Structure and Thermotropic Behavior of Bovine- and Porcine-Derived Exogenous Lung Surfactants

Protonation of palmitic acid embedded in DPPC lipid bilayers obscures detection of ripple phase by FTIR spectroscopy

The transformation of 1,2-dipalmitoyl-sn-glycero-3-phosphocholine (DPPC) lipid bilayers from the gel (Lβ') to the fluid (Lα) phase involves an intermediate ripple (Pβ') phase forming a few degrees below the main transition temperature (Tm). While the exact cause of bilayer rippling is still debated, the presence of amphiphilic molecules, pH, and lipid bilayer architecture are all known to influence (pre)transition behavior. In particular, fatty acid chains interact with hydrophobic lipid tails, while the carboxylic groups simultaneously participate in proton transfer with interfacial water in the polar lipid region which is controlled by the pH of the surrounding aqueous medium. The molecular-level variations in the DPPC ripple phase in the presence of 2% palmitic acid (PA) were studied at pH levels 4.0, 7.3, and 9.1, where PA is fully protonated, partially protonated, or fully deprotonated. Bilayer thermotropic behavior was investigated by differential scanning calorimetry (DSC) and Fourier-transform infrared (FTIR) spectroscopy which agreed in their characterization of (pre)transition at pH of 9.1, but not at pH 4.0 and especially not at 7.3. Owing to the different insertion depths of protonated and deprotonated PA, along with the ability of protonated PA to undergo flip-flop in the bilayer, these two forms of PA show a different hydration pattern in the interfacial water layer. Finally, these results demonstrated the hitherto undiscovered potential of FTIR spectroscopy in the detection of the events occurring at the surface of lipid bilayers that obscure the low-cooperativity phase transition explored in this work.

Polymyxin B-Enriched Exogenous Lung Surfactant: Thermodynamics and Structure

The use of an exogenous pulmonary surfactant (EPS) to deliver other relevant drugs to the lungs is a promising strategy for combined therapy. We evaluated the interaction of polymyxin B (PxB) with a clinically used EPS, the poractant alfa Curosurf (PSUR). The effect of PxB on the protein-free model system (MS) composed of four phospholipids (diC16:0PC/16:0-18:1PC/16:0-18:2PC/16:0-18:1PG) was examined in parallel to distinguish the specificity of the composition of PSUR. We used several experimental techniques (differential scanning calorimetry, small- and wide-angle X-ray scattering, small-angle neutron scattering, fluorescence spectroscopy, and electrophoretic light scattering) to characterize the binding of PxB to both EPS. Electrostatic interactions PxB-EPS are dominant. The results obtained support the concept of cationic PxB molecules lying on the surface of the PSUR bilayer, strengthening the multilamellar structure of PSUR as derived from SAXS and SANS. A protein-free MS mimics a natural EPS well but was found to be less resistant to penetration of PxB into the lipid bilayer. PxB does not affect the gel-to-fluid phase transition temperature, Tm, of PSUR, while Tm increased by ∼+ 2 °C in MS. The decrease of the thickness of the lipid bilayer (dL) of PSUR upon PxB binding is negligible. The hydrophobic tail of the PxB molecule does not penetrate the bilayer as derived from SANS data analysis and changes in lateral pressure monitored by excimer fluorescence at two depths of the hydrophobic region of the bilayer. Changes in dL of protein-free MS show a biphasic dependence on the adsorbed amount of PxB with a minimum close to the point of electroneutrality of the mixture. Our results do not discourage the concept of a combined treatment with PxB-enriched Curosurf. However, the amount of PxB must be carefully assessed (less than 5 wt % relative to the mass of the surfactant) to avoid inversion of the surface charge of the membrane.

Thermodynamic and Structural Study of Budesonide-Exogenous Lung Surfactant System

The clinical benefits of using exogenous pulmonary surfactant (EPS) as a carrier of budesonide (BUD), a non-halogenated corticosteroid with a broad anti-inflammatory effect, have been established. Using various experimental techniques (differential scanning calorimetry DSC, small- and wide- angle X-ray scattering SAXS/WAXS, small- angle neutron scattering SANS, fluorescence spectroscopy, dynamic light scattering DLS, and zeta potential), we investigated the effect of BUD on the thermodynamics and structure of the clinically used EPS, Curosurf®. We show that BUD facilitates the Curosurf® phase transition from the gel to the fluid state, resulting in a decrease in the temperature of the main phase transition (Tm) and enthalpy (ΔH). The morphology of the Curosurf® dispersion is maintained for BUD < 10 wt% of the Curosurf® mass; BUD slightly increases the repeat distance d of the fluid lamellar phase in multilamellar vesicles (MLVs) resulting from the thickening of the lipid bilayer. The bilayer thickening (~0.23 nm) was derived from SANS data. The presence of ~2 mmol/L of Ca2+ maintains the effect and structure of the MLVs. The changes in the lateral pressure of the Curosurf® bilayer revealed that the intercalated BUD between the acyl chains of the surfactant's lipid molecules resides deeper in the hydrophobic region when its content exceeds ~6 wt%. Our studies support the concept of a combined therapy utilising budesonide-enriched Curosurf®.

Inhalable Gene Therapy and the Lung Surfactant Problem

Lung-targeting RNA-carrying lipid nanoparticles (LNPs) are often intravenously administered and accumulate in the pulmonary endothelium. However, most respiratory diseases are localized in the airway or the alveolar epithelium. Inhalation has been explored as a more direct delivery method, but it presents its own challenges. We believe that one reason LNPs have failed to transfect RNA into alveolar epithelial cells is their interaction with the lung surfactant (LS). We propose that inhalable LNP design should take inspiration from biological agents and other nanoparticles to overcome this barrier. Screening should first focus on LS penetration and then be optimized for cell uptake and endosomal release. This will enable more efficient applications of RNA-LNPs in lung diseases.

Lung surfactant negatively affects the photodynamic inactivation of bacteria-in vitro and molecular dynamic simulation analyses

In the context of the rapid increase of antibiotic-resistant infections, in particular of pneumonia, antimicrobial photodynamic therapy (aPDT), the microbiological application of photodynamic therapy (PDT), comes in as a promising treatment alternative since the induced damage and resultant death are not dependent on a specific biomolecule or cellular pathway. The applicability of aPDT using the photosensitizer indocyanine green with infrared light has been successfully demonstrated for different bacterial agents in vitro, and the combination of pulmonary delivery using nebulization and external light activation has been shown to be feasible. However, there has been little progress in obtaining sufficient in vivo efficacy results. This study reports the lung surfactant as a significant suppressor of aPDT in the lungs. In vitro, the clinical surfactant Survanta® reduced the aPDT effect of indocyanine green, Photodithazine®, bacteriochlorin-trizma, and protoporphyrin IX against Streptococcus pneumoniae. The absorbance and fluorescence spectra, as well as the photobleaching profile, suggested that the decrease in efficacy is not a result of singlet oxygen quenching, while a molecular dynamics simulation showed an affinity for the polar head groups of the surfactant phospholipids that likely impacts uptake of the photosensitizers by the bacteria. Methylene blue is the exception, likely because its high water solubility confers a higher mobility when interacting with the surfactant layer. We propose that the interaction between lung surfactant and photosensitizer must be taken into account when developing pulmonary aPDT protocols.

A recipe for a good clinical pulmonary surfactant

The lives of thousands premature babies have been saved along the last thirty years thanks to the establishment and consolidation of pulmonary surfactant replacement therapies (SRT). It took some time to close the gap between the identification of the biophysical and molecular causes of the high mortality associated with respiratory distress syndrome in very premature babies and the development of a proper therapy. Closing the gap required the elucidation of some key questions defining the structure–function relationships in surfactant as well as the particular role of the different molecular components assembled into the surfactant system. On the other hand, the application of SRT as part of treatments targeting other devastating respiratory pathologies, in babies and adults, is depending on further extensive research still required before enough amounts of good humanized clinical surfactants will be available. This review summarizes our current concepts on the compositional and structural determinants defining pulmonary surfactant activity, the principles behind the development of efficient natural animal-derived or recombinant or synthetic therapeutic surfactants, as well as a the most promising lines of research that are already opening new perspectives in the application of tailored surfactant therapies to treat important yet unresolved respiratory pathologies.

Bilayer aggregate microstructure determines viscoelasticity of lung surfactant suspensions

Neonatal respiratory distress syndrome (NRDS) is treated by intratracheal delivery of suspensions of animal-derived lung surfactant in saline. Lung surfactants are extracted via organic solvents from animal lung lavage, followed by solvent removal and surfactant re-hydration to form multi-bilayer particles suspended in saline. Following intra-tracheal administration, the surfactant suspension spreads throughout the lungs by surface tension gradient induced flow; the spreading rate is limited by suspension viscoelasticity. Here we examine the rheology of three clinical lung surfactant suspensions: Survanta (bovine lung), Curosurf (porcine lung), and Infasurf (calf lung). These surfactants have widely different rheological properties that depend on the lipid composition and bilayer organization. The steady shear viscosity is related to the bilayer particle volume fraction as for a suspension of hard spheres, but the lipid volume fraction is not simply related to the mass loading. Optical and electron microscopy and small angle X-ray scattering show that the viscosity variation is due to the temperature and composition dependent bilayer aggregate shapes and internal particle organization. Survanta forms crystalline bilayers at 37 °C, resulting in high aspect ratio asymmetric particles. Infasurf forms aggregates of unilamellar vesicles containing water pockets, while Curosurf forms onion-like multi-layered liposomes. While the mass loading of the three clinical surfactants is different, the different bilayer organization causes the particle volume fractions to be similar. Adding polyethylene glycol dehydrates and partially flocculates the bilayer aggregates in all suspensions, leading to smaller particle volume fractions and a reduced suspension viscosity even though the solvent viscosity increases almost six-fold.