelet’s induced membrane technique. Small granules show significantly increased regrowth of periosteum and improved bone formation adjacent to the induced membrane.

Salvage procedure for chronic periprosthetic knee infection: the application of DAIR results in better remission rates and infection-free survivorship when used with topical degradable calcium-based antibiotics

PURPOSE

Debridement, systemic antibiotics and implant retention (DAIR) is very successful for early periprosthetic joint infection (PJI), but can fail in late-onset cases. We selected patients with PJI who were unsuitable for two-stage exchange total knee arthroplasty (TKA) and compared the outcomes of DAIR with or without degradable calcium-based antibiotics.

METHODS

All patients fulfilled the criteria for late-onset PJI of TKA, as defined by an International Consensus Meeting in 2013, but were unsuitable for multistage procedures and TKA exchange due to operative risk. Fifty-six patients (mean age: 70.6 years, SD ± 10.8), in two historical collectives, were treated using a single-stage algorithm consisting of DAIR without antibiotics (control group, n = 33, 2012-2014), or by DAIR following the implantation of degradable antibiotics as indicated by an antibiogram (intervention group, n = 23, 2014-2017). OSTEOSET^® (admixed vancomycin/tobramycin), and HERAFILL-gentamicin^® were used as carrier systems. The primary endpoint was re-infection or surgical intervention after DAIR.

RESULTS

There were no significant differences between the two groups in terms of mean age, Charlson comorbidity index or the rate of mixed infections. Overall, 65.2% of patients achieved remission in the intervention group compared with only 18.2% in the control group (p < 0.001); 50% of re-infections in the intervention group even occurred after 36 months. Kaplan-Meier analysis showed that, compared with controls, the intervention group experienced significantly longer 3-year infection-free survival.

CONCLUSION

DAIR shows poor efficacy in difficult-to-treat cases, as demonstrated in our control group, which had a re-infection rate of 81.8%. In contrast, a DAIR group receiving topical calcium-based antibiotics showed significantly higher 3-year infection-free survival. Therefore, the combination of DAIR and degradable antibiogram-based local antibiotics is a reasonable salvage procedure for this body of patients. This is important as the number of severely sick patients who are too old for appropriate PJI treatment is estimated to increase significantly due to demographic change.

Size matters: Effect of granule size of the bone graft substitute (Herafill®) on bone healing using Masquelet's induced membrane in a critical size defect model in the rat's femur

The Masquelet technique for the treatment of large bone defects is a two-stage procedure based on an induced membrane. The size of a scaffold is reported to be a critical factor for bone healing response. We therefore aimed to investigate the influence of the granule size of a bone graft substitute on bone marrow derived mononuclear cells (BMC) supported bone healing in combination with the induced membrane. We compared three different sizes of Herafill® granules (Heraeus Medical GmbH, Wehrheim) with or without BMC in vivo in a rat femoral critical size defect. A 10 mm defect was made in 126 rats and a membrane induced by a PMMA-spacer. After 3 weeks, the spacer was taken out and membrane filled with different granule sizes. After 8 weeks femurs were taken for radiological, biomechanical, histological, and immunohistochemical analysis. Further, whole blood of the rat was incubated with granules and expression of 29 peptide mediators was assessed. Smallest granules showed significantly improved bone healing compared to larger granules, which however did not lead to an increased biomechanical stability in the defect zone. Small granules lead to an increased accumulation of macrophages in situ which could be assigned to the inflammatory subtype M1 by majority. Increased release of chemotactic respectively proangiogenic active factors in vitro compared to syngenic bone and beta-TCP was observed. Granule size of the bone graft substitute Herafill® has significant impact on bone healing of a critical size defect in combination with Masquelet's technique in terms of bone formation and inflammatory potential.

Success Rates of Revision Knee Arthroplasty for Periprosthetic Joint Infection in Rheumatoid and Non-Rheumatoid Arthritis Patients

This study evaluated the success and failure rates as well as the final results following 2-stage revision total knee arthroplasty (TKA) for periprosthetic joint infection (PJI). Particular emphasis was placed on comparing patients with rheumatoid arthritis (RA) and non-RA patients. A total of 140 knees that required 2-stage revision for PJI after TKA were analyzed. Mean patient age at first revision TKA was 67.9 years (range, 43 to 89 years), and mean time from second-stage revision to final follow-up was 53.3 months (range, 26 to 127 months). Thirty-eight of the 140 knees (27.1%) demonstrated recurrence of infection after first 2-stage revision. Of these, 8 required another 2-stage revision, 25 required knee arthrodesis, and 2 required amputation; 3 patients refused further treatment or were lost to follow-up. There was no recurrence of infection. No statistically significant differences were observed between the RA and non-RA groups in terms of success or failure rate (P=.6) according to Diaz-Ledezma and Knee Society Scores (P=.3). These findings indicate reinfection rates and final results were similar in RA and non-RA patients following revision TKA for PJI. [Orthopedics. 2019; 42(5):e472-e476.].

Reconsidering Strategies for Managing Chronic Periprosthetic Joint Infection in Total Knee Arthroplasty: Using Decision Analytics to Find the Optimal Strategy Between One-Stage and Two-Stage Total Knee Revision

BACKGROUND

Periprosthetic joint infection (PJI) following total knee arthroplasty is a growing concern, as the demand for total knee arthroplasty (TKA) expands annually. Although 2-stage revision is considered the gold standard in management, there is substantial morbidity and mortality associated with this strategy. One-stage revision is associated with lower mortality rates and better quality of life, and there has been increased interest in utilizing the 1-stage strategy. However, surgeons are faced with a difficult decision regarding which strategy to use to treat these infections, considering uncertainty with respect to eradication of infection, quality of life, and societal costs with each strategy. The purpose of the current study was to use decision analysis to determine the optimal decision for the management of PJI following TKA.

METHODS

An expected-value decision tree was constructed to estimate the quality-adjusted life-years (QALYs) and costs associated with 1-stage and 2-stage revision. Two decision trees were created: Decision Tree 1 was constructed for all pathogens, and Decision Tree 2 was constructed solely for difficult-to-treat infections, including methicillin-resistant infections. Values for parameters in the decision model, such as mortality rate, reinfection rate, and need for additional surgeries, were derived from the literature. Medical costs were derived from Medicare data. Sensitivity analysis determined which parameters in the decision model had the most influence on the optimal strategy.

RESULTS

In both decision trees, the 1-stage strategy produced greater health utility while also being more cost-effective. In the Monte Carlo simulation for Decision Trees 1 and 2, 1-stage was the dominant strategy in about 85% and 69% of the trials, respectively. Sensitivity analysis showed that the reinfection and 1-year mortality rates were the most sensitive parameters influencing the optimal decision.

CONCLUSIONS

Despite 2-stage revision being considered the current gold standard for infection eradication in patients with PJI following TKA, the optimal decision that produced the highest quality of life was 1-stage revision. These results should be considered in shared decision-making with patients who experience PJI following TKA.

LEVEL OF EVIDENCE

Economic and Decision Analysis Level IV. See Instructions for Authors for a complete description of levels of evidence.

[Local antibiotic therapy]

The treatment of superficial wound infections with local antibiotics is considered to be problematic as it is accompanied by an increased risk of resistance development and ineffectiveness in deeper regions. On the contrary, the local application of antibiotics is useful in arthroplasty and necessary if implants are utilized. The reason for this is the prevention of a rapid biofilm formation on foreign implants and a resulting infection may remain undiscovered until it becomes chronic. Apart from exogenous material, necrotic tissue (e. g. bone sequestra) provides suitable retreat areas for pathogens in the body. Because of the characteristics of bone and joint infections and an exceptional infection recurrence rate, a combined approach is required. Systemic antibiotic prophylaxis is able to reduce the number of pathogens acquired by perioperative contamination or hematogenic spread from another focus of infection; however, systemically applied antibiotics often fail to form an effective colonization barrier around the implant because their ability to penetrate the bone is relatively low. On the other hand, the high concentration of locally released antibiotics leads to an effective protection of the implant from bacteria in situ. Thus, for the treatment of implant-associated infections, systemic and local application of anti-infective agents is a reliable adjuvant measure that improves the therapeutic success. Polymethylmethacrylate (PMMA) bone cement is the most commonly used local drug carrier. Based on clinical and microbiological results, microbiologists and infectious disease experts together with the surgeon and pharmacist determine which anti-infective agents are indicated for systemic and local, PMMA cement-related application. Because there is no evident concept for the local application, unlike the recommendation for systemic use of anti-infective agents, this review article describes which aspects should be taken into account.

Procedure for single-stage implant retention for chronic periprosthetic infection using topical degradable calcium-based antibiotics

INTRODUCTION

Surgical treatment using DAIR (debridement, systemic antibiotics, and implant retention) can lead to high rates of treatment success in cases of early periprosthetic joint infection (PJI) but can fail in late-onset cases. Supplementary local antibiotic therapy is not yet generally established and lacks evidence-based proof of efficacy. The aim of this study was to analyze DAIR outcomes in recurrent PJI cases and patients who are not suitable for a two-stage exchange, using additional degradable calcium-based antibiotics.

METHODS

All patients fulfilled the Infectious Diseases Society of America (IDSA) guidelines for chronic late-onset PJI but were not suitable for a multistage procedure because of their individual operation risk. A total of 42 patients (mean age, 73 years) were treated using a single-stage algorithm consisting of DAIR, followed by implantation of degradable antibiotics chosen in accordance with an antibiogram. OSTEOSET® (admixed ceftriaxone/vancomycin/tobramycin) and Herafill-Gentamycin® were used as carrier systems. The follow-up period was 23 months (± SD, 10.3). The study is based on institutional review board (IRB) approval.

RESULTS

The clinical entities were chronic PJI of the hip (45.2%), knee (28.6%), and knee arthrodesis (26.2%). The bacterial spectrum was composed of Staphylococcus epidermidis (29%), Staphylococcus aureus (21%), and Enterococcus faecalis (21%). 21.4% showed a combination of two or more bacteria. In 73.8%, permanent remission was achieved, while 11.9% showed chronic PJI under implant retention. Implant retention could be achieved in 85.7%.

CONCLUSION

DAIR usually shows low levels of success in difficult-to-treat cases. However, we could demonstrate the successful treatment of patients with recurrent PJI (typically considered DAIR-inappropriate) using degradable antibiogram-based topical calcium-based antibiotics. Over 70% of the cases went to remission and over 85% of the implants could be retained.