1
|
Woeppel K, Dhawan V, Shi D, Cui XT. Nanotopography-enhanced biomimetic coating maintains bioactivity after weeks of dry storage and improves chronic neural recording. Biomaterials 2023; 302:122326. [PMID: 37716282 PMCID: PMC10993103 DOI: 10.1016/j.biomaterials.2023.122326] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/01/2023] [Revised: 09/01/2023] [Accepted: 09/11/2023] [Indexed: 09/18/2023]
Abstract
We developed a nanoparticle base layer technology capable of maintaining the bioactivity of protein-based neural probe coating intended to improve neural recording quality. When covalently bound on thiolated nanoparticle (TNP) modified surfaces, neural adhesion molecule L1 maintained bioactivity throughout 8 weeks of dry storage at room temperature, while those bound to unmodified surfaces lost 66% bioactivity within 3 days. We tested the TNP + L1 coating in mouse brains on two different neural electrode arrays after two different dry storage durations (3 and 28 days). The results show that dry-stored coating is as good as the freshly prepared, and even after 28 days of storage, the number of single units per channel and signal-to-noise ratio of the TNP + L1 coated arrays were significantly higher by 32% and 40% respectively than uncoated controls over 16 weeks. This nanoparticle base layer approach enables the dissemination of biomolecule-functionalized neural probes to users worldwide and may also benefit a broad range of applications that rely on surface-bound biomolecules.
Collapse
Affiliation(s)
- Kevin Woeppel
- University of Pittsburgh, Department of Bioengineering, 4200 Fifth Avenue, Pittsburgh, PA, 15260, USA; Center for the Neural Basis of Cognition, 4400 Fifth Avenue, Suite 115, Pittsburgh, PA, 15213, USA
| | - Vaishnavi Dhawan
- University of Pittsburgh, Department of Bioengineering, 4200 Fifth Avenue, Pittsburgh, PA, 15260, USA; Center for the Neural Basis of Cognition, 4400 Fifth Avenue, Suite 115, Pittsburgh, PA, 15213, USA
| | - Delin Shi
- University of Pittsburgh, Department of Bioengineering, 4200 Fifth Avenue, Pittsburgh, PA, 15260, USA; Center for the Neural Basis of Cognition, 4400 Fifth Avenue, Suite 115, Pittsburgh, PA, 15213, USA
| | - Xinyan Tracy Cui
- University of Pittsburgh, Department of Bioengineering, 4200 Fifth Avenue, Pittsburgh, PA, 15260, USA; Center for the Neural Basis of Cognition, 4400 Fifth Avenue, Suite 115, Pittsburgh, PA, 15213, USA; McGowan Institute for Regenerative Medicine, 450 Technology Drive, Suite 300, Pittsburgh, PA, 15219, USA.
| |
Collapse
|
2
|
Sharma A, Chiang RA, Manginell M, Nardi I, Coker EN, Vanegas JM, Rempe SB, Bachand GD. Carbonic Anhydrase Robustness for Use in Nanoscale CO 2 Capture Technologies. ACS OMEGA 2023; 8:37830-37841. [PMID: 37867662 PMCID: PMC10586288 DOI: 10.1021/acsomega.3c02630] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 04/17/2023] [Accepted: 09/08/2023] [Indexed: 10/24/2023]
Abstract
Continued dependence on crude oil and natural gas resources for fossil fuels has caused global atmospheric carbon dioxide (CO2) emissions to increase to record-setting proportions. There is an urgent need for efficient and inexpensive carbon sequestration systems to mitigate large-scale emissions of CO2 from industrial flue gas. Carbonic anhydrase (CA) has shown high potential for enhanced CO2 capture applications compared to conventional absorption-based methods currently utilized in various industrial settings. This study aims to understand structural aspects that contribute to the stability of CA enzymes critical for their applications in industrial processes, which require the ability to withstand conditions different from those in their native environments. Here, we evaluated the thermostability and enzyme activity of mesophilic and thermophilic CA variants at different temperature conditions and in the presence of atmospheric gas pollutants like nitrogen oxides and sulfur oxides. Based on our enzyme activity assays and molecular dynamics simulations, we see increased conformational stability and CA activity levels in thermostable CA variants incubated week-long at different temperature conditions. The thermostable CA variants also retained high levels of CA activity despite changes in solution pH due to increasing NO and SO2 concentrations. A loss of CA activity was observed only at high concentrations of NO/SO2 that possibly can be minimized with the appropriate buffered solutions.
Collapse
Affiliation(s)
- Arjun Sharma
- Department
of Physics, The University of Vermont, Burlington, Vermont 05405-0160, United
States
| | - Rong-an Chiang
- Memzyme,
LLC, Albuquerque, New Mexico 87123, United States
| | - Monica Manginell
- Center
for Integrated Nanotechnologies, Sandia
National Laboratories, Albuquerque, New Mexico 87185, United States
| | - Isaac Nardi
- Epigentor
Consultants, Inc., Miami, Florida 87185, United States
| | - Eric N. Coker
- Electronic,
Optical, and Nanomaterials Department, Sandia
National Laboratories, Albuquerque, New Mexico 87185, United States
| | - Juan M. Vanegas
- Department
of Physics, The University of Vermont, Burlington, Vermont 05405-0160, United
States
| | - Susan B. Rempe
- Center
for Integrated Nanotechnologies, Sandia
National Laboratories, Albuquerque, New Mexico 87185, United States
| | - George D. Bachand
- Center
for Integrated Nanotechnologies, Sandia
National Laboratories, Albuquerque, New Mexico 87185, United States
| |
Collapse
|
3
|
Shen J, Salmon S. Biocatalytic Membranes for Carbon Capture and Utilization. MEMBRANES 2023; 13:membranes13040367. [PMID: 37103794 PMCID: PMC10146961 DOI: 10.3390/membranes13040367] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/27/2023] [Revised: 03/17/2023] [Accepted: 03/21/2023] [Indexed: 05/12/2023]
Abstract
Innovative carbon capture technologies that capture CO2 from large point sources and directly from air are urgently needed to combat the climate crisis. Likewise, corresponding technologies are needed to convert this captured CO2 into valuable chemical feedstocks and products that replace current fossil-based materials to close the loop in creating viable pathways for a renewable economy. Biocatalytic membranes that combine high reaction rates and enzyme selectivity with modularity, scalability, and membrane compactness show promise for both CO2 capture and utilization. This review presents a systematic examination of technologies under development for CO2 capture and utilization that employ both enzymes and membranes. CO2 capture membranes are categorized by their mode of action as CO2 separation membranes, including mixed matrix membranes (MMM) and liquid membranes (LM), or as CO2 gas-liquid membrane contactors (GLMC). Because they selectively catalyze molecular reactions involving CO2, the two main classes of enzymes used for enhancing membrane function are carbonic anhydrase (CA) and formate dehydrogenase (FDH). Small organic molecules designed to mimic CA enzyme active sites are also being developed. CO2 conversion membranes are described according to membrane functionality, the location of enzymes relative to the membrane, which includes different immobilization strategies, and regeneration methods for cofactors. Parameters crucial for the performance of these hybrid systems are discussed with tabulated examples. Progress and challenges are discussed, and perspectives on future research directions are provided.
Collapse
|
4
|
Liao Q, Guo M, Mao M, Gao R, Meng Z, Fan X, Liu W. Construction and optimization of a photo−enzyme coupled system for sustainable CO2 conversion to methanol. Process Biochem 2023. [DOI: 10.1016/j.procbio.2023.03.011] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Submit a Manuscript] [Subscribe] [Scholar Register] [Indexed: 03/13/2023]
|
5
|
NGUYEN K, ILIUTA I, BOUGIE F, PASQUIER LC, ILIUTA MC. Techno-economic assessment of enzymatic CO2 capture in hollow fiber membrane contactors with immobilized carbonic anhydrase. Sep Purif Technol 2022. [DOI: 10.1016/j.seppur.2022.122702] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/18/2022]
|
6
|
Rasouli H, Nguyen K, Iliuta MC. Recent advancements in carbonic anhydrase immobilization and its implementation in CO2 capture technologies: A review. Sep Purif Technol 2022. [DOI: 10.1016/j.seppur.2022.121299] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/16/2022]
|
7
|
RASOULI H, ILIUTA I, BOUGIE F, GARNIER A, ILIUTA MC. Hybrid enzymatic CO2 capture process in intensified flat sheet membrane contactors with immobilized carbonic anhydrase. Sep Purif Technol 2022. [DOI: 10.1016/j.seppur.2022.120505] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/19/2022]
|
8
|
Baghbaderani SS, Mokarian P, Moazzam P. A Review on Electrochemical Sensing of Cancer Biomarkers Based on
Nanomaterial - Modified Systems. CURR ANAL CHEM 2022. [DOI: 10.2174/1573411016999200917161657] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/22/2022]
Abstract
Diagnosis of cancer in the early stages can help treat efficiently and reduce cancerrelated
death. Cancer biomarkers can respond to the presence of cancer in body fluids before the
appearance of any other symptoms of cancer. The integration of nanomaterials into biosensors as
electrochemical platforms offer rapid, sensitive detection for cancer biomarkers. The use of surface-
modified electrodes by carbon nanomaterials and metal nanoparticles enhances the performance
of electrochemical analysis in biosensing systems through the increase of bioreceptors loading
capacity on the surface. In this review, novel approaches based on nanomaterial-modified systems
in the point of care diagnostics are highlighted.
Collapse
Affiliation(s)
- Sorour Salehi Baghbaderani
- Department of Nanotechnology Engineering, Faculty of Advanced Sciences and Technologies, University of Isfahan, Isfahan 81746-73441,Iran
| | - Parastou Mokarian
- Department of Biology, Faculty of Sciences, Central Tehran Branch, Islamic Azad University, Tehran 14676-86831,Iran
| | - Parisa Moazzam
- School of Chemistry, University of New South Wales, Sydney, 2052,Australia
| |
Collapse
|
9
|
Ahmad Rizal Lim FN, Marpani F, Anak Dilol VE, Mohamad Pauzi S, Othman NH, Alias NH, Nik Him NR, Luo J, Abd Rahman N. A Review on the Design and Performance of Enzyme-Aided Catalysis of Carbon Dioxide in Membrane, Electrochemical Cell and Photocatalytic Reactors. MEMBRANES 2021; 12:membranes12010028. [PMID: 35054554 PMCID: PMC8778536 DOI: 10.3390/membranes12010028] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 11/09/2021] [Revised: 11/28/2021] [Accepted: 12/04/2021] [Indexed: 11/17/2022]
Abstract
Multi-enzyme cascade catalysis involved three types of dehydrogenase enzymes, namely, formate dehydrogenase (FDH), formaldehyde dehydrogenase (FaldDH), alcohol dehydrogenase (ADH), and an equimolar electron donor, nicotinamide adenine dinucleotide (NADH), assisting the reaction is an interesting pathway to reduce thermodynamically stable molecules of CO2 from the atmosphere. The biocatalytic sequence is interesting because it operates under mild reaction conditions (low temperature and pressure) and all the enzymes are highly selective, which allows the reaction to produce three basic chemicals (formic acid, formaldehyde, and methanol) in just one pot. There are various challenges, however, in applying the enzymatic conversion of CO2, namely, to obtain high productivity, increase reusability of the enzymes and cofactors, and to design a simple, facile, and efficient reactor setup that will sustain the multi-enzymatic cascade catalysis. This review reports on enzyme-aided reactor systems that support the reduction of CO2 to methanol. Such systems include enzyme membrane reactors, electrochemical cells, and photocatalytic reactor systems. Existing reactor setups are described, product yields and biocatalytic productivities are evaluated, and effective enzyme immobilization methods are discussed.
Collapse
Affiliation(s)
- Fatin Nasreen Ahmad Rizal Lim
- School of Chemical Engineering, College of Engineering, Universiti Teknologi MARA, Shah Alam 40450, Malaysia; (F.N.A.R.L.); (V.E.A.D.); (S.M.P.); (N.H.O.); (N.H.A.); (N.R.N.H.); (N.A.R.)
| | - Fauziah Marpani
- School of Chemical Engineering, College of Engineering, Universiti Teknologi MARA, Shah Alam 40450, Malaysia; (F.N.A.R.L.); (V.E.A.D.); (S.M.P.); (N.H.O.); (N.H.A.); (N.R.N.H.); (N.A.R.)
- Catalysis for Sustainable Water and Energy Nexus Research Group, School of Chemical Engineering, College of Engineering, Universiti Teknologi MARA, Shah Alam 40450, Malaysia
- Correspondence: ; Tel.: +60-35543-6510; Fax: +60-35543-6300
| | - Victoria Eliz Anak Dilol
- School of Chemical Engineering, College of Engineering, Universiti Teknologi MARA, Shah Alam 40450, Malaysia; (F.N.A.R.L.); (V.E.A.D.); (S.M.P.); (N.H.O.); (N.H.A.); (N.R.N.H.); (N.A.R.)
| | - Syazana Mohamad Pauzi
- School of Chemical Engineering, College of Engineering, Universiti Teknologi MARA, Shah Alam 40450, Malaysia; (F.N.A.R.L.); (V.E.A.D.); (S.M.P.); (N.H.O.); (N.H.A.); (N.R.N.H.); (N.A.R.)
| | - Nur Hidayati Othman
- School of Chemical Engineering, College of Engineering, Universiti Teknologi MARA, Shah Alam 40450, Malaysia; (F.N.A.R.L.); (V.E.A.D.); (S.M.P.); (N.H.O.); (N.H.A.); (N.R.N.H.); (N.A.R.)
- Catalysis for Sustainable Water and Energy Nexus Research Group, School of Chemical Engineering, College of Engineering, Universiti Teknologi MARA, Shah Alam 40450, Malaysia
| | - Nur Hashimah Alias
- School of Chemical Engineering, College of Engineering, Universiti Teknologi MARA, Shah Alam 40450, Malaysia; (F.N.A.R.L.); (V.E.A.D.); (S.M.P.); (N.H.O.); (N.H.A.); (N.R.N.H.); (N.A.R.)
- Catalysis for Sustainable Water and Energy Nexus Research Group, School of Chemical Engineering, College of Engineering, Universiti Teknologi MARA, Shah Alam 40450, Malaysia
| | - Nik Raikhan Nik Him
- School of Chemical Engineering, College of Engineering, Universiti Teknologi MARA, Shah Alam 40450, Malaysia; (F.N.A.R.L.); (V.E.A.D.); (S.M.P.); (N.H.O.); (N.H.A.); (N.R.N.H.); (N.A.R.)
| | - Jianquan Luo
- State Key Laboratory of Biochemical Engineering, Institute of Process Engineering, Chinese Academy of Sciences, Beijing 100190, China;
| | - Norazah Abd Rahman
- School of Chemical Engineering, College of Engineering, Universiti Teknologi MARA, Shah Alam 40450, Malaysia; (F.N.A.R.L.); (V.E.A.D.); (S.M.P.); (N.H.O.); (N.H.A.); (N.R.N.H.); (N.A.R.)
| |
Collapse
|
10
|
Immobilization of carbonic anhydrase for CO2 capture and its industrial implementation: A review. J CO2 UTIL 2021. [DOI: 10.1016/j.jcou.2021.101475] [Citation(s) in RCA: 27] [Impact Index Per Article: 9.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/18/2022]
|
11
|
Liu Q, Bai X, Pham H, Hu J, Dinu CZ. Active Nanointerfaces Based on Enzyme Carbonic Anhydrase and Metal-Organic Framework for Carbon Dioxide Reduction. NANOMATERIALS 2021; 11:nano11041008. [PMID: 33920833 PMCID: PMC8071118 DOI: 10.3390/nano11041008] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 03/15/2021] [Revised: 04/01/2021] [Accepted: 04/06/2021] [Indexed: 01/19/2023]
Abstract
Carbonic anhydrases are enzymes capable of transforming carbon dioxide into bicarbonate to maintain functionality of biological systems. Synthetic isolation and implementation of carbonic anhydrases into membrane have recently raised hopes for emerging and efficient strategies that could reduce greenhouse emission and the footprint of anthropogenic activities. However, implementation of such enzymes is currently challenged by the resulting membrane’s wetting capability, overall membrane performance for gas sensing, adsorption and transformation, and by the low solubility of carbon dioxide in water, the required medium for enzyme functionality. We developed the next generation of enzyme-based interfaces capable to efficiently adsorb and reduce carbon dioxide at room temperature. For this, we integrated carbonic anhydrase with a hydrophilic, user-synthesized metal–organic framework; we showed how the framework’s porosity and controlled morphology contribute to viable enzyme binding to create functional surfaces for the adsorption and reduction of carbon dioxide. Our analysis based on electron and atomic microscopy, infrared spectroscopy, and colorimetric assays demonstrated the functionality of such interfaces, while Brunauer–Emmett–Teller analysis and gas chromatography analysis allowed additional evaluation of the efficiency of carbon dioxide adsorption and reduction. Our study is expected to impact the design and development of active interfaces based on enzymes to be used as green approaches for carbon dioxide transformation and mitigation of global anthropogenic activities.
Collapse
|
12
|
Verma M, Bhaduri GA, Phani Kumar VS, Deshpande PA. Biomimetic Catalysis of CO 2 Hydration: A Materials Perspective. Ind Eng Chem Res 2021. [DOI: 10.1021/acs.iecr.0c06203] [Citation(s) in RCA: 10] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/01/2023]
Affiliation(s)
- Manju Verma
- Department of Chemical Engineering, Motilal Nehru National Institute of Technology Allahabad, Prayagraj 211004, India
| | - Gaurav A. Bhaduri
- Department of Chemical Engineering, Indian Institute of Technology Jammu, Jammu and Kashmir, 181221, India
| | - V. Sai Phani Kumar
- Quantum and Molecular Engineering Laboratory, Department of Chemical Engineering Indian Institute of Technology Kharagpur, Kharagpur, 721302, India
| | - Parag A. Deshpande
- Quantum and Molecular Engineering Laboratory, Department of Chemical Engineering Indian Institute of Technology Kharagpur, Kharagpur, 721302, India
| |
Collapse
|
13
|
Chai M, Ye Y, Razmjou A, Chen V. Insights into the Mass Transfer Improvement of a Submerged Forward Osmosis System with Vibration-Induced Shear Enhancement. Ind Eng Chem Res 2021. [DOI: 10.1021/acs.iecr.0c05316] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/28/2022]
Affiliation(s)
- Milton Chai
- UNESCO Centre for Membrane Science and Technology, School of Chemical Engineering, The University of New South Wales, Sydney, NSW 2052, Australia
| | - Yun Ye
- UNESCO Centre for Membrane Science and Technology, School of Chemical Engineering, The University of New South Wales, Sydney, NSW 2052, Australia
| | - Amir Razmjou
- UNESCO Centre for Membrane Science and Technology, School of Chemical Engineering, The University of New South Wales, Sydney, NSW 2052, Australia
- Centre for Technology in Water and Wastewater, University of Technology Sydney, Ultimo, New South Wales 2007, Australia
| | - Vicki Chen
- UNESCO Centre for Membrane Science and Technology, School of Chemical Engineering, The University of New South Wales, Sydney, NSW 2052, Australia
- School of Chemical Engineering, University of Queensland, St. Lucia, Queensland 4072, Australia
| |
Collapse
|
14
|
Castro AMD, Prasavath D, Bevilaqua JV, Portugal CA, Neves LA, Crespo JG. Role of water on deep eutectic solvents (DES) properties and gas transport performance in biocatalytic supported DES membranes. Sep Purif Technol 2021. [DOI: 10.1016/j.seppur.2020.117763] [Citation(s) in RCA: 6] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/23/2022]
|
15
|
|
16
|
Nadar SS, Vaidya L, Rathod VK. Enzyme embedded metal organic framework (enzyme–MOF): De novo approaches for immobilization. Int J Biol Macromol 2020; 149:861-876. [DOI: 10.1016/j.ijbiomac.2020.01.240] [Citation(s) in RCA: 65] [Impact Index Per Article: 16.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/26/2019] [Revised: 01/21/2020] [Accepted: 01/23/2020] [Indexed: 12/25/2022]
|
17
|
Gu F, Wang Y, Meng Z, Liu W, Qiu L. A coupled photocatalytic/enzymatic system for sustainable conversion of CO2 to formate. CATAL COMMUN 2020. [DOI: 10.1016/j.catcom.2019.105903] [Citation(s) in RCA: 6] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/08/2023] Open
|
18
|
Jacob P, Dejean B, Laborie S, Cabassud C. An optical in-situ tool for visualizing and understanding wetting dynamics in membrane distillation. J Memb Sci 2020. [DOI: 10.1016/j.memsci.2019.117587] [Citation(s) in RCA: 15] [Impact Index Per Article: 3.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
|
19
|
Bakonyi P, Peter J, Koter S, Mateos R, Kumar G, Koók L, Rózsenberszki T, Pientka Z, Kujawski W, Kim SH, Nemestóthy N, Bélafi-Bakó K, Pant D. Possibilities for the biologically-assisted utilization of CO2-rich gaseous waste streams generated during membrane technological separation of biohydrogen. J CO2 UTIL 2020. [DOI: 10.1016/j.jcou.2019.11.008] [Citation(s) in RCA: 16] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
|
20
|
Xu Y, Goh K, Wang R, Bae TH. A review on polymer-based membranes for gas-liquid membrane contacting processes: Current challenges and future direction. Sep Purif Technol 2019. [DOI: 10.1016/j.seppur.2019.115791] [Citation(s) in RCA: 53] [Impact Index Per Article: 10.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/16/2022]
|
21
|
Babin A, Bougie F, Rodrigue D, Iliuta MC. A closer look on the development and commercialization of membrane contactors for mass transfer and separation processes. Sep Purif Technol 2019. [DOI: 10.1016/j.seppur.2019.115679] [Citation(s) in RCA: 6] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/26/2022]
|
22
|
Vitola G, Mazzei R, Poerio T, Barbieri G, Fontananova E, Büning D, Ulbricht M, Giorno L. Influence of Lipase Immobilization Mode on Ethyl Acetate Hydrolysis in a Continuous Solid–Gas Biocatalytic Membrane Reactor. Bioconjug Chem 2019; 30:2238-2246. [DOI: 10.1021/acs.bioconjchem.9b00463] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/28/2022]
Affiliation(s)
- Giuseppe Vitola
- Institute on Membrane Technology, National Research Council, ITM-CNR, via P. Bucci, 17/C, I-87030 Rende, Cosenza, Italy
| | - Rosalinda Mazzei
- Institute on Membrane Technology, National Research Council, ITM-CNR, via P. Bucci, 17/C, I-87030 Rende, Cosenza, Italy
| | - Teresa Poerio
- Institute on Membrane Technology, National Research Council, ITM-CNR, via P. Bucci, 17/C, I-87030 Rende, Cosenza, Italy
| | - Giuseppe Barbieri
- Institute on Membrane Technology, National Research Council, ITM-CNR, via P. Bucci, 17/C, I-87030 Rende, Cosenza, Italy
| | - Enrica Fontananova
- Institute on Membrane Technology, National Research Council, ITM-CNR, via P. Bucci, 17/C, I-87030 Rende, Cosenza, Italy
| | - Dominic Büning
- Lehrstuhl für Technische Chemie II, Universität Duisburg-Essen, 45117 Essen, Germany
| | - Mathias Ulbricht
- Lehrstuhl für Technische Chemie II, Universität Duisburg-Essen, 45117 Essen, Germany
| | - Lidietta Giorno
- Institute on Membrane Technology, National Research Council, ITM-CNR, via P. Bucci, 17/C, I-87030 Rende, Cosenza, Italy
| |
Collapse
|
23
|
Rehman ZU, Ghasem N, Al-Marzouqi M, Abdullatif N. WITHDRAWN: Enhancement of Carbon Dioxide Absorption using Nanofluids in Hollow Fiber Membrane Contactor. Chin J Chem Eng 2019. [DOI: 10.1016/j.cjche.2019.07.001] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/26/2022]
|
24
|
Xu Y, Lin Y, Chew NGP, Malde C, Wang R. Biocatalytic PVDF composite hollow fiber membranes for CO2 removal in gas-liquid membrane contactor. J Memb Sci 2019. [DOI: 10.1016/j.memsci.2018.11.043] [Citation(s) in RCA: 27] [Impact Index Per Article: 5.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/20/2023]
|
25
|
Zhang S, Du M, Shao P, Wang L, Ye J, Chen J, Chen J. Carbonic Anhydrase Enzyme-MOFs Composite with a Superior Catalytic Performance to Promote CO 2 Absorption into Tertiary Amine Solution. ENVIRONMENTAL SCIENCE & TECHNOLOGY 2018; 52:12708-12716. [PMID: 30345752 DOI: 10.1021/acs.est.8b04671] [Citation(s) in RCA: 64] [Impact Index Per Article: 10.7] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/08/2023]
Abstract
Carbonic anhydrase (CA) enzyme-based absorption technology for CO2 capture has been intensively investigated. The main issue related to this novel technology is the activity and stability of the CA enzyme under the typical flue gas conditions. To address this issue, CA enzymes were embedded into zeolitic imidazolate framework (ZIF-L) nanoparticles to synthesize a novel CA/ZIF-L-1 composite. The composite exhibited a superior apparent catalytic activity (1.5 times higher) for CO2 absorption compared with their free counterparts, which was due to the synergistic enhancement of CO2 adsorption by support ZIF-L and enzymatic catalysis. The analyses of Fourier transform infrared spectroscopy and circular dichroism revealed that the CA enzyme's secondary structure was not significantly varied during the CA/ZIF-L-1 preparation, resulting in a high enzyme activity retention. Moreover, the CA/ZIF-L-1 possessed a high thermal stability and reusability due to the structural rigidity and confinement of ZIF-L scaffolds. Compared with the free enzyme, its thermal stability was improved by approximately 100% at 40 °C. After six cycles of reuse, CA/ZIF-L-1 still retained a relative activity of 134%. Therefore, the CA/ZIF-L-1 can be a good candidate to promote the CO2 capture in industrial application.
Collapse
Affiliation(s)
- Shihan Zhang
- College of Environment , Zhejiang University of Technology , Hangzhou 310014 , China
| | - Mine Du
- College of Environment , Zhejiang University of Technology , Hangzhou 310014 , China
| | - Peijing Shao
- College of Environment , Zhejiang University of Technology , Hangzhou 310014 , China
| | - Lidong Wang
- School of Environmental Science and Engineering , North China Electric Power University , Baoding 071003 , China
| | - Jiexu Ye
- College of Environment , Zhejiang University of Technology , Hangzhou 310014 , China
| | - Jun Chen
- College of Environment , Zhejiang University of Technology , Hangzhou 310014 , China
| | - Jianmeng Chen
- College of Environment , Zhejiang University of Technology , Hangzhou 310014 , China
| |
Collapse
|
26
|
Nemestóthy N, Bakonyi P, Németh Z, Bélafi-Bakó K. Evaluation of pectin-reinforced supported liquid membranes containing carbonic anhydrase: The role of ionic liquid on enzyme stability and CO2 separation performance. J CO2 UTIL 2018. [DOI: 10.1016/j.jcou.2017.12.001] [Citation(s) in RCA: 11] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/18/2022]
|
27
|
Malankowska M, Martins C, Rho H, Neves L, Tiggelaar R, Crespo J, Pina M, Mallada R, Gardeniers H, Coelhoso I. Microfluidic devices as gas – Ionic liquid membrane contactors for CO2 removal from anaesthesia gases. J Memb Sci 2018. [DOI: 10.1016/j.memsci.2017.09.065] [Citation(s) in RCA: 15] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/25/2022]
|
28
|
Gao S, Mohammad M, Yang HC, Xu J, Liang K, Hou J, Chen V. Janus Reactors with Highly Efficient Enzymatic CO 2 Nanocascade at Air-Liquid Interface. ACS APPLIED MATERIALS & INTERFACES 2017; 9:42806-42815. [PMID: 29160687 DOI: 10.1021/acsami.7b14465] [Citation(s) in RCA: 14] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/07/2023]
Abstract
Though enzymatic cascade reactors have been the subject of intense research over the past few years, their application is still limited by the complicated fabrication protocols, unsatisfactory stability and lack of effective reactor designs. In addition, the spatial positioning of the cascade reactor has so far not been investigated, which is of significant importance for biphase catalytic reaction systems. Inspired by the Janus properties of the lipid cellular membrane, here we show a highly efficient Janus gas-liquid reactor for CO2 hydration and conversion. Within the Janus reactor, nanocascades containing the nanoscale compartmentalized carbonic anhydrase and formic dehydrogenase were positioned at a well-defined gas-liquid interface, with a high substrate concentration gradient. The Janus reactor exhibited 2.5 times higher CO2 hydration efficiency compared with the conventional gas-liquid contactor with pristine membranes, and the formic acid conversion rate can reach approximately 90%. Through this work, we provide evidence that the spatial arrangement of the nanocascade is also crucial to efficient reactions, and the Janus reactor can be a promising candidate for the biphase catalytic reactions in environmental, biological and energy aspects.
Collapse
Affiliation(s)
- Song Gao
- UNESCO Centre for Membrane Science and Technology, School of Chemical Engineering, University of New South Wales , Sydney 2052, Australia
| | - Munirah Mohammad
- UNESCO Centre for Membrane Science and Technology, School of Chemical Engineering, University of New South Wales , Sydney 2052, Australia
| | - Hao-Cheng Yang
- MOE Key Laboratory of Macromolecular Synthesis and Functionalization, Department of Polymer Science and Engineering, Zhejiang University , Zhejiang 310027, People's Republic of China
| | - Jia Xu
- Key Laboratory of Marine Chemistry Theory and Technology, Ocean University of China, Ministry of Education , Qingdao 266100, People's Republic of China
| | - Kang Liang
- UNESCO Centre for Membrane Science and Technology, School of Chemical Engineering, University of New South Wales , Sydney 2052, Australia
- Graduate School of Biomedical Engineering, University of New South Wales , Sydney 2052, Australia
| | - Jingwei Hou
- UNESCO Centre for Membrane Science and Technology, School of Chemical Engineering, University of New South Wales , Sydney 2052, Australia
- Department of Materials Science and Metallurgy, University of Cambridge , Cambridge CB3 0FS, United Kingdom
| | - Vicki Chen
- UNESCO Centre for Membrane Science and Technology, School of Chemical Engineering, University of New South Wales , Sydney 2052, Australia
| |
Collapse
|
29
|
Experimental and simulation study of a novel hybrid absorption and stripping membrane contactor for carbon capture. J Taiwan Inst Chem Eng 2017. [DOI: 10.1016/j.jtice.2017.10.009] [Citation(s) in RCA: 5] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/21/2022]
|
30
|
Structure and activity of magnetic cross-linked enzyme aggregates of bovine carbonic anhydrase as promoters of enzymatic CO 2 capture. Biochem Eng J 2017. [DOI: 10.1016/j.bej.2017.08.014] [Citation(s) in RCA: 20] [Impact Index Per Article: 2.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/14/2022]
|
31
|
Izák P, Bobbink FD, Hulla M, Klepic M, Friess K, Hovorka Š, Dyson PJ. Catalytic Ionic-Liquid Membranes: The Convergence of Ionic-Liquid Catalysis and Ionic-Liquid Membrane Separation Technologies. Chempluschem 2017; 83:7-18. [PMID: 31957320 DOI: 10.1002/cplu.201700293] [Citation(s) in RCA: 17] [Impact Index Per Article: 2.4] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/03/2017] [Revised: 08/24/2017] [Indexed: 12/17/2022]
Abstract
Membrane technologies enable the facile separation of complex mixtures of gases, vapours, liquids and/or solids under mild conditions. Simultaneous chemical transformations can also be achieved in membranes by using catalytically active membrane materials or embedded catalysts, in so-called membrane reactors. A particular class of membranes containing or composed of ionic liquids (ILs) or polymeric ionic liquids (pILs) have recently emerged. These membranes often exhibit superior transport and separation properties to those of classical polymeric membranes. ILs and pILs have also been extensively studied as separation solvents, catalysts and co-catalysts in similar applications for which membranes are employed. In this review, after introducing ILs and their applications in catalysis, catalytic membranes and recent advances in membrane separation processes based on ILs are described. Finally, the nascent concept of catalytic IL membranes is highlighted, in which catalytically active ILs/pILs are incorporated into membrane technologies to act as a catalytic separation layer.
Collapse
Affiliation(s)
- Pavel Izák
- Institute of Chemical Process Fundamentals of the Czech Academy of Science, v.v.i. Rozvojová 135, 165 02, Prague 6, Czech Republic
| | - Felix D Bobbink
- Institute of Chemical Sciences and Engineering, École Polytechnique Fédérale de Lausanne (EPFL), CH 1015, Lausanne, Switzerland
| | - Martin Hulla
- Institute of Chemical Sciences and Engineering, École Polytechnique Fédérale de Lausanne (EPFL), CH 1015, Lausanne, Switzerland
| | - Martina Klepic
- University of Chemistry and Technology, Technická 5, 166 28, Prague, Czech Republic
| | - Karel Friess
- University of Chemistry and Technology, Technická 5, 166 28, Prague, Czech Republic
| | - Štěpán Hovorka
- University of Chemistry and Technology, Technická 5, 166 28, Prague, Czech Republic
| | - Paul J Dyson
- Institute of Chemical Sciences and Engineering, École Polytechnique Fédérale de Lausanne (EPFL), CH 1015, Lausanne, Switzerland
| |
Collapse
|
32
|
Nogalska A, Trojanowska A, Garcia-Valls R. Membrane contactors for CO2 capture processes – critical review. PHYSICAL SCIENCES REVIEWS 2017. [DOI: 10.1515/psr-2017-0059] [Citation(s) in RCA: 5] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/15/2022]
Abstract
AbstractThe use of membrane contactor in industrial processes is wide, and lately it started to be used in CO
Collapse
|
33
|
Maeshima K, Yoshimoto M. Preparation and characterization of carbonic anhydrase-conjugated liposomes for catalytic synthesis of calcium carbonate particles. Enzyme Microb Technol 2017; 105:9-17. [PMID: 28756864 DOI: 10.1016/j.enzmictec.2017.06.002] [Citation(s) in RCA: 14] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/18/2017] [Revised: 05/15/2017] [Accepted: 06/03/2017] [Indexed: 11/27/2022]
Abstract
The biomimetic approach using immobilized enzymes is useful for the synthesis of structurally defined inorganic materials. In this work, carbonic anhydrase (CA) from bovine erythrocytes was covalently conjugated at 25°C to the liposomes composed of 15mol% 1-palmitoyl-2-oleoyl-sn-glycero-3-phosphoethanolamine-N-(glutaryl) (NG-POPE), and the zwitterionic and anionic phospholipids with the same acyl chains as NG-POPE. For the conjugation, the carboxyl groups of liposomal NG-POPE were activated with 11mM 1-ethyl-3-(3-dimethylaminopropyl)carbodiimide (EDC) and 4.6mM N-hydroxysulfosuccinimide (sulfo-NHS). The carbonic anhydrase-conjugated liposomes (CALs) with the mean hydrodynamic diameter of 149nm showed the esterase activity corresponding to on average 5.5×102 free CA molecules per liposome. On the other hand, the intrinsic fluorescence and absorbance measurements consistently revealed that on average 1.4×103 CA molecules were conjugated to a liposome, suggesting that the molecular orientation of enzyme affected its activity. The formation of calcium carbonate particles was significantly accelerated by the CALs ([lipid]=50μ M) in the 0.3M Tris solution at 10-40°C with dissolved CO2 (≈17mM) and CaCl2 (46mM). The anionic CALs were adsorbed with calcium as revealed with the ζ-potential measurements. The CAL system offered the calcium-rich colloidal interface where the bicarbonate ions were catalytically produced by the liposome-conjugated CA molecules. The CALs also functioned in the external loop airlift bubble column operated with a model flue gas (10vol/vo% CO2), yielding partly agglomerated calcium carbonate particles as observed with the scanning electron microscopy (SEM).
Collapse
Affiliation(s)
- Keisuke Maeshima
- Department of Applied Molecular Bioscience, Yamaguchi University, Tokiwadai 2-16-1, Ube 755-8611, Japan
| | - Makoto Yoshimoto
- Department of Applied Molecular Bioscience, Yamaguchi University, Tokiwadai 2-16-1, Ube 755-8611, Japan.
| |
Collapse
|