Molecular characterization of ochratoxin A producing strains of the genus Penicillium

Ochratoxin A in Dry-Cured Ham: OTA-Producing Fungi, Prevalence, Detection Methods, and Biocontrol Strategies-A Review

Traditional dry-cured hams are easily contaminated by toxigenic fungi during the fermentation and ripening stages. The detection and positive rates of ochratoxin A (OTA) are the highest among mycotoxins detected in traditional dry-cured hams, indicating that OTA in hams is a potential safety hazard to human health. This review addresses the mycotoxin-producing fungal species, the toxigenic conditions causing OTA contamination worldwide, the prevalence of OTA contamination in dry-cured hams, and the detection methods applied in OTA analysis. Additionally, this study introduces methods to prevent and control OTA in traditional dry-cured hams. The growth of common mycotoxin-producing fungi and the accumulation of mycotoxins in dry-cured ham can be controlled by a microbial starter. This review provides an important theoretical foundation for the research and control of OTA in traditional dry-cured hams.

Ochratoxin A in Slaughtered Pigs and Pork Products

Ochratoxin A (OTA) is a mycotoxin that is produced after the growth of several Aspergillus and Penicillium spp. in feeds or foods. OTA has been proved to possess nephrotoxic, hepatotoxic, teratogenic, neurotoxic, genotoxic, carcinogenic and immunotoxic effects in animals and humans. OTA has been classified as possibly carcinogenic to humans (Group 2B) by the IARC in 2016. OTA can be mainly found in animals as a result of indirect transmission from naturally contaminated feed. OTA found in feed can also contaminate pigs and produced pork products. Additionally, the presence of OTA in pork meat products could be derived from the direct growth of OTA-producing fungi or the addition of contaminated materials such as contaminated spices. Studies accomplished in various countries have revealed that pork meat and pork meat products are important sources of chronic dietary exposure to OTA in humans. Various levels of OTA have been found in pork meat from slaughtered pigs in many countries, while OTA levels were particularly high in the blood serum and kidneys of pigs. Pork products made from pig blood or organs such as the kidney or liver have been often found to becontaminated with OTA. The European Union (EU) has established maximum levels (ML) for OTA in a variety of foods since 2006, but not for meat or pork products. However, the establishement of an ML for OTA in pork meat and meat by-products is necessary to protect human health.

Fungal Diversity and Evaluation of Ochratoxin A Content of Coffee from Three Cameroonian Regions

The present study had the objective to assess the ochratoxin A content of coffee through chromatographic analysis and design a method using PCR-DGGE to analyze at the same moment the totality of fungal flora present in the coffee samples in order to determine their geographic origin. 96 samples of coffee were collected from the west region (Bafoussam and Dschang), centre region (Bafia), and east region (Batouri) of Cameroon during two years (2017 and 2018). Two treatments (dry and wet routes) were evaluated at three different steps of coffee processing (parchment coffee, green coffee, and husk coffee). The characterization of the fungal profile was done with PCR-DGGE and sequencing. The levels of OTA were assessed using HPLC analysis. The results indicated that the toxinogenic mycoflora associated with coffee beans was mainly Aspergillus niger, A. carbonarius, and A. ochraceus. PCR-DGGE data revealed that each sampling site is characterized by a specific fungal profile. Despite the influence of the treatment on the fungal population of coffee, bands common to samples coming from the same site were observed. These bands could therefore constitute potential biological markers to trace back to the origin of coffee. OTA was detected in most of the coffee samples analyzed and only few samples contented OTA at levels higher than the maximum tolerable limit for food intended for human consumption. The OTA content of coffee was significantly influenced by the sampling step and the sampling period.

Effects of Subcutaneous Ochratoxin-A Exposure on Immune System of Broiler Chicks

Ochratoxin A (OTA), an immunosuppressive mycotoxin, can increase the risk of many infectious diseases and contribute to economic losses to the poultry industry. The immunosuppressive effect has mainly been investigated through oral exposure; however, birds may also be contaminated through skin absorption. The present study investigated the influence of OTA exposure on the defense system of broiler chicks through the subcutaneous route and including low doses. Groups of broiler chicks (Cobb), 05 days old, were exposed to subcutaneous inoculation of OTA at concentrations of 0.1; 0.5; 0.9; 1.3; and 1.7 mg OTA/kg body weight. The size of the lymphoid organs, circulating immune cells, and total IgY and IgA levels were evaluated 21 days post inoculation. Subcutaneous OTA exposure decreased the weight of the thymus, spleen, and bursa of Fabricius, and leukocytopenia (p < 0.05) was detected in chicks of the OTA treated groups. In a dose-dependent way, decreased levels of circulating lymphocytes and heterophils (p < 0.05), and increased levels of monocytes (p < 0.05) were detected. Decreased IgY and IgA serum concentrations were noted in the OTA treated groups (p < 0.05). In conclusion, subcutaneous OTA exposure induces immunosuppression even at low levels.

Comparative proteome analysis of Penicillium verrucosum grown under light of short wavelength shows an induction of stress-related proteins associated with modified mycotoxin biosynthesis

In this study the differentially expressed protein population of Penicillium verrucosum grown either in the dark or under light with a wavelength of 450nm has been analyzed. Light of short wavelength led to oxidative stress in the fungal cell; under this condition the mycotoxin biosynthesis revealed a mutual shift from ochratoxin A to citrinin. Using a proteomic approach combining an optimized protein extraction method with 2-dimensional SDS-PAGE followed by HPLC-ESI-TOF-MS/MS mass spectrometric analysis, initially 56 significantly differential proteins (light vs. dark) were detected comprising proteins of a broad range of isoelectric points and molecular masses. In total, 46 proteins could be identified further by database query, most of these proteins are assumed to be involved in response to stress (e.g. antioxidative proteins, heat shock proteins) and general metabolic processes (e.g. glycolysis, ATP supply). Proteome analyses are necessary to unravel the regulation of secondary metabolite biosynthesis at a translational level. This may enable identification of proteins which are involved in mycotoxin biosynthesis, adaption processes or even stress compensation mechanisms. This study depicts the first proteome analysis of P. verrucosum.

Feeding a diet contaminated with ochratoxin A for chickens at the maximum level recommended by the EU for poultry feeds (0.1 mg/kg). 1. Effects on growth and slaughter performance, haematological and serum traits

The European Commission Recommendation 2006/576/EC, suggests that the maximum level of Ochratoxin A (OTA) in poultry feeds should be set at 0.1 mg OTA/kg. Thirty-six one-day-old male Hubburd broiler chickens were divided into two groups, a Control (basal diet) and an Ochratoxin A (basal diet + 0.1 mg OTA/kg) group. The growth and slaughter performance traits were recorded. The liver, spleen, bursa of Fabricius and thymus weights were measured. The erythrocyte and leukocyte numbers were assayed in blood samples, and the heterophils to lymphocytes (H/L) ratio was determined. Alpha-1-acid glycoprotein (AGP), lysozyme, the total protein and the electrophoretic pattern were evaluated in serum samples. Liver enzymes (alanino aminotransferase, ALT and aspartate aminotransferase, AST) and kidney function parameters (uric acid and creatinine) were quantified. The results revealed that feeding a 0.1 mg OTA/kg contaminated diet to chicks caused a decrease in the absolute thymus weight (p < 0.05) and a lower total protein (p < 0.01), albumin (p < 0.01), alpha (p < 0.05), beta (p = 0.001) and gamma (p = 0.001) globulins serum concentration in the Ochratoxin A group. Moreover, the albumin-to-globulin (A/G) ratio of the OTA-treated animals resulted to be higher (p < 0.05). Feeding broiler chickens, a diet contaminated with the maximum level admitted by the European Commission Recommendation (0.1 mg OTA/kg), did not affect the animal performance, slaughter traits, organ weights, haematological parameters, liver enzyme or renal function parameters concentrations but had an overall immunosuppressant effect, with reduction in the thymus weight and of the total serum protein, albumin, alpha, beta and gamma globulins concentration.

Genetic background of ochratoxin A production inPenicillium

A part of the gene cluster responsible for the production of ochratoxin A inP. nordicum has been characterised recently. The analysed DNA region contains three putative genes: an alcaline proteinase (aspPN), a non-ribosomal peptide synthetase (npsPN) and an polyketide synthase (otapksPN). The last two genes are putative genes of the ochratoxin A biosynthetic pathway. Interestingly theotapksPN gene is present in this form only inP. nordicum but not inP. verrucosum indicating genetic differences between both ochratoxin A producingPenicillium species. The genes in ochratoxin A producingAspergillus species seems to be completely different. It has been demonstrated that thenpsPN gene is actively transcribed inP. nordicum under ochratoxin A producing conditions, indicating that this gene is involved in ochratoxin A biosynthesis.

Molecular diagnosis of ochratoxinogenicAspergillus species

Toxigenic and non-toxigenic black aspergilli belonging to theAspergillus niger aggregate and toA. carbonarius were compared to each other and to strains of other species by DNA fingerprinting. AFLPs showed a clear separation ofA. niger andA. carbonarius. However, no clear correlation between the genetic similarity of the strains and the ability to produce ochratoxin A (OTA) was detected. Based on AFLP, marker sequences were chosen for the construction of SCAR-PCR primers for the detection ofA. carbonarius. A similar approach was used forA. ochraceus, another fungus of concern regarding ochratoxin A contamination of coffee. Cluster analysis ofA. ochraceus isolates mainly from Brazilian coffee showed a very close genetic similarity. Three species specific primer pairs were developed and one of these was used for the PCR and realtime PCR (RT-PCR) based detection of the mould in green coffee.A. ochraceus was specifically and rapidly detected and quantified in green coffee. A positive correlation between the amount of DNA and OTA content was established.

Wavelength-dependent degradation of ochratoxin and citrinin by light in vitro and in vivo and its implications on Penicillium

It has previously been shown that the biosynthesis of the mycotoxins ochratoxin A and B and of citrinin by Penicillium is regulated by light. However, not only the biosynthesis of these mycotoxins, but also the molecules themselves are strongly affected by light of certain wavelengths. The white light and blue light of 470 and 455 nm are especially able to degrade ochratoxin A, ochratoxin B and citrinin after exposure for a certain time. After the same treatment of the secondary metabolites with red (627 nm), yellow (590 nm) or green (530 nm) light or in the dark, almost no degradation occurred during that time indicating the blue light as the responsible part of the spectrum. The two derivatives of ochratoxin (A and B) are degraded to certain definitive degradation products which were characterized by HPLC-FLD-FTMS. The degradation products of ochratoxin A and B did no longer contain phenylalanine however were still chlorinated in the case of ochratoxin A. Citrinin is completely degraded by blue light. A fluorescent band was no longer visible after detection by TLC suggesting a higher sensitivity and apparently greater absorbance of energy by citrinin. The fact that especially blue light degrades the three secondary metabolites is apparently attributed to the absorption spectra of the metabolites which all have an optimum in the short wave length range. The absorption range of citrinin is, in particular, broader and includes the wave length of blue light. In wheat, which was contaminated with an ochratoxin A producing culture of Penicillium verrucosum and treated with blue light after a pre-incubation by the fungus, the concentration of the preformed ochratoxin A reduced by roughly 50% compared to the control and differed by > 90% compared to the sample incubated further in the dark. This indicates that the light degrading effect is also exerted in vivo, e.g., on food surfaces. The biological consequences of the light instability of the toxins are discussed.

Detection of ochratoxin A and cis- and trans-resveratrol in red wines and their musts from Calabria (Italy)

The natural occurrence of ochratoxin A (OTA) and cis- and trans-resveratrols in red wines has been widely reported. The aim of this work was to evaluate the ochratoxin A (OTA) and both cis- and trans-resveratrol content of red wine (from must to wine) in a pilot-scale vinification process in Calabria (Italy). Eleven samples were collected at different stages of vinification and analysis was carried out by HPLC. Wine from manufacturer 3 contained the highest amount of trans-resveratrol (3.41 mg l(-1)). This wine was characterized by an Aglianico-Magliocco grape variety. Interestingly, data regarding OTA showed that the value of this contaminant was low in all analyzed samples and, in each case, below the legal limit (2.0 mg l(-1) (ppb)). Overall, the results demonstrated the high quality of wines produced in Calabria.

Ochratoxin A producing species in the genus Penicillium

Ochratoxin A (OTA) producing fungi are members of the genera Aspergillus and Penicillium. Nowadays, there are about 20 species accepted as OTA producers, which are distributed in three phylogenetically related but distinct groups of aspergilli of the subgenus Circumdati and only in two species of the subgenus Penicillium. At the moment, P. verrucosum and P. nordicum are the only OTA producing species accepted in the genus Penicillium. However, during the last century, OTA producers in this genus were classified as P. viridicatum for many years. At present, only some OTA producing species are known to be a potential source of OTA contamination of cereals and certain common foods and beverages such as bread, beer, coffee, dried fruits, grape juice and wine among others. Penicillium verrucosum is the major producer of OTA in cereals such as wheat and barley in temperate and cold climates. Penicillium verrucosum and P. nordicum can be recovered from some dry-cured meat products and some cheeses.

Ochratoxin a: general overview and actual molecular status

Ochratoxin A (OTA) is a mycotoxin produced by several species of Aspergillus and Penicillium fungi that structurally consists of a para-chlorophenolic group containing a dihydroisocoumarin moiety that is amide-linked to L-phenylalanine. OTA is detected worldwide in various food and feed sources. Studies show that this molecule can have several toxicological effects such as nephrotoxic, hepatotoxic, neurotoxic, teratogenic and immunotoxic. A role in the etiology of Balkan endemic nephropathy and its association to urinary tract tumors has been also proved. In this review, we will explore the general aspect of OTA: physico-chemical properties, toxicological profile, OTA producing fungi, contaminated food, regulation, legislation and analytical methods. Due to lack of sufficient information related to the molecular background, this paper will discuss in detail the recent advances in molecular biology of OTA biosynthesis, based on information and on new data about identification and characterization of ochratoxin biosynthetic genes in both Penicillium and Aspergillus species. This review will also cover the development of the molecular methods for the detection and quantification of OTA producing fungi in various foodstuffs.

Comprehensive molecular system to study the presence, growth and ochratoxin A biosynthesis of Penicillium verrucosum in wheat

Based on the sequence of the ochratoxin A polyketide synthase gene (otapksPV), a polymerase chain reaction (PCR) system for the specific detection of Penicillium verrucosum in wheat has been developed. In a further approach, a real-time PCR system has been applied to determine the growth kinetics of P. verrucosum in wheat at cell numbers above 10(3) colony-forming units (cfu) ml(-1). The data obtained by real-time PCR correlated well with the data obtained by the plate count technique. For this purpose, the DNA was isolated directly from contaminated wheat without any further enrichment step. In a reverse transcriptase real-time PCR, the expression of the otapksPV gene in wheat was detected 22 days after inoculation and storage at ambient temperature. Reasonable amounts of ochratoxin A, however, could not be detected before day 30. This early activation of ochratoxin A related genes was confirmed by microarray analysis.

Molecular characterization of Aspergillus section Flavi isolates collected from peanut fields in Argentina using AFLPs

AIMS

The objectives of this study were: (i) to evaluate genetic relatedness among Aspergillus section Flavi strains isolated from soil and peanut seeds in Argentina; (ii) to determine if AFLP molecular markers could be useful to identify isolates up to species level, and to correlate these markers with the isolates' toxigenic potentials and/or vegetative compatibility group (VCG) affiliations.

METHODS AND RESULTS

Amplified fragment length polymorphism (AFLPs) analysis was applied to compare 82 isolates of Aspergillus section Flavi. Cluster analysis showed a clear separation of A. flavus and A. parasiticus, and comparison of fingerprints revealed several specific markers for each group of isolates. AFLP analysis indicates that no genotypical differences can be established between aflatoxigenic and nonaflatoxigenic producers in both species analysed. In addition, candidate AFLP markers associated with a particular VCG were not found.

CONCLUSIONS

There was a concordance between morphological identification and separation up to species level using molecular markers. The findings of specific bands for A. flavus and A. parasiticus may be useful for the design of specific PCR primers in order to differentiate these species and detect them in food.

SIGNIFICANCE AND IMPACT OF THE STUDY

The present study provides new data on molecular characterization of Aspergillus section Flavi in Argentina.

Detection of Aspergillus carbonarius and other black aspergilli from grapes by DNA OLISA microarray

Black aspergilli, and particularly Aspergillus carbonarius, are responsible for ochratoxin A production in grapes. Correct identification of these species is essential for toxicological risk assessment in grape and wine. A low-complexity oligonucleotide microarray (OLISA, Apibio, F) based on DNA oligonucleotides probes, obtained from sequences of the calmodulin gene, was set up in order to detect A. carbonarius, A. japonicus/A. aculeatus and A. ibericus isolated from grape. The designed microarray distinguished all Aspergillus species and the detection limit for A. carbonarius was 3.2 pg of DNA as a template for the PCR reaction. This microarray offers a quick and parallel analysis to detect individual Aspergillus species in pure cultures and in naturally contaminated grape samples.

Inhibition of ochratoxin A production and growth of Aspergillus species by phenolic antioxidant compounds

The phenolic antioxidants, gallic acid, vanillic acid, protocatechuic acid, 4-hydroxybenzoic acid, catechin, caffeic acid, and chlorogenic acid were studied for their effects on ochratoxin A (OTA) production and fungal growth of ochratoxigenic Aspergilli. Of the 12 strains tested, which included A. alliaceus, A. lanosus, A. ochraceus, A. albertensis, A. melleus, A. sulphureus, A. carbonarius, A. elegans, and A. sclerotiorum, the greatest inhibition of OTA production was seen in A. sulphureus, A. elegans, and A. lanosus. Vanillic acid and 4-hydroxybenzoic acid were the most inhibitory to both OTA production and growth of most of the strains tested. However, A. ochraceus was not inhibited by either compound, and A. carbonarius was not inhibited by vanillic acid. The effect of each compound on OTA production and growth differed among strains and generally was variable, suggesting that species-specific OTA production and response to phenolic compounds may be influenced by different ecological and developmental factors. In addition, inhibition of OTA production by antioxidant compounds may be useful in determining biosynthetic and regulatory genes involved in both OTA production and stress response in ochratoxigenic Aspergilli.

Occurrence of ochratoxin A in sweet wines produced in Spain and other countries

A survey for the presence of ochratoxin A (OTA) was undertaken from 2001 to 2005 in 188 samples of sweet wines produced in Spain and in 102 samples originating from other countries: France (n = 49), Austria (9), Chile (9), Portugal (9), Greece (6), Italy (5), Germany (3), Hungary (2), Slovenia (2), Switzerland (2), Canada (1), Japan (1), New Zealand (1), Ukraine (1), South Africa (1) and the USA (1). The analytical method was based on immunoaffinity chromatography clean-up and high-performance liquid chromatography (HPLC) with fluorescence detection. The limit of detection (defined as a signal-noise ratio = 3) was estimated to be 0.01 microg l(-1). The limit of quantification (0.02 microg l(-1)) was checked as being the lowest measurable concentration. OTA was detected in 281 out of 290 samples analysed (96.9% positive) at concentrations ranging from 0.01 to 4.63 microg l(-1). The overall mean and median levels were estimated to be 0.50 and 0.14 microg l(-1), respectively. In Spanish sweet wines OTA was found in 99% of the samples, with mean and median values of 0.65 and 0.19 microg l(-1), respectively. The mean value obtained in this study for OTA in the Spanish sweet wines would result in an intake of about 37.5 and 3.2 ng day(-1) of OTA for regular consumers and for the overall population, respectively. These figures represent a minor contribution to the provisional tolerable weekly intake (PTWI) or TWI established by the Joint Expert Committee on Food Additives (JECFA) and the European Food Safety Authority: 3.8 and 3.1% for regular consumers; and 0.4 and 0.3% for the whole adult population, respectively.

Genetic variation among Penicillium crustosum isolates from arctic and other ecological niches

Penicillium crustosum is an important and panglobal contaminant of lipid- and protein-rich foods and feeds. Although it is infrequent in extremely cold environments, we isolated a high number of P. crustosum strains from Arctic coastal, but particularly, subglacial environments in Svalbard, Norway. P. crustosum is extremely consistent in its phenotypic properties, including morphology, physiology, and secondary metabolite production. However, some Arctic isolates differed from other Arctic and non-Arctic strains in their weak growth on creatine and in the production of the secondary metabolite andrastin A. In this study, we characterized genetic variability of P. crustosum strains originating from different Arctic and non-Arctic environments using amplified fragment length polymorphism (AFLP) and, in addition, M13 minisatellite fingerprinting and partial beta-tubulin gene sequencing. Most of the Arctic strains (85%) showed a relatively low variability and polymorphism level. They produced nine different AFLP genotypes grouped into two clusters in accordance with glacier origin and creatine utilization. The rest of the Arctic isolates and isolates from various non-Arctic environments displayed a much greater degree of genetic variability. It seems that in stressful glacial environment low microbial genetic variation is represented by only a few adapted genotypes that were not recovered from nonpolar environments.

Penicillium populations in dry-cured ham manufacturing plants

Seven ham manufacturing plants were sampled for 1 year to assess the mycoflora present in the air and on hams, with special attention given to potential mycotoxin producers. Temperature and relative humidity were recorded in the ripening rooms. Maturing rooms held hams from 2 to 3 through 6 to 7 ripening months, and aging rooms held hams for the following 6 to 7 months, until the 14-month ripening point, when they were ready for the market. Mean temperatures and relative humidities registered during the study were 14.9 degrees C and 62.4%, respectively, in maturing rooms and 16.3 degrees C and 57.6% in aging rooms. Aspergilli and penicillia, potential mycotoxin producers, were isolated in all the plants from the air and the ham. Aspergilli represented 5% of the isolates, while penicillia were largely dominant, with Penicillium nalgiovense being the most represented species (around 60% of the penicillia), followed by Penicillium nordicum, with 10 and 26% of the penicillia isolated, respectively, from the air or the ham. Ochratoxin A production ability, checked in vitro at 250C, was observed in 50% of the P. nordicum isolates obtained both from the air and the ham. Air and ham surface contamination by penicillia was greater in the ripening rooms, where higher temperatures were registered. A certain correlation was also observed between air and ham surface contamination. On the basis of this study, P. nordicum, the ochratoxin A producer that is notable on proteinaceous substrates, is normally present in ham manufacturing plants in Italy, even though not a dominant species. Further studies are necessary to clarify and ensure if dry-curing conditions minimize the potential risk of ochratoxin A formation in the product.

Targeting a polyketide synthase gene for Aspergillus carbonarius quantification and ochratoxin A assessment in grapes using real-time PCR

Aspergillus carbonarius is an ochratoxin producing fungus that has been considered to be responsible of the ochratoxin A (OTA) contamination in grapes and wine. In order to monitor and quantify A. carbonarius, a specific primer pair Ac12RL_OTAF/Ac12RL_OTAR has been designed from the acyltransferase (AT) domain of the polyketide synthase sequence Ac12RL3 to amplify 141 bp PCR product. Among the mycotoxigenic fungi tested, only A. carbonarius gave a positive result. This specific primer pair was also successfully employed in real-time PCR conjugated with SYBR Green I dye for the direct quantification of this fungus in grape samples. A positive correlation (R(2)=0.81) was found between A. carbonarius DNA content and OTA concentration in 72 grape samples, allowing for the estimation of the potential risk from OTA contamination. Consequently, this work offers a quick alternative to conventional methods of OTA quantification and mycological detection and quantification of A. carbonarius in grapes.

Study of the effect of water activity and temperature on ochratoxin A production by Aspergillus carbonarius

The effect of water activity (aw) (0.78-0.99) and temperature (15 and 30 degrees C) on growth and production of ochratoxin A (OTA) of six Aspergillus carbonarius strains was studied in two culture media: Czapek yeast autolysate (CYA) agar and yeast extract sucrose (YES) agar, during a period of 30 days. The strains were selected to include different sources and different reported abilities to produce OTA and were characterized by RAPD and ITS-5.8S rDNA sequencing. CYA showed to be better culture medium than YES for OTA production in the isolates tested. OTA concentration was higher at 15 degrees C than at 30 degrees C. At 30 degrees C, ranges for OTA production were more restrictive than those for growth. OTA was produced from 0.86, 0.90 or 0.94 aw depending on the strain. At 15 degrees C, growth and OTA production were detected only in the 0.94-0.99 aw range. The molecular study performed showed that five of the strains were conspecific and no correlation was found between molecular data and the OTA production level or origin. The remaining strain had never been able to produce OTA and will probably represent a new species in the Aspergillus section Nigri. Our results show that A. carbonarius is able to grow and produce OTA in a wide range of water activities at both high and low temperatures.

Aspergillus ibericus: a new species of section Nigri isolated from grapes

As part of a study on the ochratoxin producing mycoflora of grapes, several Aspergillus strains were isolated and tested for their ochratoxin A (OTA) producing abilities. Aspergillus strains of the section Nigri, which did not produce detectable amounts of OTA but which had a similar morphology to A. carbonarius, were isolated from wine grapes and/or dried vine fruit in Portugal and Spain. These strains, however, have characters that allow morphological distinction from the other species in the section, particularly the conidia size (5-7 microm), which allows separation of the species from the two most common biseriate species in section Nigri: A. carbonarius (7-9 microm) and A. niger and its aggregate species (3-5 microm). The strains are described here as belonging to a new species, named A. ibericus. The validation of this new taxon is supported further by analysis of the ITS-5.8S rDNA and calmodulin gene sequences and by analysis of the amplified fragment length polymorphism (AFLP) patterns, which were consistent in separating these strains from other species in the section. A. ibericus strains do not produce OTA therefore they are interesting for biotechnological exploration because many metabolites with commercial value are produced by other species in the section.

Development of a quantitative real-time PCR assay for the detection of Aspergillus carbonarius in grapes

Aspergillus carbonarius is the main species responsible for the production of ochratoxin A (OTA) in wine grapes. To monitor and quantify A. carbonarious in grapes, a quantitative real-time PCR assay was developed as a possible tool for predicting the potential ochratoxigenic risk. DNA extraction from grape berries was performed by using conventional extraction and clean up through EZNA Hi-bond spin columns. A TaqMan probe was used to quantify A. carbonarius genomic DNA in grape berries samples. An exogenous internal positive control was used to overcome DNA recovery losses due to matrix inhibition. The quantification of fungal genomic DNA in naturally contaminated grape was performed using the TaqMan signal versus spectrophotometrically measured DNA quantities (Log10) calibration curve with a linearity range from 50 to 5 x 10(-4) ng of DNA. A positive correlation (R2=0.92) was found between A. carbonarious DNA content and OTA concentration in naturally contaminated grape samples. This is the first application of TaqMan real-time PCR for identifying and quantifying A. carbonarius genomic DNA occurring in grapes. The rapid DNA extraction method for grapes, together with the commercial availability of reagents and instrumentation, allows to perform a remarkable number of reproducible assays (96-well format) in less than 4 h.

Ochratoxin A biosynthetic genes in Aspergillus ochraceus are differentially regulated by pH and nutritional stimuli

Expression of the polyketide synthase (pks) gene which is involved in ochratoxin A (OTA) biosynthesis in Aspergillus ochraceus is linked to production of the mycotoxin, with high levels of pks mRNA accumulation occurring in cultures producing OTA, as assessed by real-time reverse transcription (RT)-PCR. OTA production is regulated by nutrient availability, with supplementation of OTA restrictive potato dextrose broth with yeast extract resulting in a 39-fold increase in production of the mycotoxin. This effect appears to be mediated at the level of gene transcription as there is a concomitant increase in pks mRNA accumulation. OTA production is also strongly influenced by culture pH with large amounts of OTA being produced at pH values <7.0 with reduced amounts being produced at higher pH values. pks transcript levels again mirrored the OTA production profile observed at the different pH values. The transcription of two putative p450 type monooxygenase genes, namely p450-H11 and p450-B03 genes closely mirrored that of the pks gene under all growth conditions tested, suggesting their involvement together with the pks in OTA biosynthesis. The expression profile of the p450-B03 gene in particular is very similar to that of the pks gene, indicating that this gene may be clustered with the pks as part of the OTA biosynthetic gene cluster.

Effect of water activity on ochratoxin A production by Aspergillus niger aggregate species

The effect of water activity (a(w)) (0.82-0.99) on growth and ochratoxin A (OTA) production by twelve Aspergillus niger aggregate strains, cultured in Czapek Yeast Autolysate agar (CYA) and Yeast Extract Sucrose agar (YES), was studied for an incubation period of 30 days. The strains were selected to include diverse sources, different reported abilities to produce OTA and different ITS-5.8 S rDNA Restriction Fragment Length Polymorphism (RFLP) pattern. They were characterized by Random Amplification of Polymorphic DNA (RAPD) and ITS-5.8 S rDNA and 28 S rDNA (D1/D2) sequencing. Regardless of the a(w) value tested, YES was a better culture medium than CYA for OTA production. The a(w) range for OTA production was narrower than that for growth. OTA was produced from 0.90, 0.92, 0.94 or 0.96 to 0.99 a(w) depending on the strain and the culture medium. The molecular study differentiated strains into two groups which corresponded to the RFLP types N and T although it did not distinguish them by their source of isolation or OTA producing abilities. Our results show that A. niger aggregate strains are able to grow and produce OTA over a wide a(w) range. These results will lead to a better understanding of the contribution of A. niger aggregate in OTA contamination of food and feed.

Toxicokinetics and toxicodynamics of ochratoxin A, an update

Ochratoxin A (OTA) is a mycotoxin produced by fungi of two genera: Penicillium and Aspergillus. OTA has been shown to be nephrotoxic, hepatotoxic, teratogenic and immunotoxic to several species of animals and to cause kidney and liver tumours in mice and rats. Because of differences in the physiology of animal species, wide variations are seen in the toxicokinetic patterns of absorption, distribution and elimination of the toxin. Biotransformation of OTA has not been entirely elucidated. At present, data regarding OTA metabolism are controversial. Several metabolites have been characterized in vitro and/or in vivo, whereas other metabolites remain to be characterized. Several major mechanisms have been shown as involved in the toxicity of OTA: inhibition of protein synthesis, promotion of membrane peroxidation, disruption of calcium homeostasis, inhibition of mitochondrial respiration and DNA damage. The contribution of metabolites in OTA genotoxicity and carcinogenicity is still unclear. The genotoxic status of OTA is still controversial because contradictory results were obtained in various microbial and mammalian tests, notably regarding the formation of DNA adducts. More recent studies are focused on the OTA ability to disturb cellular signalling and regulation, to modulate physiological signals and thereby to influence cells viability and proliferation. The present paper offers an update on these different issues. In addition since humans and animals are likely to be simultaneously exposed to several mycotoxins, especially through their diet, the little information available on the combined effects of OTA and other mycotoxins has also been reviewed.

Cloning a part of the ochratoxin A biosynthetic gene cluster of Penicillium nordicum and characterization of the ochratoxin polyketide synthase gene

Penicillium nordicum is a fungal species able to produce high amounts of ochratoxin A. A 10kb genomic DNA fragment of P. nordicumn has been cloned which carries three long open reading frames. One open reading frame (otapksPN) has homology to fungal polyketide synthases. The second open reading frame (npsPN) has homology to non-ribosomal peptide synthetases and the third open reading frame (aspPN) has homology to fungal alkaline serine proteinases. The non-ribosomal peptide synthetase and the polyketide synthase are convergently transcribed. Interestingly, the polyketide synthase can be identified by PCR only in P. nordicum strains and not in the related species Penicillium verrucosum or in ochratoxigenic Aspergillus species, indicating that the ochratoxin polyketide synthases are different in the important ochratoxigenic species. In contrast, the non-ribosomal peptide synthetase can be identified in P. nordicum and P. verrucosum, but not in other species. An inactivation of the polyketide synthase resulted in strains with abolished capacity to produce ochratoxin A. Expression of the polyketide synthase correlates with ochratoxin A biosynthesis.

The effect of substrate on mycotoxin production of selected Penicillium strains

Analytical methods are presented for detecting simultaneously 11 fungal metabolites (aflatoxins B1, B2, G1 and G2, citrinin, cyclopiazonic acid, mycophenolic acid, ochratoxin A, penicillic acid, penitrem A and roquefortine C) on different matrices. The methods were applied to determine the mycotoxins produced by different Penicillium crustosum, Penicillium nordicum and Penicillium verrucosum strains on yeast extract sucrose (YES) agar and cheese and bread analogues and are based on high-performance liquid chromatography (HPLC) and photodiode array detection (PDA). The growth substrate had a distinctive effect on the mycotoxin production ability of the fungi examined. The P. crustosum strains produced roquefortine C on all the substrates, with the highest amounts being detected on the cheese analogue. Penitrem A was synthesised on the cheese analogue only. The strains of P. verrucosum produced exclusively citrinin on YES, but both ochratoxin A and citrinin were detected in considerable amounts on the bread analogue. On the bread, toxin profiles varied significantly between the individual P. verrucosum strains. The cheese analogue was not favourable for the mycotoxin production of this species. The growth substrate had the least effect on the toxin production of the P. nordicum strains, which synthesised ochratoxin A in moderate amounts on all three media.

Advances in the molecular diagnosis of ochratoxin A–producing fungi

Ochratoxin A (OTA) is detected worldwide in various food and feed sources. The compound is produced by Penicillium nordicum and P. verrucosum, as well as by various species within the sections Nigri and Circumdati of the genus Aspergillus, with A. ochraceus and A. carbonarius known to be the predominant producers. Recently, various pairs of PCR primers based on AFLP, RFLP, RAPD and the calmodulin gene were developed to set up novel diagnostic approaches for OTA producers in the Aspergillus and Penicillium genera. Real-time PCR assays based on well-characterized genomic sequences in A. ochraceus and P. nordicum have also been set up. Since the application of such assays to the analysis of contaminated sample material was demonstrated in only a few cases, future studies should be focused on applying such methods in rapid, robust and user-friendly applications, and implementing them in HACCP concepts. The recent detection and characterization of OTA biosynthetic pathway genes in the Penicillium genus is an important step towards understanding what mechanisms influence production of the toxin in order to redesign production processes in the food and feed industry and to keep de-novo synthesis to a minimum.

DNA-based characterization of ochratoxin-A-producing and non-producing Aspergillus carbonarius strains from grapes

Using molecular methods, a total of 189 strains of black aspergilli, including Aspergillus carbonarius and uniseriate species (Aspergillus aculeatus, Aspergillus japonicus), were studied in order to characterize species responsible for ochratoxin A (OTA) contamination of grapes from Europe and Israel. Sixty-six strains were morphologically identified as belonging to the uniseriate species and 123 as A. carbonarius. None of the uniseriate species were able to produce OTA. From the A. carbonarius strains, 96.7% were OTA producers (0.1-654.3 microg/g). We characterized 53 strains of A. carbonarius from different countries by RAPD and ITS-5.8S rDNA sequencing analysis. Forty-nine strains had a similar RAPD pattern and identical ITS-5.8S rDNA sequences. They produced OTA at different levels. No correlation was observed between the obtained clusters and the OTA production level or origin. Only four strains, morphologically identified as A. carbonarius, were unable to produce OTA. These strains showed a different RAPD pattern, and the section of DNA sequenced differed from the sequence of the other 49 strains. These OTA-non-producing strains may represent a new species in the Aspergillus section Nigri.

Phylogenetic signal in AFLP data sets

AFLP markers provide a potential source of phylogenetic information for molecular systematic studies. However, there are properties of restriction fragment data that limit phylogenetic interpretation of AFLPs. These are (a) possible nonindependence of fragments, (b) problems of homology assignment of fragments, (c) asymmetry in the probability of losing and gaining fragments, and (d) problems in distinguishing heterozygote from homozygote bands. In the present study, AFLP data sets of Lactuca s.l. were examined for the presence of phylogenetic signal. An indication of this signal was provided by carrying out tree length distribution skewness (g1) tests, permutation tail probability (PTP) tests, and relative apparent synapomorphy analysis (RASA). A measure of the support for internal branches in the optimal parsimony tree (MPT) was made using bootstrap, jackknife, and decay analysis. Finally, the extent of congruence in MPTs for AFLP and internal transcribed spacer (ITS)-1 data sets for the same taxa was made using the partition homogeneity test (PHT) and the Templeton test. These analytical studies suggested the presence of phylogenetic signal in the AFLP data sets, although some incongruence was found between AFLP and ITS MPTs. An extensive literature survey undertaken indicated that authors report a general congruence of AFLP and ITS tree topologies across a wide range of taxonomic groups, suggesting that the present results and conclusions have a general bearing. In these earlier studies and those for Lactuca s.l., AFLP markers have been found to be informative at somewhat lower taxonomic levels than ITS sequences. Tentative estimates are suggested for the levels of ITS sequence divergence over which AFLP profiles are likely to be phylogenetically informative.