Stress of cupric ion and oxytetracycline in Chlorella vulgaris cultured in swine wastewater

Regulation and microbial response mechanism of nitric oxide to copper-containing swine wastewater treated by Pistia stratiotes

As a signaling molecule, Nitric oxide (NO) has been widely used in abiotic stress mitigation studies.Pistia stratiotes showed a good synergistic removal effect on heavy metals, nitrogen and phosphorus, but the high concentration of copper(Cu) in swine wastewater inhibited the comprehensive removal ability of Pistia stratiotes. At present, it is not clear how the addition of NO regulates the stress resistance mechanism of Pistia stratiotes to copper in swine wastewater, and the microbial response mechanism accompanying this process is not yet clear. Therefore, in the concentration range of 0.31∼4 mg·L-1Cu2+ and NO concentration of 0,0.05 and 0.1 mg L-1, the removal effect of Pistia stratiotes on copper from swine wastewater was studied. The results showed as follows: The treatment of non-available copper in groups M and H increased by 10.67% and 22.31%, respectively, compared with that in group L. The critical point of inhibiting effect of NO on growth rate was 2.03 mg·L-1Cu. By measuring three-dimensional fluorescence spectrum, combined with parallel factor analysis and principal component analysis, it was confirmed that exogenous addition of NO affected the humification degree of dissolved organic matter(DOM) and promoted the chelation of organic matter with copper. With the increase of Cu concentration, the Reyranella and Prosthecobacter with certain copper resistance gradually gained advantages. Redundancy analysis(RDA) showed that Emiticicia had a strong correlation with the removal rates of ammonia nitrogen, total phosphorus and copper in swine wastewater, while hgcI_clade had a strong correlation with the removal rates of total nitrogen. In conclusion, controlling the dosage of NO can effectively improve the tolerance and removal effect of Pistia stratiotes on copper in swine wastewater, which is of great significance for promoting the treatment and resource transformation of swine wastewater.

Inhibition of zinc ions in sulfur-driven autotrophic denitrification process: What is the behavior of extracellular polymeric substances?

Sulfur-driven autotrophic denitrification (SAD) process is a cost-effective and sustainable method for nitrogen removal from wastewater. However, a higher concentration of zinc ions (Zn(II)) flowing into wastewater treatment plants poses a potential threat to the SAD process. This study examined that a half maximal inhibitory concentration (IC50) of Zn(II) was 7 mg·L-1 in the SAD process. Additionally, the addition of 20 mg·L-1 Zn(II) resulted in a severe accumulation of nitrite to 150.20 ± 6.00 mg·L-1 when the initial concentration of nitrate was 500 mg·L-1. Moreover, the activities of nitrate reductase, nitrite reductase, dehydrogenase and electron transport system were significantly inhibited under Zn(II) stress. The addition of Zn(II) inhibited EPS secretion and worsened electrochemical properties. The result was attributed to the spontaneous binding between EPS and Zn(II), with a ΔG of -17.50 KJ·mol-1 and a binding constant of 1.77 × 104 M-1, respectively. Meanwhile, the protein, fulvic acid, and humic-like substances occurred static quenching after Zn(II) addition, with -OH and -C=O groups providing binding sites. The binding sequence was fulvic acid→protein→humic acid and -OH → -C=O. Zn(II) also reduced the content of α-helix, which was unfavorable for electron transfer. Additionally, the Zn(II) loosened protein structure, resulting in a 50 % decrease in α-helix/(β-sheet+random coil). This study reveals the effect of Zn(II) on the SAD process and enhances our understanding of EPS behavior under metal ions stress.

Self-flocculating Chlorella vulgaris: A high-efficiency purification mechanism of radioactive Th4+ in an aquatic environment

This study aimed to investigate the purification of radioactive thorium (Th4+) by Chlorella vulgaris in aquatic environments. Single-factor experiments and response surface optimization tests identified optimal purification conditions. The purification and metabolic response mechanisms of Chlorella to Th4+ were elucidated using physiological and biochemical analyses, three-dimensional excitation-emission matrix (3D-EEM) analysis, and metabolomic profiling. Increases in the Th4+ concentration caused Chlorella to self-flocculate, significantly improving the Th4+ purification efficiency. Under optimal conditions, the Th4+ purification efficiency for Th4+ in wastewater by Chlorella stabilized between 94.3 % and 98.2 %. Morphological analysis revealed that the purified Th4+ existed mainly in a stable residual state. Chlorella efficiently purified wastewater during treatment by regulating environmental pH, performing redox reactions, and utilizing extracellular polymeric substances (EPS) to interact with Th4+. Metabolomic analysis indicated that Chlorella adapted to the Th4+-contaminated environment and enhanced its purification function by adjusting the synthesis of metabolites, such as carbohydrates, nucleotides, and amino acids. Chlorella demonstrated a remarkable self-flocculation phenomenon and a high-efficiency purification capability for Th4+, offering new possibilities for environmental remediation. Its purification mechanism involves environmental regulation, redox reactions, and complex metabolic adjustments. The results presented here provide theoretical support for environmental remediation using Chlorella.

Chronic toxic effects of erythromycin and its photodegradation products on microalgae Chlorella pyrenoidosa

The photodegradation products (PDPs) of antibiotics in the aquatic environment received increasing concern, but their chronic effects on microalgae remain unclear. This study initially focused on examining the acute effects of erythromycin (ERY), then explored the chronic impacts of ERY PDPs on Chlorella pyrenoidosa. ERY of 4.0 - 32 mg/L ERY notably inhibited the cell growth and chlorophyll synthesis. The determined 96 h median effective concentration of ERY to C. pyrenoidosa was 11.78 mg/L. Higher concentrations of ERY induced more serious oxidative damage, antioxidant enzymes alleviated the oxidative stress. 6 PDPs (PDP749, PDP747, PDP719, PDP715, PDP701 and PDP557) were identified in the photodegradation process of ERY. The predicted combined toxicity of PDPs increased in the first 3 h, then decreased. Chronic exposure showed a gradual decreasing inhibition on microalgae growth and chlorophyll content. The acute effect of ERY PDPs manifested as growth stimulation, but the chronic effect manifested as growth inhibition. The malonaldehyde contents decreased with the degradation time of ERY at 7, 14 and 21 d. However, the malonaldehyde contents of ERY PDPs treatments were elevated compared to those in the control group after 21 d. Risk assessment still need to consider the potential toxicity of degradation products under long-term exposure.

Simultaneous removal of nitrate, oxytetracycline and copper by ferrous-manganese co-driven immobilized bioreactor

The treatment of polluted water contaminated by nitrate, antibiotics, and heavy metals is a difficult problem in the current water treatment process. In this study, MnFe2O4 modified illite was mixed with sodium alginate (SA) to prepare a biological carrier illite@MnFe2O4@SA (IMFSA), which was used to immobilize strain Zoogloea sp. MFQ7 and construct a bioreactor. The bioreactor can use sodium acetate as a carbon source as well as ferrous and manganese ions as additional electron donors to achieve efficient nitrate removal. The denitrification capability of bioreactor was considerably enhanced by the addition of illite@MnFe2O4 (IMF) in comparison to SA biological carrier. The bioreactor was able to achieve a nitrate removal efficiency of 97.2% when hydraulic retention time is 5.0 h, C/N ratio is 2.0, and the concentration of Fe2+ and Mn2+ were 5.0 mg L-1. Furthermore, the bioreactor can achieve efficient removal of oxytetracycline (91.8%) and copper (85.6%) through the adsorption by IMF and biological iron-manganese precipitates. High-throughput sequencing results indicated that Zoogloea was successfully immobilized into the biocarrier. According to the KEGG database, it is suggested that the addition of modified IMF enhances denitrification and stimulates the expression of genes associated with the iron-manganese redox cycle.

Effects of dilution and pretreatment on nutrient removal and biomass production of Chlorella vulgaris in kitchen wastewater

This research investigated the effect of kitchen wastewater (KWW) concentrations and pretreatment methods on Chlorella vulgaris biomass production, lipid content and nutrient removal. This study was divided into two separate experiments. The first experiment determined the appropriate dilution rate of KWW for the growth of microalgae, sterilized KWW was varied between 25%, 50%, 75%, and 100%(v/v). The result indicated that 50%(v/v) showed the highest nutrient removal by 90.23%, 85.87%, and 80.64% of sCOD, TKN, and TP, respectively. The highest biomass and lipid content were obtained with 50%(v/v) (1.447 g/L, 37.9%). The second experiment was to find an effective physical pretreatment method, which separated the biotic contaminant, non-sterilized KWW was diluted 50%(v/v) and filtered with different mesh size filters (150 μm, 50 μm, and 30 μm) compared with sterilized KWW as a control sample. The result indicated that pretreatment with 50 μm filtration was found highest nutrient removal by 90.51%, 84.74%, and 77.50% of sCOD, TKN, and TP, respectively. The highest biomass and lipid content were obtained with 50 μm filtration (1.496 g/L, 39.4%). Our results support the hypothesis that the optimal dilution and proper filtration of KWW helps create more favorable environment for microalgal growth.

Growth of Scenedesmus obliquus in anaerobically digested swine wastewater from different cleaning processes for pollutants removal and biomass production

Anaerobically digested swine wastewater (ASW) purification by microalgae provides a promising strategy for nutrients recovery, biomass production and CO2 capture. However, the characteristics of ASW from different cleaning processes vary greatly. At present, the cultivation of microalgae in ASW from different manure cleaning processes is rarely investigated and compared. That may bring uncertainty for microalgae growth using different ASW in large-scale application. Thus, the ASW from three cleaning processes were tested for cultivating microalgae, including manure dry collection (I), water flushing (II) and water submerging processes (III). The characteristics of ASW from three manure cleaning processes varied greatly such as nutrient and heavy metals levels. High concentration of ammonia and copper in ASW significantly inhibited microalgae growth. Fortunately, the supply of high CO2 (10%) effectively alleviated negative influences, ensuring microalgal growth at low dilution ratio. The characteristics of three ASW resulted in significant differences in microalgae growth and biomass components. The maximal biomass production in optimal diluted ASW-I, II and III reached 1.46 g L-1, 2.19 g L-1 and 2.47 g L-1, respectively. The removal of organic compounds, ammonia and phosphorus by optimal microalgae growth in diluted ASW-I, II and III was 50.6%/94.2%/64.7%, 63.7%/82.3%/57.6% and 83.2%/91.7%/59.7%, respectively. The culture in diluted ASW-I, II and III obtained the highest lipids production of 12.1 mg L-1·d-1, 16.5 mg L-1·d-1 and 19.4 mg L-1·d-1, respectively. The analysis of lipids compositions revealed that the proportion of saturated fatty acids accounted for 36.4%, 32.4% and 27.9 % in optimal diluted ASW-I, II and III, as ideal raw materials for biodiesel production.