Reduction of Escherichia coli O157:H7 and naturally present microbes on fresh-cut lettuce using lactic acid and aqueous ozone

The Use of Ultraviolet Irradiation to Improve the Efficacy of Acids That Are Generally Recognized as Safe for Disinfecting Fresh Produce in the Ready-to-Eat Stage

Fresh-cut produce is usually produced under standardized disinfection processes, which are unavailable at the ready-to-eat stage. Currently, chemical sanitizers are used for washing, but their disinfection efficacy is limited. In this study, UV-C (1.03 kJ/m2) was combined with organic acids that are generally recognized as safe (GRAS), including citric, malic, acetic, and lactic acids (LAs), to wash lettuce and cherry tomatoes that are contaminated with Escherichia coli O157:H7 and Salmonella Typhimurium. The results showed that LA was the most effective treatment among the single treatments, with a pathogen reduction and cross-contamination incidence of 2.0-2.3 log CFU/g and 28-35%, respectively. After combining with UV-C, the disinfection efficacy and cross-contamination prevention capacity of the four GRAS acids significantly improved. Among the combination treatments, the highest pathogen reduction (2.5-2.7 log CFU/g) and the lowest cross-contamination incidence (11-15%) were achieved by LA-UV. The analyses of ascorbic acid, chlorophyll, lycopene, antioxidant capacity, and ΔE indicated that neither the single nor combination treatments negatively affected the quality properties. These results provide a potential hurdle technology for fresh produce safety improvement at the ready-to-eat stage.

Processing of Fresh-Cut Potato Using Plasma-Activated Water Prepared by Decreasing Discharge Frequency

As a novel non-thermal processing method, the concentration of active compounds in plasma-activated water (PAW) is usually adjusted by changing the voltage and preparation time. We recently adjusted the discharge frequency and found that the PAW properties were improved. In this study, fresh-cut potato was selected as a model, and PAW was prepared using a frequency of 200 Hz (200 Hz-PAW). Its efficacy was compared with that of PAW prepared using 10 kHz. The results showed that the ozone, hydrogen peroxide, nitrate, and nitrite concentrations in 200 Hz-PAW were 5.00-, 3.62-, 8.05-, and 1.48-fold higher than those of 10 kHz-PAW. PAW inactivated the browning-related enzymes polyphenol oxidase and peroxidase, lowering the browning index and inhibiting browning; 200 Hz-PAW exhibited the lowest of these parameters during storage. In addition, PAW induced PAL to promote phenolic synthesis and increase antioxidant activity to delay malondialdehyde accumulation; 200 Hz-PAW exhibited the highest of these parameters. Moreover, 200 Hz-PAW had the lowest weight loss and electrolyte leakage rates. Furthermore, microbial analysis showed that the lowest aerobic mesophilic, mold, and yeast counts during storage were observed in the 200 Hz-PAW group. These results suggest that frequency-controlled PAW has the potential to treat fresh-cut produce.

Effects of Slightly Acidic Electrolyzed Water on the Quality of Fresh-Cut Apple

To investigate the effects of a slightly acidic electrolyzed water (SAEW) treatment on the quality of fresh-cut apples during storage, this research used a Box-Behnken design to determine the optimal SAEW treatment conditions. Then, the fresh-cut apple was treated under the optimal condition and subjected to a 13-d storage experiment at 4 °C. For fresh-cut apple treated under the optimal SAEW treatment conditions, the total number of surface colonies was reduced by 2.82 logarithms compared to the control group and the sensory score was 8.73. For the treated fresh-cut apple during storage, the quality of the treated group was significantly greater than the non-treatment group. Thus, the SAEW treatment not only effectively controlled the number of microbes on fresh-cut apple, but also slowed quality deterioration during storage.

Degradation of malathion and carbosulfan by ozone water and analysis of their by-products

BACKGROUND

Treatment by ozone water is an emerging technology for the degradation of pesticide residues in vegetables. The ozone dissolved in water generates hydroxyl radicals (^· OH), which are highly effective in decomposing organic substances, such as malathion and carbosulfan.

RESULTS

We found that washing pak choi with 2.0 mg L^-1 ozone water for 30 min resulted in 58.3% and 38.2% degradation of the malathion and carbosulfan contents respectively, and the degradation rates of these pure pesticides were 83.0% and 66.3% respectively. In addition, the 'first + first'-order reaction kinetic model was found to predict the trend in the pesticide content during ozone water treatment. Based on investigations by gas chromatography-mass spectrometry combined with the structures of the pesticides, the by-products generated were identified. More specifically, the ozonation-based degradation of carbosulfan generated carbofuran and benzofuranol, whereas malathion produced succinic acid and phosphoric acid. Although some new harmful compounds were formed during degradation of the parent pesticides, these were only present in trace quantities and were transient intermediates that eventually disappeared during the reaction.

CONCLUSION

Our results, therefore, indicate that ozone water treatment technology for pesticide residue degradation is worthy of popularization and application. © 2022 Society of Chemical Industry.

Ozone treatment promotes physicochemical properties and antioxidant capacity of fresh-cut red pitaya based on phenolic metabolism

Pitaya is an important fresh-cut product in the global fruit market. The health benefits of fresh-cut red pitaya fruit are attributed to its unique phenolic content and other antioxidants, but the fruit is highly susceptible to spoilage which causes a decline in nutritional quality. In this study, we monitored changes in quality and phenolic compounds of pitaya fruit treated with gaseous ozone during storage at 8 ± 2^°C for 4 days. Compared with the control group, ozone treatment was an effective strategy for preserving quality by controlling the growth of microorganisms, preventing weight loss and softening, and improving the content of soluble solids and titratable acids. The results showed that ozone induced the accumulation of phenolic compounds while maintaining the quality. The content of phenolic compounds in fresh-cut pitaya was positively correlated with antioxidant activity. Ultra-performance liquid chromatography-electrospray tandem mass spectrometry was used to fingerprint the phenolic metabolites and metabolomic analysis identified 26 phenolic compounds. The majority of these were phenylpropanoids, and the key metabolic pathways were phenylpropane metabolism and flavonoid synthesis. This study illustrated the mechanism by which of ozone prolongs the shelf life of fresh-cut pitaya fruit and validated ozone as a valuable phenolic inducer and regulator of antioxidant activity, positively influencing the potential health benefits of fresh-cut products.

Combination of ultrasound-peracetic acid washing and ultrasound-assisted aerosolized ascorbic acid: A novel rinsing-free disinfection method that improves the antibacterial and antioxidant activities in cherry tomato

Traditional ultrasound (US)-assisted disinfection is only effective during washing. Coating is an effective method to control microbial growth after washing; however, cross-contamination can occur during immersion in the coating aqueous solution. Tap water (TW) rinsing is generally used to remove sanitizer residues after US-assisted washing; however, the Food and Drug Administration stated that rinsing is unnecessary when the peracetic acid (PAA) concentration does not exceed 80 ppm. In this study, we proposed a novel US-assisted hurdle technology of 80 ppm PAA combined with low-frequency US (25 kHz) during washing, followed by US-assisted aerosolization processing (nonimmersion coating). Ascorbic acid (AA), a safe and low-cost agent, was selected as the aerosolization solution. Cherry tomatoes were selected as the model, and the proposed method was compared with traditional US-assisted disinfection methods (US-10 ppm free chlorine washing + TW rinsing and US-5 ppm chlorine dioxide washing + TW rinsing) to analyze the disinfection efficacy and quality changes. During storage, US-PAA + 1%AA facilitated additional 0.7-0.9, 0.6-0.8, 0.7-1.0, and 0.5-1.0 log CFU/g reductions in the counts of Escherichia coli O157:H7, Salmonella Typhimurium, aerobic mesophilic counts, and molds and yeasts, respectively, as compared with traditional US-assisted methods. Sensory properties, color index, total soluble solids, titratable acidity, and weight loss were not negatively affected by any of the treatments. Firmness was slightly reduced after all treatments; however, the firmness of the samples was maintained during storage, in contrast with the decreased firmness observed in the control. Phenolic content and antioxidant activity significantly increased after all treatments. Further analysis of two key enzymes (phenylalanine ammonia-lyase and 4-coumarate-CoA ligase) involved in phenolic synthesis showed that their levels significantly increased following all treatments, leading to an increase in phenolic content and antioxidant activity. This result also indicated that US-assisted washing could act as an abiotic elicitor to increase nutritional content. Overall, US-PAA + 1%AA treatment served as an effective method for disinfecting produce during washing and for controlling microbial growth after washing without prolonging the processing time, which is an advantage over traditional US-assisted washing.

Combined use of ultrasound-assisted washing with in-package atmospheric cold plasma processing as a novel non-thermal hurdle technology for ready-to-eat blueberry disinfection

Ultrasound (US) has limited disinfection efficacy, and it has been recommended to combine it with chemical disinfectants during fresh produce washing. After washing and before packaging, the disinfection effect of US-assisted washing can be weakened; thus, in-package disinfection is important. As a nutritious fruit, there are no packaged blueberries can be directly eaten. Therefore, in this study, blueberry was selected as the model, and the two most commonly used disinfectants (free chlorine [FC] at 10 ppm and peracetic acid [PAA] at 80 ppm) were combined with low-frequency US (25 kHz) during washing, followed by in-package disinfection using dielectric barrier discharge cold plasma (CP). The disinfection efficacy of US-FC and US-PAA against Escherichia coli O157:H7 and Salmonella Typhimurium was significantly higher than that of US, PAA, or FC alone. The highest disinfection efficacy of CP was observed at the pulse frequency range of 400-800 Hz. For US-FC (1 min) + CP (1 min), an additional 0.86, 0.71, 0.42, and 0.29 log CFU/g of reduction for E. coli O157:H7, S. Typhimurium, aerobic mesophilic counts, and mold and yeast was achieved, respectively, compared with US-FC (2 min) alone. For US-PAA (1 min) + CP (1 min) an additional 0.71, 0.59, 0.32, and 0.21 log CFU/g of reduction was achieved for the above organisms, respectively, compared with US-PAA (2 min) alone. Quality loss (in total color difference, firmness, and anthocyanin content) was not observed after treatment with US-FC + CP, US-PAA + CP, US-FC, or US-PAA. After treatment with US-FC + CP or US-PAA + CP, the reactive oxygen species (ROS) content was significantly lower than that in the other groups, and antioxidant enzyme activity was significantly higher than that in the other groups, suggesting that in-package CP can activate the blueberry antioxidant system to scavenge ROS, thereby lowering the risk of quality loss. US-CP combination not only improves the disinfection efficacy but also lowers quality loss caused by ROS, without prolonging the processing time.

Use of aqueous ozone rinsing to improve the disinfection efficacy and shorten the processing time of ultrasound-assisted washing of fresh produce

In minimal processing industry, chlorine is widely used in the disinfection process and ultrasound (US) increases the disinfection efficacy of chlorine and reduces the cross-contamination incidence during washing. Tap water (TW), which has no disinfection effect, is generally used to rinse off sanitizer residues on the surface of disinfected fresh-cut vegetables. In this study, aqueous ozone (AO), a low-cost and residue-free sanitizer, was used to replace TW rinsing in combination with US (28 kHz)-chlorine (free chlorine [FC] at 10 ppm, a concentration recommended for industrial use) for the disinfection of fresh-cut lettuce as a model. US-chlorine (40 s) + 2.0 ppm AO (60 s) treatment resulted in browning spots on lettuce surface at the end of storage. In contrast, US-chlorine (40 s) + 1.0 ppm AO (60 s) did not lead to deterioration of the sensory quality (sensory crispness, color, and flavor) and a change in total color difference, and the activities of browning-related enzymes were significantly lower. Moreover, US-chlorine (40 s) + 1.0 ppm of AO (60 s) treatment led to significantly lower counts of Escherichia coli O157:H7, Salmonella Typhimurium, aerobic mesophilic (AMC), and molds and yeasts (M&Y) on days 0-7 than US-chlorine (60 s) + TW (60 s) and single 1.0 ppm AO (120 s) treatments, suggesting that AO provided an additional disinfection effect over TW, while reducing the overall processing time by 20 s. Cell membrane permeability analysis (alkaline phosphatase, protein, nucleotide, and adenosine triphosphate leakage) showed that the combination with 1.0 ppm AO caused more severe cell membrane damage in E. coli O157:H7 and S. Typhimurium, explaining the higher disinfection efficacy. 16S rRNA sequencing revealed that following US-chlorine (40 s) + 1.0 ppm of AO (60 s) treatment, Massilia and Acinetobacter had higher relative abundances (RAs) on day 7 than after US-chlorine (60 s) + TW (60 s) treatment, whereas the RAs of Escherichia-Shigella was significantly lower, indicating that the former treatment has a superior capacity in maintaining a stable microbial composition. This explains from an ecological point of view why US-chlorine (40 s) + 1.0 ppm of AO (60 s) led to the lowest AMC and M&Y counts during storage. The study results provide evidence that AO has potential as an alternative to TW rinsing to increase the disinfection efficacy of US-chlorine.

Fresh-Cut Vegetables Processing: Environmental Sustainability and Food Safety Issues in a Comprehensive Perspective

The fresh-cut industry supplies the food market with healthy fresh fruit and vegetables and, in that way, may contribute to improve the nutritional status of the general population. On the other hand, over the last few years increasing concerns have been raised regarding the environmental impact of the fresh-cut industry, human health risks from exposure to disinfection by-products found in fresh-cut products and chlorine-based disinfection treatments during produce processing. This review provides a comprehensive view of the main interlinked aspects related to food safety and environmental impact of processing of fresh-cut vegetables. Advantages and downsides of the mainstream disinfection strategy, based on the use of chlorine-related disinfecting agents, along with some alternative treatments close to a wide commercial application, are discussed. Limitation in the application of these strategies to processing of organic fresh-cut produce are also highlighted, examining the specific environmental and food safety problems in the organic sector. Areas where lack of available information hinders at present a clear understanding of priorities of research and action are pointed out. Innovative conceptual tools are proposed to address these multiple and interlinking issues and to overcome limitations of currently available technologies. A comprehensive and multidisciplinary approach is suggested to move toward a more safe and environmentally sustainable production of fresh-cut products.

Effects of ultrasound-assisted low-concentration chlorine washing on ready-to-eat winter jujube (Zizyphus jujuba Mill. cv. Dongzao): Cross-contamination prevention, decontamination efficacy, and fruit quality

Wash water is circulated for use in the minimal processing industry, and inefficient disinfection methods can lead to pathogen cross-contamination. Moreover, few disinfection strategies are available for ready-to-eat fruits that do not need to be cut. In this study, the use of chlorine and ultrasound, two low-cost disinfection methods, were evaluated to disinfect winter jujube, a delicious, nutritious, and widely sold fruit in China. Ultrasound treatment (28 kHz) alone could not decrease the cross-contamination incidence of Escherichia coli O157:H7, non-O157 E. coli, and Salmonella Typhimurium, and free chlorine treatment at 10 ppm decreased the incidence from 55.00% to 5.00% for E. coli O157:H7, 65.00% to 6.67% for non-157 E. coli, and 70.00% to 6.67% for S. Typhimurium. The cross-contamination incidence was completely reduced (pathogens were not detected in sample) when the treatments were combined. The counts of aerobic mesophiles, aerobic psychrophiles, molds, yeasts, and three pathogens in the group subjected to combination treatment (28 kHz ultrasound + 10 ppm free chlorine) were significantly lower than those in the control, chlorine-treated, and ultrasound-treated groups during storage (0-7 d at 4 °C). Analysis of weight loss, sensory quality (crispness, color, and flavor), instrument color (a*/b*), soluble matter contents (total soluble solids, reducing sugar, total soluble sugar, and titratable acid), and nutritional properties (ascorbic acid and polyphenolic contents) indicated that treatment with ultrasound, chlorine, and their combination did not lead to additional quality loss compared with properties of the control. Additionally, the activities of phenylalanine ammonia-lyase and polyphenol oxidase were not significantly increased in the treatment group, consistent with the quality analysis results. These findings provide insights into disinfection of uncut ready-to-eat fruits using a minimum dose of disinfectant for cross-contamination prevention under ultrasonication. The use of ultrasound alone to decontaminate fresh produce is accompanied by a high risk of pathogen contamination, and the use of sanitizers to decrease cross-contamination incidence is recommended.

Use of Acetic Acid to Partially Replace Lactic Acid for Decontamination against Escherichia coli O157:H7 in Fresh Produce and Mechanism of Action

Escherichia coli O157:H7 is frequently detected in ready-to-eat produce and causes serious food-borne diseases. The decontamination efficacy of lactic acid (LA) is clearly established. In this study, LA was mixed with acetic acid (AA) to reduce costs while achieving consistent or better inhibitory effects. Time-kill curves and inoculation experiments using fresh-cut spinach and arugula indicated that 0.8%LA+0.2%AA shows similar antibacterial effects to those of 1%LA. To determine whether 1%LA and 0.8%LA+0.2%AA exert antibacterial effects by similar mechanisms, proteomics analysis was used. The proteins related to macromolecule localization, cellular localization, and protein unfolding were uniquely altered after the treatment with 1%LA, and the proteins related to taxis, response to stress, catabolic process, and the regulation of molecular function were uniquely altered after the treatment with 0.8%LA+0.2%AA. Based on these findings, combined with the results of a network clustering analysis, we speculate that cell membrane damage is greater in response to LA than to 0.8%LA+0.2%AA. This prediction was supported by cell membrane permeability experiments (analyses of protein, nucleotide, ATP, and alkaline phosphatase leakage), which showed that LA causes greater membrane damage than 0.8%LA+0.2%AA. These results provide a theoretical basis for the application of an acid mixture to replace LA for produce decontamination.

Combination of ozone and ultrasonic-assisted aerosolization sanitizer as a sanitizing process to disinfect fresh-cut lettuce

Reduction of sanitizer dosage and development of non-immersion disinfection methods have become major focuses of research. Here, we examined the disinfection efficacy of combining gaseous ozone (4 and 8 ppm) with aerosolized oxidizing sanitizer [sodium hypochlorite (SH, 100 and 200 ppm)] and aerosolized organic acid [acetic acid (AA, 1% and 2%) and lactic acid (LA, 1% and 2%)]. Notably, 1% AA and 4 ppm gaseous ozone were ineffective for disinfecting Salmonella Typhimurium, and treatment with 1% AA + 8 ppm ozone caused browning of lettuce leaves and stimulated increases in aerobic mesophilic count (AMC), aerobic psychrotrophic count (APC), S. Typhimurium, and Escherichia coli O157:H7. Treatment with 2% LA + 8 ppm ozone resulted in the lowest S. Typhimurium, E. coli O157:H7, Listeria monocytogenes, AMC, APC, and molds and yeasts during storage (0-7 days at 4 °C). Quality analysis indicates that LA + 8 ppm ozone and SH + 8 ppm ozone did not negatively affect L*, a*, b*, polyphenolic content, weight loss, and sensory properties; however, the levels of two individual phenolic compounds (3,4-dihydroxybenzoic acid and vanillin), responsible for phenylpropanoid synthesis, were significantly increased after treatment with 2% LA + 8 ppm ozone. These findings provided insights into the use of LA combined with gaseous ozone for application in disinfecting fresh produce.

The efficacy of washing strategies in the elimination of fungicide residues and the alterations on the quality of bell peppers

Food safety problems caused by pesticide residues in vegetables have become a top issue to raise public concern. In this study, bell peppers were grown in an experimental field and sprayed with two systemic (azoxystrobin and difenoconazole) and one contact (chlorothalonil) fungicides. Ozone (ozonated water and water continuously bubble with ozone) or conventional domestic (washing with distilled water, detergent, acetic acid, sodium bicarbonate, and sodium hypochlorite solutions) procedures were investigated to identify the most effective way to remove fungicide residues in bell peppers. The residues in the fruits and the washing solutions were determined by solid-liquid extraction with a low-temperature partition (SLE/LTP) and liquid-liquid extraction with a low-temperature partition (LLE/LTP), respectively, and analyzed by gas chromatography. Water continuously bubbled with ozone a concentration of 3 mg L^-1 was the most efficient treatment with removal of fungicides residues ranging from 67% to 87%. However, similar treatment at a lower concentration (1 mg L^-1) did not only efficiently removed fungicide residues (between 53% and 75%) but also preserving the quality of the fruit along a storage time of 13 days. Among the conventional solutions, sodium bicarbonate at 5% showed good efficiency removing between 60% and 81% of the fungicide residues from bell peppers, affecting the color quality of the fruit. Overall, the most affected physicochemical parameters in bell peppers after the treatments were weight loss, color, and vitamin C content.

Effect of ozone, lactic acid and combination treatments on the control of microbial and pesticide contaminants of fresh vegetables

BACKGROUND

Fruit and vegetable consumption has increased due to their tremendous health benefits. However, recent studies have shown that contaminated products may serve as vehicles for foodborne pathogens and harmful chemicals. Therefore, fresh vegetables must be decontaminated before consumption to ensure food safety.

RESULTS

In this study, the combined decontamination treatment of lactic acid (2.5 mL L-1 ) and ozone (9 mg L-1 ) for 10 min showed better efficacy in the removal of contaminants from fresh vegetables as compared to individual treatments. The combined treatment resulted in a reduction of 1.5-3.5 log CFU of native mesophilic bacteria per gram and 1.6-2.9 log CFU of artificially inoculated Escherichia coli per gram from tomato, cucumber, carrot and lettuce. The combined treatment also removed spiked pesticides, which represent artificial chemical contamination (28-97% chlorpyrifos and 62-100% λ-cyhalothrin residues), from fresh vegetables. No significant difference (P > 0.05) in various sensory attributes of vegetables was observed between untreated and treated (lactic acid and ozone) vegetables.

CONCLUSIONS

The combination treatment provides a novel approach to target two groups of contaminants using a single procedure. The combination treatment can be used as an alternative to currently used decontamination techniques for the supply of safe vegetables to consumers. © 2020 Society of Chemical Industry.

A Double-Edged Sword of Surfactant Effect on Hydrophobic Surface Broccoli Leaf as a Model Plant: Promotion of Pathogenic Microbial Contamination and Improvement to Disinfection Efficiency of Ozonated Water

Pathogenic microbial contamination is significantly influenced by the crop surface properties and surfactant use, which are crucial factors for the postharvest washing process. However, there is little information on the interaction between surfactant and food pathogens on food crops. Thus, this study (1) investigated whether the attachment of Salmonella increases as pesticides denature epicuticular wax crystals and (2) tested if the antibacterial effect of ozonated water can be improved on waxy produce surfaces by adding surfactant to ozonated water. As a result, significantly lower levels of Salmonella Typhimurium attached to waxy leaf surfaces than they did to glossy and pesticide-treated waxy leaf surfaces (3.28 as opposed to 4.10 and 4.32 Log colony forming units (CFU)/cm2, respectively), suggesting that the pesticide containing a surfactant application increased the attachment of S. Typhiumurium on waxy leaf surfaces. There was no significant washing effect on waxy leaf surfaces washed with ozonated water. On the other hand, S. Typhimurium were not detected on waxy leaf surfaces after washing with surfactant-added ozonated water.

A Review into the Effectiveness of Ozone Technology for Improving the Safety and Preserving the Quality of Fresh-Cut Fruits and Vegetables

In recent years, consumers have become increasingly aware of the nutritional benefits brought by the regular consumption of fresh fruits and vegetables, which reduces the risk of health problems and disease. High-quality raw materials are essential since minimally processed produce is highly perishable and susceptible to quality deterioration. The cutting, peeling, cleaning and packaging processes as well as the biochemical, sensorial and microbial changes that occur on plant tissue surfaces may accelerate produce deterioration. In this regard, biological contamination can be primary, which occurs when the infectious organisms directly contaminate raw materials, and/or by cross-contamination, which occurs during food preparation processes such as washing. Among the many technologies available to extend the shelf life of fresh-cut products, ozone technology has proven to be a highly effective sterilization technique. In this paper, we examine the main studies that have focused on the effects of gaseous ozone and ozonated water treatments on microbial growth and quality retention of fresh-cut fruit and vegetables. The purpose of this scientific literature review is to broaden our knowledge of eco-friendly technologies, such as ozone technology, which extends the shelf life and maintains the quality of fresh produce without emitting hazardous chemicals that negatively affect plant material and the environment.

Effects of aqueous ozone treatment on microbial growth, quality, and pesticide residue of fresh-cut cabbage

The influence of aqueous ozone (1.4 mg/L) treatment for 1, 5, and 10 min on the microbial growth and quality attributes of fresh-cut cabbage during storage at 4°C for 12 days was evaluated. The pesticide residue removal effect of aqueous ozone treatment for 5 min was also determined. The results show that the growth rates of aerobic bacteria, coliforms, and yeasts were significantly inhibited (p < .05) by aqueous ozone treatment during storage; treatment for 10 min showed the greatest inactivation of bacteria, coliforms, and molds. Aqueous ozone stimulated initial respiratory metabolism compared with that of the control. Aqueous ozone treatments reduced ethylene production and improved the overall quality of fresh-cut cabbage. In addition, the effect of aqueous ozone treatment for 5 min on the removal of trichlorfon, chlorpyrifos, methomyl, dichlorvos, and omethoate from fresh-cut cabbage was greater (p < .05) than that of the control. These results indicate that aqueous ozone treatment for 5 min could be an economic and effective method to remove pesticide residues and enhance the storability of fresh-cut cabbage.

Bactericidal and synergistic effects of X-ray irradiation and gallic acid against foodborne pathogens on lettuce

The objectives of this study were to evaluate the bactericidal effects of X-ray irradiation and gallic acid (GA) against Escherichia coli O157:H7, Salmonella Typhimurium, and Listeria monocytogenes on lettuce leaves and in phosphate-buffered saline (PBS). Inoculated PBS and lettuce were exposed to X-rays (0.05, 0.1, and 0.15; 0.1, 0.2, and 0.3 kGy, respectively), and GA was applied to lettuce leaves as a solution and in PBS at concentrations of 0.5% (w/v). Combined treatment with 0.3 kGy and 0.5% GA reduced E. coli O157:H7, S. Typhimurium, and L. monocytogenes cell counts 5.41, 2.57, and 1.36 log CFU/cm2 on lettuce, respectively. Combined treatment with 0.15 kGy X-ray and 0.5% GA reduced counts for the same species by 6.54, 4.24, and 1.51 log CFU/mL in PBS. The combined treatments exerted a synergistic antibacterial effect against E. coli O157:H7 on lettuce, but not against S. Typhimurium or L. monocytogenes. In PBS, the synergistic effect was confirmed in both E. coli O157:H7 and S. Typhimurium cells. Mechanistic investigations indicated that the synergistic antibacterial effect was associated with intracellular reactive oxygen species (ROS) generation and bacterial cell membrane damage. Additionally, the X-ray and GA combination treatment did not adversely affect the color, total phenol content, and texture of lettuce. These findings demonstrate that treatment with X-ray radiation and GA can enhance the microbiological safety of fresh produce.

Ozone treatment pak choi for the removal of malathion and carbosulfan pesticide residues

Since the beginning of the widespread use of pesticides, their removal from food has become a serious concern. In this study, the removal of residual pesticides (malathion and carbosulfan) from pak choi via treatment with ozonated water was investigated. Under the optimal treatment conditions, i.e., 2.0 mg/L ozonated water and a treatment duration of 15 min, malathion and carbosulfan were degraded by 53.0 and 33.0%, respectively, without any significant changes in color. Even though there was a slight decrease in vitamin C content (~7.9 mg/100 g) following the treatments, a significant decrease in the microbial colonies on the vegetables was observed. Additionally, the pesticide degradation mechanism showed good fitting with a "first + first"-order kinetic model (R² > 0.9), and the slope (k) indicated that ozone had a more prominent degradation effect on malathion than on carbosulfan. Therefore, this study provides a theoretical basis for controlling agricultural pesticide residues in household applications.

Disinfection of Ready-to-Eat Lettuce Using Polyhexamethylene Guanidine Hydrochloride

As a novel and safe sanitizer, polyhexamethylene guanidine hydrochloride (PHMG) has been used to inhibit the spoilage of agricultural products caused by fungi. However, little is known about its antibacterial effects on vegetables. In this study, we evaluated the disinfection efficacy of PHMG on ready-to-eat lettuce. PHMG (150-200 mg/L) treatment for 5 min was optimal for lettuce disinfection. Compared to several household sanitizers (vinegar: 1% acetic acid; kettle descaler: 1% citric acid; "84" disinfectant: 200 mg/L sodium hypochlorite), PHMG showed the greatest reductions in Escherichia coli O157:H7, Listeria monocytogenes, aerobic mesophilic counts, aerobic psychrotrophic counts and molds and yeasts. Quality analysis of color (as determined by L*, a* and b*) and determination of electrolyte leakage indicated that PHMG did not cause any additional quality loss as compared to other household sanitizers. These results provide a reference for the application of PHMG as a vegetable sanitizer at the ready-to-eat stage.

Combination of polyhexamethylene guanidine hydrochloride and potassium peroxymonosulfate to disinfect ready-to-eat lettuce

There is increasing demand for improved fresh produce disinfection technology during the ready-to-eat stage, especially in low-income developing countries. We previously reported that polyhexamethylene guanidine hydrochloride (PHMG) is an effective sanitizer using fresh-cut lettuce as a model. As a low-cost alternative, in the present study, we examined the disinfection efficacy of combining PHMG with the oxidizing sanitizer potassium peroxymonosulfate (PMS). PHMG (150 mg L⁻¹) reduced the counts of Escherichia coli O157:H7, non-O157 E. coli, Listeria monocytogenes, Salmonella typhimurium, and naturally present microbes on ready-to-eat lettuce. The disinfection efficacy of PMS was significantly lower than that of PHMG; however, the efficacy of their combination (100 mg L⁻¹ PHMG + 50 mg L⁻¹ PMS, 50 mg L⁻¹ PHMG + 100 mg L⁻¹ PMS, and 50 mg L⁻¹ PHMG + 50 mg L⁻¹ PMS) was equivalent to that of PHMG alone. Color and sensory analyses (crispness, color, flavour, and off-odor) indicated that the combination of PHMG and PMS will not lead to additional quality loss when compared with tap water treatment, and electrolyte leakage analysis showed no additional lettuce surface damage of the combination when compared with PHMG-only treatment. These results show that partial replacement of PHMG by PMS is a cost-reducing strategy, providing a theoretical foundation for its practical application.

Combination of polyhexamethylene guanidine hydrochloride and potassium peroxymonosulfate can achieve consistent disinfection effects as those obtained with polyhexamethylene guanidine hydrochloride but at a lower cost.

Reduction of Escherichia coli O157:H7, Listeria monocytogenes, and Naturally Present Microbe Counts on Lettuce using an Acid Mixture of Acetic and Lactic Acid

Lactic acid (LA) and acetic acid (AA) are independently used to disinfect fresh leaf vegetables. LA has a higher efficacy but costs more than AA. Herein, we compared the disinfection efficacy of LA, AA, and their mixture on lettuce to determine whether the cheaper acid mixture shows similar or more efficacy than LA. Quality analysis indicated that the acid mixture and individual acids did not cause additional loss of instrument color and polyphenolic content compared with that of the control; however, visible defects were observed at AA concentrations exceeding 0.8%. Analysis of Escherichia coli O157:H7, Listeria monocytogenes, and naturally present microbes (aerobic mesophilic and psychrotrophic bacteria, coliforms, molds, and yeasts) showed that the acid mixture led to the highest reduction in microbial count during storage. 16S rRNA sequencing was further employed to understand the effects of the acid mixture and individual acids on lettuce microbial ecology. During storage, the acid mixture and individual acids significantly decreased the abundance of Massilia spp. and Alkanindiges spp. but there was a marked increase in Escherichia-Shigella abundance (LA: 0.003-58.82%; AA: 0.01-55.34%; acid mixture: undetected to 50.71%; control: 0.007-33.09%), indicating that acid disinfection altered the microbial ecology to stimulate Escherichia-Shigella growth. These results enhance our understanding of the relationship between lettuce disinfection and ecological changes.