Effect of rearing system (mountain pasture vs. indoor) of Simmental cows on milk composition and Montasio cheese characteristics

Organic versus Conventional Raw Cow Milk as Material for Processing

Milk, as one of the basic raw materials of animal origin, must be of adequate hygienic and physicochemical quality for processing. The aim of the article was to compare the quality of raw milk from three production systems, intensive, traditional (together referred to as conventional), and organic, as material for processing, as well as the quality of products made from it. Particular attention was focused on hygienic quality (somatic cell count and total bacterial count), physical characteristics (acidity), basic nutritional value (content of dry matter, total protein, casein, fat, and lactose), content of health-promoting substances (whey proteins, fatty acids, vitamins, and minerals), and technological parameters (rennet clotting time, heat stability, and protein-to-fat ratio). Research assessing the quality of organic milk and dairy products is significantly less extensive (if available at all) than for milk from conventional production (intensive and traditional). The available reports indicate that raw milk from organic farms is more valuable, especially in terms of the content of health-promoting compounds, including vitamins, fatty acids, whey proteins, and minerals. This applies to organic dairy products as well, mainly cheese and yoghurt. This is explained by the fact that organic farming requires that animals are kept in the pasture. However, the hygienic quality of the raw milk, and often the products as well, raises some concerns; for this reason, organic milk producers should be supported in this regard, e.g., through consultancy and training in Good Hygienic Practices. Importantly, milk production in the traditional and organic systems is in line with the concept of the European Green Deal.

Fatty Acids as Biomarkers of the Production Season of Caciocavallo Palermitano Cheese

Simple Summary

In the Mediterranean environment, climatic variability determines a discontinuity in the forage availability of pastures. Caciocavallo Palermitano is a cheese obtained from the milk of the Cinisara cattle breed, mainly raised on pasture. The present study investigated the fatty acid profile of cheeses produced in two typical farms in the four seasons of the year, with the aim of identifying specific fatty acids that can be used as biomarkers to discriminate the productions obtained in the different seasons, in order to economically enhance those seasonal productions that have better health characteristics. The results revealed the possibility of distinguishing spring productions from those of other seasons on the basis of the higher content of some fatty acids deriving from grazing fresh forage, the availability of which is greater in spring. Further studies should be conducted to also evaluate the possibility of using fatty acids as biomarkers of different diets.

Abstract

This experiment aims to evaluate the potential of fatty acids (FA) of Caciocavallo Palermitano cheese as biomarkers of production season and pasture-based diet. A total of 48 cheeses were made in the four seasons with milk from two farms that raised cows of Cinisara breed. The animals were fed on pasture with supplementation of wheat bran and wheat straw in the barn, and in summer also with Opuntia ficus-indica cladodes. The chemical composition and FA profile of cheese were influenced by the season and not by the farm. In particular, cheeses produced in spring were characterized by higher protein and lower fat, and showed higher contents in trans-vaccenic acid, α-linolenic acid, rumenic acid, n-3 polyunsaturated FA (PUFA), and total PUFA. In winter, the lower availability of grazing forage, requiring a higher level of feeding integration, was responsible for an increase of saturated FA (SFA). The multivariate analysis distinguished clearly the cheeses made in winter and spring, while those produced in autumn and summer showed some overlapping points. Further investigations should be carried out to evaluate the effects of type and level of feeding integration on the presence of FA more suitable to be used as biomarkers of period and diet.

High biodiversity in a limited mountain area revealed in the traditional production of Historic Rebel cheese by an integrated microbiota-lipidomic approach

Historic Rebel (HR) cheese is an Italian heritage cheese, produced from raw milk during the summer grazing period in the Alps. The aim of this work was (i) to characterize the cheese microbiota, by 16S rRNA gene amplicons sequencing, and the volatile and non-volatile lipophilic fraction, by Gas Chromatography and Dynamic Headspace Extraction-Gas Chromatography-Mass Spectrometry, and (ii) to evaluate their respective associations. HR cheese was dominated by Firmicutes phylum (99% of the entire abundance). The core microbiota was formed by Streptococcus, Lactobacillus, Lactococcus, Leuconostoc and Pediococcus genera together representing 87.2–99.6% of the total abundance. The polyunsaturated fatty acids composition showed a high PUFA n-3, PUFA n-6 and CLA content, two fold higher than typical plain cheeses, positively correlated with pasture altitude. A complex volatilome was detected, dominated in terms of abundance by ketones, fatty acids and alcohols. Total terpene levels increased at higher altitudes, being the main terpenes compounds α-pinene, camphene and β-pinene. The HR cheese showed a great diversity of bacterial taxa and lipophilic fractions among producers, despite belonging to a small alpine area, revealing a scarce cheese standardization and a chemical fingerprint of a typical mountain cheese produced during the grazing period. A deeper knowledge of the variability of HR cheese due to its composition in microbial community and volatile compounds will be appreciated, in particular, by elite consumers looking for niche products, adding economic value to farming in these alpine areas.

Analyses of the genetic relationships between lactose, somatic cell score, and growth traits in Simmental cattle

Lactose and somatic cell score (SCS) are major economic traits of milk. However, for many countries, they are typically not directly considered in the national genetic evaluation of Simmental cattle. This study aimed to estimate the genetic relationships between lactose, SCS, and growth traits of Simmental cattle to provide information for the national genetic evaluation of the selection of traits of this cattle population. The data of 1781 animals with 6519 records obtained over a period of 41 years (1975-2016) were collected from Xinjiang Hutubi Farm, China. The analyzed traits included 305 days of milk yield (305MY), milk fat percentage (MFP), milk protein percentage (MPP), milk lactose percentage (MLP), total solids (TS), SCS, body height (BH), body length (BL), chest girth (CG), abdominal circumference (AC), rump width (RW), rump length (RL), leg circumference (LC), and cannon circumference (CC). The multiple-trait repeatability model was adopted to estimate (co)variance components using the average information-restricted maximum likelihood method implemented using the DMU statistical package. The heritability estimates for milk components and growth traits ranged from 0.09 (SCS) to 0.51 (BH). Genetic correlations for milk components ranged from 0.03 ± 0.14 (MFP and MLP) to 0.81 ± 0.08 (MFP and MPP). Genetic correlation between MLP and SCS was moderate and negative (-0.50 ± 0.15) compared with that among other traits. Genetic correlations between the milk components and growth traits ranged from 0.00 ± 0.07 (305MY and RW) to -0.64 ± 0.15 (MLP and BL). Genetic correlations of BL, LC, RW, and RL with MLP were moderate to high and negative ranging from -0.39 to -0.64. Somatic cell score showed the highest correlation with BL (0.41) followed by LC (0.21). An increase in MLP would result in an increase in 305MY or TS and a decrease in BL, LC, RW, and RL. Additionally, a decrease in SCS would occur with the selection of increased MLP and reduced BL. We conclude that selection based on easily and inexpensively measured growth traits could improve the milk quality from Simmental cattle.

Changes in Fatty Acid and Volatile Compound Profiles during Storage of Smoked Cheese Made from the Milk of Native Polish Cow Breeds Raised in the Low Beskids

This study investigated changes in the proximate chemical composition and profiles of fatty acids and volatile compounds of 12 smoked cheeses made from the milk of native Polish cow breeds used in Beskid Niski. Analyses were performed during the shelf life i.e., in the 1st, 21st, 42nd and 69th day of storage. Studies have shown that thanks to smoking and vacuum-packing, the chemical composition of cheese remained stable throughout the whole shelf-life. Up until the 21st day of storage, there were no statistically significant changes in the profile of fatty acids as well as volatile compounds. Changes were observed only after the mentioned storage time. After 21 days, there was a significant (p < 0.05) and steady decrease (up to day 69) in the proportion of odd-chain (by about 36%), branched-chain (by about 17%) and unsaturated fatty acids (by slightly over 1%). Among unsaturated fatty acids (p < 0.05), however, there was a significant increase in the proportion of monounsaturated fatty acids (by 5%) and a decrease in polyunsaturated fatty acids of nearly 12%. Storage lowered (by 47% in the 69th day of storage) the content of the conjugated linoleic acids (CLA), as well as lowered the n6 to n3 fatty acids ratio. During the 69 days of storage, the content of carboxylic acids increased to more than 50%. In the period from the 42nd to 69th day of cheese storage, the content of butyric acid and hexanoic acids increased twofold, whereas that of octanoic acid increased more than tenfold. Fifty-four volatile compounds were identified in the cheese. The largest group was ketones (34%), whose level decreased during storage, with 2-butanone, 3-hydroxy- (acetoin) and 2-butanone predominating. The research found that due to their low odor threshold, carboxylic acids may have negatively affected the flavor profile of the cheese.

Effect of Feeding Adaptation of Italian Simmental Cows before Summer Grazing on Animal Behavior and Milk Characteristics

Simple Summary

The traditional transhumant system of rearing dairy cows in mountain areas expects animals to remain indoors in the valley during the cold season, whereas during the summer they are moved to pastures at progressively higher altitudes. The animals transferred from the valley farm to the alpine pasture must adapt to various management changes. This study aimed to evaluate whether a gradual inclusion of fresh grass in the diet of dairy cows in the valley farm can improve the performance and milk characteristics during summer grazing. Three groups of six animals each were considered: one group was kept in the stable, one was transferred from the valley to the summer farm without adaptation, and the other was progressively adapted to grazing with a feeding adaptation period. Compared to animals kept indoors, grazing animals had similar performance and milk characteristics, higher rumination time and, with respect to volatile compounds in milk, higher concentrations of alcohols, aldehydes, hydrocarbons, and ketones but lower concentrations of organic acids, phenolic compounds, and dimethyl sulfone, regardless of the feeding adaptation. In conclusion, the gradual inclusion of fresh grass in the diet in the valley farm did not improve the performance and milk characteristics during summer grazing.

Abstract

According to the alpine transhumance system, dairy cows are moved from indoor feeding with conserved forage to fresh herbage feeding on pasture. The aim of this study was to assess, as a feeding adaptation technique, the effect of a gradual inclusion of fresh herbage in the diet of Italian Simmental dairy cows before their transfer to alpine pasture on performance, behavior, and milk characteristics. Eighteen cows were assigned to three groups: animals transferred to alpine pasture with a 10-d feeding adaptation period consisting in gradual access to a pasture close to the valley farm (GT), animals transferred to alpine pasture without a feeding adaptation period (AT), and animals kept in the valley farm (IND). During the first two weeks of summer grazing, GT and AT showed higher rumination time and different concentrations of ketones, hydrocarbons, organic acids, toluene, alcohols, phenols, and dimethyl sulfone in milk as compared to IND, whereas no differences were found in milk yield, composition, or coagulation properties. No differences between GT and AT were evident for the studied variables. The feeding adaptation technique used in this study did not influence the performance and milk characteristics of Italian Simmental dairy cows grazing on alpine pasture.

Shift in the cow milk microbiota during alpine pasture as analyzed by culture dependent and high-throughput sequencing techniques

In the present study, two groups of cows from a permanent lowland farm (PF) were divided during summer and reared in the PF or in a temporary alpine farm (ALP), respectively. Microbiological analyses were performed with the objective to investigate the microbial evolution of milk before, during, and after summer transhumance comparing, in particular, the two groups of cows to determine whether the alpine pasture could directly influence the milk microbiota. A significant increase of all microbial groups was registered in milk samples collected in the ALP. Interestingly, many strains belonging to species with well reported technological and probiotic activities were isolated from Alpine milk (20% Lactococcus lactis subsp. lactis/cremoris, 18% Lactobacillus paracasei, 14% Bifidobacterium crudilactis and 18% Propionibacterium sp.), whereas only 16% of strains isolated from the permanent farm milk belonged to the species Lactococcus lactis subsp. lactis/cremoris, 6% to Lactobacillus paracasei, 2% to Bifidobacterium crudilactis and 5% to Propionibacterium sp. The MiSeq Illumina data showed that Alpine milk presented a significant reduction of Pseudomonas and an increase of Lactococcus, Bifidobacterium and Lactobacillus genera. These data confirmed the practice of Alpine pasture as one of the main drivers affecting the milk microbiota. All the microbial changes disappeared when cows were delivered back from Alpine pasture to the indoor farm.

Characterisation of Formaggella della Valle di Scalve Cheese Produced From Cows Reared in Valley Floor Stall or in Mountain Pasture: Fatty Acids Profile and Sensory Properties

An important problem in mountain areas is the abandonment of pasture. This trend can be combated by the valorisation of typical dairy products, such as “Formaggella della Valle di Scalve”, a semi-cooked traditional cheese made from whole milk in a mountain area in Italy. The aim of the present research was to compare the fatty acid (FA) profile and the sensory properties of this cheese as manufactured under different conditions: i) from the milk of cows grazing on mountain or valley pasture or fed indoors; ii) from the milk of cows fed hay or fed silage. In the first case, five cheesemaking trials were conducted during two years for each of the following situations: mountain pasture (A); pasture at the bottom of the valley (P) (about 1000m asl); stall (S). In the second case, three cheesemaking trials were conducted for each of the following situations: cows fed silage (I); cows fed hay (F). S cheese was richer in medium-chain FAs, while long-chain FAs were higher in P and A cheeses. On the other hand, long chain fatty acids (LCFA) were more abundant in P and A cheeses than in S. In general, MUFA, PUFA and, consequently, total unsaturated FA (UFA), were significantly higher in the P and A cheeses than S (UFA: 36.55 and 38.34, respectively, vs. 31.13; p < 0.001), while SFA showed higher values in S (68.85 vs. 63.41 and 61.68 in P and A, respectively; p < 0.001). Conjugated linoleic acid isomers (CLA) were more represented in the P and A samples (1.86 in P and 1.52 in A, vs. 0.80 in S; p < 0.001); Omega 3 fatty acids, and in particular α-linolenic acid, were more abundant in P than in S cheese. In winter, the I sample (silage) presented higher percentages of myristic (C14), myristoleic (C14:1) and omega 6 acids, whereas F cheese (hay) contained higher concentrations of CLA. The triangular test of sensory analysis showed that, in general, F cheeses were judged as “sweeter” than I, with aromatic profiles characterized by higher content of 2- butanol and ethyl capronate.

1H NMR Metabolic Profile to Discriminate Pasture Based Alpine Asiago PDO Cheeses

Simple Summary

Nowadays, alpine cheese from grazing dairy herds has a premium market value because consumers perceive its higher degree of healthiness and sustainability. The authenticity of pasture-based cheese should be safeguarded from local hay-based milk analogues. The study aimed at assessing the reliability of proton nuclear magnetic resonance (¹H NMR) to discriminate pasture-based alpine Asiago PDO cheeses of different ripening time from similar hay-based samples processed in the same dairy plant. Cheeses were produced from raw milk collected from grazing or hay-fed alpine dairy herds and they were ripened for 2 (Pressato), 4 (Allevo_4), and 6 (Allevo_6) months. Samples of the cheeses were submitted to wet chemistry and nuclear magnetic resonance analysis. The outcomes of the ¹H NMR spectroscopy were used in a multivariate discriminant procedure. Choline, 2,3-butanediol, lysine, and tyrosine and some residual sugar-like compounds were water-soluble biomarkers of cows’ feeding system. However, the application of ¹H NMR based metabolomics was an effective fingerprinting method to correctly identify only cheese samples with the shortest ripening period. The classification of more aged cheese samples according to the cows’ feeding system was less accurate likely due to the chemical and biochemical changes induced by a prolonged maturation process.

Abstract

The study was carried out in an alpine area of North-Eastern Italy to assess the reliability of proton nuclear magnetic resonance ¹H NMR to fingerprint and discriminate Asiago PDO cheeses processed in the same dairy plant from upland pasture-based milk or from upland hay-based milk. Six experimental types of Asiago cheese were made from raw milk considering 2 cows’ feeding systems (pasture- vs. hay-based milk) and 3 ripening times (2 months, Pressato vs. 4 months, Allevo_4 vs. 6 months, Allevo_6). Samples (n = 55) were submitted to chemical analysis and to ¹H NMR coupled with multivariate canonical discriminant analysis. Choline, 2,3-butanediol, lysine, tyrosine, and some signals of sugar-like compounds were suggested as the main water-soluble metabolites useful to discriminate cheese according to cows’ feeding system. A wider pool of polar biomarkers explained the variation due to ripening time. The validation procedure based on a predictive set suggested that ¹H NMR based metabolomics was an effective fingerprinting tool to identify pasture-based cheese samples with the shortest ripening period (Pressato). The classification to the actual feeding system of more aged cheese samples was less accurate likely due to their chemical and biochemical changes induced by a prolonged maturation process.

Effects of Summer Transhumance of Dairy Cows to Alpine Pastures on Body Condition, Milk Yield and Composition, and Cheese Making Efficiency

Simple Summary

Summer transhumance of dairy cows is a seasonal pastoral system practiced in many European countries from ancient times. This practice provides additional forage supply for mountain dairy farms and plays a role in the preservation of landscape, biodiversity, and natural habitats and conservation of local traditional dairy products, but it may affect cows’ physiological and nutritional status. This study aimed to investigate the effects of transhumance of Brown Swiss cows to summer pastures on the yield, composition, and coagulation properties of milk, and on cheese yield. For this study, twelve multiparous cows from a mountain lowland permanent farm were divided into two groups of six cows: One group stayed at the permanent farm while the other moved to the alpine pasture (1860 m above sea level). Cows at the alpine pasture had reduced milk yield and body condition, and greater fat and lower protein contents in milk compared to cows at the permanent farm. Conversely, neither milk coagulation properties nor cheese yield were affected by summer transhumance. In conclusion, summer transhumance did not affect the cheese making efficiency of milk compared to permanent farm, but the negative effect on milk yield depressed daily cheese yield, which was 2 kg/d lower in cows moved to Alpine pasture.

Abstract

Summer transhumance to alpine pastures (ALP) is widespread in dairy systems of alpine regions. This study aimed to investigate the effects of transhumance of Brown Swiss cows to ALP on the yield, composition, and coagulation properties of milk (MCP), and on cheese yield (CY). The study involved 12 multiparous cows kept at a mountain lowland permanent farm (PF), which were divided into two equal groups: One remained at the PF, the other was moved to the ALP (1860 m above sea level) from July to September. Every month (June to October), daily milk yield (MY) and body condition score (BCS) were recorded, and individual milk samples (n = 60, 2000 mL each) were collected to assess milk composition, MCP, and CY. Compared with PF, ALP cows had a reduced MY and BCS, which was maintained on return to the PF, greater fat and lower protein contents of milk. Neither MCP nor CY were affected by summer transhumance. In conclusion, summer transhumance did not affect the cheese making efficiency of milk but depressed MY and consequently daily cheese yield, which was nearly 2 kg/d lower for the ALP than the PF cows and was only partially recovered after returning to the PF in autumn.

Fatty Acid Profiles of Cow's Milk and Cheese as Affected by Mountain Pasture Type and Concentrate Supplementation

The aim of this trial was to assess the effect of pasture type and concentrate supplementation on the fatty acids (FA) composition of milk and cheese obtained during summer grazing on mountain pasture. Seventy-two Italian Simmental dairy cows were assigned to two groups that differed by the amount of concentrate supplementation: 3.0 kg/head/d (HIGH) vs. 1.5 kg/head/d (LOW). The dairy cows grazed on a Poion alpinae alliance pasture (PAST1), and subsequently they grazed on a Seslerion caeruleae alliance pasture (PAST2) for 10 d each. In the last three days of each experimental period, milk samples were collected immediately before each cheese-making event. Cheese samples were collected from each cheese loaf after 60 d of ripening. LOW showed higher isoFA, FA intermediates of the ruminal biohydrogenation, C18:3 c9,c12,c15, and total polyunsaturated fatty acid (PUFA) levels than HIGH. The pasture type had a more limited effect on FA composition of milk than concentrate level and was mainly related to monounsaturated fatty acids (MUFA), which were higher in PAST1 than PAST2 (p < 0.05). In cheeses, these differences were reduced. The phytanic acid and phytanic isomer ratio (SRR/RRR) in milk were not affected either by supplement level (p > 0.05) or by type of pasture (p > 0.05). Increasing the concentrate offered to dairy cows from 1.5 to 3.0 kg/d did not markedly influence the level of PUFA in cheeses produced during summer grazing on high mountain pasture.

The effects of a synthetic analogue of the Bovine Appeasing Pheromone on milk yield and composition in Valdostana dairy cows during the move from winter housing to confined lowland pastures

This Research Communication describes the effects of a synthetic analogue of the Bovine Appeasing Pheromone (BAP) on milk parameters in Valdostana dairy cows during the first turning out from tie-stalls to confined lowland pastures around the farms. Thirty healthy lactating Valdostana cows were enroled in the study and randomly divided into 2 groups: experimental group (EG, n = 15) and control group (CG, n = 15). The two groups were separately housed in the same farm and managed outside in two different pens. Treatment (BAP and solution) and control (solution only) were poured on the nuchal skin area between the horns when the animals were inside the farm at the feeding rack every 7 d for 28 d (T0-T4). Milk samples were evaluated at the same time points (T0-T4). Daily milk production (kg/day) was higher in the EG than in the CG, particularly during the first day after the turning out to pasture (T1). Somatic Cell Count (103 cells/ml) was higher in the placebo group than in the EG, especially at T1. Proteins, fat, fat-free dry matter and casein (g/100 g) were not affected by the treatment. In T1 urea (mg/dl) content was higher in CG vs. EG, suggesting a more correct metabolic balance in the group treated with BAP. The use of BAP appears to modulate adaptation in ways that may improve dairy cow performance in the context of changes in management routines.

Concentrate Supplement Modifies the Feeding Behavior of Simmental Cows Grazing in Two High Mountain Pastures

Simple Summary

Traditional Alpine husbandry systems require dairy cows to be grazing on mountain pasture during summer and kept indoors during the remaining part of the year. Nowadays, the pasture is not able to fully satisfy the nutritional requirements of cattle; therefore, the use of concentrates is frequently required. From their use, some issues arise: the cows tend to consume the concentrates at the expense of the grass; concentrates are competitive with human diets; concentrates decrease the environmental sustainability of farm. Therefore, in order to minimize their use, it is imperative to obtain data on the grazing behavior of cows. The aim of this study was to assess the effect of concentrate levels on the behavior of dairy cows during summer grazing in two pastures characterized by Poion alpinae and Seslerion caeruleae alliance. Cows were equipped with an electronic device to evaluate feeding behavior (grazing, rumination, and walking). In addition, the plant selection by animals was assessed. In Poion alpinae, a rich pasture, the increased supplement influenced the selectivity of the pasture species, while in Seslerion caeruleae, a poor pasture, supplementation resulted in a reduction in grazing times. The study highlights how the supplement level induced a different grazing behavior depending on pasture type.

Abstract

During grazing on Alpine pastures, the use of concentrates in dairy cows’ diet leads to a reduction of the environmental sustainability of farms, and influences the selective pressure on some plant species. In order to minimize the use of concentrates, it is imperative to obtain data on the grazing behavior of cows. The aim of this study was to assess the effect of concentrate levels on the behavior of dairy cows during grazing. One hundred and ten lactating Italian Simmental cows, that sequentially grazed two pastures characterized by Poion alpinae (Poion) and Seslerion caeruleae (Seslerion) alliance, were considered. For each pasture, eight cows were selected and assigned to two groups: High and Low, supplemented with 4 kg/head/d, and 1 kg/head/d of concentrate respectively. Cows were equipped with a noseband pressure sensor and a pedometer (RumiWatch system, ITIN-HOCH GmbH) to assess grazing, ruminating, and walking behavior. In addition, the plant selection of the animals was assessed. On Poion, increased supplement intake caused a more intense selection of legumes, without affecting feeding and walking times. On Seslerion, grazing time was higher in Low than High. Grazing management in alpine region must take into account the great variability of pastures that largely differ from a floristic and nutritional point of view.

Factors Influencing the Flavour of Bovine Milk and Cheese from Grass Based versus Non-Grass Based Milk Production Systems

There has been a surge in interest in relation to differentiating dairy products derived from pasture versus confined systems. The impact of different forage types on the sensory properties of milk and cheese is complex due to the wide range of on farm and production factors that are potentially involved. The main effect of pasture diet on the sensory properties of bovine milk and cheese is increased yellow intensity correlated to β-carotene content, which is a possible biomarker for pasture derived dairy products. Pasture grazing also influences fat and fatty acid content which has been implicated with texture perception changes in milk and cheese and increased omega-3 fatty acids. Changes in polyunsaturated fatty acids in milk and cheese due to pasture diets has been suggested may increase susceptibility to lipid oxidation but does not seem to be an issue to due increased antioxidants and the reducing environment of cheese. It appears that pasture derived milk and cheese are easier to discern by trained panellists and consumers than milk derived from conserved or concentrate diets. However, milk pasteurization, inclusion of concentrate in pasture diets, cheese ripening time, have all been linked to reducing pasture dietary effects on sensory perception. Sensory evaluation studies of milk and cheese have, in general, found that untrained assessors who best represent consumers appear less able to discriminate sensory differences than trained assessors and that differences in visual and textural attributes are more likely to be realized than flavour attributes. This suggests that sensory differences due to diet are often subtle. Evidence supports the direct transfer of some volatiles via inhalation or ingestion but more so with indirect transfer post rumen metabolism dietary components. The impact of dietary volatiles on sensory perception of milk and dairy products obviously depends upon their concentration and odour activity, however very little quantitative studies have been carried out to date. Some studies have highlighted potential correlation of pasture with enhanced “barny” or “cowy” sensory attributes and subsequently linked these to accumulation of p-cresol from the metabolism of β-carotene and aromatic amino acids or possibly isoflavones in the rumen. p-Cresol has also been suggested as a potential biomarker for pasture derived dairy products. Other studies have linked terpenes to specific sensory properties in milk and cheese but this only appears to be relevant in milk and cheese derived from unseeded wild pasture where high concentrations accumulate, as their odour threshold is quite high. Toluene also a product of β-carotene metabolism has been identified as a potential biomarker for pasture derived dairy products but it has little impact on sensory perception due to its high odour threshold. Dimethyl sulfone has been linked to pasture diets and could influence sensory perception as its odour threshold is low. Other studies have linked the presence of maize and legumes (clover) in silage with adverse sensory impacts in milk and cheese. Considerably more research is required to define key dietary related impacts on the flavour of milk and cheese.

Detailed fatty acid profile of milk, cheese, ricotta and by products, from cows grazing summer highland pastures

In this research two-dimensional GC was used to analyse, for the first time, the detailed fatty acid (FA) profiles of 11 dairy matrices: raw milk (evening whole, evening partially skimmed, morning whole, and vat milk), cream, fresh cheese, whey, ricotta, scotta, 6- and 12-month-ripened cheeses, obtained across artisanal cheese- and ricotta-making trials carried out during the summer period while cows were on highland pastures. Samples were collected during 7 cheese- and ricotta-making procedures carried out at 2-week intervals from bulk milk to study possible differences in the transfer and modification of FA. Compared with morning milk, evening milk had fewer de novo synthetised FA. The detailed FA profile of partially skimmed milk differed little from that of evening whole milk before skimming, but the cream obtained differed from partially skimmed milk and from fresh cheese in about half the FA, due mainly to higher contents of all de novo FA, and lower contents of n-3 and n-6 FA. Fresh cheese and whey had similar FA profiles. The ricotta manufacturing process affected the partition of FA between ricotta and scotta, the FA profile of the latter differing in terms of groups and individual FA from the former, whereas ricotta and fresh cheese had similar composition of FA. In general, there was an increase in medium-chain saturated FA, and a decrease in many polyunsaturated FA during the first 6 months of ripening, but not during the second 6 months. Two-dimensional GC yielded a very detailed and informative FA profile on all the 11 dairy products and by-products analysed.

Effect of pasture versus indoor feeding systems on quality characteristics, nutritional composition, and sensory and volatile properties of full-fat Cheddar cheese

The purpose of this study was to investigate the effects of pasture-based versus indoor total mixed ration (TMR) feeding systems on the chemical composition, quality characteristics, and sensory properties of full-fat Cheddar cheeses. Fifty-four multiparous and primiparous Friesian cows were divided into 3 groups (n = 18) for an entire lactation. Group 1 was housed indoors and fed a TMR diet of grass silage, maize silage, and concentrates; group 2 was maintained outdoors on perennial ryegrass only pasture (GRS); and group 3 was maintained outdoors on perennial ryegrass/white clover pasture (CLV). Full-fat Cheddar cheeses were manufactured in triplicate at pilot scale from each feeding system in September 2015 and were examined over a 270-d ripening period at 8°C. Pasture-derived feeding systems were shown to produce Cheddar cheeses yellower in color than that of TMR, which was positively correlated with increased cheese β-carotene content. Feeding system had a significant effect on the fatty acid composition of the cheeses. The nutritional composition of Cheddar cheese was improved through pasture-based feeding systems, with significantly lower thrombogenicity index scores and a greater than 2-fold increase in the concentration of vaccenic acid and the bioactive conjugated linoleic acid C18:2 cis-9,trans-11, whereas TMR-derived cheeses had significantly higher palmitic acid content. Fatty acid profiling of cheeses coupled with multivariate analysis showed clear separation of Cheddar cheeses derived from pasture-based diets (GRS or CLV) from that of a TMR system. Such alterations in the fatty acid profile resulted in pasture-derived cheeses having reduced hardness scores at room temperature. Feeding system and ripening time had a significant effect on the volatile profile of the Cheddar cheeses. Pasture-derived Cheddar cheeses had significantly higher concentrations of the hydrocarbon toluene, whereas TMR-derived cheese had significantly higher concentration of 2,3-butanediol. Ripening period resulted in significant alterations to cheese volatile profiles, with increases in acid-, alcohol-, aldehyde-, ester-, and terpene-based volatile compounds. This study has demonstrated the benefits of pasture-derived feeding systems for production of Cheddar cheeses with enhanced nutritional and rheological quality compared with a TMR feeding system.

From cow to cheese: genetic parameters of the flavour fingerprint of cheese investigated by direct-injection mass spectrometry (PTR-ToF-MS)

BACKGROUND

Volatile organic compounds determine important quality traits in cheese. The aim of this work was to infer genetic parameters of the profile of volatile compounds in cheese as revealed by direct-injection mass spectrometry of the headspace gas from model cheeses that were produced from milk samples from individual cows.

METHODS

A total of 1075 model cheeses were produced using raw whole-milk samples that were collected from individual Brown Swiss cows. Single spectrometry peaks and a combination of these peaks obtained by principal component analysis (PCA) were analysed. Using a Bayesian approach, we estimated genetic parameters for 240 individual spectrometry peaks and for the first ten principal components (PC) extracted from them.

RESULTS

Our results show that there is some genetic variability in the volatile compound fingerprint of these model cheeses. Most peaks were characterized by a substantial heritability and for about one quarter of the peaks, heritability (up to 21.6%) was higher than that of the best PC. Intra-herd heritability of the PC ranged from 3.6 to 10.2% and was similar to heritabilities estimated for milk fat, specific fatty acids, somatic cell count and some coagulation parameters in the same population. We also calculated phenotypic correlations between PC (around zero as expected), the corresponding genetic correlations (from -0.79 to 0.86) and correlations between herds and sampling-processing dates (from -0.88 to 0.66), which confirmed that there is a relationship between cheese flavour and the dairy system in which cows are reared.

CONCLUSIONS

This work reveals the existence of a link between the cow's genetic background and the profile of volatile compounds in cheese. Analysis of the relationships between the volatile organic compound (VOC) content and the sensory characteristics of cheese as perceived by the consumer, and of the genetic basis of these relationships could generate new knowledge that would open up the possibility of controlling and improving the sensory properties of cheese through genetic selection of cows. More detailed investigations are necessary to connect VOC with the sensory properties of cheese and gain a better understanding of the significance of these new phenotypes.

Cheesemaking in highland pastures: Milk technological properties, cream, cheese and ricotta yields, milk nutrients recovery, and products composition

Summer transhumance of dairy cows to high Alpine pastures is still practiced in many mountainous areas. It is important for many permanent dairy farms because the use of highland pastures increases milk production and high-priced typical local dairy products often boost farm income. As traditional cheese- and ricotta-making procedures in Alpine pastures are central to this dairy system, the objective of this study was to characterize the quality and efficiency of products and their relationships with the quality and availability of grass during the grazing season. The milk from 148 cows from 12 permanent farms reared on a temporary farm located in Alpine pastures was processed every 2wk during the summer (7 cheesemakings from late June to early September). During each processing, 11 dairy products (4 types of milk, 2 by-products, 3 fresh products, and 2 ripened cheeses) were sampled and analyzed. In addition, 8 samples of fresh forage from the pasture used by the cows were collected and analyzed. At the beginning of the pasture season the cows were at 233±90d in milk, 2.4±1.7 parities, and produced 23.6±5.7kg/d of milk. The milk yield decreased with the move from permanent to temporary farms and during the entire summer transhumance, but partly recovered after the cows returned to the permanent farms. Similar trends were observed for the daily yields of fat, protein, casein, lactose, and energy, as we found no large variations in the quality of the milk, with the exception of the first period of Alpine pasture. The somatic cell counts of milk increased during transhumance, but this resulted from a concentration of cells in a lower quantity of milk rather than an increase in the total number of cells ejected daily from the udder. We noted a quadratic trend in availability of forage (fresh and dry matter weight per hectare), with a maximum in late July. The quality of forage also varied during the summer with a worsening of chemical composition. The evening milk (before and after natural creaming), the whole morning milk, and the mixed vat milk had different chemical compositions, traditional coagulation properties, and curd-firming modeling parameters. These variations over the pasture season were similar to the residual variations with respect to chemical composition, and much lower with respect to coagulation and curd-firming traits. Much larger variations were noted in cream, cheese, and ricotta yields, as well as in nutrient recoveries in curd during the pasture season. The protein content of forage was correlated with some of the coagulation and curd-firming traits, the ether extract of forage was positively correlated with milk fat content and cheese yields, and fiber fractions of forage were unfavorably correlated with some of the chemical and technological traits. Traditional cheese- and ricotta-making procedures showed average cream, cheese, and ricotta yields of 6.3, 14.2, and 4.9%, respectively, and an overall recovery of almost 100% of milk fat, 88% of milk protein, and 60% of total milk solids.

Effects of grazing cow diet on volatile compounds as well as physicochemical and sensory characteristics of 12-month-ripened Montasio cheese

The aim of this study was to evaluate the effects of pasture type and cow feeding supplementation level on a 12-mo-ripened Montasio protected designation of origin (PDO) cheese, which is one of the most important PDO cheeses produced in northeast Italy. Cheeses were characterized for volatile compounds, color, mechanical variables, and sensory descriptors. Pasture type significantly affected most of the instrumental variables considered and, as a consequence, sensory properties were affected as well. Cheeses from the pasture characterized by a nutrient-rich vegetation type were higher in protein and lower in fat content. Furthermore, such cheeses, evaluated by a sensory panel, were more intense in color with a more pungent and less cow-like odor, in agreement with what found through instrumental analyses. Supplementation level resulted in less pronounced effects, limited to volatile compounds and texture properties, which were not detected by sensory analysis. The characterization of the 12-mo ripened Montasio cheese reported here is an important step for the valorization of this PDO product.

Proton transfer reaction time-of-flight mass spectrometry: A high-throughput and innovative method to study the influence of dairy system and cow characteristics on the volatile compound fingerprint of cheeses

The aim of this work was to study the effect of dairy system and individual cow-related factors on the volatile fingerprint of a large number of individual model cheeses analyzed by proton transfer reaction time-of-flight mass spectrometry (PTR-ToF-MS). A total of 1,075 model cheeses were produced using milk samples collected from individual Brown Swiss cows reared in 72 herds located in mountainous areas of Trento province (Italy). The herds belonged to 5 main dairy systems ranging from traditional to modern and the cows presented different daily milk yields (24.6±7.9kg × d(-1)), stages of lactation (199±138 d in milk), and parities (2.7±1.8). The PTR-ToF-MS revealed 619 peaks, of which the 240 most intense were analyzed, and 61 of these were tentatively attributed to relevant volatile organic compounds on the basis of their fragmentation patterns and data from the literature. Principal component analysis was used to convert the multiple responses characterizing the PTR-ToF-MS spectra into 5 synthetic variables representing 62% of the total information. These principal components were related to groups of volatile compounds tentatively attributed to different peaks and used to investigate the relationship of the volatile compound profile obtained by PTR-ToF-MS to animal and farm characteristics. Lactation stage is related to 4 principal components which brought together 52.9% of the total variance and 57.9% of the area of analyzed peaks. In particular, 2 principal components were positively related to peaks tentatively attributed to aldehydes and ketones and negatively related to alcohols, esters, and acids, which displayed a linear increase during lactation. The second principal component was affected by dairy system; it was higher in the modern system in which cows received total mixed rations. The third principal component was positively related to daily milk production. In summary, we report the first application of this innovative, high-throughput technique to study the effects of dairy system and individual animal factors on volatile organic compounds of model cheeses. Individual cheesemaking procedures together with this spectrometric technique open new avenues for genetic selection of dairy species with respect to both milk and cheese quality.

Montasio cheese liking as affected by information about cows breed and rearing system

European consumers are more and more aware of the credence attributes of foods, particularly of those of animal origin. The aim of the paper was to assess whether the information about production system may modify the consumer liking of cheese. Montasio PDO cheese (MC), usually made by milk from indoor reared cows of different breeds, was processed from pure milk of Italian Simmental (IS) cows (ISMC) or of IS cows grazing on mountain pasture (ALP-ISMC). A consumer test was carried out in two sessions on 60-d ripened cheeses. In the first, both cheeses were tasted by Montasio consumers in blind condition (Perceived liking, PL). Then the respondents were asked to read information about the breed and the rearing system and to give their Expected liking (EL). Two weeks after, in the second session, the same consumers tasted the two cheeses with the linked information (Actual liking, AL). Despite the similar PL average score (ISMC: 21±2·3 vs. ALP-ISMC: 23±2·2 points on Labelled Affective Magnitude scale, P>0·05), it was possible to identifying consumers’ clusters with differential liking for the two types of Montasio PDO, that were characterised by different physico-chemical properties. Consumers express a high EL for ISMC (38±2·6 points) and even more for ALP-ISMC (61±2·5 points). The AL of ISMC (35±2·1 points) was similar and statistically not different from the EL (complete assimilation of information about breed). For ALP-ISMC the assimilation was complete for consumers (29%) who have expressed a positive PL for it, at least twice as much than ISMC. For the rest of consumers, both information and intrinsic properties play a significant role in the AL of the pasture-derived cheese.

Volatile compounds and sensory properties of Montasio cheese made from the milk of Simmental cows grazing on alpine pastures

The aim of this study was to analyze the volatile compounds, physicochemical characteristics, and sensory properties of Montasio, a semicooked pressed cheese, produced from the milk of the dual-purpose Italian Simmental cows grazing on alpine pastures. A total of 72 cows grazing on 2 pastures, which differed in botanical composition (nutrient-rich pasture vs. nutrient-poor pasture), received 2 different levels of supplementation (3.0 vs 1.5 kg/head per day). The experimental cheeses were produced from whole, raw milk and ripened for 60 d. Sixty-one volatile compounds, including alcohols (11), aldehydes (6), ketones (10), lactones (2), esters (6), hydrocarbons (3), carboxylic acids (6), phenolic compounds (4), monoterpenes (7), sesquiterpenes (1), sulfur compounds (4), and amines (1), were detected. The main families in terms of relative weight appeared to be carboxylic acids, esters, and alcohols. A panel of trained assessors described the experimental cheeses as having an intense color; small and evenly distributed eyes; an intense odor and flavor of milk-sour, milk, and cow; and a tender and creamy texture. The pasture type affected the volatile fraction, particularly ketones, phenolic compounds, and terpenes, which are overall higher in nutrient-poor pastures. A slight effect on the sensory analyses, in particular the effect of the cow attribute on odor and flavor, was perceived by the panelists. The cheeses produced on nutrient-rich pasture had higher b* (yellowness) index. These results were consistent with the color evaluation of the sensory panel. In addition, the pasture affected some textural attributes (adhesivity, creaminess, and granules) as perceived by the panelists. Concentrate supplementation, which is required to meet the feeding requirements of grazing cows, had no clear effect on either the volatile compounds or the sensory properties of the cheeses. Thus, at least within levels of integration adopted, it is expected not to alter the organoleptic characteristics of this product.

The future of yogurt: scientific and regulatory needs

Lactation biology, microbial selection, and human diversity are central themes that could guide investment in scientific research, industrial innovation, and regulatory policy oversight to propel yogurt into the central role for health-promoting food products. The ability of yogurt to provide the nourishing properties of milk together with the live microorganisms from fermentation provides a unique combination of food assets. Academic research must now define the various targets on which these biological assets act to improve health and develop the metrics that can quantitatively document their benefits. The food industry must reconcile that yogurt and its microorganisms cannot be expected to provide measurable benefits for all consumers, at all doses, and at all times. A supportive regulatory oversight must demand safety and yet encourage innovations that support a value proposition for yogurt in health. Health valuation in the marketplace will be driven by parallel innovations, including accurate assessment technologies, validated microbial ingredients, and health-aware consumers.