Past, present, and future trends in boar taint detection

Development of a highly reproducible GC-HRMS method for determination of Skatole in pig tissues

This study presents a sensitive and reproducible mass spectrometry method for quantifying skatole in porcine adipose tissue, muscle, and serum samples applicable for abattoirs and laboratories. Leveraging gas chromatography-high-resolution Orbitrap microscopy and microwave-assisted liquefication of the adipose tissue, the method demonstrates robust performance across key parameters. Impressive linearity (R2) values of 0.9999 and 0.9996 for adipose tissue and serum, respectively. Notably, the method exhibits a low Limit of Detection (LoD) of 0.5 ppb for adipose tissue and 0.9 ppb for serum, with corresponding Limits of Quantification (LoQ) at 1.65 ppb and 3.04 ppb, respectively. The method showed significant reproducibility of 5.9% and repeatability (RSD%) of 8.78% for adipose tissue and 4.08% for serum, with recovery rates of 90% and 87%, respectively. This streamlined method offers promising, effective quantification of boar taint compounds, emphasizing its sensitivity and reproducibility.

Enhanced HPLC Method for Boar Taint Quantification

Boar taint is an unpleasant odour found in the carcasses of entire male pigs, resulting from androstenone and skatole accumulation during pubertal development, and impacting pork quality. This study proposes the validation of an adapted chromatographic method for quantifying skatole and androstenone in the pigs' liquid fat using fluorescence detection. A good chromatographic separation was achieved, with skatole (SKA) and androstenone (AND) elution at 4.4 and 9.9 min., respectively. An external calibration method was applied, with calibration curves correlation coefficient of 0.9999 for both analytes. Detection limit values were 1.53 and 16.02 ng/g for SKA and AND, respectively. SKA recovery was 99.72±2.34 % (2.34 % RSD) and 102.84±1.62 % (1.57 % RSD) for AND. Results showed good precision values (repeatability <2.46 % RSD for SKA, <6.85 % RSD for AND; intermediate precision <2.87 % RSD for SKA, <6.98 % RSD for AND). The method's robustness was tested and the values were within the reference ranges. The validation results proved that the adaptation of an existing method resulted in good assessments of robustness, reliability and accuracy.

Development and validation of a classification model for boar taint detection in pork fat samples

This study aims to characterize a complete volatile organic compound profile of pork neck fat for boar taint prediction. The objectives are to identify specific compounds related to boar taint and to develop a classification model. In addition to the well-known androstenone, skatole and indole, 10 other features were found to be discriminant according to untargeted volatolomic analyses were conducted on 129 samples using HS-SPME-GC×GC-TOFMS. To select the odor-positive samples among the 129 analyzed, the selection was made by combining human nose evaluations with the skatole and androstenone concentrations determined using UHPLC-MS/MS. A comparison of the data of the two populations was performed and a statistical model analysis was built on 70 samples out of the total of 129 samples fully positive or fully negative through these two orthogonal methods for tainted prediction. Then, the model was applied to the 59 remaining samples. Finally, 7 samples were classified as tainted.

Sustainable animal production: exploring the benefits of sperm sexing technologies in addressing critical industry challenges

The sex of the animals is of paramount importance in many animal production systems. This is particularly evident in the production of milk or in breeding programs focused on the production of female animals. In some cases, slaughter or euthanasia of animals of the unwanted sex becomes the only solution, highlighting ethical and economic concerns. As global demand for food continues to rise, the importance of addressing these issues becomes more evident. Reproductive technologies, such as sperm sexing techniques, may hold the key to addressing both animal welfare and the sustainability of animal production. The use of semen enriched with sperm capable of producing offspring of the desired sex can serve as a valuable tool for producers to exert greater control over production outcomes, not only helping to mitigate welfare issues related to the unnecessary premature death of unwanted offspring but also providing a possible ally in the face of stricter animal welfare guidelines. In addition, sexed semen can also contribute to financial gains and reduce greenhouse gas emissions and food waste associated with the less profitable part of the herd. This paper explores the positive impacts that sperm sexing can have on animal welfare, economy, and environment. It also discusses currently available options and strategies for more successful implementation of sexed semen. Partnerships between companies and scientists will be essential to find innovative ways to adapt current production systems and develop sperm sexing technologies that apply to most livestock industries.

Outdoor Finishing of Intact Male Portuguese Alentejano Pigs on a Sustainable High-Fiber Diet: Impacts on Blood, Growth, Carcass, Meat Quality and Boar Taint Compounds

This trial evaluated the effect of sex on the blood, growth, carcass, meat quality, and boar taint compounds in male Alentejano (AL) pigs (n = 30). From ~40 to 130 kg LW, castrated (C) and intact pigs (I and IExp groups) were fed commercial diets ad libitum. Between ~130 and 160 kg (slaughter), C and I pigs continued on commercial diets, while IExp were fed an experimental diet containing locally produced pulses and by-products aimed at reducing boar taint. At ~160 kg, blood urea levels were higher in IExp than C pigs, triacylglycerols were lower in both intact groups, and cortisol was lower in IExp. IExp pigs exhibited faster growth, improved feed conversion ratio, carcass higher commercial yield and leaner meat than C pigs. The loin intramuscular fat in intact pigs was lower, less saturated and more polyunsaturated, while total collagen was higher. Fat androstenone content was higher in intact pigs and skatole content was similar across treatments, although they were below threshold values for consumer detection. Finally, although boar taint compounds were low in intact AL pigs raised outdoors, adding pulses and by-products to the experimental diet did not result in a reduction in fat skatole content compared to pigs fed the commercial diet.

Lipid Serum Profiling of Boar-Tainted and Untainted Pigs Using GC×GC-TOFMS: An Exploratory Study

Mass spectrometry (MS)-based techniques, including liquid chromatography coupling, shotgun lipidomics, MS imaging, and ion mobility, are widely used to analyze lipids. However, with enhanced separation capacity and an optimized chemical derivatization approach, comprehensive two-dimensional gas chromatography (GC×GC) can be a powerful tool to investigate some groups of small lipids in the framework of lipidomics. This study describes the optimization of a dedicated two-stage derivatization and extraction process to analyze different saturated and unsaturated fatty acids in plasma by two-dimensional gas chromatography-time-of-flight mass spectrometry (GC×GC-TOFMS) using a full factorial design. The optimized condition has a composite desirability of 0.9159. This optimized sample preparation and chromatographic condition were implemented to differentiate between positive (BT) and negative (UT) boar-tainted pigs based on fatty acid profiling in pig serum using GC×GC-TOFMS. A chemometric screening, including unsupervised (PCA, HCA) and supervised analysis (PLS-DA), as well as univariate analysis (volcano plot), was performed. The results suggested that the concentration of PUFA ω-6 and cholesterol derivatives were significantly increased in BT pigs, whereas SFA and PUFA ω-3 concentrations were increased in UT pigs. The metabolic pathway and quantitative enrichment analysis suggest the significant involvement of linolenic acid metabolism.

A Scenario Analysis for Implementing Immunocastration as a Single Solution for Piglet Castration

Painful castration of male piglets to avoid boar taint can potentially be replaced by three more ethical alternatives: entire male production in combination with a detection method, immunocastration (an active vaccination against the gonadotrophin-releasing factor, GnRF), and castration with pain relief (anesthesia and/or analgesia). With the aim of abandoning piglet castration and facilitating internal trade, the European Union (EU) was initially in favor of a single alternative. Immunocastration was proposed as a potential solution, but it has not yet been sufficiently assessed regarding its market potential. To address this point, this paper uses scenario analysis to examine whether and under what conditions immunocastration could be the general solution sought by the EU. The study constructs two extreme scenarios: one in which all uncertain elements negatively influence the growth of immunocastration; another in which all uncertain elements have positive influences. These scenarios provide insights into the variance in possible futures for the implementation of immunocastration. The results show that it is unlikely that immunocastration will become a single solution for all producers in the EU, because it is not the optimal solution for all types of EU pork production systems (i.e., cost-efficiency oriented, quality oriented, animal-friendly oriented, import dependent). Rather than debating and looking for evidence about which single method is the best for the entire EU, EU authorities are advised to allow the co-existence of all alternatives and to develop protocols for applying them in the pork industry.

Dissecting grilled red and white meat flavor: Its characteristics, production mechanisms, influencing factors and chemical hazards

Meat flavor is composed of a complex mixture of volatile compounds developed as a result of heat driven multi-directional reactions. Typical reactions include Maillard reaction, lipid oxidation, as well as nitrogenous compounds degradation. Such complex flavor is characterized by a rich variety of volatile species, and to strongly influence consumer's preference. The objective of this review is to holistically dissect the flavor characteristic for cooked meat products with special emphasis on grilling and the factors that affect their production to ensure best quality and or safety levels. The review also highlights different analytical techniques used for the detection of flavor compounds in grilled meat. This comprehensive literature research critically analyze grilled flavor derived from heat mediated reactions, with a special emphasis on key flavors or hazard chemicals and their production mechanism. The various influencing factors i.e., grilling temperature, meat, food components, animal ante-mortem factors and food additives are summarized.

Comprehensive SPME-GC-MS Analysis of VOC Profiles Obtained Following High-Temperature Heating of Pork Back Fat with Varying Boar Taint Intensities

Boar taint detection is a major concern for the pork industry. Currently, this taint is mainly detected through a sensory evaluation. However, little is known about the entire volatile organic compounds (VOCs) profile perceived by the assessor. Additionally, many research groups are working on the development of new rapid and reliable detection methods, which include the VOCs sensor-based methods. The latter are susceptible to sensor poisoning by interfering molecules produced during high-temperature heating of fat. Analyzing the VOC profiles obtained by solid phase microextraction gas chromatography–mass spectrometry (SPME-GC-MS) after incubation at 150 and 180 °C helps in the comprehension of the environment in which boar taint is perceived. Many similarities were observed between these temperatures; both profiles were rich in carboxylic acids and aldehydes. Through a principal component analysis (PCA) and analyses of variance (ANOVAs), differences were highlighted. Aldehydes such as (E,E)-nona-2,4-dienal exhibited higher concentrations at 150 °C, while heating at 180 °C resulted in significantly higher concentrations in fatty acids, several amide derivatives, and squalene. These differences stress the need for standardized parameters for sensory evaluation. Lastly, skatole and androstenone, the main compounds involved in boar taint, were perceived in the headspace at these temperatures but remained low (below 1 ppm). Higher temperature should be investigated to increase headspace concentrations provided that rigorous analyses of total VOC profiles are performed.