1
|
Banjar MF, Joynal Abedin FN, Fizal ANS, Muhamad Sarih N, Hossain MS, Osman H, Khalil NA, Ahmad Yahaya AN, Zulkifli M. Synthesis and Characterization of a Novel Nanosized Polyaniline. Polymers (Basel) 2023; 15:4565. [PMID: 38232004 PMCID: PMC10708272 DOI: 10.3390/polym15234565] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/22/2023] [Revised: 11/17/2023] [Accepted: 11/20/2023] [Indexed: 01/19/2024] Open
Abstract
Polyaniline (PANI) is a conductive polymer easily converted into a conducting state. However, its limited mechanical properties have generated interest in fabricating PANI composites with other polymeric materials. In this study, a PANI-prevulcanized latex composite film was synthesized and fabricated in two phases following chronological steps. The first phase determined the following optimum parameters for synthesizing nanosized PANI, which were as follows: an initial molar ratio of 1, a stirring speed of 600 rpm, a synthesis temperature of 25 °C, purification via filtration, and washing using dopant acid, acetone, and distilled water. The use of a nonionic surfactant, Triton X-100, at 0.1% concentration favored PANI formation in a smaller particle size of approximately 600 nm and good dispersibility over seven days of observation compared to the use of anionic sodium dodecyl sulfate. Ultraviolet-visible spectroscopy (UV-Vis) showed that the PANI synthesized using a surfactant was in the emeraldine base form, as the washing process tends to decrease the doping level in the PANI backbone. Our scanning electron microscopy analysis showed that the optimized synthesis parameters produced colloidal PANI with an average particle size of 695 nm. This higher aspect ratio explained the higher conductivity of nanosized PANI compared to micron-sized PANI. Following the chronological steps to determine the optimal parameters produced a nanosized PANI powder. The nanosized PANI had higher conductivity than the micron-sized PANI because of its higher aspect ratio. When PANI is synthesized in smaller particle sizes, it has higher conductivity. Atomic force microscopy analysis showed that the current flow is higher across a 5 µm2 scanned area of nanosized PANI because it has a larger surface area. Thus, more sites for the current to flow through were present on the nanosized PANI particles.
Collapse
Affiliation(s)
- Mohd Faizar Banjar
- Malaysian Institute of Chemical and Bioengineering Technology, Universiti Kuala Lumpur (UniKL), Alor Gajah 78000, Melaka, Malaysia; (M.F.B.); (F.N.J.A.); (N.A.K.)
| | - Fatin Najwa Joynal Abedin
- Malaysian Institute of Chemical and Bioengineering Technology, Universiti Kuala Lumpur (UniKL), Alor Gajah 78000, Melaka, Malaysia; (M.F.B.); (F.N.J.A.); (N.A.K.)
| | - Ahmad Noor Syimir Fizal
- Centre for Sustainability of Ecosystem & Earth Resources (Pusat ALAM), Universiti Malaysia Pahang, Lebuh Persiaran Tun Khalil Yaakob, Gambang 26300, Pahang, Malaysia;
| | | | - Md. Sohrab Hossain
- HICoE-Centre for Biofuel and Biochemical Research, Institute of Self-Sustainable Building, Fundamental and Applied Sciences Department, Universiti Teknologi Petronas (UTP), Seri Iskandar 32610, Perak, Malaysia;
| | - Hakimah Osman
- Faculty of Chemical Engineering & Technology, Universiti Malaysia Perlis, Arau 02600, Perlis, Malaysia;
| | - Nor Afifah Khalil
- Malaysian Institute of Chemical and Bioengineering Technology, Universiti Kuala Lumpur (UniKL), Alor Gajah 78000, Melaka, Malaysia; (M.F.B.); (F.N.J.A.); (N.A.K.)
- Polymer Science Program, Division of Physical Science, Faculty of Science, Prince of Songkla University, Hat-Yai 90110, Songkla, Thailand
| | - Ahmad Naim Ahmad Yahaya
- Green Chemistry and Sustainability Cluster, Branch Campus, Malaysian Institute of Chemical and Bio-Engineering Technology, Universiti Kuala Lumpur (UniKL), Taboh Naning, Alor Gajah 78000, Melaka, Malaysia;
| | - Muzafar Zulkifli
- Green Chemistry and Sustainability Cluster, Branch Campus, Malaysian Institute of Chemical and Bio-Engineering Technology, Universiti Kuala Lumpur (UniKL), Taboh Naning, Alor Gajah 78000, Melaka, Malaysia;
| |
Collapse
|
2
|
Jing Tao, Wang T, Men C, Li G. Effect of Aniline Oligomers in Aniline Chemical Oxidative Polymerization on Polyaniline Supramolecular Structures. POLYMER SCIENCE SERIES B 2022. [DOI: 10.1134/s1560090422700178] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/23/2022]
|
3
|
Moshrefi R, Connors E, Merschrod E, Stockmann TJ. Simultaneous electropolymerization/Au nanoparticle generation at an electrified liquid/liquid micro-interface. Electrochim Acta 2022. [DOI: 10.1016/j.electacta.2022.140749] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/03/2022]
|
4
|
Lin CW, Xue S, Ji C, Huang SC, Tung V, Kaner RB. Conducting Polyaniline for Antifouling Ultrafiltration Membranes: Solutions and Challenges. NANO LETTERS 2021; 21:3699-3707. [PMID: 33886345 DOI: 10.1021/acs.nanolett.1c00968] [Citation(s) in RCA: 15] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/12/2023]
Abstract
Conjugated polyaniline can impact the field of water filtration membranes due to its hydrophilic and antibacterial nature, facile and inexpensive synthesis procedure, heat and acid tolerance, and unique doping/dedoping chemistry. However, the gelation effect, its rigid backbone, and the limited hydrophilicity of polyaniline severely restrict the adaptability to membranes and their antifouling performance. This Mini Review summarizes important works of polyaniline-related ultrafiltration membranes, highlighting solutions to conquer engineering obstacles in processing and challenges in enhancing surface hydrophilicity with an emphasis on chemistry. As a pH-responsive polymer convertible to a conductive salt, this classic material should continue to bring unconventional advances into the realm of water filtration membranes.
Collapse
Affiliation(s)
- Cheng-Wei Lin
- Department of Chemistry and Biochemistry and California NanoSystems Institute, University of California, Los Angeles, California 90095, United States
- Physical Sciences and Engineering Division, Catalysis Center, King Abdullah University of Science and Technology, 23955-6900 Thuwal, Kingdom of Saudi Arabia
| | - Shuangmei Xue
- Institute for Advanced Study, Shenzhen University, Shenzhen 518060, China
| | - Chenhao Ji
- Institute for Advanced Study, Shenzhen University, Shenzhen 518060, China
| | - Shu-Chuan Huang
- Department of Chemistry, National Dong Hwa University, Shoufeng, Hualien 97401, Taiwan
| | - Vincent Tung
- Physical Sciences and Engineering Division, Catalysis Center, King Abdullah University of Science and Technology, 23955-6900 Thuwal, Kingdom of Saudi Arabia
| | - Richard B Kaner
- Department of Chemistry and Biochemistry and California NanoSystems Institute, University of California, Los Angeles, California 90095, United States
- Department of Materials Science and Engineering and California NanoSystems Institute, University of California, Los Angeles, California 90095, United States
| |
Collapse
|