1
|
Queiroz de Oliveira W, Angélica Neri Numa I, Alvim ID, Azeredo HMC, Santos LB, Borsoi FT, de Araújo FF, Sawaya ACHF, do Nascimento GC, Clerici MTPS, do Sacramento CK, Maria Pastore G. Multilayer microparticles for programmed sequential release of phenolic compounds from Eugenia stipitata: Stability and bioavailability. Food Chem 2024; 443:138579. [PMID: 38301560 DOI: 10.1016/j.foodchem.2024.138579] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/16/2023] [Revised: 01/07/2024] [Accepted: 01/23/2024] [Indexed: 02/03/2024]
Abstract
A co-delivery system based on multilayer microparticles was developed and characterized for the sequential release of phenolic compounds (PCs) using different encapsulation processes (spray drying: SD and drying-chilling spray: SDC) and wall materials to improve the stability and bioavailability of PCs. Samples were characterized in terms of process yield (PY%), phenolic retention efficiency (PRE%), chemical structure and crystallinity (NMR, FTIR, DXR), thermal stability (DSC and FT-IR), anti-radical capacity (ORAC and ABTS) and in vitro digestion. PRE% of samples by SD were higher (p < 0.05) than SDC due to the formation of PCs from CRF (cará-roxo flour). NMR, FTIR, DXR confirmed the presence of key components and interactions for the formation of the advanced co-delivery system. The SDC particles showed crystalline regions by XRD and were stable at ∼47 °C. All samples showed good release of PC in the intestinal phase, and antiradical capacity that reached 23.66 µmol TE g-1.
Collapse
Affiliation(s)
- Williara Queiroz de Oliveira
- Laboratory of Bioflavours and Bioactive Compounds, Department of Food Science, Faculty of Food Engineering, University of Campinas, 13083-862 Campinas, SP, Brazil.
| | - Iramaia Angélica Neri Numa
- Laboratory of Bioflavours and Bioactive Compounds, Department of Food Science, Faculty of Food Engineering, University of Campinas, 13083-862 Campinas, SP, Brazil
| | - Izabela D Alvim
- Technology Center of Cereal and Chocolate, Food Technology Institute (ITAL), 13070-178 Campinas, SP, Brazil
| | | | - Leticia B Santos
- Embrapa Instrumentation, R. 15 de Novembro, 1452, 13560-970 São Carlos, SP, Brazil; Graduate Program in Food, Nutrition and Food Engineering, UNESP - São Paulo State University, Rodovia Araraquara-Jaú, km 01, 14800-903 Araraquara, SP, Brazil
| | - Felipe T Borsoi
- Laboratory of Bioflavours and Bioactive Compounds, Department of Food Science, Faculty of Food Engineering, University of Campinas, 13083-862 Campinas, SP, Brazil
| | - Fábio F de Araújo
- Laboratory of Bioflavours and Bioactive Compounds, Department of Food Science, Faculty of Food Engineering, University of Campinas, 13083-862 Campinas, SP, Brazil; Faculty of Pharmaceutical Science, University of Campinas, 13083-871 Campinas, SP, Brazil
| | - Alexandra C H F Sawaya
- Faculty of Pharmaceutical Science, University of Campinas, 13083-871 Campinas, SP, Brazil
| | - Gustavo C do Nascimento
- Department of Food Science and Nutrition, School of Food Engineering, University of Campinas, 13083-862 Campinas, SP, Brazil
| | - Maria Teresa P S Clerici
- Department of Food Science and Nutrition, School of Food Engineering, University of Campinas, 13083-862 Campinas, SP, Brazil
| | - Célio K do Sacramento
- Department of Agricultural and Environmental Sciences, State University of Santa Cruz, 45662-900 BA, Brazil
| | - Glaucia Maria Pastore
- Laboratory of Bioflavours and Bioactive Compounds, Department of Food Science, Faculty of Food Engineering, University of Campinas, 13083-862 Campinas, SP, Brazil
| |
Collapse
|
2
|
Guirlanda CP, Alvim ID, Takahashi JA. Atomization of Cocoa Honey Using Whey Protein Isolate to Produce a Dry Formulation with Improved Shelf Life for Industrial Application. Foods 2023; 12:4269. [PMID: 38231713 DOI: 10.3390/foods12234269] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/05/2023] [Revised: 11/21/2023] [Accepted: 11/24/2023] [Indexed: 01/19/2024] Open
Abstract
Cocoa honey, a by-product obtained during the processing of cocoa, is a juice rich in pectin, organic acids, minerals and phenolic compounds with antioxidant properties. Fresh cocoa honey is quickly fermented due to its high content of reducing sugars, such as fructose and glucose, which limits its shelf life. Currently, cocoa honey is only commercialized in frozen form, as logistical challenges prevent the wide distribution or export of this by-product for applications in the market of sweets, jellies, beverages, confectionery, and nutraceutical foods among others. Spray-drying technology is a viable prospect for the large-scale stabilization of products such as cocoa honey, with less heat exposure compared to other conventional drying methods. This work aimed to evaluate the efficacy of drying adjuvants for a rapid removal of the water present in cocoa honey via atomization, since this process minimizes the effects of glass transition temperature (Tg) related to materials with high sugar contents. Physical parameters such as the moisture content, hygroscopicity, particle size, and yield of the products obtained were determined. Cocoa honey presented 85.3 ± 0.20 g/100 g of moisture. The formulations successfully decreased moisture content, which was lower than 11.72 ± 0.08 g/100 g in the formulations. Water activity ranged between 0.1464 ± 0.0043 and 0.1562 ± 0.029, with no significant difference between the formulations. The hygroscopicity of cocoa honey powders ranged from 29.29 to 29.87 g of water/100 g of cocoa honey. The combination of 20% maltodextrin and 1% whey protein isolate (WPI) led to the best yield, resulting in a free-flowing powder as the final product. On the other hand, the formulation composed of maltodextrin and whey protein isolate in the ratio of 29:1, respectively, led to the most stable product, with less loss of phenolic compounds during the drying process (6.04%). Regarding particle diameter, 90% of the accumulated distribution did not exceed 57 μm. The greatest dispersion of particles occurs in the Ma20W10 formulation with a span of 2.72, inferring greater variation in size between small (7.01 ± 0.06 μm), medium (18.25 ± 0.37 μm), and large (56.65 ± 1.17 μm) particles. The use of whey protein isolate as an adjuvant proved to be an efficient drying process in the production of cocoa honey powder, and was also advantageous for enriching the nutritional content of the final product due to its protein origin. Furthermore, the combination of spray-drying technology and the use of whey protein isolate as adjuvant led to a free-flowing cocoa honey powder with an adequate particle size and benefits in terms of shelf-life extension, providing new opportunities for the commercialization of cocoa honey as an ingredient for the food industry, with benefits for the circular economy.
Collapse
Affiliation(s)
- Christiano Pedro Guirlanda
- Food Science Graduate Program, Department of Food Science, College of Pharmacy, Universidade Federal de Minas Gerais, Av. Antônio Carlos, 6627, Belo Horizonte 31270-901, MG, Brazil
| | - Izabela Dutra Alvim
- Institute of Food Technology, Cereal and Chocolate Technology Center, Av. Brasil 2880, Campinas 13070-178, SP, Brazil
| | - Jacqueline Aparecida Takahashi
- Department of Chemistry, Exact Sciences Institute, Universidade Federal de Minas Gerais, Av. Antônio Carlos, 6627, Belo Horizonte 31270-901, MG, Brazil
| |
Collapse
|
3
|
Alves Gragnani Vido M, Dutra Alvim I, Vinderola G, Isabel Berto M, Blumer Zacarchenco Rodrigues de Sá P, Mauricio Barreto Pinilla C, Torres Silva E Alves A. Microencapsulation of Limosilactobacillus reuteri (DSM 23878) for application in infant formula: Heat resistance and bacterial viability during long-time storage. Food Res Int 2023; 173:113378. [PMID: 37803716 DOI: 10.1016/j.foodres.2023.113378] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/21/2023] [Revised: 08/11/2023] [Accepted: 08/16/2023] [Indexed: 10/08/2023]
Abstract
This study aimed to evaluate the survival capacity of the probiotic culture Limosilactobacillus reuteri (DSM 23878) to microencapsulation by spray drying, and its potential as component of an infant formula. Preliminary tests were performed between skim milk (SM) and infant formula (IF) as wall material and two inlet temperatures, evaluating the encapsulation efficiency, moisture content, water activity and stability, to choose the drying parameters. After drying in optimized conditions, the powder of microencapsulated L. reuteri was characterized and the viability after dilution in an infant formula at 70 °C was determined. In addition, the survival rate throughout 360 days of storage was assessed. As results, encapsulation efficiency was superior to 90 % in both wall materials. However, the use of IF as for microencapsulation produced microparticles with lower water activity (Aw) and moisture, as compared with the SM. Final microparticles produced with IF as wall material presented values of Aw, moisture content, and particle diameter averaged 0.11 ± 0.02, 2.10 ± 0.35 % and 10.30 ± 0.12 μm, respectively. The viability of microencapsulated L.reuteri decreased 1 Log CFU/mL after dilution at 70 °C and the powder maintained a survivor of 73.5 % after 365 days of storage at 4 °C. Thus, the microencapsulation by spray drying under the conditions of this study proved to be an effective technique to protect the probiotic L. reuteri for application in infant formulas, obtaining an adequate number of viable cells after reconstitution at 70 °C and during long time the storage.
Collapse
Affiliation(s)
| | - Izabela Dutra Alvim
- Cereal and Chocolate Technology Center, Institute of Food Technology, Brazil (ITAL), Campinas, São Paulo, Brazil
| | - Gabriel Vinderola
- Instituto de Lactología Industrial (CONICET-UNL), Facultad de Ingeniería Química, Universidad Nacional del Litoral, Santa Fe, Argentina
| | - Maria Isabel Berto
- Dairy Technology Center (TECNOLAT) of the Food Technology Institute (ITAL), Campinas, São Paulo, Brazil
| | | | | | | |
Collapse
|
4
|
Santos PDDF, Batista PS, Torres LCR, Thomazini M, de Alencar SM, Favaro-Trindade CS. Application of spray drying, spray chilling and the combination of both methods to produce tucumã oil microparticles: characterization, stability, and β-carotene bioaccessibility. Food Res Int 2023; 172:113174. [PMID: 37689927 DOI: 10.1016/j.foodres.2023.113174] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/28/2023] [Revised: 06/16/2023] [Accepted: 06/19/2023] [Indexed: 09/11/2023]
Abstract
The aim of this work was to produce tucumã oil (PO) microparticles using different encapsulation methods, and to evaluate their properties, storage stability and bioaccessibility of the encapsulated β-carotene. Gum Arabic was used as carrier for spray drying (SD), while vegetable fat was the wall material for spray chilling (SC) and the combination of the methods (SDC). Powders were yellow (hue angle around 80°) and presented particles with small mean diameters (1.57-2.30 µm). PO and the microparticles possess high β-carotene contents (∼0.35-22 mg/g). However, some carotenoid loss was observed in the particles after encapsulation by SD and SDC (around 20%). After 90 days of storage, SDC particles presented the lowest degradation of total carotenoids (∼5%), while SD samples showed the highest loss (∼21%). Yet, the latter had the lowest contents of conjugated dienes (4.1-5.3 µmol/g) among treatments. At the end of simulated digestion, PO and the microparticles provided low β-carotene bioaccessibility (<10%), and only SC increased this parameter compared to the pure oil. In conclusion, carotenoid-rich microparticles with attractive color were obtained through microencapsulation of PO by SD, SC and SDC, revealing their potential as natural additives for the development of food products with improved nutritional properties. The SC method stood out for providing microparticles with high carotenoid content and retention, high oxidative stability, and improved β-carotene bioaccessibility.
Collapse
Affiliation(s)
- Priscila Dayane de Freitas Santos
- Departament of Food Engineering, College of Animal Science and Food Engineering, University of São Paulo, Pirassununga 13635-900, SP, Brazil.
| | - Pollyanna Souza Batista
- Departament of Agri-Food Industry, Food and Nutrition, Luiz de Queiroz College of Agriculture, University of São Paulo, Piracicaba 13418-900, SP, Brazil.
| | - Larissa Catelli Rocha Torres
- Center for Nuclear Energy in Agriculture, Luiz de Queiroz College of Agriculture, University of São Paulo, Piracicaba 13416-000, SP, Brazil.
| | - Marcelo Thomazini
- Departament of Food Engineering, College of Animal Science and Food Engineering, University of São Paulo, Pirassununga 13635-900, SP, Brazil.
| | - Severino Matias de Alencar
- Departament of Agri-Food Industry, Food and Nutrition, Luiz de Queiroz College of Agriculture, University of São Paulo, Piracicaba 13418-900, SP, Brazil.
| | - Carmen Sílvia Favaro-Trindade
- Departament of Food Engineering, College of Animal Science and Food Engineering, University of São Paulo, Pirassununga 13635-900, SP, Brazil.
| |
Collapse
|
5
|
Chasquibol N, Gonzales BF, Alarcón R, Sotelo A, Gallardo G, García B, Pérez-Camino MDC. Co-Microencapsulation of Sacha Inchi ( Plukenetia huayllabambana) Oil with Natural Antioxidants Extracts. Foods 2023; 12:foods12112126. [PMID: 37297371 DOI: 10.3390/foods12112126] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/01/2023] [Revised: 05/01/2023] [Accepted: 05/06/2023] [Indexed: 06/12/2023] Open
Abstract
Sacha inchi (Plukenetia huayllabambana) oil was co-microencapsulated with natural antioxidant extracts (NAE), such as camu-camu (Myrciaria dubia (HBK) Mc Vaugh) fruit, Añil variety Andean potato (Solanum tuberosum andigenum, and elderberry fruit (Sambucus peruviana). Gum Arabic and the ternary combination of gum Arabic (GA) + maltodextrin (MD) + whey protein isolate (WPI) at different formulations were used as coating materials for the encapsulation process using spray-drying. The moisture content, particle size distribution and morphology, total phenolic content, antioxidant activity, fatty acid and sterol composition, oxidative stability, and shelf-life were evaluated. Co-microcapsules of sacha inchi (P. huayllabambana) oil with camu camu skin extract (CCSE) at 200 ppm encapsulated with GA + MD + WPI had the highest total polyphenol content (4239.80 µg GAE/g powder), antioxidant activity (12,454.00 µg trolox/g powder), omega-3 content (56.03%), β-sitosterol (62.5%), greater oxidative stability (Oxidation Onset temperature of 189 °C), higher shelf-life (3116 h), and smaller particle sizes (6.42 μm). This research enhances the knowledge to obtain microcapsules containing sacha inchi (P. huayllabambana) oil with natural antioxidant extracts that could be used for the development of functional foods. Further research is needed to study the potential interactions and their influence between the bioactive components of the microcapsules and the challenges that may occur during scale-up to industrial production.
Collapse
Affiliation(s)
- Nancy Chasquibol
- Grupo de Investigación en Alimentos Funcionales, Carrera de Ingeniería Industrial, Instituto de Investigación Científica, Universidad de Lima, Av. Javier Prado Este 4600, Fundo Monterrico Chico, Surco, Lima 15023, Peru
| | - Billy Francisco Gonzales
- Grupo de Investigación en Alimentos Funcionales, Carrera de Ingeniería Industrial, Instituto de Investigación Científica, Universidad de Lima, Av. Javier Prado Este 4600, Fundo Monterrico Chico, Surco, Lima 15023, Peru
| | - Rafael Alarcón
- Grupo de Investigación en Alimentos Funcionales, Carrera de Ingeniería Industrial, Instituto de Investigación Científica, Universidad de Lima, Av. Javier Prado Este 4600, Fundo Monterrico Chico, Surco, Lima 15023, Peru
| | - Axel Sotelo
- Grupo de Investigación en Alimentos Funcionales, Carrera de Ingeniería Industrial, Instituto de Investigación Científica, Universidad de Lima, Av. Javier Prado Este 4600, Fundo Monterrico Chico, Surco, Lima 15023, Peru
| | - Gabriela Gallardo
- Instituto Nacional de Tecnología Agropecuaria (INTA), Gabriel de Aristizabal, B1686 William C. Morris, Buenos Aires C1033AAE, Argentina
| | - Belén García
- Instituto de la Grasa-Consejo Superior de Investigaciones Científicas, Campus Universidad Pablo de Olavide Ed. 46, Crtra. Sevilla-Utrera km 1, 41013 Sevilla, Spain
| | - María Del Carmen Pérez-Camino
- Instituto de la Grasa-Consejo Superior de Investigaciones Científicas, Campus Universidad Pablo de Olavide Ed. 46, Crtra. Sevilla-Utrera km 1, 41013 Sevilla, Spain
| |
Collapse
|
6
|
Procopio FR, Klettenhammer S, Ferrentino G, Scampicchio M, do Amaral Sobral PJ, Hubinger MD. Comparative Study of Cinnamon and Paprika Oleoresins Encapsulated by Spray Chilling and Particles from Gas Saturated Solutions Techniques: Evaluation of Physical Characteristics and Oleoresins Release in Food Simulated Media. FOOD BIOPROCESS TECH 2023. [DOI: 10.1007/s11947-023-03058-5] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 03/29/2023]
Abstract
AbstractIn this study, cinnamon and paprika oleoresins were encapsulated by two technologies, respectively, spray chilling and particles from gas saturated solutions. Both technologies used palm oil as wall materials. The physical characteristics of the microparticles were compared as well as the oleoresins release behavior in high- and low-fat simulated food media. The spray chilling microparticles had an average diameter of 143.7 ± 1.5 µm, spherical shape, smooth surface, and passable flow property. In contrast, microparticles obtained by particles from gas saturated solutions (PGSS) showed an average diameter of 105.7 ± 0.6 µm, irregular shape, porous surface, poor flow property but higher encapsulation efficiency. In evaluating the compounds released in a simulated food medium, the spray chilling particles delivered 30.7%, while PGSS reached 23.1% after 1 h. Both microparticles well fitted the Kosmeyer-Peppas (R2 = 0.98 and 0.96 for spray chilling and PGSS) and Peppas-Sahlin models (R2 = 0.98 and 0.97 for spray chilling and PGSS). However, spray chilling microparticles showed a diffusion mechanism, while for PGSS ones erosion was the main mechanism. Despite the different physical characteristics, both microparticles proved to be possible facilitators in delivering oleoresins in food products.
Collapse
|
7
|
Spray-and freeze-drying of microcapsules prepared by complex coacervation method: A review. Food Hydrocoll 2023. [DOI: 10.1016/j.foodhyd.2023.108650] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 03/06/2023]
|
8
|
Yan C, Kim SR, Ruiz DR, Farmer JR. Microencapsulation for Food Applications: A Review. ACS APPLIED BIO MATERIALS 2022; 5:5497-5512. [PMID: 36395471 DOI: 10.1021/acsabm.2c00673] [Citation(s) in RCA: 13] [Impact Index Per Article: 6.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/18/2022]
Abstract
Food products contain various active ingredients, such as flavors, nutrients, unsaturated fatty acids, color, probiotics, etc., that require protection during food processing and storage to preserve their quality and shelf life. This review provides an overview of standard microencapsulation technologies, processes, materials, industrial examples, reasons for market success, a summary of recent applications, and the challenges in the food industry, categorized by active food ingredients: flavors, polyunsaturated fatty acids, probiotics, antioxidants, colors, vitamins, and others. We also provide a comprehensive analysis of the advantages and disadvantages of the most common microencapsulation technologies in the food industry such as spray drying, coacervation, extrusion, and spray cooling. This review ends with future perspectives on microencapsulation for food applications.
Collapse
Affiliation(s)
- Cuie Yan
- Division of Encapsulation, Blue California, Rancho Santa Margarita, California 92688, United States
| | - Sang-Ryoung Kim
- Division of Encapsulation, Blue California, Rancho Santa Margarita, California 92688, United States
| | - Daniela R Ruiz
- Division of Encapsulation, Blue California, Rancho Santa Margarita, California 92688, United States
| | - Jordan R Farmer
- Division of Encapsulation, Blue California, Rancho Santa Margarita, California 92688, United States
| |
Collapse
|
9
|
Klettenhammer S, Ferrentino G, Imperiale S, Segato J, Morozova K, Scampicchio M. Oxidative stability by isothermal calorimetry of solid lipid microparticles produced by particles from gas saturated solutions technique. Lebensm Wiss Technol 2022. [DOI: 10.1016/j.lwt.2022.114370] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/25/2022]
|
10
|
Perez-Palacios T, Ruiz-Carrascal J, Solomando JC, de-la-Haba F, Pajuelo A, Antequera T. Recent Developments in the Microencapsulation of Fish Oil and Natural Extracts: Procedure, Quality Evaluation and Food Enrichment. Foods 2022; 11:3291. [PMID: 37431039 PMCID: PMC9601459 DOI: 10.3390/foods11203291] [Citation(s) in RCA: 7] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/30/2022] [Revised: 10/15/2022] [Accepted: 10/18/2022] [Indexed: 09/28/2023] Open
Abstract
Due to the beneficial health effects of omega-3 fatty acids and antioxidants and their limited stability in response to environmental and processing factors, there is an increasing interest in microencapsulating them to improve their stability. However, despite recent developments in the field, no specific review focusing on these topics has been published in the last few years. This work aimed to review the most recent developments in the microencapsulation of fish oil and natural antioxidant compounds. The impact of the wall material and the procedures on the quality of the microencapsulates were preferably evaluated, while their addition to foods has only been studied in a few works. The homogenization technique, the wall-material ratio and the microencapsulation technique were also extensively studied. Microcapsules were mainly analyzed for size, microencapsulation efficiency, morphology and moisture, while in vitro digestion, flowing properties, yield percentage and Fourier transform infrared spectroscopy (FTIR) were used more sparingly. Findings highlighted the importance of optimizing the most influential variables of the microencapsulation procedure. Further studies should focus on extending the range of analytical techniques upon which the optimization of microcapsules is based and on addressing the consequences of the addition of microcapsules to food products.
Collapse
Affiliation(s)
- Trinidad Perez-Palacios
- Meat and Meat Product University Institute (IProCar), University of Extremadura, Avda. de las Ciencias s/n, 10003 Cáceres, Spain
| | | | | | | | | | | |
Collapse
|
11
|
Tian S, Xue X, Wang X, Chen Z. Preparation of starch-based functional food nano-microcapsule delivery system and its controlled release characteristics. Front Nutr 2022; 9:982370. [PMID: 36046140 PMCID: PMC9421261 DOI: 10.3389/fnut.2022.982370] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/30/2022] [Accepted: 07/29/2022] [Indexed: 11/22/2022] Open
Abstract
Most of the functional substances in food are absorbed in the small intestine, but before entering the small intestine, the strong acid and enzymes in the stomach limit the amount that can reach the small intestine. Therefore, in this paper, to develop a delivery system for functional food ingredients, maintain the biological activity of the ingredients, and deliver them to the target digestive organs, preparation of starch-based functional food nano-microcapsule delivery system and its controlled release characteristics were reviewed. Embedding unstable food active ingredients in starch-based nano-microcapsules can give the core material excellent stability and certain functional effects. Starch-based wall materials refer to a type of natural polymer material that uses starch or its derivatives to coat fat-soluble components with its hydrophobic cavities. The preparation methods of starch-based wall materials mainly include spray drying, extrusion, freeze drying, ultra-high pressure, coagulation, fluidized bed coating, molecular inclusion, chemical, and enzymic methods. The controlled release of functional food can be achieved by preparing starch-based nano-microcapsules to encapsulate the active agents. It has been reported that that compared with traditional embedding agents such as gelatin, acacia gum, and xanthan gum, starch-based functional food nano-microcapsule delivery system had many good properties, including improving antioxidant capacity, bioavailability, probiotics, and concealing bad flavors. From this review, we can learn which method should be chosen to prepare starch-based functional food nano-microcapsule delivery system and understand the mechanism of controlled release.
Collapse
Affiliation(s)
- Shuangqi Tian
- College of Food Science and Technology, Henan University of Technology, Zhengzhou, China
| | - Xing'ao Xue
- College of Food Science and Technology, Henan University of Technology, Zhengzhou, China
| | - Xinwei Wang
- College of Food Science and Technology, Henan University of Technology, Zhengzhou, China
| | - Zhicheng Chen
- College of Food Science and Technology, Henan University of Technology, Zhengzhou, China
| |
Collapse
|
12
|
Encapsulation of Rich-Carotenoids Extract from Guaraná (Paullinia cupana) Byproduct by a Combination of Spray Drying and Spray Chilling. Foods 2022; 11:foods11172557. [PMID: 36076743 PMCID: PMC9455470 DOI: 10.3390/foods11172557] [Citation(s) in RCA: 9] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/20/2022] [Revised: 08/08/2022] [Accepted: 08/10/2022] [Indexed: 11/25/2022] Open
Abstract
Guaraná byproducts are rich in carotenoids, featuring strong antioxidant capacity and health-promoting benefits. However, these compounds are highly susceptible to oxidation and isomerization, which limits their applications in foods. This research aimed to encapsulate the carotenoid-rich extract from reddish guaraná peels by spray drying (SD), chilling (SC), and their combination (SDC) using gum arabic and vegetable fat as carriers. The carotenoid-rich extract was analyzed as a control, and the formulations were prepared with the following core–carrier ratios: SD20 (20:80), SD25 (25:75), SD33 (33:67), SC20 (20:80), SC30 (30:70), SC40 (40:60), SDC10 (10:90), and SDC20 (20:80). The physicochemical properties of the formed microparticles were characterized, and their storage stability was evaluated over 90 days. Water activity of microparticles formed during the SD process increased during storage, whereas those formed by SC and SDC processes showed no changes in water activity. The formed microparticles exhibited color variation and size increase over time. Carotenoid degradation of the microparticles was described by zero-order kinetics for most treatments. Considering the higher carotenoid content and its stability, the optimum formulation for each process was selected to further analysis. Scanning electron micrographs revealed the spherical shape and absence of cracks on the microparticle surface, as well as size heterogeneity. SD increased the stability to oxidation of the carotenoid-rich extract by at least 52-fold, SC by threefold, and SDC by 545-fold. Analysis of the thermophysical properties suggested that the carrier and the process of encapsulation influence the powder’s thermal resistance. Water sorption data of the SDC microparticles depended on the blend of the carrier agents used in the process. Carotenoid encapsulation via an innovative combination of spray drying and spray chilling processes offers technological benefits, which could be applied as a promising alternative to protect valuable bioactive compounds.
Collapse
|
13
|
Zhao W, Zhang B, Liang W, Liu X, Zheng J, Ge X, Shen H, Lu Y, Zhang X, Sun Z, Ospankulova G, Li W. Lutein encapsulated in whey protein and citric acid potato starch ester: Construction and characterization of microcapsules. Int J Biol Macromol 2022; 220:1-12. [PMID: 35970362 DOI: 10.1016/j.ijbiomac.2022.08.068] [Citation(s) in RCA: 8] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/21/2022] [Revised: 07/26/2022] [Accepted: 08/10/2022] [Indexed: 11/24/2022]
Abstract
The poor water solubility and stability of lutein limit its application in industry. Microencapsulation technology is an excellent strategy to solve these problems. This study used citric acid esterified potato starch and whey protein as an emulsifier to prepare oil-in-water lutein emulsion, and microcapsules were constructed by spray drying technology. The effects of different component proportions on microcapsules' microstructure, physical and chemical properties, and storage stability were analyzed. Citrate esterified potato starch had good emulsifying properties, and when compounded with whey protein, the encapsulation efficiency (EE) of microcapsules increased, and the embedding effect of lutein improved. After microencapsulation, the solubility of lutein increased significantly, reaching over 49.71 %, and gradually raised with more whey protein content. Furthermore, the high proportion of whey protein helped improve microcapsules' EE and thermal properties, with the maximum EE reaching 89.36 %. The glass transition temperatures of microcapsules were all higher than room temperature, which indicated that they keep a stable state under general storage conditions. The experimental results of this study may provide a reference for applying lutein in food and other fields.
Collapse
Affiliation(s)
- Wenqing Zhao
- Engineering Research Center of Grain and Oil Functionalized Processing in Universities of Shaanxi Province, College of Food Science and Engineering, Northwest A&F University, 22 Xinong Road, Yangling 712100, Shaanxi, PR China
| | - Bo Zhang
- Engineering Research Center of Grain and Oil Functionalized Processing in Universities of Shaanxi Province, College of Food Science and Engineering, Northwest A&F University, 22 Xinong Road, Yangling 712100, Shaanxi, PR China
| | - Wei Liang
- Engineering Research Center of Grain and Oil Functionalized Processing in Universities of Shaanxi Province, College of Food Science and Engineering, Northwest A&F University, 22 Xinong Road, Yangling 712100, Shaanxi, PR China
| | - Xinyue Liu
- Engineering Research Center of Grain and Oil Functionalized Processing in Universities of Shaanxi Province, College of Food Science and Engineering, Northwest A&F University, 22 Xinong Road, Yangling 712100, Shaanxi, PR China
| | - Jiayu Zheng
- Engineering Research Center of Grain and Oil Functionalized Processing in Universities of Shaanxi Province, College of Food Science and Engineering, Northwest A&F University, 22 Xinong Road, Yangling 712100, Shaanxi, PR China
| | - Xiangzhen Ge
- Engineering Research Center of Grain and Oil Functionalized Processing in Universities of Shaanxi Province, College of Food Science and Engineering, Northwest A&F University, 22 Xinong Road, Yangling 712100, Shaanxi, PR China
| | - Huishan Shen
- Engineering Research Center of Grain and Oil Functionalized Processing in Universities of Shaanxi Province, College of Food Science and Engineering, Northwest A&F University, 22 Xinong Road, Yangling 712100, Shaanxi, PR China
| | - Yifan Lu
- Engineering Research Center of Grain and Oil Functionalized Processing in Universities of Shaanxi Province, College of Food Science and Engineering, Northwest A&F University, 22 Xinong Road, Yangling 712100, Shaanxi, PR China
| | - Xiuyun Zhang
- Engineering Research Center of Grain and Oil Functionalized Processing in Universities of Shaanxi Province, College of Food Science and Engineering, Northwest A&F University, 22 Xinong Road, Yangling 712100, Shaanxi, PR China
| | - Zhuangzhuang Sun
- Engineering Research Center of Grain and Oil Functionalized Processing in Universities of Shaanxi Province, College of Food Science and Engineering, Northwest A&F University, 22 Xinong Road, Yangling 712100, Shaanxi, PR China
| | - Gulnazym Ospankulova
- Kazakh Agrotechnical University, Zhenis avenue, 62, Nur-Sultan 010011, Kazakhstan
| | - Wenhao Li
- Engineering Research Center of Grain and Oil Functionalized Processing in Universities of Shaanxi Province, College of Food Science and Engineering, Northwest A&F University, 22 Xinong Road, Yangling 712100, Shaanxi, PR China.
| |
Collapse
|
14
|
Wang X, Amason AC, Lei Y, Gabbard R, Wieland JA, Gross RA. Bio-based alternative for encapsulating fragrance oils in epoxy resin microcapsules. Colloids Surf A Physicochem Eng Asp 2022. [DOI: 10.1016/j.colsurfa.2022.128387] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/30/2022]
|
15
|
Figueiredo JDA, Silva CRDP, Souza Oliveira MF, Norcino LB, Campelo PH, Botrel DA, Borges SV. Microencapsulation by spray chilling in the food industry: Opportunities, challenges, and innovations. Trends Food Sci Technol 2022; 120:274-287. [PMID: 36569414 PMCID: PMC9759634 DOI: 10.1016/j.tifs.2021.12.026] [Citation(s) in RCA: 12] [Impact Index Per Article: 6.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/06/2021] [Revised: 12/10/2021] [Accepted: 12/21/2021] [Indexed: 12/27/2022]
Abstract
Background The increasing demand for healthy eating habits and the emergence of the COVID-19 pandemic, which resulted in a health crisis and global economic slowdown, has led to the consumption of functional and practical foods. Bioactive ingredients can be an alternative for healthy food choices; however, most functional compounds are sensitive to the adverse conditions of processing and digestive tract, impairing its use in food matrices, and industrial-scale applications. Microencapsulation by spray chilling can be a viable alternative to reduce these barriers in food processing. Scope and approach This review discusses the use of spray chilling technique for microencapsulation of bioactive food ingredients. Although this technology is known in the pharmaceutical industry, it has been little exploited in the food sector. General aspects of spray chilling, the process parameters, advantages, and disadvantages are addressed. The feasibility and stability of encapsulated bioactive ingredients in food matrices and the bioavailability in vitro of solid lipid microparticles produced by spray chilling are also discussed. Main findings and conclusions Research on the microencapsulation of bioactive ingredients by spray chilling for use in foods has shown the effectiveness of this technique to encapsulate bioactive compounds for application in food matrices. Solid microparticles produced by spray chilling can improve the stability and bioavailability of bioactive ingredients. However, further studies are required, including the use of lipid-based encapsulating agents, process parameters, and novel formulations for application in food, beverages, and packaging, as well as in vivo studies to prove the effectiveness of the formulations.
Collapse
Affiliation(s)
- Jayne de Abreu Figueiredo
- Department of Food Science (DCA), Federal University of Lavras, P.O. Box 3037, 37200-900, Lavras, MG, Brazil,Corresponding author. Federal University of Lavras, Department of Food Science (DCA), Laboratory of Packaging and Encapsulation, P.O. Box 3037, 37200-000, Lavras/Minas Gerais, Brazil
| | - Carlos Ramon de Paula Silva
- Department of Food Science (DCA), Federal University of Lavras, P.O. Box 3037, 37200-900, Lavras, MG, Brazil
| | | | - Laís Bruno Norcino
- Biomaterials Engineering, Federal University of Lavras, P.O. Box 3037, 37200-900, Lavras, MG, Brazil
| | - Pedro Henrique Campelo
- Faculty of Agrarian Science, Federal University of Amazonas, 69077-000, Manaus, AM, Brazil
| | - Diego Alvarenga Botrel
- Department of Food Science (DCA), Federal University of Lavras, P.O. Box 3037, 37200-900, Lavras, MG, Brazil
| | - Soraia Vilela Borges
- Department of Food Science (DCA), Federal University of Lavras, P.O. Box 3037, 37200-900, Lavras, MG, Brazil
| |
Collapse
|
16
|
de Jesus Freitas T, Assunção LS, de Lima Silva V, Oliveira TS, Conceição ISR, Machado BAS, Nunes IL, Otero DM, Ribeiro CDF. Prospective Study on Microencapsulation of Oils and Its Application in Foodstuffs. RECENT PATENTS ON NANOTECHNOLOGY 2022; 16:219-234. [PMID: 33888053 DOI: 10.2174/1872210515666210422123001] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/30/2020] [Revised: 12/24/2020] [Accepted: 03/02/2021] [Indexed: 06/12/2023]
Abstract
BACKGROUND Edible oils have gained the interest of several industrial sectors for the different health benefits they offer, such as the supply of bioactive compounds and essential fatty acids. Microencapsulation is one of the techniques that has been adopted by industries to minimize the degradation of oils, facilitating their processing. OBJECTIVE To evaluate the intellectual property related to patent documents referring to microencapsulated oils used in foods. METHODS This prospective study investigated the dynamics of patents filed in the Espacenet and National Institute of Industrial Property (INPI) databases, and it mapped technological developments in microencapsulation in comparison with scientific literature. RESULTS The years 2015 and 2018 showed the greatest growth in the number of patents filed in the Espacenet and INPI databases, respectively, with China leading the domains of origin, inventors, and owners of microencapsulation technology. The largest number of applications of microcapsules were observed in the food industry, and the foods containing microencapsulated oils were powdered seasonings, dairy products, rice flour, nutritional formulae, pasta, nutritional supplements, and bread. The increase in oxidative stabilities of oils was the most cited objective to microencapsulate oils. Spray drying was the most widely used microencapsulation technique, and maltodextrin, gum arabic, and modified starch were the most widely used wall materials. CONCLUSION Microencapsulation of oils has been expanding over the years and increasing the possibilities of the use of microcapsules, but further investments and development of policies and incentive programs to boost this technology need to be made in less developed countries. For future perspectives, the microencapsulation technique is already a worldwide trend in the food industry, enabling the development of new products to facilitate their insertion in the consumer market.
Collapse
Affiliation(s)
| | | | | | | | | | - Bruna Aparecida Souza Machado
- University Center SENAI CIMATEC, National Service of Industrial Learning, Laboratory of Pharmaceutical's Formulations, SENAI Institute of Innovation (ISI) in Advanced Health Systems (CIMATEC ISI SAS), Salvador, Brazil
| | - Itaciara Larroza Nunes
- Department of Food Science and Technology, Federal University of Santa Catarina, Florianópolis, Brazil
| | | | - Camila Duarte Ferreira Ribeiro
- Faculty of Pharmacy, Federal University of Bahia, Salvador, Brazil
- Nutrition School, Federal University of Bahia, Salvador, Brazil
| |
Collapse
|
17
|
Goyal A, Tanwar B, Kumar Sihag M, Sharma V. Sacha inchi (Plukenetia volubilis L.): An emerging source of nutrients, omega-3 fatty acid and phytochemicals. Food Chem 2021; 373:131459. [PMID: 34731811 DOI: 10.1016/j.foodchem.2021.131459] [Citation(s) in RCA: 15] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/28/2021] [Revised: 10/20/2021] [Accepted: 10/20/2021] [Indexed: 12/30/2022]
Abstract
Sacha inchi (Plukenetia volubilis) (SI) is an oleaginous plant producing oil and protein-rich seeds. It has been cultivated for centuries and is native to the tropical rainforest of the Amazon region of South America including parts of Peru and northwestern Brazil. At present, SI seeds are emerging as a potential source of macro- and micronutrients, α-linolenic acid and phytochemicals. This review attempts to elucidate the nutrients, phytonutrients, safety, toxicity, health benefits and food applications of SI seed. Recent scientific studies have associated the consumption of SI seed/oil with reduced risk of chronic inflammatory diseases. However, lack of awareness and in-depth understanding has resulted in it being neglected both at the consumer and industrial level. In all, SI is an underutilized and undervalued oleaginous crop which not only has the potential to mitigate food and nutritional insecurity but also offers humongous opportunities for the development of novel value-added food products.
Collapse
Affiliation(s)
- Ankit Goyal
- Department of Dairy Chemistry, Mansinhbhai Institute of Dairy and Food Technology, Mehsana 384002, Gujarat, India.
| | - Beenu Tanwar
- Department of Dairy Technology, Mansinhbhai Institute of Dairy and Food Technology, Mehsana 384002, Gujarat, India.
| | - Manvesh Kumar Sihag
- Department of Dairy Chemistry, College of Dairy Science, Guru Angad Dev Veterinary and Animal Sciences University, Ludhiana 141001, Punjab, India.
| | - Vivek Sharma
- Dairy Chemistry Division, National Dairy Research Institute (ICAR-NDRI), Karnal, Haryana, India.
| |
Collapse
|
18
|
Influence of Sechium edule starch on the physical and chemical properties of multicomponent microcapsules obtained by spray-drying. FOOD BIOSCI 2021. [DOI: 10.1016/j.fbio.2021.101275] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/20/2022]
|
19
|
Zhou Q, Wei Z. Food-grade systems for delivery of DHA and EPA: Opportunities, fabrication, characterization and future perspectives. Crit Rev Food Sci Nutr 2021; 63:2348-2365. [PMID: 34590971 DOI: 10.1080/10408398.2021.1974337] [Citation(s) in RCA: 9] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/17/2022]
Abstract
Docosahexaenoic acid (C22: 6n-3, DHA) and eicosapentaenoic acid (C20: 5n-3, EPA) have been shown to provide the opportunity to inhibit onset and escalation of chronic diseases. Nevertheless, their undesirable characteristics including poor water solubility, oxidation sensitivity, high melting point and unpleasant sensory attributes hinder their application in the food industry. In recent years, utilizing food-grade delivery systems to deliver DHA/EPA and improve their biological efficacy has emerged as an attractive approach with fascinating prospects. This review focuses on introducing potential delivery systems for DHA/EPA, including microemulsions, nanoemulsions, Pickering emulsions, hydrogels, lipid particles, oleogels, liposomes, microcapsules and micelles. The opportunities, fabrication and characterization of these delivery systems loaded with DHA/EPA are highlighted. Besides, food sources of DHA/EPA, their benefits to the human body and a series of challenges for effective utilization of DHA/EPA are discussed. Promising future research trends of food-grade systems for delivery of DHA/EPA are also presented. Conducting in vivo experiments, applying DHA/EPA-loaded delivery systems into real food, improving the applicability of such delivery systems in industrial production, co-encapsulating DHA/EPA with other substances, seeking measures to improve the performance of existing delivery systems and developing novel food-grade delivery systems inspired by other fields are various future considerations.
Collapse
Affiliation(s)
- Qi Zhou
- College of Food Science and Engineering, Ocean University of China, Qingdao, China
| | - Zihao Wei
- College of Food Science and Engineering, Ocean University of China, Qingdao, China
| |
Collapse
|
20
|
Fadini AL, Alvim ID, Carazzato CA, Paganotti KBDF, Miguel AMRDO, Rodrigues RAF. Microparticles loaded with fish oil: stability studies, food application and sensory evaluation. J Microencapsul 2021; 38:365-380. [PMID: 34278940 DOI: 10.1080/02652048.2021.1948622] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/20/2021] [Accepted: 06/23/2021] [Indexed: 10/20/2022]
Abstract
AIM Evaluate the stability of microparticles loaded with fish oil produced by spray drying, spray chilling and by the combination of these techniques (double-shell) and use the microparticles for food application. METHODS Samples were stored for 180 days at 6 °C and 24 °C (75% RH). Performed investigations included encapsulation efficiency, moisture content, aw, size (laser scattering), colour (L*, a*, b*), polyunsaturated fatty acids (PUFAs) (GC), thermal behaviour (DSC) and crystalline structure (XRD). RESULTS Double-shell microparticles containing 26 wt% core material, 22.74 ± 0.02 µm (D0.5) and 2.05 ± 0.03 span index, 1.262 ± 0.026 wt% moisture content and 0.240 ± 0.001 of aw had PUFAs retention higher than 90 wt% during storage at 6 °C without changes in crystalline structure (β'-type crystals) and melting temperature (54 °C). The sensory evaluation suggested low fish oil release in oral phase digestion. CONCLUSIONS Double-shell microparticles were effective to protect and deliver PUFAs.
Collapse
Affiliation(s)
- Ana Lúcia Fadini
- Cereal Chocotec, Institute of Food Technology, Campinas, Brazil
- Department of Food and Nutrition, School of Food Engineering, University of Campinas, Campinas, Brazil
| | | | | | | | | | - Rodney Alexandre Ferreira Rodrigues
- Phytochemistry Division, CPQBA, University of Campinas, Paulínia, Brazil
- Department of Food and Nutrition, School of Food Engineering, University of Campinas, Campinas, Brazil
| |
Collapse
|
21
|
Functional and Oxidative Quality Characterization of Spray-Dried Omega-3-Enriched Milk Powder. J FOOD QUALITY 2021. [DOI: 10.1155/2021/6693960] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/17/2022] Open
Abstract
In the present study, fish oil (FO) and wall material were supplemented to milk to produce spray-dried powder (SDP). Furthermore, the mandate of the study was to enlighten the effect of spray-drying (SD) operating conditions on functional and oxidative quality of produced SDP samples. Purposefully, the cow milk was supplemented with 3% FO as omega-enriched source of eicosapentaenoic acid (EPA) and docosahexaenoic acid (DHA) for development of milk and FO blends (MFOBs). The lecithin was used as an emulsifier and maltodextrin was supplemented as the wall material (WM) in the MFOBs. Initially, the FO, milk fat (MF), and MFOB samples were characterized for EPA, DHA, and peroxide value (PV) before the SD. The SD of MFOB samples was carried out to produce SDP samples by using a mini spray dryer. Central composite design (CCD) with face-centered rotation was used to optimize SD independent conditions such as inlet air temperature (IAT), pump speed (PS), maltodextrin percentage (MD), and needle speed (NS) in the ranges of 160–200°C, 3–9 mL/min, 10–30%, and 5–9 s, respectively. The encapsulation efficiency (EE) ranged between 89.30 and 81.57%. The EPA and DHA retentions were in the ranges of 2.19–1.87 g/100 g and 3.20–2.75 g/100 g, respectively. The highest results for responses were observed on the following conditions: IAT was 160°C, PS was 9 mL/min, MD was 30%, and NS was 9 s, respectively; the minimum values of response factors were obtained on the following conditions: IAT was 200°C, PS was 3 mL/min, MD was 10%, and NS was 5 s, respectively. The percent losses of EPA and DHA were noted in the range of 2–18%. The IAT was observed as main factor for FA reduction in SDP samples. The SDP samples were stable, and low rate of peroxide values was noted. Overall, spray drying can be potentially used to incorporate the essential fatty acids in milk to produce stable SDP for food applications.
Collapse
|
22
|
Impact of vacuum spray drying on encapsulation of fish oil: Oxidative stability and encapsulation efficiency. Food Res Int 2021; 143:110283. [DOI: 10.1016/j.foodres.2021.110283] [Citation(s) in RCA: 11] [Impact Index Per Article: 3.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/13/2020] [Revised: 02/28/2021] [Accepted: 02/28/2021] [Indexed: 01/09/2023]
|
23
|
Pattnaik M, Mishra HN. Amelioration of the stability of polyunsaturated fatty acids and bioactive enriched vegetable oil: blending, encapsulation, and its application. Crit Rev Food Sci Nutr 2021; 62:6253-6276. [PMID: 33724100 DOI: 10.1080/10408398.2021.1899127] [Citation(s) in RCA: 9] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/21/2022]
Abstract
Lipid oxidation in vegetable oils is the primary concern for food technologists. Modification of oils like hydrogenation, fractionation, inter-esterification, and blending are followed to improve nutritional quality. Blending non-conventional/conventional vegetable oils to obtain a synergistic oil mixture is commonly practiced in the food industry to enhance the nutritional characteristics and stability of oil at an affordable price. Microencapsulation of these oils provides a functional barrier of core and coating material from the adverse environmental conditions, thereby enhancing the oxidative stability, thermo-stability, shelf-life, and biological activity of oils. Microencapsulation of oils has been conducted and commercialized by employing different conventional methods including emulsification, spray-drying, freeze-drying, coacervation, and melt-extrusion compared with new, improved methods like microwave drying, spray chilling, and co-extrusion. The microencapsulated oil emulsion can be either dried to easy-to-handle solids/microcapsules, converted into soft solids, or enclosed in a gel-like matrix, increasing the shelf-life of the liquid oil. The omega-rich microcapsules have a wide application in confectionery, dairy, ice-cream, and pharmaceutical industries. This review summarizes recent developments in blending and microencapsulation technologies in improving the stability and nutritional value of edible oils.
Collapse
Affiliation(s)
- Monalisha Pattnaik
- Agricultural and Food Engineering Department, Indian Institute of Technology Kharagpur, Kharagpur, West Bengal, India
| | - Hari Niwas Mishra
- Agricultural and Food Engineering Department, Indian Institute of Technology Kharagpur, Kharagpur, West Bengal, India
| |
Collapse
|
24
|
Electro-encapsulation of probiotics in gum Arabic-pullulan blend nanofibres using electrospinning technology. Food Hydrocoll 2021. [DOI: 10.1016/j.foodhyd.2020.106381] [Citation(s) in RCA: 34] [Impact Index Per Article: 11.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/16/2022]
|
25
|
Dhakal SP, He J. Microencapsulation of vitamins in food applications to prevent losses in processing and storage: A review. Food Res Int 2020; 137:109326. [DOI: 10.1016/j.foodres.2020.109326] [Citation(s) in RCA: 38] [Impact Index Per Article: 9.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/28/2019] [Revised: 05/11/2020] [Accepted: 05/16/2020] [Indexed: 01/29/2023]
|
26
|
Jamshidi A, Cao H, Xiao J, Simal-Gandara J. Advantages of techniques to fortify food products with the benefits of fish oil. Food Res Int 2020; 137:109353. [PMID: 33233057 DOI: 10.1016/j.foodres.2020.109353] [Citation(s) in RCA: 39] [Impact Index Per Article: 9.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/16/2020] [Revised: 05/20/2020] [Accepted: 05/24/2020] [Indexed: 02/08/2023]
|
27
|
Menegazzi GDS, Teixeira EC, Pinto LADA, Burkert JFDM. Spray-Drying Microencapsulation of Carotenoids Produced by Phaffia rhodozyma. Ind Biotechnol (New Rochelle N Y) 2020. [DOI: 10.1089/ind.2020.0025] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/12/2022] Open
Affiliation(s)
- Guilherme da Silva Menegazzi
- Bioprocess Engineering Laboratory, School of Chemistry and Food, Federal University of Rio Grande, Rio Grande, Brazil
| | - Erika Carvalho Teixeira
- Bioprocess Engineering Laboratory, School of Chemistry and Food, Federal University of Rio Grande, Rio Grande, Brazil
| | - Luiz Antonio de Almeida Pinto
- Industrial Technology Laboratory, School of Chemistry and Food, Federal University of Rio Grande, Rio Grande, Brazil
| | | |
Collapse
|
28
|
Harada-Padermo SDS, Dias-Faceto LS, Selani MM, Alvim ID, Floh EIS, Macedo AF, Bogusz S, Dias CTDS, Conti-Silva AC, Vieira TMFDS. Umami Ingredient: Flavor enhancer from shiitake (Lentinula edodes) byproducts. Food Res Int 2020; 137:109540. [PMID: 33233168 DOI: 10.1016/j.foodres.2020.109540] [Citation(s) in RCA: 22] [Impact Index Per Article: 5.5] [Reference Citation Analysis] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/27/2020] [Revised: 06/30/2020] [Accepted: 07/09/2020] [Indexed: 12/19/2022]
Abstract
An alternative use of shiitake stipes, usually treated as waste, was proposed for the production of a powder ingredient, rich in umami compounds, aiming its application in food. The extraction of umami compounds was optimized through the Response Surface Methodology (RSM), in order to obtain an extract with high umami taste intensity. From the optimized condition, a comparative analysis of shiitake stipes dehydration method was performed. Stipes were dehydrated by hot air drying (HD) and freeze drying (FD), submitted to extraction and the umami compounds in the extracts were compared. The comparative analysis showed that the 5' - nucleotides are more sensitive to prolonged heating, while the release of free amino acids (FAA) was favored by hot air drying. The HD samples extract showed higher Equivalent Umami Concentration (EUC). The spray drying of the HD samples extract allowed the production of a newly powder ingredient rich in umami compounds (Umami Ingredient) that can be applied in diverse food matrices. Due to the presence of umami compounds, Umami Ingredient can be a potential alternative to help in the process of sodium reduction by enhancing food flavor.
Collapse
Affiliation(s)
- Samara Dos Santos Harada-Padermo
- University of São Paulo, "Luiz de Queiroz" College of Agriculture, Department of Agri-Food Industry, Food and Nutrition. Avenida Pádua Dias 11, CEP 13418-900 Piracicaba, São Paulo, Brazil.
| | - Liara Silva Dias-Faceto
- São Paulo State University (Unesp), Institute of Biosciences, Humanities and Exact Sciences (Ibilce), Department of Food Engineering and Technology. Rua Cristóvão Colombo, 2265, CEP 15054-000 São José do Rio Preto, São Paulo, Brazil
| | - Miriam Mabel Selani
- Federal University of São Carlos, Lagoa do Sino Campus, Center of Natural Sciences, Rod. Lauri Simões de Barros, km 12, SP-189, CEP 18290-000 Buri, São Paulo, Brazil.
| | - Izabela Dutra Alvim
- Institute of Food Technology (ITAL), Cereal and Chocolate Technology Center (CEREAL CHOCOTEC), Av. Brasil n. 2880, Jardim Chapadão, CEP 13070-178 Campinas, São Paulo, Brazil.
| | - Eny Iochevet Segal Floh
- University of São Paulo, Institute of Biosciences, Department of Botany. Rua do Matão, 277 - Sala 107 - Butantã, CEP 05508-090 São Paulo, São Paulo, Brazil.
| | - Amanda Ferreira Macedo
- University of São Paulo, Institute of Biosciences, Department of Botany. Rua do Matão, 277 - Sala 107 - Butantã, CEP 05508-090 São Paulo, São Paulo, Brazil.
| | - Stanislau Bogusz
- University of São Paulo, São Carlos Institute of Chemistry. Av. Trabalhador Sancarlense, 400, Parque Arnold Schimidt, CEP 13566590 São Carlos, São Paulo, Brazil.
| | - Carlos Tadeu Dos Santos Dias
- University of São Paulo, "Luiz de Queiroz" College of Agriculture, Department of Agri-Food Industry, Food and Nutrition. Avenida Pádua Dias 11, CEP 13418-900 Piracicaba, São Paulo, Brazil.
| | - Ana Carolina Conti-Silva
- São Paulo State University (Unesp), Institute of Biosciences, Humanities and Exact Sciences (Ibilce), Department of Food Engineering and Technology. Rua Cristóvão Colombo, 2265, CEP 15054-000 São José do Rio Preto, São Paulo, Brazil.
| | - Thais Maria Ferreira de Souza Vieira
- University of São Paulo, "Luiz de Queiroz" College of Agriculture, Department of Agri-Food Industry, Food and Nutrition. Avenida Pádua Dias 11, CEP 13418-900 Piracicaba, São Paulo, Brazil.
| |
Collapse
|
29
|
Chasquibol NA, Gallardo G, Gómez-Coca RB, Trujillo D, Moreda W, Pérez-Camino MC. Glyceridic and Unsaponifiable Components of Microencapsulated Sacha Inchi ( Plukenetia huayllabambana L. and Plukenetia volubilis L.) Edible Oils. Foods 2019; 8:foods8120671. [PMID: 31842305 PMCID: PMC6963851 DOI: 10.3390/foods8120671] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/07/2019] [Revised: 12/09/2019] [Accepted: 12/10/2019] [Indexed: 12/18/2022] Open
Abstract
Sacha inchi (Plukenetia huayllabambana L. and Plukenetia volubilis L.) edible oils were microencapsulated and the lipid fraction of the microparticles was characterized. Hi-cap®, Capsule®, Arabic gum, and the binary combination of Arabic gum + maltodextrin and the ternary combination of Arabic gum + maltodextrin + whey protein isolate, were used as coating materials for the encapsulation process using spray-drying. The surface and the total oils obtained from the microparticles were evaluated in terms of fatty acid composition, minor glyceride polar compounds, polymers, oxidized triglycerides, diglycerides, monoglycerides, and free fatty acids, along with their unsaponifiable components, sterols, and tocopherols. Differences between the original oils and the microencapsulated ones were determined. The most remarkable results included the presence of polymers when there were none in the original oils, the slight loss in ω3-fatty acids, up to 6%, the loss in tocopherols, in some of the cases around 30%, the maintaining of the phytosterol in their initial levels and the presence of cholesterol in the oils encapsulated with whey protein isolate.
Collapse
Affiliation(s)
- Nancy A. Chasquibol
- Center of Studies and Innovation of Functional Foods (CEIAF)-Faculty of Industrial Engineering, Institute of Scientific Research, IDIC, University of Lima, Avda. Javier Prado Este, 4600 Surco, Lima 15023, Peru;
| | - Gabriela Gallardo
- National Institute of Industrial Technology, INTI- Av. Gral. Paz 5445, San Martín, Buenos Aires B1650WAB, Argentina;
| | - Raquel B. Gómez-Coca
- Department of Characterization and Quality of Lipids, Instituto de la Grasa-CSIC, Ctra. Sevilla-Utrera km 1, Campus University Pablo de Olavide. Bg. 46, E-41013 Sevilla, Spain; (R.B.G.-C.); (D.T.); (W.M.)
| | - Diego Trujillo
- Department of Characterization and Quality of Lipids, Instituto de la Grasa-CSIC, Ctra. Sevilla-Utrera km 1, Campus University Pablo de Olavide. Bg. 46, E-41013 Sevilla, Spain; (R.B.G.-C.); (D.T.); (W.M.)
| | - Wenceslao Moreda
- Department of Characterization and Quality of Lipids, Instituto de la Grasa-CSIC, Ctra. Sevilla-Utrera km 1, Campus University Pablo de Olavide. Bg. 46, E-41013 Sevilla, Spain; (R.B.G.-C.); (D.T.); (W.M.)
| | - M. Carmen Pérez-Camino
- Department of Characterization and Quality of Lipids, Instituto de la Grasa-CSIC, Ctra. Sevilla-Utrera km 1, Campus University Pablo de Olavide. Bg. 46, E-41013 Sevilla, Spain; (R.B.G.-C.); (D.T.); (W.M.)
- Correspondence:
| |
Collapse
|
30
|
Filiponi MP, Gaigher B, Caetano-Silva ME, Alvim ID, Pacheco MTB. Microencapsulation performance of Fe-peptide complexes and stability monitoring. Food Res Int 2019; 125:108505. [DOI: 10.1016/j.foodres.2019.108505] [Citation(s) in RCA: 8] [Impact Index Per Article: 1.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/22/2018] [Revised: 06/01/2019] [Accepted: 06/17/2019] [Indexed: 02/09/2023]
|
31
|
Cutrim CS, Alvim ID, Cortez MAS. Microencapsulation of green tea polyphenols by ionic gelation and spray chilling methods. Journal of Food Science and Technology 2019; 56:3561-3570. [PMID: 31413383 DOI: 10.1007/s13197-019-03908-1] [Citation(s) in RCA: 13] [Impact Index Per Article: 2.6] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Revised: 05/27/2019] [Accepted: 06/28/2019] [Indexed: 02/02/2023]
Abstract
The consumption of teas has been increasing with the dissemination of information regarding the health benefits of its constituents. Obtaining food products with healthier profiles is already a reality for industry with the increasing development of new functional ingredients, including the use of tea and its derivatives (extracts). This work aimed to evaluate the encapsulation of green tea extract powder in lipid microparticles (LMP) by the spray chilling method and in ionic gelation microparticles (IGMP) by the ionic gelation method to obtain polyphenol-rich water insoluble components. Microparticles were adequately obtained in both methods, with typical physical characteristics consistent with the results in literature results, 83.5 ± 2.8% encapsulation efficiency for LMP and 72.6 ± 0.4% for IGMP, and antioxidant activity (IC50 μg/mL) of 33,169.4 ± 123.8 (IGMP) and 2099.7 ± 35.3 (LMP). The microparticles samples were considered suitable as ingredients for add polyphenols in foods.
Collapse
Affiliation(s)
- Camila Sampaio Cutrim
- 1Laboratory of Technology of Dairy Products, Food Technology Department, Faculty of Veterinary Medicine, Fluminense Federal University, Niterói, Rio de Janeiro 24230-340 Brazil
| | - Izabela Dutra Alvim
- 2Cereal and Chocolate Technology Center, Food Technology Institute (ITAL), Brasil Avenue, 2880, Campinas, São Paulo 13070-178 Brazil
| | - Marco Antonio Sloboda Cortez
- 1Laboratory of Technology of Dairy Products, Food Technology Department, Faculty of Veterinary Medicine, Fluminense Federal University, Niterói, Rio de Janeiro 24230-340 Brazil
| |
Collapse
|
32
|
Sacha inchi oil encapsulation: Emulsion and alginate beads characterization. FOOD AND BIOPRODUCTS PROCESSING 2019. [DOI: 10.1016/j.fbp.2019.05.001] [Citation(s) in RCA: 14] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 02/04/2023]
|
33
|
Rojas ML, Alvim ID, Augusto PED. Incorporation of microencapsulated hydrophilic and lipophilic nutrients into foods by using ultrasound as a pre-treatment for drying: A prospective study. ULTRASONICS SONOCHEMISTRY 2019; 54:153-161. [PMID: 30765214 DOI: 10.1016/j.ultsonch.2019.02.004] [Citation(s) in RCA: 15] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/14/2018] [Revised: 02/02/2019] [Accepted: 02/03/2019] [Indexed: 06/09/2023]
Abstract
The present work proposes using the ultrasound technology to incorporate microencapsulated nutrients during pre-treatments for drying of food products. Both hydrophilic and lipophilic nutrients were evaluated: incorporation of microcapsules of iron (obtained by spray drying using maltodextrin as wall material) and carotenoids (obtained by hot emulsification and solidification using hydrogenated palm oil as wall material). The ultrasound pre-treatment was applied in water and ethanol, where the microcapsules were dispersed, and food samples were immersed. Pumpkin and apple were selected as suitable food material to perform the iron and carotenoid incorporation, respectively. Ultrasound allowed more homogeneous iron incorporation in pumpkin. The iron content increased more than 1000% in pre-treated samples compared to control. In the same manner, carotenoid content increased in about 430% when ultrasound was applied. After drying, the carotenoid content decreased by 65% in control samples. However, better carotenoid retention was obtained after drying in ultrasound processed samples. The results show that pre-treatment with ultrasound can be used to incorporate nutrients into the food matrix, increasing not only the incorporated quantity but also promoting their preservation. Nevertheless, future studies must be performed to determine the nutrient bioavailability and bioaccessibility.
Collapse
Affiliation(s)
- Meliza Lindsay Rojas
- Department of Agri-food Industry, Food and Nutrition (LAN), Luiz de Queiroz College of Agriculture (ESALQ), University of São Paulo (USP), Piracicaba, SP, Brazil.
| | - Izabela Dutra Alvim
- Technology Center of Cereal and Chocolate, Food Technology Institute (ITAL), Campinas, SP, Brazil
| | - Pedro Esteves Duarte Augusto
- Department of Agri-food Industry, Food and Nutrition (LAN), Luiz de Queiroz College of Agriculture (ESALQ), University of São Paulo (USP), Piracicaba, SP, Brazil; Food and Nutrition Research Center (NAPAN), University of São Paulo (USP), Piracicaba, SP, Brazil.
| |
Collapse
|
34
|
Fadini AL, Dutra Alvim I, Paganotti KBDF, Bataglia da Silva L, Bonifácio Queiroz M, Miguel AMRDO, Rodrigues RAF. Optimization of the production of double-shell microparticles containing fish oil. FOOD SCI TECHNOL INT 2019; 25:359-369. [DOI: 10.1177/1082013219825890] [Citation(s) in RCA: 9] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/30/2023]
Affiliation(s)
- Ana Lúcia Fadini
- Institute of Food Technology (ITAL), Cereal Chocotec, Campinas, Brazil
| | | | | | | | | | | | | |
Collapse
|
35
|
Lis Arias MJ, Coderch L, Martí M, Alonso C, García Carmona O, García Carmona C, Maesta F. Vehiculation of Active Principles as a Way to Create Smart and Biofunctional Textiles. MATERIALS 2018; 11:ma11112152. [PMID: 30388791 PMCID: PMC6266968 DOI: 10.3390/ma11112152] [Citation(s) in RCA: 10] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 09/20/2018] [Revised: 10/23/2018] [Accepted: 10/29/2018] [Indexed: 11/17/2022]
Abstract
In some specific fields of application (e.g., cosmetics, pharmacy), textile substrates need to incorporate sensible molecules (active principles) that can be affected if they are sprayed freely on the surface of fabrics. The effect is not controlled and sometimes this application is consequently neglected. Microencapsulation and functionalization using biocompatible vehicles and polymers has recently been demonstrated as an interesting way to avoid these problems. The use of defined structures (polymers) that protect the active principle allows controlled drug delivery and regulation of the dosing in every specific case. Many authors have studied the use of three different methodologies to incorporate active principles into textile substrates, and assessed their quantitative behavior. Citronella oil, as a natural insect repellent, has been vehicularized with two different protective substances; cyclodextrine (CD), which forms complexes with it, and microcapsules of gelatin-arabic gum. The retention capability of the complexes and microcapsules has been assessed using an in vitro experiment. Structural characteristics have been evaluated using thermogravimetric methods and microscopy. The results show very interesting long-term capability of dosing and promising applications for home use and on clothes in environmental conditions with the need to fight against insects. Ethyl hexyl methoxycinnamate (EHMC) and gallic acid (GA) have both been vehicularized using two liposomic-based structures: Internal wool lipids (IWL) and phosphatidylcholine (PC). They were applied on polyamide and cotton substrates and the delivery assessed. The amount of active principle in the different layers of skin was determined in vitro using a Franz-cell diffusion chamber. The results show many new possibilities for application in skin therapeutics. Biofunctional devices with controlled functionality can be built using textile substrates and vehicles. As has been demonstrated, their behavior can be assessed using in vitro methods that make extrapolation to their final applications possible.
Collapse
Affiliation(s)
- Manuel J Lis Arias
- Textile Research Institute of Terrassa (INTEXTER-UPC), 08222 Terrassa, Spain.
| | - Luisa Coderch
- Catalonia Advanced Chemistry Institute (IQAC-CSIC), 08034 Barcelona, Spain.
| | - Meritxell Martí
- Catalonia Advanced Chemistry Institute (IQAC-CSIC), 08034 Barcelona, Spain.
| | - Cristina Alonso
- Catalonia Advanced Chemistry Institute (IQAC-CSIC), 08034 Barcelona, Spain.
| | | | | | - Fabricio Maesta
- Textile Engineering Dept., Federal Technological University of Paraná, Apucarana 86812-460, Brazil.
| |
Collapse
|