Influence of putative polyphenoloxidase (PPO) inhibitors on strawberry (Fragaria x ananassa Duch.) PPO, anthocyanin and color stability of stored purées

Infrared radiation blanching-inhibited browning and extended shelf life of pecan kernels

To evaluate infrared radiation (IR) blanching in comparison to conventional hot water (HW) blanching in inhibiting the browning and extending the shelf life of pecan kernels, the technology of IR blanching at 500-700 W for 90-45 s or HW blanching at 90°C for 60 s, and subsequently drying with hot air at 60, 70, and 80°C, respectively, was used, and then the activities of lipoxidase (LOX) and polyphenol oxidase (PPO), antioxidant capacities, color change, microscopic structure, and the shelf life of kernels were analyzed. Results showed that IR blanching not only significantly decreased the subsequent drying time but also effectively inactivated the activities of LOX and PPO, showing a lower residual activity of 15.74%-40.41% and 16.75%-56.25%, respectively. A higher retention of total phenolics was observed in kernels subjected to IR blanching, from 25.03 ± 0.04 to 29.50 ± 0.96 mg GAE/g compared with HW blanching (14.43 ± 0.07 mg GAE/g). Meanwhile, IR-blanched samples showed lower peroxide values, p-anisidine values, total color difference values, browning index, quinones contents, and lipofuscin-like pigments levels but had higher 2,2-diphenyl-1-picrylhydrazyl inhibition rate and better storage stabilities than HW-blanched samples. The technology of IR blanching at 600 W for 60 s followed by drying with hot air at 70°C for 40 min is suitable for producing pecan kernels with better qualities and a longer shelf life, through inactivating the endogenous enzymatic reactions and inhibiting the formation of lipofuscin-like pigments. PRACTICAL APPLICATION: Blanching is an essential pretreatment of food processing. Conventional blanching is achieved by hot water, which has some disadvantages of low-intensity enzyme inactivation, loss of water-soluble substances, etc. In this study, the potential of using infrared blanching, prior to drying, was studied to find solutions to improve the nutritional value, and the shelf life of pecan kernels. The results showed that infrared blanching at 600 W for 60 s followed by drying with hot air at 70°C for 40 min could inhibit the color degradation, improve the oxidation resistance, and prolong the shelf life of kernels.

Advances in the Chemistry, Analysis and Adulteration of Anthocyanin Rich-Berries and Fruits: 2000-2022

Anthocyanins are reported to exhibit a wide variety of remedial qualities against many human disorders, including antioxidative stress, anti-inflammatory activity, amelioration of cardiovascular diseases, improvement of cognitive decline, and are touted to protect against neurodegenerative disorders. Anthocyanins are water soluble naturally occurring polyphenols containing sugar moiety and are found abundantly in colored fruits/berries. Various chromatographic (HPLC/HPTLC) and spectroscopic (IR, NMR) techniques as standalone or in hyphenated forms such as LC-MS/LC-NMR are routinely used to gauge the chemical composition and ensure the overall quality of anthocyanins in berries, fruits, and finished products. The major emphasis of the current review is to compile and disseminate various analytical methodologies on characterization, quantification, and chemical profiling of the whole array of anthocyanins in berries, and fruits within the last two decades. In addition, the factors affecting the stability of anthocyanins, including pH, light exposure, solvents, metal ions, and the presence of other substances, such as enzymes and proteins, were addressed. Several sources of anthocyanins, including berries and fruit with their botanical identity and respective yields of anthocyanins, were covered. In addition to chemical characterization, economically motivated adulteration of anthocyanin-rich fruits and berries due to increasing consumer demand will also be the subject of discussion. Finally, the health benefits and the medicinal utilities of anthocyanins were briefly discussed. A literature search was performed using electronic databases from PubMed, Science Direct, SciFinder, and Google Scholar, and the search was conducted covering the period from January 2000 to November 2022.

Postharvest treatments with MnCl2 and ZnCl2 reduce enzymatic browning and enhance antioxidant accumulation in soya bean sprout

Soya bean sprout is a nutrient-abundant vegetable. However, enzymatic browning of soya bean sprouts during storage remains a challenge. In this study, the effects of treatment with MnCl₂ or ZnCl₂ on the browning index, antioxidant nutrient accumulation, total antioxidant capacity and enzyme activities of phenylalanine ammonia-lyase (PAL), polyphenol oxidase (PPO), peroxidase (POD), superoxide dismutase (SOD) and catalase (CAT) were investigated in soya bean sprouts after storage at 4 °C and 90% relative humidity for 0, 7, 14 and 21 days. The results showed that postharvest treatment with 1, 2 and 10 mM MnCl₂ or ZnCl₂ profoundly retarded enzymatic browning in soya bean sprouts to different extents. Compared with the control, the 10 mM MnCl₂ and ZnCl₂ treatments drastically enhanced ascorbic acid, total thiol and phenolic content, and enhanced FRAP (ferric-reducing ability of plasma) antioxidant capacity in stored soya bean sprouts. Moreover, the MnCl₂ and ZnCl₂ treatments enhanced SOD, CAT and PAL but decreased PPO and POD activities compared with the control. In addition, the Mn and Zn content in soya bean sprouts significantly increased, by approximately two- to threefold, compared with the control. This study provides a new method for improving the nutrient quality of soya bean sprouts based on postharvest Mn or Zn supplementation.

Effects of Naringin on Postharvest Storage Quality of Bean Sprouts

This study investigated the effects of naringin on soybean and mung bean sprouts postharvest quality. It was found that naringin could maintain the appearance and quality of soybean sprouts and mung bean sprouts during a 6-day storage period as well as delay the occurrence of browning in mung bean sprouts and soybean sprouts. The optimal application rate of naringin was 50–100 μg/mL, which could effectively inhibit the activity of polyphenol oxidase (PPO) and peroxidase (POD) in bean sprouts and increase the ascorbic acid content, where this inhibition response to the browning of mung bean sprouts and soybean sprouts was significantly reduced. Naringin treatment increased gallic acid and p-coumaric acid content in mung bean sprouts as well as the daidzin and rutin content in soybean sprouts, which was also reflected in the improvement of antioxidant activity. The binding of naringin with PPO and POD was analyzed with molecular docking, naringin, and PPO had a lower binding energy (−1.09 Kcal/mol). In conclusion, naringin application in postharvest preservation of mung bean sprouts and soybean sprouts can maintain favorable consumer quality.

The mechanism of interaction between lotus rhizome polyphenol oxidase and ascorbic acid: Inhibitory activity, thermodynamics, and conformation analysis

In this study, the interaction between lotus rhizome polyphenol oxidase (PPO) and ascorbic acid (AA) was discussed from the aspects of inhibitory activity, thermodynamics, and conformation. Results showed that PPO was purified from lotus rhizome by DEAE-52 anion exchange chromatography and Sephadex G-100 gel filtration chromatography, with its optimum substrate being determined as pyrogallic acid. Spectrophotometric and polarographic assays demonstrated that AA exhibited strong inhibitory activity against PPO. Thermodynamics, fluorescence, and circular dichroism spectral analysis showed that hydrophobic interactions caused the formation of AA-PPO complex, leading to the remarkable fluorescence quenching and conformational change of PPO. Atomic force microscopic analysis revealed that binding to AA induced significant changes in the surface morphology and molecular aggregation of PPO molecules. In this study, the interaction mechanism between PPO and AA was proposed for the first time, which provided a theoretical basis for AA to inhibit lotus rhizome browning. PRACTICAL APPLICATIONS: Lotus rhizome, an aquatic vegetable, is prone to enzymatic browning in processing operations, which leads to a decrease in market value and economic loss. At present, ascorbic acid (AA) is widely used in industries as an excellent antioxidant because of its good antibrowning effect and relatively low cost. However, the interaction between the enzymatic browning-related polyphenol oxidase (PPO) from lotus rhizome and ascorbic acid has not been clearly studied. Understanding the mechanism of inhibiting PPO will help to prevent vegetable browning, especially fresh-cut products. The inhibitory effect of AA on PPO in lotus rhizome favors simultaneous use with other types of PPO inhibitors because of their likely synergistic effects.

Thermal processing under oxygen-free condition of blueberry puree: Effect on anthocyanin, ascorbic acid, antioxidant activity, and enzyme activities

The effect of thermal treatment of blueberry was investigated using a designed grinding and continuous packaging system under oxygen-free conditions. The grinding, packaging, and heating at 90 °C for 30 min under anaerobic condition were compared to heating under aerobic conditions, showing complete inactivation of oxidative enzymes. Heating without oxygen retained anthocyanins and ascorbic acid whereas heating in atmospheric air does not. Delphinidin glycoside was mostly influenced by oxygen deficiency during heating, followed by petunidin and malvidin glycosides. The differences in oxygen sensitivity may be closely associated with the number of hydroxylation in the B ring. The result of anthocyanin led to higher antioxidant activity and redness values of purees heated without oxygen than purees heated with oxygen. Consequently, thermal processing under oxygen-free condition can prevent oxidation of anthocyanin, resulting in higher retention of color and nutritional values of blueberry products.

Effect of Basil Leaves and Wheat Bran Water Extracts on Antioxidant Capacity, Sensory Properties and Microbiological Quality of Shredded Iceberg Lettuce during Storage

The effect of basil leaf (BLE) and wheat bran (WBE) extracts (potent anti-browning agents), on the phenolic content, antioxidant potential, microbiological quality, and consumer quality of shredded lettuce during storage were studied. Treatment of lettuce with increasing concentrations of BLE proportionally increased the total phenolic content and antioxidant properties. Compared to the control, the treatment enhanced the antiradical properties. This was especially visible during the analysis of the chemical extracts, while this effect was not retained in the potentially bioaccessible fraction. In the lettuce stored for 8 days, the highest reducing potential and ability to quench radicals were observed in samples treated with 1% BLE-33 mg Trolox equivalent/g d.m. and 2.8 mg Trolox equivalent/g d.m., respectively. Compounds exhibiting antiradical properties were easily bioaccessible in vitro. There was no negative effect of the treatments on the consumer quality. Most importantly, after 8 days of storage, lettuce treated with the studied extract, except 10% WBE, had higher microbiological quality. After 8-day storage, the coliforms count was reduced by 84% and 88% in samples treated with 0.5% BLE and 10% WBE, respectively. In conclusion, treatments of shredded lettuce with BLE and WBE maintain or even improve its quality during storage.

Inhibitory effects of organic acids on polyphenol oxidase: From model systems to food systems

Organic acids are widely utilized in the food industry for inhibiting the activity of polyphenol oxidase (PPO) and enzymatic browning. This review discusses the mechanisms of inhibition of PPO and enzymatic browning by various organic acids based on studies in model systems, critically evaluates the relevance of such studies to real food systems and assesses the implication of the synergistic inhibitory effects of organic acids with other physicochemical processing techniques on product quality and safety. Organic acids inhibit the activity of PPO and enzymatic browning via different mechanisms and therefore the suitability of a particular organic acid depends on the structure and the catalytic properties of PPO and the physicochemical properties of the food matrix. Studies in model systems provide an invaluable insight into the inhibitory mechanisms of various organics acids. However, the difference in the effectiveness of PPO inhibitors between model systems and food systems and the lack of correlation between the degree of PPO inhibition based on in vitro assays and enzymatic browning imply that the effectiveness of organic acids can be accurately evaluated only via direct assessment of browning inhibition in a particular food system. Combination of organic acids with physical processing techniques is one of the most viable approaches for PPO inhibition since the observed synergistic effect helps to reduce the undesirable organoleptic quality changes from the use of excessive concentration of organic acids or intense physical processing.

Chemical and physicochemical characterization of orange by-products derived from industry

BACKGROUND

Industrial extraction of orange juice produces a large amount of waste that affects the environment and gives rise to important economic losses; at the same time, information about the composition of the waste is still limited. The present study carried out an exhaustive chemical and physicochemical characterization of the residues in the waste, aiming to increase their potential application for the extraction of functional ingredients.

RESULTS

Four different products (three solids and one liqueur) were provided by the industry. The overall characterization indicated that carbohydrates comprised the main components. During processing, carbohydrate derivatives were formed such as those corresponding to the initial steps of the Maillard reaction. In this sense, furosine was demonstrated to be a suitable indicator with respect to the control of the process. Although the phenolic content substantially decreased (by up to 57%) as the processing proceeded, the antioxidant capacity was affected to a much lesser extent (∼10%). Dehydrated products were rich in galacturonic acid and hardly any change was detected during their elaboration. The liqueur by-product was found to have a much higher level of fructose than glucose and sucrose.

CONCLUSION

Orange juice waste obtained industrially under the conditions described in the present study could be used as a source of pectic derivatives or fructose in the case of solid or liquid by-products, respectively. The results reported here could diversify the present application of these products as a source of food ingredients, contributing to an improvement in their utilization. © 2018 Society of Chemical Industry.

Evaluation of microfiltration and heat treatment on the microbiological characteristics, phenolic composition and volatile compound profile of pomegranate (Punica granatum L.) juice

BACKGROUND

Since processing technology and storage may influence the sensory and nutritional value as well as the shelf life of pomegranate juice (PJ), mild technologies based on microfiltration may be a promising alternative to heat treatments for fruit juice preservation. In this study, physicochemical and microbiological properties of raw (RPJ), microfiltered (MPJ) and cloudy pasteurized (PPJ) PJ were compared over a period of 4 weeks.

RESULTS

Data demonstrated that microfiltration was comparable to pasteurization in guaranteeing microbiological stability of the juice, avoiding spoilage of the final product. After treatment, PPJ showed the highest amounts of gallic acid (GA) and ellagic acid derivatives (EAs). During storage, the amount of ellagitannins, EAs and GA similarly decreased in all types of juice. Trends towards variations of monomeric anthocyanins in MPJ and variations of polymeric and copigmented anthocyanins in both MPJ and PPJ were found over storage.

CONCLUSION

The optimization of pretreatments and filtration parameters can lead to the industrial scale-up of microfiltration technology for the development of high-quality non-heat-treated PJ. © 2017 Society of Chemical Industry.

Effects of blanching, acidification, or addition of EDTA on vitamin C and β-carotene stability during mango purée preparation

The impact of acidification with citric acid, addition of EDTA or water blanching at high temperature, and short time (HTST) conducted at 90°C for 4 min, on the retention of vitamin C (L‐AA and DHAA) and β‐carotene was studied in mango purée 30 min after crushing. HTST blanching prior to matrix disruption into purée resulted in complete inactivation of polyphenol oxidase (PPO) and minor residual activity (8%) of ascorbic acid oxidase (AAO). The retention of total vitamin C was 100% in blanched purées and in purée with EDTA and about 90% in purées at pH 3.9 and 5.0. Acidification, blanching, and addition of EDTA preserved vitamin C mainly as L‐AA, while complete conversion into DHAA was observed in purée at pH 5.0. The retention of all‐trans‐β‐carotene was between 65 and 72%, with the highest value in purée with EDTA and the lowest value in purée of blanched mango. The ratio of 13‐cis‐β‐carotene in fresh mango was 8.2 ± 0.5% that increased significantly after blanching and in purée at pH 5.0.

Sesquiterpene lactone content and overall quality of fresh-cut witloof chicory (Cichorium intybus L. var. foliosum Hegi) as affected by different washing procedures

Fresh-cut chicory was produced by four different processing lines testing cold and warm water (4/45 °C, 120 s) and cold water containing cysteine (0.5 mM) against an unwashed control. Levels of sesquiterpene lactones (SLs), sensory, and color attributes as well as O2 and CO2 levels in the modified atmosphere of the fresh-cut produce stored in consumer-sized bags (4 °C, 10 days) were monitored. All washing procedures applied significantly reduced the SL contents and bitterness in fresh-cut chicory. Warm water washing was most effective, reducing the total SL levels by 60.9-64.5%. Sensory and color attributes were also retained best by warm water washing, suggesting such treatments to be suitable measures to improve the quality and reduce the bitterness of fresh-cut chicory. SL profiles changed substantially in all samples during storage, revealing lactucopicrin to be the major SL directly after processing, whereas 11(S),13-dihydrolactuin prevailed at the end of storage.