A Simple Two-Step Method for Simultaneous Isolation of Tocopherols and Free Phytosterols from Soybean Oil Deodorizer Distillate with High Purity and Recovery

Separation of tocol (tocopherol & tocotrienol) and phytosterols from palm fatty acid distillate by saponification and purification by low temperature solvent crystallization

The tocotrienols (T3) are the vitamin E family members with excellent antioxidant properties and prevent autocatalytic lipid peroxidation. Palm Fatty Acid Distillate (PFAD) is a volatile organic material obtained during palm oil refining and consists of tocol (α-tocopherol/T, α, γ, β, and δ- tocotrienol/T3) up to 0.8% and represents a potential source for recovering these valuable compounds. Various methods have been studied to extract vitamin E; however, only a few are commercially available. To fulfil the need for technology for recovering these minor components, leaching the tocotrienol from solidified PFAD was carried out. In this study, the fatty acid of PFAD was saponified using NaHCO₃/Ca(OH)₂ and extracted the unsaponifiable fraction using solvent. Further, fraction was purified by low temperature solvent based crystallization using hexane at 5 ± 1.0 °C for 24 h and removed sterol. The best determined parameters like reaction time (30 min), the ratio of PFAD to Ca(OH)₂ (1,w/w), reaction temperature (30 °C) and stirring speed 300 rpm were yielded up to 98.6% fatty acid conversion to calcium soap and extraction with hexane obtained higher concentration of tocol (28.1%). The sterol separated from the tocol rich fraction by low temperature solvent crystallization contains up to 37.1% of phytosterol (β-sitosterol) concentration.

SUPPLEMENTARY INFORMATION

The online version contains supplementary material available at 10.1007/s13197-022-05402-7.

Performance of Liquid Eversa on Fatty Acid Ethyl Esters Production by Simultaneous Esterification/Transesterification of Low-to-High Acidity Feedstocks

Liquid Eversa was evaluated in hydrolysis of acylglycerols from soybean oil deodorizer distillate (SODD), as well as simultaneous esterification/transesterification of SODD with low-to-high free fatty acids (FFAs) content using ethanol as acyl acceptor. Hydrolysis of SODD at mild temperature (37 °C) and without pH control (water:SODD mass ratio of 4:1) increased its FFAs content from 17.2 wt.% to 72.5 wt.% after 48 h reaction. A cold saponification of SODD allowed a saponification phase (SODD-SP) to be recovered with 93 wt.% saponification index and 2.25 wt.% FFAs content, which was used to find the experimental conditions for simultaneous esterification/transesterification reactions by experimental design. Temperature of 35 °C, enzyme concentration of 8.36 wt.%, and molar ratio of 3.64:1 (ethanol:SODD-SP) were found as the best conditions for fatty acid ethyl esters (FAEEs) production from SODD-SP (86.56 wt.% ester yield after 23 h reaction). Under the same reaction conditions, crude SODD (17.2 wt.% FFAs) and hydrolyzed SODD (72.5 wt.% FFAs) yielded products containing around 80 wt.% FAEEs. Caustic treatment could increase the ester content to around 90 wt.% and reduce the FFAs content to less than 1 wt.%. Our results show the good performance of liquid Eversa in aqueous (hydrolysis reactions) and organic (esterification/transesterification reactions) media.

Novel Fast Chromatography-Tandem Mass Spectrometric Quantitative Approach for the Determination of Plant-Extracted Phytosterols and Tocopherols

Phytosterols and tocopherols are commonly used in food and pharmaceutical industries for their health benefits. Current analysis methods rely on conventional liquid chromatography, using an analytical column, which can be tedious and time consuming. However, simple, and fast analytical methods can facilitate their qualitative and quantitative analysis. In this study, a fast chromatography-tandem mass spectrometric (FC-MS/MS) method was developed and validated for the quantitative analysis of phytosterols and tocopherols. Omitting chromatography by employing flow injection analysis—mass spectrometry (FIA-MS) failed in the quantification of target analytes due to analyte-to-analyte interferences from phytosterols. These interferences arise from their ambiguous MS fingerprints that would lead to false identification and inaccurate quantification. Therefore, a C18 guard column with a 1.9 µm particle size was employed for FC-MS/MS under isocratic elution using acetonitrile/methanol (99:1 v/v) at a flow rate of 600 µL/min. Analyte-to-analyte interferences were identified and eliminated. The false peaks could then be easily identified due to chromatographic separation. In addition, two internal standards were evaluated, namely cholestanol and deuterated cholesterol. Both internal standards contributed to the observed analyte-to-analyte interferences; however, adequate shift in the retention time for deuterated cholesterol eliminated its interferences and allowed for an accurate quantification. The method is fast (1.3 min) compared to published methods and can distinguish false peaks observed in FIA-MS. Seven analytes were quantified simultaneously, namely brassicasterol, campesterol, stigmasterol, β-sitosterol, α-tocopherol, δ-tocopherol, and γ-tocopherol. The method was successfully applied in the quantitative analysis of phytosterols and tocopherols present in the unsaponifiable matter of canola oil deodorizer distillate (CODD). β-sitosterol and γ-tocopherol were the most abundant phytosterols and tocopherols, respectively.

Advances in various techniques for isolation and purification of sterols

Plants consist of triterpenoids such as phytosterols (PT) (C₂₉H₅₀O) with steroidal nuclei, including sitosterol, stigmasterol, brassicasterol and campesterol. They are hydrophobic but soluble in alcohol and other organic solvents and are isolated from industrial waste deodorizer distillates of various edible oil industries. They exist as free PT or their ester derivatives in soybean, rice, wheat, oat, cottonseed and corn fiber, and other cereals and grains. Conventional isolation techniques such as solvent extraction, distillation, evaporative fractionation, saponification and chemical esterification are employed for isolation and purification of PT. The present article reviews the various advanced separation techniques like solvent crystallization, supercritical fluid extraction, high speed counter-current chromatography and enzymatic process as strategic methods to isolate and purify sterols.

Current and new insights on phytosterol oxides in plant sterol-enriched food

Over the past 15 years, plant sterol-enriched foods have faced a great increase in the market, due to the asserted cholesterol-lowering effect of plant sterols. However, owing to their chemical structures, plant sterols can oxidize and produce a wide variety of oxidation products with controversial biological effects. Although oxyphytosterols can derive from dietary sources and endogenous formation, their single contribution should be better defined. The following review provides an overall and critical picture on the current knowledge and future perspectives of plant sterols-enriched food, particularly focused on occurrence of plant sterol oxidation products and their biological effects. The final objective of this overview is to evince the different aspects of plant sterols-enriched food that require further research, for a better understanding of the influence of plant sterols and their oxides on consumers' health.