Protection of cattle against rinderpest by intranasal immunisation with a dry powder tissue culture vaccine

Aerosolized Intratracheal Inoculation of Recombinant Protective Antigen (rPA) Vaccine Provides Protection Against Inhalational Anthrax in B10.D2-Hc0 Mice

Anthrax caused by Bacillus anthracis is a fatal zoonotic disease with a high lethality and poor prognosis. Inhalational anthrax is the most severe of the three forms of anthrax. The currently licensed commercial human anthrax vaccines require a complex immunization procedure for efficacy and have side effects that limit its use in emergent situations. Thus, development of a better anthrax vaccine is necessary. In this study, we evaluate the potency and efficacy of aerosolized intratracheal (i.t.) inoculation with recombinant protective antigen (rPA) subunit vaccines against aerosolized B. anthracis Pasteur II spores (an attenuated strain) challenge in a B10.D2-Hc⁰ mouse (deficient in complement component C5) model. Immunization of rPA in liquid, powder or powder reconstituted formulations via i.t. route conferred 100% protection against a 20× LD₅₀ aerosolized Pasteur II spore challenge in mice, compared with only 50% of subcutaneous (s.c.) injection with liquid rPA. Consistently, i.t. inoculation of rPA vaccines induced a higher lethal toxin (LeTx) neutralizing antibody titer, a stronger lung mucosal immune response and a greater cellular immune response than s.c. injection. Our results demonstrate that immunization with rPA dry powder vaccine via i.t. route may provide a stable and effective strategy to improve currently available anthrax vaccines and B10.D2-Hc⁰ mice challenged with B. anthracis attenuated strains might be an alternative model for anthrax vaccine candidate screening.

Assessment of the control measures of category A diseases of the Animal Health Law: Infection with rinderpest virus (Rinderpest)

EFSA received a mandate from the European Commission to assess the effectiveness of control measures against diseases included in the Category A list according to Regulation (EU) 2016/429 on transmissible animal diseases ('Animal Health Law'). This opinion belongs to a series of opinions where these control measures are assessed, with this opinion covering the assessment of control measures for rinderpest (RP), the only animal disease to have been globally eradicated. In this opinion, the AHAW Panel reviewed the effectiveness of: (i) clinical and laboratory sampling procedures, (ii) monitoring period and (iii) the minimum radius of the protection and surveillance zone, and the minimum length of time the measures should be applied in these zones. The general methodology used for this series of opinions has been published elsewhere. The transmission kernels used for the assessment of the minimum radius of the protection and surveillance zones are shown. Several scenarios for which control measures had to be assessed were agreed prior to the assessment. Considering that RP has been eradicated globally, a re-emergence that is not stopped in its early phases could have a devastating impact on animal health and the economy. The panel concludes that no suitable strategies are available to entirely mitigate the risk associated with granting derogations from killing of animals in an affected establishment or for animal movements. Therefore, the panel recommends to not grant any derogations. The monitoring period of 21 days was assessed as effective, except for the hypothetical first re-emergence of RP, when lack of awareness and diagnostic capability may extend the time to detection. It was concluded that the protection and the surveillance zones would contain 90% and > 99%, respectively, of the infections from an affected establishment. Enlarging the protection zone to 4 km would contain the disease spread with 95% probability.

Intranasal Vaccination Strategy to Control the COVID-19 Pandemic from a Veterinary Medicine Perspective

Simple Summary

Intranasal vaccination is one of the methods used to stimulate mucosal immunity. It has been widely practised to control many human and animal respiratory diseases. Coronavirus disease 2019 (COVID-19) is a highly contagious respiratory disease caused by severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2), which resulted in a global pandemic. COVID-19 has reminded some veterinarians of various contagious veterinary diseases, including coronavirus infections in animals. This article discusses the control of highly contagious diseases of veterinary importance with emphasis on an intranasal vaccination approach, and the potential of implementing similar strategies in human medicine to control the ongoing COVID-19 pandemic.

Abstract

The world is currently facing an ongoing coronavirus disease 2019 (COVID-19) pandemic. The disease is a highly contagious respiratory disease which is caused by severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2). Current control measures used by many countries include social distancing, wearing face masks, frequent hand washing, self-isolation, and vaccination. The current commercially available vaccines are injectable vaccines, although a few intranasal vaccines are in trial stages. The reported side effects of COVID-19 vaccines, perceptions towards the safety of the vaccines, and frequent mutation of the virus may lead to poor herd immunity. In veterinary medicine, attaining herd immunity is one of the main considerations in disease control, and herd immunity depends on the use of efficacious vaccines and the vaccination coverage in a population. Hence, many aerosol or intranasal vaccines have been developed to control veterinary respiratory diseases such as Newcastle disease, rinderpest, infectious bronchitis, and haemorrhagic septicaemia. Different vaccine technologies could be employed to improve vaccination coverage, including the usage of an intranasal live recombinant vaccine or live mutant vaccine. This paper discusses the potential use of intranasal vaccination strategies against human COVID-19, based on a veterinary intranasal vaccine strategy.

Formulation of a dry powder influenza vaccine for nasal delivery

The purpose of this research was to prepare a dry powder vaccine formulation containing whole inactivated influenza virus (VIIV) and a mucoadhesive compound suitable for nasal delivery. Powders containing WIIV and either lactose or trehalose were produced by lyophilization. A micro-ball mill was used to reduce the lyophilized cake to sizes suitable for nasal delivery. Chitosan flakes were reduced in size using a cryo-milling technique. Milled powders were sieved between 45 and 125 μm aggregate sizes and characterized for particle size and distribution, morphology, and flow properties. Powders were blended in the micro-ball mill without the ball. Lyophilization followed by milling produced irregularly shaped, polydisperse particles with a median primary particle diameter of ≈21 μm and a yield of ≈37% of particles in the 45 to 125 μm particle size range. Flow properties of lactose and trehalose powders after lyophilization followed by milling and sieving were similar. Cryo-milling produced a small yield of particles in the desired size range (<10%). Lyophilization followed by milling and sieving produced particles suitable for nasal delivery with different physicochemical properties as a function of processing conditions and components of the formulation. Further optimization of particle size and morphology is required for these powders to be suitable for clinical evaluation.

Stable dry powder formulation for nasal delivery of anthrax vaccine

There is a current biodefense interest in protection against anthrax. Here, we developed a new generation of stable and effective anthrax vaccine. We studied the immune response elicited by recombinant protective antigen (rPA) delivered intranasally with a novel mucosal adjuvant, a mast cell activator compound 48/80 (C48/80). The vaccine formulation was prepared in a powder form by spray-freeze-drying (SFD) under optimized conditions to produce particles with a target size of D(50) = 25 μm, suitable for delivery to the rabbit nasal cavity. Physicochemical properties of the powder vaccines were characterized to assess their delivery and storage potential. Structural stability of rPA was confirmed by circular dichroism and attenuated total reflectance-Fourier transform infrared spectroscopy, whereas functional stability of rPA and C48/80 was monitored by cell-based assays. Animal study was performed using a unit-dose powder device for direct nasal application. Results showed that C48/80 provided effective mucosal adjuvant activity in rabbits. Freshly prepared SFD powder vaccine formulations or powders stored for over 2 years at room temperature elicited significantly elevated serum PA-specific and lethal toxin neutralization antibody titers that were comparable to that induced by intramuscular immunization with rPA. Nasal delivery of this vaccine formulation may be a viable alternative to the currently licensed vaccine or an attractive vaccine platform for other mucosally transmitted diseases.

Protective immunity in mice achieved with dry powder formulation and alternative delivery of plague F1-V vaccine

The potential use of Yersinia pestis as a bioterror agent is a great concern. Development of a stable powder vaccine against Y. pestis and administration of the vaccine by minimally invasive methods could provide an alternative to the traditional liquid formulation and intramuscular injection. We evaluated a spray-freeze-dried powder vaccine containing a recombinant F1-V fusion protein of Y. pestis for vaccination against plaque in a mouse model. Mice were immunized with reconstituted spray-freeze-dried F1-V powder via intramuscular injection, microneedle-based intradermal delivery, or noninvasive intranasal administration. By intramuscular injection, the reconstituted powder induced serum antibody responses and provided protection against lethal subcutaneous challenge with 1,000 50% lethal doses of Y. pestis at levels equivalent to those elicited by unprocessed liquid formulations (70 to 90% protection). The feasibility of intradermal and intranasal delivery of reconstituted powder F1-V vaccine was also demonstrated. Overall, microneedle-based intradermal delivery was shown to be similar in efficacy to intramuscular injection, while intranasal administration required an extra dose of vaccine to achieve similar protection. In addition, the results suggest that seroconversion against F1 may be a better predictor of protection against Y. pestis challenge than seroconversion against either F1-V or V. In summary, we demonstrate the preclinical feasibility of using a reconstituted powder F1-V formulation and microneedle-based intradermal delivery to provide protective immunity against plague in a mouse model. Intranasal delivery, while feasible, was less effective than injection in this study. The potential use of these alternative delivery methods and a powder vaccine formulation may result in substantial health and economic benefits.

Novel dry powder preparations of whole inactivated influenza virus for nasal vaccination

The purpose of these studies was to enhance mucosal and systemic antibody production in response to increased local residence time of a whole inactivated influenza virus administered as a dry powder nasal vaccine formulation. Spray-freeze-drying (SFD) particles suitable for nasal delivery were characterized for physico-chemical properties and stability. Mucoadhesive compounds (MA) were characterized for their effects on nasal residence time of vaccine powders in rats compared with published in vitro data and elicited immune responses. SFD particles (D(50) = 26.9 microm) were spherical with a specific surface area of 1.25 m(2)/g. Thermal analysis indicated SFD powders were amorphous and demonstrated improved stability with respect to liquid formulations under various storage conditions. In vitro physico-chemical studies and in vivo scintigraphic imaging experiments indicated sodium alginate (SA) and carboxymethylcellulose-high molecular weight (CMC-HMW) powder formulations most significantly increased residence time in Brown Norway rats. Intramuscular delivery provided equivalent serum antibody titers to intranasal (IN) powder without MA, in the presence of CMC-HMW, SA, and hydroxypropyl methylcellulose (HPMC-HMW) after initial dosing and all formulations except IN powder with chitosan after boosting. IN liquid provided equivalent serum antibody titers to all IN powders after the initial vaccination and significantly greater serum antibody titers than IN powder with chitosan after boosting. Trends were consistent between residence time studies and immune response; however, no statistically significant differences between powder and liquid formulations were observed. It was concluded that enhanced serum and mucosal antibody responses were elicited by a dry powder nasal vaccine, specifically, administered in the presence of sodium alginate.

A novel dry powder influenza vaccine and intranasal delivery technology: induction of systemic and mucosal immune responses in rats

Intranasal (i.n.) vaccination represents an attractive non-invasive alternative to needle-based injection and provides superior protection at mucosal surfaces. However, new formulations are needed to improve efficacy and reduce the refrigerated storage and distribution requirements associated with standard liquid vaccines. Here, we describe a powder formulation of whole inactivated influenza virus and a novel i.n. delivery platform. The powder-formulated vaccine elicited a significant serum antibody response in rats that was at least as strong as that provided by the liquid vaccine administered i.n. or via intramuscular (i.m.) injection. Significant nasal IgA responses were also observed solely after i.n. delivery. This study demonstrates for the first time the generation of potent nasal mucosal and systemic immune responses using an i.n. delivered influenza vaccine powder and suggests an alternative approach to vaccination against influenza and other infectious diseases.

Oral immunization of cattle with hemagglutinin protein of rinderpest virus expressed in transgenic peanut induces specific immune responses

Rinderpest is an acute, highly contagious often fatal disease of large and small ruminants, both domestic and wild. Global eradication of rinderpest needs a robust, safe and cost-effective vaccine. The causative agent, rinderpest virus (RPV) is an important member of the genus Morbillivirus in the Paramyxoviridae family. We have generated transgenic peanut (Arachis hypogea L.) plants expressing hemagglutinin protein of RPV and report here, the induction of immune responses in cattle following oral feeding with transgenic leaves expressing hemagglutinin protein without oral adjuvant. Hemagglutinin-specific antibody was detected in the serum as confirmed by immunohistochemical staining of virus-infected cells, and in vitro neutralization of virus infectivity. Oral delivery also resulted in cell-mediated immune responses.