Selective retension of active cells employing low centrifugal force at the medium change during suspension culture of Chinese hamster ovary cells producing tPA

Separation of CHO cells using hydrocyclones

Hydrocyclones are simple and robust separation devices with no moving parts. In the past few years, their use in animal cell separation has been proposed. In this work, the use of different hydrocyclone configurations for Chinese hamster ovary (CHO) cell separation was investigated following an experimental design. It was shown that cell separation efficiencies for cultures of the wild-type CHO.K1 cell line and of a recombinant CHO cell line producing granulocyte-macrophage colony stimulating factor (GM-CSF) were kept above 97%. Low viability losses were observed, as measured by trypan blue exclusion and by determination of intracellular lactate dehydrogenase (LDH) released to the culture medium. Mathematical models were proposed to predict the flow rate, flow ratio and separation efficiency as a function of hydrocyclone geometry and pressure drop. When cells were monitored for any induction of apoptosis upon passage through the hydrocyclones, no increase in apoptotic cell concentration was observed within 48 h of hydrocycloning. Thus, based on the high separation efficiencies, the robustness of the equipment, and the absence of apoptosis induction, hydrocyclones seem to be specially suited for use as cell retention devices in long-term perfusion runs.

Gene amplification and its application in cell and tissue engineering

Gene amplification means the repeated replication of a certain gene without a proportional increase in the copy number of other genes and is a widespread phenomenon in eukaryotes. It is an important developmental and evolutionary process in many organisms. This article focuses on mammalian gene amplification and its application in cell and tissue engineering. The dhfr gene amplification in Chinese hamster ovary (CHO) cells, the gene amplification mechanism, the selection protocol and the application of gene amplification were reviewed.

Characterization of changes in PER.C6™ cellular metabolism during growth and propagation of a replication-deficient adenovirus vector

PER.C6 cells were cultivated for propagation of a replication-defective adenovirus vector in serum-free suspension bioreactors. Cellular metabolism during cell growth and adenovirus propagation was fully characterized using on-line and off-line methods. The energy metabolism was found to accelerate transiently after adenovirus infection with increases in glucose and oxygen consumption rates. Similar to other mammalian cells, glucose utilization was highly inefficient and a high lactate:glucose yield was observed, both before and after virus infection. A higher consumption of most of the essential amino acids was observed transiently after the infection, likely due to increased protein synthesis requirements for virus propagation. To improve virus propagation, a medium exchange strategy was implemented to increase PER.C6 cell concentration for infection. During cell growth, a 50% increase in glucose consumption and lactate production rates was observed after initiation of the medium exchange in comparison to the batch phase. This decrease in medium capacity only affected the central carbon metabolism and no increase in amino acid consumption was observed. In addition, even though cell concentrations of up to 10 x 10(6) cells/mL were reproducibly obtained by medium exchange, infections at cell concentrations higher than 1 x 10(6) cells/mL did not proportionally improve volumetric adenovirus productivities. No measured nutrient limitation was observed at those high cell concentrations, indicating that adenovirus cell-specific productivity at higher cell concentrations is highly dependent on cell physiology. These results provide a better understanding of PER.C6 cellular metabolism and a basis for intensifying PER.C6 growth and adenovirus propagation.

Sampling and monitoring in bioprocessing using microtechniques

In this review we describe aspects of interactions between bioreactors and analytical systems including microsystems. Principles of bioprocess monitoring are summarized, before we focus on the miniaturization of sampling systems guaranteeing bioprocess sterility and providing analytical systems with a liquid sample. The application of negative dielectrophoresis as a new principle for cell retention in a sampling system is described followed by theoretical aspects and results. Properties of micromachined silicon membranes as filters for sampling systems and for biosensor protection are discussed.